2018 Ford Explorer complaints

The contact owns a 2018 Ford Explorer. The contact stated while driving at an undisclosed speed, the transmission experienced rough downshifting. No warning light was illuminated. The contact stated that the transmission had previously been replaced twice; however, the failure persisted. The vehicle was taken to the dealer, where it was diagnosed with torque converter failure, and it was determined that the transmission needed to be replaced for the third time. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,000.

The contact owns a 2018 Ford Explorer. The contact stated that the front A-pillar trim located at the bottom of the windshield had started to crack and was making an abnormal buzzing sound while driving. The vehicle was taken to a dealer where the contact was informed that the part was not included in NHTSA Campaign Number: 24V031000 (Structure). The dealer referred the contact to the manufacturer who offered no assistance. The vehicle was not repaired. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,698.

The contact's parents own a 2018 Ford Explorer. The parents received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated while driving 80 MPH, the driver’s side A-pillar detached and flew off the vehicle. The vehicle was taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the driver’s side B-pillar trim detached from the vehicle and flew off. Additionally, the passenger's side B-trim pillar was dangling. The contact stated that because of the failure, several wires were exposed, and several unknown warning lights were illuminated. The contact also stated that the tailgate ajar warning light was illuminated with the tailgate properly closed. The contact disconnected the battery because of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the local dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

The contact owns a 2018 Ford Explorer. The contact stated while driving 65 MPH, the driver's side key panel detached. The contact stated that after the failure the liftgate ajar warning light illuminated and the contact pulled over to the shoulder of the roadway. After a visual inspection, the contact observed that the liftgate could no longer be opened. The vehicle was taken to the dealer, who diagnosed a failure with the panel adhesive, resulting in damages to the electrical wiring and preventing the liftgate from functioning properly. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 104,000.

The contact owns a 2018 Ford Explorer. The contact stated while driving 73 MPH, the front driver's side window exterior trim where the keyless entry keypad was located, had detached, and was hanging by the electrical wiring. The vehicle was taken to the dealer, but the vehicle was not diagnosed or repaired. Additionally, the contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,950. Parts distribution disconnect.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side and the passenger's side windshield exterior A-pillar trims had detached. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. Parts distribution disconnect.

My cars B Pillar (security pad) became unattached from my car while simply driving down the road. This part detaching caused my liftgate to lock and make me unable to open my truck for anyone and also the part could have fallen into the road way and caused a disturbance or accident to cars behind me. There was no indication of my security pad going to detach from my car and with the current recall on the A Pillars it is safe to believe that manufacturing caused this issue as well with the B Pillars as other Explorer owners have had this similar experience with the vehicles.

Ford EcoBoost 2.0 engine failure at 66,000 miles as coolant has leaked into the engine compartment and oil pan. Known issue by Ford as design defect on the EcoBoost engines. Current class action lawsuit over this [XXX] et al., v. Ford Motor Company, Case No. [XXX], filed in the United States District Court for the District of Delaware. Plaintiffs have experienced the exact same failures on the EcoBoost engines. Ford issued multiple technical service bulletins (TSBs) and other service messages for vehicles equipped with EcoBoost engines. Luckily, the failure occurred at home and not while driving at highway speeds as there have been reports of fires occurring if vehicle is moving during failure. Vehicle began rough idling 7-10 days ago and check engine light showed a code for misfire of cylinder. Had plugs changed but check engine light returned and then as of today, after overheating light came on dash upon startup with clouds of white smoke coming from exhaust, checked coolant levels and it was empty and drained down into the oil pan showing milky colored oil. Again... Ford knows about this issue with EcoBoost and has since 2017 and has failed to issue recall for customer safety due to cost factors and continues to address on case by case basis with most common offer to cover partial cost of engine replacement. Most consumers don't have the financial resources to sue Ford, so they continue to take advantage of their size and financial power to abuse customers. Please take ac

Both right and left side exterior A-pillar trim parts detached while driving. 2018 Ford Explorer.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, the contact's husband noticed that the passenger's side front windshield trim had detached. In addition, the contact stated that the passenger's side front windshield trim clips had fractured. The dealer was made aware of the failure but confirmed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V316000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

Power Steering Assist Fault warning flashed briefly on 6/1/2024, everything has been fine until 6/8/2024 I went out and started my car the Power Steering Assist Fault warning came on again so I turned the car off and turned it back on the warning was still there. My husband came out and did the same thing, still there. He noticed that the steering wheel was locked and would not turn easily. So we took it down to the Ford Dealership and it is the steering rack needs replaced. My car has 21,000 miles on it. Going to be in shop for 4 days to fix.

The contact owns a 2018 Ford Explorer The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that while at a complete stop and attempting to turn left, the steering wheel seized, and the vehicle veered to the right. The vehicle was taken to an independent mechanic who diagnosed the vehicle with a fractured steering column. The contact was informed that the steering column needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 20,261.

I own a 2018 Ford Explorer there has been an issue when it’s cold out the APIM is not responding and turning on the reverse camera when vehicle is put into reverse. When it is above 70 degrees Fahrenheit the APIM works intermittently. The problem with this is out of the blue when it decides to work at times it turns the radio on with volume at max level This has startled me not knowing it’s going to come on and it won’t let you turn the radio down or power it off. Ford says there is no recall on the issue.

The contact owns a 2018 Ford Explorer. The contact stated while driving at approximately 50 MPH, there was an abnormal sound as if there was something striking the windshield. The contact became aware several months later that the exterior A-Pillar trim was loose. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, the contact noticed that the passenger's side A-pillar trim had detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that on several occasions the vehicle failed to start. Additionally, while driving at various speeds, the vehicle shut off unintendedly. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the alternator was faulty and needed to be replaced. The vehicle was not repaired. The contact stated that the A-pillar trim had detached from the vehicle causing excessive wind noise and water to leak into the cabin of the vehicle. The vehicle was not repaired. The contact was made aware of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 75,000.

Back up camera went blue screen. I noticed they had recalls on the 2018's that were manufactured in October of 2018 however my car was manufactured before Oct 2018

The contact owns a 2018 Ford Explorer. The contact stated that the driver’s side windshield was cracked. The contact also stated while driving at an undisclosed speed, she became aware of a crack on the passenger’s side windshield. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. The windshield failure mileage was approximately 70,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that the vehicle was shaking while idling, initially without warning. Recently, while the vehicle was in reverse(R), the vehicle shut off while idling with the transmission warning light illuminated. The contact restarted the vehicle and drove to an independent mechanic. The mechanic performed a diagnostic test and diagnosed the vehicle with transmission failure. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle related to the transmission. The contact was provided a case number and referred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 120,000.

The contact owns a 2018 Ford Explorer. The contact stated that while the vehicle was parked, he became aware that the driver’s and passenger’s side roof rails were partially detached near the rear of the vehicle. The vehicle was taken to a dealer where it was diagnosed that the roof rails needed to be replaced. The vehicle was repaired but the failure reoccurred. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 70 MPH, the cowl detached, and the contact witnessed a vehicle swerve. It was unknown if the cowl crashed into the vehicle. The contact stated that the failure recurred, the A-pillar trim detached, and the contact heard a flapping sound. The contact stated that duct tape was placed on the trim to prevent the cowl from detaching. The vehicle was taken to the dealer. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the cruise control failed to operate as needed. No warning lights were illuminated. The dealer was not made aware of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable. VIN tool confirms parts not available.

Air bag style seat belt has broken twice and won’t allow seat belt to latch after it breaks. Broke while seat belt was in use and driving down the highway. When replacing the buckle I found that the frame piece on the seat was broke and moved when trying to tighten the buckle. The buckle has been unavailable online through multiple vendors and finally found one in stock.

The contact owns a 2018 Ford Explorer The contact stated while driving 70 MPH, the passenger’s side front door A-pillar trim detached and flew off the vehicle and almost hit another vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The dealer was contacted and recommended that the contact sought assistance from the manufacturer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to confirm when the part would be available for the recall repair. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The contact's son owns a 2018 Ford Explorer. The owner received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Front hood paint bubbling, corrosion and peeling

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving at approximately 65 MPH, the driver's side trim on the A Pillar detached from the vehicle. The contact stated that the trim also damaged a part of the plastic at the base of the windshield and the driver’s side near the A Pillar while detaching from the vehicle. The contact drove the vehicle to a local dealer who diagnosed the vehicle and determined that the trim on the A-Pillar on the driver's side and the entire plastic cowl under the windshield needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 64,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, he heard an abnormal sound emanating from the exterior of the vehicle. After a visual inspection, the contact observed that the windshield cowl had become detached. The vehicle was taken to the dealer, who diagnosed a failure with the windshield cowl. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 40,000.

No incident yet.Between front door and back door, trim not secure. Is this included in recall #24V031?

Car developed leaks and a mold smell. brought car to dealer, apparently, sunroof drains were plugged up cause water to build up in the car. The mold is making my wife and I sick. This is a severe health hazard caused by a manufacturing or design defect. The service dept at the dealer tried 3 or 4 time to sanitize, all failed and now they recommend replacing ALL of the upholstery in the car, rugs, headliner and seats. Mold has permeated this vehicle and it is not driveable. Ford should issue a recall for this problem and cover any costs.

Water pump failed. Coolant is leaking

Ford explorer transmission is out and at 62000 miles just under 5 years old. While driving vehicle it will loose power, making it difficult to drive safely. vehicle is currently at a ford dealership that verified issued. Ford motor company states must submit complaint here. when vehicle looses power it states "check manual" with a wrench symbol. No check engine is displayed.

Three times within the last 4 years I have had a Map Sensor failure. I was told the first time, this is rare. I was told the second time, this never happens twice. This time I'm told that they just don't know what is causing it. Must be 3 bad sensors in a row somehow. The engine failure on [XXX] was nearly catastrophic and I nearly died. I was going 70mph on a [XXX] at [XXX]. [XXX] can be dangerous under the best conditions, this was during dangerous storms along with being at rush hour. The engine completely stalls and I lose all power to drive. The first time it happened in a parking lot in August of 2020. The second time was Sept of 2022 and I was in my neighborhood. Sunset Ford has no explanation and have repaired it and sent me on my way once again. There are no signs this will happen - it just suddenly happens and I have no ability to react due to the complete engine stall. I have also had 2 oil system failures with this vehicle. It has only 42k miles on it. I do not feel safe driving this vehicle. I don't understand how this is acceptable at all honestly. How can I feel safe driving my children in this vehicle? 5 major repairs in just over 4 years. Have the repairs been done correctly? I question why more has not been done to ensure that another catastrophic event doesn't happen that could result in death of myself or family. Even my numerous requests for information and service reports were met with resistance and what seems like attempts at hiding information from Su

The contact owns a 2018 Ford Explorer. The contact stated while driving approximately 55 MPH, a tractor trailer truck passed by in the opposite lane and the rear GPS fin and the radio antenna blew off the vehicle. The contact stated that the loss of the rear fin exposed the electrical circuits to the wind and water. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at 40 MPH, there was an abnormal sound coming from the driver's side of the front window. The contact's wife observed a piece of the molding flapping. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that the exterior A-pillar trim needed to be replaced. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. VIN tool confirms parts not available. The failure mileage was approximately 42,100.

The contact owns a 2018 Ford Explorer. The contact stated that the rear backup camera would display a blue image on the infotainment screen. The dealer was notified of the failure and informed the contact that there were no recalls on the vehicle. The manufacturer was also notified of the failure and was given the same information as the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 42,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that the vehicle was parked when there was heavy rain in the area. The contact stated that after the heavy rain passed when they were placing items in the back seat, they noticed that water was in the cup holder. The contact discovered a crack in the sunroof allowing water to enter the vehicle. The contact stated that the failure recurred multiple times. The contact was concerned that there was no impact on the sunroof to have caused it to crack. The vehicle was taken to a dealer where the vehicle was diagnosed with a cracked sunroof frame. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was 99,000.

Frame around windshield is loose on the right. Rattles when driving at higher speeds.

Lost A pillar trim yesterday on a drive. I was advised that the recall was still in advanced notice. I am not paying to repair my vehicle while they figure their stuff out. I will be driving around without an A pillar now!

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, rainwater was entering the interior of the vehicle. The contact stated that the rainwater was entering from the bottom of the front windshield on the front driver's side. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The contact was informed that parts would be available in ten days. The manufacturer was made aware of the failure. The failure mileage was approximately 55,267. VIN tool confirms parts not available.

See attached document for complaint

Passenger side A-pillor flew off car on hwy near sweetwater tx luckily there wasn’t a car behind while driving hwy speed

The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 65 MPH, the engine overheated. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to the water pump and fan. The water pump was replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 91,200.

The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving at approximately 65 MPH, the passenger side A-pillar detached from the vehicle. The contact called the dealer and informed the contact that the parts were not yet available for the NHTSA Campaign Number: 24V031000 (Structure). The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Heat stopped working in Dec. Had it checked by local mechanic coolant very low but couldn’t find leak. Heat was working and no check engine light ever went on. About month later had car back for oil change and mechanic found leak, again no check engine or warning ever came on. Finally got appt at ford dealer $3000 to repair and was told would take 11 hrs. Ten days later car was supposed to be fixed. Pick up car. Next day when heat was put on there was a terrible burning rubber smell and now a very load noise which wasn’t there when vehicle was dropped off