2020 Ford Explorer complaints

The contact owns a 2020 Ford Explorer. The contact stated that while reversing, the vehicle stalled. The vehicle jolted forward while parking. The brakes were locking up. While driving 5 MPH, the steering wheel locked up. The 4-WD fault light was illuminated. The contact stated that the Pre-collision Assist, Hill Assist and Reverse messages were displayed. The contact stated that the failure was related to Technical Service Bulletin: 23-2174. The vehicle was taken to the local dealer, where it was diagnosed that the AWD actuator was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 89,156.

11/5/24 Transmission failed. Gear selector knob went unresponsive. Wrench light on dash came on. 1/2/25- new transmission received. 4/25/25- car hesitates going into reverse gear- 10 second delay. Still continues. 7/1/25- transmission starts slipping again. 7/2/25- transmission slamming while accelerating.

Back latch is getting stuck in secondary position when released. Module is intermittently not communicating.

The contact owns a 2020 Ford Explorer. The contact stated upon shifting to park(P), the vehicle rolled and almost struck two pedestrians. The contact engaged the parking brake, and the vehicle stopped. There was no warning light illuminated. The contact stated upon driving to the residence and attempting to park near the garage door, the failure recurred, and the vehicle struck the garage door. The contact engaged the parking brake and the vehicle stopped. The contact stated that the vehicle then became inoperable. The contact turned off and restarted the vehicle, and the vehicle responded as needed. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 41,000.

The contact owns a 2020 Ford Explorer. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, and then the contact depressed the accelerator pedal, and the engine seized. No warning light was illuminated. The contact attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with a failed power control module. The contact was informed that the power control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced an unknown recall; however, the VIN was not included in the unknown recall. The failure mileage was approximately 90,000.

Experiencing issues with power steering after battery replacement. Taken to two Ford dealerships (Fayetteville, GA & Morrow, GA) . One unable to diagnose (Fayetteville) and the other reset battery settings (Morrow). Issue still persistent with intermittent power steering failure while driving. Very dangerous and scary! Errors that appear: service advance trac, steering assist fault service required & pre-collision assist not available.

The contact owns a 2020 Ford Explorer. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, and the vehicle jerked abnormally. No warning light was illuminated. The vehicle was taken to the dealer; however, the previous owner had previously taken the vehicle to the dealer for diagnostic testing, and the failure information was already in the dealer database. The contact was informed that the failure was due to transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. In addition, the contact stated the vehicle was purchased two weeks prior to the failure. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 47,000.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power after coming to a stop. The contact stated that the oil pressure message was displayed. The contact stated that the failure had occurred thirty days after an oil change. The vehicle was towed to the dealer, who determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

On the glass panels in between the rear and front side windows, the panels are shattering underneath both sides. When looking up online to see if anyone else has this problem, there’s all kinds of pictures of this problem posted online..I’m including photos of mine. Have included photos of driver and passenger side.

The rear axle is slipping when going up any incline and when traveling on regular roads has vibration they have a recall but say mine not covered when it comes from the same plant in question during the time frame listed

Under 23S55 my rear bolt was supposed to be replaced at my recall appointment at the Nice ford dealership in Sioux Falls South Dakota. Only the bushing always replaced as stated by the service writer and also the paperwork says they found no broken bolts and the bushing and ‘hardware’ was replaced. I have the invoice. 1 1/2 year later the bolt snapped causing my differential to nearly come completely off, hanging by one bolt, nearly killing my wife and I, coconut point ford in Estero fl, had the audacity to say bolts aren’t covered under my 100k warranty and the recall is closed so you have to pay. Then they said they’d pay 2100 then 2600 towards the 5300 repair which is not fair as this is a known recall issue that ford failed to fix at my recall appt. Please assist and pressure ford to fix this under the recall. They are saying it is closed which seems inaccurate,

The directional headlights low beams have failed to work on several occasions, it started at 30000 miles. If is extremely dangerous when the headlights go out during night driving.

Under ford recall 23S55 I had my car service @ a ford dealership where I don't believe they replaced the bolt. This was in Jan 2024. It's stated they replaced the bushing and hardware but found no broken bolts so it seems only an inspection was done. That would explain why 1 1/2 year later as this is a 2020 Ford explorer that the rear axle bolt did break and caused the differential to fall off putting my family's life at risk. That being said Ford is refusing to reopen the recall to pay for the damage caused by this ongoing issue. I know there is a class action lawsuit against Ford regarding this so I'd like to settle this amicably with Ford and see if You can help reopen the recall so that my vehicle can be repaired and be safe to drive again.

Driver side headrest does not properly lock in place. The headrest moves from the upright position to a forward angle position when jostled. While braking heavily in a car accident, my driver side headrest abruptly moved forward causing the headrest to slam into the back of my head.

While driving at 50 MPH, the Powertrain malfunction light, Hill Start assist malfunction light , and PreCollision malfunction light came on. Took vehicle to Performance Ford, Randolph, NJ where it was determined that it was the front axle disconnect actuator assembly was broken. FORD is aware of this problem per TSB 23-2174 but has not advised the owners of the problem, at least not myself. The cost was $2946.61. This is a safety issue and should be addressed and repaired by Ford. Also had to rent a car for 3 days

The contact owns a 2020 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side front end of the hood was lower than normal. The vehicle was taken to the dealer, where it was confirmed that the failure was not due to a collision because all the bolts were in place. The dealer determined that the driver's side hood adjuster was missing, and the dealer installed a new hood adjuster on the driver's side of the vehicle; however, the hood remained unleveled. The contact stated that the passenger's side front end of the hood was in contact with the fender while there was a quarter inch gap between the driver's side front end of the hood and the trim. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 68,000.

The panoramic sunroof shade has lost its tension when opens. The roller may have broken its clip to hold since being plastic. When open it blockes from seeing from rear view mirror as it sags down. In short cant use sunroof as it poses a risk of view

The contact owns a 2020 Ford Explorer. The contact stated while driving 40 MPH, there was an abnormally loud sound coming the rear end of the vehicle. No warning light was illuminated. The contact returned to the residence and inspected underneath the vehicle and became aware that the right exhaust had detached. The vehicle was taken to a dealer where it was diagnosed and determined that right exhaust needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21B35 (Right-Hand Catalytic Converter and Right-Hand and Left-Hand Exhaust Flexible Pipe(s) Inspection); however, the VIN was not included in the Customer Satisfaction Program. The manufacturer was notified of the failure but provided no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,416.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact heard a loud sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the rear axle horizontal mounting bolt, causing the rear driveshaft to disconnect. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V675000 (Power Train); the VIN was included, but the vehicle was already repaired under the recall. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 70,000.

After maintaining a speed, accelerating just a bit, the steering wheel vibrates until i increase the speed. Twice I have had it into the shop after I purchased it and the Ford dealership said there is nothing wrong. It cost me the 2nd time. There is a recall on a bolt on the rear axle on mine and a steering bolt on another 2020 vehicle. Another mechanic said it could be the transmition not working properly. It drives down the road good except when accelerating a little. It sometimes has a hard shift into drive or reverse. Thank You

My 2020 Ford Explorer has 63,853 miles on it. My power train started to hard shift up and down out of nowhere on Wednesday June 18, 2025. It was fine in the morning before work and on my way home after work it started to hard shift.

Ford Explorer has a panoramic roof cover that has a small plastic part that breaks and and creates a fold in the material - the window retracts but the material doesn't and fold down. This is a safety risk, because with the shade sagging down it blocks your view of the rear. According to others posting on online forums, a small plastic trim piece that is breaking and the cost to repair is around $1800. Repair shops has to pull the headliner and replace the fabric and new plastic bit. Apparently there is no way to make this repair without removing the entire sunroof window. What a design flaw!

I am filing a complaint regarding a safety issue with my 2020 Ford Explorer that was not properly addressed during a recall repair, leading to a dangerous situation. Vehicle Details Make: Ford Model: Explorer Year: 2020 Recall Repair Details In January 2024, I took my vehicle to Coconut Point Ford in Estero, FL, for a recall repair related to the rear axle horizontal mounting bolt, which was at risk of fracturing. The recall required the replacement of the subframe bushing and rear axle bolt to prevent driveshaft disconnection. Incident Description Recently, while driving under normal conditions, the bolt fractured, causing the differential to nearly detach from the vehicle. This failure could have resulted in a catastrophic accident. I am now facing a $6,000 repair bill for an issue that should have been resolved under the recall. Safety Risk The failure of the bolt and the near detachment of the differential posed a severe safety risk, as it could have led to a loss of control of the vehicle, especially at highway speeds. Dealership Response When I brought this to the attention of Coconut Point Ford, they stated that "bolts are not covered under the extended warranty." However, since this is a recall-related issue, I believe Ford is obligated to cover the repair costs. The service writer, Steve, has been helpful, but the resolution has been delayed. Additional Context I am aware of class action lawsuits against Ford regarding this defect, which allege that the recall fix do

Recently, my 2020 Ford Explorer showed a front passenger TSMP failure followed by the rear driver TSMP failure light about 3 weeks later. Within a day or two of the second TSMP light displaying, I had multiple codes lighting up my dash: 4WD fault, hill-start assist unavailable, service advance track, pre-collision assist unavailable, check manual, etc. I found my car was not accelerating every time I pressed the acceleration pedal, and it would stop maintaining my speed and appear to drift like power was lost for a couple to few seconds before resuming power. This caused me to move into a turn lane or make an unexpected turn off the road as I could not maintain speed in the midst of traffic. It was terrifying and dangerous to myself, my children and the vehicles moving around me. One reputable repair shop replaced the TSMP sensors; however, the codes for the other warning lights showed a communication error that only Ford could diagnose. Ford stated the AWD module failed, which meant the different systems were not in communication when I was driving which led to the loss of power that I experienced multiple times while driving to repair shops. Ford stated the AWD module needed to be replaced. It is unbelievable that I would have 2 TSMP sensors and an AWD module fail in less than 5 years of the vehicle being manufactured when I have never replaced any of those items in 7-8 years of owning other vehicles with similar components. I believe Ford has used inferior parts that they

The contact owns a 2020 Ford Explorer. The contact had received notification of NHTSA Campaign Number: 23V675000 (Power Train) and the vehicle was taken to a local dealer where the recall was repair was performed; however, several months later while driving 50 MPH, the rear axle bolt split in half. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the rear axle bolt was faulty and needed to be replaced. The vehicle was not repaired. The contact was informed that the vehicle was no longer under warranty. The manufacturer was notified of the failure. The approximate failure mileage was 118,000.

While slowing, between 30-25mph the transmission downshifts hard and the vehicle jerks. This just began happening. No alarms or errors present on the vehicle. Regularly serviced with no issues.

Front axle boot defective and leaks grease causing steering instability and possible powertrain failure. Dealer charged $475 to fix/replace the part. Upon further research on-line, it is apparent that thousands of 2020 Ford Explorers exhibit the same problem and the manufacturer should be fixing this problem free of charge.

Vehicle accelerates rapidly at low speeds when attempting to slightly accelerate in slow speed area such as in parking lots. Transmission chugs shifts hard when trying to maintain speeds below 50 MPH. Transmission was rebuilt by dealer under warranty but same problem still exists. Dangerous and happens often.

The contact owns a 2020 Ford Explorer. The contact stated that the vehicle was recently repaired under NHTSA Campaign Number: 25V159000 (Back Over Prevention); however, the vehicle experienced a failure with the back over prevention system. The contact stated that the image on the screen was occasionally blue, or the image was frozen. The contact had taken the vehicle back to the same dealer and was informed there would be a charge for a diagnostic test and the repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 65,000.

The contact owns a 2020 Ford Explorer. The contact stated while reversing out of the driveway and making a right turn, the vehicle felt like the front axle was locked in 4WD Mode. The contact stated that the failure recurred several times while reversing out of the driveway. The power train warning light was illuminated. The vehicle was taken to the dealer, where the failure was confirmed, and the dealer diagnosed that the front axle and the front axle boots needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 78,950.

The Abs failed and my car break system went out while on the highway with two small kids. Very dangerous

The contact owns a 2020 Ford Explorer. The contact stated while driving at various speeds the transmission unexpected downshifted from a high gear to a low gear, and the vehicle lurched forward while attempting to decelerate. The TPMS warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.

When entering a roundabout, the vehicle failed to accelerate for a few moments. The vehicle then suddenly accelerated agressviely putting the occupants at risk for a collision with the oncoming traffic amd vehciles ahead of us, already in the roundabout.

THIS RECALL HAS BEEN REMEDIED AND THERE IS NOTHING WRONG WITH THE CAR. I NEED THIS RECALL MARKED TAKEN CARE OF SO THAT I CAN CONTINUE RENTING IT. PLEASE REMOVE THIS CARE OFF THE UNREPAIRED LIST ASAP!!!!!

On May 14, 2025, at approximately 72,000 miles, the vehicle began making a loud rumbling noise when put into gear and proceeding in forward or reverse. The rumbling\shaking would happen to a lesser degree if torque was maintained in the system and all turns were made while accelerating. The vehicle was immediately taken to the Ford Dealership. The transmission tech began to back up the vehicle, at which point the rumbling\shaking occurred and the tech stated that the rear differential (RDU) had failed. The vehicle was left at the Ford Dealership awaiting complete diagnosis. The vehicle was previously taken to the dealership on October 8, 2024, October 14, 2024, October 24, 2024, November 19, 2024, and December 16, 2024 to have the rumbling\jerking\slipping issues fixed and the complete drivetrain evaluated. On May 30, 3025, the owner was advised that the diagnosis was a failed rear differential and a failed transmission. As documented in NHTSA Safety Issue ID# 11655556, both front axles were just fully replaced replaced three times on October 2, 2024 (65,221 miles), October 16, 2024 (65,301 miles), and October 28, 2024 (65,597 miles) September to address issues with severe vibrations and rumbling which occurred when making turns and driving around curves. These severe vibrations and rumblings coupled with rough shifting and a hop\slip of the transmission when approaching 0 mph caused alarm and deep concern to the passengers in the car, so much so that they expressed fear for

Transmission harsh shifting and sometimes going into limp mode where vehicle will not accelerate even on the highway and at highway speeds- according to ford dealer their is no recall for this- vehicle has 64k miles but it’s a 2024 and apparently out of warranty- sometimes it will shift down to 1st gear at 55mph. No help from ford- dealership wants $180 just to diagnose problem.

This vehicle is equipped with a panoramic sun/moon roof which has a cover inside that retracts to keep the sunlight out. Something has failed in the mechanism that retracts the fabric cover and it is causing it to sag down and block the rear view mirror visibility. Ford Motor should issue a recall on this as it is a design flaw and a common failure point in these vehicles. This part can fail without warning, at any time and block the driver's view through the rear view mirror and cause a dangerous visibility issue to the rear of the vehicle.

While driving at highway speeds, my 2020 Ford Explorer ST began to hard-shift and hesitate between gears, resulting in a dangerous loss of power. The transmission would delay or fail to engage, making it difficult to accelerate or maintain speed, creating a serious safety risk for both myself and my wife while in traffic. After safely reaching home and placing the vehicle in park, the transmission completely failed. It would no longer engage Drive or Reverse and behaved as though it was in Neutral in all positions. No warning lights or error messages were displayed at any point before, during, or after the failure. The vehicle has only 85,000 miles, and the failure occurred just after the extended warranty expired. I have since learned that the 10R60 transmission in this vehicle has experienced similar issues in other Ford models, indicating a possible widespread defect. This failure could have caused a serious accident had it occurred at high speed or in heavy traffic.

The sunroof shade on the explorer just dropped blocking my rearview mirror view.

Loose trim in the exterior rear window came loose and flew towards another can the lucky avoided the metal trim

The hill assist malfunction warning followed by multiple malfunction warning failures started about a two weeks ago since being inspected at the dealer. Other warnings include pre-collision malfunction warning and advance track malfunction warning occurs then a wrench appears on the top left of display screen

Back up camera glitches and back up lights went out cause me to back into a tree at night

The vehicle’s transmission system has been malfunctioning exhi jerky, delayed, and unpredictable shifting behaviors, especially noticeable at speeds between approximately 27 an 30 mph and higher. At lower speeds, the jerking is less frequent, but as speed increases, the jerks become more severe and abrupt. These issues manifest during various driving conditions, including accelerating, decelerating, coming to a stop, and lane changes on highways and city roads. When the problem first occurred, the vehicle suddenly jolted in a manner that felt as if I had been rear-ended, causing a sharp, uncomfortable sensation akin to whiplash. The unexpected jerks cause the vehicle to surge or hesitate unpredictably, significantly affecting my ability to maintain smooth control. On multiple occasions, this behavior happened while I was slowing down at stop signs, red lights, or in traffic, with vehicles close behind me, increasing the risk of rear-end collisions. In one hazardous incident, while attempting to merge from the right lane to the outermost left lane in order to cross an intersection, the vehicle jerked suddenly and unexpectedly, nearly causing me to collide with multiple vehicles behind me. This loss of control was alarming and made it unsafe to continue driving in this condition. At the time of these transmission malfunctions, my children were passengers in the vehicle, which made the situation even more alarming due to the increased risk of injury to my family. To date, this t

The rear hatch of my 2020 Ford Explorer does not open reliably. There is no manual release mechanism to open the hatch in case of failure. The only methods to open the hatch are via the button on the hatch itself, the button on the dashboard, or the key fob. When any of these are pressed, the hatch makes sounds as if it is trying to engage and open, but it does not actually open. Additionally, the vehicle dashboard displays an alert indicating that the hatch is open, even though it remains securely closed. This false alert is confusing and concerning. The problem is unpredictable and intermittent, sometimes allowing the hatch to open normally, but often failing without warning. This issue significantly limits access to the cargo area and poses a safety concern in situations where quick or emergency access to the hatch is needed. I had the vehicle inspected by a dealer regarding the hatch issue. They diagnosed the problem as a faulty hatch motor. The estimated cost to repair or replace the motor is approximately $1,300.00. Given the high cost, I am concerned about the safety and reliability of the vehicle, as well as the financial burden of any potential repairs. Because the rear hatch does not open reliably, I am forced to access the cargo area by crossing over the rear seats, which is inconvenient and unsafe, especially when carrying groceries or large items. Moreover, I am unable to access the spare tire in case of an emergency, which poses a serious safety risk.

Back up camera turns off out of nowhere while in use. We have to stop immediately and turn back and not always is there visibility through the rearview window. Has not been inspected, they wanted to charge me $200 just to look at it. Once it goes out after a while it states that backup camera not available and to contact the dealership on the screen.

Vehicle continuously shows a fault for Hill Start Assist, AWD Mode disabled, AdvanceTrac fault, Park Sensor, AWD Module Failure, ABS disabled. These faults started showing 13/04/25. While in traffic, driver was giving the throttle gas. While giving gas, driver lost power, and noticed a ticking noise as car was losing power in normal drive mode. Driver could have potentially been rear ended, pushed into traffic, and fear that the vehicle will eventually have a brake failure; or have the brakes lock up on the car while driving that could also lead to fatality, or bodily injuries of driver, or civilians. After making it to destination, driver parked for the night. The next day driver started car all faults were gone. Driver then trashed car to dealership to see what malfunction the car had and everything was fine. Fault later appeared, and driver lost power again. Driver then proceeds to a nearby Auto store where driver had a diagnostic of the car. The store associate then tells driver that the car had a faulty PCM. Driver also notes that the car was Purchased used with mileage reported at 29,000 miles. Driver now has 57k miles. Though car isn’t new. It isn’t old. Being that it is used, car is and was practically new. Driver feels a car with low mileage should not be malfunctioning given the status of its components.

Per Ford, the headlights are supposed to last the life of my vehicle. My drivers side headlight is now out. You can’t just change the bulb. You have the change the whole assembly which is $1500+. The extended warranty doesn’t cover it either. It’s a MAJOR safety issue and most people (like myself) can’t afford it out of pocket

Electronic brake booster has failed. Ford has issued a customer service bulletin to address however ended the program in 2022. This needs to be turned into a recall as it could easily lead to a fatality if not addressed and replaced. Speaking with ford they have done numerous replacements of these.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at various highway speeds, the transmission experienced harsh downshifting from seventh to sixth gear. During the failure, the vehicle was shaking and vibrating abnormally, and decelerated unintendedly. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 35,000.

Sunroof cover no longer fully retracts causing the fabric to hang and block rear visibility.