2017 Ford Explorer complaints

Traveling at Highway speed (70mph) on level road without unusual road conditions is clear daytime weather, the drivers side windshield pillar trim separated from the vehicle, and the drivers side mid pillar trim loosened, but did not separate. No other vehicle damage occurred. The vehicle had been purchased from a Dealer in Bowie Tx, 15 minutes before the incident. The dealer has agreed to repair the damage.

At highway speed the Windshield-Outer Trim Molding Pillar Driver Left Side departed the vehicle. I saw something flicker by but did not know what it was until I stopped and saw the missing trim piece.

Pulled my Explorer into the driveway because the temperature gauge came on While driving up my hill. Then when pulling in the driveway there was fluid leaking throughout my driveway and then there was a big puddle. I had it towed to a local service station in my town and I just got the estimate. The water pump was no good. I have only 74,599 miles on my SUV. I just found out that in the past (2011-2016) Explorers had issues with the water pumps. I brought it to a local auto repair station because I couldn't get my explorer in for 3 weeks at a local dealership.

While driving on the interstate the second day that we had the car, bought it used the right side window A pillar trim came off the car and landed on the interstate and broke in pieces. Several cars behind us had to swerve to keep from hitting the parts. Could have caused a very bad accident as there was a lot of cars on the road. I see that this a major issue with the Explorers and should be recalled due to safety.

The trim and seals around the front windshield are cracked and coming apart. This has caused parts to fly off potentially hitting other cars. This has happened in multiple occasions.

"A" pillar window trim fails to remain affixed to the vehicle. After just a year of new vehicle ownership, on at least 15 different occasions, my passenger side "A" window trim or driver's side window trim would fly off while in travel. This usually occurs on the highway at any speeds exceeding 40 mph. I feel that this creates a safety issue and a financial burden as the piece and sometimes the mounting bracket have to be purchased at each incident. The safety issues are a somewhat large part of the vehicle separates and goes flying into any following traffic. The separation from the vehicle is usually a noisy and distracting affair for the operator/driver. Further, following traffic has to avoid the now airborne part. An additional safety concern is the missing part exposes the edges of the windshield, possibly affecting the integrity of the windshield, not to mention little protection from rain, water or snow. Lastly, the missing part creates a very unsightly vehicle. Attached are pictures of my vehicle without the part and my 2023-2022 eBay purchases. The document shows 6 replacements/purchases in just over a one year period. I have purchased both very expensive OEM parts and after market parts, with the same unfortunate results. I am not an engineer, but it appears that poor design allows 45+ mph wind to get under the trim, forcing it away and off the windshield pillar. Please, consult with any 2011-2019 Ford Explorer owner and I'm sure they have a similar story. I make a

Internal water pump failed. Dealer indicated that it needs replacement at a cost of $4,000. This is a know issue for Ford Explorer models for multiple years going back to 2011 including the model year 2017. Ford has not recalled the vehicles with this safety issue. Vehicles can overheat and cause engine damage including my location in the Phoenix Desert.

The contact owns a 2017 Ford Explorer. The contact stated that on various occasions while the vehicle was parked, there was a fluid leak underneath the vehicle. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the water pump and radiator needed to be replaced. The vehicle was not repaired and was then taken to an independent mechanic, where it remained awaiting parts for the repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 134,000.

Piller moldings between the front and rear windows became loose and one came off. this creates a hazard to other vehicles on the road. we had them replaced by Earnhardt ford in Chandler AZ on 2/10 2023. .

On December 19, 2022, while driving to work in the morning on Interstate 580 I heard some cracking noises coming from outside my vehicle then all of a sudden I see something fly off the right side of my windshield. I immediately looked in my rearview mirror and see a piece of what appeared to be plastic bouncing off the ground luckily no one was hurt nor did it hit another car but it could have easily considering the force with which it ripped off. Once I arrived at work I noticed the right side of the windshield trim panel was gone there were no warning lights or alert notices on the vehicle prior to this incident. I had this same piece replaced approx 3-4 years ago believing that it was our fault (per the service department at the Ford dealership) for driving the truck through a brush-type carwash since then we NEVER returned to those types of carwashes. The car is available for inspection as we have not had the part replaced. In January I came across a news article in USA TODAY regarding this same issue occuring to others yet no recall has been issued!

While driving under 80 mph on the highway my passenger side panel flew off and almost hit the vehicle behind me. I was able to locate the panel after having to drive in reverse on the shoulder for a few minutes. This is my second ford explorer and it flew off on my drive side on the first vehicle.

Windshield trim piece covering passgener side windshield pillar flew off while driving at highway speed. Sounded like something hit the vehicle, but once we stopped, I realized a piece of the car had flown off.

Traveling west on I90 out of Boston a piece of the bodywork (plastic trim sealing the windshield) on the passenger side of the car tore away and flew into the path of vehicles behind. The car has been inspected and repaired by a Ford dealer to the expense of $250 parts and labor. I have filed a complaint with Ford. They simply said that they would not pay for the damage. Nevertheless, this should not be happening. The bodywork should not failing while driving. No police or insurance representatives have been involved. And there was no indication this would happen prior to the incident on Thursday, January 26, 2023.

Wind pulled the ‘A’ pillar trim off the vehicle, breaking g the plastic trim and rubber gasket. This is a know problem that FORD has not issued a recall on, but should.

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 65 MPH, the driver’s side windshield trim panel suddenly dislodged from the vehicle. The vehicle was taken to the local dealer who replaced the trim panel. The contact stated that while driving on another occasion, the failure occurred with the passenger’s side windshield trim panel. The vehicle was taken back to the local dealer who replaced the trim panel. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was 3,000.

While we were driving the door trim on the front passenger side of our 2017 Ford Explorer blew off. We had it replaced by the Ford dealer in Anderson, IN on December 9, 2020. It has again blown off while we were driving in June of 2022. We were on the freeway both times and it could have hit another car.

While driving, the driver side windshield trim flew off almost hitting a car behind me. While inspecting the vehicle, the other side is also starting to coming off, and the panel near the code to enter the drive side door is also starting to come off. The auto body shop has confirmed that this was a recognized problem by Ford and they have seen many Explorers come in with this issue and the body problem was tweaked in upgrades on 2020 explorers and later. Luckily the car behind me was not damaged and it didn't cause an accident but this is not safe & when calling the auto body shop, it would be over $1000 to repair both side windshield trim; not including the door panel that is also starting to dislodge. For this to be a known problem, this should be covered by Ford.

The trim and gasket around the windshield has become broken and cracked within the first 60k miles. The gasket has come loose and was flapping against the windshield while driving. In order to replace the trim must be broken off. Ford refused to fix and said would be $1200 to fix. If you look at many explorers from these model years it’s a recurring thing they they know about. This needs to be recalled because it can come off and fly and hit the vehicle behind us.

In Jan 2023, the driver's side windshield plastic trim flew off my car. It was at night so I do not know if there was an issue behind me. This is the second time we experienced this issue. It happened last year on the same side. We brought it to the Ford dealership and their parts person told me that she had seen this regularly and have talked to Ford about it. They fixed it, and were going to charge me $600 for each side, total $1200 (asked them to reseat the other side). There was no warning that the trim was going to separate from the car and fly off. I see there is a Safety probe on this issue and believe there should be a recall and force Ford to fix this since there could be accidents, injuries and potential for death if the trim comes off and causes other drivers to lose control or hit a motorcycle driver directly. It would be like a spear coming at the motorcycle rider. Thank you.

The contact owns a 2017 Ford Explorer. The contact stated while driving at approximately 40-45 MPH, the windshield trim panel detached from the windshield. The vehicle was taken to the dealer; however, the contact was informed that the failure was not covered under warranty. The vehicle was repaired however, the contact stated that she repaired the trim panel at her own expense. The manufacturer was not notified of the failure. The failure mileage was approximately 65,000.

In October, 2022 I was traveling on interstate 75 in GA. Heard a strange sound in front of vehicle. When I stopped later, I noticed that the trim along the edge of my windshield was no longer there. Upon arriving in FL, later that week, I had Sunrise Ford in Ft. Pierce replace that windshield trim. They said that it was a pretty common problem.

The trim on my windshield is coming off. I saw an article about people reporting this. Due to funds I have just put some medical tape on it to keep it on. It was flying off on the interstate and I had to pull off the road and only had a first aid kit with medical tape in it. The trim is unfortunately built into the plastic of the car so you have to replace the entire thing. There are also small chips of glass coming off the actual windshield. My car has its original windshield. I feel like this is unsafe because it could just go flying off an impair your vision. My car is available for inspection. There were no warnings. The dealer inspected it and said it is a common problem and would be $700-$800 to repair.

I bought the 2017 Ford Explorer on 8/29/2020. The next month I drove to Nags Head, N.C. from Nashville, Tn. Sometime within an hour of arrival, the a piece of trim on the passenger side panel between the doors fell off while going over the bridges. We never saw it and did not know where it landed. I ordered a replacement from Ford Parts to replace it.

The driver side windshield panel thing flew off while I was driving.

The contact owns a 2017 Ford Explorer. The contact stated that she discovered that the side panel trim for the front passenger’s side window was missing from her vehicle upon exiting the vehicle. The vehicle was taken to the dealer where they diagnosed that the adhesive had deteriorated causing the panel to detach from the vehicle. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The contact stated that she had read an article regarding the failure. The approximate failure mileage was 100,000.

The windshield trim became detached near the hood of the vehicle while driving on the freeway. I attempted to secure it back down but some of the clips had gotten brittle and broken. I taped it down until I could get off the freeway and get it repaired. It ended up detaching again and flying off the car. The replacement piece doesn’t seem to attach well either and seems like it’s only a matter of time before it happens again.

The transmission would slip and/or lag. This started around 65k miles. It was reported to the dealer, they couldn’t reproduce it. Then at 101k miles the engine started vibrating when in gear and idling. Motor mounts were replaced, but the problem persisted. Eventually got the entire transmission replaced.

Left windshield trim suddenly detached while driving on freeway, which presents the risk of flying debris striking other cars; since I was in the left lane during the incident in the middle of Nebraska and it landed in the median, no others were known to be struck. Since the problem was a known issue within a Ford Explorer owner's group on Facebook, I simply ordered a replacement part soon after it happened and did not notify anybody. However, keep in mind that since I had a windshield crack and it was replaced with a new trim panel in December 2022, the replacement part is not available anymore as well.

The contact owns a 2017 Ford Explorer. The contact stated while driving 65 MPH, the driver's side front window trim detached. The contact pulled over but was unable to locate the window trim. The dealer was made aware of the failure and confirmed that the driver's side front window trim needed to be replaced; however, the replacement part was on backorder. The contact was able to purchase the replacement part online; however, he had to glue it to the front driver's side window due to fractured clips used to secure the window trim in place. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 12,000.

The cowl needs to be repaired. It makes an annoying buzzing sound inside of the car on the dashboard. It distracts the drive and the driver, I can't go over 40mph. I did my research and put masking type over it and it stopped the noise. I've only had the vehicle since 2019

While driving down the road, the right-side windshield trim came off and struck the vehicle following me.

The contact owns a 2017 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the driver's side front door trim panel detached. The vehicle was taken to the dealer, and the dealer replaced the driver's side front door trim panel. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE23001 (Structure). The failure mileage was approximately 58,800.

Front drivers side trim piece for windshield flew off going 75mph on interstate. Had it replace and did it again a few months later. Passenger side is loose but has not come off yet.

Coolant intrusion into the motor causing the motor to overheat Ford recommend new motor but will not take responsibility of the cost. There was a recall on the 2.0 motor but not on the 2.3 and it is the same design of motor. The problem is the way Ford design the motor the new ones after 2017 are designed differently.

Windshield trim panel flew off my car while traveling at highway speeds. I was traveling on the highway when suddenly the trim and seal under the trim flew off my car and got caught on my side mirror. I was in the middle of a trip nowhere near a ford dealer and had to tape up my car so that it was protected from the elements. I had to pay hundreds of dollars to fix this problem on my own.

At the end of December 2022, my entire right side of my windshield trim piece flew off on the highway. In addition, my right side passenger applique has come off twice on the highway since summer of 2021. The second one was a replacement and it only lasted less than a year before flying off while on the highway again in the fall of 2022. Pictures attached show the windshield piece completely cracked and flew off taking the seal with it.

Driving from Lubbock Texas home to Carlsbad New Mexico on January 18. Very windy out. At approximately 6:00 pm my wife and I heard a noise like something light hit our windshield. It was dark when we got home and we went to bed. Got up to go to the office in the am and same the drivers side A pillar windshield trim piece missing. Saw that there was a recall for this issued in Dec 2022. Went to the Ford Dealer and they said this vehicle was not in the recall list. Why?

Water pump leaking

The right side trim piece on the windshield came off while driving and was dangerous for me and my passenger. The whole side is exposed and will most likely leak. The rubber gasket tore after the trim piece came off and was hitting the side window.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, she noticed a bluish-gray cloud of smoke coming from the rear of the vehicle. No warning light was illuminated. The contact was able to maneuver the vehicle off the road. The vehicle was towed to an independent mechanic where it was diagnosed that the turbocharger leaked on the engine and the turbocharger tubes needed to be replaced. The dealer was not notified of the failure. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling). The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 94,000.

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the passenger's side windshield rubber seal detached. The dealer was made aware of the failure and informed the contact that the failure was caused by wear and tear. The dealer determined that the front windshield rubber seal needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000. The VIN was unavailable.

2017 FORD EXPLORER. CONSUMER STATED THAT THE SEATBELT BUCKLE WOULD NOT RELEASE. THE CONSUMER STATED TOOK THE VEHICLE TO BE REPAIRED THE DEALER LOST THE STEP PANEL AND ALSO NEED ADDITIONAL PARTS TO INSTALL THE NEW SEATBELT.

Front hood top coat issue. I bought the vehicle in Oct ‘22, and it had a pre-existing issue on the front hood.

My husband was driving on the highway on a windy day and the Apillar Trim blew off the car. It got stuck in one of the side mirrors and was bashing against the window until my husband could pull over and get it. When I called the dealership and told them what happened, they shared that it happens frequently. I brought it into the dealership to be repaired and was told by 3 people that it happens frequently. The repair will cost $685. We are going to see if a different repair shop can fix it for less. Either way, our car should not blow apart on a windy day. -Had the part blown into traffic, it could have seriously injured a car behind them or coming toward them -In addition, it was surprising to my husband who said he nearly drove off the road because this part was banging against the car -There was no warning -The dealership has inspected it

Driving on busy interstate at approximately 55mph there was a sudden loss of acceleration ability and check engine light came on, white smoke coming from exhaust. Car was taken to dealership and diagnosed with bank 1 broken turbocharger turbine wheel, and bank 2 turbocharger turbine wheel damaged requiring replacement of both turbocharger turbine wheels, both catalytic converter assemblies, o2 sensors, tailpipe, flex pipe, gaskets. Estimated repair cost greater than $9000. Mechanic at dealership reports this is a very common problem with this vehicle. Vehicle at 88k miles with routine maintenance and no collisions, similar recall for other years of same make and model

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle hesitated to accelerate while the RPM was inoperable. Additionally, the vehicle experienced rough idling and shaking while driving. The contact stated that the dealer previously performed Customer Satisfaction Program: 20B27 (Powertrain Control Module Reflash). The vehicle was taken to the dealer and Grieco Ford of Raynham (1651 New State Hwy, Raynham, MA 02767) however, the dealers were unable to duplicate the failure. The vehicle was then taken to two independent mechanics, who diagnosed that the failure was related to Customer Satisfaction Program: 20N07 (Transmission Extended Warranty Coverage). The mechanics determined that the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle was not covered by the TSB. The manufacturer advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 75,000.

In March of 2022, this vehicle was repaired for a rear suspension toe link recall. On Christmas evening, December 25, 2022, the toe link failed. The car fishtailed briefly before veering uncontrollably off the road. I had no warnings that this was going to happen aside from a slight "clunk" in the rear of the car a second beforehand. Fortunately oncoming traffic immediately stopped and avoided me and I was able (with much difficulty) to move the car to safety. I was only going about 35 mph; I cannot imagine how much carnage I would have created had I been on the highway I was headed to just 3 miles away. The car was flat-bedded to the Ford dealership that has always repaired the car the very next morning, December 26. While waiting for the wrecker, I walked the area where I heard a "clunk" just before the car's steering became inoperable and found a bolt which I brought with me to the dealership. In conversations on December 27, 28 and 29, the Ford service manager stated to me that he and the shop foreman were at a loss as to why the rear suspension toe link failed, but in examining the bolts, they believe they were machined/bored just a little too small allowing it the ability to unscrew itself from the toe link assembly and fall off the car. While the car was at the dealership, I reached out to Ford Motor Company's customer escalation team with the issue. My concern was not just for my own safety, but there are 600,000 other Ford Explorers on the road that might experience

The side pillars on both the driver side and front passenger side became loose. There was a definite rattle sound inside the car. Thankfully I noticed it before they flew off and hit another person/car on the highway. This could have led to multiple injuries. When I brought the car back to the dealership they mentioned that this has happened to other cars. Perhaps there needs to be a recall. This only compounds the situation I had in April of 2022. While driving on a highway I suddenly had a rattle in the front window. I discovered that the moulding had rotted and the window was separating. When replaced by the dealership, they told me that they have dealt with this problem numerous times. Is it time to recall and have Ford pay back these expenses?

I own a 2017 Ford Explorer XLT with 2.3L Eco Boost. It was recently diagnosed with coolant leaking into the cylinder. I was told there is nothing that can be done about it other than buying a new engine. Since August 2022, this car has had the "check engine" light on and has been to several different mechanics and 2 different Ford dealers before finally being diagnosed. After researching this issuer, I have learned that Ford has known about this issue since 2010 and chosen to do nothing about it. I have been driving this vehicle around, not knowing that this problem could cause the engine to catch on fire, endangering all the lives of my family! Ford should take responsibility for this issue and replace the engine!

The contact owns a 2017 Ford Explorer. The contact stated that on numerous occasions while driving at an undisclosed speed, the check engine warning light intermittently illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant was leaking into cylinder #3, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 96,000.