2017 Ford Explorer complaints

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, he noticed fluid leaking underneath the vehicle. There was no warning light illuminated. The contact, who is an independent mechanic, diagnosed the vehicle and determined that the water pump needed to be replaced. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 56,000.

On 11/21/22, my car ‘lost’ it’s transmission at 72,704 miles. This is when a wrench light came on the dashboard, and the car went into limp mode-putting myself and my 2 children at risk while driving. I was luckily able to pull off the road. When I restarted the car, the light went off and allowed me to slowly drive back to my house. We had it towed to a Ford Dealership for further investigation. Prior to this incident, the car had been having intermittent issues with shifting gears on hills, and an occasionally clunking noise that paired with it. We had taken it to the dealership and asked them to investigate. They told us there were no issues, that the transmission was fine, which meant no codes. We had just had some powertrain issues resolved, due to other lights associated with the terrain management system. The issues continued, intermittently, but we were unable to get into another appointment prior to its failure. Once in, we were informed that it was ‘rare’ and that while they hadn’t fully investigated the issue the prior time-there had been no computer codes to indicate this would happen. So, now we have no car and an $8200 bill to fix it, as quoted by our Ford Dealership

I WAS DRIVING ON I95 ON FRIDAY AND THE DRIVER LEFT SIDE WINSHIELD OUTER PILLAR OUTER TRIM MOLDING FLEW OFF IN THE WIND VERY HARD. ON SATURDAY I WAS DRIVING ON THE BELTWAY WHEN THE PASSENGER SIDE RIGHT SIDE WINDSHIELD OUTER PILLAR OUTER TRIM MOLDING FEW OFF I WAS SO SCARED BECAUSE I DONT KNOW IF HIT THE WINDSHILED OF THE CAR BEHIND ME. THIS IS VERY DANGEROUS. NOW BOTH ARE GONE.

I purchased 2 2017 ford explorers and they both developed the same problem . The plastic windshield pillar facia trim breaks off at highway speed. Not only is this a dangerous distraction to the driver, the part flying off at 65 mph becomes a projectile that is a hazard to vehicles following behind. Based on forums, you tube videos, and the availability of aftermarket replacement trim, this would appear to be a wide scale problem.

While driving on the highway the driver side windshield flew off the car into the roadway.

- The weather stripping around my front windshield failed and caused the molding around the windshield to also fail. - This failure occurred while driving at highway speeds. The flying debris alarmed me and could have obstructed my view. It could also have hit another vehicle and caused an accident. - There are instances online of this happening to Ford Explorers. Unknown if it has been inspected by dealers. - My vehicle has not yet been inspected for this defect. - There were no warning lamps or messages/symptoms before this failure. It first appeared on 12/1/2022. My vehicle is a 2017 and at 56000 miles.

I bought the car from modern Corp s in Fort Myers Florida and the brakes are bad the catalytic converters are melted the steering makes noise sounds like it's just going to break in half we have a warranty and they will not honor any of it after they said they would we had to put it in the shop not even a week of having it because of the AC and the only thing the warranty covered was the sway bars ball joints and a couple other things I drive this car every single day I just feel like this car is not going to make it nobody wants to honor the word about anything and I see there is a recall for the roof rack one side of it is missing if anybody can help me that would be great because I would love to get my vehicle repaired the right way

The contact owns a 2017 Ford Explorer. The contact stated that carbon monoxide was entering the cabin of the vehicle. The contact stated that there was an abnormally strong exhaust odor inside the vehicle after driving short distances. The contact stated that he felt lightheaded while driving the vehicle. No medical attention was sought. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000.

The contact owns a 2017 Ford Explorer. The contact stated that the front and rear passenger's side doors failed to open from the outside whenever the door was locked. The dealer was notified of the failure and informed the contact that the failure was a known issue. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.

I was driving in the highway and one of the roof racks went off flying and almost hit the car behind me. After I stopped I checked the other rack and it is also lose and coming off.

Fuel leak from damaged fuel line. Fuel leaking onto the upper part of the engine resulting in raw fuel fumes into the cabin thru ventilation. Extreme fire hazard in the engine compartment and or to the entire car. observed cause : crimp clamp located on the air box intake hose was installed in a position where the crimped part of the hose clamp rubs on the metal fuel line causing leak.

IN JANUARY 2021 I had a recall for the roof rails on my 2017 Ford Explorer - it took them a year to get the parts due to covid but they finally fixed the roof rails. About one month ago the roof rails started to pop back up - I made appointment at local Ford Dealership in Fuquay Varina, NC. The told me the recall was closed and they were not responsible for them coming up again as they repaired them for the recall. Once recall is closed out that is it .. nothing can be done. Is this correct? They finally agreed to cover 60 percent and I would have to pay 40 percent. Is this correct. Why should I have to pay out of pocked when the repair did not fix the problem. I contacted Ford at [XXX],[XXX] and they told me the same thing and said I only had until December 21 to make a decision. How can this be fair. Please help. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the side window molding was peeling off. The contact then stated that the driver's side molding was coming apart. No warning lights were illuminated. The vehicle was taken to a local dealer, where the contact was informed that the driver's and passenger's side window molding needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was made aware of the failure and offered to cover only a portion of the repair. The approximate failure mileage was 15,000.

After purchasing a 2017 Ford Explorer Eco Boost (65K miles) it was only 6 -7 months (yes months) later that I would find myself in a devastating car situation. At exactly 72,000 miles, I discovered my engine would need to be completely replaced. I discovered this after having my vehicle diagnosed at the Ford dealership. Coolant in the #2 and #3 cylinders. The dealership said it would cost $9500 for a new motor. I just bought the car! After searching the internet, I am finding more and more people are having the same problems, and some are prone to engine fire! I have children! There is already law suite against the Ford Company, But I try to do the right thing, I called Ford Motor Company to report my problem. Case No. CAS-39543003-F9S9T0 CRM:040000805. They said they would look into it. My hopes were up. I received a call, They know it is a default in the motor but it has not been recalled yet! Really! So I’m supposed to wait until there is a recall! I was so upset! She did say that they would pay for $4500, but I only have 30 days to let them know if I will take their offer. I told her I don’t have $5 - $6000 sitting around. Ford motors is aware of this issue and has refused to offer assistance in the whole cost. It should be a recall...

The contact owns a 2017 Ford Explorer. The contact stated that after starting the vehicle, the message to "See Owner’s Manual" and the coolant level overheating warning light were illuminated. The vehicle was taken to an independent mechanic, where the contact was made aware that there was a coolant leak and was advised to take the vehicle to a local dealer for further diagnostic testing. The vehicle was not yet taken to a dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling); and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 100,000.

The contact owns a 2017 Ford Explorer. The contact stated while driving 30 MPH, the vehicle stalled. The contact stated that an unknown warning light was illuminated. The contact inspected under the hood and noticed that the spark plugs were crossed in the engine. The contact took the vehicle to the local dealer, where it was diagnosed with needing the spark plugs to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 101,000.

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the vehicle would not properly accelerate while depressing the accelerator pedal. Additionally, the vehicle would not properly shift gears while attempting to accelerate. The vehicle was taken to an independent mechanic who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not notified of the failure. The failure mileage was 60,000.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the temperature gauge failed to increase. The contact stated that a message appeared on the instrument panel indicating that the engine power had been reduced to prevent engine failure. The contact stated that after the vehicle was parked, he noticed that coolant was leaking on the ground. The dealer was notified of the failure and informed the contact that the potential cause was due to a faulty water pump. The contact was informed that the water pump needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was advised to take the vehicle in for diagnostic testing. The failure mileage was approximately 133,000.

The contact owns a 2017 Ford Escape. The contact stated that the vehicle had overheated. The contact took the vehicle to the dealer who diagnosed that the water pump had failed. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 105,000.

Water pump: coolant leak, overheated engine.

The contact owns a 2017 Ford Explorer. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the air bag connectors needed to be replaced. The vehicle was repaired. The manufacturer was not contacted or notified of the failure. The failure mileage was 114,000.

No warning lights, took vehicle in for clicking noise - diagnosed ball joint repair. Also Ford dealers tells me my water pump is leaking and repair will cost over $3,500. I have read that this is a common problem and I would like to report it.

The APIM module failed in our 2017 Ford Explorer. The module failed so the windshield wipers do not work, the turn signals do not work, the heater does not work, the speedometer does not work, the tachometer does not work, the temperature gauge does not work, the fuel gauge does not work, the center display does not work, the reverse camera does not work and the radio will not turn off and the center display lights will not turn off.

Husband returning home, pulled into carport and as he removed foot from accelerator to brake, accelerator pedal kept accelerating. This caused explorer to hit carport awning, classic 65 mustang, 2007 Harley and shed. Airbags did not work. Accelerator is still pressed to floorboard.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at 80 MPH, the driver's side front windshield molding detached. The dealer was made aware of the failure; however, the vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN and that the replacement part was not covered under warranty. The failure mileage was approximately 59,000.

Sunroof leaked & water dripped into top center light assembly and down either side of the windshield support frames, then into the back of the plastic panels under them, continuing down the supports that lead to far left & right frames and into the carpet under the rubber mats.Very concerned about water mixing with electrical parts of the lights in the overhead area over the dash & starting a fire.Tried to open sun roof so I could wipe the channels dry and reclose sunroof but the electric components to it stopped working probably due to water damage,so sunroof was now partially opened to the environment. Vehicle is available at my home in my driveway mostly covered by a blue tarp until I take it to the Ford dealer next week on Thursday to get inspected,checked & fixed (I hope).Was initially scared the water leak mixing with electricity of the overhead front lights & dripping behind the dash panel on either side of the front seats might create a spark and catch something on fire, but got fortunate and didn’t happen.Do not know if Ford dealer can reproduce it until they check it next weeThurs, but one of representatives at dealership repair shop mentioned they are aware of a common problem where if the sunroof is not cleaned & checked regularly the drain channels can get clogged and cause water to leak inside the car-my reply “why would Ford built car that leaks through the roof when it rains”, could leak into electrical components inside the car-got no reply. Asked if this was

We had an issue with Fuse 34, it popped and sent warning lights to the dash regarding safety systems and sensors, as well as the cameras in front and back stopped working. We replaced the fuse and it held for a while, but then popped again. I noticed a lamp flickering one day on the front of the vehicle, and upon further inspection saw that the front camera and wiring harness had started on fire. The wiring harness is fully melted and there are signs of smoke and fire damage on the front of the car. I took the vehicle to a Ford dealer who confirmed their wiring harness had failed, but will not take responsibility for the issue. The care only has about 45k miles on it. I called to their corporate office who also rejected any liability. Obviously this is more than just the money for repairs, but a safety hazard that they will not respond to.

The contact owns a 2017 Ford Explorer. The contact stated that the keyless entry outside the front driver’s side door popped off without warning. The contact also stated that the rear tailgate latch failed to operate. The vehicle was taken to the dealer where the wiring of the keyless entry was repaired also repaired the rear tailgate latch. Additionally, the contacts stated that the roof rail cover started to detach from the sunroof, and water leaked through the sunroof. The contact then received notification of the NHTSA Campaign Number: 21V316000 (Structure). The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed to call the NHTSA Hotline. The failure mileage was 119,000

Bad APIM, available for inspection. Diagnosed by Ford dealer when I took it in for Sync screen going black, navigation fault, steering wheel Sync controls not working. Backup camera does not work periodically - which is my prime safety concern. It is also distracting when the navigation and sync screen go black while driving. Ford seems to know the problem, and from other on-line posts, this is a popularly recurring malfunction.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at various speeds, the vehicle was swaying and became difficult to control with several unknown warning lights illuminated. The contact then received notification of NHTSA Campaign Number: 22V537000 (Steering). The dealer had been notified on multiple occasions of the issue and informed the contact that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 48,000. Parts distribution disconnect.

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was outside in the rain, the contact noticed a moldy and musty odor inside the vehicle. The contact noticed that the trunk and spare tire compartment was wet. The vehicle was taken to the local dealer where a water specialist diagnosed the vehicle and informed him that the passenger's side luggage pillar rack was cracked. The mechanic added sealant to the pillars. The vehicle was repaired. The manufacturer was contacted and referred him to the NHTSA Hotline. The approximate failure mileage was 49,831.

After having the fan replaced on my vehicle less than 200 miles put on it the AC compressor went out.

The contact owns a 2017 Ford Explorer. The contact stated that while her husband was driving approximately 70 MPH, the door lock access panel on the driver's side started to loosen and almost separated from the door frame. The contact pulled off the highway and observed that the passenger’s side door lock access panel was also loosened. The contact stated that her husband used duct tape to secure the panels. The contact had taken the vehicle to a local dealer however, the vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 87,000.

Window trim on the winshield flew off while driving. Apparently this is a common issue with explorers, as when I went to the Ford Dealership to inquire about replacement they knew exactly what i was talking about and that they have tons of people coming in about it and that they are shocked that it hasnt been a recall so far. I was told that even the owner of the dealership has an explorer and it happened to theirs as well. When the trim flew off i was driving on the interstate going 70 mph- Not only is it faulty but if it were to hit someone they could be injured.

The contact owns a 2017 Ford Explorer. The contact stated that the engine overheating warning message would appear on the instrument panel while driving at various speeds. The vehicle was initially taken to an independent mechanic who discovered that the coolant reservoir was empty and linked the failure to a defective water pump. The mechanic then referred her to a dealer for assistance. The dealer was notified of the failure and provided an estimate for a diagnostic test. The manufacturer was also notified of the failure and informed the contact that they might help if a diagnostic test was performed by the dealer. The vehicle was taken back to the independent mechanic where it remained in their possession. The vehicle was not repaired. The failure mileage was approximately 66,000.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed and attempting to make a left turn, the steering wheel failed to respond. The contact shifted to park(P) and then shifted back into drive(D). The vehicle then regained steering functionality. The contact was able to continue driving however, the failure recurred on several occasions. The vehicle was taken to the local dealer on three occasions; however, the dealer was unable to duplicate the failure and the failure persisted. The manufacturer was notified of the failure and referred the contact to NHTSA Hotline for assistance. The failure mileage was approximately 30,676.

The contact owns a 2017 Ford Explorer. The contact stated that while driving approximately 10 MPH, warning message regarding the engine cooling was displayed before the vehicle stalled. The vehicle was towed to the local dealer who diagnosed that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The VIN was not available. The failure mileage was 70,000.

I took my Vehicle in because the AC stop blowing cold air, and the overheating lights kept coming on. After waiting for a week, I was told it was a water pump but that did not fixed the AC being at all, couple days later I got a call from the dealership (GRAPEVINE FORD) that the compressor went out. After 3 weeks of waiting, I end up paying out of pocket what is supposed to be covered based of this letter I received from FORD. I feel like I should not have to pay for something that FORD should have covered. Letter below explained the very issues I had with the vehicle, including OVERHEATING and damages like bad cooling relay would cause.

The hood on the vehicle has decay/bubbling. It is most prevalent along the front edge of the hood. I am not sure if this affects the structural integrity, safety worthiness, or latching aspects of the hood. If so, this is a major concern for all owners of this vehicle. I was made aware by another owner of same make and model that this is common occurrence.

The contact owns a 2017 Ford Explorer. The contact stated while walking up to the vehicle parked in the driveway, she noticed a trail of fluid in the driveway. The dealer was notified of the failure and advised the contact to add water to the radiator and to bring the vehicle in to the dealer to be inspected. The vehicle was taken to the dealer where it was diagnosed that the water pump had leaked and caused coolant to leak into the engine, causing the engine to be damaged. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 69,891.

Carbon monoxide leaking into my car—tailgate area and through the front hvac. Weird sound from engine that sounds and smells like electrical burning or something overheating.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at various speeds, the power steering assist would fail to operate as needed. The contact stated that excessive force was required to steer the vehicle due to the failure. The contact took the vehicle to the dealer and was informed that the tires and battery were the cause of the steering failure. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 17V530000 (Steering). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 69,000.

On freeway, pushed brakes but vehicle did not stop or slow down resulting in multi car rear end collision. Auto braking and ABS features did not engage. Vehicle was towed and our insurance agent claim adjuster recommended we reach out to you. No warning lamps, messages, etc. went off at the time or had gone off previously.

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle previously had the driver's side rear seat belt retainer replaced; however, the failure recurred with the passenger's side rear seat belt retainer. The vehicle was taken to the dealer where it was diagnosed that the passenger's side rear seat belt retainer had fractured inside the buckle assembly. The dealer informed the contact that the passenger's side rear seat belt retainer needed to be replaced; however, the part was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 78,000.

Our model is a platinum explorer with the panoramic sunroof. Apparently there is a sunroof leak which due to the way the headliner is made , fills the headliner (holds like a bowl) then either spills out at the front of the vehicle or rear depending on going forward , reverse, accelerating, braking, uphill, or downhill etc. The front is worse because of the electrical in the overhead lights, sunroof motors, and lane departure at the rear view mirror. Also everything electronic below on the dashboard and center console. There are high expenses related to replacing these electronics due to water damage in addition to the driver being suddenly started by a wave of water crashing down on them while accelerating or braking.

The windshield trim has flown off of my car twice. It's happened twice bc I repaired and then 3 mos. later it happened again. The 1st time it flew off I was driving home in rush hour traffic in downtown fort worth, tx and it flew off into the oncoming traffic. I could have seriously injured someone or caused a wreck, having car parts flying off at high rates of speed in the middle of a major city.

Exhaust Fumes entering the passenger cabin through the heat/ac vents and causing carbon monoxide poisoning to passengers! Having medical issues due to this issue and it has been found twice and it’s been doing this since day 3 of owning it! Purchased new on February 21, 2018 with only 2 miles and 6 miles when paperwork was signed! On day 5, 02-26-2018, called dealer was told by the salesman Tommy, it was the new smell and it would go away, Never has and never will! I’ve been sick for over 2 years and 90% of my medical issues has came from purchasing this vehicle and it’s still releasing exhaust fumes and causing me problems. I would like to know WHY a recall has never been done and FORD to be made response for their actions and deceit for this major problem!

Ford Eco Boost Coolant Intrusion Issues. If the car sits an idles the coolant light will come on an say the coolant is too hotIf I run the air conditioning it will do the say, or drive it on the freeway. There are no leaks, no were. And you can smell the coolant, it smells really hot. My engine line is on.

The gasket or weatherstripping around windshield is falling away from the windshield. This has led to leaking into the headliner to the map light around the frame of the door on body of car and flooded floorboard.

Transmission is giving out has turned off while driving and sometimes it won't go reverse and Or won't go into gears Machine shows code p0731