2017 Ford Explorer complaints

Recall has been issued on the ford explorer for smell of exhaust in the cabin. I have had the recall inspected and completed in 2019. I am now smelling the exhaust again upon acceleration. I told the dealership I have always been able to smell the exhaust even after they "fixed" the issue the first time. It just wasn't as bad. The smell is much worse now.

After a heavy rain water accumulated inside the car front passenger floor and under the seat. After inspecting I could not determine where the water came in. I feel this is a safety concern due to the electrical wiring under the seat

I HAVE A 2017 FORD EXPLORER. THE PASSENGER SIDE WINDSHIELD TRIM RIPPED OFF AS I WAS DRIVING APPROXIMATELY 55 MPH AND FLEW UP IN THE AIR AND LANDED BEHIND ME. FORTUNATELY, THERE WAS NOT A VEHICLE BEHIND ME. THE DRIVER'S SIDE WAS LOOSE, AND I GLUED IT DOWN WITH GORILLA GLUE AS A TEMPORARY HOLD. SINCE THAT TIME, I HAVE NOTICED MANY EXPLORERS WITH THE SAME MISSING WINDSHIELD TRIM. I FEEL THIS POSES A DANGER NOT NECESSARILY TO THE DRIVER, BUT OTHER DRIVERS ON THE ROAD.

THE DOOR DOOR KEYLESS ENTRY PAD BROKE OFF AND FLEW FROM THE VEHICLE WHILE DRIVING DOWN THE HIGHWAY. NO PRIOR DAMAGE TO THE KEYPAD/DOOR TRIM PRIOR TO THIS OCCURRING. UPON INSPECTION THE PASSENGER DOOR TRIM (WITHOUT THE KEYPAD) ALSO SEEMS TO BE "LOOSE" AT THE TOP, POTENTIALLY HAVING IT FLY OFF DURING NORMAL USE OF THE VEHICLE. DEALER SAID THAT A RECALL WAS IN PLACE FOR THE DRIVERS SIDE BUT THAT MY VEHICLE WAS NOT INCLUDED IN THE RECALL. ALTHOUGH, ALL DESCRIPTIONS I COULD FIND SEEM TO HAVE INCLUDED EXACTLY WHAT HAPPENED TO MY VEHICLE.

I HAD THE REAR SUSPENSION RECALL DONE AND AFTER PURCHASING A NEW SET OF TIRE MY REAR RIGHT TIRE IS WEARING INCREDIBLY FAST AS IF THE REAR SUSPENSION ISSUE IS STILL PRESENT.

WHILE DRIVING ON A STRAIGHT STREET 25-35 MPH JULY 30, 2020, ON A SUNNY DAY,MY CAR RIGHT PASSENGER TIRE CAME OFF. ON A CITY STREET. CAUSING MY CAR TO HIT THE CURB. THERE WAS NO BODY DAMAGE EXCEPT FOR THE PASSENGER FRONT AND REAR TIRE.

I HAVE 2 RECALLS THAT MY DEALER WONT FIX BECAUSE THEY WONT GET ME A RENTAL CAR WHILE MY IS REPAIRED.MY QUESTION WHO IS RESPONSIBLE IF INJURY OR DEATH OCCURS BECAUSE OF THESE RECALLS ?

THE VEHICLE AND ITS WHEELS WITH ONLY 16,000 MILES HAS DEEP CRACKS AND CUTS ON THE SIDES OF THE TREAD, THREATENING FUTURE BREAKAGE OR EXPLOSION. AS FOREMENTIONED THE VEHICLE UNDERGOES REGULAR MAINTENANCE AS WELL TIRE ROTATION. THERE IS NO REASON FOR THE WHEELS TO BE THIS DAMAGED WITH SO LITTLE USE. TIRES: HANKOOK TIPE: VENTUS S1 NOBLE SIZE: 255 150/20 105H DOT 5MNC 1A H (1817) QUANTITY : 5

MY TRANSMISSION ON A PREVIOUS FORD EXPLORER AND NOW THIS FORD EXPLORER HAVE STARTED TO GIVE ME ISSUES AROUND THE 3RD YEAR OF OWNERSHIP. TRANSMISSION SLIPS, JERKS, AND CAR CUT OFF FOR AROUND 10 SECONDS 4 SEPARATE TIMES NOW. I CAN'T GET AN APPOINTMENT AT THE DEALERSHIP SO IT'S HARD TO HAVE CAR LOOKED AT. ALSO LEAKING TRANSMISSION FLUID AND RPM JUMPS HIGH THROUGHOUT DRIVE. THIS HAS HAPPENED WHILE DRIVING ON CITY STREETS AND FREEWAYS. TRANSMISSION IS ROUGHER ON ROADS THAT INVOLVE UPHILL AND DOWNHILL.

ONE WEEK AGO, MY FAMILY AND I TOOK A TRIP IN A RECENTLY PURCHASED EXPLORER WHERE WE ALL EXPERIENCED SYMPTOMS OF POISONING. WE ARE CURRENTLY GETTING THE VEHICLE SERVICES BY THE DEALERSHIP. HOWEVER, WE ARE NOT CONFIDENT THAT THE FIX WILL BE CORRECTED AS IT SEEMS LIKE THERE ARE MORE THAN ONE LOCATION WHERE THE LEAK CAN TAKE PLACE. I'D LIKE TO BE INCLUDED IN THE INVESTIGATION FOR THE CARBON MONOXIDE DETECTION IN THE FORD EXPLORERS. IF YOU HAVE ANYONE TO POINT US TOO IN REGARDS TO MAKING THIS A RECALL ON THESE VEHICLES IT WOULD BE APPRECIATED. THIS NEEDS TO HAVE MORE ATTENTION FOR ALL CARS AND HIGHER SAFETY STANDARDS SHOULD BE IMPLEMENTED ON BEHALF OF THE CONSUMER, IN MY OPINION. THANK YOU FOR YOUR TIME AND MY FAMILY LOOKS FORWARD TO HELP THIS INVESTIGATION.

LEFT SIDE REAR SUSPENSION TOE LINK FRACTURE IN MY CAR OCURRED WHEN THE CAR WAS IN SERVICE ON A HIGHWAY! AFTER THE FAILURE MODE OCURRED, WE LOST THE CONTROL OF THE CAR AND WE FRONT CRASHED AGAINST A TRUCK. FORTUNATELLY A FATALITY DOES NOT OCURRED BUT IT WAS CLOSED, ONLY BODY INJURIES AND A LOST CAR. THIS FAILURE MODE HAS A RECALL AND CAMPAIGN UNDER THE NUMBER 20V675000, FORD DEALER IN MEXICO DOES NOT WANTS TO TAKE FULL RESPOSIBILTY OVER THE CATASTROFIC FAILURE AND DEFECTS COMING FROM THE OEM! THEY JUST REJECTED MY CLAIM. I NEED HELP ON THIS ISSUE ASAP. THIS UNIT WAS SOLD IN MEXICO, WE PLACED A REPORT WITH FORD MEXICO BUT THEY REJECTED, AND HIS ARGUMENT WAS THAT THE FAILURE ALREADY OCURRED AND THEY ARE NOT RESPONSIBLE NOW! DEALER SAID THE SAME. THIS IS SERIOUS AND SAFETY ISSUE DUE TO A DEFECTIVE PART WAS PLACED BY FORD AND PASSED AS AN ""OK" PART, MANY LIFES ARE IN RISK NOW!!! AND THEY JUST SAID IS NOT THEIR ISSUE.*DT*DT*DT CONSUMER STATED THERE HAVE BEEN 8 RECALLS SUBMITTED TO NHSTA RELATED TO THIS VEHICLE SO FAR.*JB

THE VEHICLE HAD LOOSE K MEMBER BOLTS, BENT STRUTS, LOOSE EXHAUST SYSTEM. THIS WAS FOUND WHEN WE TOOK VEHICLE IN FOR FIRST OIL CHANGE

MY 2017 FORD EXPLORER WITH 62,000 MILES SUFFERED A CATASTROPHIC ENGINE FAILURE WHILE DRIVING AT HIGHWAY SPEED. THE CAR IMMEDIATELY LOST POWER AND I WAS ALMOST HIT FROM BEHIND. I LIMPED INTO A REST AREA WHERE THE VEHICLE HAD TO BE TOWED TO A DEALER. THE FORD DEALER SERVICE TECHNICIAN DIAGNOSED THE ISSUE AS A MAIN BEARING FAILURE. THE CAR NOW REQUIRES A NEW ENGINE THAT WILL COST $6700 DOLLARS AND FORD HAS DENIED TO PROVIDE ANY FINANCIAL ASSISTANCE EVEN THOUGH THE VEHICLE HAS ONLY 62,000 MILES ON IT.

THE REAR SUSPENSION STARTED WITH A LOWER NOISE IN THE REAR PASSENGER SIDE, WHENEVER I MAKE TURNS OR THE ROAD IS A LITTLE ROUGH. TO THIS DAY IS GETTING A LOT WORSE, MORE NOISE AND UNSTABLE WHEN I TAKE TURNS. ALSO THE SEAT BELT LIGHT COME ON, AND I WAS TOLD THAT THE MODULE IS MALFUNCTION AND NEED TO RESET OR REPLACE WITH A NEW ONE.

REAR BRAKE CALIPERS SEIZED AND WORE BRAKE PADS ALL THE WAY DOWN. SLIGHT INTERMITTENT SOUND WAS NOTICED WHEN CAR WAS IN MOTION BUT THOUGHT IT MAY BE RELATED TO THE ROOF RACK DETACHMENT THAT WAS PENDING REPAIR. SQUEALING BECAME PERSISTENT AND STOPPED UPON BREAKING, AND STARTED AGAIN AFTER BRAKE RELEASED. UPON IDENTIFYING THIS CORRELATION TOOK THE EXPLORER TO THE DEALERSHIP AND THIS ISSUE IDENTIFIED WAS SEIZED CALIPERS.

AUGUST 2020: WHEN PASSING A VEHICLE ON THE HIGHWAY, APPLIED GAS PEDAL FULLY TO THE FLOOR, IT STUCK. VEHICLE CONTINUED TO ACCELERATE, PEDAL WOULD NOT RETURN TO NORMAL POSITION. HAD TO GET TO SHOULDER, SHOVE VEHICLE INTO NEUTRAL AND TURN OFF. FORD DEALER REVIEWED, DETERMINED ONLY LIKELY CAUSE COULD BE THE THROTTLE BODY, REPLACED THROTTLE BODY. APRIL 2021: WHEN ACCELERATING ON THE HIGHWAY, PRESSED PEDAL TO FLOOR, PEDAL ONCE AGAIN STUCK. WOULD NOT RETURN TO NORMAL POSITION, CONTINUED TO ACCELERATE. MOVED TO SHOULDER AT HIGH RATE OF SPEED, APPLIED BRAKES AS MUCH AS POSSIBLE AND PUT VEHICLE INTO NEUTRAL, THEN PARK. VEHICLE COMPLETELY REVVED OUT, ENGINE AT MAX RPMS. TURNED OFF VEHICLE. WAITED A FEW MINUTES. TRIED TO TURN VEHICLE BACK ON, SOUNDED LIKE STARTER WAS STUCK. TURNED OFF VEHICLE. WAITED A FEW MOMENTS, TURNED ON AND DROVE CAREFULLY HOME.

THE TRIM MOLDING IS COMING OFF THE DRIVERS SIDE DOOR AT THE TOP ABOVE THE ELECTRONIC KEYLESS ENTRY TOUCH PAD. AT HIGHWAY SPEEDS IT MAKE A NOISE THAT I CAN HEAR AS I AM DRIVING. I AM AFRAID THAT IT WILL BREAK OFF AND FLY LOOSE IMPACTING ANOTHER VEHICLE.

THE WATER PUMP LEAKED COOLANT INTO THE ENGINE OIL AND WILL COST OVER $3,000.00 TO FIX. THE FORD EXROPLER ENGINE DESIGN WITH THE WATER PUMP IN THE ENGINE IS A CASH TRAP FOR CONSUMERS. THE DESIGN IS HORRIBLE.

*VEHICLE MAKES POPPING NOISE *JERKS, LOSS OF POWER WHEN GOING DOWN THE ROAD, HARD TO STEER, PUSH ON GAS AND WILL NOT GO. ENGINE LIGHT AND WRENCH COME ON. CALLED DEALER WHEN FIRST HAPPENED WAS TOLD TO TURN OFF BACK ON TO RESET. HAVE WORKED WITH DEALER AND MANUFACTURE. THIS IS DANGEROUS AND I'M TERRIFIED TO DRIVE THE VEHICLE. THIS WILL BE AT LEAST THE FOURTH TIME BACK IN THE SHOP FOR REPAIRS. IN ADDITION TO SEVERAL CALLS.

WIFE AND I PURCHASED AN 2017 XLT SPORT WITH 11,000 MILES AND WITHIN MONTHS WE KEPT HEARING POPPING NOISES AS SHE TURNS. ITS THE STRUTS AND THEY HAVE BEEN REPLACED TWICE WITHIN WITH 20K MILES. JUST HAD THEM REPLACED AGAIN AT OUR LOCAL DEALERSHIP WHO HELPED US TREMENDOUSLY AND DIDN'T CHARGE US THAT MUCH SINCE IT IS NOW OUT OF WARRANTY 39,000 MILES REPLACING THEM AND ITS POPPING AGAIN. I HAVE RESEARCHED THAT THE STRUTS ON THESE MODELS ARE BAD. THIS NEEDS TO BE LOOKED INTO.

REAR WINDOW GLASS SPONTANEOUSLY SHATTERED WHILE SITTING AT STOP LIGHT. DEFROSTER WAS OFF, OUTSIDE TEMP WAS 38 DEGREES FAHRENHEIT. NO KNOWN REASON. GOOGLE SHOWS THIS HAPPENING TO OTHER 2017 FORD EXPLORERS, BUT WHEN I CALLED FORD, THEY DENIED ANY KNOWLEDGE OF THIS PROBLEM.

WE BOUGTH THE CAR ON AUGUST 2019 WITH 4700 MILES. IN NOVEMBER 2019 THE CAR STARTED OCCASIONALLY (3 TIMES DURING 3 MONTH PERIOD) TO SOUND THE REVERSE ALARM SENSOR WHILE DRIVING. THEN CAR DIDN'T START, SO WE CHANGED THE BATTERY. IN MID MARCH, AFTER TAKING MY 3 KIDS (OUR DAUGHTER 6 AND THE TWINS WERE 2) TO THE PARK, THE CAR WILL START BUT THE STEERING WHEEL WAS NOT TURNING. IT WAS JUST STOCK AND HARD TO MOVE. WE ARE SO GRATEFUL THAT THIS DIDN'T HAPPEN WHILE DRIVING. WE COULDN'T TAKE IT TO THE DEALER BECAUSE OF THE PANDEMIC (WE DIDN'T WANTED TO EXPOSED OURSELVES TO ANY OTHER PEOPLE). FINALLY IN SEPTEMBER, THE CAR WAS TOWED TO THE DEALER. THEY CALLED THE FOLLOWING DAY AND EXPLAINED THAT TO REPAIR WILL COST US $ 1790. PLUS OTHER REGULAR ITEMS THAT NEEDED TO BE DONE FOR A TOTAL OF $2098. WHILE I DO UNDERSTAND THAT MANUFACTURING ERRORS DO HAPPEN, STILL I CAN'T COMPREHEND THE FACT THAT THE CAR IS 50519 MILES AND ALREADY NEEDS THESE EXPENSIVE REPAIRS THAT COULD HAVE CAUSE A VERY DANGEROUS ACCIDENT TO MY FAMILY. THIS IS OUR FAMILY CAR! I DRIVE MY KIDS TO SCHOOL AND TO THE PARK EVERY DAY. HOW COME SOMETHING THIS SERIOUS IS NOT PUT ON A TEST BEFORE PUTTING A CAR INTO THE MARKET (?). BUT, MORE THAN BEING VERY DISAPPOINTED AND SHOCKED FROM WHAT HAPPENED AND I FIND THE SITUATION VERY IRRITATING. NEW CARS SIMPLY DON'T DO THAT. I WOULD LIKE TO PLEASE HELP ME UNDERSTAND WHAT HAPPENED TO OUR FAMILY CAR AND I WOULD LIKE FOR YOU TO ENSURE THIS WONT HAPPEN AGAIN, I AM SCARED OF DRIVING MY FAMILY IN

THE TRIM ON THE PASSENGER SIDE OF THE WINDSHIELD FLEW OFF ON THE HIGHWAY. LUCKILY, IT CRASH INTO IN THE SHOULDER AND CRUMBLED INTO A MILLION PIECES. THE DRIVERS SIDE TRIM ALSO APPEARS TO BE LOOSE. IT WASN'T PARTICULARLY WINDY THIS DAY AND I WAS TRAVELLING AT NORMAL HIGHWAY SPEEDS (70-75MPH).

THE ADHESIVE HOLDING ON THE PANEL COVERING ON THE DRIVER DOOR FAILED. THIS HAPPENED WHILE TRAVELING ON THE HIGHWAY THE PANEL PRIED LOOSE AND FLAPPED AGAINST THE CAR, CRACKING AND SENDING A CHUNK OF THE PLASTIC COVERING BEHIND INTO TRAFFIC. THIS COULD HAVE HIT A MOTORCYCLIST OR OTHER VEHICLE AND BEEN VERY DANGEROUS. I KNOW THIS CAR HAS ANOTHER RECALL FOR THE ADHESIVE FAILING ON THE ROOF COVERINGS. THIS FAILURE SHOULD ALSO BE FIXED. THE CAR IS A 2017 SO NOT THAT OLD.

DEALER SERVICED MY ROOF RACK 12 DIFFERENT TIME BECAUSE THE COVER WHICH IS APPROXIMATELY 5 FEET LONG HAS BECOME LOOSE 12 SEPARATE OCCASIONS. THE MOST RECENT ISSUE WAS THE COMPLETE COVER BLEW OFF THE TOP OF THE VEHICLE WHILE DRIVING ON THE INTERSTATE. THE VEHICLES TRAILING ME TOOK EVASIVE MANEUVERS TO AVOID BEING STRUCK BY THE ROOF RACK COVER. I TOOK THE VEHICLE TO THE DEALER AND THEY ORDERED NEW PARTS AGAIN WHICH ARE UNDER RECALL BY FORD. THE ISSUE NOW IS I'M DRIVING THE VEHICLE THAT CURRENTLY HAS A LOUD WHISTLING NOISE THAT STARTS AT 50 MPH AND BECOME SO LOUD IT IS A DISTRACTION ABOVE 60MPH. I CANNOT SAFELY DRIVE THE VEHICLE ON THE INTERSTATE BECAUSE OF THE MISSING ROOF RACK COVER. THE DEALER SAID THEY ARE STILL WEEKS AWAY FROM RECEIVING THE BACK ORDERED PARTS. WHILE AT THE DEALER I OBSERVED FOUR OTHER FORD EXPLORERS IN THE SERVICE BAY, ALL FOR ROOF RACK SERVICE. THE DEALER INFORMED ME THAT THEY AVERAGE 8 SERVICE CALLS A DAY FOR THIS ISSUE WITH SEVERAL A WEEK MISSING THE ROOF RACK COVER FROM BEING BLOWN OFF THE VEHICLE WHILE THE VEHICLE WAS IN MOTION. FORD IS OFFERING ME A BUY BACK ON MY VEHICLE, HOWEVER THEY HAVE NOT PROVIDED THE OFFER IN THE TIME FRAME THEY COMMITTED TO. NOTE, I AM FOND OF FORDS, I OWN THREE OF THEM HOWEVER THIS IS AN EXTREME SAFETY ISSUE. I'M RETIRED FROM LAW ENFORCEMENT AND WAS A CERTIFIED CRASH RECONSTRUCTIONIST. I FORESEE VEHICLE CRASHES OCCURRING AS A RESULT OF THIS ISSUE WITH PARTS FALLING OFF THIS YEAR AND MAKE OF FORD VEHICLE (2017 EXPLORER)*DT*DT*J

WHEN ACCELERATING ON TO THE HIGHWAY OR UPHILL, THE INSIDE CABIN SMELLS OF FUMES. I BELIEVE IT IS CARBON MONOXIDE. WHEN THE CAR IS WARMING UP IN THE MORNING, THE CABIN SMELLS DO FUMES, I BELIEVE ITNIS CARBON MONOXIDE. I HAVE PURCHASED A CARBON MONOXIDE DETECTOR AND WILL INCLUDE IT IN THE CABIN.

USED MY REMOTE START AS USUAL, PULLED OUT OF MY DRIVEWAY AND AT THE END OF MY STREET I HEARD MY BACK WINDOW BURST. IT LOOKS AS IF IT'S EXPLODED FROM THE INSIDE, AS THE WINDOW IS BOWED OUTWARD.

THE DRIVER'S AND PASSENGER SIDE WINDSHIELD PILLAR MOLDINGS ARE LOOSE AND COMING OFF AND MAKING A VIBRATION SOUND WHILE DRIVING AT ANY SPEED OVER 30 MPH. I HAVE READ MULTIPLE COMPLAINTS OF THEM FLYING OFF WHILE DRIVING AND POTENTIALLY CAUSING AN ACCIDENT TO OTHER MOTORISTS. I HAVE HAD THEM CHECKED BY THE DEALER AND THERE IS NO RECALL FOR THEM.

THE HOUSING FOR THE ANTENNAS AND GPS ON THE TOP OF THE EXPLORER CAME OFF WHILE DRIVING. TWO DIFFERENT FORD SERVICE TECHS SAID THAT IS A KNOWN PROBLEM. WE WILL NOW BE OUT OF POCKET $650 FOR A PROBLEM THEY KNOW ABOUT.

EXPLORER TRUCK STARTED LEAKING COOLANT FROM WATER PUMP. IN PARKED POSITION A PUDDLE STARTED TO FORM UNDER IT.

1ST TIME I HAD MY CAR WASHED THROUGH A DRIVE THROUGH CAR WASH THE LUGGAGE RACKS ON TOP OF THE EXPLORER LIFTED UP. TOOK THE VEHICLE TO FORD DEALERSHIP IN EL CAJON CA (WERE THE VEHICLE WAS PURCHASED) AND THEY WANTED $500 TO FIX IT. DID NOT GIVE ME A TICKET WITH THE PROBLEM LISTED ON IT. IT WAS A BRAND NEW VEHICLE. THEY NOW LIFT IN HEAVY WIND OR IF I TRY TO WASH THE TOP OF THE VEHICLE. NOT SURE OF DATE WAS IN 2017 RIGHT AFTER BOUGHT THE CAR.

THIS ISSUE ALREADY HAS AN NHTSA ID NUMBER 10156860 LEAKING PDU. THE PARTICULAR FAILURE OF THIS UNIT LEAKS OIL ONTO HOT EXHAUST AND ACCORDING TO A LOCAL SERVICE CENTER IS A FIRE RISK PUTTING OCCUPANTS AND PROPERTY IN POTENTIAL HARMS WAY. IT APPEARS TO BE A VERY WELL DOCUMENTED AND COMMON FAILURE AND IN MY OPINION SHOULD BE A RECALL DUE TO THE SAFETY CONCERNS. THE COST OF REPAIR VARIES ACROSS THE COUNTRY HOWEVER APPEARS TO RANGE BETWEEN $1800.00-$4000.00 MINE ALTHOUGH FAILED PRE WARRANTY EXPIRATION BY THE TIME I WAS ABLE TO GET IT INTO THE DEALERSHIP I WAS 3600 MILES OVER MY DRIVETRAIN WARRANTY. THEY ARE POTENTIALLY OFFERING "SOME FINANCIAL ASSISTANCE" THROUGH SOME FORD LOYALTY PROGRAM HOWEVER I HAVE YET TO SEE WHAT THAT WILL LOOK LIKE.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT WHILE SITTING IDLE, THE VEHICLE SUDDENLY STARTED TO SHAKE VIOLENTLY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, WHEN THE VEHICLE NEEDED TO SWITCH GEARS, THE VEHICLE WOULD REV UP IN SPEED, SLIGHTLY STALL, AND THEN JOLT FORWARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER - ANDY MOHR FORD (2713 E MAIN ST, PLAINFIELD, IN 46168; (317) 836-2299) AND REPAIRED UNDER AN UNKNOWN SEAT AND LIFTGATE RECALL HOWEVER, THE MECHANIC WAS NOT ABLE TO IDENTIFY THE CAUSE OF THE FAILURE. THE CONTACT STATED THAT AFTER THE REPAIR THE FAILURE INCREASED IN OCCURRENCE. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE CONTACT CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN A POWER TRAIN RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

CAR OFF. WHEN FILLING TANK, WHEN IT'S FULL AND THE PUMP CLICKS OFF THAT YOUR TANK IS FULL AND YOU PULL THE GAS PUMP OUT THE CAR IT SPILLS OUT FUEL THERE'S NO SAFETY OR STOP EVERY TIME I FILL MY GAS TANK GAS COMES OUT DOWN THE CAR ONTO THE GROUND SINCE I HAVE HAD THE VEHICLE SINCE NEW.

PLASTIC WINDSHIELD MOLDING ON DRIVER AND PASSENGER SIDE ARE PULLING AWAY FROM THE WINDSHIELD AND ARE NOW LOOSE. ROOF RAILS HAVE STARTED TO PULL AWAY FROM THE ROOF AND ARE WARPING ALONG THE EDGES. THE ROOF RAILS WERE REPLACED WITHIN A MONTH OF ORIGINAL PURCHASE FOR THE SAME ISSUE. PLASTIC MOLDING AT THE DOORS APPEARS TO BE MELTING AND WARPING IN SEVERAL AREAS.

PAINT IN FRONT OF ROOF STARTED BUBBLING DO TO CORROSION FORMING UNDER THE PAINT. FORD WONT COVER IT BECAUSE IT NEEDS TO HAVE A HOLE FOR THEM TO COVER IT.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN DEALER WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

USED AUTO START FEATURE TO START THE CAR.WHEN I GOT IN THE CAR THE REAR GLASS EXPLODED. TEMPERATURE WAS AROUND 15 DEGREES FAHRENHEIT. I BELIEVE THE WINDOW HEATER CAUSED THE FAILURE.

LAST NIGHT ONE OF MY HANKOOK S1 NOBLE ON MY 2017 FORD EXPLORER BLEW OUT WHILE DRIVING ON THE 405 FREEWAY AND REQUIRED ME TO PULL OVER AND CHANGE THE TIRE. AT 21,000 MILES ON THE VEHICLE/ TIRES THE MECHANIC SHOP TOLD ME THE TIRES WERE BASICALLY BALD AND HAD RUBBER EVENLY ERODING (WHICH INDICATES NOT AN ALIGNMENT ISSUE). THE TIRES WERE ALSO ROTATED AND SUPPOSED TO LAST 50,000 MILES. THERE ARE ALSO MANY OTHER COMPLAINS ON THESE TIRES THROUGHOUT THE INTERNET BUT NOT RECALL HAS BEEN INITIATED BY HANKOOK. THEY HAVE ADVISED THEY WILL GIVE A PRO-RATED DISCOUNT ON NEW TIRES, WHICH IS COMPLETELY UNREASONABLE AND NEGLIGENT..

MY 3 YR OLD TRUCK ALREADY HAS A LEAKING COOLANT LINE WHICH COME TO FIND OUT IS DRAINING INTO THE WATER LINE IN THE ENGINE. I CAN'T DRIVE MORE THAN 5MILES BEFORE I NEED TO REFILL MY COOLANT. IN ADDITION, THE HEATING ELEMENTS IN BOTH THE DRIVER AND PASSENGER SEATS HAS GONE OUT. I THOUGHT IT WAS A FUSE AND OF COURSE ITS SOMETHING MORE.

I WAS ON MY WAY HOME AND THE ROOF RACK BROKE AND FLEW OFF MY CAR WHILE I WAS DRIVING DOWN THE HIGHWAY AND ALMOST HITTING THE CAR BEHIND ME. THE CAR HAS 31,998 MILES ON IT

CAR PULLED IN MY LANE MY CAR AUTO BREAKED, I ALSO PUT ON BREAK THEN ICON CAME ON ABOUT AIRBAG ISSUE. TOOK TO FORD RUN TEST. THE PIG TAIL THAT GOES TO AIRBAGS, NEED TO SAUTER 21 PINS THAT GOES TO CONNECTION OF PIGTAIL TO AIRBAG.

WHILE DRIVING DOWN THE HIGHWAY THE BACK SEAT IN FOLDED DOWN POSITION CAUGHT FIRE AND BURNED A 12 INCH HOLE THROUGH TOP AND BOTTOM OF SEAT. TO OUR KNOWLEDGE THE SEAT HEATER WAS NOT ON THE INDICATOR LIGHT WAS NOT ON.

REAR CAMERA GLITCHES OUT AND IMAGE IS DISTORTED ON MANY CASES WHEN BACKING UP.. SIMILAR TO CONCERNS ON RECENT RECALL ON NEWER MODELS. ADDITIONALLY, BACK ELECTRIC 12V PORT DOES NOT DISENGAGE AND HAS LIVE CONNECTION EVEN WITH NO KEY IN IGNITION. FINALLY, VENTS NEXT TO PASSENGER SIDE DOOR APPEARS TO EXUDE HOT AIR INTO CAR THAT MAY BE LINKED WITH EXHAUST WHEN CAR IS ON.

PURCHASED MY 2017 FORD EXPLORER 2/12/2018, BOUGHT NEW FROM DEALER, AND NOW HAS 6029 MILES ON IT. THE WINDSHIELD SEAL AND ROOF RAILS HAVE DETERIORATED AND COMING AWAY FROM THE SUV. BUT, THE PARTS THEY QUOTED ME WAS FOR FOUR PILLERS THAT GO ON EACH SIDE OF WINDSHIELD, NOTHING ABOUT A SEAL. I WAS INFORMED THIS IS NOT COVERED BY MY WARRANTY. I BELIEVE IT IS A DEFECT FROM THE MANUFACTURE AND SHOULD BE COVERED. QUOTED $982.01 TO REPAIR. THIS SHOULD BE A RECALL AND FORD SHOULD HAVE TO TAKE CARE OF IT. THE SERVICE ADVISOR SAID THIS PROBLEM WILL CONTINUE TO GET WORSE AND WINDSHIELD COULD CRACK CAUSING VISION PROBLEMS UNEXPECTEDLY AND COULD CAUSE HARM/INJURY TO THE DRIVER. THIS NEEDS TO BE INVESTIGATED BEFORE SOMEONE GET SERIOUSLY HURT OR KILLED IN A ACCIDENT THAT COULD HAPPEN. I HAVE ALWAYS HAD FORD VEHICLES, BUT WILL NOT BUY ANOTHER AGAIN.

THE FRONT DRIVER SEAT FEELS LOOSE. WHEN DRIVING AND TAKING A SHARP CURVE OR GOING OVER BUMPS THE SEAT SHIFTS.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60-65 MPH, THE VEHICLE STARTED OVERHEATING. THE CONTACT STATED THAT PRIOR TO THE FAILURE, THE VEHICLE HAD RECEIVED AN OIL CHANGE AND THE COOLANT AND OTHER UNSTATED FLUIDS WERE TOPPED OFF. THE CONTACT PULLED OVER TO THE SIDE OF THE ROADWAY AND HAD THE VEHICLE TOWED TO MAPLECREST FORD LINCOLN OF UNION LOCATED AT 2800 SPRINGFIELD AVE, SUITE 1, VAUXHALL, NJ 07088, WHERE THE VEHICLE WAS DIAGNOSED. THE CONTACT WAS INFORMED THAT COOLANT WAS FOUND IN THE ENGINE AND ALSO THAT THE WATER PUMP WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED DUE TO THE REPAIR COST. THE CONTACT WAS ALSO INFORMED THAT THE WARRANTY HAD EXPIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 16V925000 (ENGINE AND ENGINE COOLING) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE BUT PROVIDED NO FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

MY EXPLORER HAS 70.000 MILES AND THE TRANSMISSION STARTED TO MAKE SOUNDS WHEN IS IN MOTION LIKE METAL TO METAL AND WHEN I ACELERATE IS GETING WORST AND WHEN IT SHIFT IT JUMP AT 3.000 RPM I BRING THE EXPLORER TO THE DEALER AND IM WAITING FOR DIAGNOSTIC

I NOTICED A STRANGE NOISE WHEN I MADE TURNS AND IT FELT AS IF MY DRIVER SEAT MADE A SLIGHT MOVEMENT. WHEN THE DEALERSHIP FINALLY LOOKED AT IT THOROUGHLY AFTER 3 TIMES THEY DETERMINED THE BAR UNDER MY SEAT THAT BASICALLY HOLDS MY SEAT IN PLACE WAS BROKE COMPLETELY IN HALF. NO EXPLANATION. THE CAR HAS NEVER BEEN IN AN ACCIDENT AND HAS LESS THAN 50,000 MI ON IT. THEY STATED THEY HAVE NEVER SEEN ANYTHING LIKE IT CHARGED ME THE DEDUCTIBLE AND FIXED IT MY CONCERN IS THAT IT WAS A MANUFACTURING PROBLEM AND IF IT HADN'T NOTICED IT AND HAD AN ACCIDENT I FELT LIKE MY SEAT WOULD HAVE DETACHED. IT WAS A LITTLE SCARY AND DISCONCERTING.

MY STEERING WHEEL WOULD BECOME VERY STICKY. I WOULD MAKE A TURN AND THEN WHEN I WOULD GO TO TURN THE WHEEL BACK, IT WOULD STICK. IT ALMOST THREW ME INTO A TRACTOR TRAILER YESTERDAY. I NOTICED IT MORE AT HIGH SPEEDS AND MOST TIMES IT WAS SOMETHING I COULD 'DEAL WITH', PLANNING AHEAD WHEN TURNING, SLOWING MY SPEED, ACCOUNTING FOR OVER CORRECTING THE WHEEL, BUT YESTERDAY WAS VERY SCARY. I FELT LIKE I HAD TO MAKE CONSTANT LITTLE TURNS WITH MY WHEEL EVEN THOUGH I WAS GOING PERFECTLY STRAIGHT. I PULLED OFF AND TURNED MY CAR OFF AND THEN TURNED IT BACK ON AND IT WAS AS NOTICEABLY NOT AS BAD. I TOOK IT STRAIGHT TO THE DEALERSHIP BECAUSE I'VE HAD IT FOR LESS THAN TWO MONTHS AND THEY INFORMED ME I NEED A NEW STEERING GEAR BOX. I WAS CONSTANTLY AFRAID OF OVER CORRECTING MY WHEEL TO ACCOMMODATE FOR THE STICKINESS OF IT AND ENDING UP IN THE OTHER LANE OR OFF THE SIDE OF THE ROAD.