Torque converter failed at 60k miles. Engine failure at 110k miles while driving causing risk of serious injury due to being stranded in the road. Transmission failure at 127k miles causing risk of serious injury or death due to failing while driving. Driver was unable to accelerate vehicle in automatic (rpms would increase to unsafe levels but no speed was gained). Driver able to switch to Sporty mode and manually switch between gears enough to safely exit the highway. This particular model of the Explorer has been a mess and a headache from day one! Attempted to request a buyback from Ford, which was denied. Ford did provide partial assistance with the replacement of the engine, but refuse to provide any assistance with the transmission failure.
2018 Ford Explorer complaints
Owner reports filed with NHTSA about this vehicle, newest first and reproduced as filed. They are unverified accounts: one proves nothing, and a pattern across many is the thing worth reading. Back to the full 2018 record →
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that the manufactured had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
I bought my 2018 Explorer in July of 2024, End of November 2024 it was completely dead no power what so ever, got it jumped and replaced the battery. Things had been going well until the middle of January I had to jump it every day took it to my dealership they tested the battery and said it had a bad cell, I took the battery back to where I bought it and had it replaced everything went fine again for a week and back to jumping it every single day except this time it would even jump with a jumper pack. There is no lights or warnings on at all indicating at problem
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the A-pillar trim on the passenger’s side was loosened at the top of the trim. Additionally, the rubber gasket around the windshield at the bottom of the windshield under the windshield wipers, was loosened and disintegrating. The failure mileage was approximately 20,000. VIN tool confirms parts not available.
Description In some of the affected vehicles it may be possible that some of the exterior a-pillar applique trim clip attachments are not properly engaged due to improper assembly or repair. If this occurs, the a-pillar applique trim, which borders the right and left side of the windshield, may be loose, missing or become detached. Safety Risk An exterior a-pillar trim part that detaches while driving can create a road hazard for other road users, increasing the risk of a crash. I bought the car Jauary 19, 2024. The parts to fix this was supposed to be here by fall of 2024. This is affecting my job and will not be able to work soon. I do uber and they want this fixed or they will cancel me.
The High-Speed Cooling Fan Motor Relay (Recall 21N01) and the Exterior A-Pillar Apical Molding (Recall 24V031) failed on my vehicle. The cooling fan caused the engine to overheat repeatedly, and the vehicle became undrivable. Unfortunately, I no longer have the vehicle, as it was surrendered to my bank and later sold at auction. However, service records, diagnostic reports, and recall information are available upon request. The overheating engine presented a significant safety risk while driving, as it could have caused the vehicle to stall or catch fire. A AAA roadside technician confirmed that the vehicle was unsafe to drive due to the overheating issue. This defect left me stranded, requiring alternative transportation and creating a hazard for others on the road had I continued driving the vehicle. Yes, the problem was confirmed by a AAA roadside technician, who performed a diagnostic scan and identified that the engine overheating was due to a defective cooling fan relay. The issue aligns with Recall 21N01. The molding defect (Recall 24V031) was not specifically inspected, but it was noted as part of the recall documentation. No, the vehicle was not inspected by Ford or any other representatives after the issues arose. I checked Ford’s website in February 2024 and learned about the recalls, but I was never notified by Ford about these safety defects while I owned the vehicle. AAA provided the only diagnostic assessment before I surrendered the vehicle to my bank. Yes, th
My 2018 Ford Explorer rolled backwards down a hill while in park and engine off.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that the manufactured had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
We took the car in for the recall 24V031 which is not able to be fixed at this time due to lack of parts. The Ford dealership explained to us that there were 2 other recalls on this vehicle that had not been addressed. They asked us if we wanted them fixed. We agreed to have them fixed. One being the luggage rack clips the other being high speed fan motor relay switch. The luggage rack was completed. The dealership replaced the fan not the relay switch as the recall indicated. When we brought the vehile home, the fan was super loud and would come on when ever it wanted too, whether the vehicle was running or shut off. It would also runn continuously even though it was not hot out nor had the car been running. We took the car back to the dealership. They looked into it. Ordered apart that never came. They had our car for 3 weeks and finally after arguing amongst themselves determined the relay switch should be replaced. Once we brought the car home, again the fan is super loud and runs randomly. The dealership has washed their hands of this situation. Telling us we are welcome to take it to another dealership as they believe the fan is running properly. We never had any indication that the fan was running improperly to begin with. My car was quiet and ran wonderfully. Now it is loud and actually embarrassing. Our friend was walking by and heard a loud noise like an airplane. He turned the corner and said wow that's your fan in the explorer, that isn't right. This sucks. I love
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact stated that upon his mother attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the high-speed cooling fan motor relay. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N01. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 90,000.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 65-70 MPH, the driver's side windshield exterior A-Pillar trim detached. The contact later applied tape to secure the trim. The vehicle was taken to the local dealer, where it was inspected; however, the dealer confirmed that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the engine overheated. The contact stated that the vehicle was losing coolant, but there was no indication of a coolant leak. There were no warning lights illuminated. There was cool air coming from the heater vents. The contact called an independent mechanic for orange coolant, who informed the contact that the coolant was on backorder. The vehicle was taken to the local dealer for a routine oil change and diagnosed that the water pump was leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was approximately 95,000.
The A-pillar appliqué trim has cracked and is pulling away from body of vehicle. There is a safety recall notice that was issued in February 2024. I have been calling regarding remedy of this issue and I have been told parts are still not available. It has almost been one year.
While driving down the interstate, parts on both sides of my windsheild came flying off, leaving the sides of my windshield exposed and debris flying behind me into oncoming traffic. I got notice of the recall, called FORD, they indicated it would be fine, its not dangerous, and parts were on back order until February. This happened, I called FORD again, and now the parts are not available until MARCH. Meanwhile I'm drivng around with missing pieces on either side of my windwhield, a whistling wind noise in the interior of my car and possibly damaged someone behind me on the interstate. this is unacceptable on behalf of ford. please advise.
The vehicle experienced multiple defects, including: Overheating due to a malfunctioning cooling fan motor relay. Exterior A-pillar trim detachment. Persistent starting issues, even after replacing the battery. The vehicle is no longer in my possession due to repossession, so inspection may not be possible. How was your safety or the safety of others put at risk? The overheating issue posed a risk of engine failure while driving. The detached A-pillar trim could have caused a road hazard for other drivers if it fell off while in motion. The starting issues left me stranded on multiple occasions, which could have been dangerous in certain environments. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the dealership confirmed the issues but stated the vehicle needed to meet specific conditions (e.g., 100 miles for certain repairs) and required costly repairs that I couldn’t afford. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle was inspected by the dealership, but Ford Motor Company has not performed any direct inspections to my knowledge. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? For the overheating issue, the engine temperature warning light appeared intermittently. For the starting issue, there were no warning lights; the vehicle simply failed to start on multiple occasions
The contact owns a 2018 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal cracking sound coming from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.
This will be another submission as I am getting frustrated. My Explorer has had constant issues like clock work every 6/7 months. I have gone through 6 batteries in a two year time span. I have had the battery control module replaced because I thought that would be the fix. However it is not. While operating my vehicle yesterday on [XXX] after barely even starting the battery died and my car said multiple systems were failing almost causing someone to rear ended me. This is a safety issue like no other. When will I receive feedback for these matters I keep submitting? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the remedy parts were not available. The manufacturer was not made aware of the issue The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact stated that the driver’s side A-pillar trim had raised up. The contact stated that there was a 1-inch gap from top to bottom of the windshield. There were no warning lights illuminated. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 24V031000 (Structure). The vehicle was repaired, but the failure recurred. The vehicle was taken to another dealer, Biener Ford (661 Northern Blvd, Great Neck, NY 11021); and the contact was informed that the recall was closed. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 103,500.
While traveling on [XXX] eastbound in the St. Louis, MO area I heard a pop and noticed my passenger side A-frame trim body piece was free from the top mooring point. This caused me to have to exit the freeway earlier than expected. Fortunately, the trim piece did not come completely dislodged and cause further danger on the freeway. I still need to drive this vehicle with a trim piece that is only partially connected to the vehicle. This is related to an unresolved recall and could cause further safety concerns on an ongoing recall. Please help me contact Ford to ensure a quick resolution to this recall that is supposed to be resolved "late 2024". INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURER); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The local dealer was not contacted. The contact had not experienced the failure. The VIN tool confirms parts not available.
Failed water pump and coolant leak. Numerous vehicles are failed for the same reason at each local shop and Ford dealer we’ve contacted for a quote. Repair costs are expected between $5,000 and $6,000.
Unknown Multiple owners of 2018 Ford Explorers are reporting oil leaks from bad seals. The oil leaks can cause fires, so we are in the process of having our Ford repaired at a mechanic and will know more at a later date.
Intermittent wipers would not turn off. Took car to dealership and they charged $629.38 to fix a FORD quality issue. Wipers scratch the windshield and cause unnecessary distraction during dry conditions as they would not turn off. This issue (wipers not turning off) occurred after the A-Pillar flew off my vehicle and hit another car. The other driver did not stop. FORD needs to cover the cost of the wiper switch and also compensate owners for lack of part availability to fix the A-Pillar issue for a year now. No alerts, warning messages provided.
Driver's side heated seat coil burnt out. Many complaints about this.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V0310000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at approximately 65 MPH, the driver’s side A-pillar trim detached. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 67,000. VIN tool confirms parts not available.
Body control module has went out in the vehicle multiple times. Which causes the battery to die and the vehicle not to start. Part has been replaced multiple times.
Radio and back up screen stop working 1 month after purchase.
The A-pillar appliques on my vehicle are detaching and my windshield vibrates while i drive, putting my family at risk, and others as well. The rubber seal around windshield is coming off on the outside of car. I have reached out to Ford on multiple occasions with no course of action. I have done my research and have let them know since they can not fix the problem, I have contacted a lawyer. Still nothing. When driving my car any speed the windshield vibrates, idling and the windshield vibrates. this is a safety concern for my family. Please help us
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the sound of wind was heard while driving at speeds 40 MPH or higher coming from the sides of the front windshield. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 102,500. VIN tool confirms parts not available.
Exterior A- Left pillar become detached on the interstate and was a hazard to the cars behind, almost caused a crash. Exterior A-Right pillar is loose. I have attempted to get the recall repair completed at a dealership, but have been unsuccessful.
The contact owns a 2018 Ford Explorer. The contact stated that while approaching a stop sign, the vehicle started shuddering while depressing the brake pedal. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000.
The keyless entry panel on driver's side next to driver's window is poorly put on and is starting to come off and could tear off on freeway and cause a safety risk to others. We took the vehicle into a Ford dealership for repairs on some other trim that had a recall and when we received our vehicle back we heard a whistling noise on drivers side and saw the keyless entry panel trim piece was coming off and when we called back to have them fix they stated they didn't damage it during the other trim work they performed and it isn't part of the recall
I first contacted the dealership on July 29, 2024 to set up an appointment and again on Oct. 8, 2024. I took my vehicle to the dealership on 11/22/24 to have the recalls on my vehicle corrected. On pickup I was informed that the pillars had not been fixed became there were no parts available. The following day while driving on the highway something hit the side of my vehicle. When I arrived at my destination I noticed on the passenger side windshield pillar was missing and the passenger doors were scratched. I’m concerned because the drivers side pillar may fall of and hurt someone. In addition I’m concerned about the windshield falling due to the cracking of the sealant. I need to use my vehicle to go to work.
The contact owns a 2018 Ford Explorer. The contact stated that while attempting to shift to revere, the vehicle jerked and hesitated before shifting into reverse. The contact stated that after shifting to drive, the RPM revved; however, the vehicle failed to accelerate as needed. The contact released the accelerator pedal, shifted to neutral and back to drive while slowly depressing the accelerator pedal for the vehicle to operate as needed. The contact stated that afterwards while driving 20 MPH or more, the vehicle sputtered and was making an abnormal grinding sound. While idling, the vehicle started shaking violently. The contact stated that the “WRENCH” and check engine warning lights were illuminated. The vehicle was taken to the dealer who was unable to identify the cause of the failure. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the transmission had failed due to failed spark plugs and filters. The mechanic also stated that there was a significant amount of rust on the engine. The vehicle had not been repaired. The contact became aware of a Customer Satisfaction Program: 10181988 (Power Train) and Technical Service Bulletin 10184634 (Engine and Engine Cooling, Power Train) and linked the TSB and CSP to the failure. The manufacturer was made aware of the failure and confirmed that the VIN was not included in a recall, Customer Satisfaction Program 10181988 (Power Train), and Technical Service Bulletin 10184634 (Engine
The contact owns a 2018 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact noticed that water was leaking in on both sides of the windshield. The contact stated that due to the failure, rainwater was leaking onto instrument panel, causing the instrument panel to become inoperable. The contact stated that the air bag warning light was also illuminated. The vehicle was taken to the dealer and the dealer confirmed the failure. The contact was informed that the vehicle was not included in NHTSA Campaign Number: 24V031000 (Structure). The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 138,000.
My car has 105k miles on it. And the check engine light came on. Code was 3rd cyl. Misfire. Changed spark plug and coil pack. Light cane back on the next day. Then the overheat warning comes on. Shut vehicle off to cool. The coolant is now completely empty. Vehicle will not start. Have towed and the dealership gets it yo start but smoking. Dealership basically doesn't even notice that the fluid is low after we had filled it again. They say there's nothing wrong even though it wouldn't start and then was smoking when it did. Take to another mechanic to discover coolant in the 3rd Cylinder and need a whole new motor. This issue has been common in these ecoboosts! But Ford has still failed to recall or do anything about it. Can cause overheating and fire from what I've read. And also cracked head and or block! $8000 repair on a vehicle just out of the extended warranty for an issue they know they had!
THE FRONT SEAL OF WINDSHIELD SEEMS TO BE LETTING QUITE A BIT OF AIR FLOW THROUGH WINDOW INTO VEHILE WHEN DRIVING 35+ MILES/HR. THERE IS A RECALL ON THE PARTICUALAR PART THAT NEEDS TO BE REPLACED. THE VIHICLE HAS YET TO BE INSPECTED BY PROFESSIONAL.
The clips on my windshield are not holding windshield in properly and the black rubber on outside of windshield is deteriorating and my windshield vibrates while driving.
Reading these
NHTSA publishes every complaint as the owner wrote it and investigates only a fraction. Spelling, capitalisation and judgement are the filer’s own. What carries weight is repetition: the same component failing the same way across many filings, and whether the manufacturer eventually opened a recall for it.
Full record for the 2018 Ford Explorer → · Every Explorer year → · How the figures are calculated →