2006 Ford F-150 complaints

BRAKES WORKED FINE UPON ARRIVING AT STORE. UPON LEAVING PARKING LOT AS I APPROACHED STREET, I APPLIED BRAKES TO LEARN THAT THE VEHICLE HAD NO BRAKES. I PRESSED THE BRAKES VERY HARD AND WAS ABLE TO SLOWLY STOP. I WAS PROBABLY TRAVELING AT LESS THAN 5-10 MPH LEAVING PARKING. I CHECKED BRAKE FLUID AND ANY ENGINE CODES, ALL WERE NORMAL. I PROCEEDED TO THE HOUSE CAREFULLY ALLOWING FOR MAXIMUM DISTANCE. BY PRESSING VERY HARD ON BRAKE PEDAL, I WAS ABLE GRADUALLY COME TO A STOP. ON MONDAY, 11/19/2007, I TOOK THE VEHICLE TO THE LOCAL FORD DEALERSHIP. THE VEHICLE THIS MORNING HAD A CHECK ENGINE LIGHT VISIBLE. THE TROUBLE WAS QUICKLY DIAGNOSE BY SERVICE MECHANIC AS A BROKEN VACUUM LINE BEHIND THE ENGINE. THE SMALL COUNTRY DEALERSHIP RELATED THAT THEY REPLACED THE SAME LINE ON A SIMILAR VEHICLE THE WEEK BEFORE. THE DEALERSHIP WAS IN SOUTHEAST GEORGIA AND THE NEAREST PART WAS IN MEMPHIS, TN AND WOULD TAKE 2 DAYS TO ARRIVE. PLUS, THE MANIFOLD AND OTHER PARTS HAD TO BE REMOVED TO GET TO LINE. IT TOOK SOME 6 HOURS OF LABOR TO REPLACE. THE PARTS AND LABOR WAS $767.80 AND THE RENTAL CAR WAS $112.19. THE SERVICE ON THE VEHICLE WAS COMPLETED IN THE AFTERNOON OF 11/21/2007. THE MILEAGE ON THE TRUCK WAS 43996 MILES WHEN TAKEN IN FOR SERVICE. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT AT 395 MILES, THE PASSENGER SIDE FRONT BUMPER WAS BENT AND THE BED WAS ALIGNED IMPROPERLY. THE FORD DEALER REPAIRED THE VEHICLE FOR FREE. THE INSIDE OF THE FRONT TIRES HAD SEVERE EDGE WEAR BECAUSE OF AN ISSUE WITH THE ALIGNMENT ONCE AGAIN AT 4,076 MILES. THE DEALER PERFORMED A 4-WHEEL ROTATION AND ALIGNED THE VEHICLE. THE CONTACT TOOK THE VEHICLE BACK AT 11,000 MILES FOR THE SAME FAILURE. HE ALSO STATED THAT THE STEERING WHEEL VIBRATED WHEN DRIVING 70 MPH. THE DEALER CHANGED THE DRIVER SIDE FRONT TIRE, FRONT SHOCK ABSORBER, AND PERFORMED ANOTHER WHEEL ALIGNMENT. THE CONTACT TOOK THE VEHICLE BACK AND THE DEALER CALLED FORD MOTOR COMPANY. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO MISSION VALLEY FORD FOR A WHEEL ALIGNMENT. THEY PERFORMED A WHEEL ALIGNMENT AND INFORMED HIM TO COME BACK FOR A FOLLOW-UP VISIT AFTER 1,000 MILES. THE CONTACT OBEYED AND THE VEHICLE WAS FOUND TO BE OUT OF ALIGNMENT ONCE AGAIN. MISSION VALLEY FORD CALLED FORD MOTOR COMPANY AND THE CONTACT WAS THEN ADVISED TO TAKE THE VEHICLE TO SUNNYVILLE FORD. FORD AUTHORIZED FOUR NEW TIRES AND AN ALIGNMENT AT 18,456 MILES. HE WAS ADVISED ONCE AGAIN TO TAKE THE VEHICLE BACK AFTER 1,000 MILES FOR A FOLLOW-UP VISIT. THE FRONT TIRES WERE FOUND TO HAVE INSIDE EDGE WEAR AND THE DEALER ROTATED THEM AND PERFORMED ANOTHER ALIGNMENT. THE CONTACT TOOK THE VEHICLE BACK AT 19,640 MILES AND THEY ROTATED THE TIRES ONCE MORE. THE CONTACT TOOK THE VEHICLE BACK AFTER 1

RANDOM STALLING, LOOSES POWER AND COMPLETELY SHUTS DOWN EVERYTHING. 2006 FORD F150. *TR

VEHICLES MISFIRING AND STUBBLING DURING MODERATE ACCELERATIONS AND CRUISING WHEN A LOAD IS PUT ON MOTOR. ( GOING UP A HILL, SLIGHT INCLINE AND PASSING). *TR

WHILE DRIVING 40MPH POWER BRAKES FAILED WITHOUT WARNING. I WAS ABLE TO STOP & PULL OVER WITH COMBINATION OF E BRAKE AND COASTING. FORTUNATELY THIS HAPPENED ON A SIDE STREET WITH ONLY LIGHT TRAFFIC. THE VEHICLE WAS TOWED TO FORD DEALER WHO DETERMINED THAT A VACUUM BOOST HOSE WAS DETACHED FROM THE MANIFOLD. THE DEALER REPLACED THE HOSE AND ADDED A CLAMP TO THE CONNECTION. *TR

CONTACT: CRYSTAL SHAW, FORD MOTOR COMPANY, 5700 GRANITE PKWY, STE 1000, PLANO, TX 75024-6640 HER FAX NUMBER: 972-334-1832 GO TO : HTTP://WWW.CONSUMERAFFAIRS.COM/NEWS04/2006/11/FORD_LEMON_LINEUP.HTML I OWN 2006 FORD F-150 LEMON. THE LEMON AIR CONDITIONER WAS COMING-APART WITHIN TWO WEEKS OF PURCHASED. THE TRUCKS REQUIRES NUMEROUS JUMPS. THE LIGHTS FAIL NEARLY KILLING US . THEY STILL HAVE NOT GOTTEN MY REPLACEMENT VEHICLE, PAY FOR MY RENTALS, OTHER EXPENSES. THIS IS LEMON PRESENTS SERIOUS SAFETY HAZARDS. I HAVE A 74 YEAR-OLD HANDICAPPED MOTHER. I NEED YOUR ASSISTANCE. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT HEARD A POPPING SOUND AND NOTICED SMOKE UNDER THE HOOD AND DASHBOARD WHEN THE VEHICLE WAS STARTED. THE NOISE SOUNDED AS IF THE VEHICLE BACKFIRED. WHILE DRIVING 55 MPH, THE POWER BRAKES FAILED WITHOUT WARNING. THE CONTACT APPLIED THE EMERGENCY BRAKE TO STOP THE VEHICLE AND PULLED OFF THE ROAD. HE NOTICED THAT THE VACUUM HOSE WAS DETACHED FROM THE MANIFOLD, WHICH SUPPLIES VACUUM POWER TO THE BRAKE BOOSTER. THE VEHICLE WAS TOWED TO A FORD DEALER. THE DEALER PLACED THE VACUUM HOSE BACK ON THE ENGINE AND INFORMED THE CONTACT THAT IT SHOULD BE REPLACED. THE WEATHER WAS NOT A FACTOR. THE CURRENT MILEAGE WAS 23,000 AND FAILURE MILEAGE WAS 22,000. UPDATED 11/15/07 *TR

I HAVE A 2006 FORD F-150 THAT HAS PAINT PEELING OFF THE FRONT CAP JUST BELOW THE GRILL. WHAT REALLY CONCERNS ME IS THAT I WORK FOR A LARGE COMPANY THAT HAS HUNDREDS OF FORD VEHICLES AND MOST OF THE 2004, 2005, & 2006 MODELS ARE PEELING AS WELL. WHAT IS FORD GOING TO DO ABOUT THIS.. I FIND THIS VERY UN-ACCEPTABLE.. *JB

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT HEARD A RATTLING NOISE UNDERNEATH THE VEHICLE. THE DEALER STATED THAT THE A/C COMPRESSOR WAS SEPARATING. THE DEALER MADE THE REPLACEMENT, HOWEVER, THE NOISE CONTINUED. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF FAILURE. IN ADDITION, THE VEHICLE FAILED TO START. AS OF SEPTEMBER 24, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 495 AND CURRENT MILEAGE WAS 23,900.

2006 FORD F-150 WITH BRAKE FAILURE. CUSTOMER STATES THAT THE BRAKE PEDAL FELL ALMOST ALL THE WAY TO FLOOR LEVEL. HE STATES THAT THE DEALER IS UNABLE OR UNWILLING TO FIX THE PROBLEM. *KB

INSTRUMENT CLUSTER HAS A SHORT. PART COST WILL BE $500. PLUS LABOR. THIS MEANS CLUSTER WILL START A FIRE. EVENTUALLY. RIGHT NOW THE DASH IS INTERMITTENT. SOMETIMES THERE IS NO SPEEDOMETER, AC, ENGINE TEMPERATURE,CRUISE CONTROL, OIL PRESSURE, FAN, DEFROST. THESE GO ON AND OFF WHILE DRIVING. SINCE TRUCK IS ONLY ONE YEAR OLD, THIS MEANS FORD WANTS YOU TO PAY UP TO A THOUSAND DOLLARS A YEAR FOR AN INSTRUMENT CLUSTER. THIS SHOULD BE A RECALL. *JB

ACCELERATION WHEN APPLYING THE BRAKES. THIS HAS OCCURRED SEVERAL TIME THE MOST RECENT BEING TODAY. I ALMOST RAN INTO A BUILDING PULLING INTO A PARKING SPACE. THE TIME BEFORE WAS AT A RED LIGHT, NO ONE WAS IN FRONT OF ME AND THE TIME BEFORE THAT I WAS HAULING AN ANTIQUE CAR ON A TRAILER WITH TRAILER BRAKES THAT ACTUALLY KEPT ME FROM HITTING ANYONE WHEN THE TRUCK BRAKES CAUSED AN ACCELERATION. I AM AFRAID TO DRIVE THIS TRUCK. I ALSO HAD A PROBLEM WITH THE FUEL PUMP POURING FUEL OUT OF THE TRUCK ONTO THE EXHAUST SYSTEM.

INSTRUMENT PANEL GOES OFF AND ON. TOOK TO DEALER FOR RECALL ON THIS PROBLEM #06C11. 24 HOURS LATER TRUCK DASH STILL INTERMITTENT. NO ODOMETER READING AT ALL NOW. SPEEDOMETER, AC, CRUISE CONTROL, TACHOMETER AND WATER TEMPERATURE GAUGE GO OFF AND ON WHILE DRIVING. TIME LENGTH RANDOM. VERY DISCONCERTING NOT TO KNOW HOW FAST YOU ARE DRIVING. PROBLEM IS INCREASING-ANYWHERE FROM 1 TO 5 TIMES IN AN HOUR OF DRIVING. *JB

ON AUGUST 26, 2007 I WAS TRAVELING EAST ON HIGHWAY 190 BETWEEN KEMPNER, TX AND COPPERAS COVE, TX AT ABOUT 10:30 A.M. IN A 2006 FORD F-150 SUPER CREW WITH ABOUT 25,000 MILES ON IT. ROAD CONDITIONS WERE DRY AND THE ROADWAY WAS RECENTLY REDONE. MY SPEED WAS ABOUT 65 MPH IN A 70 ZONE. FOR NO REASONS THAT I CAN DETERMINE THE RIGHT REAR TIRE RAPIDLY DEFLATED. I MANAGED TO KEEP THE VEHICLE UNDER CONTROL AND PULLED ONTO THE SHOULDER. THE TIRE WAS DESTROYED WITH EVIDENT DAMAGE TO THE OUTER SIDEWALL. I PUT THE SPARE TIRE ON AND CONTINUED. MONDAY, 27 AUGUST I VISITED AUTOMAX FORD AND ASKED THEM TO REPLACE ALL THE TIRES ON THE VEHICLE. THE SERVICE MANAGER TOLD ME THAT TIRE DEFECTS WERE THE RESPONSIBILITY OF THE MANUFACTURER. I MADE THE DECISION AT THAT TIME TO REPLACE ALL THE TIRES WITH ANOTHER BRAND. *JB

COMPLETE POWER BRAKE FAILURE.I TURNED ON MY ENGINE, HEARD A LOUD POPPING SOUND, DROVE FORWARD A FEW FEET AND DISCOVERED THE POWER BRAKES INOPERABLE. NO WARNING LIGHTS CAME ON BEFORE OR AFTER THE INCIDENT. I TOOK THE VEHICLE TO THE NEAREST FORD DEALERSHIP --OLYMPIC LINCOLN MERCURY SEATTLE-- AND THEY REPAIRED IT UNDER WARRANTY. THEY SAID A POOR CONNECTION OF A PRESSURE LINE UNDER THE FUEL RAIL CAUSED THE PROBLEM. THEY SAID NO RECALLS HAD BEEN ISSUED. THEY HAD NO EXPLANATION FOR WHY THE WARNING LIGHTS DID NOT COME ON. THIS INCIDENT HAPPENED APPROXIMATELY 4 MONTHS AGO. I DON'T HAVE THE PAPERWORK IN HAND. IF NEEDED I CAN PROVIDE THE EXACT DATE. THE DATE ABOVE IS A QUESTIONED. OLYMPIC LINCOLN MERCURY HAS CHANGED HANDS, IT IS NOW JACK CARROLS LINCOLN MERCURY. THIS SUDDEN LOSS OF BRAKES WITHOUT WARNING COULD HAVE BEEN DISASTROUS. MY SON WAS WITH ME. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE VEHICLE HAS HANKOOK DYNAPRO AS TIRES, SIZE P235/75R17. IN JULY OF 2007, THE CONTACT NOTICED THAT ONE OF HIS TIRES WAS FLAT. FORD STATED THAT HIS NEGLIGENCE CAUSED THE FLAT TIRE. THE TIRE FAILURE MILEAGE WAS 3,000. THE CURRENT VEHICLE MILEAGE WAS 3,200 AND FAILURE MILEAGE WAS 3,000. UPDATED 02-01-08. *KB

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 60 MPH, THE CONTACT SMELLED SMOKE COMING FROM THE VEHICLE. SHE WAS THEN ALERTED BY A MOTORIST THAT HER VEHICLE WAS ON FIRE. THERE WERE NO WARNING INDICATORS. SHE PULLED OVER AND EXITED THE VEHICLE BEFORE IT BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VEHICLE WAS TOWED AWAY. THE VEHICLE HAD AN OIL CHANGE TWO DAYS BEFORE THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 36,000.

TL*THE CONTACT OWNS A 2006 FORD F150. EVER SINCE THE VEHICLE WAS PURCHASED, IT HAS BEEN TO THE DEALER ON FOUR OCCASIONS. THE CONTACT STATED THAT HIS BRAKES FEEL SPONGY AT ALL SPEEDS AND WHEN IDLING. HE STATED THAT THE BRAKE PEDAL STOPS THE VEHICLE, BUT IT IS NOT FIRM AND EXTENDS ALL THE WAY TO THE FLOORBOARD AT ANY GIVEN MOMENT. DURING ONE OF THE FOUR TRIPS TO THE DEALER, THE MECHANIC BLED THE BRAKE LINE, BUT THIS DID NOT RESOLVE THE FAILURE. THE CONTACT RECEIVED A LETTER FROM FORD IN FEBRUARY OF 2006, WHICH STATED THAT THE VEHICLE FAILED TO CONFORM TO BOTH STANDARD #105 AND #135. THE CURRENT MILEAGE IS 6,888 AND FAILURE MILEAGE WAS 100.

2006 FORD F150 WITH 34000 MILES, CONTINENTAL CONTITRAC TIRES ARE WORE OUT IRREGULARLY AND PREMATURELY. REPLACED TIRES.

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 70 MPH, THE CONTACT DROVE OVER A SERIES OF BUMPS IN THE ROAD AND HIS VEHICLE BEGAN TO JUMP AND SHAKE VIOLENTLY. AS TIME PROGRESSED, HE COULD DRIVE 55 MPH AND RIDE OVER A POTHOLE OR EVEN THE SLIGHTEST OF BUMPS. AS A RESULT, THE VEHICLE BEGAN TO SHAKE AND VIBRATE SIMILAR TO HOW A FLAT TIRE WOULD FEEL. THE DEALER STATED THAT HE NEEDED SHOCKS AND TIRES. AFTER SPENDING $1,600 DOLLARS ON WHAT THE DEALER RECOMMENDED, HIS VEHICLE IS STILL VIBRATING AND SHAKING UNCONTROLLABLY. THE CURRENT MILEAGE IS 41,132 AND FAILURE MILEAGE WAS 10,000.

WHILE ON INTERSTATE ENTRANCE RAMP, 3 SECOND DELAY IN ENGINE RESPONSE AND NEARLY REAR ENDED BY A SEMI TRACTOR TRAILER. MONTHS EARLIER, FORD DEALERSHIP UPGRADED PCM TO LATEST SOFTWARE DUE TO HESITATION IN THROTTLING (FORD WAS AWARE). ENGINE HARD TO START AT TIMES AND IT HESITATED WORST AT HARD THROTTLE, WHILE ATTEMPTING TO PASS OR ENTER HIGHWAY SPEEDS. *TR

DRIVER''S SIDE EXTERIOR MIRROR VIBRATES WHEN GOING DOWN THE ROAD. THIS DISTRACTS THE DRIVER''S VISION AND COULD CAUSE AN ACCIDENT. IT GIVES YOU THE FALSE IMPRESSION THAT THERE IS A VEHICLE MOVING INTO YOUR BLIND SPOT. THIS HAS BEEN REPORTED TO THE DEALER THREE TIMES AND HAS NOT BEEN CORRECTED TO DATE.

WAS TRAVELING BACK FROM DECLO IDAHO FROM MY FATHERS PASSING AWAY ,HEADED FOR BOISE IDAHO AT 11:00 PM, JUST PASSED JEROME ABOUT TWO MILES WEST THE HEADLIGHTS AND ALL OTHER LIGHTS, INTERIOR AND EXTERIOR WENT OUT AT 75 MPH ON THE FREEWAY , IN THE VEHICLE I HAD MY SON 8 YEARS OLD , MY WIFE 40 YEARS OLD , MY MOTHER 65 YEARS OLD, AND MYSELF 44 YEARS OLD WE COULD HAVE BEEN KILLED BY A MERGING OR PASSING SEMI, BUT I QUICKLY SWITCHED THE HEADLIGHT SWITCH FROM AUTO TO HEADLAMP AND THE LIGHTS CAME BACK ON, SO I SWITCHED BACK TO AUTO AND WE TRAVELED 8 MILES AND THE LIGHTS WENT OUT AGAIN , SO ,I REPEATED THE SAME THING AGAIN BY TURNING THE SWITCH BACK TO HEADLAMP, AND THE LIGHTS ONCE AGAIN CAME BACK ON. THEN, I SWITCHED IT BACK TO AUTO AGAIN AND THEY STAYED ON FOR ABOUT 8 TO 10 MILES AND WENT OUT AGAIN . I SWITCHED THEM BACK AND LEFT THE SWITCH ON HEADLAMP AND CONTINUED OUR TRIP HOME FROM DECLO NO MORE PROBLEMS WITH SWITCH ON HEADLAMP MOD. ALSO, I HAD FOG LAMPS ON THIS ENTIRE TIME WHICH ENTAILED PULLING THE HEADLIGHT SWITCH OUT TO ENGAGE THE FOG LAMPS. THEN A WHILE LATER LIKE A WEEK I WENT TO WORK AT THE AIRPORT AT NIGHT GRAVES . I GOT TO WORK SHUT DOWN THE VEHICLE AND PUT THE KEYS ON THE FLOOR AS PER PAD TO OPEN VEHICLE, LOCKED VEHICLE BY PAD AND ENTERED THE BUILDING, ABOUT AN HOUR OR SO LATER RECEIVED A CALL FROM HORIZON EMPLOYEE THAT THERE WAS A VEHICLE WITH ITS LIGHTS ON IN THE PARKING LOT WHICH WAS MY VEHICLE. I RETURNED TO THE VEHICLE AND TURNED THE HEADLAMP SWITCH FROM AUTO TO HEAD

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT HEARS A THUMPING NOISE. THE DEALER STATED THAT THE SOLENOID NEEDS TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 43,000.

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT'S FOOT BECAME STUCK TO THE ACCELERATOR PEDAL WHEN HE ATTEMPTED TO APPLY THE BRAKE. THE VEHICLE FAILS TO BRAKE PROPERLY UNLESS THE PEDAL IS TOUCHING THE FLOOR. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. WHEN TURNING THE STEERING WHEEL, THE CONTACT HEARS A SQUEALING NOISE AND IT BECOMES DIFFICULT TO MANEUVER. THE DEALER REPLACED THE POWER STEERING PUMP, BUT THE SQUEALING NOISE IS STILL AUDIBLE. THE CURRENT MILEAGE IS 37,000 AND FAILURE MILEAGE WAS 9,346. THE CONSUMER STATED THE BRAKE AND GAS PEDAL WERE DESIGNED TOO CLOSE TOGETHER. THE CONSUMER HAS MISTAKENLY HIT THE GAS PEDAL WHEN TRYING TO BRAKE. THE MASTER CYLINDER HAD AN INTERNAL LEAK. THE MUFFLER HAD A LEAK. UPDATED 06/06/07. *JB

2006 FORD F-140 TRITION 5.4 LITER FLEX FUEL V-8 ENGINE AND 4 SPEED AUTOMATIC TRANSMISSION HESITATES WHEN ACCELERATING FROM STOP SIGNS OR LIGHTS AND WHEN MERGING WITH HIGHWAY / INTERSTATE TRAFFIC. *TR

TWO SEPARATE OCCASIONS I EXPERIENCED A FUEL INJECTOR FAILURE ON MY '06 F-150 WHILE TRAVELING ON I-65 ON 10-10-06 AND ON I-10 ON 10-14-06. I WAS TOLD BY A DEALER IN CULMAN ALABAMA THAT I COULD DRIVE IT ON TO MEMPHIS WITH THE ENGINE LIGHT ON. UPON ARRIVAL IN MEMPHIS DOBBS FORD TOLD ME THERE WAS NOTHING WRONG AND I HAD TO TAKE HIS WORD. ON MY TRIP BACK TO TAMPA THE ENGINE LIGHT CAME ON AGAIN AND I HAD TO TOWED TO AMERICAN FORD IN TALLAHASSEE. THE REPLACED #6 FUEL INJECTOR. LATER, WHILE IN MEMPHIS #5 INJECTOR FAILED AND WAS REPLACED AT LANDERS FORD IN COLLIERVILLE. A FEW DAYS LATER THE ENGINE LIGHT CAME ON AGAIN AND THIS TIME IT WAS THE CATALYTIC CONVERTER, WHICH HAD TO BE REPLACED. *JB

TL*THE CONTACT OWNS A 2006 FORD F-150. THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE BEGAN TO VIBRATE WHILE IN TRAFFIC. THE VEHICLE WAS TOWED TO DEALER, AMERICAN FORD. THE DEALER REPLACED THE # 6 FUEL INJECTOR. AT 9,670 MILES, THE SAME FAILURE RECURRED, AND THE DEALER REPLACED THE # 5 FUEL INJECTOR. AT 9,735 MILES, THE ENGINE LIGHT ILLUMINATED AGAIN. THE DEALER STATED THAT THE CATALYTIC CONVERTER FAILED BECAUSE OF THE FUEL. THE CURRENT MILEAGE IS 10,765, AND FAILURE MILEAGE WAS 7,462.*AK

2006 FORD F-150 PICKUP CUSTOMER STATES THAT WHEN BRAKE IS APPLIED HIS FOOT ALSO HITS THE GAS CAUSING THE ENGINE TO RACE**NAR**CC UPDATE *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE VEHICLE WAS PURCHASED WITH ONLY 30 MILES. THE CONTACT ASKED THE DEALER PRIOR TO PURCHASING THE VEHICLE IF THERE WERE ANY RELATED RECALLS AND WAS ADVISED THAT THERE WERE NONE. THE CONTACT RECEIVED RECALL NOTICE 06C11 ON APRIL 7, 2007 STATING THAT THE INSTRUMENT CLUSTER CALIBRATION HAD NOT BEEN REPAIRED. THE MANAGER CONFIRMED THAT THEY WERE AWARE OF THE RECALL NOTICE FIVE MONTHS PRIOR TO THE PURCHASE. HOWEVER, WAS NOT ADVISED TO SCHEDULE AN APPOINTMENT FOR THE REPAIRS. ALSO, THE DEALER STATED THAT THE MODULE BEHIND THE DASH WAS FAULTY. THE CONTACT STATED THAT CRUISE CONTROL WAS NEAR THE RELATED RECALL COMPONENT AND COULD CATCH ON FIRE. ON TWO PRIOR OCCASIONS DURING AN OIL CHANGE THE DEALER INDICATED THE INCORRECT MILEAGE. THIS COULD POTENTIALLY AFFECT THE VEHICLE'S WARRANTY, AND INDICATE THAT THE CONTACT HAS EXCEEDED THE ALLOTTED MILEAGE FOR THE NEXT OIL CHANGE. THE CURRENT AND FAILURE MILEAGE WERE 10,500.*AK

I CURRENTLY DRIVE A 2006 FORD F-150 WHICH I LEASED NEW IN MARCH OF 2006. SINCE DAY ONE I HAVE COMPLAINED ABOUT THE BRAKES ON THE TRUCK. THE BRAKE PEDAL GOES BELOW THE GAS PEDAL WHEN THE BRAKES ARE APPLIED. MY WIFE CANNOT DRIVE THE TRUCK BECAUSE SHE CONSTANTLY HIT THE BRAKE AND GAS AT THE SAME TIME. I HAVE CHECKED WITH OTHER OWNERS AND THEY HAVE THE SAME PROBLEM. I HAVE ALSO COMPLAINED TO THE DEALERSHIP AND THEY TELL ME THAT THIS IS NORMAL WITH THE NEW FORD TRUCKS. COMPLAINTS TO FORD DIRECT HAVE RESULTED IN NO RESPONSE. I ALSO HAVE THE PROBLEM OF HITTING THE BRAKE AND GAS AT THE SAME TIME UNLESS I PUMP THE BRAKES FIRST, IN A PANIC SITUATION THERE IS NOT TIME TO PUMP THE BRAKES. THIS PROBLEM IS AN ACCIDENT WAITING TO HAPPEN. *AK

TL* THE CONTACT WAS A PASSENGER IN A 2006 FORD F-150 EXTENDED CAB. THE CONTACT TRIED TO OPEN THE REAR PASSENGER DOOR AND HER HAND WAS CAUGHT IN AN AREA OF THE DOOR THAT BROKE HER RIGHT INDEX FINGER. FOUR STITCHES WERE REQUIRED DUE TO THE INJURY. THAT AREA OF THE DOOR COULD POTENTIALLY CUT OFF A CHILD'S FINGER. THE DOOR SHOULD HAVE A COVER, ANDWAS CURRENTLY A SAFETY RISK. THE PASSENGER DIDN'T HAVE THE SPECIFICS REGARDING THE VEHICLE. *AK

TL* - THE CONTACT OWNS A 2006 F150 FORD. THE CONTACT STATED THAT WHEN BACKING UP, AND APPLYING THE BRAKES IT WAS EASY TO PRESS THE GAS PEDAL AT THE SAME TIME. THIS HAPPENED THREE TIMES. ON ONE OCCASION HE WAS BACKING UP IN THE DRIVEWAY WHEN HE BUMPED THE GARAGE AND DID SOME DAMAGE TO THE GARAGE. THE CONTACT STATED THAT THE VEHICLE ONLY HAD 5600 MILES ON IT. THIS ONLY HAPPENED WHILE IN REVERSE. THIS OCCURRED WHEN THE CONTACT WAS WEARING WORK BOOTS. THE ACCELERATOR PEDAL AND THE BRAKE PEDAL ARE TOO CLOSE TOGETHER. *AK UPDATED 03/19/07. *JB

WHILE PULLING INTO A PARKING SPOT AT A LOCAL GAS STATION(5 - 8 MPH), I APPLIED THE BRAKE TO STOP AND IT WENT ALL THE WAY TO THE FLOOR. THE TRUCK JUMPED THE SIDEWALK AND CRASHED INTO THE BUILDING. AFTER PICKING THE TRUCK UP THE NEXT DAY, THE BRAKES WORKED FINE AND EVERYBODY THINKS I'M NUTS! CURRENTLY HAVING TRUCK ACCESSED BY DIFFERENT SOURCES. *JB

I HAVE HAD MY TRUCK SERVICED BY THE DEALERSHIP THREE TIMES SINCE I PURCHASED IT IN JULY 2006. THE BED VIBRATES EXCESSIVELY WHEN TRAVELING ABOVE 45 MPH, ALMOST AS IF IT IS LOOSE. THERE IS ALSO A NOTICEABLE GROANING FROM THE REAR WHEN THE TRUCK GOES IN AND OUT OF GEAR. THE SERVICE MANAGER VERIFIED THE PROBLEM BUT DOES NOT KNOW HOW TO FIX IT. *NM

TL* - ON DECEMBER 20, 2006, THE CONTACT RECEIVED A CALL FROM THE POLICE DEPARTMENT STATING HIS 1995 FORD F150 AND THE CAR PORT WERE ON FIRE AT HIS RESIDENCE. THE VEHICLE CAUGHT FIRE UNDER THE HOOD. THE CONTACT STATED THAT THE VEHICLE HAD BEEN PARKED FOR TWO MONTHS. A WITNESS STATED THAT THE VEHICLE SOUNDED AS IF IT WERE TRYING TO START ON ITS OWN. THE WITNESS LOOKED INTO THE VEHICLE AND CONFIRMED THAT NO ONE WAS IN IT AND CALLED 911. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THERE WERE NO RECENT REPAIRS TO THE VEHICLE. THE VEHICLE HAD APPROXIMATELY 210,000 MILES ON IT. THE FIRE DEPARTMENT STATED THE CAUSE OF THE FIRE TO BE A FAULTY SPEED CONTROL DEACTIVATION SWITCH. THE CONTACT HAS PICTURES, A FIRE DEPARTMENT REPORT AND THE VEHICLE STORED. *NM UPDATED 03/19/07. *JB

MY NEW F150 HAS A TERRIBLE SHUDDER IN THE STEERING WHEEL FOR THE FIRST 10 MILES AFTER THE CAR IS STARTED. IF IT IS COLD OUT, IT IS VERY DIFFICULT TO CONTROL THE VEHICLE ABOVE 50 MPH. FORD HAS REPLACED THE TIRES, BUT THEY REPLACED THEM WITH THE SAME PIRELLIS AND IT DID NOT HELP. *JB

TL* - THE CONTACT STATED THAT WHILE THE 2006 FORD F-150WAS IN PARK HADTO DEPRESS THE BRAKE PEDAL TO SWITCH THE TRANSMISSION TO A DRIVE GEAR. ONCE HE HAD THE VEHICLE IN GEAR WITHOUT FOOT ON THE ACCELERATION PEDAL THE VEHICLE WILL ACCELERATE UNEXPECTEDLY. THE CONTACT STATED THAT THE VEHICLE WILL ACCELERATE FOR A FEW SECONDS AND THEN RELEASE ITSELF. IT ACCELERATED WHEN VEHICLE WAS IN DRIVE OR REVERSE GEAR. ONE TIME WHEN THE CONTACT WAS ON THE HIGHWAY IN CRUISE CONTROL AT 70 MPH ON AN EXIT RAMP, WHEN HE PRESSED THE BRAKE PEDAL TO RELEASE THE CRUISE CONTROL AND SUDDENLY THE VEHICLE ACCELERATED FOR ABOUT 3 SECONDS. CONTACT TOOK THE VEHICLE TO THE DEALERSHIP ON 11/01/06 AND THEY PUT A BOX THAT CONTACT STATED WORKED LIKE A BLACK BOX ON THE PLANE TO DIAGNOSE VEHICLE FAILURE. THE CONTACT HAD THE BOX ON FOR 6 WEEKS AND THE DEALERSHIP WASN'T ABLE TO DIAGNOSE THE FAILURE. *AK UPDATED 1/30/2007 - *NM

HAD A GENERAL AMERI-TECH GO FLAT (613 MILES ON IT) COULD FIND NO HOLES OR LEAK EXCEPT FROM TIRE/RIM SEAL. FORD DEALER CLAIMED IT HAD A NAIL HOLE IN SIDE WALL AND I HAD TO PAY FOR A NEW TIRE MYSELF. AGAIN I ATTEMPTED TO AIR TIRE BACK UP BUT IT WAS LEAKING FROM TIRE AT RIM. *JB

ALL FORD LIGHT TRUCKS, SUVS, AND CARS MANUFACTURED SINCE 1987 ALL THE WAY UNTIL 2006 NEED TO HAVE THE HEADLIGHTS ADJUSTED. I HAVE BEEN DRIVING FOR 24 YEARS AND I HAVE SEEN THESE VEHICLES SWITCH FROM HIGH TO LOW BEAMS AND THE LIGHTS ARE STILL TOO BRIGHT. THIS IS DANGEROUS BECAUSE IT BLINDS INCOMING TRAFFIC DRIVERS. THIS IS ALSO TRUE WHEN FORD PRODUCTS ARE DRIVEN BEHIND OTHER VEHICLE. THIS IS FAR TOO DANGEROUS AND THE PROBLEM NEEDS TO BE INVESTIGATED. *NM

TL* - THE CONTACT WAS DRIVING AT 8 - 10 MILES PER HOUR, AND APPLIED THE BRAKES. THE CAR ACCELERATED AND CRASHED INTO A WALL AND WAS BADLY DMAGED ON THE PASSENGER SIDE. THE CONTACT STATES THAT THIS HAS HAPPENED BEFORE. WE WILL BE CONTACTING THE CALLER FOR MORE INFORMATION.

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY, AND PULLED TO BOTH THE LEFT AND RIGHT. EXCESSIVE FORCE WAS REQUIRED TO KEEP THE VEHICLE MOVING STRAIGHT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER ON 3 DIFFERENT OCCASIONS, WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.

DURING ADVERSE WEATHER CONDITIONS (WINTER ICE AND SNOW, COLD TEMPS) MY WHEELS HAD ICE FREEZE IN THEM CREATING AN IMPOSSIBLE STEERING SITUATION. THE DESIGN OF THESE WHEELS ALLOWS THEM TO HOLD ABOUT AN INCH OF WATER ABOUT 3 INCHES IN LENGTH, WHEN THIS FREEZES THE RESULT IS AN OUT OF BALANCE WHEEL, ( IN THIS CASE 4 OUT OF BALANCE WHEELS) MAKING THEM WOBBLE (VIBRATE) UNCONTROLLABLY ON ICY ROADS. THIS CAUSED ME TO EXPERIENCE A TERRIFYING DRIVE FOR THE 17 MILES TO TOWN. I BELIEVE THIS COULD CAUSE AN ACCIDENT WITH A LESS EXPERIENCED DRIVER. *JB

MY 2006 FORD F-150 SUPER CAB PICKUP, 2X4, V-8 ENGINE, HAS A MAJOR PROBLEM WITH THE OUTSIDE MIRRORS FALLING TOWARDS THE GROUND CAUSING ME NOT TO BE ABLE TO PICK UP MOVING TRAFFIC WHILE DRIVING DOWN THE HIGHWAY...I HAVE TAKEN THE TRUCK TO THREE DIFFERENT FORD DEALERSHIPS AND THEY REFUSE TO GIVE ME A TRADE-IN ON A TRUCK WITH POWER MIRRORS...I HAVE HAD (3) NEW SETS OF MIRRORS INSTALLED ON THIS TRUCK ALREADY SINCE I PURCHASED THE TRUCK IN JANUARY 2006....I HAVE HAD A RESTRICTION PUT ON MY DRIVERS LICENSE STATING THAT I MUST HAVE A RIGHT HAND MIRROR ON ALL VEHICLES I DRIVE DUE TO HAVING AMBLYOPIA IN MY RIGHT EYE....CAN'T SEE ANYTHING WHEN MY MIRRORS POINT DOWN TOWARDS THE GROUND...SHOULDN'T' HAVE TO TAKE A BEATING ON THE TRADE-IN SINCE I BOUGHT THE TRUCK IN GOOD FAITH BELIEVING THAT FORD WOULD STAND BEHIND ITS WARRANTY...THEY ARE NOT REIMBURSING ME FOR THE TIME OR GAS TO TAKE THE TRUCK IN FOR REPAIRS AND I BELIEVE THREE SETS OF MIRRORS ARE ENOUGH....I WANT THIS TO BE DOCUMENTED IN CASE THAT I HAVE A MINOR OR MAJOR ACCIDENT THAT IS INVOLVING A LIFE BECAUSE I COULDN'T SEE OUT OF MY MIRROR WHILE CHANGING A LANE..... *NM

I WAS INVOLVED IN AN ACCIDENT WHICH WAS CAUSED BY HITTING THE BRAKE PEDAL AND THE ACCELERATOR AT THE SAME TIME. I THOUGHT I WAS HITTING THE BRAKE WHEN AND HIT THE GAS AT THE SAME TIME CAUSING MY VEHICLE TO REAR END COLLIDE WITH THE VEHICLE IN FRONT OF ME. SINCE I HAVE BEEN DRIVING THE VEHICLE THIS HAS HAPPENED SEVERAL TIMES, THE GAS PEDAL IS TOO CLOSE IN HEIGHT TO THE BRAKE PEDAL. *NM

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 5 MPH IN A PARKING LOT, THE BRAKE PEDAL EXTENDED ALL THE WAY TO THE FLOOR BOARD, AND THERE WAS AN INCREASED STOPPING DISTANCE WHICH RESULTED IN A REAR END COLLISION. NO INJURIES WERE SUSTAINED; THE CONTACT WAS WEARING A SEAT BELT. THE VEHICLE SUSTAINED MINOR DAMAGE. THE POLICE WERE NOT ALERTED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM.

DT*: THE CONTACT STATED AT VARIOUS SPEEDS, THERE WAS A WHINING NOISE UNDER THE DRIVER SIDE FLOOR BOARD. THE NOISE SOUNDED AS THOUGH IT WAS COMING FROM THE SUSPENSION. THE DEALERSHIP WAS UNABLE TO DETERMINE THE PROBLEM.

DT*: THE CONTACT STATED WHILE STOPPED, THE VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE DURING NORMAL ROAD CONDITIONS. THE FRONT SEATS COLLAPSED, AND THE DRIVER SUSTAINED NECK AND KNEE INJURIES. THE PASSENGER SUSTAINED KNEE INJURIES. THE VEHICLE WAS DEEMED TOTAL, AND A POLICE REPORT WAS TAKEN.

WHILE DRIVING I HEARD A POP AND THE TRUCK JERKED TO THE RIGHT. I HAD NO CONTROL OF THE STEERING. I HIT A LARGE TREE STUMP. IT CAUSED SEVERAL THOUSAND DOLLARS OF DAMAGE. WHILE THE INSURANCE APPRAISER AND BODY SHOP OWNER WERE LOOKING AT THE TRUCK THEY DISCOVERED THAT THE SCREW FROM THE TIE ROD INTO THE RACK AND PINION STEERING WAS STRIPPED. IT FELL APART TAKING AWAY ALL MY CONTROL OF STEERING THE TRUCK. FORD REFUSES TO EVEN LOOK AT THE TRUCK. *NM

NEW 2006 FORD F150 EXTENDED CAB, LESS THAN 2500 MILES, DRIVING IN MODERATE TO HEAVY RAIN WHEN WINDSHIELD WIPERS COMPLETELY FAILED. FORTUNATELY THE DRIVER, MY SON, WAS ABLE TO IMMEDIATELY CROSS 3 LANES OF TRAFFIC AND PULL OFF THE ROAD WITHOUT ACCIDENT OR INJURY. THIS IS A SERIOUS DEFECT / FAILURE THAT COULD HAVE RESULTED IN SEVERE INJURY OR DEATH. WIPER MOTOR WAS REPLACED AT A FORD DEALERSHIP THE NEXT DAY.