1999 Ford F-150 complaints

AFTER HEARING OF A RECALL OF THIS VEHICLE FOR CORROSION OF FUEL TANK STRAPS AND CHECKING MY VEHICLE THEY ARE CORRODING. I HAVE TALKED TO THE DEALERSHIP, FORD CUSTOMER CARE AND E-MAILED THE COMPANY I AM TOLD THAT THIS VEHICLE IS NOT INCLUDED IN THE RECALL AND THEY CAN DO NOTHING. WHY ARE ALL FORD F-150'S NOT INCLUDED INTO RECALL, ESPECIALLY IF THEY ARE DEFECTIVE. WHAT OTHER ACTION CAN I TAKE TO HAVE THIS TAKEN CARE OF? *TR

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH HE HEARD A LOUD NOISE AND PULLED ONTO THE SIDE OF THE ROAD. HE THEN NOTICED THAT THE FUEL TANK HAD DETACHED, AND BOTH STRAPS WERE FRACTURED AND HAD COMPLETELY DETERIORATED. FUEL SPILLED AND IT WAS APPROXIMATELY A LOSS OF 4 TO 5 GALLONS OF FUEL SPILLED OUT OF THE VEHICLE DUE TO THE FAILURE. THE VEHICLE WAS TOWED AND REPAIRED BY AN INDEPENDENT MECHANIC. THE VEHICLE WAS REPAIRED WHICH INCLUDED REPLACING THE TWO FUEL TANK STRAPS. THE FAILURE MILEAGE WAS APPROXIMATELY 133,786. UPDATED 08/31/11 *BF THE GAS TANK STRAPS, FUEL LINES AND FUEL TANK WERE REPLACED. UPDATED 09/07/11

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS OVER RAILROAD TRACKS HE HEARD A LOUD NOISE AND NOTICED THAT THE FUEL TANK HAD DETACHED FROM THE VEHICLE. THE TWO STRAPS THAT HOLD THE TANK IN PLACE HAD FRACTURED AND THEY WERE COVERED WITH RUST. FUEL SPILLED FROM THE FUEL TANK AND APPROXIMATELY FIVE TO SIX GALLONS SPILLED ONTO THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPAIRED THE VEHICLE AND ALSO REPLACED THE STRAPS. THE FAILURE MILEAGE WAS APPROXIMATELY 226,600.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING A MODERATE SPEEDS WHEN THE FUEL TANK STRAP FRACTURED AND CAUSED THE FUEL TANK TO DRAG. THE CONTACT STATED THAT BY THE TIME HE WAS ABLE TO STOP THE VEHICLE, A HOLE WAS CREATED IN THE FUEL TANK AND CAUSED A LEAK. THE CONTACT HAD THE VEHICLE TOWED TO THEIR PERSONAL MECHANIC FOR REPAIRS. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 105,000.

1999 FORD F150 GAS TANK STRAPS FAILED. VEHICLE WAS TRAVELING ON A SMOOTH ROAD AT ABOUT 35 MPH. HUSBAND AND DAUGHTER IN THE TRUCK, PULLED OVER RIGHT AWAY, TRUCK WAS TOWED TO A MECHANIC. GAS TANK WAS DRAGGING ON THE GROUND. GAS SPILLED OUT. *TR

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THE FUEL TANK WAS LEAKING; WHEN THE VEHICLE WAS INSPECTED HE NOTICED THAT THE FUEL TANK AND ONE OF THE STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE AND THE CURRENT MILES WERE 109,393. UPDATED 6/8/11 *CN UPDATED 06/24/11

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT ONE OF THE STRAPS THAT HOLD THE FUEL TANK BROKE AS A RESULT OF CORROSION. THE CONTACT ALSO MENTIONED THAT A ROPE HAD TO BE ATTACHED IN ORDER TO TEMPORARILY HOLD THE FUEL TANK IN PLACE. THE VEHICLE WAS TAKEN TO THE DEALER WHO REFERRED HER TO NHTSA. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,915. THE CONSUMER ALSO STATED THE NOZZLE WAS CRACKED. UPDATED 07/15/11

GAS TANK DROPPED FROM UNDERNEATH THE TRUCK. THE RESTRAINING STRAPS BROKE. THE TANK WAS FILLED WITH FUEL AND THE TANK WAS DESTROYED.

GAS TANK STRAP BROKE AWAY. TANK WAS HANGING BY GAS LINE AND FILL TUBE. TEMPORARILY REPAIRED WITH NYLON STRAPPING. *TR

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT WAS DRIVING 5 MPH AND TRAVELED OVER A SPEED BUMP WHEN THE FUEL TANK DETACHED FROM THE VEHICLE. THERE WAS MINIMAL FUEL SPILLAGE. THE FUEL STRAPS WERE RUSTED AND CORRODED YET THE FRONT STRAP WAS THE ONLY ONE THAT FRACTURED. THE VEHICLE WAS REPAIRED BY THE CONTACT AT A COST OF $200. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 184,000. UPDATED 6/8/11 *CN

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS ATTEMPTING A TURN AND DROVE OVER A POTHOLE WHEN THE FUEL TANK STRAPS FRACTURED. THE FUEL TANK THEN DETACHED FROM THE VEHICLE AND CAUSED A FULL TANK OF GASOLINE FUEL TO SPILL. IN ADDITION, THE FUEL TANK THEN STRUCK AND RUPTURED THE REAR BRAKES LINES. IN ORDER TO STOP THE VEHICLE, THE CONTACT HAD TO ABRUPTLY APPLY THE EMERGENCY BRAKE AND SHIFT INTO PARK SIMULTANEOUSLY. THE VEHICLE WAS TOWED TO THE CONTACTS HOME WHERE IT WAS INSPECTED BY THE INSURANCE COMPANY. THE INSURANCE COMPANY DISCOVERED THAT THE FUEL STRAPS WERE CORRODED AND WAS THE CAUSE OF FAILURE. THE FAILURE MILEAGE WAS 139,000 AND THE CURRENT MILEAGE WAS 141,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, SHE NOTICED THAT THE FUEL TANK HAD DETACHED FROM THE VEHICLE. NO FUEL WAS LOST. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED THE FUEL TANK STRAPS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 117,841 UPDATED 11/02/11

THE FUEL TANK AND FUEL TANK STRAPS WERE BADLY RUSTED AND THE FUEL TANK WAS LEAKING. MOISTURE AND DIRT WAS ACCUMULATING INSIDE THE STRAP CAUSING IT TO RUST.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT HE HEARD AN ABNORMAL THUMP WHILE DRIVING APPROXIMATELY 55 MPH. THE VEHICLE WAS PULLED OVER AND THE CONTACT NOTICED ONE OF THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WAS FRACTURED AND THE FUEL TANK WAS HANGING DOWNWARD.THERE WAS ALSO FUEL SPILLING ONTO THE GROUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THE STRAPS AND FUEL TANK WERE REPLACED. THE CONTACT WAS ALSO TOLD THAT THE OLD STRAPS AND FUEL TANK WERE CORRODED. THE FAILURE MILEAGE WAS 144,895 AND THE CURRENT MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.

THE FRONT STRAP ON MY F-150 FUEL TANK HAS RUSTED AND BROKE BUT THE BACK ONE IS STILL HOLDING, I AM WAITING ON THE INVESTIGATION OF THIS PROBLEM TO TURN IT INTO A RECALL AND I THOUGHT I SHOULD REPORT THIS TO ADD TO THE INVESTIGATION

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN SHE STARTED TO HEAR A LOUD DRAGGING NOISE FROM THE VEHICLE. SHE THEN NOTICED THAT THE FUEL TANK HAD FRACTURED FROM THE VEHICLE. THE VEHICLE WAS THEN TOWED TO A INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE STRAPS THAT HELD THE TANK WERE MISSING AND NEEDED TO BE REPLACED AS WELL AS THE TANK. THE VEHICLE WAS REPAIRED FOR THE STRAPS AND THE FUEL TANK. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HER THAT THERE WOULD POSSIBLY BE A RECALL FOR THE FAILURE IN THE FUTURE. THE FAILURE MILEAGE WAS APPROXIMATELY 166,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH WHEN HE HEARD A LOUD NOISE COMING FROM THE VEHICLE. HE THEN PULLED OVER AND NOTICED THAT THE FUEL TANK HAD DETACHED FROM THE VEHICLE. THE VEHICLE WAS THEN TOWED TO A DEALER AND THEY ADVISED HIM THAT THE STRAPS HAD RUSTED, CAUSING THE TANK TO DETACH. THE VEHICLE WAS REPAIRED FOR THE STRAPS AND THE FUEL TANK. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THERE WAS NO RECALL FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 182,500. THE VIN WAS UNAVAILABLE. UPDATED 6/8/11 *CN UPDATED 06/20/11

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT NOTICED THAT THE FUEL TANK WAS COVERED WITH RUST AND IT WAS FRACTURED, CAUSING IT TO DETACH FROM THE VEHICLE WHILE DRIVING. THE CONTACT DID NOT INFORM THE DEALER OR MANUFACTURER OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO REPLACED THE GASOLINE TANK STRAPS, FUEL LEVEL SENSOR AND THE FUEL TANK. THE CURRENT MILEAGE WAS 93,000 AND THE FAILURE MILEAGE WAS 92,000.

I HAVE A FORD F-150 PICKUP TRUCK 1999 AND LAST WEEK THE GAS TAND FELL OFF. MY MECHANIC SAID THAT THE STRAPS HOLDING THE TAND WERE RUSTED THROUGH. WHEN THE TANK FELL IT ALSO TOOK OUT THE BRAKE LINES AND I HAD NO BRAKES. *TR

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN HE NOTICED A COMPONENT FRACTURING FROM THE VEHICLE. HE THEN PULLED TO THE SIDE OF THE ROAD AND NOTICED FUEL LEAKING FROM THE VEHICLE. THE POLICE WERE CALLED AND A REPORT WAS FILED. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT THE FUEL TANK AND THE STRAPS HAD FRACTURED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

ONE OF THE METAL STRAPS HOLDING ON THE GAS TANK HAS RUSTED AND BROKEN OFF. THE GAS TAKE IS UNSTABLE AND TILTED. THE OTHER METAL STRAP IS RUSTED BUT NOT BROKEN YET.

AFTER FILLING UP THE GAS TANK WITH PREMIUM FUEL, WHILE DRIVING DOWN THE ROAD THE GAS TANK STRAPS BROKE DUE TO RUST. THE STRAPS APPEARED TO HAVE BEEN RUSTED COMPLETELY THROUGH, WITH ONLY THE PLASTIC TANK STRAP SLEEVES HOLDING THE TANK UP. THE TANK DROPPED TO THE PAVEMENT, CAUSING A HOLE IN THE FRONT LOWER CORNER OF THE TANK. ALL FUEL SPILLED OUT OF THE TANK. THE FIRE DEPARTMENT WAS CALLED, AND THE SPILL WAS CLEANED UP. THE ROAD WAS WET FROM RAIN AT THE TIME, THUS PREVENTING SPARKING AND IGNITION OF THE SPILLED FUEL, ACCORDING TO THE FIRE CHIEF. *TR

DRIVING HOME FROM WORK AND HEARD LOUD SCRAPING AND THEN SMELLED GAS. PULLED OVER TO FIND GAS TANK DRAGGING ON THE GROUND WITH GAS LEAKING OUT OF TANK. HAD IT TOWED HOME. HAD TO REPLACE GAS TANK,HOSES,VENT AND BOTH TANK STRAPS. THE CONSUMER STATED BOTH STRAPS BROKE AND RUSTED ACROSS THE WHOLE WIDTH OF THE TANK. THEY FELL APART IN PIECES. THEY WERE CORRODED VERY BAD. UPDATED 08/15/11 *TR

I OWN A 1999 FORD F-150, 5.4L V-8 TRITON. I RECENTLY HAD A TUNE UP IN DECEMBER 2010 WITH ALL EIGHT SPARK PLUGS AND WIRES CHANGED OUT FOR A MERE $700. IN FEB 2011, AS I WAS TAKING MY CHILDREN TO SCHOOL, I HEARD A LOUD POP THEN MY ENGINE STARTED TO SOUND LIKE A TRACTOR WITHOUT A MUFFLER ON IT. I PULLED OVER AND CALLED WRECKER TO RETURN THE TRUCK TO MY HOUSE, OUT OF POCKET $60, NOT KNOWING ANYTHING ABOUT ENGINES. I CALLED THE REPAIR CENTER WHO THEN HAD IT TRANSFERRED BACK TO THEIR SHOP FOR REPAIR. THE #8 PLUG HAD COMPLETELY SHOT OUT RIPPING THE COIL WITH IT. THEY FIXED THAT, NOW TWO WEEKS LATER, THE #7 PLUG IS FOULED ACCORDING TO THE MECHANIC. THIS IS A MAJOR SAFETY CONCERN AND A FINANCIAL BURDEN, AS I READ OTHER STATEMENTS OF THE SAME DEFECTIVE ISSUES WITH FORD, CONSIDERING FIRE COULD HAVE BEEN A RESULT. PLEASE RE-OPEN THIS INVESTIGATION AND FORCE FORD TO ISSUE RECALL SO THAT THOSE OF US WHO ARE FINANCIALLY STRAPPED CAN HAVE OUR TRUCKS REPAIRED. OTHERWISE I CAN ASSURE THAT I WILL NEVER BUY FORD PRODUCT AGAIN. *TR

TOOK OUR F150 FORD IN FOR AN OIL CHANGE AND TO CHECK EVERYTHING OUT. FOUND THAT ONE GAS TANK STRAP WAS RUSTED ALL THE WAY THRU AND THE OTHER ONE WAS ALMOST RUSTED THRU. NOT VERY SAFE@. *TR

TL*THE CONTACT OWNS A 1999 FORD F150. WHEN THE CONTACT ATTEMPTED TO SLOW DOWN FOR A TRAFFIC LIGHT THE FUEL TANK SEPARATED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST AND CONFIRMED THAT THE GASOLINE TANK STRAPS WERE CORRODED. THE VEHICLE WAS REPAIRED. THE DEALER REPLACED THE GASOLINE TANK, STRAPS, AND HOSES. THE FAILURE AND THE CURRENT MILES WERE 101,014. UPDATED 06/01/11*LJ THE CONSUMER ALSO HAD TO REPLACE THE GAS LINES. UPDATED 08/22/11

1999 FUEL TANK STRAP RUSTED APART AND FUEL TANK FILL NOZZLE BECAME LOOSE WHEN STRAPS LET GO AND FUEL BEGAN COMING OUT. *TR

I HAVE A 1999 FORD F150 THAT WHILE DRIVING DOWN THE HIGHWAY AT 70 MILES PER HOUR, THE #3 SPARKPLUG SUDDENLY BLEW CAUSING THE TRUCK TO TREMENDOUSLY JERK. I HAVE READ NUMEROUS COMPLAINTS OF THIS HAPPENING AND FORD DENYING IT IS A ISSUE WITH THEIR MOTORS. I CANNOT AFFORD $800 THAT FORD WANTS TO CHARGE ME TO FIX A SPARK PLUG ISSUE. I'M NOT MECHANICAL INCLINED AND DO NOT KNOW HOW TO DO IT BY MYSELF. MY TRUCK HAS BEEN SITTING FOR 2 MONTHS BECAUSE OF GROSS NEGLIGENCE BY FORD MOTOR COMPANY BY NOT TAKING RESPONSIBILITY FOR AN ISSUE THAT CLEARLY NEEDS TO BE RECALLED AND REPAIRED BEFORE (IF IT HAS NOT HAPPENED ALREADY) CAUSING DEATH. LUCKILY, IT WAS LATE AT NIGHT AND NO OTHER CARS WERE NEAR ME WHEN IT JERKED MY TRUCK SO BADLY THAT SOMEONE CLEARLY WOULD HAVE REAR ENDED ME.

WHILE DRIVING 45MPH ON SUBURBAN TWO LANE HIGHWAY I HEARD A LOUD BANG AND SUBSEQUENT RHYTHMIC POPPING SOUND ACCOMPANIED BY AN ENGINE MISFIRING. UPON INSPECTION I FOUND THE # 4 CYLINDER SPARK PLUG LYING ON THE VALVE COVER; UN ATTACHED TO THE CYLINDER HEAD. THE MECHANIC FOUND THE THREADS "BLOWN OUT" OF THE HEAD AND HAD TO UTILIZE A HELI-COIL KIT TO REPAIR. THE SPARK PLUG WAS A MOTORCRAFT ORIGINAL EQUIPMENT PART. THIS SEEMS TO BE A PREVALENT PROBLEM WITH THE TRITON 5.4 LITER ENGINE. I SUSPECT THE PROBLEM ORIGINATING FROM UNDUE STRESS FRACTURES IN THE ALUMINUM HEAD AFTER CONTINUED USE AND INHERENT THERMAL DIFFERENTIAL RATES (EXPANSIONS/CONTRACTIONS) OF THE TWO DIFFERENT METALS; I.E. STEEL SPARK PLUG VS. ALUMINUM ALLOY HEAD. POOR ENGINEERING !! I AM THE ORIGINAL OWNER OF THE F150 WITH 140K MILES. *TR

1999 FORD F150 BRAKE FAILURE DO TO BRAKE LINES RUSTED THROUGH. *TR

WE HAVE A 1999 FORD F-150 AND THE GAS TANK FELL OUT! FORTUNATELY IT WAS AT HOME IN THE DRIVEWAY, BUT THIS IS CRAZY. WE WERE BACKING UP OUR DRIVEWAY WHEN WE HEARD A THUD AND THE TRUCK WAS SHAKING AND JITTERING. WE CONTINUED UP THE DRIVEWAY, WHICH CAUSED A DEEP GOUGE IN THE DRIVEWAY. WE'RE GOING TO HAVE TO HAVE OUR DRIVE WAY REPAIRED, AND WE JUST HAD IT PUT IN ON OCTOBER 16TH, 2010. THE STRAPS THAT HOLD THE TANK IN PLACE, RUSTED OUT, THEY ARE A CRUMBLED MESS. WE ARE CURRENTLY TRYING TO FIND A WAY TO GET THE GAS OUT OF THE TANK SO WE CAN LIFT IT BACK IN TO PLACE AND USE NEW STRAPS. *TR

STRAPS TO HOLD FUEL TANK ONTO VEHICLE RUSTED OUT AND FAILED. HAD TO REPLACE FUEL TANK STRAPS. *TR

TL*THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 TO 60 MPH ON ICY ROAD CONDITIONS AND CRASHED INTO A HERD OF CATTLE AND THE AIR BAGS DID NOT DEPLOY. NO WARNING LIGHTS WERE VISIBLE PRIOR TO THE CRASH. THE CONTACT AND THE PASSENGER RECEIVED MINOR ABRASIONS AND BRUISES. THE POLICE WERE CALLED, BUT DID NOT ARRIVE. THE VEHICLE WAS TOWED, BUT HAD NOT BEEN INSPECTED NOR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 167,000. UPDATED 03/29/11 *BF UPDATED 05/06/11

F-150 FUEL TANK MOUNTING STRAP FAILURE. *TR UPDATED 08/01/11 *BF THE CONSUMER STATED THE FORWARD STRAP FAILED. IT BROKE NEAR THE FRAME ATTACH POINT. THE STRAP WAS MANUFACTURED WITH A SPOT WELD DOUBLER PLATE WHERE IT ATTACHES TO THE FRAME. BOTH STRAPS WERE SEVERELY CORRODED. THE TRUCK IS GARAGE KEPT AND SHOWS NO SIGNS OF CORROSION ELSEWHERE. NO FUEL WAS SPILLED AND THE STRAPS WERE REPLACED BEFORE TOTAL SUPPORT FAILURE OCCURRED. UPDATED 08/02/11

I HAVE A 1999 FORD F-150 WHILE ON VACATION I HEARD SOMETHING BREAK WHEN I TOOK IT TO THE SHOP THEY SAID THAT ALL OF MY STRAPS HAD SNAPPED THE ONLY THING HOLDING IT UP WAS SKID PLATE AND ON THE SECOND INCIDENT WAS WHEN I WAS DRIVING MY BRAKE PEDAL HAD WENT SOFT CAUSING ME TO ALMOST CAUSE AN ACCIDENT THEN THE BRAKE LIGHT HAD CAME ON WHEN I TOOK IT TO FORD THEY HAD SAID THAT ALL MY BRAKE LINES FROM THE BACK TO THE MASTER CYLINDER HAD TO BE REPLACED SO BETWEEN THE TWO INCIDENTS THE TRUCK HAS COST ME CLOSE TO ONE THOUSAND DOLLARS. *TR UPDATED 08/01/11 *BF BOTH STRAPS FAILED DUE TO RUST. THERE WAS NO FUEL SPILL. UPDATED 08/02/11

1999 FORD TRITON 5,4L. #2 SPARKPLUG THREAD FAILURE. THE SPARKPLUG WAS BLOWN OUT OF HEAD AND IGNITED A SMALL FIRE UNDER THE HOOD. *TR

I WAS DRIVING A 1999 FORD F-150 ON THE HIGHWAY AT 70 MPH WHEN THE GAS TANK STRAPS BROKE AND THE TANK DRAGGED ON THE HIGHWAY FOR 5 MILES BEFORE ANOTHER DRIVER NOTICED THE DRAGGING TANK AND MOTIONED FOR ME TO PULL OVER. THE ONLY THING HOLDING THE TANK FROM COMPLETELY FALLING OFF WAS THE FUEL LINES. THE TANK WAS ALSO LEAKING GAS ON THE HIGHWAY. THERE WAS NO FIRE, BUT MOST LIKELY THERE WOULD HAVE BEEN IF I DIDN'T PULL OVER. THE REPAIR SHOP SAID THAT IT WOULD COST ABOUT $600 TO REPLACE THE DAMAGED TANK AND FUEL PUMP. THE TRUCK IS NOT WORTH REPAIRING, SO IT IS GOING TO THE JUNK YARD. *TR

MY 1999 FORD F150 TRUCK WAS SITTING IN MY DRIVEWAY AND HAD NOT BEEN DRIVEN FOR OVER TWO DAYS. THE ECU MODULE SHORTED OUT AND STARTED TO BURN LARGE AMOUNT OF SMOKE BILLOWED OUT FROM UNDER THE HOOD OF TRUCK. TRUCK WAS REPAIRED WITH A USED PART SINCE FORD NO LONGER MANUFACTURES THE ECU MODULE. *TR

I HAVE A 99 FORD F150 PICKUP TRUCK WHICH HAS TWO FUEL TANK STRAPS THAT ARE UNSAFE BECAUSE OF EXTREAM RUST. ONE IS COMPLETELY RUSTED THRU AND THE OTHER ONE RUSTED BADLY. I HAD THEM REPLACED AT MY EXPENSE BY FORD DEALER. I CALLED FORD MOTOR CO AND TALKED TO REP REGARDING POSSIBLE RECALL AND WAS TOLD THERE WERE NO PLANS FOR A RECALL OF THIS DEFECT AT THIS TIME. THIS WAS ON SEP 27 2010 BY CUSTOMER RELATIONSHIP CENTER REP. THERE WAS NOT AN INCINDENT BECAUSE OF THIS DEFECT BECAUSE I INSPECTED MY VEH AND SAW THE PROBLEM MYSELF AND WENT TO FORD DEALER TO INQUIRE ABOUT POSSIBLE RECALL AND WAS TOLD NONE, SO I CALLED FORD CUSTOMER SERV. *TR

1-SEVERE CORROSION OF FUEL TANK STRAPS. THE REAR STRAP IS COMPLETELY RUSTED THROUGH, RESULTING IN THE TANK BEING HELD UP BY THE FRONT STRAP. THE SKID PLATE IS KEEPING THE TANK FROM FALLING DOWN. LUCKILY I NOTICED THIS WHILE CHECKING THE AIR PRESSURE IN MY TIRES. I WILL BE GETTING NEW STRAPS THIS WEEK TO DO THE REPAIR MYSELF. I WILL KEEP THE OLD STRAPS. 2- BRAKE PRESSURE SWITCH ON MASTER CYLINDER LEAKS. THIS CAUSES THE CRUISE CONTROL TO BE INOPERATIVE. BRAKE FLUID LEAKS OUT ONTO THE WIRING. THIS VEHICLE HAS HAD THE REPAIR FOR THE RECALL ON THE WIRING HARNESS. I BELIEVE THAT THE LEAKING BRAKE PRESSURE SWITCH ALSO CREATES A FIRE HAZARD AS IT COULD POTENTIALLY CAUSE A SHORT IN THE WIRING. I WILL ALSO OBTAIN AND REPLACE THIS PART. *TR

TL*THE CONTACT OWNS A 1999 FORD F-150. WHILE EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL TANK STRAP HAD RUSTED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 115,000.

1999 F150 4X4, THE REAR FUEL TANK SUPPORT STRAP WAS RUSTED IN HALF AND HANGING BELOW TRUCK. I REPLACED BOTH STRAPS ON THE TRUCK. *TR

3 SEPARATE INCIDENTS OF BRAKE FAILURE DUE TO ROTTED/RUSTED BRAKE LINES. LUCKILY THE INCIDENTS HAPPENED AT LOW SPEEDS AND I WAS ABLE TO STOP WITH THE EMERGENCY BRAKE. IF I WAS GOING FASTER THIS COULD HAVE HAD DEADLY CONSEQUENCES! SINCE THEN, ALL BRAKE LINES HAVE BEEN REPLACED WITH STAINLESS STEEL LINE AT MY OWN EXPENSE. EVERY PROBLEM THAT I HAVE HAD WITH THIS TRUCK (AND THERE WERE MANY) CAN BE TRACED BACK TO CATASTROPHIC METAL FATIGUE! THERE IS NO EXCUSE FOR THIS MANUFACTURERS CONTINUED USAGE OF SUBSTANDARD AND/OR POORLY DESIGNED MATERIALS!!!! *TR

1999 FORD F-150 WAS TOWED INTO SHOP FOR A NO START PROBLEM WHICH WAS DIAGNOSED AS A FAULTY FUEL PUMP. THE FUEL PUMP ON THIS PARTICULAR TRUCK IS LOCATED INSIDE THE FUEL TANK ITSELF WHICH MUST BE REMOVED TO GAIN ACCESS TO THE PUMP. WHEN STARTING THIS PROCEDURE, THE MECHANICS IMMEDIATELY DISCOVERED THAT BOTH TANK STRAPS HAD RUSTED THROUGH AND THE FUEL TANK WAS NO LONGER HELD IN PLACE BY THE FUEL TANK STRAPS AND WAS INSTEAD RESTING ON THE FUEL TANK SKID PLATE. IF THIS WAS A 2-WHEEL DRIVE VEHICLE, THERE WOULD HAVE BEEN NO SKID PLATE AND THE TANK WOULD INSTEAD HAVE BEEN DRAGGING IN THE GROUND CREATING A DANGEROUS SITUATION. *TR

WHEN TRUCK IS FILLED WITH GAS..THE TANK LEAKS.....AND VERY STRONG GAS SMELL..... *TR

TL*THE CONTACT OWNS A 1999 FORD F-150. WHILE DRIVING 35 MPH, THE FUEL TANK SUDDENLY FELL OFF THE VEHICLE BECAUSE THE STRAPS THAT HELD IT HAD RUSTED. THE VEHICLE WAS TOWED TO A REPAIR SHOP BUT HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 162,000. UPDATED EVOQ 12/01/10

1999 FORD F150 4WHEEL DRIVE THE FRONT GAS TANK STRAP BECAME DETACHED FROM THE MOUNT . THE STRAP DRAGGED THE GROUND . I AM HAPPY IT DID NOT CAUSE ANY OTHER DAMAGE. THE STRAP MOUNT IS TOTALLY RUSTED THROUGH AND I DO NOT KNOW HOW OR IF IT CAN BE REPAIRED. THE TRUCK ONLY HAS 93K MILES ON IT. *TR

THE METAL GAS TANK STRAP ON MY 1999 FORD F150 IS RUSTED IN TWO AND CAUSED THE GAS TANK TO SAG. IF I WOULD NOT HAVE CAUGHT THIS THE OTHER TANK STRAP COULD HAVE BROKE CAUSING MY TANK TO FALL WHILE DRIVING. *TR

IN APRIL OF 2010 MY F150 PICK UP GAS TANK FELL OFF. I HAD TO BUY A NEW ONE. THE STRAPS RUSTED AND THE TANK FELL. I LOST ALL OF THE GAS THAT IN IT. IT COST ME $600.00. THE TRUCK IS A1999. THE STRAPS SHOULD BE MADE OF STAINLESS STEEL. *TR

ON SEPTEMBER 12, 2010, I WAS DRIVING ON A DIRT ROAD AT SPEEDS OF UNDER 25 MILES PER HOUR WHEN I HEARD A NOISE COMING FROM UNDER THE VEHICLE. I PULLED THE VEHICLE SAFELY OVER TO THE SIDE OF THE ROAD AND MYSELF, AND THE 2 OTHER PEOPLE IN THE TRUCK GOT OUT TO ATTEMPT TO LOCATE THE SOURCE OF THE NOISE. IMMEDIATELY, WE NOTICED THAT THE FRONT FUEL TANK STRAP(THE STRAP CLOSEST TO THE FRONT OF THE VEHICLE) WAS RUSTED AND BROKEN. AS A RESULT, THE TANK WAS LOOSE AND BOUNCING. THAT CAUSED IT TO HIT THE UNDERSIDE OF THE PASSENGER COMPARTMENT. SINCE WE WERE MANY MILES FROM AN AUTO PARTS STORE, WE USED A SMALL RACHET STRAP TO KEEP THE FUEL TANK IN PLACE. THE NEXT DAY, I SAW A NEWS STORY ABOUT THE INVESTIGATION, AND DECIDED TO HOLD OFF ON MAKING THE REPAIR UNTIL I CONTACTED THE NHTSA OFFICE. *TR