2020 Ford Explorer complaints

Vehicle suffered a catastrophic drivetrain lock-up while traveling at approximately 25 mph. The rear wheels physically halted, creating an immediate loss of control and safety hazard. Upon inspection, the Rear Drive Unit (RDU) was found to have a failed pinion bearing/internal gear failure, resulting in dual fluid leaks. This is a REMEDY FAILURE related to Safety Recall 23S55 (NHTSA Campaign #23V675000). The vehicle underwent the 23S55 recall repair 90 days prior (Jan 2026). The internal failure is a direct consequence of latent fatigue and stress placed on the RDU pinion and housing due to the defective axle mounting bolts and subframe bushings addressed in the recall. Furthermore, the vehicle is within the coverage window of Ford Customer Satisfaction Program 24N01 (10-year/150,000-mile extension for Rear Axle Bolt and Housing). The dealer (Hertrich Ford) and Ford Corporate Case Management (ASO Case #XXX) have refused to authorize an Administrative Rental or acknowledge the related damage, leaving the owner in a hazardous financial and logistical situation. I am reporting this as a failure of the federal safety remedy to adequately protect the vehicle’s drivetrain from consequential damage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Three alerts appeared on my dash after starting my car. These alerts are “Pre-Collision Assist Not Available,” “Service AdvanceTrac,” and “4WD Fault Service Required.” This has been an ongoing issue with this vehicle which directly affects the safety of drivers. After discussing with other consumers, this system failure is happening more and more. While these alerts are displayed, the front end collision assist is completely nonfunctional, thus increasing the risk of an accident. The Advanced Traction Control System is also nonfunctional. Based on other consumers with the same experience, the only solution is to replace the AWD module.

On Tuesday April 7 as I was driving to work, as I was stepping on the break to pull into the parking lot and when the car hit 25 mph it jerked forward.; this was the first time I’ve ever experienced this so I didn’t think much of it. When I was leaving work that evening pulling out of the parking lot onto the main street the car jerked forward once I hit hit 35 miles an hour and then again jerking as I was slowing down to 25 to make the stop at a light this happened five or six times I live 3.9 miles away from my job. This had never happened before. I called the Ford dealership in Brentwood, Ca Bill Brant Ford as I had an oil change scheduled for Friday, April 10. They told me they would check it out at the time of my appointment. I got a call from the service department saying that my transmission was shot and then I would have to buy a new one for $8000. My car is a 2020. It has 53,000 miles on it and I need to buy a new transmission? I’ve had cars for over 10 years that had never needed a new transmission!! There was never a maintenance light or a check light, so who knows how long this was going on and I wasn’t aware and now five days after the first experience I have to replace the transmission. The service department says it is an internal issue that is why I was not seeing any warning lights… so the owner does get to know there is a problem until it’s too late far a repair?? This does not sound like something that can happen in 5 days.

Scenic sunroof shade has drooped and sagged down impeding my visibility in the rear view mirror to check traffic while backing out and seeing my grandchildren in their car seats

The driver side headlight low beam will not work. Dealership said 1700+ labor to replace. I have looked into this and several other ford explorer platinum owners have same issue.

Thank you for your time reviewing my complaint. I've answered each of your bullet points below. - the transmission is hard shifting in low gears however no warning/no dashboard lights to indicate issue. The vehicle is available for inspection upon request. - I use my car for work which includes transporting individuals to work and appointments. This hard shift happened with a passenger while on the freeway in traffic, then continued for the remainder of the ride each time I approached low speeds. - A vehicle diagnostic was performed by an independent service center/certified mechanic and no errors registered with the transmission. However the transmission diagnosis was determined by the service center driving the car and experiencing the hard shifts. I have a copy of the report. - The vehicle or component has not been inspected by the manufacturer, police, insurance or any other representatives. _ There were no warning lamp messages leading to the problem or a this current time and currently there are no warning lights indicating the transmission issue, although it has been diagnosed by a certified mechanic/service center as "Engine concern - neutralizing in gears between 1st & 2nd". There were sporadic episodes of this "hard shifting" within the last few months and the frequency of hard stops occurring were random. Additionally, there were no warning lamps or messages to indicate an issue. On 4/4/26 a hard shift happened on the freeway and has been consistent daily at low sp

I had a really disappointing experience at Delta Sonic Car Wash in [XXX] and feel like other customers should be aware. During my visit, an employee used a pressure washer on my windshield before I entered the wash. This caused small debris to stick to the glass, and instead of being removed, it stayed on my windshield as my car went through the wash. The equipment then dragged that debris across the glass, leaving a deep scratch about 8 inches long. My windshield was only 2 months old and in perfect condition before this. I reported the damage immediately on-site, but my claim was denied. There was no real accountability, no effort to make it right—just a flat refusal. What makes this even more frustrating is that my fiancé and I have been loyal customers for years. We’ve spent hundreds here and have had memberships every winter since 2018. Because of how this was handled, we have now canceled our membership and have urged others to do the same. Also worth noting—many of the reviews here focus heavily on the food and not the car wash itself, which I now find misleading based on my experience. I understand that accidents can happen, but how a business handles those situations matters. In this case, the damage was caused by their process, and they still chose not to take responsibility. I would recommend taking photos of your vehicle before entering or reconsidering using this location altogether. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

Sunroof liner is sagging, blocking rear vision. Currently unable to use sunroof unless I pay 4k for repairs.

The chrome overlay on the driver side interior door handle is chipping and caused an injury to my finger. The chipped chrome broke off and became wedged in my skin and also resulted in a 0.5in scratch. The injury was extremely painful and required medical attention to remove the broken chrome chip that was lodged in my finger.

Since purchase as a preowned vehicle, we noted this vehicle is equipped with a faulty transmission/tcm software design that is dangerously unpredictable and creates erratic driving conditions. This passenger SUV Is equipped with a 10 speed automatic that (once at operating temperature) the gear shifts and operation become highly unpredictable, often causing severe safety issues navigating in traffic, slowing down to sudden stops, and any acceleration, frequently getting stuck in 1st gear or neutral while attempting to accelerate on roadways from a stop. The (10r60E) has nearly caused several accidents severe accidents while under normal use as our primary family vehicle. The Ford dealerships I contacted were aware the problem was concurrent on every vehicle equipped with that Transmission and deemed it normal operation. This is highly concerning there hasn’t been some sort of safety recall implemented as it is a known flaw that creates very unsafe driving conditions on a vehicle marketed to families.

Vehicle Issue Description – 2020 Ford Explorer Limited (Transmission Failure) The issue involves the transmission system in a 2020 Ford Explorer Limited. The transmission began exhibiting hard and erratic shifting, particularly between lower gears and when decelerating to a stop. A within days experienced complete failure, leaving the vehicle unable to properly move or engage gears. There were no warning lights, messages, or dashboard indicators at any point prior to the failure. This lack of warning prevented any opportunity to address the issue before it became severe. This failure created a significant safety risk, as the vehicle became unreliable in traffic conditions. Hard shifting and delayed engagement made it difficult to predict acceleration and deceleration, increasing the risk of being rear-ended or unable to safely merge into traffic. The final failure rendered the vehicle inoperable, which could have been dangerous if it occurred in a high-traffic or unsafe location. The problem appears consistent with known transmission issues reported by other owners of 2020 Ford Explorers, including hard shifting, jerking, hesitation between gears, and sudden loss of drivability.  Many drivers report similar symptoms progressing to severe transmission problems or complete failure. At this time: •Confirmation by dealer or service center: 3/18/26 Despite the number of similar complaints and documented issues, there has not been a specific recall issued for the transmission syst

I previously reported a safety issue re. Brakes not working in park. Vehicle rolled back and car almost hit mom and young daughter walking behind vehicle in parking lot. When I brought it to BellFord in [XXX] they told me it was not covered under the recall since it wasn’t being caused by rear axle. Instead they wanted to charge me $3,000 to diagnose their manufacturing defect. In addition when I notified Ford rep who never said anything other then I must get car diagnosed and pay for it and then “we will see .” Ford complaint XXX and I believe this is the NHTSA Complaint # XXX. Here is my initial Ford complaint Cxh-XXX was closed without explanation no one could tell me why no one had contacted me. I am very concerned that Ford is not taking responsibility for defective cars. My car now has only 47k. Brake issue. I had to replace front boots due to leaking and front axle was leaking. I had that fixed and now rear back up camera isn’t working. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The driver side door latch is defective. I’ve often been locked in or out of my vehicle. Obviously the main door on the vehicle. Many times i have to climb over the center console to exit my vehicle. What if I’m in an accident or my car catches fire, I can’t get out. Leaving me trapped. Or if I’m in danger and need to get in my car but I’m locked out. Often since latch doesn’t function it doesn’t shut my automatic lights off potentially wearing down the battery. Pretty sure my insurance company would not be happy that they are insuring a vehicle with these dangers and potential for someone to enter my vehicle when it decides to not lock. I’ve been told the vehicle is not part of a recall and the vehicle part is on a national backorder with no ETA. Dealership contacted me recently stating part was in, lost a whole day of work to find out they ordered the wrong part and the part is still not available. I bought this vehicle used off of a lease program only a year ago with 42,000 miles and have only put less that 10,000 miles on it. Transmission issues but dealership says they can’t find anything wrong. Car jerks and makes wining grinding noises when first taking off. I find it hard to believe ford does not think this is s safety issue with driver being trapped in or locked out of vehicle.

I've received more than one recall notice from Ford (Recall Number: 25S09) but ever time I contact my dealer to schedule service, they say that Ford has not released the parts. I'm very concerned since this is a SAFETY recall. I'm also baffled because the letter says it's a "improperly torqued" fastener. I don't understand why they need parts for that. But what the heck do I know? Please help!

Rear view camera 360 camera when backing up is going to a blue or black screen. When it’s not going black or blue the image is very grainy and hard to see image while backing up.

2020 Ford Explorer with the 10r80 transmission went bad. Shuttering between 2/3 gear, neutraled out of gear. Shop wants $5,800 for a remanufactured transmission.

Transmission had hard downshifts, whining, would.not change gears intermittently and would clunk when going into reverse or drive. Upon inspection at the dealership, the fluid was burnt and there were chunks of gears in the transmission pan.

SUMMARY OF FACTS FOR LEGAL CONSULTATION Bad Faith Redhibition Claim — Louisiana Civil Code Art. 2545 Prepared for Attorney Consultation 1. Vehicle & Transaction Information Vehicle2020 Ford Explorer ST — AWDPurchase DateMarch 2025Purchase Structure$17,000 trade-in applied + $17,000 remaining loan balanceAdditional Warranty$2,500 paid warranty purchased through dealership at time of saleSelling DealerIndependently licensed dealership (non-Ford franchise)Warranty ServiceWarranty work performed during coverage period 2. The Technical Service Bulletin (TSB 23-2174) Ford issued TSB 23-2174 in July 2023 — nearly two years before the vehicle was sold to the client. Key facts about the TSB: •Covers: 2020–2021 Ford Explorer/Lincoln Aviator AWD vehicles •Component affected: Front Axle Disconnect Actuator (FADA) — left side •Failure mode: FADA O-ring seal failure causing AWD malfunction, triggering powertrain warning light (wrench icon) with DTCs C00A6 and/or C0631 •Required repair per TSB: Full replacement of FADA with revised intermediate shaft AND reprogramming of transfer case control module •Result of proper TSB repair: Permanently eliminates front axle disconnect capability — a fundamental, permanent change to vehicle drivetrain operation •TSB was publicly available on [XXX] at time of purchase — free, searchable by VIN 3. Critical Pre-Sale Service Record — January 2025 The dealership's own service center performed the following repair on the vehicle approximately 1–2 months befor

My Right windshield wiper dose not working properly . When I turn on the wipers the right one don't move . Sometimes it will come up but the only one that's works right is the left one . This is a safety hazard for driving

The Driver's side pillar along the door and windshield blew off and almost hit the car behind me. On 10/22/24, the exact same thing happened but on the passenger side that time. Our Ford Dealer said the 2020 Ford Explorer model was not a recall item only 2017-2019 however later models also had many issues where these side pillars blew off.

On 2/27/26 I heard a knocking sound in my car, no warning lights came on, took it to local car place and was told there was no oil in the tank. I immediately made an appt to take it to River View Ford dealership for service. They looked at it on 3/2 and found the engine to be damaged from the turbos pulling oil out of the oil tank and sucking it into the engine. They informed me nothing was being offered to replace the engine for that year 2020 and my warranty just ended 11/25. This car is worth $70,000 new, just paid it off early, otherwise in great condition. I called the Customer service line and was told there is nothing they can do or offer and filed the complaint. My husband called back and spoke to 3 different rude people requesting someone call our dealer and talk with the service people- this didn't happen. Earlier this year this car had a differential leak that cost $3000; it also had the undercarriage of the car that holds the flex pipes up, fall apart and required the entire undercarriage to be replaced. I find it appalling that you google ST engine issues and they specifically say 2020 models have issues with and suffer from severe oil-related issues, including high oil consumption, oil starvation, and, in some cases, turbocharger failure or engine knocking. How is this not a recall? No warning signs til its too late.

Power Train, Automatic Transmission Issue The vehicle is a 2020 Ford Explorer XLT with approximately 71,000 miles. The automatic transmission has developed delayed engagement and harsh shifting during normal driving conditions. The issue occurs most often during low speed driving, rolling stops, and when shifting from Park into Drive or Reverse. The transmission will hesitate or pause before engaging, followed by a sudden harsh shift or jerk into gear. The condition has been reproduced multiple times during normal driving and is consistent. This behavior creates unpredictable vehicle response when I accelerate into traffic or proceed from a rolling stop. The delay followed by sudden engagement can cause the vehicle to lurch forward unexpectedly, which could increase the risk of a crash when entering intersections, merging into traffic, or operating near pedestrians. The vehicle is scheduled for inspection at a Ford dealership, and the issue will be evaluated under known Ford technical service bulletins addressing harsh or delayed shifting in the 10-speed automatic transmission. At this time, the vehicle has not yet been inspected by the manufacturer. The vehicle will be inspected by an authorized Ford dealer Monday March 9, 2026. No warning lights or messages have appeared. The condition occurs without warning indicators and is noticeable through delayed engagement and harsh gear shifts. My vehicle has been regularly maintained and received the recommended 60,000 mile service

Wheels / Tire Pressure Monitoring System The tire pressure monitoring system (TPMS) on my 2020 Ford Explorer intermittently fails to detect the tire pressure in one or more tires. The system will show missing pressure readings or fail to display a reading for a tire. The vehicle may operate without accurate tire pressure information being displayed to the driver. This creates a potential safety risk because the driver may not be alerted to a low tire pressure condition. The vehicle had approximately 56,000 miles when this began, and the issue appeared without prior warning. The vehicle is scheduled for inspection by a Ford dealership.

Found transmission fluid burnt. Found harsh 7-8 downshift and delayed engagement in various gear ranges. Suspect front support is broken causing damage to a/b clutchpacks. Internal fault. Overhaul required. Found transfer case has failed internally also. Recommend replacing transfer case at same time.

The contact owns a 2020 Ford Explorer. The contact stated that while driving 75 MPH with cruise control activated, the vehicle unintendedly decelerated while the accelerator pedal was depressed. No warning light was illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired because the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 26,000.

Headlight Assembly. Low beam is "out". Check headlight assembly message appears on dash. Was told by Ford that the whole unit needed to be replaced for $1000+. Weeks later it started working normally again. How can it suddenly work when I was told the light was "out"? This has happened to MANY people with a Platinum Explorer.

We have a 2020 Ford Explorer Limited and the sunshade for the sunroof has come off the tracks or something has broken that keeps the sunshade from operating correctly. When the sunshade is open, it hangs down blocking my view of the back window. This seems to be a problem for many people with this model car. The dealership has looked at this and quoted me $1500 for repair.

Passenger headlight, LED low beam has gone out. Daytime running lights, high beam, and turn signal still work. Tried replacing the module and it's the headlamp that is bad.

My Explorer has the optional double moonroof with an electric sunshade that opens or closes with a button. A week ago when I tried to retract the sunshade I noticed that the driver side of the fabric started drooping. After trying a few more times the roller failed to retract the fabric completely. So when I try to open the sunshade the fabric just hangs from the roller and impedes my view out the rear window, thereby creating a safety hazard

I own a 2020 Ford Explorer with approximately 85,776 miles. The vehicle has experienced two separate loss-of-propulsion events in traffic. On both occasions, the vehicle suddenly lost power while driving and stalled in the middle of a busy intersection. There was no prior warning of imminent engine failure. After stalling, the vehicle would crank but would not restart. The vehicle was disabled in the intersection for approximately 45 minutes to one hour each time. My family was inside the vehicle during these incidents. The vehicle displayed multiple malfunction warnings including “Shift System Fault” and messages indicating the vehicle was not in Park even when the shifter was in the Park position. The dealership, Hansel Ford of Petaluma, verified the concern and referenced Ford Technical Service Bulletin (TSB) 23-2249 related to internal transmission components, including the valve body and park pawl actuator system. The dealership confirmed that when the vehicle is placed in Park, it may actually remain in Neutral. This creates an additional safety risk of unintended vehicle movement. This issue presents a serious safety hazard due to: •Sudden loss of propulsion in traffic •Vehicle disabled in active intersections •Extended inability to restart •Potential rollaway risk due to Park malfunction The vehicle is currently pending major transmission-related repairs. I am submitting this complaint due to concerns about loss of propulsion and park system malfunction creating a saf

Sunroof clip broke and fabric sags which can affect visibility.

The rear differential axle bolt on my vehicle has broken. There was no impact or collision prior to this failure. The vehicle suddenly made a loud noise and came to a complete stop in the middle of the road while I was driving with my [XXX] daughter in the car. This created a serious safety hazard. Although my VIN does not currently appear under an active recall, I am aware that there have been prior recalls issued for this specific issue on the same vehicle. I am requesting that this matter be reviewed promptly for safety concerns and potential coverage, as the failure occurred without warning and placed my family at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The back camera screen went blue, even though I already replaced the camera as per the previous recall. This time, the entire screen went blue.

The catalytic converters (both) on my 5-year-old Ford Explorer both failed due to cracked welds. This failure appears to be common with the v6 ecoboost engines. It happened sometime before 124000 miles, it was only noticed because my wife and daughters started complaining about headaches and sleepiness when riding in the vehicle. The failure was only noticed when a mechanic evaluated it, the failure was not noticeable otherwise. I believe this is a very dangerous condition, as the fumes were evidently getting into the vehicle somehow and causing symptoms of carbon monoxide poisoning. The estimate to repair both is $5000, but according to the repair shop, there are currently none available. Ford has acknowledged this defect in Customer Satisfaction Program 21B35 and the 2025 service bulletin covering cracked weld failures. At about the same time, the transmission suddenly. The failure is very specific, and is documented in Ford Technical Service Bulletin 22-2411 as a known defect. The vehicle experienced harsh shifting, delayed engagement, and ultimately complete transmission failure requiring full replacement at a cost of approximately $7000. This appears to be a widespread defect, and I believe it represents a safety concern due to unpredictable loss of drivetrain function.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Driving at speed and starting to slow down the vehicle downshifted hard and afterwards would shift hard on every shift. Vehicle was taken to dealership and was diagnosed with CDF drum failure. Vehicle was under 100k miles and not under warranty.

Sun roof sun shade malfunctions and the shade sags down unable to see out of rear of vehicle, or rear view mirror. Also sags down on rear passengers and children and could cause your passengers to stop breathing from covering your face. Very dangerous.

LED Headlight assembly failure. Loss of headlight is a safety concern because by law you need both headlights working. It allows cars to see you. The malfunction of the headlight has been confirmed by a Ford Dealership. There are several reports online of this happening to the 2020 Explorer LED headlamps. The only warning was the message system.

Sunroof shade failed during normal operation. It is hanging down and obstructing the back window.

The contact owns a 2020 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the transmission was shifting roughly while upshifting or downshifting before slamming into gear. Several warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted and worsened. There was transmission fluid odor coming from the vehicle and entering the cabin of the vehicle through the A/C vents. The contact stated that the engine unexpected revved while driving on the freeway. The contact stated that when the transmission slammed into gear, the vehicle felt like the parking brake was activated. The vehicle was taken to another dealer where it was diagnosed with transmission failure. The vehicle was not repaired due to the cost. The contact stated that the repairs were put on hold until the warranty had ended. Most recently, the contact stated that while his wife was driving at an undisclosed speed, the transmission was shifting roughly while upshifting and downshifting before slamming into gear. The vehicle was pulled over to the side of the road. The contact was called for assistance and went to where the vehicle was pulled over. The vehicle was driven back to the residence in LIMP Mode. The vehicle was towed to another dealer, where it was confirmed that the transmission had failed. The vehicle remained at the dealer unrepaired. The contact stated that the fai

Sagging sunroof shade.

**Upon request, all failed components can be inspected anytime for any reason. From this date (01/23/26) forward. If any repairs or replacementa had been rectified by Ford, receipts of the repair(s) will be provided regardless. I cannot recall exactly when these issues started so my ball park is 5/11/22. That is literally 2 years of driving the car from the show room. I was getting some lights on my dash that I have lost all functions with the vehicle ...ie: drivers assistance, airbags, up hill decent, pre- collision, no driving modes and the car felt normal. I was still under warranty so the repair that was done was an update to the BCM (is what I am told.) So the mechanic did a reprogram to the module. About a year I noticed I was then getting check headlamp notification pin my dash. I check the lamps and all seemed to be just fine. Also I was dealing with a dead battery all the time. at least once a month. But I was told I needed to drive the car more often. No matter still getting a dead monthly battery and here and there "check headlamp". Approx last year 2025, I realized. it was really dark driving the SUV. I get out and long behold the low beam headlamp was out. Played with switches..nothing. Checked into just getting a new one. its is a STAGGERING 1.5K!!!!PER HEADLamp! Well, the cops pull me over 4 times. For a headlight with LEDs why am I even having to price this? This Platinum trim just h I 5 years old and I cant believe all the problems. Along with that I found th

The middle row passenger side seatbelt randomly unbuckles when we drive. We have had ford dealership look at it and are going to fix it as there is not a spicific recall for this but it is a saftey concern as the seatbelt doesn't stay fastened when driving.

Car will be in drive or reverse, start to move with foot on gas then will shift itself into park

Passenger side headlight quit working, except on high beams. Also, dashboard warning came on about headlamp not working. Tried to get new bulbs and was told that the whole headlight assembly had to be replaced and dealership charges $1500+

The vehicle has experienced repeated automatic transmission malfunctions, including harsh and delayed shifting and hesitation. These issues caused unpredictable acceleration/deceleration and hesitation when starting from a stop or merging, creating a safety risk. The condition has been confirmed by authorized Ford dealers with repairs attempted and service bulletin referenced. The transmission is available for inspection. Symptoms have recurred despite repairs. Warning indicators and abnormal shifting behavior were observed intermittently beginning around 65,000 miles.

I was driving on the highway and I heard a loud bang , with grinding and a jerk i assumed the rear axel or differential something in the rear area along with smoke and I was able to swerve to the side of the highway along the grass and jump out with my kids multiple cars where behind me but I turned on my emergency lights & got out just in time before causing a accident , this is all tied to a recall that’s been fixed twice now here we are a third time and it’s back again at ford dealership

The transmission developed a harsh engagement from part to reverse and a harsh downshift when decelerating. The vehicle would frequently not change gears at highway speeds.Inspection showed that the transmission pan was full but fluid was burnt.

On 1/11/2026 while was driving vehicle started making screeching sound. Stopped vehicle and a bolt came off from the rear arm of vehicle and unit was towed for service, which at this moment Ford dealer claimed could not not find any recall notice on file. After researching the internet came across recall 21S11 re Rear Lower Control Arm Bolts May Break announced 3/10/2021.

The 2nd row seat folding buttons have been malfunctioning for years and folding unexpectedly but Ford would simply say that it was user error causing it to stick. In June of 2025 I received a recall for the issue stating the buttons on the second row may bind or stick. The notice said the parts werent available and that I would be notified again by Ford when the parts came in to schedule a service appointment to complete the repairs free of charge. However, the notice was misleading because when the follow up notice came it stated "Following an inspection/replacement, dealers will ensure proper operation of the switch free of charge." When the dealer came to service the vehicle they inspected the buttons and said that they "looked fine" and offered to dust the buttons off. After they left, the seats continued to sporadically fold until finally one day I went to remove my daughter's car seat to a booster and the seat kept folding as I went back and forth to remove the old seat and install the new one. I was able to record a video of the seat folding repeatedly and reached back out to the dealership. The dealership came out did an inspection and took the parts from the vehicle. They claimed they would resubmit the issue to Ford to approve the parts under the recall and/or the manager was willing to pay out of pocket for them. Jordan Ford insisted removing the parts so that the seats wouldn't unexpectedly fold on my daughter. They didn't know if the issue was mechanical, electri