2018 Ford Explorer complaints

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts to do the recall repair were not yet available. The dealer was contacted and confirmed that parts were not yet available, and there was a waiting list in place for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at 50 MPH, the passenger's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The contact stated that on a separate occasion, the passenger's side A-pillar trim was loose. The local dealer was not contacted. The vehicle was not repaired for the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 75,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V301000 (Structure). The contact stated that while driving 65 MPH in high winds, the passenger’s side exterior A-pillar trim detached from the vehicle. The vehicle was taken to a dealer on two occasions, where it was diagnosed and determined that the exterior A-pillar trim needed to be replaced. The vehicle was not repaired due to the parts not being available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

Intermittent failures of both front turn signals and parking lamps due to wiring failure. The turn signals and parking lights on both sides of the front end of the vehicle sometimes failed to illuminate correctly. Upon investigation, failed wiring was found on the jumpers between the main engine bay harness and the lamp sockets. The wire insulation had become brittle and was flaking away, causing electrical shorts. The same failures were present on both sides. Only that short jumper segment experienced the issue, all other wiring in the engine bay was fine. The faulty wiring jumpers are available for inspection upon request. Safety was put at risk because the turn signals would not reliably signal driver intent. I am an independent mechanic, and discovered the issue while performing other work in May 2025. No one else has investigated the vehicle or component. There were no warnings or symptoms prior to the failure.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The reverse camera does not work, when the car is in reverse.there is no visual on the monitor, which makes it unsafe when the car is in reverse, took the car to the dealer, was told that this car is not in recall

I was driving on a freeway when the engine stopped without warning. The timing chain apparently; slipped and the pistons collided with the alves leaving me stranded on the road. This si a dangerous situation that Ford knows of adn is ignoring. THe car had 101000 miles on it. The car was serviced at 98500 miles by Ford but the timing issue was ignored by the mechanics becasue the computer produced no error codes. The obvious ticking of the engine was the only indication that there was a problem that the mechanics ignored. This is a know premature failure and danger to drivers and the engine should be recalled for repair at Ford's expense. Please issue a safety recall on this engine. ( 3.5L V-Shaped 3.5L Ti-VCT) Consumers are at risk for unexpected breakdowns without warning, at speed, in traffic...

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated while driving 70 MPH, the passenger's side windshield A-pillar trim detached and flew off the vehicle. The vehicle was pulled over to the side of the road and was inspected. The contact observed that the passenger's side A-pillar trim was missing. The vehicle was taken to a dealer, where the contact was advised that there was a related recall associated with the VIN, but the parts were not currently available. The dealer used Gorilla duct tape on both windshield A-pillar trims. The manufacturer was notified of the failure. The failure mileage was 56,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was being serviced at a local car wash, the exterior roof rail rack detached. Upon further inspection, the front driver’s side A-pillar trim fractured, and water was leaking onto the interior, causing damage to the rear mirror power module. The contact stated that the front driver’s side mirror failed to adjust as intended when the control module was in use. The local dealer was contacted; however, parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

It has been 1.5 years since this recall and Ford has not remedied the problem in a timely manner.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not available. The vehicle was taken to the dealer; however, the vehicle was inspected, and the contact was informed that the parts were not yet available for the repair. The manufacturer was not contacted. The contact had not experienced a failure.

In November 2023, our SUV started to over heat and engine shut off. We noticed the coolant reservoir was bone dry. We added coolant. It was bone dry again within a couple days. We had a mechanic friend diagnose and he told us it is the water pump. We took it to the Ford dealership and we were quoted $3000 to repair it. We could not afford this, so thankfully we met a mechanic that works at dealerships but also repairs on the side. He fixed it for $1000. Flash forward to November 2025 and we notice the heat in our car is not working. Couple weeks later, overheat warning and I'm forced to pull over with my 3 children in the car on a busy highway. Once car cooled down, we went straight home and forfeited our plans. Notice the reservoir is empty again. Refill it. It's empty within a few days. Come to find out, it's the water pump again and Ford dealership wants $4400 this time to fix it and our friend who fixed it last time wants $2000 to fix it. He had another Ford Explorer currently in his shop with the same problem. He said it will continue to fail. We are at a loss. Car overheats almost immediately and loses coolant almost immediately. Ford should HAVE A RECALL ON THE WATER PUMP. Why does the engine have to be pulled out to replace the water pump that is just going to fail every 2 years. I have bought Ford since 2008 and swore I always would buy Ford. I have had 3 Ford vehicles. This experience with this vehicle and the Ford dealerships has changed my opinion. I will never bu

Purchased 5 years ago aprox 100k miles.kept oil changed regularly. Of course parts kept coming off, monk safety clips etc. It's a dime store matcbox wannabe. Then the abs and engine light came on. The computer was acting up and it would do crazy things. Lock and unlock, go into that slow drive as i was pulling into a road. Etc. These would self correct, all but the abs in a matter of minutes. Oh i did have it checked. All that came up was right wheel speed sensor. I paid to have it fixed. Ford dealer told me his news, new sensor bad news still says it's bad. I was moving to another state. Stranger things kept happening. None could find out what was wrong. It started back firing so new plugs and coils. The shop told me after that it still had issues and while no code it was the transmission. It started to violently shake going 70mph. Scared me to death. I sold it and now car shopping. Never Ford again! I have always trusted them but they have compromised on quality, safety and customer loyalty.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that after arriving home and exiting the vehicle, the contact became aware that the A-pillar trim on the driver's side had detached. The dealer was contacted, and it was confirmed that the part to repair the vehicle was not available. Another dealer was contacted, AutoNation Ford Valencia (23920 Creekside Rd, Valencia, CA 91355), and confirmed that the part was not available. The manufacturer was not made aware of the failure. The failure mileage was 84,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving approximately 70 MPH, there was a loud sound coming from the roof or the side of the vehicle. The vehicle was taken to the residence, and the contact became aware that the passenger’s side A-pillar trim had detached from the windshield. The dealer was contacted and informed the contact that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.

I do not no at this time

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at undisclosed speeds on several occasions, there was a whooshing air sound coming from the windshield. The contact stated that the trim around the windshield had dry rotted and detached. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure milage was approximately 30,000.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, there were abnormal sounds coming from the roof. The contact stated that while looking in the rear-view mirror, the contact noticed that the plastic molding around the roof rack had detached from the vehicle and flew off into traffic. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure milage was approximately 55,000.

I believe the APIM has malfunctioned. I have a black screen. No backup camera, no controls for the functions on the screen, no radio and no hands free telephone. The safety of being able to see what is behind me while backing up is gone. The screen started malfunctioning about 8 months ago. It would work sporadically, now it doesn't work at all. I did the soft reset and the hard reset, plus Ford walked me through the update but it never worked.

Both driver and passenger low beam headlights started strobe, than completely stopped working while driving at night. This was extremely stressful and dangerous as I was no longer able to see the roads very well, my options were get a tow truck to pick up and bring my vehicle from Michigan back to Minnesota or sit on the side of the road until the morning also a safety risk. Upon inspection the following day, it was only the low beam that was not working and all other LED's were working. This is when I tried to replace both headlight modules, that did not fix the issue. I then bought new headlights thinking the low beam LED stopped working after going through 3 sets of headlights the issue was never resolved.

These parts are still unavailable. This should be a class action lawsuit.

Had a recall at 60K miles for transmission, every since then the transmission has been breaking down at every 20k miles, I am going through my 3rd transmission now and Ford can't make their transmission right. The diagnoses is internal failure every time.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that upon further inspection, it was noticed that the front passenger side A-pillar trim sealant was deteriorating. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

The contact owns a 2018 Ford Explorer. The contact stated that due to sunlight exposure, the outer layer of the dashboard peeled off and continued to expand near the location of the air bags. The contact was concerned that the defect might cause an air bag deployment malfunction in the event of a crash. The vehicle was taken to the local dealer, and the contact was informed that the entire dashboard needed to be replaced. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 45,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the A-pillar trim detached, and the front windshield made an abnormal sound. The dealer was made aware of the failure but confirmed that parts were not yet available. The contact was informed that tape could be used as a temporary repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000.

Fault code B14E7:08-0A Right Front Enhanced Exterior Lighting System, passenger headlamp will not turn off until BCM disconnects after 20 minutes. Dealer diagnosis determined a possible headlamp control module FB5Z13C788D fault (replaced left module with right module and same headlamp stayed on so both headlamp control modules are correctly functioning) this indicates a broken wire in right front enhanced exterior lighting system wiring harness. Problem remains unresolved.

None of the parts listed above are the problem. But we can hear a weird noise coming from the sides of the windshield and can definitely tell that it's getting worse as the noise has increased significantly as time goes by. I just called a glass company and they told me that the parts needed to get this fixed are pretty expensive. That's why I am reaching out since it looks like there is a recall specifically for this issue. Can Ford take care of this issue?

Another timing chain failure on highway with engine stopping on road. This should be a recall!!!!! Only 101,300 miles on engine. No warnings no check engine lights until after failure.

Backup Camera does not work. This has been going on for two years. We have been to the dealer about this situation. There were intermittent messages saying that the camera didn't work, then it completely stopped. This started in 2023. We went to the dealer to find out about what it would cost to have it fixed and found out that all the years around the 2018 had been recalled for this problem. We wanted you to know that the 2018 has the same problem as these other vehicles with the backup camera.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure). However, the part to do the recall repair was not yet available. The contact stated that while driving at 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted; however, the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 99,700.

On Saturday 10/18/2025 the rear drivers side tow link of my 2018 Ford Explorer XLT snapped while driving 70 mph under normal driving conditions on a 4-lane section of i-75 in Detroit, MI. This caused a loss of steering, and my family and almost hit the median concrete wall when it sharply veered to the left completely unexpectedly. There were no warning sounds or symptoms and happened at random on a straight away. We then spun out doing multiple 360 spins on 2 wheels, almost flipping completely, and landing in the middle 2 lanes. We had a semi truck and another vehicle narrowly miss us. I was able to then move fast enough to the side of the road and avoid being hit by more oncoming traffic. We called 911 and AAA for towing to Suburban Ford of Troy who did an inspection and found the drivers side rear tow link has snapped due to a seized knuckle. There is a recall for the exact same known issue in the 2011-2017 Ford Explorers. My wife’s 2017 explorer has the same parts as my 2018 and has the recall for the tow links and ball joint due to this known issue, yet Ford is refusing to acknowledge the issue is still affecting later model years. My Explorer only had 74,000 miles on it and never any accidents or abnormal driving conditions/hard driving. My family and I are extremely lucky to be alive after such a catastrophic failure. This type of issue should never happen on any vehicle and is a totally unacceptable engineering failure. Ford needs to inspect this issue on the later mo

Nothing has happened yet, but I want to make dure nothing does happen as a result of not taking care of this potential problem.

The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 50 MPH, the front driver’s side A-pillar trim was suddenly ejected from the vehicle. The local dealer was notified of the failure. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V031000(STRUCTURE), which was related to the failure, but parts needed to repair the vehicle were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that later the front passenger’s side A-pillar trim experienced the same failure. The manufacturer was not made aware of the failure. The failure mileage was unknown

The plastic covers on the roof rails are both loose and constantly pop out. I'm nervous that they are going to fly off when driving, causing an issue for other drivers.

Traveling 50mph, noticed smoke rolling from under the dash. Got to the side of the road. The entire dash was engulfed in fire. I had to fight my way out of the car after the doors locked. After I got out of the vehicle I called 911. Fire department came. It has been ruled as electrical. I am not sure whom I need to reach out to yet in regards to this matter and a total loss.

The dash on my 2018 Ford Explorer platinum is rolling up from the front of the dash. It is made out of some sort of leather or vinyl. But with it rolling up towards the driver, it causes a glare onto the windshield which causes visibility issues. I know I'm not the only one experiencing these problems with the platinum trim on the 2018 ford explorer. But this really needs to be looked into and recalled. You can also look up the explorer platinum on a vehicle search website and visibly see that every platinum edition explorer has this issue. It's unsafe and should be addressed immediately.

1 year ago, the exterior pillar trim detached on the 202 Highway in Mesa, Arizona while I was drivign 65 MPH. It cracked another windshield. I received the recall and went in to Robert Horne Ford Dealership. They informed me those pieces are on recall. I told them to notify me when they became available. It has been 1 1/2 years and still nothing. This week, the other side pillar trim came off, again while I was on the highway. This is dangerous. Now I feel like my windshield is not secure, as it is shaking while I am driving. The recall was announced in January of 2024. It is October of 2025. How can a company ignor the recall and simply not address explicit safety violations? NHTSA # 24V031

The paint is bubbling and peeling on front hood and looks like trash. I have 50,000 miles on my car it isn’t used that frequently

See attached document for complaint. I am writing to express my concern with the February 2024 recall from Ford (Safety Recall Notice 24S02/NHTSA Recall 24V031. This has been a known safety issue from Ford since February 2024. The recall letter (attached) advised that parts were expected later half of 2024. To date, no parts or further communication has been sent from Ford. I was driving my daughter and a friend home. While traveling on 196, the passenger side A-pillar applique trim clip attachment became detached from vehicle, hitting my windshield and then flying backwards on the expressway toward other vehicles. On this particular Sunday, 196 was rather busy. I was able to safely check my rear-view mirrors to ensure that other vehicles traveling behind me were not impacted by the detached trim. I am grateful that this incident occurred without any harm to any individual. I have no idea if the trim caused any damage to the vehicles traveling behind me. I am finding it unacceptable that Ford has sent out zero communication on this safety recall. My husband took my 2018 Ford Explorer to Tony Betten Ford & Sons to inquire about the missing trim and how we go about it getting repaired. He was simply told that Ford has not communicated any ETA for delivery of such parts and as far as they know, Ford is not making enough to meet the recall demand. It is now approximately 18 months since the initial recall notice and Ford has yet to send out any repaired parts. This is unacceptabl

See attached document for complaint.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

My rear view camera goes to a dark blue or gray s screen with the words “check surroundings for safety” & “Camera is unavailable” and it does not work. This is the same recall issue that is on 1,900+ plus vehicles from a recall. I have called and filled a complain with Ford and have visited 3 dealers in our area and that is what they tell me. I have photos and I need this repair done ASAP because I travel with an [XXX] I’ve called Ford four different times since July and I keep getting the run around and visit different t dealers that tell me that it is the same problem as the recall but the explorers are not yet part of the recall. I NEED YOUR HELP PLEASE THANK YOU [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact had received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE). The contact stated that a dealer was contacted; however, the contact was informed that parts were unavailable. The vehicle was not repaired. The manufacturer was contacted regarding parts availability. The contact had not experienced a failure.

Rear view camera not functioning since March 2025

This recall has been 1.5 years and still does t have a remedy by Ford? Part was checked by Ford dealership, they advised yep it qualifies but we don't have parts then left. That was 1 year ago.

My 2018 Ford Explorer Limited has been having issues with the back up camera for longer than 18 months. My local Ford in Margate Florida is aware of the problem. My camera goes blank when I’m backing up it stops working my mirrors on the driver side will not fold out my passenger side door if I touch it when it’s locked will alarm I believe all of this is related to an electrical problem in the camera. This is dangerous and I’m very frustrated. I want my car looked at free of charge by Ford because something‘s going on with the camera and it’s extremely dangerous while I’m backing up to have the camera stop and then for me to reset it I can’t do it while backing up. I have a neck injury that prevents me from looking over my shoulder currently Can somebody please call me my name is [XXX] my phone number is [XXX] or you may email me at [XXX] thank you very much. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact had been calling the local dealer to schedule an appointment for over 9-months and the contact was informed that parts were not yet available. The contact had not experienced a failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the lack of parts.

Ford sent me a recall notice for my 2018 Explorer A-Pillar replacement February 2024. I made an appointment and they attempted to install the new A-Pillars. However they broke the new replacement part (drivers side) during the install. They gave me my Explorer back without an A-Pillar and said they would expedite getting an new one. It's now been over a year, the dealership is not responsive, only saying it's a manufacture problem. I called Ford and get the same message. Meanwhile I have a very unsightly SUV, it is also very noisy to drive. Additionally, I would like to replace this vehicle, but its now worth much less. Is their anything that the NHTSB can do to hold Ford accountable for this repair? Thank you in advance, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)