2015 Ford Explorer complaints

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving 65 MPH, the passenger’s side exterior A-pillar trim detached from the vehicle and flew off the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the A-pillar trim was detaching from both the driver’s and passenger’s side of the windshield. While in reverse, the back over prevention camera screen was black and fail to display the image of the rear of the vehicle. The message “Camera Not Available" was displayed on the screen. The failure had become more persistent. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 88,000.

Rear back up camera is glitching in and out and at times goes completely black or won’t come in at all once put in reverse

The back up camera works only intermittently. It's fine sometimes and other times I just get a black screen. this has been going on for a year or more.

The current recall of ford backup cameras including this year but not this vehicle type almost exactly matches what happens with this rear view camera. Either is blacks out completely or when it is on it shows the lines curving when In fact you are going straight and the picture can be extremely blurry as well.

See attached document for complaint. I am writing to formally report a serious and ongoing delay in the fulfillment of Safety Recall 24S02 (NHTSA Recall 24V031) for my 2015 Ford Explorer, which poses a hazard not only to my family but to others on the road. This recall involves the exterior trim on the A-pillars of the vehicle detaching while driving. In our case, this hazard has already occurred-one of the trims on our vehicle flew off while we were on the highway. Thankfully, no one was injured, but this incident highlights the urgency of the recall and the risk posed by the remaining trim, which could detach at any time. Despite receiving the recall notice in early 2024, and despite repeated attempts over the past year and a half to get the necessary parts, we have been informed by our dealership that Ford has not manufactured or supplied any parts for this recall. The dealership confirmed that they requested the parts back in February 2024, but as of today, no update or estimated timeline has been provided by Ford. This situation is unacceptable and has left us driving a vehicle with a known, active safety hazard. We feel that Ford has failed to meet its obligation to repair this defect within a reasonable timeframe, and we are deeply concerned for our safety and the safety of others on the road.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 65 MPH, the A-pillar trim on the driver's side of the windshield detached. The dealer was contacted and confirmed that the part for the recall repair was not yet available. The dealer suggested that the A-pillar trim be secured with duct tape by a technician, or the contact could also perform the temporary fix. The contact secured the trim piece with duct tape to prevent further detachment and eliminate the outside sound entering the cabin of the vehicle due to the failure. The manufacturer was made aware of the issue. The failure mileage was approximately 70,000.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the front A-pillar trims on the driver’s and passenger’s side detached. The contact stated that the A-pillar trims were temporarily repaired with duct tape. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

I was in a parking lot when the electric power steering went out. Couldn’t turn wheel at all

Hello. From what I understand, Ford has not come up with a solution for the exterior a--pillar applique trim clip attachments. I fully believe they have abandoned this issue as its not a brand new vehicle. Well, its new to me so it fully counts and should not be abandoned. I was on the highway in St. Louis, Missouri (I live right across the river in Illinois) and out of nowhere, something hit my car. I swerved and almost hit a driver to my left and after that, I almost got the guy in front of me. Now this caused a massive panic attack and soon after anxiety set in. I have horrible anxiety issues and I have the prescriptions to prove it. Its so bad, I can't fall asleep and so I take another prescrption for help getting to sleep. Anyway, I got off the closest ramp ands parked to see what happened. Sure enough, the passenger side exterior a-pillar is hanging there. That's the "something that hit the car and almost caused a multi car accident. I tried to call Ford about this but I'm left with ongoing ringing. Live chat agent had no idea what I was talking about. That set me off. I had taken a screenshot of the Kelly Blue Book website stating there was a recall, which, by the way, has been removed. Now that is extra suspicious. The KBB website stated notices were sent sometime earlier this year but I got nothing. The registration is in my name and is 100% accurate with my address and phone number are all up to date. I found no other way to contact Ford. I didn't want to file a com

The exterior A-pillar trim part is loose causing water to leak through. You can hear/feel the air in the corner of the windshield as the SUV is moving. I have tried several times since receiving this recall notice in FEBRUARY 2024 to get this fixed and replaced through FORD. Each time brought my car in for service over the past 18 months, I was told that the part was not available but was on back order. In the meantime, water and moisture gets through causing a smell and mold. This is a health and safety issue. How do I get this repaired?

The contact owns a 2015 Ford Explorer. The contact stated that the driver’s and passenger’s side A-pillar trims were loose. The dealer had been contacted for over a year for parts availability and was informed that parts were not yet available to repair the vehicle. The manufacturer was contacted and informed the contact that parts were available, and the contact was referred to a dealer to schedule an appointment for the vehicle to be repaired under NHTSA Campaign Number: 24V031000 (Structure). The contact called the dealer again and was informed that parts were not yet available. The vehicle was not repaired. The failure mileage was approximately 119,000.

The contact owns a 2015 Ford Explorer. The contact stated that the trim on the passenger’s side A-pillar was cracked in the middle and was very loose. The contact stated that water entered the vehicle, raining and soaking the passenger’s side floor mat. The contact called several dealers and was informed that parts to repair the vehicle were not available. The contact attempted to stop the water by using silicon caulk on the trim; however the temporary fix still allowed water into the vehicle. The contact recently became aware that the driver's side trim was separating at the top of the trim, and water was entering on the driver's side. Additionally, the contact stated that the windshield gasket was crumbling along the top of the windshield. The contact stated that the manufacturer exceeded a reasonable amount of time to repair the vehicle under NHTSA Campaign Number: 24V031000 (Structure). The manufacturer was not informed of the failure. The failure mileage was approximately 136,000.

While driving with the ac on you can smell exhaust fumes in the cabin and it's worse towards the rear carbin of the vehicle. I've gotten nauseated and sleepy from the fumes and have had several headaches in addition to the other symptoms. Ford needs to recall this issue. Also I have an active recall for the window pillars and the dealership says they still dont have the parts to fix it, and it's been over a year, what's the hold up Ford??!!

I received a recall letter in February 2024 stating there was a recall on my vehicle and that the parts for fixing the recall were out of stock, and they should be available in the latter half of 2024. I never recieved another letter and the part of my vehicle that is recalled flew off my vehicle while driving on the highway it hit my rear passenger window and scared everyone in the vehicle the window didn't bust and I didn't realize that it was a piece of my vehicle that flew off until I got to where I was headed and seen the part missing, while we were driving I thought someone threw something out the window.

The back up camera only works occasionally because of the height of vehicle it is difficult to back up safely . Sometimes the camera works and other times it sends a message to contact the dealer

The contact owns a 2015 Ford Explorer. The contact stated that while driving 50-55 MPH, the vehicle lost power steering functionality. The message "Power Steering Failure -Service Immediately" was displayed. The contact was able to pull over to the side road. The contact was able to drive to an independent mechanic, where the vehicle was diagnosed and determined that the steering column needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 139,160.

The contact owns a 2015 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact heard a loud flapping sound coming from the windshield. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The vehicle was taken to the local dealer, where it was determined that the A-pillar trim had failed and needed to be replaced. The dealer ordered the parts and informed the contact that parts needed to be reordered due to the parts being damaged upon arrival. The manufacturer was not made aware of the failure. The approximate failure mileage was 130,000.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving 60 MPH, the passenger’s side A-pillar trim detached from the vehicle. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

The pillar trim recall has been in effect for nearly 2 years. I took my husband’s Explorer (I am his legal guardian as he suffered [XXX] and he has been hospitalized for over a year) to Chillicothe MO Ford in October of 2024 for the safety recall on this trim issue, as my A pillar trim flew off from the highway and may have impacted another vehicle on [XXX] between St. Joseph and Kansas City at around that time. Chillicothe Ford inspected the vehicle and ordered parts. It is now almost over a year, and neither Chillicothe Ford or Ford Corporate Office can give me an estimate on when it the parts are available. I escalated this concern yet again to Ford Corporate, and they blamed it on the Chillicothe dealership for not requesting an emergency part order. I talked to Chillicothe Ford immediately thereafter, and they said that they did escalate the part request, and nothing has been done -not just for me but over 10 other Explorer owners who are waiting on the parts for this recall. I called Richmond MO Ford dealership this week, and was informed they had the same problem and that Ford is lying about the part availability. Almost a million consumers are affected by this recall, and accordingly there are exponentially as many unfortunate drivers who could be hit by flying parts, and Ford REFUSES TO ADDRESS THIS RECALL. My sister had the same part fall off her car into traffic a month ago with her Ford Explorer. THIS IS A LIFE SAFETY ISSUE AND NHSTA NEEDS TO HOLD FORD MOTOR COMPA

The factory installed headlight screw punctured the coolant line of my 2015 Ford Explorer causing my transmission to stop working properly. This resulted in a $725 tow bill and $1,067.56 in repairs. The certified mechanic verified that the screw was an original part and it punctured the line, likely after some time rubbing against it. The transmission did not appear to be damaged however my safety was at risk trying to pull over to when the vehicle would no longer shift gears. I have a video of the leak that lines up with the screw placement but was not able to upload it...I am happy to email it to you.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving at an undisclosed speed, one of the A-pillar trims partially detached and struck the windshield. The vehicle was taken to a dealer where it was determined that parts for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 140,000.

The contact owns a 2015 Ford Explorer. The contact stated that the power steering assist was inoperable. The failure occurred while the contact’s husband was stopped for fuel. The driver turned on the vehicle and the steering wheel had seized. The engine maintenance warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the rack and pinion and steering needed to be replaced; however, the vehicle was not repaired by the dealer. The contact stated that an independent mechanic confirmed that the steering and rack and pinion needed to be replaced, but the parts were on backorder. The manufacturer was contacted, and a case was opened. The owner was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 102,000.

As I was parking my 2015 Ford Explorer Sport, a warning appeared on the instrument panel stating “Power Steering Assist Fault,” and the steering suddenly became so difficult that I was unable to move the vehicle. Although this has only happened once, I’m very concerned about the possibility of it occurring again—especially while driving on the highway. Losing the ability to steer could put my family’s lives, and the lives of others, in serious danger. I have read numerous customer complaints about this exact issue on the NHTSA website. It’s time for the manufacturer to issue a recall for these vehicles and fix the problem before someone loses their life due to this defect.

The contact owns a 2015 Ford Explorer. The contact stated while shifted to reverse, the rearview camera failed to display an image, comprising the back over prevention system. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention); but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2015 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver's and passenger's side A-pillar trims detached and flew off the front windshield. The vehicle was taken to the dealer where the contact was informed that parts were not available to repair the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 138,000. VIN tool confirms parts not available.

The contact owns a 2015 Ford Explorer. The contact stated that while driving at various speeds, the vehicle lost automotive power, with the ABS, traction control, and check engine warning lights illuminated. The vehicle was taken to a local dealer to be diagnosed, and the contact was informed that the ABS control module was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 158,443.

The contact owns a 2015 Ford Explorer. The contact stated while driving at an undisclosed speed, the passenger's side A-pillar trim detached. In addition, the contact stated that the following week the driver's side A-pillar trim detached. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure but provided no assistance. The contact referenced NHTSA Campaign Number: 24V031000 (Structure); however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 150,000.

The power steering assist in my vehicle is becoming progressively worse, I would welcome an inspection. Basically, the power steering assist will vary throughout the sweep of the steering wheel. During a turn or lane change the power steering may feel normal, be non-existent, or alternate between the 2 conditions, often requiring significant force to steer the vehicle (vehicle speed seems to make no difference.) This condition is an obvious safety risk for vehicle occupants or any other vehicles, pedestrians, or property in the vicinity. The problem has not been confirmed by a dealer or service center - I have gathered from researching various message boards that Ford will disavow the issue and tell me that I will need a new steering rack at a charge of approximately $3,000. No inspection has been done as of yet. No warning lamps or messages have presented as of yet and there are no unusual sounds accompanying the problem. The problem has been going on for approximately 3 weeks.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the driver’s side A-pillar trim had detached. The approximate failure mileage was 120,000. VIN tool confirms parts not available.

The contact owns a 2015 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the passenger’s side windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 80,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and sent a representative to the residence to inspect the vehicle. The dealer discovered that the A-pillar trim was detaching from the vehicle. The contact was informed that the parts would be ordered, and the contact would be contacted for the recall repair. The contact had not received a call back from the dealer. The vehicle was not repaired. The manufacturer was not made aware of the issue. The failure mileage was approximately 119,000. VIN tool confirms parts not available.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while driving at approximately 65 MPH, there was an abnormal tapping sound coming from the passenger’s side of the front windshield. The contact observed that the top of the trim on the A-pillar had loosened. The contact used tape to secure the trim. The failure mileage was 182,000. VIN tool confirms parts not available.

When you are in park and the car is on there is a lot of play in the steering wheel and it sounds like something is broken and when you are driving, the steering wheel and car itself starts shaking. I believe it is the rack and pinion as everything the dealer quoted it was the rack and pinion and steering box. it is now undrivable because we took it to the dealership and couldn't afford the parts and labor to fix it even though it was clearly a manufacturing issue.

THE EXTERIOR A-PILLAR APPLIQUE TRIM CLIP ATTACHMENTS ON BOTH SIDES OF MY VEHICHLE HAVE LIFTED OFF THE VEHICHLE AND THE MANUFACTURER HAS FAILED OR HAS BEEN UNABLE TO REMEDY THIS SAFETY RECALL IN A TIMELY MANNER.

My back up camera tends to go blank when I reverse. It’ll take some time for it to come back on or sometimes it says to contact ford.

Best Ford in NH stated NHTSA recall 24v031 was completed but it was not, possible fraud.

The contact owns a 2015 Ford Explorer. The contact stated that while reversing, the camera was blank. The contact stated that occasionally the camera image was distorted. The contact stated that the failure was related to NHTSA Campaign Number: 25V442000 (Back Over Prevention) however, neither the VIN nor the model year was included. The contact stated that the failure had become more prevalent. There were no warning lights illuminated. The local dealer was not contacted. The contact attempted to call the manufacturer, but the number was inoperable. The failure mileage was approximately 140,000.

The contact owns a 2015 Ford Explorer. The contact stated while driving at an undisclosed speed, the passenger’s side exterior A-pillar trim detached and flew off the vehicle. The vehicle was taken to the dealer where it was diagnosed with a detached exterior A-pillar trim, however the contact was informed that the parts were not available to repair the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 70,000. VIN tool confirms parts not available.

The contact owns a 2015 Ford Explorer. The contact received notification NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving at approximately 65 MPH, the driver’s side A-pillar trim detached from the vehicle and flew behind the vehicle. The vehicle was taken to a dealer, where it was diagnosed and determined that the driver’s side A-pillar trim needed to be replaced; however, parts were on back order. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000. VIN tool confirms parts not available.

This has happened multiple dates. I can't enter that on the next screen. Probably started 9+ months ago. My backup camera goes blank and then back on sporadically. Sometimes, when I put in reverse and sometimes when I'm in the middle of reversing. Sometimes for a couple of seconds (or more) and sometimes until I change gears and go back to reverse. I see there is a recall for some Ford explorer years and was wondering why the 2015 wasn't included. My issues sound similar to the recalled years. Putting in notice in case there are more 2015s like me experiencing likewise issues. Thank you for taking the time to review my issue. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My back up camera will work then it stops working as im backing up and says unavailable contact dealer

1-emergency brake will no longer engage, alert continues to sound while driving even though it’s not working. Took it to a mechanic and he was unable to diagnose exactly where in the emergency brake system the issue is.

My vehicle’s backup camera does not work about 98% of the time and a black screen will show up with a message saying it is not working. Once in a great while it will actually work.

See attached document for complaint.

The contact owns a 2015 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side windshield exterior A-pillar trim had detached, and the passenger's side windshield exterior A-pillar trim had separated from the vehicle. The vehicle was taken to the dealer, where it was inspected; however, the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

I own a 2015 ford and the power steering system just stopped working with abs and traction being lost as well. My husband owns a 2016 Ford F150 and has the same thing going on with his truck. I am seeing this is being reported as a common problem with Fords electric power steering.

The a pillar trim is defective and there is a currently recall. However the last updated said parts will be available in 2024. We are currently halfway through 2025 with no resolution. This is unacceptable and the manufacture needs to address this ASAP.

The contact owns a 2015 Ford Explorer. The contact stated that while driving at 60 MPH, the vehicle lost power steering functionality and the vehicle became difficult to maneuver before the steering wheel seized. The contact stated the message 'Steering Wheel Default" was displayed on the instrument panel. The contact was able to pull over to the side. The contact turned the vehicle off and after a few minutes, the vehicle was able to restart. The vehicle functioned normally for the rest of the drive. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not diagnosed or repaired due to costs. The failure was progressively worsening, and the vehicle was no longer being driven. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The contact related the failure to NHTSA Campaign Number: 14V286000(STEERING). However, the VIN was not included. The failure mileage was approximately 139,000.

The contact owns a 2015 Ford Explorer. The contact stated that while driving on the highway at 40 MPH, there was a clanking sound coming from the steering wheel. The contact stated that the steering wheel shifted to the left and the contact immediately corrected the steering wheel; however, in the process the vehicle became airborne. The contact stated that upon landing, the front driver’s, the front passenger’s, and rear driver’s side tires were deflated. The vehicle was towed to a local dealer where the vehicle was diagnosed and the contact was advised that the control arms, wheel axles, wheel bearings, rims, and tires were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.