2005 Ford Explorer complaints

FOUND A CRACK ON THE REAR LIFTGATE RIGHT AROUND THE FORD EMBLEM. AFTER MENTIONING IT TO A FRIEND, TURNS OUT SHE HAD THE SAME PROBLEM WITH HER EXPLORER AND A SEARCH ONLINE SHOWS MANY OTHERS HAVE HAD THE SAME ISSUE WITH THIS MODEL YEAR. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT THE LIFTGATE DOOR WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHO VERIFIED THE FAILURE AND STATED THAT THE REAR LIFTGATE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 45,000. UPDATED 02/22/12*LJ THE CONSUMER STATED THE BACK PANEL THAT IS CRACKED, IS ALSO SOMING UNGLUED. THE PANEL WAS REPLACED BEFORE AT 20,000 MILES. UPDATED 003/01/12

THE GEARS IN THE POWERED BRAKE/GAS PEDAL ASSEMBLY SEEM TO STRIP. THEN THE BRAKE/GAS PEDAL WON'T CHANGE POSITION. THAT CREATES A DANGEROUS SITUATION FOR THE DRIVER BECAUSE THE PEDALS GET STUCK TOO FAR AWAY FOR SOME DRIVERS AND TOO CLOSE FOR OTHERS. THIS IS A FLEET WIDE ISSUE FOR ALL FORDS WITH ADJUSTABLE PEDALS. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THE FUEL SENSOR BOARD FAILED AND NEEDED TO BE UPGRADED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 91,400.

VEHICLE DRIVE BELT FALLS OFF WITHOUT NOTICE DUE TO CRANKSHAFT PULLEY SEPARATING FROM ENGINE MAKING VEHICLE INOPERATABLE. *TR

DROVE THE VEHICLE TO WORK AND WENT TO LEAVE AND I HAD NO REVERSE. THE TRANSMISSION HAD BEEN SLAMMING INTO REVERSE AND THEN ENGAGING PRIOR TO THIS-BUT NO SLIPPING OR ANYTHING ELSE. I HAD THE FLUID CHANGED AND THERE WERE NO TEETH OR ANY METAL IN THE FILTER OR PAN-BUT THIS DID NOT FIX THE PROBLEM. SPOKE WITH 3 TRANSMISSION SHOPS IN MY TOWN AND ALL TOLD ME THE 05 EXPLORERS HAD JUNK TRANSMISSIONS. THAT THE FLUID IN PART OF THEM FROM THE FACTORY WAS BAD AND THE TRANNY ITSELF WAS JUST A BIG MISTAKE. THIS NEEDS TO BE RECALLED- $1338 LATER, I HAVE A REBUILT 'JUNK' TRANSMISSION. I HAVE OWNED FORDS IN THE PAST AND LOVED THEM, BUT MY EXPLORER ENDED THIS LOVER AFFAIR. EVERYWHERE YOU LOOK ONLINE THERE ARE COMPLAINTS ABOUT THIS VEHICLE- AND NO ONE IS MAKING FORD DO ANYTHING ABOUT IT. *TR

RIGHT NEXT TO THE FORD EMBLEM A CRACK DEVELOPED. IT'S ON THE REAR GLASS HATCH AND RUNS FROM THE TOP OF THE FIBERGLASS PANEL TO THE BOTTOM. THE PANEL KEEPS EXPANDING AND CONTRACTING WITH THE CRACK GOING FROM JUST A SLIGHT LINE TO A 3/16" GAP! DEFINITELY A MANUFACTURER DEFECT. I'VE SEEN MANY OTHER EXPLORERS WITH THE SAME ISSUE. THE TRUCK WAS IN PERFECT CONDITION WHEN IT APPEARED AND FORD SAYS THAT IT'S NOT THEIR PROBLEM. TOO BAD YOUR WARRANTY HAS RUN OUT! POOR DESIGN THAT FORD SHOULD FIX FOR THE MONEY WE HAVE GIVEN THEM FOR THE VEHICLE. *TR

HEAT COMPONENT: TRIED TO DEFROST THE WINDOWS ON MY VEHICLE, WHEN I ADJUSTED THE CONTROLS TO THE HEAT I BEGAN TO HEAR A LOUD CLICKING NOISE AND NO HEAT WAS COMING OUT OF THE VENT. WINTER IS IN AND IT IS EXTREMELY DIFFICULT TO SEE WHEN DRIVING DUE TO THIS ISSUE. TWO OTHER INDIVIDUALS WITH THE SAME MAKE & MODEL HAVE THE SAME EXACT ISSUE WITH THERE VEHICLE. I FEEL THAT IT IS A FAILED PIECE OF EQUIPMENT THAT CAUSES A HIGH SAFETY RISK. *TR

JUST BOUGHT THIS CAR. TRANSMISSION WAS HAVING TROUBLE SHIFTING GEARS AND IS NOW SLIPPING. THIS SHOULD BE A RECALL, AS I HAVE FOUND TOO MANY COMPLAINTS ABOUT THIS TRANSMISSION FALLING APART. FORD SHOULD FIX THIS ISSUE AND REPLACE WITH A DIFFERENT TRANSMISSION. I DON'T WANT TO SPEND THOUSANDS OF DOLLARS ON A TRANSMISSION THAT IS BOUND TO FAIL AGAIN. THIS IS A BLATANT MISSED RECALL. THE TRANS IS MODEL 5R55S. PLEASE RECALL THIS. *TR

REAR LIFTGATE PANEL UNDER WINDOW 10 INCH CRACK IN MIDDLE. GLASS LOOSE. *KB

STARTED TO FEEL A LOSS OF POWER AND HEAR KNOCKING FROM UNDER THE HOOD OF THE VEHICLE SO TOOK IT TO THE NEAREST GARAGE TO HAVE IT CHECKED OUT AND I WAS TOLD US THAT IT WAS THE TIMING CHAIN AND THAT THE TIMING CHAIN ON A LOT OF THE NEW FORDS HAVE BEEN GOING BAD. NO WARNING, NO WARNING. IT IS RECOMMENDED BY EVERYONE TO REPLACE THE ENGINE. *TR

DESPITE MY MAINTAINING THE VEHICLE IN PERFECT CONDITION, LIKE MANY OTHER FORD EXPLORERS, MINE DEVELOPED A CRACK ALONG THE FORD LOGO ON THE REAR LIFT GATE, RUNNING FROM THE WINDOW TO THE BOTTOM OF THE LIFT GATE. TEMPERATURES HAVE NOT BEEN EXTREME IN OUR AREA, YET THE CRACK APPEARED WITHIN A TIME FRAME OF 5 HOURS. FORD MOTOR COMPANY SHOULD BE HELD RESPONSIBLE FOR THIS OBVIOUS DEFECT IN THE EXPLORERS. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS STOPPED AND THE GEAR SHIFTER WAS SHIFTED INTO PARK WHEN IT ROLLED FORWARD UNTIL CRASHING INTO ANOTHER VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS AWAITING A RESPONSE. THE FAILURE AND THE CURRENT MILEAGES WERE 90,000.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT THE EXTERIOR PLASTIC TRIM OF THE LIFTGATE GLASS WAS CRACKED. THE DEALER ADVISED THE CONTACT THAT THE FAILURE WAS COMMON. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 87,000 AND THE CURRENT MILEAGE WAS 89,000.

WE BOUGHT OUR EXPLORER NEW JULY 4TH 2005, HAVE HAD SEVERAL PROBLEMS BUT THIS IS THE WORST. I HAVE HAD THE TRANSMISSION CHECKS DONE ON TIME AT 40,000 AND 60,000 MILES. I TOLD THEM TWICE BEFORE THE TRANSMISSION WAS NOT RIGHT IT WAS SLIPPING. NOW THAT I FINALLY PAID THEM $200.00 FOR THEIR TEST IT SHOWS THE BANDS ARE ABOUT TO BREAK AND IT WILL BE $3900.00 FOR A REBULIT ONE. I HAVE CHECKED OUT THE LIST OF PROBLEMS WITH THERE TRANSMISSIONS,SO WHERE IS THE RECALL,COME ON WE CAN'T ALL BE WRONG. LOOKING FOR HELP IN THESE HARD TIMES,BEING DISABLED AND WIFE ABOUT TO RETIRE THIS PRICE IS ABSURD,BECAUSE OF ALL THE OTHER COMPLAINTS. BOUGHT LAST TWO CARS FROM FORD ,DON'T THINK IT WILL HAPPEN AGAIN. THANKS FOR LETTING ME VENT. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHEN THE DEFROSTER FAILED TO OPERATE WHEN ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THAT THE DASHBOARD WOULD HAVE TO BE REMOVED AND THE BLENDING CHAMBER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 07/15/2013 *JS UPDATED 7/10/13 *CN

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE HATCH PANEL FRACTURED RIGHT BELOW THE WINDOW. THE DEALER WAS NOTIFIED OF THE FAILURE VIA VOICEMAIL. THE VEHICLE WAS NOT INSPECTED NOR HAD IT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.

TOOK OUR 2005 FORD EXPLORER TO SERVICE DEPT. BEFORE WARRANTY EXPIRED-PREVIOUSLY ALEXANDER FORD, NOW FORD OF MURFREESBORO. THE TRANSMISSION HAD BEEN SLIPPING PERIODICALLY AT THE TIME. THEY DROVE IT & SAID NOTHING WAS NOTICEABLE. I INDICATED TO THEM THAT IT SLIPPED MAYBE ONCE OR TWICE EVERY MONTH OR SO. NOW VEHICLE IS OUT OF WARRANTY. I WAS DRIVING IN TRAFFIC AND THE TRANSMISSION SLIPPED ON ME. I HAD A CAR IN FRONT OF ME & WHEN IT FINALLY LET UP, I ALMOST HIT THE VEHICLE IN FRONT OF ME-WITH A BABY IN A CAR SEAT IN THE BACK SEAT. WHEN I SLAMMED ON MY BREAKS AFTER THE TRANSMISSION KICKED IN, I SUFFERED WHIPLASH. IT SCARED ME TO DEATH. THERE APPEAR TO BE SO MANY TRANSMISSION PROBLEMS WITH THE 2005 EXPLORERS. THIS IS DANGEROUS AND SOMEONE SHOULD DO SOMETHING ABOUT IT FOR A RECALL. THEY SHOULD HAVE CHECKED MY VEHICLE OUT MORE EXTENSIVELY RATHER THAN BARELY DRIVE IT FOR A FEW MINUTES WHEN IT WAS UNDER WARRANTY. I COULD HAVE INJURED A CHILD & I DID INJURE MYSELF. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT WHILE TURNING RIGHT AT APPROXIMATELY 15 MPH, ALL OF THE LUG NUTS ON THE REAR DRIVER SIDE WHEEL SHEERED OFF. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT SOME OF THE LUG NUTS WERE ALSO SHEERED OFF FROM ALL OF THE OTHER WHEELS. ALL OF THE LUG NUTS AND THE LUG NUT STUDS WERE REPLACED. THE FAILURE RECURRED APPROXIMATELY TEN MONTHS LATER. THE CONTACT STATED THAT ALL OF THE LUG NUTS OF THE REAR DRIVER SIDE WHEEL SHEERED OFF. THE VEHICLE WAS TOWED BACK TO THE AUTHORIZED DEALER WHERE THE IT REMAINED IN THEIR POSSESSION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 95,000.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THE GEAR SHIFT WAS ABLE TO BE MOVED FROM PARK TO REVERSE AND DRIVE WITHOUT THE KEYS IN THE IGNITION OR THE VEHICLE BEING ON. THE CONTACT STATED THAT A CHILD WAS ABLE TO MOVE THE GEAR SHIFT WHILE IT WAS TURNED OFF AND THE VEHICLE ROLLED BACKWARDS. THE CONTACT WAS ABLE TO BE STOP THE VEHICLE, GET INTO IT AND APPLY THE BRAKE PEDAL. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT AND ADVISED THE CONTACT THE VEHICLE WOULD NOT BE INSPECTED BECAUSE THERE WAS NO CORRECTION TO BE MADE OR RECALL RELATED TO THE VIN. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

CRACKED REAR DOOR PANEL JUST BELOW THE WINDOW, IN THE MIDDLE OF THE FORD EMBLEM. MAY CAUSE REAR WINDOW TO FALL OUT UNEXPECTEDLY. FORD IS AWARE OF THE DEFECT BUT REFUSES TO RECALL AND FIX IT. *TR

THE ACTIVHEAT HEATED CAR SEAT COVER MODEL # 6HCSCBL24 WAS RECALLED BECAUSE THE SEAT COVER COULD OVERHEAT AND BURN ME. ON AUGUST 12, 2011 I MAILED IN MY REQUEST FOR A NEW SEAT COVER ALONG WITH A 3" X 5" SECTION OF THE FRONT MESH FABRIC OF THE SEAT COVER TO ACTIVHEAT SEAT RECALL, C/O ATLAS NORTH, PO BOX 873, WOODBURY, NJ 08096. THE RECALL LETTER STATED THAT I WOULD RECEIVE THE NEW SEAT COVER IN 30 DAYS. IT HAS BEEN OVER 60 DAYS AND I HAVE NOT RECEIVED THE REPLACEMENT SEAT COVER. I HAVE CALLED 800-541-3722 TWICE TO INQUIRE ABOUT THE RECALL. THE ANSWERING SERVICE HAS TAKEN MY NAME AND PHONE # AND SAID THEY WOULD CALL ME. I HAVE NOT RECEIVED A CALL. PLEASE HELP ME OBTAIN THE NEW SEAT COVER.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT NOTICED A CRACK ON THE REAR LIFTGATE NEAR THE MANUFACTURING EMBLEM. NEITHER THE DEALER NOR THE MANUFACTURER OFFERED ANY ASSISTANCE SINCE THERE WERE NO RECALLS FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 56,000.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER . THE CONTACT STATED THAT THE HATCH BACK PANEL WAS CRACKED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED THAT THE FAILURE WAS A MANUFACTURING DESIGN FLAW. AS A RESULT, THE PANEL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 62,000. UPDATED 12/06/11*LJ UPDATED 12/12/11

WHILE DRIVING ON THE HIGHWAY, TRANSMISSION SLIPPAGE OCCURRED SWITCHING SUDDENLY FROM DRIVINIG TO NEUTRAL, GEAR COULD NOT BE CHANGED UNLESS VEHICLE WAS PARKED AND BRAKE PEDAL WAS PRESSED DOWN. SCARY SITUATION CONSIDERING THAT I COULD BE DRIVING ON THE LEFT LANE. PLEASE CONSIDER THIS AS A SAFETY COMPLAINT AND REQUEST FOR SAFETY RECALL. *KB

I OWN A 2005 FORD EXPLORER THAT I PURCHASED IN JUNE, 2005. ON SATURDAY, FEBRUARY 21, 2009, I ATTEMPTED TO SHIFT MY 2005 FORD EXPLORER, WHICH HAD ROUGHLY 49,000 MILES DRIVEN AT THE TIME, INTO REVERSE IN ORDER TO BACK OUT OF MY DRIVEWAY. IN DOING SO, THE GEARSHIFT ALMOST COMPLETELY BROKE AWAY FROM THE STEERING COLUMN. I WAS ABLE TO TURN THE IGNITION OFF, BUT WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. AFTER HAVING THE VEHICLE TOWED TO THE DEALER, I WAS INFORMED THAT THE GEARSHIFT IS NOT A SERVICEABLE PART AND THAT THE ENTIRE STEERING COLUMN WOULD NEED TO BE REPLACED. THE SERVICE REPRESENTATIVE STATED SHE HAD NEVER SEEN THIS ISSUE BEFORE, IT WAS NOT COVERED UNDER WARRANTY, AND THE COST FOR A NEW STEERING COLUMN AND ASSOCIATED LABOR WOULD BE MORE THAN $1,600. SHE ALSO INFORMED ME THAT A USED STEERING COLUMN FROM A JUNKYARD WOULD COST MUCH LESS, BUT THAT SHE WOULD NOT BE ABLE TO PROVIDE THE EXACT AMOUNT UNTIL EARLY MONDAY MORNING. ON MONDAY MORNING, I WAS INFORMED BY KRF SOUTH THAT THEY COULD OBTAIN A USED STEERING COLUMN AND THE TOTAL COSTS FOR PARTS AND LABOR WOULD BE $620. I CHOSE TO HAVE THE USED USED STEERING COLUMN INSTALLED DUE TO THE PRICE DIFFERENTIAL. SIMPLY PUT, A GEARSHIFT SHOULD NOT BREAK OFF FROM THE STEERING COLUMN THROUGH NORMAL VEHICLE USE. I BELIEVE THIS TO BE A SERIOUS SAFETY ISSUE THAT SHOULD BE ADDRESSED BY FORD. I WAS FORTUNATE ENOUGH TO BE ABLE TO TURN OFF THE IGNITION AFTER THE GEARSHIFT BROKE AWAY. HAD I NOT BEEN ABLE TO TURN THE VEHICLE OFF, I WOULD H

VERY LARGE CRACK IN THE REAR LIFT GATE FROM TOP TO BOTTOM LIKE 1 FOOT LONG AND 3/16 WIDE CLOSE TO THE FORD LOGO. *TR

HTTPS://AIAHD.TELESISHQ.COM/MRCGI/MRSPELLCHECK.PL

WHILE SHIFTING INTO REVERSE SOMETIMES THERE IS A 3-4 SECOND DELAY. IT IS ALSO SLAMMING INTO REVERSE AT TIMES. MORE FREQUENT AS TIME GOES ON. THIS IS A KNOW ISSUE FROM TSB 05-15-4 CAUSING BY THE FORD FACTORY FAILING TO PUT AN ADDITIVE IN THE TRANSMISSION FLUID. THIS SHOULD BE COVERED BY FORD. I'M NOW LOOKING AT A COSTLY REPAIR. *TR

MY 2005 FORD EXPLORER ENGINE SHUTS OFF WHILE DRIVING WHEN CRUISE CONTROL IS ON. THE ENGINE ALSO HAS A HUM SOUND WHILE CRUISE CONTROL WAS ON. *TR

TL* THE CONTACT OWNED A 2005 FORD EXPLORER. THE CONTACT STATED THE DRIVER WAS DRIVING APPROXIMATELY 55 MPH, WHEN SHE CRASHED INTO A TRUCK AND THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS TAKEN TO THE HOSPITAL, BY AMBULANCE FOR SERIOUS INJURIES. THE VEHICLE WAS DESTROYED AND TOWED TO A TOWING YARD. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE.

THE CAR STALLS WHILE DRIVING AT VARIOUS SPEEDS FROM 25 MPH TO 55 MPH WITHOUT WARNING. THE LOSS OF POWER BRAKES AND STEERING AT THESE HIGHER SPEEDS IS EXTREMELY DANGEROUS ESPECIALLY IN CLOSE TRAFFIC. AFTER COASTING TO A STOP THE CAR RESTARTS EASILY. THIS STALLING OCCURS WITH THE CRUISE CONTROL ON AND OFF AND DOES NOT APPEAR TO BE A FACTOR. WEATHER IN ALL CASES WAS DRY AND WARM. THE STALLING HAS OCCURRED SEVERAL TIMES ,WEEKS AND MONTHS APART. TWO FORD DEALERS HAVE LOOKED AT THE CAR BUT CANNOT FIND A COMPUTER CODE PROBLEM, THEY ALSO HAVEN'T BEEN ABLE TO RECREATE THE PROBLEM THUS THEY SAY THEY CANNOT FIX THE PROBLEM. A WEB SEARCH DIVULGES THAT OTHERS HAVE REPORTED THIS SIMILAR PROBLEM TO FORD FOR THE 2002,2004 AND 2005 EXPLORER. PLEASE LOOK INTO THIS BEFORE SOMEONE GETS INJURED OR KILLED! *TR

PARKING BRAKE SHOES BROKEN. ADVISED DURING REGULAR SERVICE THAT SHOES WERE BROKEN DURING EARLIER SERVICE AND WAS ADVISED TO WAIT UNTIL REAR BRAKES REQUIRED SERVICE SINCE PARKING BRAKE IS RARELY USED. DURING SERVICE ON 9/21/2011 REQUEST REPAIR OF PARKING BRAKE IN WHICH THE SHOES WERE REPLACED AT COST OF $424.19. INQUIRED AS TO CAUSE SINCE PARKING BRAKE IS RARELY USED AND WAS TOLD THAT COULD BE THE REASON. OVERHEARD ANOTHER SERVICE REP STATE THAT, QUOTE, "EXPLORER'S ARE NOTORIOUS FOR THAT". CURRENTLY CONTACTING FORD NATIONAL CUSTOMER RELATIONS TO INQUIRE ABOUT POSSIBLE PARTIAL REIMBURSEMENT SINCE PROBLEM APPEARS TO BE WIDE SPREAD. *TR

REAR DIFFERENTIAL WHINE IS VERY BAD/LOUD ! THIS IS A KNOWN ISSUE BY FORD MOTOR COMPANY. THIS IS A VERY BAD DEFECT. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THE REAR LIFTGATE WAS CRACKED UNDERNEATH THE WINDOW AND EXTENDED TO THE BOTTOM OF THE GATE ON THE LEFT SIDE OF THE EMBLEM. THE CRACK HAD BECOME PROGRESSIVELY WORSE OVER TIME. THE DEALER INFORMED THE CONTACT THAT THE FAILURE WAS A DESIGN FLAW AND IF IT WAS REPAIRED, IT WOULD PROBABLY CRACK AGAIN. THE CURRENT MILEAGE WAS 99,992.

I WAS DRIVING HOME AND THE CAR DIED. AAA TOWED THE CAR TO MY REPAIR SHOP. MY MECHANIC SAID THAT THE TIMING CHAIN OR CHAINS (THERE ARE 5 AND THE ENGINE HAS TO COME OUT TO REPLACE THE REAR CHAIN) BROKE AND THE PISTONS HIT AND BENT THE VALVES. (ENGINE SHOT). I RELIGIOUSLY CHANGE THE OIL WITH SYNTHETIC EVERY 3-4000 MILES. THIS IS A DEFECT THAT FORD IS HIDING- THERE ARE COMPLAINTS GALORE ON THE INTERNET. I SPOKE TO [XXX] AT FORD CONSUMER IN MAHWAH, NJ AND GOT NOWHERE. PLEASE HELP, I CANNOT AFFORD A NEW ENGINE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B). *TR

FRONT ALUMINUM HOOD BEGAN PAINT BLISTERING AT ABOUT 2 YEARS OF OWNERSHIP. TOOK BACK TO THE DEALER FOR REPAIR. TWO YEARS LATER, PAINT BLISTERS RETURN. TSB 6-25-15 ISSUED WITH PAINTING GUIDELINES BUT NO REPAIR AUTHORITY. AFTER SECOND OCCURRENCE, DEALER SAID NO REPAIRS WOULD BE MADE AND ADVISED US TO PAY TO REPLACE THE HOOD AND PAINT. THIS IS UNACCEPTABLE FOR A $45K CAR (LIMITED VERSION WITH ALL OPTIONS) *TR

NOTICED A CRACK RUNNING FROM THE BOTTOM OF MY REAR WINDOW DOWN TO THE BOTTOM OF THE UPPER PORTION OF THE REAR LIFT GATE TO THE LEFT OF THE FORD EMBLEM ON MY 2005 EXPLORER. CRACK JUST APPEARED FOR NO REASON. DID NOT TAKE IT IN OR HAVE IT FIXED. FORD WILL NOT OWN UP TO THIS FLAW SO I WILL NOT PAY TO HAVE IT FIXED. I WILL NOT BUY ANOTHER FORD SINCE THEY DON'T STAND BY THEIR PRODUCT. I ONLY HAVE 41000 MILES ON IT AND I BOUGHT IT BRAND NEW. *KB

ON FRIDAY, 8/12/11, AT APPROXIMATELY 5:30 PM, I NOTED AN APPROXIMATELY 2" LONG CRACK ON THE REAR HATCH PANEL, LOCATED JUST ABOVE AND BESIDE THE FORD EMBLEM. AS OF THIS PAST MONDAY, 8/15/11, THIS CRACK HAS NOW EXTENDED ALL THE WAY ACROSS THE PANEL. I HAVE HAD THIS VEHICLE FOR 3 YEARS WITHOUT ANY TYPE OF BODY DAMAGE OR ACCIDENTS. THIS IS NOT AN AREA WHERE ANOTHER VEHICLE WOULD HAVE HIT MINE. AS FAR AS I KNOW, THIS JUST APPEARED WITH NO REASON. I HAVE DONE EXTENSIVE RESEARCH ON THE INTERNET AND NOTED THIS IS A COMMON PROBLEM WITH THIS YEAR, MAKE AND MODEL OF FORD AND IS APPARENTLY BASED ON DEFECTIVE GLUE. I CONTACTED A LOCAL FORD COMPANY AND WAS ADVISED THAT THIS IS NOT UNDER WARRANTY.

THE PAINT ON OUR 2005 EDDIE BAUER EXPLORER IS BUBBLING AND PEELING OFF AND HAS BEEN DOING THIS SINCE 2008, BUT NOW IS GETTING WORSE. WHEN AT THE FORD DEALER WHILE GETTING THE COMPUTER CHANGED WICH IS ANOTHER PROBLEM WITH FUEL EFFICIENCY, WE ASKED ABOUT THE PAINT AND WE WERE TOLD THAT THERE ISN'T ANY TYPE OF RECALL. WE ARE ALSO HAVING PROBLEMS WITH HAVING TO CHANGE TIRES EVERY 15000 MILES. THI TRUCK HAS MANY DEFECTS. *TR

GAS CAP LIGHT COMES ON TRIGGERING THE CHECK ENGINE LIGHT. *KB

WHILE STOPPED AT A TRAFFIC LIGHT I SWITCHED ON MY TURN SIGNAL TO INDICATE A RIGHT TURN AND NOTICED THE NORMAL CLICK OF THE TURN SIGNAL WAS NOT OCCURRING. I LOOKED DOWN AT MY INSTRUMENT PANEL AND SAW THE RIGHT TURN LIGHT WAS LIT BUT NOT FLASHING. THE REST OF THE TRIP I HAD TO CONTINUALLY TURN ON AND TURN OFF THE TURN SIGNAL TO LET OTHERS NOW MY INTENTIONS SINCE THE SIGNALS WOULD NO LONGER FLASH. FINALLY I RAPIDLY WORKED THE SWITCH UP AND DOWN AND WAS ABLE TO GET THE TURN SIGNALS TO OPERATE CORRECTLY AGAIN. ALSO ON OTHER OCCASIONS THE SIGNAL WOULD CLICK VERY FAST WHICH AND THE ACTUAL SIGNAL LIGHT WOULD NOT FLASH OR LIGHT BUT WOULD EVENTUALLY START WORKING AGAIN. I ASSUMED IT WAS A BURNED-OUT BULB BUT WHEN IT CAME BACK ON AGAIN I KNEW THAT WAS NOT THE CASE. I SAW A RECALL RECENTLY FOR THE TURN SIGNAL SWITCH ON RANGER PICKUPS AND EXCURSION SUVS IN THE AGE RANGE OF MY VEHICLE AND THIS SEEMS TO BE EXACTLY WHAT IS HAPPENING WITH MY EXPLORER.

WHILE DRIVING, WHEN I APPLIED THE BRAKES, THE CAR LURCHED AND MADE A NOISE. ABOUT 1 MINUTE AFTER THAT, A WARNING LIGHT THAT STATED "ENGINE FAIL SAFE MODE" AND A LITTLE WRENCH SHOWED UP ON THE LEFT OF THE INSTRUMENT PANEL. I WAS DRIVING HOME, AND THE CAR STARTED TO SPEED UP WITHOUT MY INCREASING THE SPEED USING THE GAS PEDAL. THE CAR CONTINUED TO LURCH OFF AND ON UNTIL I GOT HOME. I RESEARCHED THIS PROBLEM ON THE INTERNET AND IT SEEMED TO BE THE THROTTLE BODY ASSEMBLY THAT HAD FAILED. UPON TAKING IT TO THE MECHANIC, THAT IS EXACTLY WHAT IS WAS. THE CAR WAS DANGEROUS TO DRIVE, I COULD HAVE BEEN KILLED HAD THE CAR'S SPEED KEPT INCREASING. THE REPAIR WAS $1026.00.

I HAVE 2005 FORD EXPLORER THAT I WAS DRIVING IN FREEWAY WITH SPEED OF 60MPH WITH 3 KIDS IN THE VEHICLE AND MY WIFE AND JUST TRANNY FAILED AND SPEED DROP ALMOST GET IN ACCIDENT NOW I AM WITHOUT THE CAR AND WITHOUT THE WORK I DID CHANGE MY TOYOTA TO THE AMERICAN VEHICLE 2 YEARS AGO TO HELP ECONOMY OF USA AND NOW I HAVE NO IDEA THAT WHERE I GET $3000.00 TO REPLACE THE TRANNY. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT AFTER REFUELING, FUEL BEGAN TO SPILL OUT FROM THE FUEL FILLER NECK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE A CANNISTER WITHIN THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILAGE WAS 142,202.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED WHEN SHIFTING THE GEAR SELECTOR THERE WAS A DELAYED RESPONSE AND THE VEHICLE WOULD LUNGE FORWARD. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT PLANNED TO NOTIFY THE MANUFACTURER REGARDING THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

CRACKED PANEL UNDER REAR WINDOW 2005 FORD EXPLORER. *TT

WAS DRIVING DOWN THE ROAD ABOUT 200 MILES FROM HOME AND CAR WAS DOING FINE. ALL OF THE SUDDEN I LOST MY GAS GAUGE AND THE MILES TO EMPTY READING "---". I HAVE NEVER HAD THIS PROBLEM. THEN ABOUT 8 MILES FROM MY 314 MILE DESTINATION IT WORKED AGAIN, IN WHICH IT READ HALF A TANK. THEN AFTER REFUELING, THE GAS GAUGE DID THE SAME THING. IT HAS BEEN THAT WAY FOR A DAY NOW AND I TRY TO GO ABOUT 200 MILES AND THEN TOP IT OFF AGAIN. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER XLT. THE CONTACT STATED THAT THE GEAR SHIFTER WOULD SPORADICALLY MOVE INTO NEUTRAL FROM PARK OR DRIVE WITHOUT THE KEY BEING IN THE IGNITION. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THERE WERE NO RECALLS FOR THE PARTICULAR FAILURE. THE FAILURE MILEAGE WAS 90,000.

MY 2005 FORD EXPLORER HAS A LARGE VERTICAL CRACK IN THE REAR PANEL. I HAVE SEEN THIS IN DOZENS OF VEHICLES WITH SIMILAR BODY STYLES, FOR REFUSES TO FIX THE PROBLEM AND GAVE ME A QUOTE OF $472. *TR