2011 Ford Explorer complaints

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 65 MPH, THE SERVICE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT WAS ABLE DRIVE TO HIS RESIDENCE. THE VEHICLE WAS TAKEN TO HAMMONASSET FORD (191 BOSTON POST RD, MADISON, CT 06443; (203) 245-8828), WHERE IT WAS DIAGNOSED WITH NEEDING THE POWER STEERING ASSEMBLY TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 73,900.

WHILE DRIVING DOWN INTERSTATE 75 FROM GAINESVILLE FL TO LOGANVILLE GA MY POWER STEERING PUMP WENT OUT ! THANKFULLY MY CHILDREN WERE NOT IN THE CAR , BUT EVEN AFTER PULLING OVER AND CUTTING THE VEHICLE OFF TO TRY TO RESET IT IT DID NOT WORK!

THE STEERING WHEEL LOCKED UP WHEN MY MOM STARTED THE VEHICLE AND TRIED TO BACK UP. TOOK IT TO FORD THEY SAID A RECALL WAS OUT ON THIS BUT FORD IS NOT COVERING IT.

DRIVEING ON RT 53 IN ADDISON IL AT 45 MPH TOTAL LOSS OF STEERING

MAKING RIGHT TURN AT TRAFFIC AIGNAL, 8:30 AM S/W/C ANTHEM WAY & DAISY MOUNTAIN ANTHEM AS 85086 LOSS POWER STEERING. WARNING LIGHT CAME ON STATING POWER STEERING ASSISTANCE LOSS

MY POWER STEERING TOTALLY WENT OUT. IT KEPT SAYING POWER STEERING FAULT AND JUST STOPPED WORKING. THEN IT STARTED SAYING SOMETHING ABOUT TRAC TERRAIN FAULT OR SOMETHING. I'VE ONLY HAD THIS CAR SINCE 2018 AND THEN FOUND OUT TODAY THERE WAS A RECALL ON THEM FOR POWER STEERING. WE BOUGHT OUR CAR IN OKLAHOMA AND NOW LIVE IN ALABAMA. THE POWER STEERING HAS BEEN WEIRD ON ME BEFORE BUT TURNING OFF THE CAR AND RESTARTING IT WOULD FIX IT, BUT IT HAS WENT OUT SAYING FAULT WHILE I WAS GOING AROUND A TURN AND I HAD TO BRAKE QUICKLY, THROW ON MY HAZARDS, TURN OFF THE CAR AND RESTART IT. BUT NOW NOTHING IS FIXING IT, I HAD TO TOW IT TO MY HOUSE FROM AN HOUR AWAY BECAUSE I WAS STUCK AT WORK AT 1AM. I AM THE ONLY PERSON IN MY FAMILY ABLE TO WORK AND WORK ABOUT 52HOURS A WEEK AND DON'T KNOW I CAN AFFORD TO FIX THIS ISSUE THAT APPARENTLY WAS KNOWN BUT NOT FIXED IN MY VEHICLE BEFORE IT WAS SOLD TO ME (NOT YOUR FAULT, THE DELEARSHIPS FAULT, BUT THEY ARE 10 HOURS AWAY...)

AS I WAS IN MOTION DRIVING MY SERVICE POWER STEERING LIGHT CAME ON AND ABOUT 30 SECONDS LATER I LOST ALL POWER STEERING CAUSING MY VEHICLE TO SWERVE TO THE LEFT. I WAS ABLE TO STOP THE VEHICLE. THE VEHICLE IHAS HAS THIS ISSUE OF LOOSING POWER STEERING IN THE PAST AUGUST OF 2019 AND THE POWER STEERING RACK WAS REPLACED FEBRUARY OF 2018. I HAVE TAKEN MY VEHICLE INTO THE LOCAL FORD DEALERSHIP IN 2019 AND WAS ADVISED IT NEEDED A NEW POWER STEERING RACK AT MY COST! I HAVE SINCE HAD THIS ISSUE AGAIN NOVEMBER 3RD. I HAVE CONTACTED FORD AND THE DEALERSHIP IN 2019 CREATED A FRAUD CLAIM FOR REPROGRAMING THE CLIMATE CONTROL MODULE NOTHING WITH THE ISSUE THAT I INITIALLY BROUGHT IN WITH. IM SCARED FOR THE SAFETY OF MY FAMILY IN THIS VEHICLE AND THE UNETHICAL CLAIM BARNES BAKER AUTOMOTIVE OF TRENTON, MO HAS CLAIMED. MY VEHICLE IS NOT SAFE TO DRIVE AT THIS TIME AND I HAVE CONCERNS THAT THE SUSPENSION RECALL HAS EVEN BEEN PREFORMED. THE RECALL FOR THE POWER STEERING HAS BEEN PERFORMED BUT, IS AN ONGOING PROBLEM FOR MY VEHICLE. FORD IS CLAIMING THIS IS NOT A RECALL RELATED ISSUE WHICH THIS VEHICLE HAS HAD A ONGOING P[ROBLEM WITH THE POWER STEERING LOCKING UP. THIS ALMOST CAUSED AN ACCIDENT!

POWER STRESSING WENT OUT ALONG WITH WARNING NOTICES OF SELECT TRACK SERVICE REQUIRED

MY AIR BAG CONTROL LIGHT CAME ON 3 YEARS, I TOOK THE VEHICLE TO THE FORD DEALERSHIP A D THEY DISCOVERED THE SEAT BELT PRETENSIONER HAD SHORTED OUT. IT WAS REPLACED AT MY EXPENSE. FAST FORWARD TO TODAY AND THE SAME LIGHT IS BACK ON FOR WHAT I IMAGINE IS THE SEAT BELT PRETENSIONER AGAIN! THE LIGHT STAYS ON FROM THE TIME THE CAR IS STARTED TILL IT'S TURNED OFF.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING IN DRIVEWAY AT LOW SPEEDS, THE STEERING WHEEL WAS FIRM AND HARD TO TURN HOWEVER, AFTER SHIFTING TO PARK AND RESTARTING THE VEHICLE, THE STEERING WORKED AS DESIGNED. THE POWER STEERING ASSIST WARNING LIGHT WAS ILLUMINATED. THE CONTACT CALLED FAMILY FORD, INC., (30 NJ-183, NETCONG, NJ 07857, (973) 347-3000) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT STATED THAT THE FAILURE WAS LIKE THE FAILURE MENTIONED IN NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING). THE FAILURE MILEAGE WAS 77,022.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE CONTACT ENTERED AND STARTED THE VEHICLE. THE VEHICLE WAS SHIFTED INTO REVERSE HOWEVER, WHILE TURNING THE STEERING WHEEL THE VEHICLE FAILED TO OPERATE AS DESIGNED. THE POWER STEERING WARNING LIGHT BECAME ILLUMINATED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT SPOKE WITH A REPRESENTATIVE AT TONY SERRA FORD (40905 HIGHWAY 280, SYLACAUGA, AL 35150 (256) 245-5000) AND WAS INFORMED THAT THE VEHICLE WAS NOT UNDER RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED WHILE HIS WIFE WAS STARTING THE VEHICLE, THE POWER STEERING WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AL PACKER FORD ROYAL PALM BEACH LOCATED AT 10601 SOUTHERN BLVD, ROYAL PALM BEACH, FL 3341, (561) 790-1100, WHERE IT WAS DIAGNOSED WITH NEEDING STEERING BOX TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING) HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,000.

TERRAIN MANAGEMENT AND SERVICE TRAC LIGHT IS ON AND MY STEERING WHEEL IS UNABLE TO TURN

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE STEERING WHEEL SEIZED WITH THE SERVICE ADVANCE TRAC WARNING LIGHT ILLUMINATED. THE CONTACT REGAINED CONTROL OF THE STEERING WHEEL AND VEER TO THE SHOULDER OF THE ROADWAY. THE CONTACT TURNED THE VEHICLE AROUND AND DROVE BACK TO HER RESIDENCE. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER TO BE DIAGNOSED. THE MECHANIC DETERMINED THAT THE RACK AND PINON FAILED AND NEEDED TO BE REPLACED. THE FAILURE RECURRED INTERMITTENTLY. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED AND INFORMED THAT THE WARRANTY WAS EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

AS A REPAIR SHOP OWNER, THE VEHICLE OWNER STATED THAT THERE WAS A STRONG FUEL ODOR AFTER FILLING THE FUEL TANK. I NOTICED FUEL STAINS FROM THE TOP OF THE TANK SO I REMOVED THE TANK AND FOUND FUEL LEAKING FROM THE FUEL PUMP MODULE. I FOUND THE STEEL LOCK RING RETAINING THE MODULE TO THE PLASTIC FUEL TANK HAD RUSTED AND THE RESULTING RUST 'BLOOM' HAD CRUSHED THE PLASTIC FLANGE CAUSING THE FUEL LEAK. I HAVE NOTICED THIS ON ANOTHER CAR ( 2007 DODGE GRAND CARAVAN, VIN [XXX]) JUST LAST WEEK WITH THE SAME ISSUE. AFTER SHARING THE PICTURES WITH A DIAGNOSTIC DISCUSSION GROUP, OTHERS HAVE SEEN THIS AROUND THE COUNTRY AND CANADA, ESPECIALLY IN THE "RUST BELT" STATES. THIS ISSUE SEEMS TO APPLY TO ANY FUEL SYSTEM WITH A PLASTIC FUEL PUMP MODULE AND A STEEL LOCK RING IN A RUST PRONE AREA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE STEERING IS KNOCKING WHEN TURNING WHEN STATIONARY AND WHEN IN MOTION. THE STEERING LOCKS IN MID TURN WHILE IN MOTION.

HAZARD LIGHTS CUT ON BY THEIRSELVES WHILE I WAS AT WORK. VEHICLE WAS PARKED AND SHUT OFF. LIGHTS WILL NOT TURN OFF

POWER STEERING FAILED FOR THE SECOND TIME IN 4 YEARS

I WAS GETTING READY TO LEAVE WORK AND I PUT MY CAR IN REVERSE THAT'S WHEN MY POWER STEERING ASSIST MALFUNCTIONED. IT HAS DONE THAT BEFORE AND I WOULD JUST PUT IT IN PARK SHUT IT OFF THEN RESTART IT AND IT WOULD BE FINE. I'VE TALKED TO MY LOCAL DEALERSHIP ABOUT GETTING IT FIXED BECAUSE IT'S A RECALL ONLY FOR THEM TO TELL ME THAT IT'S A CLOSED RECALL. AND THEY DIDN'T TELL ME THAT BEFORE I BROUGHT IT IN AND THEY'RE WANTING ME TO PAY $77 FOR THE DIAGNOSTICS TEST NOW.

WAS BACKING OUT OF A PARKING SPACE WHEN I COULDN'T TURN THE WHEEL AND HAD THE POWER STEERING ASSIST FAULT ALERT COME ON THE DASHBOARD.

WHILE DRIVING WITH MY 3 YOUNG KIDS ON A BUSY ROAD, MY WATER PUMP FAILED AND CATASTROPHICALLY DAMAGED MY ENGINE. MY CAR TURNED OFF WHILE DRIVING, WITH NO WARNING. WE WERE ALMOST INVOLVED IN A HORRIBLE CAR ACCIDENT BECAUSE OF THIS. THE CAR BEHIND ME HAD TO MAKE AN ABRUPT STOP. HAD HE HIT MY CAR, WE WOULD HAVE SPUN BECAUSE OF THE FORCE. THE WATER PUMP FAILS AND BECAUSE IT'S INSIDE THE ENGINE, IT DAMAGES THE ENGINE IN SECONDS WITHOUT PRIOR WARNING. THIS TYPE OF PROBLEM PUTS PEOPLE'S LIVES IN DANGER, ESPECIALLY THOSE OF KIDS. LEAVES YOU STRANDED IN THE MIDDLE OF A HIGH TRAFFIC STREET. WITHOUT WARNING THERE IS NO WAY WE CAN PREVENT PUTTING OUR LIVES IN DANGER THIS WAY. FORD STATES THAT WATER PUMPS SHOULD LAST THE LIFE OF THE ENGINE AND ITS MANUAL DOESN'T STATE THAT THE WATER PUMP NEEDS TO BE REPLACED AFTER CERTAIN MILES. REPAIR SHOP IS QUOTING 6,000 FOR A NEW ENGINE.

THE STEERING FAILED WITH ASSOCIATED STEERING FAIL MESSAGE WHILE MAKE A LOW SPEED TURN MAKING IT VERY DIFFICULT TO CONTROL THE VEHICLE.I DELIVERED THE VEHICLE TO THE DEALER AS I DISCOVERED THERE WAS AN OPEN RECALL (14S06 & 15N01) ON IT FOR THIS PROBLEM. THE DEALER STATED THAT ALTHOUGH MY VEHICLE VIN WAS SUBJECT TO THESE RECALLS, FORD DENIED THE RECALL COVERAGE AS THE MILEAGE EXCEEDED PROGRAM TERMS BY 7,000 MILES. FURTHER REVIEW OF FORDS LETTER TO DEALERS DATED MAY 17, 2019, THE LETTER STATED THAT THE REPAIR WOULD BE COVERED "REGARDLESS OF MILEAGE OR WARRANTY. THIS WAS STATED IN SUPPLEMENT #3 TO THE SAFETY RECALL 14S06.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE LOSS POWER STEERING ASSIST AND BECAME DIFFICULT TO STEER. THE CONTACT THE SERVICE POWER STEERING WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. STERLING MCCALL FORD LOCATED AT 6445 SOUTHWEST FWY, HOUSTON, TX 77074, (281) 588-5000, WAS CONTACTED AND MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.

VEHICLE TURNS OFF AUTOMATICALLY WHILE IN MOTION. COMPLETE SHUT OFF

I HAVE A 2011 FORD EXPLORER LIMITED, AT RANDOM TIMES WHILE DRIVING IT WILL MAKE A GRINDING NOISE, THE VEHICLE WILL SLOW DOWN AND THEN THE TRACTION CONTROL LIGHTS WILL FLASH. IF THE TRACTION CONTROL LIGHTS STOP FLASHING THE VEHICLE WILL PICK UP SPEED AND DRIVE NORMAL BUT IF THE TRACTION CONTROL LIGHT CONTINUES TO FLASH FOR A LONG TIME EVENTUALLY THE TRACTION CONTROL SYSTEM WILL DISABLE AND THEN THE WARNINGS LIGHTS WILL SAY SERVICE ADVANCE TRAC AND COLLISION WARNING MALFUNCTION WARNING. IF I LET THE VEHICLE SIT FOR HOURS IT MAY RESET BUT IT HAS CONTINUED TO DO SO AT RANDOM TIMES AND SPEED. *TR

THERE IS CURRENTLY A RECALL FOR FORD EXPLORES 2011-2013. THE RECALL IS LISTED AS 14S06. I WAS TOLD BY FOR CUSTOMER SERVICE THAT MY VIN NUMBER IS NOT COVERED IN THAT RECALL. I WOULD LIKE TO APPEAL THAT. IN JANUARY 2020 MY POWER STEERING FAILED AND MY VEHICLE HAD TO BE TOWED TO A SHOP AND THE STEERING RACK AND ASSEMBLY HAD TO BE REPLACED. THIS COST ABOUT 3K IN OUT OF POCKET COSTS FOR ME TO REPAIR. LESS THEN 3 MONTHS LATER MY POWER STEERING FAILED AGAIN. THIS RESULTED IN MY VEHICLE HAVING TO BE TOWED TO THE SHOP AGAIN I WAS THEN TOLD THAT THE POWER STEERING CONTROL MODULE NEEDED TO BE UPDATED AND IT WAS ANOTHER ALMOST $400 FOR THEM TO UPDATE THE MODULE. ALL OF THE ABOVE ISSUES ARE THE SAME ISSUES LISTED IN THE RECALL UNDER 14S06. THE ONLY ISSUE IS MY VIN NUMBER IS NOT ASSOCIATED WITH THE RECALL. I'D LIKE TO APPEAL THE DECISION THAT DID NOT INCLUDE MY VEHICLE IN THE VIN LISTING FOR THIS RECALL. *TR

WHEN TURN CAR ON POWER STEERING FAULT LIGHT COMES ON AND I CAN NOT TURN STEERING WHEEL. LIKE IT IS LOCKED UP. TRY NUMEROUS TIMES BY TURNING CAR OFF AND NOTHING CHANGES. I WAS IN MY WORK PARKING LOT TRYING TO BACK OUT OF A PARKING LOT WHEN IT HAPPENED. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 8 MPH, THE VEHICLE LOSS POWER STEERING ASSIST WITHOUT WARNING. THE CONTACT TURNED OFF THE VEHICLE, AND WHEN RESTARTED THE POWER STEERING FAULT MESSAGE ILLUMINATED. THE VEHICLE WAS DRIVEN TO MURRAY FORD OF KINGSLAND (2030 GA-40, KINGSLAND, GA 31548). THE CONTACT WAS INFORMED THAT THE FAILURE WAS PREVIOUSLY COVERED UNDER A CUSTOMER SATISFACTION PROGRAM HOWEVER, THE MILEAGE WAS EXCEEDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,980.

POWER UNIT ASSIST FAULT. POWER STEERING FAILED WITH MY WIFE DRIVING AND SHE WAS LUCKY TO NOT HAVE AN ACCIDENT. I FOUND THAT THERE IS A RECALL THAT WAS ISSUED FOR THIS YEAR AND MODEL BUT FOR SOME REASON OUR VEHICLE IS NOT INCLUDED IN THIS RECALL. IT IS THE EXACT ISSUE AS SPECIFED IN THE RECALL. MY WIFE WAS DRIVING ON BACK FROM THE STORE WHEN THIS FAILED. SHE WAS ABLE TO PULL OFF THE ROAD WITH SOME EFFORT AND NOTICED THE FAULT LIGHT ON THE DASH. SHE CALLED ME AND I TOLD HER TO STOP AND RESTART THE CAR. SHE DID BUT THE FAULT STILL SHOWS. THE CAR IS ALMOST IMPOSSIBLE TO DRIVE IN THIS CONDITION AND A SAFETY HAZARD.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE OVERHEATED AND LOSS MOTIVE POWER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS DESIGNED, THE WATER PUMP WAS PLACED ON THE INSIDE OF ENGINE. THE CONTACT STATED THAT WHEN THE WATER PUMP FAILED, COOLANT ENTERED THE ENGINE WHICH CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS NOT REPAIRED. JEFFERSON MOTOR CO INC, LOCATED AT 141 LEE ST, JEFFERSON, GA 30549, (706)367-5217, WAS CONTACTED HOWEVER, THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED AT A COST OF $8,000. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.

WHEN DRIVING ON THE HIGHWAY AND MY VEHICLE REACHES 50MPH, I EXPERIENCE HESITATION AND/OR A PUTTING SENSATION THAT CONTINUES UNTIL I ACCELERATE TO 60MPH OR DROP TO 49MPH OR BELOW. WHEN I TOOK THE VEHICLE TO KOONS FORD OF BALTIMORE FOR SERVICE, THEY DETERMINED THAT THE PROBLEM STEMS FROM THE FACT THAT OIL HAS BEEN SEEPING INTO MY AIR INTAKE SYSTEM AND SATURATING MY AIR FILTER. I WAS TOLD THAT IT IS DUE TO THE DESIGN FLAW ON THE FACTORY INSTALLED VALVE COVER GASKET. I LEARNED THAT THE ISSUE OCCURS ON SEVERAL FORD VEHICLES INCLUDING 2011-2013 EXPLORERS AS THE DEFECTIVE VALVE COVER WAS USED ON THOSE MODELS AT THE TIME THE VEHICLES WERE MANUFACTURED. IN ORDER TO CORRECT THE PROBLEM I WOULD NEED TO HAVE THE EXISTING VALVE COVER REPLACED WITH A NEWLY DESIGNED VALVE COVER THAT WAS SPECIFICALLY CREATED TO RESOLVE THE OIL LEAKAGE/OIL SEEPAGE ISSUE. MY AFTERMARKET WARRANTY WILL NOT COVER THE REPAIRS AS THEY DEFINE THE REPLACEMENT PART AS "BETTERMENT" TO THE VEHICLE OR INSTALLATION OF AN UPGRADED PART. ACCORDING TO THE SERVICE ADVISOR AT KOONS, THE VALVE COVER INSTALLED WHEN THE VEHICLE WAS MANUFACTURED IS OBSOLETE AND WOULD NOT RESOLVE THE ISSUE EVEN IF IT WERE STILL AVAILABLE. I MUST HAVE THE NEWLY DESIGNED VALVE COVER INSTALLED IN ORDER TO PREVENT FURTHER DAMAGE, STOP THE OIL FROM SEEPING IN AND AROUND THE AIR INTAKE SYSTEM AND THROTTLE BODY AND TO ALSO PREVENT CONTAMINATION OF THE MASS AIRFLOW SENSOR. THE COST FOR THE REPAIRS IS APPROXIMATELY $700. I CONTACTED THE FORD CORPORATE OFFIC

LACK OF POWER STEERING ASSIST, THE STEERING EFFORT IS GREATER, ESPECIALLY AT LOW SPEEDS. AFTER AN APPOINTMENT (FOR RECALL) THE VEHICLE IS COMPLETE LACK. THE VEHICLE WAS NOT REPAIRED AND NOT DRIVABLE AND THEY'RE ASKING FOR 5.0 HOURS OF DIAGNOSTIC.

THE INTERFACE MODULE ON FORD EXPLORER STOP WORKING AND HAZARD LIGHTS STAY ON AND ONLY FIX AND BY A DEALERSHIP

MY SON WAS DRIVING AND MADE A U TURN ON A CITY STREET AND DURING THE END OF THE U TURN THE PASSENGER CONTROL ARM SNAPPED NEAREST TO THE WHEEL. THE CAR DID NOT HIT A CURB OR RUN OVER ANYTHING TO CAUSE THE BREAK. THE LOCAL POLICE DEPT, TOW TRUCK DRIVER AND MYSELF INSPECTED THE AREA AND THERE WAS NOTHING THAT WAS "HIT" TO CAUSE THIS. ONCE THE MECHANIC WAS ABLE TO LOOK AT THE CONTROL ARM WHEN IT WAS ON THE HOIST THEY POINTED OUT TO US THAT THE METAL CONTROL ARM WAS DEFECTIVE WHEN IT WAS CAST OR WASN'T FABRICATED CORRECTLY. THE METAL WAS LESS DENSE AND MORE HOLLOW ON ONE SIDE OF THE BREAK THAN THE OTHER SIDE. THE BREAK WAS A CLEAN BREAK WITHOUT JAGGED EDGES. THIS WAS THE CAUSE OF THE BROKEN CONTROL ARM. WE WHERE LUCKY SINCE MY SON DRIVES THE FREEWAY AT 65MPH SPEEDS ALMOST ON A DAILY BASIS AND IF THIS FRONT CONTROL ARM BROKE AT THOSE SPEEDS HE WOULD HAVE LOST CONTROL OF HIS CAR AND CAUSE A MAJOR ACCIDENT AND THERE COULD HAVE BEEN A LOSS OF LIFE. WE HAD ROUTINE MAINTENANCE WORK DONE ON THE CAR IN OCTOBER AND THE MECHANIC SAID HE SAW NOTHING WRONG WITH THE CAR THEN AND SUGGESTED THAT SINCE THE DRIVER SIDE CONTROL ARM WAS ALSO AN ORIGINAL PART AND PROBABLY CAST AT THE SAME TIME AND USING THE SAME METHODS THAT IT WAS ONLY A MATTER OF TIME BEFORE THE DRIVER SIDE CONTROL ARM GAVE OUT SIMILARLY. WE OPTED TO PAY THE ADDED COST TO REPLACE BOTH FRONT CONTROL ARMS SINCE OUR SON'S SAFETY IS PARAMOUNT.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED WHILE HIS WIFE WAS DRIVING AT 35 MPH, THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES BEFORE THE VEHICLE CAME TO A STOP. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS INFORMED THE EXTENDED TRAVEL PLAY NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE BRAKES WERE REPLACED TWICE HOWEVER, THE VEHICLE STILL EXPERIENCED THE FAILURE. THE VEHICLE WAS TAKEN TO LOCAL DEALER (SHAWNEE MISSION FORD LOCATED AT 11501 SHAWNEE MISSION PKWY, SHAWNEE, KS 66203), AND THE SERVICE MANAGER WAS INFORMED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE AFTER STARTING THE VEHICLE THE FRONT WINDSHIELD WIPERS INDEPENDENTLY ACTIVATED CAUSING A VISIBILITY HAZARD TO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER SAM SCISM MOTORS (5019 FLAT RIVER RD., FARMINGTON MO) AND THE MANUFACTURER WERE BOTH NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 55MPH, UNKNOWN WARNING LIGHTS ILLUMINATED AND THE POWER STEERING FAILED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE SAFELY HOME. THE CONTACT SCHEDULED A DIAGNOSTIC APPOINTMENT AT A DEALER (FINLEY MOTORS 942 3RD ST SE, MAYVILLE, ND 58257). THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE 170,000.

EXPERIENCED LOSS OF ELECTRIC POWER STEERING ASSIST WHILE DRIVING ON WINDING MOUNTAIN ROAD WITHIN 11 MONTHS OF HAVING RECALL 14S06 PERFORMED ON VEHICLE. WAS INFORMED BY FORD SERVICE THAT CAUSE WAS FAILURE OF PART REPLACED TO RESOLVE RECALL 14S06.

WE'VE HAD OUR 2011 FORD EXPLORER FOR LESS THAN A YEAR. WE BOUGHT IT USED WITH APPROXIMATELY 130,000 MILES ON IT, IT NOW CURRENTLY HAS APPROXIMATELY 190,000 MILES. WE WERE ABOUT TO LEAVE OUR HOUSE, SO THE EXPLORER WAS STATIONARY AT THE TIME. I STARTED IT UP AND IMMEDIATELY AN ERROR POPPED UP ON THE DASH FOR "POWER STEERING FAULT" AND "ADVANCETRAC" WARNING. I ATTEMPTED TO DRIVE THE VEHICLE, BUT WITHOUT POWER STEERING I WOULD BE PUTTING MY FAMILY AND MYSELF IN DANGER. LUCKILY THIS HAPPENED WHILE THE VEHICLE WAS STATIONARY. IF MY WIFE WERE OUT DRIVING AND THIS HAPPENED, IT COULD HAVE BEEN VERY BAD FOR HER AND MY KIDS. WE SET UP AN APPOINTMENT THE FORD DEALERSHIP IN OUR TOWN, THEY FOUND THAT THE POWER STEERING RACK NEEDED TO BE REPLACED AND TOLD US THAT IT WOULD COST ~$2100. I TOLD THEM IT SHOULD BE COVERED BECAUSE OF A RECALL I FOUND ONLINE FOR THIS PROBLEM. THEY TOLD ME TO CALL FORD CUSTOMER SERVICE. MY WIFE CALLED AND THEY TOLD HER THERE WAS NOTHING THEY COULD DO. I PROCEEDED TO CALL BACK THE FORD CUSTOMER SERVICE AND SPOKE TO A REP. AFTER GETTING THE RUN AROUND HE FINALLY GAVE ME A CASE NUMBER TO GIVE TO THE FORD DEALERSHIP, EXPRESSING THAT THIS WOULD BE FULLY COVERED UNDER A FIELD SERVICE ACTION #: 15N01 FOR EPAS STEERRING EFFORTS, WITH NO COST TO ME. I GAVE THE CASE NUMBER TO THE FORD SERVICE REP. TODAY I GET A CALL BACK THAT THE CASE NUMBER IS DECLINED BY FORD BECAUSE OUR VEHICLE HAS OVER 150,000 MILES ON IT. WE NEVER GOT A RECALL NOTICE IN THE MAIL OR A CALL FROM FORD MENT

POWER STEERING QUIT WORKING. VEHICLE CONSOLE DISPLAYED 'POWER STEERING ASSIST FAULT'. FORD DEALERSHIP WOULD NOT REPAIR SINCE OUR VEHICLE WAS OVER 150,000 MILES. MILEAGE WAS 175,000 WHEN IT STOPPED WORKING.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 55 MPH, THE POWER STEERING ASSIST FAULT WARNING INDICATOR ILLUMINATED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS POWERED OFF AND RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED BEDFORD FORD LINCOLN (6985 LINCOLN HWY, BEDFORD, PA 15522, (814) 623-8154) AND SCHEDULED AN APPOINTMENT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 153,494.

AFTER DRIVING FOR A LITTLE WHILE AND THEN STOPPING AT A STOP LIGHT I SMELL EXHAUST COMING IN THROUGH THE VENT.I ONLY NOTICE IT WHEN AT A STOP.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WATER FROM THE MOON ROOF CAUSED THE WINDSHIELD TO FREEZE. THE VEHICLE WAS TAKEN TO LEVITTOWN FORD (3195 HEMPSTEAD TURNPIKE, LEVITTOWN, NY 11756, (516) 336-4718), BUT WAS NOT DIAGNOSED OR REPAIRED DUE TO THE COST. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,800.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO JONES FORD CASA GRANDE (1932 N PINAL AVE, CASA GRANDE, AZ 85122, (520) 836-3100) WHERE IT WAS DIAGNOSED THAT THE ENGINE BLOCK WAS MIXING WITH THE OIL. THE VEHICLE WAS REPAIRED. ON ANOTHER OCCASION, THE POWER STEERING WAS LOCKING CONSISTENTLY, AND THE INTERLOCK AND ADVANCETRAC WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER AND WAS REPAIRED AGAIN. THE CONTACT STATED THAT THE POWER ASSIST WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE SAME DEALER WHERE THE GEARS AND ALIGNMENT WERE RESET. THE CONTACT ALSO MENTIONED THAT THE CHECK ENGINE WARNING INDICATOR CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE IT WAS DETERMINED THAT AN UNKNOWN PART NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE CONTACT STATED THAT THE FUEL FILTER NECK ASSEMBLY ALSO NEEDED TO BE REPLACED. THE EVAPORATOR CANISTER WAS REPLACED AND THE TECHNICIAN INFORMED THE CONTACT THAT THE FUEL TANK WAS LEAKING FUEL. THE VEHICLE WAS NOT REPAIRED BECAUSE THE FUEL TANK WAS NO LONGER MANUFACTURED BY FORD. THE CONTACT STATED THAT THE VEHICLE REMAINED AT THE DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

LOSS POWER STEERING, STEERING WHEEL LOCKED WHEN ATTEMPTING TO BACK UP FROM PARKING SPACE. COULD NOT STEER WHEEL IN THE DIRECTION TO BACK OUT OF THE PARKING SPACE.

TL* THE CONTACT'S WIFE OWNS A 2011 FORD EXPLORER. WHILE DRIVING 10 MPH, THE STEERING WHEEL SEIZED AND THE POWER ASSIST WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO RANDALL FORD (5500 ROGERS AVE, FORT SMITH, AR 72903, (479) 452-1311). THE DEALER STATED THAT THE POWER STEERING RACK NEEDED TO BE REPAIRED BEFORE REPROGRAMMING THE MODULE, AND THAT THE VEHICLE WAS OVER THE WARRANTY MILEAGE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT ANYTHING OUTSIDE OF THE RECALL REPAIR WOULD HAVE TO BE PAID OUT OF POCKET. THE FAILURE MILEAGE WAS 151,000.

LOSS OF POWER STEERING. THERE IS A RECALL FOR THIS CONCERN FOR MY MODEL YEAR BUT MY VIN IS NOT INCLUDED.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 40 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED; HOWEVER, THE VEHICLE WAS SLUGGISH AND LOST POWER. ALSO, THE BRAKES AND STEERING BECAME INOPERABLE AND THE OIL PRESSURE AND CHECK ENGINE WARNING INDICATORS WERE ILLUMINATED. THE CONTACT ALSO HEARD AN ABNORMAL CRANKING NOISE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE WATER PUMP FAILED AND OIL WAS IN THE COOLANT. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 131,000.

THERE IS A EXTREME EXHAUST SMELL THAT COMES IN MY TRUCK WHENEVER I TURN THE HEAT ON. THE EXCESSIVE FUMES ARE CAUSING MY CHILDREN AND ME TO EXPERIENCE DIZZINESS AND HEADACHES. THE SMELL ONLY COMES IN THE TRUCK WHEN THE HEAT IS ON. THE SMELL IS STILL STRONG EVEN WHEN I CRACK THE WINDOWS. IT'S UNBEARABLE AT THIS POINT AND I'M AFRAID I MAT EXPERIENCE AN ACCIDENT, BECAUSE I'M BECOME SO LIGHTHEADED. THE FUMES ARE STILL EXCESSIVE WHETHER THE TRUCK IS SITTING OR IN MOTION.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE PULLING OUT OF THE DRIVEWAY IN REVERSE, "POWER STEERING ASSIST FAULT" APPEARED ON THE MESSAGE CENTER AND THE VEHICLE LOST POWER STEERING ABILITY. THE CONTACT DROVE THE VEHICLE TO ROUSH FORD (5575 KEIM CIR, COLUMBUS, OH 43228) WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC POWER STEERING FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.