2012 Ford Explorer complaints

POWER STEERING LOSS WHILE DRIVING. STEERING BECOMES DIFFICULT. MUST SHUT OFF CAR AND RESTART TO RECOVER POWER STEERING. HAPPENS OFTEN. TAKEN IN FOR SERVICE AND SOURCE OF PROBLEM WAS NOT ISOLATED OR FIXED. *TR

I WAS DRIVING APPROX. 35MPH AND ALL OF A SUDDEN THE WRENCH LIGHT ON THE ENGINE CAME ON I LOST ALL POWER TO THE ACCELERATOR. I HAD TO COAST TO STOP, TURN OFF THE VEHICLE, START IT BACK UP AND PROCEED. IT HAS HAPPENED 4 MORE TIMES SINCE THE ORIGINAL DATE. ONE OF THOSE TIMES WAS WHEN I WAS CROSSING AN INTERSECTION AND WAS ALMOST BROADSIDED. THIS IS VERY DANGEROUS AND IS HAPPENING WITH NO WARNING OR PATTERN. I HAVE LOOKED ONLINE AND IT SEEMS TO HAVE HAPPENED WITH MANY FORD EXPLORER OWNERS. I AM READING IT HAS TO DO WITH THE POWERTRAIN CONTROL MODULE. *TR

THE THROTTLE BOX HAS GONE BAD. THE CAR STALLS RANDOMLY WHEN TAKING OFF FROM A START AND REQUIRES A NEW THROTTLE BODY AT ONLY 47K MILES. THIS IS PART OF THE POWERTRAIN, BUT NOT COVERED BY THE WARRANTY. FORD HAD LOTS OF PROBLEMS WITH THROTTLE BODIES IN EARLIER MODELS AND IT SEEMS THEY HAVEN'T FIXED IT YET. *TR

THE POWER STEERING PUMP QUIT WORKING 2 TIMES ON MY MOTHERS SUV. VEHICLE WAS TAKEN TO FORD TWICE BECAUSE THEY DID NOT FIX IT THE FIRST TIME. SAW RECALL BUT EXPLORER WAS NOT IN THE LIST. I AM A MECHANICAL ENGINEER AND WAS DRIVING THE VEHICLE ON BOTH OCCURRENCES. IT IS MY ETHICAL RESPONSIBILITY TO REPORT THIS ISSUE. I ALSO WORK IN AUTOMOTIVE FIELD AND I KNOW THIS WAS A FAILURE OF THE POWER STEERING. I DO NOT WANT MY MOTHER OR ANY INDIVIDUAL HURT DUE TO LACK OF INVESTIGATION. I EXPECT A RESPONSE FROM YOUR ORGANIZATION. THE DEALERSHIP CAN PULL UP ALL INFO, A RENTAL WAS PROVIDED. I WAS BARELY ABLE TO MANAGE THE VEHICLE TO THE SIDE OF THE ROAD, A WEAKER DRIVER, PHYSICALLY, WOULD HAVE HAD AN ACCIDENT. *TR

WE HAVE A 2012 FORD EXPLORER WITH 46,000 MILES AT THIS TIME. ON AUGUST 30, 2014, WE WERE DRIVING ABOUT 35 MPH WHEN THE CAR LOST ALL POWER, AND THE POWERTRAIN/WRENCH LIGHT CAME ON IN THE DISPLAY. THE CHECK ENGINE LIGHT DID NOT COME ON. I PULLED TO THE SIDE OF THE ROAD WHERE THE CAR WAS SHAKING LIKE IT WANTED TO STALL. I TURNED THE CAR OFF AND BACK ON, AND IT STARTED UP FINE, AND THE WRENCH LIGHT WENT OFF. WE DROVE ANOTHER 100 MILES WHEN IT DID THE SAME THING AGAIN ON SEPTEMBER 1 GOING ABOUT 50 MPH. I TOOK IT TO THE LOCAL SHOP WHO NOTICED THAT THE VOLTAGE WAS DROPPING FROM 14 VOLTS DOWN TO 12VOLTS AND SHUTTING DOWN THE COMPUTERS (SO THEY SAID). THEY CHANGED OUT THE ALTERNATOR- $560. EVERYTHING WAS FINE UNTIL SEPTEMBER 20 WHEN THE CAR DID THE SAME THING TWICE AGAIN, ABOUT 10 MINUTES APART, GOING 70 MPH (CAR LOST POWER, WRENCH LIGHT ON, HAD TO PULL OVER AND RESTART). I TOOK IT TO THE CLOSEST FORD DEALER WITHIN 2 DAYS; THEY DROVE THE CAR 55 MILES AND COULD NOT DUPLICATE THE PROBLEM BECAUSE IT IS INTERMITTENT. THERE WERE NO ERROR CODES PRESENT. THE CHECK ENGINE LIGHT NEVER CAME ON. THEY SAID TO COME GET THE CAR AND KEEP DRIVING IT. INTERNET RESEARCH INDICATES THAT THIS IS LIKELY A THROTTLE BODY (ETB) MALFUNCTION. I CALLED THE FORD DEALER WHERE WE BOUGHT THE CAR (NOT WHERE IT WAS NOW) AND DESCRIBED THE PROBLEM TO A SERVICE MANAGER WITH 19 YEARS EXPERIENCE. HE SAID IT WAS LIKELY THE THROTTLE BODY SINCE THE CAR WOULD RESTART. HE SAID ONLY 2 THINGS TRIGGER THE WRENCH LIGHT- THE TRANSMI

MY CAR IS LESS THAN 3 YEARS OLD. AT THE TIME OF THE FIRST INCIDENT, I WAS DRIVING ABOUT 25 MPH AND MY CAR JUST SUDDENLY STALLED. I SAW AN "AWD OFF" MESSAGE ON MY DASH. I TRIED TO ACCELERATE TO PULL OVER TO THE SIDE OF THE ROAD, AND THERE WAS NO RESPONSE TO THE FOOT PEDDLE. I HIT THE BRAKES AND KILLED THE ENGINE. I WAS ABLE TO RESTART THE CAR AND CONTINUE ON TO WORK. I JUST ASSUMED THAT I HAD SOMEONE HIT THE GEAR INTO THAT MODE. BUT IT HAPPENED A 2ND AND THEN A 3RD TIME THAT SAME WEEK. I BROUGHT THE CAR IN TO THE DEALERSHIP AROUND THE MIDDLE OF AUGUST. BEFORE I BROUGHT THE CAR, I SEARCHED THE INTERNET FOR OTHER RELATED COMPLAINTS FROM FORD OWNERS. I FOUND A SITE AT WWW.CARGURUS.COM AND FOUND OUT THAT THERE ARE MANY OTHER FORD OWNERS WITH THE SAME COMPLAINT. ONE OWNER SAID THAT HIS DEALERSHIP REPLACED THE "THROTTLE BODY ASSEMBLY" AND HE HAS NEVER HAD THAT PROBLEM AGAIN. I BROUGHT THIS INFORMATION TO MY DEALERSHIP AND I PAID THEM $99.00 FOR THIS SERVICE CALL. THEY WERE NOT ABLE TO FIND OUT WHAT WAS WRONG, BUT THEY DID DO SOME SORT OF SERVICE NOTICE THAT I HAD NOT YET DONE ON MY CAR. THEY HOPED IT WOULD TAKE CARE OF THE PROBLEM AND IT DID FOR ABOUT A MONTH. BUT THIS WEEK, IT HAPPENED 5 MORE TIMES. YESTERDAY WAS THE FIRST TIME THAT IT HAPPENED TWICE WITHIN A FEW MINUTES. THIS TIME THE CHECK ENGINE LIGHT CAME ON. I HAVE THE CAR AT THE DEALERSHIP RIGHT NOW AND I AM HOPING THAT THEY WILL FIND THE THROTTLE BODY ASSEMBLY IS THE ISSUE. IF NOT, THEN I AM CONCERNED THAT THIS WILL HAPPEN A

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE WRENCH WARNING LAMP ILLUMINATED AND THE VEHICLE SUDDENLY DECELERATED. THE CONTACT DEPRESSED ACCELERATOR PEDAL REPEATEDLY BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION, DIAGNOSIS AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

ELECTRONIC THROTTLE BODY HAS FAILED AND VEHICLE WILL STALL. THROTTLE WILL NOT WORK. YOU ARE STRANDED UNTIL YOU TURN THE VEHICLE OFF AND BACK ON. *TR

SAFETY RECALL NOTICE 14S06/NHTSA RECALL 14V-286 WE RECEIVED THIS RECALL NOTICE IN THE MAIL FROM FMC. KNOWING WE HAD A TRIP COMING UP, I IMMEDIATELY TOOK THE VEHICLE IN TO KEN GARFF FORD IN UTAH FOR SERVICING AND TO HAVE THE RECALL CORRECTED. THEY SUPPOSEDLY FIXED THE ISSUE SO I WENT ON MY WAY. I DROVE A SINGLE GAS TANKS WORTH (APPX 400 MILES) AND THEN EVERYTHING WENT TO HELL. POWER STEERING FAILED, TRACTION CONTROL FAILED, TERRAIN MANAGEMENT FAILED. THIS IS THE EXACT PROBLEM FOR WHICH FORD ISSUED THE RECALL IN THE FIRST PLACE. THE FORD DEALERSHIP IS NOW TELLING ME THAT THEY COMPLETELY FIXED THE PROBLEM AND IT IS MY FAULT THAT THESE SYSTEMS FAILED. THEY WANT ME TO BELIEVE AN ELABORATE TALE ABOUT HOW I HAVE DRIVEN MY EXPLORER 72000 MILES WITHOUT A PROBLEM AND SUDDENLY, AFTER THE RECALL GETS FIXED, I THEN HAVE THAT EXACT PROBLEM? THAT IS A SNEAKY LIE THAT MIGHT WORK ON SOMEONE MORE PASSIVE. WHEN THE VEHICLE FAILED WE WERE DRIVING WITH OUR FAMILY ON A VACATION AND THIS INCIDENT STRANDED US IN MERIDIAN, IDAHO, WHERE OUR VEHICLE CURRENTLY SITS 6 WEEKS LATER. IT SEEMS TO ME THAT WHEN A SAFETY RECALL IS ISSUED AND "FIXED" IT SHOULDN'T CREATE A SAFETY ISSUE FOR THE CONSUMER ANYMORE, WHICH IS EXACTLY WHAT THIS PROBLEM CAUSED. IT ALSO SEEMS TO ME THAT IT IS AWFULLY CONVENIENT FOR FMC THAT MY CAR BROKE IMMEDIATELY AFTER IT WAS "FIXED". SO NOW I AM LIABLE FOR THE REPAIRS. HOW NICE FOR FMC. MEANWHILE, IT TOOK FMC 6 WEEKS TO GET THE PART TO THE DEALERSHIP IN IDAHO SO THEY COULD "FIX" THE IS

WHILE DRIVING AT A CONSTANT SPEED OF APROX. 35 MPH ON A CITY STREET, THE VEHICLE SUDDENLY AND DRAMATICALLY LOST SPEED. THE ACCELERATOR PEDAL / MOTOR SPEED CEASED RESPONDING AND THE ENGINE STARTED TO RUN VERY ROUGHLY. THE CAR WENT INTO "IDLE" AND I WAS FORCED TO STOP IN THE MIDDLE OF THE ROAD. THE EVENT WAS COMPLETELY UNEXPECTED. I HAD NO WARNING AND NOT ENOUGH POWER TO GET OFF THE ROAD. AN ORANGE "WRENCH" WARNING LIGHT APPEARED ON THE DASHBOARD. I TURNED OFF THE VEHICLE AND WAS ABLE TO RESTART WITH NORMAL OPERATION. I IMMEDIATELY HAD THE CAR TOWED TO THE DEALERSHIP SERVICE DEPARTMENT WHERE THEY REPLACED THE LEFT VALVE COVER. I DROVE THE CAR WITH NO PROBLEMS UNTIL 14 DAYS LATER WHEN THE SAME PROBLEM RE-OCCURRED. THIS SUDDEN AND UNEXPECTED LOSS OF VEHICLE CONTROL SEEMS TO BE A SIGNIFICANT SAFETY CONCERN. GOD HELP ME IF THIS HAPPENS WHILE I'M ON THE FREEWAY... *TR

FORD RECENTLY DECLINED TO REPAIR THE BUBBLING PAINT ON THE HOOD OF MY 2012 FORD EXPLORER ON THE BASIS IT IS OUT-OF-WARRANTY DUE TO MILEAGE. BASED ON MY RESEARCH, FORD HAS HAD CORROSION ISSUES FOR SOME TIME BUT HAS FAILED TO CORRECT THE ISSUE. *TR

THE AIR BAG LIGHT IS ON AND THE FORD DEALER SAYS THAT THE ISSUE IS RELATED TO THE CONNECTIONS THAT ARE UNDER THE SEATS. THE CONNECTIONS NEED TO BE CLEANED AND REATTACHED. THEY INDICATED THAT IT WAS CAUSED BY COOKIE CRUMBS, JUICE, ETC. PROBABLY FROM CHILDREN. I INDICATED THAT THE VEHICLE IS A 2012 AND THAT COOKIES, ETC. SHOULD NOT BE ABLE TO CAUSE A SAFETY DEVICE AS IMPORTANT AS AN AIR BAG FROM NOT WORKING. I BELIEVE THAT THIS ISSUE SHOULD BE INVESTIGATED AS IF COOKIE CRUMBS, ETC. CAN CAUSE AIR BAGS TO FAIL THEN THERE SHOULD BE AN IMMEDIATE RECALL TO ADDRESS THE ISSUE. *TR

I AM EXPERIENCING AN ODOR OF CARBON MONOXIDE INSIDE THE CAR. I LIVE IN EL SALVADOR CENTRAL AMERICA AND HAVE FOUND IN THE INTERNET THAT THERE IS A RECALL FOR THIS PROBLEM THE AGENCY IN MY COUNTRY DOES NOT RESPONSABILIZE ON THIS I HAVE SMALL CHILDREN AND WE CANT BE SMELLING THIS EXHAUST FUMENS AND STRANGE ODORS INSIDE OUR CAR. *TR

DASH REPORTS TMS FAULT, THEN AWD OFF SUCCESSIVELY. THEN CAR BECOMES UNRESPONSIVE TO THE ACCELERATOR AND SLOWS DOWN RAPIDLY. THE DASH ALSO DISPLAYS A SERVICE INDICATOR "WRENCH." DEALER REPORTS VEHICLE THROWS CODE P2112, THROTTLE BODY STUCK CLOSED. I BELIEVE THE SCOPE OF FORD CSP 13N03 IN RESPONSE TO NHTSA ACTION NUMBER PE13003 NEEDS TO BE EXPANDED OR MANY MORE DRIVERS WILL BE STUCK IN FORD VEHICLES THAT ALL BUT SHUT DOWN ON THE INTERSTATE DURING A THROTTLE BODY FAILURE. *TR

I WAS ON VACATION AND I STARTED TO GET A VERY LOUD GRINDING NOISE FROM THE REAR BRAKES EVERY TIME I STARTED I HAD TO PUT THE BRAKES ON. I DECIDED TO END THE VACATION EARLY AND HEADED HOME. BEFORE I GOT HOME I HAD TO STOP AT A FORD DEALER ABOUT 300 MILES FROM HOME. THE GUY AT THE DEALER TEST DROVE THE CAR AND THEN INSPECTED THE BRAKES. HE TOLD ME THE REAR BRAKES PADS AND ROTORS HAD TO BE REPLACED BECAUSE THEY WERE WORN TO METAL ON METAL. I HAD THEM FIX THE REAR BRAKES FOR $324.13. HE LUBED THE CALIPERS AND SINCE THEN I HAVE HAD NO PROBLEM. I THINK THE BRAKES SHOULD LAST LONGER THAN 30,550 MILE ON A $46,000 VEHICLE. *TR

RECEIVED RECALL LETTER FROM FORD TO GET MY VEHICLE IN IMMEDIATELY. CALLED SACRAMENTO DOWNTOWN FORD AND SPOKE WITH DAVID. DAVID SAID "SORRY, CAN'T HELP YOU RIGHT NOW AS THEY HAVE NOT SENT US THE PARTS OR THE SOFTWARE". HE ADDED, "CALL BACK IN A COUPLE OF WEEKS". I WAS SHOCKED THAT NOTHING WAS OFFERED. WEBSITE EVEN STATES MAY CAUSE INABILITY TO STEER YOUR CAR AND LETTER EVEN STATES MAY CAUSE AN ACCIDENT. BUT THEY CAN'T HELP ME RIGHT NOW? SO DISAPPOINTED IN FORD! IF SOMETHING HAPPENS TO ME OR MY FAMILY FORD WILL PAY.

I WAS STOPPED AND THE CAR WAS IDLING IN DRIVE (I WAS BRAKING) WHEN THE CAR BEEPED AND DISPLAYED TWO WARNINGS, ONE ABOUT POWER ASSIST FAILURE OR OFF AND THE OTHER ABOUT ADVANCETRAC SERVICE (I DON'T REMEMBER THE EXACT WORDING OF THE ERRORS). THE POWER STEERING WAS NO LONGER WORKING IN THE CAR. I PUT THE CAR IN PARK AND TURNED IT OFF AND ON AGAIN. AFTER IT TURNED ON IT STILL SAID THE ERRORS BUT I WAS ABLE TO MOVE THE STEERING WHEEL, AND WHEN I PUT IT IN DRIVE AND MOVED UP A BIT THE ERRORS ALSO WENT AWAY. I CALLED THE DEALERSHIP AND THEY WERE ABLE TO TELL ME THERE IS AN ACTIVE RECALL BUT THAT THEY DIDN'T KNOW ANYTHING ON HOW TO FIX IT WHAT IT WAS, OR ANY TYPE OF REMEDY OR REASSURANCE. THEY SAID THE SOONEST THEY COULD TAKE THE VEHICLE TO LOOK AT IT WAS A WEEK AWAY. *TR

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE LOW ENGINE OIL PRESSURE WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000. UPDATED 8/28/14*CN UPDATED 09/15/2014 *JS

I WAS DRIVING ON RT44 IN MA WHEN I NOTICED ONCOMING DRIVERS YELLING AT ME. I THOUGHT I WAS DOING SOMETHING WRONG AND WHEN I CAME TO A STOP LIGHT, THE DRIVER IN FRONT OF ME GOT OUT OF HIS CAR AND YELLED THAT MY 2012 FORD EXPLORED HAD FLAMES COMING FROM THE BOTTOM OF THE VEHICLE. I IMMEDIATELY EVACUATED THE CAR WITH MY WIFE AND CHILDREN AND MY CAR WAS INDEED ON FIRE. I HAPPENED TO HAVE A FIRE EXTINGUISHER WITH ME AND WAS ABLE TO PUT OUT THE FIRE. I WAS IN FRONT OF A FORD DEALER WHEN THIS HAPPENED AND THEY CAME OUT TO INSPECT THE CAR AND I WAS TOLD THE HEAT SHIELD WAS IGNITED FROM TOUCHING THE EXHAUST. THEY REMOVED THE PLATE AND YOU CAN SEE THE BURNT DAMAGE (I HAVE PICS). THIS SITUATION COULD HAVE TURNED FATAL AND THEY SAID THEY WILL PUT A NEW ONE ON. THIS SHOULD NOT BE ABLE TO CATCH FIRE AND IF IT WASN'T FOR OTHER DRIVERS I DON'T KNOW HOW THIS COULD OF ENDED. MY WIFE AND 3 YEAR OLD SON ARE NOW TERRIFIED TO RIDE IN THE EXPLORER. THIS NEEDS TO BE INVESTIGATED IMMEDIATELY. *JS

I HAVE BEEN SMELLING EXHAUST INTO VEHICLE CABIN, LOOKED AT FORUMS, & FOUND 62 PAGES OF COMPLAINTS BY EXPLORER OWNERS, ON WWW.EXPLORERFORUM.COM, CALLED DEALER, TOOK VEHICLE IN FOR 2 DAYS, UNDER TSB-128-12-12-4, SERVICE WORK, STILL HAVE SAME ISSUE MONTHS LATER, STILL WAITING FOR FORD TO CORRECT PROBLEM. AT PRESENT TIME A LAW SUIT HAS BEEN FILED IN FLORIDA, ARTICLE FOUND IN SUN SENNTIAL NEWSPAPER, AT WWW.SUN-SENNTIAL.COM VIDEO SHOWS CO AT 139 ACCEPTABLE LEVEL SHOULD BE 100. *TR

CAR HESITATES AFTER TURNS AND THEN AGAIN WHEN ACCELERATING AND ACTS LIKE IT DOESN'T HAVE ENOUGH POWER. CAR HAD TO BE TOWED ON A SEPARATE INCIDENT IN 2013 AFTER LOSING ALL POWER DURING A TURN; THE THROTTLE BODY - AIR INTAKE HAD TO BE REPLACED AT 24,457 MILES. THE PROBLEM IS ONGOING, SOMETHING IS WRONG WITH THE CAR. EVERY TIME I TAKE IT IN TO BE CHECKED, I GET THE SAME RESPONSE: CANNOT NOT RECREATE THE CONCERN, RAN THROUGH OASIS AND NO PROBLEM FOUND. I AM OVER FORD! THERE WAS A CUSTOMER SATISFACTION PROGRAM (AKA RECALL WITHOUT THE PRESS INVOLVED) (PROGRAM NUMBER 12B36) IN APRIL OF 2012 THAT HAD TO REPROGRAM THE VEHICLE'S PCM (POWERTRAIN CONTROL MODULE). THIS WAS DUE TO THE FACT THAT "INOPERATIVE ENGINE COOLING FANS COULD LEAD TO HIGH ENGINE TEMPERATURE GAUGE READINGS AND REDUCED AIR CONDITIONING PERFORMANCE. CONTINUED OPERATION OF THE VEHICLE COULD RESULT IN ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT (MIL) AND EVENTUALLY CAUSE THE ENGINE TO AUTOMATICALLY ENTER DERATE (REDUCED POWER) MODE." THIS WAS "FIXED" 14 MONTHS BEFORE THE CAR WAS TOWED.... *TR

DRIVING TO WORK ON JUNE 25, 2013 (20,420 MILES) ON THE HIGHWAY GOING 55 MPH WHEN A "POWER STEERING ASSIST" FAULT CODE POPPED ONTO THE SCREEN AND WITH VERY LIMITED STEERING CAPABILITIES WAS ABLE TO PULL OFF OF THE HIGHWAY, TURN OFF THE ENGINE FOR 10 MINUTES AND THE ERROR CORRECTED ITSELF. ON MAY 9, 2014 (30,513 MILES), AFTER COMING OFF A WINDING ROAD TURNED ONTO A STRAIGHT LANE, POWER STEERING ASSIST FAULT CODE POPPED UP AGAIN, WAS ABLE TO DRIVE IT HOME. ON MAY 23, 2014 (31,002 MILES), GOT INTO MY PARKED VEHICLE TURNED ON ENGINE AND THE POWER STEERING ASSIST CODE POPPED UP AND I WASN'T ABLE TO TURN THE WHEEL AT ALL, HAD TO TURN OFF THE ENGINE AND RESTART IT AGAIN. WHEN THE FIRST INCIDENT HAPPENED ON JUNE 25, I CONTACT MY LOCAL DEALERSHIP AND I WAS INSTRUCTED "IF IT HAPPENS AGAIN, BRING IN YOUR VEHICLE." FOR THE SECOND INCIDENT, I TOOK MY VEHICLE TO THE DEALERSHIP AND BECAUSE THERE WAS NO FAULT CODE SHOWING AT THAT TIME, THEY COULDN'T FIND ANYTHING WRONG AND WAS TOLD "IF IT HAPPENS AGAIN, DON'T TURN OFF YOUR ENGINE AND DRIVE STRAIGHT TO THE NEAREST DEALERSHIP SO THEY CAN RETRIEVE THE CODES." MY MAIN CONCERN IS NOT BEING TO CONTROL THE VEHICLE IF IT HAPPENS AGAIN AND CAUSING AN ACCIDENT. *TR

FORD EXPLORER 2012 WITH VIBRATION AND GRINDING SOUND IN THE STEERING COLUMN AND LOSS OF ALL STEERING. INITIALLY INFREQUENT HOWEVER AFTER TWO YEARS THE OCCURRENCE IS COMMON AT ALL SPEEDS AND ROAD CONDITIONS. I HAVE EXPERIENCED SUDDEN AND TEMPORARY LOSS OF ALL STEERING ON THE INTERSTATE HIGHWAYS. I TOOK MY VEHICLE TO THREE SEPARATE FORD DEALERS FOUR TIMES FOR THIS PROBLEM. I WAS TOLD BY THE SERVICE ADVISER THERE WERE NO DIAGNOSTIC ERRORS AND THE PROBLEM COULD NOT BE REPLICATED IN A TEST DRIVE BY THE SERVICE TECHNICIAN. WHEN I RETURNED TO MY LOCAL FORD DEALER IN MAY, 2014 I BROUGHT WEBSITE REPORTS OF OTHER DRIVERS EXPERIENCING STEERING GEAR FAILURE IN THEIR 2011 AND 2012 FORD EXPLORERS. THIS VEHICLE IS CURRENTLY WAITING AT THE FORD DEALER (OVER TWO WEEKS) FOR REPLACEMENT PARTS. *TR

ON THREE DIFFERENT OCCASIONS WITHIN THE LAST MONTH THE POWER STEERING FAULT ASSIST HAS GONE OFF. TWICE WHILE DRIVING AND ONCE WHEN FIRST STARING THE VEHICLE. I TOOK IT TO THE SHOP AND THEY DROVE IT FOR A FEW DAYS BUT CAN'T FIX THE PROBLEM UNLESS SOMETHING IS RECALLED OR THE PROBLEM HAPPENS WHILE THEY HAVE THE VEHICLE. THIS IS TO DANGEROUS OF AN ISSUE TO HAPPEN WHILE DRIVING WHEN MY TWO SMALL CHILDREN ARE IN THE CAR. *TR

IN SEPTEMBER 2013, I WAS DRIVING DOWN A NEIGHBORHOOD ROAD AT ABOUT 15-20 MPH WHEN A WRENCH SYMBOL APPEARED ON THE SCREEN AND THE VEHICLE BEGAN SLOWING TO A STOP. THE GAS WOULD NOT WORK DURING THIS TIME AND I TURNED OFF THE ENGINE. IT DID RESTART WITHOUT PROBLEMS, BUT DID IT AGAIN A LITTLE LATER. I TOOK IT IN TO MY LOCAL FORD DEALERSHIP, WHERE I LEASED THE CAR FROM. THEY LOOKED AT IT AND SAID THEY COULDN'T FIND ANYTHING WRONG, BUT COULD NOT GET CODES BECAUSE THE ENGINE HAD BEEN TURNED OFF. I WAS TOLD TO BRING IT BACK IF IT HAPPENED AGAIN. IT HAPPENED 2 MORE TIMES IN OCTOBER. BOTH TIMES WERE AT NIGHT OVER A WEEKEND WHEN THE DEALERSHIP WAS CLOSED. AGAIN, THEY LOOKED AT IT AND SAID THEY COULDN'T FIND ANYTHING WRONG, BUT RESET THE "SYSTEM" AND I WAS TOLD TO BRING IT IN IF IT HAPPENED AGAIN. NO PROBLEMS UNTIL THE NIGHT OF MAY 3, 2013. I WAS DRIVING OUTSIDE OF MCKINNEY, TX, WITH MY CRUISE SET AT 74 WHEN IT HAPPENED AGAIN. THIS REALLY SCARED ME BECAUSE I HAD JUST COME OFF OF I-75 WHERE THEY ARE DOING CONSTRUCTION AND THERE ARE CONCRETE WALLS ON EITHER SIDE OF TWO LANES WITH NO SHOULDER! SINCE YOU CANNOT CONTROL THE SPEED, AND THE ONLY WAY TO MAKE THE CAR WORK IS TO TURN THE ENGINE OFF, WAIT A FEW MINUTES, THEN RESTART IT, I HAVE NO DOUBT THAT WE (MYSELF AND 2 CHILDREN) WOULD HAVE BEEN IN AN ACCIDENT. IT IS A VERY BUSY AREA WITH SPEEDS UP TO 75 MPH AND LOTS OF SEMI-TRUCKS. I SPOKE TO THE SERVICE MANAGER AND GM OF PARIS FORD WHO BOTH AGREED TO A LOANER CAR UNTIL MINE COULD BE FIXED, AN

WHILE DRIVING DOWN THE INTERSTATE MY POWER STEERING WENT OUT. IT WAS VERY HARD TO MANEUVER MY CAR TO THE EXIT RAMP AND ALMOST IMPOSSIBLE TO TURN ON SMALLER STREETS. *TR

THE WINDSHIELD WIPERS DO NOT TURN OFF. THEY CONTINUE TO RUN UNTIL THE VEHICLE IS TURNED OFF. *TR

I BROUGHT MY CAR TO FORD FOR SERVICE. I NOTICED THAT THE PAINT ON THE HOOD WAS BUBBLING. I SHOWED IT TO THE SERVICE WRITER. HE REPORTED IT TO FORD. THEY SAID THERE IS NOTHING THEY WILL DO FOR IT. *TR

ON FRIDAY APRIL 18, 2014 MY WIFE AN I PRESTARTED THE CAR TO GO TO DINNER, AFTER ONLY 2 MINUTES THE CAR SHUT OF. UPON REVIEW OF THE ISSUE THE LOW OIL PRESSURE LIGHT CAME ON, THE STABILITY CONTROL LIGHT CAME ON, AS WELL AS HE SERVICE ENGINE SOON LIGHT. THE MILEAGE AT THE INCIDENT WAS APPROX 45,500 BUT THE COMPLAINT SAYS 44,000 BECAUSE THIS IS THE SECOND TIME IT HAS DONE THIS, AND THE FIRST TIME FOR THE STABILITY CONTROL LIGHT TO ILLUMINATE. AFTER DINNER WE CAME HOME AND ATTEMPTED TO RESTART THE VEHICLE, EVERYTHING SEEMED NORMAL, IT STARTED IT DROVE, BUT SUBSEQUENTLY WE HAD IT TOWED TO FORD, SO THEY COULD ADDRESS THE PROBLEM. *TR

THIS IS THE SECOND INCIDENT WITH THE STEERING ASSEMBLY. IN AUGUST OF 2012 MY POWER STEERING FAILED AND THE STEERING ASSEMBLY WAS REPLACED AFTER A TWO MONTH WAIT FOR PARTS. (FIRST CLUE THERE WAS A SERIOUS PROBLEM) IT WAS REPAIRED AND 6 MONTHS LATER IT HAS FAILED AGAIN. I AM A POLICE OFFICER AND WE HAVE PURCHASED FORD EXPLORERS AS PATROL VEHICLE. I HAVE WRITTEN A LETTER TO THE POLICE ASSOCIATION WITH MY CONCERNS ABOUT OFFICER SAFETY ISSUE. WHEN IS NHTSA GOING TO STEP UP TO THE PLATE AND RECOGNIZE THE SERIOUS SAFETY ISSUES WITH THIS FLAW. THIS PROBLEM COULD HAVE BEEN BURIED YEARS AGO, BUT WITH SOCIAL MEDIA THE PROBLEM IS EXPOSED. YOUR CREDIBILITY AS AN INVESTIGATIVE BODY IS CERTAINLY AT QUESTION. THE FACT RECALLS WERE FORCED ON TOYOTA AND YOU BLATANTLY IGNORE THE ISSUES WITH FORD IS AN INTEGRITY ISSUE WITH YOUR ABILITIES TO BE IMPARTIAL. MY NEIGHBORS LOST A 4 YEAR OLD SON IN THE OLD CHRYSLER MINI VAN ISSUES WITH THE REAR LATCH PROBLEM. IT WAS UNCOVERED THAT CHRYSLER WAS AWARE OF THIS PROBLEM AND WAS EXPOSED BY THE MEDIA. DEALING WITH FORD HEAD OFFICE GIVES ME THE IMPRESSION THAT THEY ARE NOT CONCERNED ABOUT CUSTOMER SAFETY OR MY CONCERNS. I WONDER HOW THEY WERE SO EMPOWERED. THERE ARE MANY ARTICLES SINCE 2012 ABOUT NHTSA INVESTIGATING THIS ISSUE. INFLUENCED BY CORPORATE POWER OR AN INEPT INVESTIGATIVE BODY. I THINK BOTH. *TR

MY WIFE WAS DRIVING OUR 2012 FORD EXPLORER DOWN THE HIGHWAY WHEN THE STEERING WENT STIFF (POWER STEERING WENT OFF), CAUSING THE VEHICLE TO SWERVE INTO THE OTHER LANE, AFTER WHICH THE TERRAIN MANAGEMENT SYSTEM FAULT LIGHT CAME ON. I HAPPENED TO BE IN OUR OTHER CAR FOLLOWING DIRECTLY BEHIND HER AND WAS ABLE TO WATCH THE INCIDENT HAPPEN. SHE IMMEDIATELY SLOWED DOWN AND STEERED THE VEHICLE TO THE SIDE OF THE ROAD. I SWITCHED VEHICLES WITH HER AND DROVE THE EXPLORER TO OUR HOUSE, WITH NO ADDITIONAL TROUBLE. AFTER RESTARTING THE VEHICLE, THE FAULT LIGHT WAS NO LONGER ON. OUR VEHICLE IS AT THE DEALER NOW, AND THEY COULD NOT FIND ANY ISSUES. I DID A GOOGLE SEARCH AND FOUND THIS WEBPAGE, WHICH CLEARLY SHOWS THAT THIS ISSUE IS WIDE SPREAD AND COULD EASILY CAUSE A FATALITY: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2012/FORD/EXPLORER/STEERING FORTUNATELY, MY WIFE WAS ONLY TRAVELING 45 MPH AND THERE WAS NO OTHER VEHICLE IN THE OTHER LANE WHEN THE CAR PULLED OUT OF THE LANE. WE HAVE NOT RECEIVED A SAFETY RECALL FOR THIS ISSUE YET, BUT WE RECOMMEND NHTSA CONTACTS FORD IMMEDIATELY TO INQUIRE ON WHAT THEY ARE DOING TO IDENTIFY THE DEFECT AND IMPLEMENT AN IMMEDIATE SOLUTION. THIS ISSUE, IF NOT CORRECTED, MAY RESULT IN A FATALITY - ESPECIALLY IF THE VEHICLE IS BEING OPERATED BY A YOUNG, ELDERLY OR DISTRACTED DRIVER. *TT

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING SUDDENLY MALFUNCTIONED MAKING THE STEERING WHEEL VERY DIFFICULT TO TURN. THE CONTACT INDICATED THAT THE DISABLED AIR BAG AND DISABLED TRACTION CONTROL SENSOR LIGHTS ILLUMINATED DURING THE INCIDENT. THE VEHICLE WAS TURNED OFF AND BACK ON SEVERAL TIMES IN ORDER TO CORRECT THE DEFECT. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT BUT NO SOLUTION WAS OFFERED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 51,805.

SLUSH ON THE WINDSHIELD PULLED THE WIPER FROM THE WIPER ARM ON THE PASSENGER SIDE MAKING ME PULL OVER ON A BUSY STREET. THE MANUFACTURED ARM IS THE CHEAPEST AND MOST UNRELIABLE ARM I'VE EVER SEEN. I CHECKED WITH OTHER 2012 FORD EXPLORERS AND THEY HAVE THE SAME ARM. THE 2013 AND 2014 HAVE DIFFERENT STYLE ARMS THAT HOLD THE WIPER ON SECURELY. I'M GOING BACK TO THE DEALER TO SEE IF THEY CAN PUT DIFFERENT ARMS ON BUT THIS DEFINITELY IS A SAFETY ISSUE. JUST BY RAISING THE WIPER ARM UP AND GRABBING THE BOTTOM OF THE BLADE THE WIPER SNAPS OFF. I WAS LUCKY NOT TO BE ON THE INTERSTATE HWY WHEN THIS HAPPENED. *TR

TL* THE CONTACT OWNS A 2012 FORD EXPLODER. THE CONTACT STATED THAT THE THIRD-ROW POWER SEAT DETECTION SYSTEM FAILED TO OPERATE PROPERLY. THE CONTACT INDICATED THAT WHILE PUTTING BAGS IN THE HATCH AREA, THE THIRD- ROW POWER SEAT BUTTON WAS ACCIDENTLY DEPRESSED AND CAUSED THE SEAT TO MECHANICALLY RISE TO THE SEATED POSITION. THE CONTACT INDICATED THAT DURING THE TRANSITION FROM THE FOLDED POSITION TO THE SEATED POSITION, A COAT AND BOOT BECAME STUCK UNDER THE SEAT. THE CONTACT INDICATED THAT THE THIRD- ROW POWER SEAT DETECTION SYSTEM DID NOT REVERSE THE DIRECTION OF THE SEAT AFTER MAKING CONTACT WITH THE OBJECTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 40,000.

ON MONDAY 10MARCH2014, MY 2012 FORD EXPLORER STARTED AND IMMEDIATELY STALLED OUT, WHEN I LOOK AT THE DASH IT HAD SAID IT HAD LOW OIL PRESSURE. THE VEHICLE WAS TOWED TO CAVALIER FORD IN CHESAPEAKE, VA WHERE IT HAS BEEN DETERMINED THAT THE HIGH PRESSURE FUEL LINE AND HIGH PRESSURE FUEL PUMP HAVE TO BE REPLACED. DURING FURTHER TROUBLE SHOOTING IT WAS DISCOVERED THAT HENDERSON FORD IN BAY ST. LOUIS, MS HAD INSTALLED A FUEL INJECTOR INTO THE ENGINE WITHOUT PROPERLY ENSURING THE CLEANLINESS OF EITHER THE INJECTOR OR THE POINT OF INSERTION. IT HAS BEEN DETERMINED BY CAVALIER FORD THAT HENDERSON FORD IMPROPERLY INSTALLED A REPLACEMENT PART, AND ALLOWED ME TO DRIVE OVER 1,000 MILES WITH THIS PROBLEMATIC PART IN PLACE! *TR

ON MONDAY MARCH 10, 2014 I STARTED THE MY 2012 FORD EXPLORER AND DROVE IT TO WORK APPROXIMATELY 2 MILES AND SHUT IT OFF, AFTER 25 MINUTES I RETURNED TO THE VEHICLE AND ATTEMPTED TO START IT. THE VEHICLE STARTED AND THEN IMMEDIATELY SHUT OFF AND SAID LOW OIL PRESSURE, I PROCEEDED TO REMOVE THE KEY AND OPEN THE HOOD. I CHECKED THE OIL AND ALL WAS WITHIN RANGE, NO ISSUE IMMEDIATELY NOTED, I CLOSED THE HOOD AND ATTEMPTED TO RESTART THE CAR. UPON THE ATTEMPTED RESTART THE CAR TOOK A SUBSTANTIAL AMOUNT OF TIME TO FINALLY TURN OVER, I IMMEDIATELY SHUT THE CAR OFF AND FIGURED IT NEEDED TO REFRESH ITSELF AND WAITED A MOMENT. AFTER RESTARTING ON THE THIRD TRY I THEN ATTEMPTED TO DRIVE IT ALL INDICATORS HAD TURNED OFF. WHILE DRIVING THE VEHICLE IT REFUSED TO ACCELERATE OVER 35MPH, I IMMEDIATELY REPORTED THE ISSUE TO FORD AND THE VEHICLE HAD TO BE TOWED TO CAVALIER FORD IN GREENBRIER, VA. *TR

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT, A GRINDING NOISE WAS HEARD WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 44,000. *TR

WHEN CAR WAS 3 WEEKS OLD, WE HAD AN INTERMITTENT GAS ODOR WHEN RESTARTING CAR. ALSO, WHEN SITTING IN GARAGE. DEALER COULD NOT REPRODUCE PROBLEM. EVENTUALLY DID AND REPLACED THE FUEL CANISTER. ODOR CAME BACK WITHIN 3 WEEKS. NOW HAS 40,000 MILES AND STILL HAVE SAME PROBLEM. SAW 2 RECALLS ON 2013 EXPLORER RELATED TO FUEL ODOR AND THOUGHT ARE 2012 WOULD BE INCLUDED, BUT FORD SAYS NO. OUR CAR WAS BUILT ON 12/15/2011. *TR

WHILE TRAVELING 70 MPH ON A HIGHWAY STEERING WHEEL LOCKED UP, POWER STEERING ASSIST LIGHT AND TRACTION CONTROL LIGHTS STARTED FLASHING. VEHICLE BEGAN TO SWERVE AS BRAKES WERE APPLIED. WAS ABLE TO COAST OFF OF HIGHWAY WITH MUCH EFFORT AND PULL INTO A PARKING LOT TO CALL FOR ASSISTANCE. VEHICLE TAKEN TO DEALERSHIP. ORIGINALLY TOLD IT "SOUNDS LIKE A SENSOR HAS GONE BAD." NOTIFIED TODAY THAT RACK AND PINION ASSEMBLY MUST BE REPLACED FOR AN APPROXIMATE COST OF $2300. BASIC WARRANTY HAS EXPIRED AND THIS IS NOT COVERED UNDER POWER TRAIN WARRANTY. THIS VEHICLE IS ONLY 2 YEARS OLD!!! ALSO NOTIFIED THAT THERE IS A RECALL ON THE SYNC SYSTEM THAT I WAS NEVER MADE AWARE OF. HAVE HAD THIS PARTICULAR VEHICLE IN THE SHOP 5 TIMES SINCE I GOT IT BUT CAN'T AFFORD TO REPLACE IT! *TR

MAY 2013 (13490 MILES) WAS DRIVING 30 35 MPH POWER STEERING WENT OUT, TRACTION CONTROL LIGHT WENT ON, I TURNED OFF AND RESTARTED. ALL WAS OK. TOOK TO DEALER AND DEALER REPLACED THE STEERING RACK DECEMBER 23,2013, (21173 MILES) WAS DRIVING 40 MPH POWER STEERING WENT OUT, TRACTION CONTROL LIGHT WENT ON. WOULD NOT RESET BY TURNING ON AND OFF. DROVE TO DEALER WITH NO POWER STEERING AND DEALER RESET COMPUTER AND SENT ME ON MY WAY. JANUARY 17,2014 (21808 MILES) WAS DRIVING 35 MPH POWER STEERING WENT OUT, TRACTION LIGHT WENT ON WOULD NOT RESET BY TURNING ON AND OFF. DROVE TO DEALER WITH NO POWER STEERING. DEALER RESET COMPUTER AND SENT ME ON MY WAY. *TR

ON DEC. 2, 2013 I WAS STOPPED ON THE SIDE OF THE ROAD WITH A SLIGHT DECLINE AT A SCHOOL BUS STOP. I PUT THE VEHICLE IN PARK (WHILE STILL ON) AND GOT OUT OF THE CAR TO RETRIEVE A FORGOTTEN ITEM FROM THE BACK FOR ONE OF THE CHILDREN (AS I HAVE DONE NUMEROUS TIMES BEFORE WITHOUT INCIDENT). WHEN I EXITED THE VEHICLE, IT STARTED TO ROLL FORWARD (WHILE STILL IN PARK). IT ROLLED OFF OF THE ROAD, DOWN AN EMBANKMENT, INTO A DITCH/RAVINE, CRASHED INTO A TREE AND ROLLED ONTO THE DRIVER'S SIDE, COMING TO REST AT AN APPROXIMATE 45 DEGREE ANGLE. MY 20-MONTH-OLD CHILD WAS IN THE CAR AT THE TIME AND WAS SEATED ON THE SIDE OF THE CAR THAT WAS IN CONTACT WITH THE GROUND WHEN THE CAR CRASHED. AFTER RETRIEVING THE CHILD (PHYSICALLY UNHARMED) FROM THE CAR WITH HELP FROM A PASSERBY, I NOTICED THE CAR WAS STILL RUNNING. THE PASSERBY AND I WENT DOWN TO TURN THE CAR OFF AND REMOVE THE KEYS, AT WHICH POINT IT WAS VERIFIED THAT THE CAR WAS IN FACT STILL SHIFTED INTO THE PARK POSITION. THE TOW TRUCK COMPANY ALSO VERIFIED THAT THE CAR WAS IN PARK WHEN THEY ARRIVED. SPEED OF THE VEHICLE AT THE TIME OF IMPACT IS UNKNOWN, AS IT STARTED FROM A STOP AND INCREASED IN SPEED AS IT CONTINUED TO ROLL FORWARD AND DOWN THE EMBANKMENT. POST CRASH, THE 20-MONTH-OLD WAS PHYSICALLY FINE, BUT EXPRESSED SIGNIFICANT EMOTIONAL ANXIETY WHEN BEING PLACED IN HIS OTHER CAR SEAT FOR SUBSEQUENT CAR RIDES. SIDE AIRBAGS ON BOTH SIDES OF THE CAR DEPLOYED, FRONT DID NOT (PRESUMABLY BECAUSE NO ONE WAS SEATED IN THE FRONT OF THE VEHICL

AFTER NUMEROUS TRIPS TO THE DEALER TO COMPLAIN ABOUT THE WAY THIS CAR WAS DRIVING MY CAR FINALLY FAILED ON AND COMPLETELY SHIFT ITSELF OFF IN THE MIDDLE OF AN INTERSECTION WHILE MAKING A LEFT TURN. I COULD NOT STEER OR ACCELERATE. I COASTED TO THE SHOULDER. TOOK THE CAR TO THE DEALER AND THEY FINALLY SAID IT WAS THE THROTTLE BODY STICKING AND REPLACED IT. LUCKILY IT WAS UNDER WARRANTY. MY PRIOR VISITS I WAS TOLD THAT THE COMPUTER SOFTWARE NEEDED TO BE UPDATED AND THAT MAYBE THE GAS I WAS PUTTING INTO THE CAR HAD TO MUCH ETHANOL. *TR

THE VEHICLE POWER STEERING AND POWER BRAKES SHUT OFF WHILE DRIVING MAKING PULLING OVER AND STOPPING VERY DIFFICULT FOR A MATURE MALE DRIVER. I FIND IT DIFFICULT I CAN ONLY IMAGINE HOW DIFFICULT AND DANGEROUS THIS COULD BE FOR MY WIFE OR ANY SMALLER OR LESS EXPERIENCED DRIVER. THIS HAPPENED MULTIPLE TIMES DURING REGULAR DRIVING ON FAIRLY SMOOTH SURFACE NORMAL CONDITIONS. *TR

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT WAS DRIVING 50 MPH WHEN THE ADVANCE TRACKING WARNING LAMP ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN THE DEALER FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE ELECTRONIC POWER ASSISTANCE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 37,000. *TR

THIS IS A CONTINUAL PROBLEM REPORT ONE 8/10/13 19,000 MILES: POWER STEERING LIGHT CAME ON AND POWER STEERING WENT OUT WHILE DRIVING VEHICLE <15 MPH AND BACK CEILING LIGHT CAME ON AND WOULDN'T GO OUT. FORD: 8/13/2013 SAID CEILING LIGHT SHORTENED OUT BATTERY AND CAUSED POWER STEERING TO GO OUT - ORDERED LIGHT BULB CAME BACK IN 3 DAYS TO REPLACE LIGHT BULB - THEY SAID POWER STEERING WAS FIXED. REPORT TWO 9/23/13 23,891 MILES: POWER STEERING LIGHT CAME ON WHILE PARKED. FORD: DID DIAGNOSTIC SAID THE ISSUE WAS MOST LIKELY WIRING AND SAID ISSUE WAS FIXED AND I LEFT WITH CAR REPORT THREE 10/02/13 24,280 MILES: POWER STEERING LIGHT CAME ON DASHBOARD AND POWER STEERING WENT OUT WHILE DRIVING ON A HIGHWAY 65 MPH, PULLED OFF HWY. REPORTED INCIDENT TO FORD. FORD: RAN DIAGNOSTIC, SAID ISSUE WAS MOTHERBOARD. ORDERED PART AND I RETURNED IN A FEW DAYS TO REPLACE COMPUTER BOARD. TOLD ISSUE WAS RESOLVED AND LEFT WITH MY CAR. REPORT FOUR 10/31/2013 25,295 MILES: POWER STEERING YELLOW LIGHT CAME ON DASHBOARD AS I STARTED VEHICLE IN PARKING LOT. POWER STEERING HAD NOT GONE OUT ONLY HAD WARNING LIGHT SHOWING. I DROVE A FEW MINUTES HOME WITHOUT THE STEERING GOING OUT. I STARTED CAR ABOUT AN HOUR LATER IN GARAGE AND POWER STEERING WAS COMPLETELY OUT. BRIGHT RED LIGHTS ON DASHBOARD. WARNING LIGHT SAID SOMETHING TO THE TUNE OF 'REPORT POWER STEERING IMMEDIATELY". FORD: KEPT CAR FOR 4 FULL DAYS WHILE WE DROVE RENTAL AND WAS TOLD THEY HAVE NO SOLUTION AND FORD REGIONAL'S ENGINEERS SUPPOSEDLY SAID 'THIS I

STEERING SUDDENLY BECAME EXTREMELY HARD AND STIFF TO THE POINT WHERE I COULD NOT MAKE A TURN OF MORE THAN 10% AT ANY SPEED. LUCKILY I WAS ONLY GOING 25MPH AT THE TIME OF THE INCIDENT SO I WAS ABLE TO GRADUALLY GUIDE THE CAR TO THE SIDE OF THE ROAD BRINGING IT TO A FULL STOP. I TRIED RESETTING THE "ERROR CONDITION" BY RESTARTING THE CAR, BUT THE STEERING BECAME ONLY MARGINALLY BETTER. I WAS HOWEVER ABLE TO DRIVE THE CAR DOWN THE SIDE STREET AT 5-10MPH TO MY HOUSE WHICH WAS A FEW SHORT BLOCKS AWAY. SINCE THE CAR WAS UNDRIVABLE, I HAD IT TOWED TO ALL AMERICAN FORD IN PARAMUS NJ, FOR SERVICE. WHERE THEY CLAIMED THAT THEY HAVE ONLY HEARD OF ONE OR TWO CASES SUCH AS MINE. I DIRECTED THEM TO THIS SITE TO HELP THEM WITH THEIR RESEARCH, WHICH THEY OF COURSE THEY WERE NOT INTERESTED IN. *TR

POWER STEERING FAILED DURING A TURN MAKING CONTROLLING THE VEHICLE DIFFICULT. WARNING LIGHTS FOR POWER STEERING ASSIST, TRACTION CONTROL AND TERRAIN MONITOR CAME ON. AFTER SHUTTING DOWN THE CAR AND RESTARTING THE VEHICLE THE PROBLEM WAS CLEARED. *TR

WHILE DRIVING ON THE HIGHWAY STEERING WHEEL BECAME STIFF AND A MESSAGE APPEARED "POWER STEERING ASSIST FAILED". VEHICLE WAS VERY HARD TO STEER BUT I MANAGED TO TURN ON FLASHERS, REDUCE SPEED AND STEER SAFELY TO THE SIDE OF THE ROAD. I TURNED THE VEHICLE OFF AND CALLED FOR ASSISTANCE. WHILE WAITING FOR HELP I RESTARTED THE VEHICLE TO TRY TO MANEUVER TO A SAFER ROADSIDE POSITION. AT THAT TIME THE POWER STEERING SEEMED TO BE WORKING AGAIN SO I DROVE CAREFULLY HOME. I THEN VISITED THE FORD DEALERSHIP WHERE NO ERROR CODES OR ERROR HISTORY WAS FOUND AND THEY FOUND NO PROBLEM AND SENT ME ON MY WAY. *TR

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE INDEPENDENTLY ENGAGED THE BRAKES. THE VEHICLE WAS DESIGNED WITH A UNIQUE BRAKING PROGRAM DESIGNED TO ENGAGE WITH THE CRUISE CONTROL WHEN THE VEHICLE WAS APPROACHING A SECOND VEHICLE. THE SYSTEM ENGAGED DESPITE THERE NOT BEING A VEHICLE IN FRONT OF THE CONTACT?S VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THERE WAS NO REMEDY FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 14,000 AND THE CURRENT MILEAGE WAS 28,000. ...UPDATED 12-24-13 *BF THE CONSUMER STATED THE ADAPTIVE CRUISE CONTROL WORKED FINE WHEN HE WAS FOLLOWING A VEHICLE IN HIS LANE. HOWEVER, WHEN HE WAS IN A SEPARATE LANE, PASSING A LARGE SEMI WITH LARGE BRIGHT ALUMINUM OR LIGHT COLORED SIDES, ON A STRAIGHT HIGHWAY WITHOUT CURVES, THE VEHICLE OCCASIONALLY APPLIED THE BRAKES AS IF HE WERE FOLLOWING IN THE SAME LANE AS THE TRUCK. THE CONSUMER BELIEVED THE RADAR SENSORS ON THE VEHICLE WERE REFLECTING FROM THE LARGE BRIGHT SIDES ON SOME TRUCKS.

THE THROTTLE BODY ON THE FORD EXPLORER FAILED AND CAUSED THE VEHICLE TO STALL SEVERAL TIMES AT VARIOUS SPEEDS FROM 15 MPH TO 60 MPH ON LOCAL STREETS AND HIGHWAYS. THE DEALERSHIP SERVICE UNIT IDENTIFIED IT AS A FAILED THROTTLE BODY. *TR