2020 Ford Explorer complaints

The contact owns a 2020 Ford Explorer. The contact stated while driving 75 MPH and depressing the accelerator pedal, the vehicle failed to accelerate as needed and decelerated significantly while the RPMs increased. The contact stated that the incident was frightening for both the contact and her children who were also inside the vehicle. The contact stated that the check engine warning light was illuminated, and the message "Power Train Malfunction - Reduced Power" was displayed. The contact was able to pull over to the side of the road in a construction zone. The contact stated that upon turning the gear shifter knob to park(P), the vehicle failed to shift to park(P), and the parking brake automatically engaged. The vehicle was towed to the dealer, where it was diagnosed with transmission failure. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 93,000.

As I was driving down the road I heard a pop and a loud grinding sound. I pulled over to check and was immediately stuck in park (in a turning lane on rt1 with a 4yr old and a 8 month old) even though the car was still in drive. The gear shifter would not come out of park no matter what you shifted to, they just flashed. I got the vehicle towed to a shop because I couldn't get ahold of anyone at the dealer. After describing to them what happened and a little research on their end, they discovered that this matched a recall that ford had already released in 2023 for the plant and year model that my car is. The recal number is 23S05. The warning light states that "park not available" even though it's stuck in park. Unsure why it didn't include my vehicle in the recall but being that im having the same problem as this recall, it should be included. Everything in the recall letter matched what had happened to my vehicle.

THE SUNSHADE IS FALLING AND I CANT SEE OUT THE REAR OF THE VEHICLE. DURING REVERSING THE VEHICLE AND TRYING TO CHANGE LANES WHEN LOOKING BEHIND ME I CANT SEE ANYTHING WITH IT FALLING DOWN. IT HAS BEEN CONFIRMED BY A DEALER THAT WASNT FORD. NO WARNING LAMPS MY KIDS TOLD ME ABOUT IT AFTER WE WENT THROUGHT THE CARWASH WHEN I HAD IT OPEN FOR THEM TO WATCH THE COLORED SOAP. I CLOSED IT AND DROVE AWAY AND THEY SAID IT WAS FALLING IN ON THEM

My 2020 Ford Explorer required a transmission replacement just after 100,000 miles. The service department that handled the repair informed me that the issue with my vehicle’s transmission matches the same issue affecting 2021 and newer Ford Explorer models — models which, I understand, have been recalled due to this known transmission defect. Despite this, my vehicle—just one model year earlier—was not included in the recall, and I was required to cover the full cost of the transmission replacement. This is frustrating and concerning, as it indicates the issue may extend beyond the currently recalled model years. To make matters worse, about a month after the replacement, I had to return to the dealership because the transmission required an update that had not been performed. As a loyal Ford customer, I’m disappointed that I’ve had to endure these issues — both with a known transmission defect and with the quality of the repair — at my own expense. Ford Motor Company cannot cover the repairs due to it not being included in the recalled vehicles, even though the issue is the same.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, several DTC were displayed. The contact stated that the messages “Service 4WD”, “Service Advancetrac”, “Cruise Control not Available”, “Collision Alert”, and “Traction Control” were displayed. The vehicle was not yet diagnosed. The contact stated that several months ago the vehicle was repaired for the same failures. The contact stated that the failure persisted. The manufacturer was not contacted. The failure mileage was approximately 80,000.

Sunroof is sagging and blocking rear window/rearview mirror. Hazard for visibility and could possibly fall during driving.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, the vehicle started jerking while depressing the accelerator pedal, with the check engine warning light illuminated. The contact stated that the lights on the electronic gear shifter were flashing, causing the contact to pull over and restart the vehicle. The contact stated that during the most recent failure, the vehicle failed to accelerate, and the contact was left stranded on the road. Due to failure, the vehicle was towed to a dealer and was diagnosed with transmission failure. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 75,000.

I am upset that the led headlamps on my vehicle are not covered. LED lights are meant to have long lives, well beyond my 4 year old SUV. My complaint is that either Ford or the manufacturer of the headlamp should warranty their product to a standard of every other LED product sold. Thank you.

Fuel purge valve not working properly causing the vehicle to not start after filling with gas, needing to keep vehicle running while filling with gas, safety issue. Turbo faulty causing car to loose power while driving and towing. Safely concern for multiple reasons. Flex exhaust pipe broken and mesh ripped causing burning smell and dangerous debris.

The transmission, when slowing down from 3rd to 2nd gear is shifting really hard and jerking. I haven't noticed this when it upshifts, only downshifting. There are times when backing up it will also act like the brake isn't completely off. It will jerk and scoot until you put it in park and let it set for a minute and then start backing up again.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

While driving the car made a grinding noise and experienced a brief loss of power. We were in two lanes of traffic, traveling at 65 MPH on an incline with a tractor trailer behind us. Then when reaching destination the car would not engage in park, but continued to roll. We were visiting our grandchildren’s house and they come out to greet us and my husband was getting out of the car as the car was still rolling. We drove the car to our Ford dealership and the manager drove the car and also experienced the car’s inability to engage in PARK. The Ford dealership inspected the vehicle.

* The component that appears to be malfunctioning is the driveshaft and/or related transmission system. I have experienced repeated issues such as abnormal jerking when switching gears, grinding or clunking noises, and jerking through the drivetrain with erratic RPMs before the vehicle regains power. These symptoms are consistent with problems covered in recent recalls for the 2020 Ford Explorer. The vehicle is still in my possession and available for inspection upon request. *The issues have made it feel unsafe to drive the vehicle, especially with children in the car. The unpredictable jerking and loss of power present a serious danger, particularly when accelerating into traffic or driving at highway speeds. I am extremely concerned that a sudden failure could result in loss of control, a rollaway, or even a serious accident. Another concern is the defect involving the driveshaft or half shafts that might disconnect or stop functioning. This disconnection can lead to a loss of drive power or, if the parking brake is not applied, a possible vehicle rollaway. *While I have not yet had the issue diagnosed by a service center, I have filed a lemon law claim, and I’m in the process of addressing the matter formally. The symptoms I’m experiencing appear to match known issues that Ford has already recalled for the 2020–2021 Explorer models. *The manufacturer has not yet inspected the vehicle, and no inspections have been conducted by police or insurance representatives. I am open

The contact owns a 2020 Ford Explorer. The contact stated while driving approximately 65 MPH, the vehicle was making an abnormal screeching sound underneath the floorboards. The contact stated while slowing down the vehicle stalled. The contact stated there was no warning light illuminated, and the vehicle could to be restarted. The contact had the vehicle towed to a local dealer who diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred two more times. The contact stated that the last failure of the transmission had occurred several weeks ago. The vehicle was taken to the same dealer. The vehicle was diagnosed, and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 147,000.

I was traveling down the highway when my vehicles hood unattached and smashed into my windshield causing extensive damage to my windshield and hood. The impact of the hood releasing and shattering my windshield caused glass to enter the cabin of my vehicle. This was an unsafe incident as I had my toddler in my backseat, and I was traveling down a busy highway at the time of the event causing my vision to be impaired by the hood. I safely maneuvered to the shoulder of the roadway and was able to pull the hood down. Following the incident, I was unable to drive my vehicle due to the windshield damage. I have since contacted my insurance agency and filed a claim for the damages. I have had the windshield replaced, totaling $886.85. I have an appointment with my local body shop for damages to the hood.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the transmission failed to operate as designed, and the vehicle started losing motive power. The contact stated that the vehicle returned to normal functionality afterwards. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the transmission oil cooler had failed and was leaking transmission fluid. The vehicle was not repaired. The vehicle was taken to a local dealer where it was diagnosed and confirmed that the transmission oil cooler had failed. The vehicle was pending repair. The contact stated that recently, while the vehicle was parked, there were oil stains found on the ground. The vehicle was not repaired after the most recent failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The contact related the failure to the Manufacturer Recall Number: 20B34. The failure mileage was approximately 68,000.

The contact owns a 2020 Ford Explorer. The contact stated that the parking assist was inoperable, and the reverse automatic emergency braking was inoperable. The vehicle was taken to the local dealer where it was diagnosed that the sensors needed to be replaced. The vehicle was repaired, but the failure recurred. The contact used a scanning tool and determined that the failure was still present. The contact stated that several unknown warning lights were illuminated. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 61,000.

The contact owns a 2020 Ford Explorer. The contact stated that while driving 70 MPH, the contact depressed the button to open the moonroof, and the cloth material covering the moonroof detached. The contact's daughter was sitting in the second row in the middle seat and alerted the contact to the failure. No warning lights were illuminated. The contact stated that hanging cloth covers over the rear-view mirror was obstructing his view. The vehicle was not taken to a dealer. There was no cause for the failure found. The vehicle was not repaired due to the cost. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was unknown.

Ford Customer Service Case: [XXX] The transmission presented multiple problems, and eventually completed failed. Hard shifting, failing to engage properly, jerking and jolting in gear. Failure to shift to Park after stopping. Failing to shift gears up or down while driving. Loss of propulsion all together after stopping at lights or stop-signs. This put our family at risk, losing power in traffic. No warning lamps presented until the failure happened. The vehicle was towed to the dealership, and transmission failure was confirmed. The dealership did supply an estimate for transmission replacement ($6300). The vehicle is currently available for inspection, and has not yet been repaired. The interesting thing is that all of these symptoms seem to be extremely common for this exact model based on research. Multiple TSBs were issued in relation to the same model and transmission, but no repairs were ever made or suggested for this particular vehicle. It appears there may have been a recall for other 2020 Explorer STs, but somehow this particular one was excluded from the list, but manifested the exact same transmission failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The sunroof screen blocks the rear window view due to sagging. The Ford Explorer has a common issue in which the fabric retractor spring fails causing the sunroof shade to not retract. Once engaged it blocks the rear window view. Additional since it won't retract, it continues to sage due to lack of tension. This will eventually block the rear window.

Panoramic sunroof shade came off track causing it to sag.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at approximately 15 MPH, the vehicle jolted and failed to shift into gear as intended while the gear lever was used. No warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with a transmission failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.

Currently have my vehicle in for a recall notice and mentioned to the Ford service staff that the transmission makes a jerking motion when engaged in a low gear but no warning lights are lit up. Technician states I need an entire new transmission and my vehicle is just barely out of the powertrain warranty. Ford refuses to replace transmission on their dime because its out of warranty. However, I've researched and found multiple complaints of people experiencing the same problem that just barely out of warranty their Ford transmissions are failing and need complete replacement too. Why is this not a recall issue with Ford!? My issue could create a safety issue if it completely failed without warning while I was driving. A car transmission typically lasts between 100,000 to 200,000 miles, or approximately 7 to 10 years for most drivers, yet mine is only 5 years old and 65,000 miles when it failed.

See attached document for complaint

The cloth cover for the panoramic sun roof came off the tracks. Now when you retract the cover, it all comes down into the cabin seriously blocking drivers visibility to the back. I am unable to get the cloth cover back into the track mechanism.

At 84000 miles, just roughly 6k after my "extended warranty" expires ford says my transmission needs to be replaced. I had an issue with my transmission September 07, 2023, they looked at it verified it was slipping and the fluid was dirty but did nothing to replace it at that time acting like that was normal. Ok. It would have and should be covered under the warranty I paid for, they took advantage of me because I'm a women. I have the paperwork from that and I would like someone to reach out to me personally. On top of that there is a recall on other 2020 ford explorer with the exact same engine and transmission as mine. At 84000 miles I should not be looking at replacing a 10,000$ transmission! Especially when they should have fixed it the first time.

Powertrain malfunction/reduced power came on when I came home from work as I pulled in my driveway. The check engine light comes on and off for the past week or two prior to the powertrain malfunction.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (SEAT BELTS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at approximately 30 MPH, the transmission unexpectedly downshifted and the vehicle lost motive power while the accelerator pedal was depressed. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the failure was linked to Technical Service Bulletin: 20 – 2305. The contact was informed that the A-clutch and transmission front support needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 64,000.

I was involved in an accident. I was traveling through a green light and a car was coming towards my driver side, they failed to yield. I attempted to accelerate and my transmission slipped prior to impact. I have tried to address this concern with Ford in the past and have reported the vehicle jerks on acceleration and when slowing down. You can feel the transmission slip when it is attempting to go from gear to gear.

When driving the vehicle felt sluggish and the 4wd fault came on, on the dashboard. Decided to take it to the dealer and they inspected it and stated the front differential actuator needs to be replaced. It's a component that is electrical and it turns on the four wheel drive and turns it off when not needed. This should be covered by ford since it's a manufacturing error for putting faulty components to control the AWD.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Ford Explorer. The contact stated while driving 75 MPH, the sunroof fractured without impact. Additionally, the fractured glass fell onto the contact and all over the interior of the vehicle. The contact sustained cuts from the fractured glass. The contact had not received medical treatment. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

Sun Shade: Sunroof shade guide has lost the bolt securing it to the shade, will need bolt to re-secure. When retracted back sunroof Sun Shade sags, blocking rearview window. Causes driver to be unable to see out back window. No warning lamps. Problem has been inspected by ford dealership. According to ford the bolt that secures the Sun Shade to the sunroof has come out.

When accelerating to enter the highway the car loses forward momentum and emits a loud grinding sound from the console area from the transmission

The contact owns a 2020 Ford Explorer. The contact stated while driving at approximately 65 MPH and driving over a slight deformation in the road surface, the vehicle was swaying to the left and right with the Electronic Stability Control warning light illuminated. The contact slowed down and regained control of the vehicle. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. Additionally, the contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts) which linked a failure with NHTSA Campaign Number: 24V493000 (Steering) in the summary; however, the failures were unrelated. The manufacturer was not informed of the failure. The failure mileage was approximately 118,000.

The contact owns a 2020 Ford Explorer. The contact's husband stated while driving 60 MPH, the brake pedal was depressed, and the vehicle failed to respond. The Forward Collision Avoidance Automatic Emergency Braking warning light illuminated. The vehicle was taken to an independent mechanic and was diagnosed with a possible sensor failure or transmission failure. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

I have 68,000 miles on car and car suddenly started making a thumping sound and jerking when braking. Slip also when driving at low speeds. The Dealership says it needs a new Transmission. I have searched online and found this is a common problem for this year and model.

The wiring is faulty. We have had electrical issues since buying this vehicle. The car is not old- I turned my car on put it into reverse and all these lights popped up saying there’s electrical issues and it can’t work and the brakes legitimately did not work. We almost went into traffic from a business with no ability to break. For a 4-5 year old car this should not even be a thing I feel like. And it should not be having this serious electrical issues. Everything electrical in the car is not working and the fuses are fine according to the mechanic. Si we are going down the list of issues that could be an issue. But he is saying the wiring could just be faulty. Which is scary because it almost cost me and my oldest child our lives.

The vehicle was driven to the destination and then turned off. Upon turning the vehicle back on and attempting to drive it, the vehicle vibrated and shuttered violently at times. The vehicle was looked over on-site before being driven to a mechanic for any loose parts or debris in the fender wells. The vehicle was able to be driven slowly to mechanic and only wide turns could be made or it would shudder and vibrate. After inspecting the vehicle, the mechanic stated that the front axles needed to be replaced and this would solve the issue. Approval for the front axle replacements to be completed was given to the mechanic and the soul was completed. However, the vehicle continued to vibrate and shudder in forward and reverse gears, especially when turning. The mechanic suggested to go to the dealership to get it checked out and reset/reprogram the PCM. The vehicle was taken to the dealer who looked it over and checked for a rear axle bolt failure and then sent it back to the original mechanic to swap the axles as they are unsure if the correct parts were installed. The original mechanic contacted the Ford dealership and ordered the front axles again and installed them. The problem persisted. The mechanic then attempted the completion of the TSB 23-2174 to see if that would help solve the problem. The vehicle was then driven to the dealership to have the PCM reprogrammed and the work completed by the mechanic reviewed. After leaving the vehicle at the dealership for several week

Low beam projector bulb prematurely fails. Replaced under warranty and failed again. Due to dynamic bending feature dealer recommended replacing entire assembly at a cost of $1500. High beam and dynamic bending works, just low beam out of service. Seems like a less costly option to replace LED bulb. Online research lead to other owners reporting similar failures and replacement cost. Some owners replaced control module which fixed the issue, so it is possible that this is controller fault. But a non-working headlight is a safety issue as well as traffic violation. Is this an issue for this agency?

We received a recall stating that one or more of our seat restraint fasteners may have been improperly secured which may not effectively restrain an occupant during a crash, increasing the risk of injury. However, there are no parts or fix available.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was leaking oil near the front wheels. Additionally, the vehicle was shaking while driving at various speeds. The contact stated that the rear seat belts failed to secure the passengers. The vehicle was taken to a certified mechanic, who diagnosed the vehicle and determined that the right and left bearings were leaking oil and needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that there were no additional recalls on the VIN. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

Fuel does not pump in correctly and causes spit back. The car has been taken into ford numerous times without a solution & parts have been replaced. The problem still exists. This causes gas to leak at the gas station as it doesn’t flow fast into the tank even on the lowest flow possible. You are also unable to move the nozzles around, in or out to make it work.

Door handle chrome plating is peeling off. Finger cut when opening the car door. Chrome tips on window buttons had already been recalled for the same reason, but the door handles were not included in this recall. Attached picture of finger was 7 days later.

The panoramic roof fabric has become unhinged from the track and caused a visibility issue for my rear view mirror.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (SEAT BELTS); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

We had an issue where the abs light came on going down the road. If you applied the brakes the dash would say release parking brakes and then the vehicle did not want to stop when I actually needed too.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, the vehicle felt misaligned and made an abnormal rubbing sound. The vehicle was taken to the dealer, where the failure could not be duplicated; however, the dealer recommended the transmission be replaced. The manufacturer was notified of the failure and covered the transmission replacement. The dealer replaced the transmission. The contact stated that the failure persisted. The vehicle was taken back to the dealer, where it was test-driven, and the failure was duplicated; however, the dealer could not determine the cause of the failure. The vehicle was not diagnosed or repaired. The contact related to the failure of Ford Campaign Number: 24N01. The manufacturer was contacted, but no further assistance was provided. The failure mileage was unknown.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle briefly jerked and jolted before returning to normal functionality. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission control module. The contact was informed that the TCM needed to be updated. The vehicle was repaired, but the failure reoccurred. The vehicle was taken to the dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 108,000.