2017 Ford Explorer complaints

THERE'S EXHAUST FUME IN THE CABIN MY WIFE HAS SUFFERED SEVERE HEADACHE AFTER 60 MINS OF DRIVING INCLUDED MY 20MONTHS OLD BABY. MY CAR HAS ALREADY BEEN REPAIRED ONCE AND IS IN THE SHOP AGAIN BECAUSE I LEFT A CO2 SENORS IN BACK SEAT AND HAS GONE OFF MULTIPLE TIMES. FORD IS NOT BEING VERY HELPFUL BECAUSE I DON'T WANT THE CAR ANYMORE. IT IS A HUGE SAFETY CONCERN AND I DON'T WANT MY WIFE AND TODDLER IN THE VEHICLE AT ALL.

FAILED TO ACCELERATE FROM STOP.

MY WIFE WAS INVOLVED IN AN ACCIDENT ON ICY ROADS ON DECEMBER 5. SHE WAS DRIVING OUR 2017 FORD EXPLORER WHICH WE HAD PURCHASED ON MAY 31, 2017. SHE WAS STOPPED AT A RED LIGHT ON A COUNTRY HIGHWAY AND HEADED NORTH. THE LIGHT TURNED GREEN AND SHE HAD JUST GOTTEN THROUGH THE INTERSECTION WHEN A VEHICLE THAT WAS HEADING SOUTH, LOST CONTROL AND HIT HER HEAD-ON. THE ATTACHED PICTURE SHOWS THE AMOUNT OF DAMAGE SUSTAINED ON THE FRONT END OF THE VEHICLE. BEYOND THIS DAMAGE, THE IMPACT WAS STRONG ENOUGH THAT A MOTOR MOUNT MOUNTING PIN WAS SHEARED CLEAN OFF THE MOTOR AS WAS THE COVER ON THE TIMING BELT. THE REBAR IN FRONT OF THE RADIATOR WAS SNAPPED COMPLETELY IN HALF. ALL THIS DAMAGE...AND THE AND AIRBAGS DID NOT DEPLOY. THERE WAS SUFFICIENT DAMAGE THAT THIS $50,000+ VEHICLE WAS CONSIDERED A TOTAL LOSS. I'VE CONTACTED THE FORD DEALERSHIP IN SIOUX FALLS, SD WHERE WE BOUGHT THE VEHICLE. AS SOON AS I MENTIONED AIRBAGS, THEY SAID THEY WOULD NOT ADDRESS OR COMMENT ON ANY ADDITIONAL QUESTIONS I RAISED ABOUT THE VEHICLE SAFETY FEATURES. I'VE CONTACTED FORD MOTOR COMPANY DIRECT. SAME STORY. AS SOON AS THE SUBJECT OF AIRBAGS WAS LOCKED FIRMLY IN THE MIND OF THE LADY I WAS TALKING WITH, SHE PROCEEDED WITH ABOUT TEN MINUTES OF QUESTIONS. AFTER SPENDING PROBABLY 20 MINUTES ON THE PHONE WITH THIS LADY, ALL I GOT WAS, "YOU NOW HAVE A CASE NUMBER IN OUR SYSTEM." WHEN I ASKED ABOUT GETTING ANY FOLLOWUP CORRESPONDENCE, I WAS TOLD, "ALL FUTURE CORRESPONDENCE WILL BE BETWEEN THE INSURANCE COMPANY AND FORD

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHEN THE CONTACT'S DAUGHTER GOT INTO THE FRONT PASSENGER SIDE OF THE VEHICLE AND CLOSED THE DOOR, THE FRONT PASSENGER SIDE WINDOW SHATTERED. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE OR AFTER THE FAILURE. THE VEHICLE WAS TAKEN TO LITHIA FORD LINCOLN OF FRESNO (195 E AUTO CENTER DR, FRESNO, CA) WHERE THE VEHICLE WAS DIAGNOSED. THE DIAGNOSIS WAS UNDETERMINED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 7,500.

WHEN APPLYING JUST THE SLIGHTEST BIT OF PRESSURE TO THE BRAKE PEDAL AT THE SAME MOMENT THE BRAKE LIGHTS COME ON A CLANKING OR CLICKING NOISE HAPPENS. THE NOISE SOUNDS LIKE IT IS COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE NOISE IS ALSO RANDOM AND DESPITE EFFORTS TO INTENTIALLY DUPLICATE NOISE, IT APPEARS TO HAPPEN RANDOMLY. BROUGHT THE VEHICLE TO FORD DELEARSHIP 5 PLUS TIMES AND THEY HAVE FIXED EVERYTHING FROM THE SUSPENSION TO NUTS AND BOLTS BUT HAVE YET TO RESOLVE THE PROBLEM. THE NOISE OCCURS WHEN THE VEHICLE IS IN MOTION AND AT THE EXACT MOMENT ANY PRESSURE IS APPLIED TO THE BRAKE PEDAL.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT IT TOOK TOO LONG TO UNLATCH THE SEAT BELTS. THE VEHICLE WAS TAKEN TO REDLANDS FORD INC (1121 COLTON AVE, REDLANDS, CA, 92374) WHERE IT WAS STATED THAT THE MANUFACTURER WOULD BE MADE AWARE OF THE FAILURE. THE CONTACT DID NOT RECEIVE A RESPONSE FROM THE MANUFACTURER NOR THE DEALER. THE CONTACT MADE THE MANUFACTURER AWARE OF THE FAILURE AND WAS ADVISED TO TAKE THE VEHICLE TO FAIRVIEW FORD (292N G STREET, SAN BERNARDINO, CA 92410) WHERE THE TECHNICIAN STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 400.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THERE WAS A STRONG ODOR COMING FROM INSIDE THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE FAILURE CAUSED THE CONTACT TO SUSTAIN A HEADACHE, DIZZINESS, EYES WATERED, LIPS DRIED AND HAD CHEST PAIN THAT REQUIRED NO MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO THE LASCO FORD DEALER LOCATED AT 2525 OWEN RD, FENTON, MI 48430 WHERE IT WAS DIAGNOSED THAT THE INSULATE 05 AND THE VALVE A009 NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,000.

EXHAUST FUMED SMELL IN CAR... SPECIFICALLY WHEN AC IS RUNNING AND BACKING UP

FORD RECALL. I STARTED FEELING FATIGUED, NAUSEOUS AND GETTING HEADACHES OVER THE PAST WEEK AFTER DRIVING TO AND FROM WORK. I DROVE HOME FROM WORK ON 12/6/2017 AT NIGHT AND WAS STRUGGLING TO KEEP MY EYES OPEN AND GOT SICK. MY WIFE SAID SHE SMELLED A CHEMICAL TYPE SMELL IN THE CAR. WE DID SOME RESEARCH AND FOUND THAT FORD ACKNOWLEDGED SOME EXPLORERS HAVE AN ISSUE WHERE THE EXHAUST FUMES GET BACK INTO THE CAR. I TOOK THE CAR TO THE DEALER TODAY AND THEY SAID IT WAS CONFIRMED TO HAVE THE PROBLEM AND THEY FIXED IT.

2017 FORD EXPLORER ECOBOOST WITH APPROXIMATELY 8800 MILES STARTED MAKING A WHINNING NOISE FROM THE TRANSMISSION. NOTICED MAKING RIGHT TURNS THE TRANSMISSION FELT LIKE IT WOULD DISENGAGE AND ABRUPTLY ENGAGE AS IF THROWN IN NEUTRAL THEN SLAMMED INTO DIRIVE. TAKING OFF FROM LIGHT WOULD DO SIMILAR ISSUE. IN A COUPLE OF EVENTS, VEHICLE WOULD NOT MOVE AND WAS IN TURNING LANE WITH TRAFFIC APPROACHING ALMOST CAUSING TO GET T BONED. EXPLORER HAS BEEN AT THE DEALER AND TRANSMISSION HAS BEEN SERVICED TWICE WITH THE TRANSMISSION SKIPPING GEARS OR SHIFTING NORMAL UNTIL A STOP AND ENGAGES 5TH GEAR, STAYS STUCK IN 5TH GEAR.

HAVE THE CARBON MONOXIDE SMELL INSIDE MY SUV. I TOOK IT TO THE DEALERSHIP IN OCT. AND WAS TOLD PARTS WERE BACKORDERED TO DEC. FORD RUSHED IN PARTS AND REPLACED A LIST OF THINGS. THAT FIX FAILED AND STILL HAVE THE SAME ISSUE WITH NO ETA ON WHEN IT WILL BE LOOKED AT AGAIN. FORD REFUSES TO TAKE THE SUV IN AGAIN AND FORD REFUSES TO TALK ABOUT THIS ISSUE. I DO TRAVEL FOR PERSONAL USE AND HAVE HAD THE STRONG ODER INSIDE AND HAVE HAD BAD HEADACHES AND DROWSINESS. I GET THE ODER DRIVING, TAKING OFF FROM STOPS OR GETTING ON THE FREEWAY/INTERSTATE.

EXHAUST LEAKING INTO CABIN OF VEHICLE: WHILE DRIVING I NOTICED AFTER A PERIOD OF 1 HOUR I GET DIZZY, HEADACHES, AND FEEL NAUSEATED. WHEN AFTER ARRIVING AT MY DESTINATION I FELT VERY LETHARGIC TAKING MANY HOURS BEFORE I FELT RELIEF. MY WIFE NOTICED IT DRIVING ON A TWO HOUR TRIP WHERE HER VISION BECAME DOUBLED. AFTER BEING OUT OF THE VEHICLE SHE FOR A PERIOD OF TIME SHE FELT BETTER. I SPOKE WITH MY DEALER ABOUT THE ISSUE WHEN DOING ROUTINE MAINTENANCE AND FORD TOLD ME THAT THEIR IS NO RECALL AT THE MOMENT FOR THIS COMPLAINT.

WE HAVE NEW AIRBAG TYPE REAR SEATBELTS, AND IT IS ABSOLUTELY ALMOST IMPOSSIBLE TO BUCKLE THE PASSENGERS IN AS LONG AS WE HAVE A CHILD SEAT IN THE MIDDLE, WE ALWAYS HAVE A CHILD SEAT IN THE MIDDLE, LEFT PASSENGER CANNOT BUCKLE THEMSELVES IN,. I'VE BEEN TO 2 DEALERS AND CALLED FORD TWICE AND NO ONE WILL PURSUE FIXING THE PROBLEM, THIS IS A VERY STRESS FULL KNOWING ITS A 2017 AND WE CANNOT USE THIS AS A FAMILY CAR

EXTREMELY SHARP METAL TABS STICK OUT NEARLY 1" FROM THE INBOARD SIDE OF BOTH DRIVER AND PASSENGER SEATS. TABS ARE INTENDED TO HOLD PLASTIC TABS ON SEAT COVERS HOWEVER BOTH OF MINE WERE NOT INSTALLED PROPERLY OR HAD COME OFF IN THE 6 MONTHS WE'D OWNED THE VEHICLE. THIS TAB CUT MY HAND WIDE OPEN AND CUT TENDONS WHILE REACHING FOR MY KEYS THAT HAD DROPPED. SURGERY WAS REQUIRED. A FRIEND WHO OWNS A 2016 EXPLORER CONFIRMED THESE SHARP TABS AS WELL. THIS SHARP METAL TAB IS LIKE A KNIFE AND I WOULD LIKE TO SEE THIS PROBLEM CORRECTED FLEETWIDE (FILING DOWN THE EDGES WOULD BE A VERY SIMPLE FIX) TO ENSURE OTHERS AREN'T MAIMED LIKE I WAS. IT'S NOT UNREASONABLE TO SEE HOW SOMEONE COULD CUT A WRIST WITH A RISK TO LIFE.

IT HAS BEEN JUST OVER 1 YEAR DRIVING THIS VEHICLE, 8115 MILES CURRENTLY. A FEW DAYS AGO WHILE WALKING AROUND MY CAR, I NOTICED CHIPPING, CRACKING, & PEELING AWAY OF THE TREAD ON MY TIRES. IT DOES NOT LOOK NORMAL AND NOT TOO SURE IF IT IS SAFE TO CONTINUE TO DRIVE. I TOOK IT TO THE LOCAL FORD DEALER WHERE WE LEASED IT FROM AND THEY CLAIMED THAT IT IS NORMAL TIRE WEAR FOR HAWAII ROADS. I DONT THINK SO. I HAVE OWNED SEVERAL VEHICLES OVER THE PAST FEW YEARS AND HAVE NEVER SEEN THIS BEFORE. THE VEHICLE HAS NEVER BEEN OFF-ROAD, PULLED A HEAVY LOAD, OR DRIVEN AGGRESSIVELY, AND IS IN IMMACULATE CONDITION OTHERWISE. THE VEHICLE WAS JUST IN FOR SERVICE JUST OVER 1 MONTH AGO SO I AM NOT SURE HOW THIS WAS NOT CAUGHT IN THE MULTI-POINT INSPECTION OR THE TIRE ROTATION THEY SUPPOSEDLY DID.

THERE'S EXHAUST FUME IN THE CABIN AFTER HARD ACCELERATION(RPM WAS AROUND 5000). AND MY FAMILY SUFFERED A SEVERE HEADACHE AFTER 90 MINUTES DRIVING INCLUDED MY 12 MONTHS OLD BABY. MY CAR HAS ALREADY BEEN REPAIRED TWICE IN FORD, BUT IT HAS NOT BEEN RESOLVED.

OUR 2017 FORD EXPLORER WAS INVOLVED IN A BAD ACCIDENT. WE WERE STRUCK ON THE DRIVER SIDE WHILE MAKING A LEFT TURN. THE STRIKE OCCURRED AT THE LEFT FRONT WHEEL BACK TO THE DRIVERS DOOR. TRAVELING RATE OF SPEED OF THE STRIKING VEHICLE WAS APPROX. 50MPH. THE INSURANCE ADJUSTER ADVISED THE CAR IS A TOTAL LOSS. MY CONCERN IS WHILE WE WALKED AWAY WITH MINIMAL INJURY, NOT ONE AIRBAG IN THE CAR WENT OFF. THE ADJUSTER ADVISED THAT AT THE VERY LEAST THE SIDE IMPACT BAGS SHOULD HAVE GONE OFF. WANTING TO GET ANOTHER EXPLORER BUT AM CONCERNED THAT THE SAFETY SYSTEM DOES NOT FUNCTION AS IT IS DESIGNED TO.

I BOUGHT A 2017 FORD EXPLORER FOR MY DAUGHTER TO DRIVE BACK AND FORTH TO COLLEGE. SHE HAS BEEN EXPERIENCING DIZZINESS, HEADACHES AND NEARLY PASSED OUT AFTER DRIVING THE VEHICLE. WHEN I GET IN THE VEHICLE AND START IT UP, IT SMELLS LIKE EXHAUST INSIDE THE VEHICLE. THERE IS OBVIOUSLY A PROBLEM.

HANKOOK VENTUS S1 NOBEL 2 SIZE 255/50R20 105H DOT 5MNC 1A H 1916 THESE TIRES HAVE 16,940 MILES (13 MONTHS SINCE BOUGHT IT) ON THEM AND CAME OEM ON 2017 FORD EXPLORER. THE TIRE TREAD IS PEELING AND SHREDDING. PREMATURE WEAR. I TOOK IT TO FORD AND THEY SAID THAT A SERVICE MESSAGE (SSM 46905) RELATIVE TO 2015-2018 EXPLORER- HANKOOK TIRES- CHIPPING, CUTTING AND/OR UNUSUAL/ACCELERATED TREAD WEAR. THE MESSAGE STATES " SOME 2015-2018 EXPLORER VEHICLES EQUIPPED WITH HANKOOK BRAND TIRES MAY EXHIBIT CHIPPING,CUTTING AND/OR UNUSUAL OR EVEN ACCELERATED TREAD WEAR.IF THE SIZE WALL IS MARKED AS:255/50R20 105H VENTUS S1 NOBLE 2CONTACT HANKOOK TECHNICAL SERVICES". THE DEALER DID AND HANKOOK KNOWS ABOUT THE ISSUE BUT ONLY OFFERED A 50% DISCOUNT ON NEW TIRES AS A CORRECTIVE MEASURE. SO BASICALLY THEY SOLD BAD TIRES AN THE CUSTOMER HAS TO PAY TO FIX THE PROBLEM.

ON 10/31/17 WHILE OUT WITH MY CHILDREN TRICK-OR-TREATING, THE LIFTGATE ON MY LEASED 2017 FORD EXPLORER BECAME "STUCK" IN AN UPRIGHT POSITION AND WOULD NOT CLOSE ELECTRONICALLY OR MANUALLY. MY FAMILY AND I HAD PULLED OVER AND PARKED IN A RESIDENTIAL AREA TO GET ITEMS OUT FROM THE REAR STORAGE AREA. I HAD OPENED THE HATCH WITH THE ELECTRONIC SWITCH AND THE DOOR STOPPED ABOUT 2/3 OF THE WAY UP. AS THIS HAD HAPPENED TO ME PREVIOUSLY, I FOLLOWED THE MANUAL DIRECTIONS TO SET THE LIFTGATE OPEN HEIGHT. WE FINISHED GETTING OUR ITEMS OUT OF THE VEHICLE AND PRESSED THE CONTROL BUTTON TO CLOSE. IT WAS AT THIS POINT THAT THE LIFTGATE--NOW AT MAXIMUM HEIGHT--SIMPLY MADE "WHIRRING" SOUNDS AND WOULD NOT CLOSE. DESPITE REFERENCING THE OWNER'S MANUAL, CALLING FORD ROADSIDE ASSISTANCE AND SCOURING THE INTERNET FOR POTENTIAL SOLUTIONS, ALL ATTEMPTS TO BYPASS THE ELECTRONIC SYSTEM/MOTOR AND MANUALLY CLOSE THE DOOR WERE UNSUCCESSFUL. I WAS FORCED TO DRIVE MY FAMILY HOME WITH THE REAR LIFTGATE PRECARIOUSLY LEFT WIDE OPEN. THE NEXT DAY I WAS ADVISED BY MY LEASING COMPANY TO HAVE A TOW TRUCK PICK THE VEHICLE FOR SAFETY REASONS. THE TOW DRIVER WAS SHOCKED AT THIS ODD MALFUNCTION AND EXPRESSED CONCERN TRANSPORTING THE VEHICLE AS ROAD BUMPS COULD POTENTIALLY CAUSE EXCESSIVE BOUNCING AND PERMANENT DAMAGE. WE DETACHED THE LIFT ARMS HOLDING UP THE REAR GATE SO AS TO CLOSE THE DOOR--ONLY TO FIND THAT THE REAR HATCH STILL WOULD NOT FULLY CLOSE. THE REPORT FROM THE FORD DEALERSHIP HERE IN PHOENIX WAS SIMPLY T

I WAS STOPPED AT A TRAFFIC LIGHT ON THE HIGHWAY TO MAKE A LEFT. ONCE LIGHT CHANGED, I STEPPED ON THE GAS AND THE CAR WOULDN'T MOVE. I THEN HEARD A LOUD "THUMP" AND THOUGHT I'D BEEN HIT FROM THE REAR. WHAT ACTUALLY HAPPENED WAS THE TRANSMISSION, SLAMMED INTO GEAR AND PROCEEDED TO MOVE AT ABOUT 2-3 MPH. IT NEVER REGAINED SPEED. AS I MADE MY TURN, I WAS STUCK ON ANOTHER MAJOR ROAD AT A TRAFFIC LIGHT AND I PLACED IN NEUTRAL AND HEARD THE LOUD "THUMP" AGAIN AS THE TRANS SHIFTED INTO NEUTRAL. ONCE THE TRAFFIC LIGHT CHANGED, I PUT THE VEHICLE BACK INTO "DRIVE" AND YET AGAIN, A LOUD "THUMP" AS IT SLAMMED INTO DRIVE. VEHICLE AGAIN PROCEEDED TO MOVE AT A SNAILS PACE, AT ABOUT 2-3 MPH. FINALLY ON THE DASH I GOT A "WRENCH" LIGHT AND THE ENGINE LIGHT COME ON AS WELL. I PULLED OVER ON A SIDE STREET AND TURNED THE VEHICLE OFF. I WAITED A FEW MINUTES, TURNED THE VEHICLE BACK ON AND WHEN I SHIFTED INTO REVERSE, NEUTRAL AND THEN DRIVE, THE TRANSMISSION SLAMMED INTO GEAR ON EACH OF THEM VERY HARD. I PROCEEDED TO TURN THE VEHICLE OFF AND CALL A TOW SERVICE TO HAVE THE VEHICLE DROPPED OFF AT THE DEALERSHIP. MIGHT I ADD THAT THIS IS A 2017 FORD EXPLORER WITH ONLY 1045 MILES....THIS IS A NEW VEHICLE!!!!!

CARBON MONOXIDE EMISSIONS IN AIR CONDITIONING SYSTEM

ORIGINALLY FILED COMPLAINT 10883479 AND 10954630 ON A 2015 FORD EXPLORER LIMITED FOR EXHAUST ODOR IN THE CABIN. AFTER SEVERAL TSB REPAIRS THE EXHAUST ODOR WAS STILL IN THE CABIN. ON JUNE 20, 2017, I PAID $4670.29 AND FORD REPLACED MY 2015 WITH A SIMILAR 2017 FORD EXPLORER LIMITED. ABOUT 12 MILES AFTER DRIVING MY NEW 2017 DOWN THE FREEWAY FROM THE DEALERSHIP, THERE WAS EXHAUST ODOR IN THE CABIN ON MY NEW EXPLORER. SO I FILED ANOTHER COMPLAINT 11010052, SEE DETAILS OF FAILURE MODE. THEREAFTER FORD DID PHASE 1 OF TSB 17-0044 ON ORDER 57558, AND AFTER FURTHER EXHAUST ODORS IN THE CABIN, FORD DID THE SECOND PHASE OF THE TSB ON ORDER 57730. I STILL HAVE EXHAUST ODOR IN THE CABIN, THE ODOR IS NOT AS STRONG AND DOES NOT LAST AS LONG, BUT IT IS STILL THERE. FORD ADVISED THAT THERE IS ANOTHER REPAIR 17N03, BUT THIS APPEARS TO ALREADY TO HAVE BEEN DONE ON THE TSB 17-0044. THE DEALER, SCOTT PETERSON MOTORS OF STURGIS IN SD, HAS DONE ALL THAT THEY CAN DO SO FAR I APPRECIATE THEIR EFFORTS IN GOING THE EXTRA MILE. CONSEQUENTLY, I AM FILING ANOTHER COMPLAINT IN AN EFFORT TO ASSIST FORD IN RESOLVING THIS PROBLEM.

THERE'S SOME BURNING ODOR IN THE CABIN. MY FAMILY SUFFERED A SEVERE HEADACHE AFTER 2 HOURS DRIVING INCLUDED MY 11 MONTHS OLD BABY.

DRIVING ON INTERSTATE AND SMELLED A STRONG ODOR AND FUMES. NO CARS OR TRUCKS WERE IN FRONT OF ME AND I COULD NOT FIGURE OUT WHERE THE ODOR WAS COMING FROM. LATER IN THE 3 HOUR DRIVE, GOT VERY SLEEPY AND DIZZY. STOPPED AT REST AREA FOR FRESH AIR. THIS HAS NEVER HAPPENED TO ME BEFORE. NOW AFRAID TO DRIVE THIS EXPENSIVE VEHICLE ON THESE TRIPS TO TAKE CARE OF GRANDCHILDREN. CALLED DEALERSHIP AND WAS TOLD NO RECALLS AND NOTHING THEY COULD DO. PURCHASED THIS VEHICLE FOR DRIVING LONG DISTANCES AND NOW AFRAID TO DRIVE IT AND MY SON WILL NOT LET OUR GRANDCHILDREN RIDE IN IT. CANNOT SALE IT BECAUSE I WOULD LOOSE SO MUCH MONEY. A RECALL SHOULD BE ISSUED SINCE NUMEROUS COMPLAINTS HAVE BEEN MADE FROM OTHERS WITH THE SAME ISSUES.

THE SUBJECT VEHICLE HAS APPROXIMATELY 12,200 MILES ON OEM SUPPLIED HANKOOK VENTUS S1 NOBLE 2 TIRES. SIZE 255/50R20. TREAD IS PEELING OFF AND PREMATURE WEAR. 50K MILE RATED TIRE IS AT 5/32 @ APPROX. 12200 MILES WITH SCHEDULED ROTATION PERFORMED. FORD DEALER AND HANKOOK REP HAVE ACKNOWLEDGED HANKOOK IS HAVING A PROBLEM WITH THESE TIRES ON THIS VEHICLE. PLEASE INVESTIGATE THE SAFETY OF THESE TIRES. SEE ATTACHED PHOTO OF PEELED TREAD.

HANKOOK VENTUS S1 NOBEL 2 SIZE 255/50R20 DOT 5MNC 1A H 1216 THESE TIRES HAVE 12,200 MILES ON THEM AND CAME OEM ON 2017 FORD EXPLORER. THE TIRE TREAD IS PEELING AND SHREDDING. PREMATURE WEAR. PLEASE INVESTIGATE AS OTHERS ARE REPORTING THE SAME EXACT PROBLEM ON THE SAME VEHICLE.

DRIVING DOWN A DIRT TRAIL FROM A MOUNTAIN OUTLOOK THE CARS ELECTRICAL SHUT OFF. WE HAD NO CONTROL OF BRAKES, OR ANYTHING BUT STEARING. NOT TO MENTION WE WERE PICKING UP MAJOR SPEED DOWN A MOUNTAIN, AND BOUNCING EVERYWHERE. WE HAD TO SWERVE BACK AND FORTH, HITTING BUSHES AND SEMI DRIVING UP THE SIDE OF THE MOUNTAIN TO TRY AND SLOW DOWN. OUR WHOLE FAMILY WAS IN THE CAR, INCLUDING A TWO MONTH OLD AND A THREE YEAR OLD. THE ONLY WAY WE GOT IT TO WORK AGAIN WAS SLAMMING THE SHIFTER INTO NEUTRAL AND THEN PUSHING THE RESTART BUTTON, BUT IT WAS PROBABLY JUST OUR PRAYERS THAT GOT THE CAR TO TURN BACK ON AND GIVE US BRAKE CONTROL AGAIN. I'M AFRAID TO DRIVE MY CAR IN FEAR OF IT HAPPENING AGAIN.

MY 2017 FORD EXPLORER XLT WITH BASE 3.5 V6 HAS BEEN HARD TO START FROM THE FIRST WEEK OF OWNERSHIP. IT HAS LESS THAN 5000 MILES ON IT NOW AND ISN'T FIXED. FORD DEALERSHIP STATED IT WOULD HAVE TO GET WORSE BEFORE THEY COULD FIX IT. VEHICLE SHOWS NO DTC'S OR ANY HISTORY! MY WIFE HAS REFUSED TO DRIVE IT OUT OF TOWN DUE TO THE FEAR OF IT NOT STARTING AT ALL. WE HAVE RECORDED OVER 30 VIDEOS OF IT NOT STARTING AND HAVE SENT VIDEOS TO FORD MOTOR CO. WITH THE SAME RESPONSE, CANT FIX IT IF IT ISN'T BROKE. APPARENTLY IT WILL HAVE TO EITHER BREAK SOMETHING INTERNALLY AND LEAVE MY WIFE AND CHILD STRANDED, BEFORE IT WILL BE DIAGNOSED. IT IS A $40000 LEMON THAT TAKES 3-4 TIMES ATTEMPTING TO START BEFORE THE ENGINE WILL RUN. THIS WEEKEND IT TOOK AT LEAST 30-40 SECONDS BEFORE VEHICLE STARTED, THEN IT WOULD NOT IDLE CORRECTLY! STILL NO DTC'S! VEHICLE DOES THIS NO MATTER THE LENGTH OF TIME ENGINE HAS RUN OR LEVEL OF FUEL? IT DOES IT DURING REMOTE START OR THE PUSH BUTTON. IT DOES AT TIMES HAVE A STRONG ODOR OF GAS AFTER START-UP, ALMOST AS IF IT WAS FLOODED? AS A PERSON IN THE AUTOMOTIVE REPAIR WORLD, THE ABSENCE OF CONCERN FROM FORD IS SHOCKING! SO INSTEAD OF TRYING TO CORRECT A ISSUE BEFORE IT BECOMES A DANGER, THEY WOULD RATHER IT BECOME DANGEROUS AND THEN REPAIR IT? IF IT IS A FUEL RELATED ISSUE, THEN THIS IS A POTENTIAL HAZARD THAT NEEDS TO BE ADDRESSED. THE VEHICLE IS GETTING WORSE, BUT AS SAID EARLIER, IT WILL HAVE TO COMPLETELY NOT START BEFORE SOMETHING IS DONE. FORD MOTOR CO HAS NOT

SMELL OF EGG/SULFUR IN THE CABIN OF THE CAR AFTER RAPID ACCELERATION. I HAD NOTIFIED THE DEALERSHIP AT MY LAST OIL CHANGE. THEY DIDN'T SEEM CONCERNED ABOUT IT. THE SMELLS HAS CONTINUED. DEALERSHIP IS NOW TELLING ME TO WAIT TILL NOV 1ST. THIS HAS BEEN HAPPENING SINCE I BOUGHT THE CAR IN DEC 2016 AND HAS STEADILY GOTTEN WORSE. I DIDN'T THINK IT WAS A BIG DEAL SINCE THE DEALERSHIP DIDN'T SEEM CONCERNED.

HAVING HEAD ACHES AND SHORT OF BREATH, CHEST PAINS, FATIGUE,DIZZINESS. HARD TIME BREATHING. POSSIBLE CARBON MONOXIDE POISONING.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, CARBON MONOXIDE EMITTED THROUGH THE VENTS IN THE VEHICLE. THE DRIVER BECAME DROWSY WHILE DRIVING. THE CARBON MONOXIDE REMAINED IN THE VEHICLE UNTIL THE WINDOWS WERE ROLLED DOWN. THE CARBON MONOXIDE DETECTOR DETECTED 13 PPM TO 16 INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO LAKE ELSINORE FORD (31500 AUTO CENTER DR, LAKE ELSINORE, CA 92530, PHONE NUMBER: (951) 471-4100), BUT THEY COULD NOT DETECT THE CARBON MONOXIDE DUE TO NOT HAVING A CARBON MONOXIDE DETECTOR. THE MANUFACTURER INFORMED THE CONTACT THAT IT WAS NOT AN ISSUE AND SOMEONE WOULD CALL BACK. THE APPROXIMATE FAILURE MILEAGE WAS 20,350.

EXHAUST IS ENTERING THE VEHICLE AND MAKING MYSELF AND MY 2.5 YEAR OLD SON SICK. I IMMEDIATELY GET A HEADACHE WHEN DRIVING AND FEEL NAUSEOUS, EXTREME FATIGUE, BODY AND MUSCLE ACHES, MEMORY ISSUES, CONFUSION, AND I'VE BEEN COUGHING UP BROWN MUCOUS WHICH IS LINKED TO THE INHALATION OF HAZARDOUS POLLUTION AND GASES. THESE SYMPTOMS LAST LONG AFTER I AM FINISHED DRIVING MY CAR AND HAVEN'T GONE AWAY FOR MORE THAN FOUR DAYS. MY SON IS HAVING THE SAME SYMPTOMS AND IT MAKES ME NERVOUS BECAUSE EXPOSURE TO THESE GASES WILL HINDER HIS NEURODEVELOPMENT. IT IS DIFFICULT TO SAY WHEN THE GAS IS ENTERING THE CAR, BUT I OPENED MY SUNROOF WHILE DRIVING THIS MORNING WITH THE WINDOWS UP AND THE A/C ON AND I COULD SMELL A NATURAL GAS SMELL AND I FELT THE EFFECTS OF INHALING THE GAS IMMEDIATELY. THE GAS WAS ESCAPING THROUGH THE SUNROOF AND RIGHT BY MY HEAD.

CAR SMELLS LIKE ROTTEN EGGS FROM THE OUTSIDE OF THE VEHICLE. I NOTICED A SLIGHT ODOR IN THE TRUNK AREA, BUT IT'S MOSTLY COMING FROM UNDERNEATH THE VEHICLE.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. EVER SINCE THE CONTACT PURCHASED THE VEHICLE AND BEGAN DRIVING IT, SHE EXPERIENCED NAUSEA, VOMITING, DIZZINESS, BLURRED VISION, AND HEADACHES INTERMITTENTLY. THE CONTACT REQUIRED HOSPITALIZATION FOR THE SYMPTOMS, BUT RECEIVED NO DIAGNOSIS. THE CONTACT STATED THAT THE SYMPTOMS OCCURRED WHEN SHE WAS IN THE VEHICLE FOR AN EXTENDED PERIOD OF TIME. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. A DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 300.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS HIGH SPEEDS, EXHAUST FUMES ENTERED INTO THE CABIN OF THE VEHICLE. WHEN THE HEATER AND AIR CONDITIONER WERE ACTIVATED, THE ODOR OF EXHAUST FUMES ENTERED THROUGH THE VENTILATION SYSTEM. THE CONTACT SUFFERED HEADACHES FROM EXPOSURE TO THE FUMES. CRAIN FORD IN LITTLE ROCK, ARKANSAS, 72210 REPLACED A GASKET AND SEALED THE VEHICLE (EXACT REPAIRS UNKNOWN), BUT THE FAILURE RECURRED. THE DEALER REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED THE CONTACT WITH CASE NUMBER: CAS-13337847. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000.

EXHAUST CAN BE EASILY SMELLED WHEN ACCELERATING, POSSIBLY INDICATING A LEAK OF CARBON MONOXIDE INTO THE CABIN.

EXHAUST SMELL.....ROTTEN EGGS OR SULFER SMELL WHILE ACCELERATING WITH THE A/C ON IN RECIRCULATE SO I KNOW ITS NOT FROM OUTSIDE VEHICLES

MY WIFE AND I PURCHASED A 2017 FORD EXPLORER AND SHE WAS COMPLAINING OF BURNING EYES AND NESUEA I DID THINK NOTHING OF IT UNTIL I SAW A CBS REPORT ABOUT THE POLICE INTERCEPTORS SO WHEN I WENT TO MY LOCAL DEALERSHIP AND ASKED THEM ABOUT IT THEY SAID NOT TO WORRY BECAUSE MY EXPLORER WAS NOT PART OF THE RECALL PLEASE NHTSA MAKE THEM TAKE THE EXPLORERS BACK AND EXCHANGE IT'S NOT FAIR THAT WE PAID FOR A $34,000 VEHICLE THAT IS NOT SAFE FOR US AND THE PUBLIC THANK YOU,

MY PARENTS BOUGHT THIS UNIT 8 MONTHS AGO FROM TIPTON FORD DEALERSHIP IN BROWNSVILLE TX. SOON AFTER THAT MY MOM STARTING COMPLAINING ABOUT TINGLING IN HER HANDS AND HAD LOST 8 POUNDS IN 2 WEEKS. SHE WAS RECENTLY ADMITTED IN THE HOSPITAL FOR 4 DAYS WITH CARBON MONOXIDE LEVEL IN HER BLOOD. THE LOCAL FORD DEALERSHIP HAS NOT BEEN HELPFUL WHAT SO EVER.

WHEN ACCELERATING VEHICLE OVER 45 MPH EXHAUST FUMES INSIDE VEHICLE APPARENTLY COMING THROUGH AC VENTS

WE PURCHASED THIS VEHICLE BRAND NEW ON 8/11/2017 (19 MILES)AND WE STARTED NOTICING A SMELL OF EXHAUST WHEN WE ACCELERATED AND WHEN WE HAD THE REAR A/C ON COMING IN THE CABIN. WE HAD IT AT THE DEALERSHIP FROM SEPT 25, 2017 TO OCT 6,2017 (1496 MILES). THE PROBLEM STILL EXISTS WHEN WE PICKED IT UP FROM THE DEALERSHIP ON OCT 6, 2017. WE BELIEVE THIS IS A SERIOUS HEALTH CONCERN AS WE HAVE BEEN EXPERIENCING HEADACHES, ESPECIALLY MY WIFE, WHO IS THE PRIMARY DRIVER. WE WILL NOT LET OUR GRANDCHILDREN RIDE IN THIS VEHICLE WITH THE EXHAUST FUMES PRESENT. WE ARE AWARE THAT FORD IS AWARE OF THIS PROBLEM SINCE 2012. AS THIS IS A BRAND NEW VEHICLE,WITH 1496 MILES, WE FEEL THAT THIS PROBLEM IS NOT GOING TO GO AWAY ANYTIME SOON. WE DO NOT WANT HAVE TO KEEP TAKING THIS TO THE DEALERSHIP FOR TEMPORARY FIXES (TSB). WE WANT A PERMANENT FIX, IF THAT INCLUDES GETTING A NEW ONE.

EXHAUST FUMES COMING INSIDE CAR WHEN ACCELERATING

EXHAUST FUMES IN CABIN ARE EXTREMELY STRONG WHEN DRIVING 35 MPH OR HIGHWAY. I AM LIGHTHEADED, DIZZY,TROUBLE BREATHING EXASPERATED WITH COPD AND ASTHMA. DEALER SAID THEY DID NOT NOTICE EXHAUST IN CABIN WITH CO DETECTOR.

OUR 2017 FORD EXPLORER SPORT HAS A CONSTANT FOUL SMELL AFTER ACCELERATION. THE SMELL OVERWHELMS THE PASSENGER COMPARTMENT AND IS SIMILAR TO A SULFUR OR BURNING HAIR SMELL. ADDITIONALLY, IF THE VEHICLE IS STOPPED IDLE FOR ANY PERIOD OF TIME, UPON INITIAL ACCELERATION, A LARGE CLOUD OF WHITE SMOKE COMES FROM THE TAILPIPES.

EXHAUST FUME LEAKS INTO PASSENGER CABIN - PROBLEM SINCE PURCHASING THIS VEHICLE NEW THIS SPRING; ANYTIME WHEN ACCELERATING TO MERGE INTO HIGHWAY TRAFFIC WITH RECIRCULATING AC ON A BURNING OIL OR ACRID ODOR LEAKS INTO THE CABIN. IN AN ATTEMPT TO FIX THE PROBLEM THE LOCAL FORD DEALER 'RESEALED" THE UNDERCARRIAGE, HOWEVER THE PROBLEM PERSIST. ON A RECENT 400 MILE ROAD TRIP WITH RECIRCULATING AC ON PASSENGER AND DRIVER GOT VERY DROWSY, WINDOWS HAD TO BE OPENED, RECIRCULATING AC TURNED OFF AND STOPS MADE TO SHAKE OFF THE EFFECTS. MY PREVIOUS 2013 FORD EXPLORER HAD THE SAME EXHAUST PROBLEM BUT NEVER LIKE THIS. WHEN I PURCHASED THIS NEW MODEL I TOOK IT ON FAITH THE "PROBLEM" WOULDN'T AFFECT THE 2017S. FORD HAS HAD A LONG TIME TO FIGURE THIS OUT AND CORRECT WHATEVER MANUFACTURING OR DESIGN DEFECT IS CAUSING THIS. I WILL CONTACT THE LOCAL DEALER WHO HAS BEEN VERY ACCOMMODATING TO ADVISE I HAVE FILED THIS COMPLAINT. I JUST WANT A SUV THAT DOESN'T HAVE THIS ISSUE SINCE 80% OF MY TRIPS ARE 40+ MILES OF HIGHWAY DRIVING AT HIGHER SPEEDS. ALL I WANT IS A FORD EXPLORER THAT DOESN'T PUT MY HEALTH AT RISK.

THE RIGHT REAR QUARTER PANEL WINDOW SPONTANEOUSLY SHATTERED WHILE THE CAR WAS PARKED AT THE END OF MY DRIVEWAY, OBSTRUCTING VISABILITY.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL TO INCREASE THE RPMS TO APPROXIMATELY 25-30 MPH, THE VEHICLE EMITTED A STRONG, FOUL ODOR SIMILAR TO ROTTEN EGGS. THE CONTACT TOOK THE VEHICLE TO SANDERS FORD (1135 LEJUNE BLVD, JACKSONVILLE, NC 28540; 1-888-897-8527) WHO DIAGNOSED THE VEHICLE AND COMPLETED THE DIRECTIONS ON A SPECIFIC SERVICE BULLETIN. THE CONTACT STATED THAT THE DEALER REPLACED THE VENTS UNDERNEATH THE BUMPER. THE SERVICE BULLETIN NUMBER WAS UNKNOWN. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 9,000.

SINCE BUYING MY EXPLORER I HAVE NOTICED ANY TIME I ACCELERATE I BEGIN TO NOTICE AN AWFUL SMELL. IF WE DO NOT ROLL WINDOWS DOWN, EVERYONE IN THE VEHICLE GETS NAUSEOUS OR DIZZY. TODAY WHILE ACCELERATING ON THE INTERSTATE I HAD TO QUICKLY STOP TO THROW UP. IT HAS NEVER GOTTEN TO THAT POINT UNTIL TODAY. AFTER BRINGING IT TO NEAREST FORD DEALERSHIP IT WAS CONFIRMED THAT IT IS A CARBON MONOXIDE LEAK AND I WOULD HAVE TO TAKE IT BACK TO WHERE I PURCHASED IT TO HAVE IT REPAIRED.

WHEN DRIVING VEHICLE I SUFFER FROM BURNING EYES, HEADACHE, NASEA, FEELING ILL, VEHICLE WAS AT DEALER FOR CO2 LEAK, VEHICLE WAS OUT OF SERVICE FOR APPROXIMATELY 60 DAYS, I PICKED IT UP, DROVE HOME APPROXIMATELY 30 MINUTES AND BECAME ILL, SAME AS BEFORE IT WAS SUPPOSEDLY REPAIRED. I RETURNED IT TO DEALER THE SAME DAY SO THEY CAN TRY TO FIGURE WHY REPAIR DIDN'T CORRECT THE PROBLEM, I WAS TOLD A DISTRICT TECHNICIAN WOULD NEED TO COME INSPECT THE VEHICLE, THIS HAS BEEN A PROBLEM SINCE THE FIRST DAY WE DROVE IT HOME FROM THE DEALER. VEHICLE HAS LESS THAN 3,000 MILES ON IT. THIS REPAIR WAS SUPPOSED TO BE THE "RECALL REPAIR" FOR CO2 LEAKING INTO VEHICLE, THIS REPAIR DID NOT RESOLVE MY ISSUE, SO NOT SURE IF FORD REALLY HAS THIS FIGURED OUT YET.