2005 Ford F-150 complaints

I WAS DRIVING ALONG IN MY 2005, FORD F-150 PICK-UP TRUCK ABOUT TO MAKE A STOP WHEN THE PASSENGER SIDE WINDOW JUST FELL INTO THE DOOR, IT SOUNDED LIKE A SMALL EXPLOSION FRIGHTENING MYSELF AND MY WIFE WHO WAS A PASSENGER. I HAVE READ TO MANY STORIES CONCERNING THE PROBLEMS WITH THE WINDOWS FALLING TO NOT REPORT THIS ONE. IF IT HAVE NOT HAPPEN YET, THERE IS THE POSSIBILITY OF ONE OF THESE GLASSES BREAKING AND FLYING OUT OF THE WINDOW FRAME BECAUSE MY GLASS TEMPORARILY HUNG AT AN AWKWARD POSITION PREMATURELY BEFORE DROPPING DOWN INTO DOOR FRAME.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT FAULTY SPARK PLUGS FRACTURED IN THE CYLINDER HEAD AND THE REMAINS BECAME STUCK IN THE ENGINE BLOCK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 95,000. UPDATED 08/01/11*LJ THE DEALER HAD THE VEHICLE FOR FOUR WEEKS TO REMOVE THE SPARK PLUGS. THE CONSUMER PAID $ 467.50 IN LABOR. UPDATED 08/11/11

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS: FRONTAL: DRIVER SIDE INFLATOR MODULE), THE DEALER WAS CONTACTED TO SECURE AN APPOINTMENT FOR REPAIRS. THE DEALER ADVISED THAT THERE WAS A WAITING LIST OF EIGHTY CUSTOMERS WHO NEEDED REPAIRS BUT THE PARTS NEEDED WERE NOT AVAILABLE. THE CONTACT WAS UNABLE TO SCHEDULE AND APPOINTMENT FOR REPAIRS AND THE MANUFACTURER WAS NOT CONTACTED IN REGARDS TO THE WAITING PERIOD. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 90,000.

WE HAVE HAD 3 ACTUATORS ON OUR WINDOWS IN OUR FORD F-150 GO OUT WHILE DRIVING ON THE HIGHWAY. WE ALMOST HAD A VERY BAD ACCIDENT WHEN THE LAST ONE "EXPLODED". IT SOUNDS LIKE SOMEONE HAS SHOT THE WINDSHIELD WHEN IT HAPPENS AND IT IS VERY HARD TO CONCENTRATE ON DRIVING AND NOT SWERVE INTO ANOTHER CAR OR GO OFF THE ROAD. I HAVE TALKED TO MANY PEOPLE THAT HAVE HAD THE SAME PROBLEM WITH THEIR FORD VEHICLES. THIS IS VERY DANGEROUS AND COULD CAUSE A FATAL ACCIDENT. WE DID GO OFF THE ROAD WHEN THE FIRST ONE BROKE, AND IF WE HAD BEEN ON A HIGHWAY WITH ANOTHER CAR BESIDE US, WE WOULD HAVE HIT IT. *TT

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED AFTER RECEIVING NHTSA CAMPAIGN I.D. NUMBER 11V107000: ( AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE) THE CONTACT CALLED THE DEALER TO SCHEDULE AN APPOINTMENT. THE DEALER SCHEDULE AN APPOINTMENT BUT LATER STATED TO THE CONTACT THAT THE PARTS WERE NOT AVAILABLE. THE DEALER STATED THEY WOULD CALL THE CONTACT WHEN THE PARTS WERE AVAILABLE. THE CONTACT WAS NOT NOTIFIED REGARDING THE PART AVAILABILITY. THE CONTACT CALLED THE MANUFACTURER REGARDING THE RECALL AND THEY ALSO STATED THE PARTS WERE NOT AVAILABLE AND DID NOT PROVIDE ANY INDICATION ON WHEN THE PARTS WOULD BE AVAILABLE. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE DUE TO THE RECALL REMEDY REPAIR NOT BEING PERFORMED. THE FAILURE MILEAGE WAS 18,000. UPDATED 07/21/11 *BF THE CONSUMER STATED THE DELER REPLACED THE PART. UPDATED 07/28/11

TL* THE CONTACT OWNS A 2005 FORD F-150 WITH GENERAL TIRE & RUBBER AMERI-TRAC TIRES SIZE P255/70/R17, DOT NUMBER: A3ND45NW3904. THE CONTACT STATED THAT ALL FOUR TIRES WERE DEFECTIVE. THE FRONT PASSENGER SIDE TIRE BLEW AND SIX MONTHS LATER, THE REAR DRIVER SIDE TIRE SIDE WALLS EXPLODED, CAUSING DAMAGE TO THE VEHICLE AND THE REMAINING TWO TIRES EXPERIENCED TREAD SEPARATION. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO REQUESTED TO HAVE THE TIRES RETURNED TO THEM. THE TIRES WERE REPLACED. THE FAILURE MILEAGE WAS 35,326 AND CURRENT MILEAGE WAS 37,700. UPDATED 01/04/12*LJ THE CONSUMER STATED GENERAL TIRES FINALLY REIMBURSED HIM FOR THREE TIRES AND FOR THE DAMAGE DONE TO HIS TRUCK WITHOUT ADMITTING LIABILITY. UPDATED 01/05/12

2005 FORD F150, 139,000 MILES. TRUCK STARTED MAKING GRIND/BUZZ NOISE INTERMITTENTLY AND WOULD STOP WHEN ACCELERATOR WAS RELEASED. TOOK TO FORD DEALER AND WAS TOLD 4WD VACUUM SWITCH DAMAGED FROM WATER AND DRIVER SIDE INDEPENDENT WHEEL END NEEDED REPLACED. NEW SWITCH HAS WATER SHROUD TO PREVENT WATER DAMAGE WHICH WOULD INDICATE THIS IS A KNOWN PROBLEM. *TR

WHILE DRIVING DOWN THE ROAD, I HEARD A LOUD POP AND THE DRIVER SIDE WINDOW WENT CRASHING DOWN INSIDE THE DOOR. HAD IT REPLACED UNDER WARRANTY. A FEW DAYS AFTER THE MAINTENANCE WARRANTY ENDED (1YR 2 DAYS)....THE SAME PROBLEM HAPPENED TO THE SAME WINDOW AND IT HAPPENED WHILE I WAS DRIVING DOWN THE ROAD AGAIN AND ALMOST CAUSED ME TO WRECK. THIS IS A VERY UNSAFE ISSUE THAT I AM FINDING OUT ABOUT WITH A LOT OF 2005 FORD VEHICLES. PLEASE DO SOMETHING ABOUT THIS ISSUE FORD. *TR

I CANNOT GET THE RECALL PARTS FOR THE AIRBAGS ON MY 2005 FORD F150. NO ONE HAS THEM!!! AND CANNOT SAY WHEN THEY WILL BE IN. WHAT IF SOMETHING HAPPENS IN THE MEANTIME???? AND WHY DO A RECALL IF YOU DON'T HAVE THE PARTS!!!! OUTRAGEOUS. *TR

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE DEALER STATED THEY WERE UNABLE TO REPAIR NHTSA RECALL CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS: FRONTAL: DRIVER SIDE INFLATOR MODULE) BECAUSE THE MANUFACTURER DID NOT PROVIDE THE PARTS. THE CURRENT MILEAGE ON THE VEHICLE WAS 80,000. UPDATED 07/08/11 *BF THE CONSUMER STATED THE COMPONENT HAS NOT FAILED. 07/15/11

2005 FORD F150 TRUCK 4X4 AUTO TRANSMISSION EXPERIENCED MECHANICAL FAILURE WITH NO WARNING. LOST FORWARD LOW GEARS. ONLY HAS 57K MILES. TRUCK WAS ALWAYS DEALERSHIP SERVICED AND MAINTAINED AS RECOMMENDED. NO HARSH WEATHER CONDITIONS EXPERIENCED. NO HEAVY TOWING DONE. REPLACED WITH REBUILT TRANSMISSION. OLD PART WILL BE MADE AVAILABLE. *TR

IN A THREE CAR ACCIDENT. THE 1ST CAR TURNED ON THEIR SIGNAL AT THE SAME TIME ATTEMPTED TO TURN INTO THEIR DRIVEWAY, THE 2ND CAR HIT THE 1ST CAR FROM THE REAR, AS MY F-150 APPROACHED THE 2ND VEHICLE, I APPLIED THE BRAKES TO STOP BEFORE COLLIDING INTO 2ND VEHICLE AND THE BRAKES BECAME SOFT AND DID NOT SLOW THE F-150, THE F-150 WAS TRAVELING AT WELL BELOW THE POSTED SPEED LIMIT, AIR-BAGS DID NOT DEPLOY, THERE FORE HITTING THE 2ND VEHICLE IN THE REAR CAUSING ALMOST NO DAMAGE TO 2ND VEHICLE AND CAUSING AN ALMOST TOTALED FRONT END TO THE F-150 WITH CLOSE TO $13000 IN DAMAGE TO F-150. NO MAJOR INJURIES WERE REPORTED, ONLY MINOR BACK PAIN TO BOTH PERSONS IN F-150 WERE CONCURRED. *TR

IT WAS A SCORCHING SUNNY FLORIDA DAY WHEN MY WINDOW ON MY 2005 F150 WOULD NO LONGER WORK DUE TO A WINDOW MOTOR REGULATOR ASSEMBLY FAILURE THAT THE DEALERSHIP WOULD LIKE TO REPAIR IT AT THE WONDERFUL COST OF OVER $300 AMERICAN DOLLARS. THE WINDOW MOTOR REGULATOR ASSEMBLY HAS BEEN INTERMITTENTLY WORKING IN THE TRUCK FOR THE PAST FEW MONTHS, NOT TO MENTION THE WINDOW SWITCH WHICH HAD TO BE REPLACED AT MY OWN EXPENSE A COUPLE ABOUT A YEAR AGO ON MY TRUCK WHICH IS WAS ONLY 4 1/2 YEARS OLD AT THE TIME. THE WINDOW WOULD NO LONGER ROLL UP, CAUSING SEVERE SUN BURN TO ARMS. FORD SHOULD REPAIR THIS ISSUE AT NO COST, ESPECIALLY SINCE IT IS A KNOWN PROBLEM ALREADY. *TR

2005 FORD F-150, RIGHT REAR WINDOW MECHANISM POPS REAL LOUD,WINDOW FALLS INTO THE DOOR. I WAS NOT ROLLING IT UP OR DOWN,JUST DRIVING DOWN THE ROAD. THE TRUCK JUST TURNED 34,000 MILES. IT HAS BEEN GARAGED AND TAKEN CARE OF ALL ITS LIFE. *TR

HEARD LOUD POP WHEN ROLLING WINDOW UP AND THEN WINDOW FELL INTO THE DOOR. THIS WAS THE PASSENGER SIDE WINDOW. I HAD THE EXACT SAME THING HAPPEN IN SEPTEMBER 2009 WITH THE DRIVERS SIDE WINDOW. THE CAUSE OF THAT WAS BROKEN REGULATOR IN THE WINDOW. THE WINDOWS JUST FALL DOWN INTO THE DOORS. COULD BE VERY DANGEROUS IF THERE IS A DEFECT WITH THE REGULATORS AND SOMEONE WAS TRAVELING AT ANY RATE OF SPEED. LUCKILY MY WINDOWS DID NOT SHATTER IN THE DOOR WHEN THEY FELL.

AT A STOP WITH MY FOOT ON THE BRAKE THE TRUCK LUNGED FORWARD. *TR

I WAS DRIVING HOME FROM WORK AT 0530 WHEN DRIVER WINDOW SUDDENLY DROPPED. IT WAS THE WINDOW REGULATOR THAT BROKE. THAT WASN'T THE ONLY INCIDENT ALL WINDOW REGULATORS BROKE WITHIN A YEAR AFTER THAT AND JUST RECENTLY THE DRIVER WINDOW BROKE AGAIN. SO THAT A TOTAL OF 5 WINDOW REGULATOR THAT BROKE IN MY TRUCK. A DEFINITE MANUFACTURER DEFECT.

WHILE DRIVING I LOST ACCELERATION CROSSING LANES AND WAS ALMOST HIT BY A TRUCK. *TR

TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE MOTOR WAS FAULTY DUE TO THE DESIGN, CAUSING A CARBON BUILD UP THAT BLOCKS THE SPARK PLUGS. THE VEHICLE WAS TOWED TO THE DEALER; HOWEVER, THE DEALER WAS UNABLE TO REMOVE THE SPARK PLUGS. THE MANUFACTURER REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGE WAS 131,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 2 MPH, THE FRONT DRIVER SIDE AIR BAG DEPLOYED INDEPENDENTLY. THE DRIVER SUFFERED MINOR INJURIES AS A RESULT OF DEPLOYMENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE YET THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS: FRONTAL: DRIVER SIDE INFLATOR MODULE). THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 100,000. UPDATED 6/8/11 *CN UPDATED 06/13/11

THIS PAST MARCH, DURING A HEAVY SNOW STORM I TRIED TO ENGAGE MY 4 WHEEL DRIVE ON MY 2005 F150 AND IT WOULDN'T ENGAGE. SINCE THEN, I'VE NOTICED A NOISE COMING FROM MY RIGHT FRONT WHEEL (THAT'S SINCE PROGRESSED TO MY LEFT FRONT WHEEL). FOUND A TSB #06-8-15 THAT AFFECTS THE IWE SOLENOIDS ON 04-06 F150'S. REPLACED THE SOLENOID, AND STILL HAVE NOISE. NOW BEING TOLD BY A FORD MECHANIC THAT MY ACTUATOR HUBS ARE PROBABLY SHOT FROM WATER GETTING INTO THE OLD SOLENOID AND TRAVELING DOWN THE VACUUM HOSES TO THE HUBS. *TR

2005 FORD F-150. CONSUMER STATES DEFECTIVE POWER WINDOW SYSTEM *TGW

2005 FORD F-150 SPARK PLUGS FUSE TO ENGINE AND BREAK VERY EASILY. THE TRUCK HAS LESS THAN 100,000 MILES AND WAS BROUGHT TO THE DEALERSHIP FOR A TUNE UP. THE DEALERSHIP TRIED TO REMOVE THE PLUGS AND THEY BROKE. THEY ARE NOW FORCED TO REMOVE THE HEADER AND REPLACE THE PLUGS. THIS IS NOW GOING TO COST $2600 FOR A KNOWN PROBLEM WITH THE MANUFACTURE PROVIDED PLUGS. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT WAS DRIVING AT RELATIVELY LOW SPEEDS WHEN THE BRAKES WERE APPLIED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE ENGINE MASS AIR FLOW SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 90,000.

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT ALL OF THE POWER WINDOWS FAILED EXCEPT FOR THE DRIVERS SIDE WINDOW. THE WINDOWS CANNOT BE MANEUVERED BACK INTO THE UPRIGHT POSITION. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE DEALER ADVISED HIM THAT THE ACTUATOR TO THE POWER WINDOWS MAY HAVE CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT AS HE ENTERED THE VEHICLE AND STARTED THE IGNITION, THE DRIVER SIDE AIR BAG DEPLOYED INDEPENDENTLY. HE RECEIVED INJURIES TO THE ARM AND WAS KNOCKED UNCONSCIOUS FROM BEING STRUCK BY THE AIR BAG. THE CONTACT WAS THEN TRANSPORTED TO THE HOSPITAL. THE VEHICLE WAS NOT NEITHER INSPECTED BY A DEALER NOR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 59,300.

MY 2005 FORD F150 QUIT WHILE DRIVING DOWN THE HIGHWAY WITH MY 12 YR OLD SON. ENGINE BEGAN TO SPIT AND SPUTTER AND STRANDED US ON THE HIGHWAY. AFTER TOWING TO MY LOCAL FORD DEALER. THE DEALER DISCOVERED THE TIMING CHAIN HAD SLIPPED CAUSING THE TRUCK TO JUMP TIME AND RUINING THE ENGINE. THE TRUCK HAS 130,000 HIGHWAY MILES. NOW THEY WANT $7,500 FOR A NEW ENGINE. THE OTHER ISSUE IS MY REAR DRIVER SIDE WINDOW JUST FELL INTO THE DOOR. THEY WANT BETWEEN 200 AND 300 DOLLARS TO REPAIR.

WINDOWS SUDDENLY FALLING DOWN WHILE TRAVELING ON PUBLIC ROADS. POSES POTENTIAL HAZARD TO OCCUPANTS AND DRIVER. *TR

2005 FORD F150 SPARK PLUG EJECTED FROM ENGINE. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE VEHICLE WAS TAKEN FOR INSPECTION WHEN THE CONTACT WAS INFORMED THAT BOTH FRONT LOWER BALL JOINTS WERE WORN AND WOULD NEED TO BE REPLACED. THE CONTACT DID NOT INFORM THE DEALER OR MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 36,500. UPDATED 05/04/11 *BF UPDATED 05/31/11

FUEL PUMP CONTROL MODULE IS SUBJECT TO CORROSION DUE TO LOCATION. I WAS DRIVING UP HILL ON THE FREEWAY WHEN MY 2005 F150 STALLED. I LOST ALL POWER, POWER STEERING, BRAKES. I WAS NEARLY KILLED WHEN THE SEMI BEHIND ME COULD NOT STOP IN TIME DUE TO THE FAILURE OF FUEL PUMP CONTROL MODULE. THANKFULLY I WAS STRONG ENOUGH TO FORCE THE TRUCK TO THE SHOULDER AND STOP DESPITE HAVING NO POWER BRAKES OR STEERING WHILE TOWING A 6000 LB TRAILER. AFTER PAYING FOR A TOW FOR MY TRUCK AND TRAILER I FIND HUNDREDS OF REPORTS DEALING WITH THE FAULTY PLACEMENT OF THE FUEL PUMP CONTROL MODULE ONLINE. AT THE REPAIR SHOP I WAS AMAZED BY THE EXTENT OF THE CORROSION. THERE WAS BARELY ANYTHING LEFT OF THE MODULE. THE PART WAS REPLACED WITH THE SAME FAULTY CONTROLLER DUE TO A BACKORDER FROM FORD BECAUSE THE PROBLEM IS SO WIDE SPREAD. I ALMOST DIED DUE TO A KNOWN PROBLEM THAT SHOULD HAVE NEVER BEEN ALLOWED TO OCCUR. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT DRIVER SIDE WHEEL EXHIBITED SIGNS OF FAILING. THE CONTACT DISCOVERED THAT THE TIRE WAS GOING FLAT AND ADDED MORE AIR. THE VEHICLE WAS THEN TAKEN TO A LOCAL TIRE SHOP WHERE THE CONTACT WAS ADVISED THAT THE FRONT DRIVER SIDE WHEEL WAS FRACTURED. THE LOCAL REPAIR SHOP REPLACED THE TIRE WITH A SPARE AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 65,148 AND THE CURRENT MILEAGE WAS 65,200.

TL*THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 45 MPH WITH THE FOUR WHEEL DRIVE ACTIVATED DURING ICY ROAD CONDITIONS AND FORCED THE CONTACT TO CRASH INTO A DITCH AND A TREE . THE CONTACT WAS ABLE TO EXIT THE VEHICLE WITHOUT INJURIES. THERE WAS NO MENTION OF A POLICE REPORT. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO A COLLISION CENTER. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

2005 F150 SUPERCREW 4X4 LARIAT; WITH A 5.4 3 VALVE/CYLINDER ENGINE; CHECK ENGINE LIGHT CAME ON AND INDICATED CYLINDER 5; MECHANIC WENT TO PULL THE PLUG WHICH BROKE IN TWO WITH THE BOTTOM PART STILL IN THE BLOCK. HAD TO HAVE IT TOWED TO A FORD DEALER; $150 TO REMOVE THE PLUG PLUS $29 PARTS AND LABOR. PLUG HAS A DESIGN FLAW THAT FORD HAS KNOWN ABOUT SINCE AT LEAST 1997. FOR MOST TRITON EGNINE OWNERS, YOU FIND OUT THE HARD WAY WHEN THE ENGINE LIGHT COMES ON OR WHEN YOU GO IN FOR A TUNE UP; MINIMUM COST $150; FOR EVERY BROKEN PLUG - $150 TO REMOVE IT; IF IT CAN NOT BE REMOVED, THE ENGINE AND/OR FRONT END HAS TO BE PULLED (PER FORD REPAIR BULLETIN) TO REMOVE THE HEAD(S). COST: $1,000 - $3,000. MOST VEHICLES ARE "OUT OF WARRANTY" BY THIS TIME WHICH FORD THEN DISMISSES AS NOT A "WARRANTY PROBLEM" BUT RATHER A "SERVICE ISSUE". THE DEALERSHIPS MAKE A KILLING OFF THE CUSTOMERS BECAUSE OF AN INEPT, INCOMPETENTLY DESIGNED SPARK PLUG. FORD HAS KNOWN ABOUT THIS PROBLEM SINCE THE LATE 1990S BUT REFUSES TO DO ANYTING AS THE NTSB HAS DONE NOTHING TO ISSUE A RECALL. DUH *TR

I BOUGHT MY FORD F-150/V/8 IN 2005. SINCE 2005 I HAVE HAD PROBLEMS WITH THE FUEL INJECTORS TO DATE (03/20/2011). I HAVE SPENT CLOSE TO $4,000.00 FOR PROBLEMS RESULTING FROM THE FUEL INJECTORS. ALTHOUGH FORD SENT OUT A LETTER DATED DECEMBER 2007, REFERENCING AND ACKNOWLEDGING PROBLEMS WITH THE INJECTORS STICKING OPEN/CLOSE. IT HAS BEEN A NIGHTMARE AT THE SERVICE DEPARTMENTS. AGAIN ALTHOUGH, FORD EXTENDED THE WARRANTY ON FUEL INJECTORS TOTALING 11 YEARS OR 120,000 MILES FROM THE START DATE. THE CUSTOMER PAYS FOR ALL OTHER PROBLEMS THAT OCCUR AS A RESULT OF THE DAMAGE THAT THE INJECTORS CAUSED. I EXPERIENCED TOO MUCH GAS IN THE ENGINE CAUSING A BENT ROD. INJECTORS STICKING OPEN AND CLOSED CAUSING SHUT DOWN OF THE ENGINE OR FAST ACCELERATION. I'M SEEKING REIMBURSEMENT FROM FORD MOTOR COMPANY FOR MONIES SPENT FORM PROBLEMS THAT WERE CAUSE BY THE FUEL INJECTORS. I HAVE BEEN TO THE SERVICE 7 TO 8 TIMES PROBLEMS ASSOCIATED WITH THE FUEL INJECTORS. THIS PROBLEM HAS BECOME A FINANCIAL BURDEN. *TR

I HAVE AN 05 FORD F -150 AND ONE NIGHT I CAME TO A STOP SIGN AT TOP OF HILL WITH ON COMING TRAFFIC IN BOTH DIRECTIONS AND MY BRAKE PEDAL WENT TO FLOOR BUT TRUCK NEVER STOPPED THEN IT WENT COMPLETELY POWERLESS AT NIGHT. ROLLED DOWN HILL HOME WITH NO POWER OR LIGHTS IN NEUTRAL. HAD NO WARNING OR CHANGE IN BRAKES. OIL CHANGE AND CLOCKSPRING RECALL WORK DONE THE DAY BEFORE AT ALAN VIGIL DEALERSHIP. TRUCK HAS ONLY BEEN WORKED ON BY DEALER FOR OIL CHANGE AND TIRE ROTATION. TURNED INTO SOMEONE'S YARD AND DROVE TILL TRUCK STOPPED ON ITS OWN BEFORE TRYING TO MAKE IT GO HOME. I COULD HAVE HURT SOMEONE OR MYSELF IF I HAD NOT BEEN A SKILLED DRIVER.I TRIED TO TELL DEALERSHIP TO HAVE PART CHECKED OUT FOR DEFECT BUT THEY SAID IT JUST BLOWS A SEAL AT ANYTIME. I HAVE HAD DOZENS OF VEHICLES AND THIS IS THE FIRST AND ONLY MASTER CYLINDER THAT I HAVE HAD TO REPLACE. MY TRUCK ONLY HAS 89000 MILES ON IT LOOKS AND DRIVES LIKE A BRAND NEW TRUCK. PLEASE HELP. NO ONE OR FAMILY SHOULD EVER HAVE MY EXPERIENCE. *TR

A SPARK PLUG BLEW OUT OF THE CYLINDER HEAD, DESTROYING THE COIL ABOVE IT. NO HINT OF ANY PROBLEMS PRIOR TO BLOW OUT. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT WAS DRIVING 1 MPH IN REVERSE WHEN THE FRONT DRIVER SIDE AIR BAG INDEPENDENTLY DEPLOYED. THE CONTACT SUSTAINED INJURIES TO THE LEFT ARM AS A RESULT. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE FAILURE BUT RECEIVED NO ASSISTANCE. THE MANUFACTURER WAS THEN CONTACTED AND ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR DIAGNOSTIC TESTING. THE DIAGNOSTIC TEST WAS PERFORMED AND THE RESULTS WERE SENT TO THE MANUFACTURER WHERE THE CONCLUDED THAT THEY WOULD NOT PROVIDE ANY FURTHER ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE APPROXIMATE CURRENT MILEAGE WAS 197,000.

TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE MECHANIC INFORMED THE CONTACT THAT A SPARK PLUG HAD FRACTURED IN THE HEAD OF CYLINDER FIVE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WERE NO RECALLS FOR THE FAILURE AND SUGGESTED THE CONTACT KEEP ALL RECEIPTS FOR POSSIBLE REIMBURSEMENT IF THERE WAS A RECALL IN THE FUTURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 100,800.

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS RECENTLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS: FRONTAL: DRIVER SIDE INFLATOR MODULE) YET THE FAILURE RECURRED ONE WEEK AFTER REPAIRS. THE CONTACT WAS ABLE TO SECURE AN APPOINTMENT WITH THE DEALER FOR FURTHER DIAGNOSIS. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 70,000. UPDATED 05/03/11*LJ THE DEALER INFORMED THE CONSUMER THE FRONT IMPACT SENSOR WAS CAUSING THE AIR BAG LIGHT TO ILLUMINATE, INDICATING THE AIR BAGS WOULD NOT DEPLOY IF AN ACCIDENT OCCURRED. UPDATED 07/01/11*JB

TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO MANEUVER OFF THE ROADWAY AND SHIFTED INTO PARK. HE WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL MINUTES. THE FAILURE RECURRED APPROXIMATELY FIVE TIMES AND THE VEHICLE WAS TAKEN TO BOTH AN AUTHORIZED DEALER AND AN INDEPENDENT MECHANIC WHO WERE BOTH UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 03/24/11*LJ UPDATED 04/05/11*LJ UPDATED 04/05/11

TL * THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG DEPLOYED WITHOUT ANY WARNING AND THE VEHICLE WAS NOT IMPACTED. THE VEHICLE WAS TAKEN TO THE DEALER YET THEY WERE UNABLE TO DIAGNOSE WHY THE FAILURE OCCURRED. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 40,662. UPDATED 4/11/2011 *CN THE CONSUMER STATED HER LEFT ARM WAS BRUISED AND THERE WAS SWELLING FROM THE IMPACT. THE TRUCK WAS REPAIRED AT THE CONSUMERS EXPENSE. UPDATED 08/22/11

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT AS HE STARTED THE VEHICLE AND SHIFTED INTO REVERSE, THE FRONT DRIVER AIR BAG ABRUPTLY DEPLOYED WITHOUT WARNING. THERE WAS NO PERSONAL INJURY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT NOT REPAIRED. THE CONTACT STATED PRIOR TO THE FAILURE THE VEHICLE WAS TAKEN TO THE DEALER THREE DIFFERENT TIMES FOR AN INTERMITTENT ILLUMINATION OF THE AIR BAG WARNING INDICATOR HOWEVER, THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000. UPDATED 03/31/11*LJ UPDATED 04/22/11

THE 2005 FORD F150 CREW CAB HAS BEEN HAVING PROBLEMS WITH ITS THROTTLE BODY ACTUATOR. THIS PROBLEM WILL CAUSE THE VEHICLE TO EITHER STALL OR LOSE POWER WITH OUT ANY NOTICE. *TR

2005 F150 STALLED WITHOUT WARNING WHILE DRIVING SOMETIMES AT HIGHSPEED ON THE HIGHWAY. IT HAPPENED VERY FREQUENTLY AND THE CHECK ENGINE LIGHT FINALLY CAME ON SO I TOOK IT TO THE DEALERSHIP FOR REPAIR. I WAS TOLD THAT THE THROTTLE BODY WOULD NEED REPLACING AT APPROX $750.00 AND WAS TOLD THAT THIS IS A TYPICAL REPAIR FOR THIS VEHICLE. I UNDERSTAND MANY OTHERS HAVE HAD THIS ISSUE. PRIOR TO REPAIRING I STALLED SEVERAL TIMES IN THE HIGH SPEED LANE AND HAD TO PULL OVER TO THE LEFT HAND OF THE 4 LANE HIGHWAY WHICH I WAS FORTUNATE NOT TO BE HIT. THIS SEEMS TO BE A VERY SERIOUS SAFETY ISSUE. *TR

DRIVER AIR BAG EXPLODED INSTANTLY UPON ENTERING THE VEHICLE.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WOULD ILLUMINATE ON AN INTERMITTENT BASIS. THE VEHICLE WAS INSPECTED BY A DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS ALSO CONTACTED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 67,100. UPDATED 03/24/11*LJ UPDATED 05/05/11

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE AIR BAG LIGHT WOULD ILLUMINATE INTERMITTENTLY WHILE DRIVING ANY SPEED. THE DEALER WAS CONTACTED AND ADVISED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 2005 FORD F 150 FX. THE CONTACT WAS DRIVING 45 MPH WHEN THE ELECTRONIC THROTTLE CONTROL LAMP ILLUMINATED AND THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE CONTACT ATTEMPTED TO ACCELERATE BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE THEN STALLED BUT WAS ALE TO BE RESTARTED YET THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY WERE AWARE OF THE FAILURE AND WERE UNABLE TO OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 74,000.

TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS TAKEN TO THE DEALER YET THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS) BUT THE CONTACTS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.