2004 Ford Explorer complaints

VEHICLE WAS PARKED. OPERATOR OPENED REAR HATCH GLASS, AT WHICH TIME THE RIGHT HINGE SEPARATED. THIS CAUSED THE GLASS TO SLAM DOWN. FORTUNATELY, THE OPERATOR WAS ABLE TO JUMP OUT OF THE WAY TO AVOID INJURY. THE GLASS DID NOT BREAK, BUT THE STRUTS ARE BENT. BOTH THE RIGHT AND LEFT HINGES APPEAR TO BE DEFECTIVE AND IN NEED OF REPLACEMENT. THE REAR HATCH IS NOT USABLE UNTIL THE HINGES AND STRUTS ARE REPLACED. *TR

WHILE DRIVING NORTH ON US23 AT BRIGHTON MI THE RIGHT FRONT WHEEL AND TIRE SEPARATED FROM THE VEHICLE BECAUSE OF THE FRACTURE OF THE 5 WHEEL LUGS. ACCORDING TO THE MSP THIS IS A COMMON OCCURANCE BECAUSE OF METAL FATIGUE CAUSED BY THE IMPROPER USE OF IMPACT AND NOT TORQUE WRENCHES WHEN THE VEHICLE IS SERVICED. THE PROBLEM IS BEING IGNORED BY THE AUTO MANUFACTURERS, AND I HAVE FOUND PUBLICATIONS ON THIS SUBJECT MATTER. THERE ARE LIKELY MILLIONS OF AFFECTED VEHICLES IN SERVICE, AND THE WHEEL LOSS WOULD PRODUCE RESULTS SIMILAR TO THE PREVIOUS FORD/FIRESTONE TIRE PROBLEM. *TR

WHILE PUTTING THE CAR IN REVERSE IN THE PARKING LOT THE GEAR SHIFT COMPLETELY SNAPPED OFF AND THE CAR WAS STUCK IN REVERSE. THE KEYS WERE STUCK IN THE IGNITION AND I COULDN'T TURN THE CAR OFF. I HAD TO PUT THE EMERGENCY BRAKE ON AND CALL FOR HELP ON MY CELL PHONE. WHEN HELP ARRIVED AFTER A COUPLE OF HOURS THEY WERE ABLE TO MANUEVER WHAT WAS LEFT OF THE GEAR SHIFT ENOUGH TO PUT THE CAR BACK IN PARK AND TURN THE CAR OFF. I CALLED THE FORD CUSTOMER SERVICE DIVISION AND SPOKE WITH A REPRESENTATIVE NAMED [XXX], HE PRECEDED TO TELL ME THAT FORD HAS NEVER HEARD OF SUCH A PROBLEM AND THAT HE COULDN'T HELP ME. HE SAID THERE ARE CURRENTLY NO RECALLS AVAILABLE FOR THIS PART. I SEARCHED THE INTERNET AND FOUND HUNDREDS OF THE SAME COMPLAINT ON FORDS AND ADVISED [XXX] AND AGAIN HE SAID FORD HAS NEVER HEARD OF SUCH A PROBLEM. I AM RELIEVED THAT IT HAPPENED IN A PARKING LOT AND IT DIDN'T CAUSE AN ACCIDENT. FORD SHOULD BE ASHAMED OF THEMSELVES AND THEIR SHODDY WORKMANSHIP AND TAKE THE NECESSARY STEPS TO RESOLVE THIS PROBLEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE HINGE ON THE RIGHT SIDE OF THE REAR LIFTGATE GLASS IS FALLING OFF. I PURCHASED THIS VEHICLE USED IN AUGUST 2012. THE HINGE SEEMED TO BE IN TACT THEN BUT HAS SLOWLY BEEN CORRODING AND FALLING OFF. THE GLASS MAKES AN AWFUL NOISE WHEN I DRIVE OVER POT HOLES, BUMPS, ETC. I DO NOT USE THE GLASS IN FEAR IT WILL FALL ON ME. THERE HAVE BEEN TIMES WHEN I TURN MY VEHICLE ON AND THE MESSAGE CENTER SAYS "REAR LIFTGATE AJAR" ONLY TO FIND THAT SOMEHOW THE GLASS LIFTGATE IS NOT LATCHED. NOBODY USES IT SO UNSURE IF THE CORROSION AND BROKEN HINGE IS CAUSING THE GLASS TO AJAR FROM THE LATCH. I CALLED A LOCAL FORD DEALERSHIP TO SEE IF THIS HAS BEEN RECALLED ON MY VEHICLE, AS IT HAS ON NUMEROUS OTHER 2004 FORD EXPLORER. I WAS TOLD IT WAS NOT RECALLED AND THE PART IS $50/PIECE. THE LEFT HINGE IS STARTING TO DO THE SAME AS WELL. I AM SCARED THAT THIS WILL EVENTUALLY FALL OFF WHILE I AM DRIVING THE VEHICLE AND THINK THIS SHOULD BE RECALLED AS IT IS A HUGE SAFETY ISSUE. *TR

AFTER A DAY OF SHOPPING I PULLED INTO MY DRIVEWAY AND PARKED MY SUV. I WENT TO OPEN THE REAR WINDOW HATCH WHEN THE LEFT SIDE CAME APART FROM THE VEHICLE AND LANDED ON TOP OF ME. FORTUNATELY THE RIGHT SIDE OF THE WINDOW WAS ABLE TO STAY INTACT WHILE MY HUSBAND WAS ABLE TO RUN TO MY AID TO LIFT THE DOOR UP. I AM FOUR MONTHS PREGNANT AND MY THREE YEAR OLD SON WAS STANDING BY MY SIDE. I HAVE READ THAT MANY COMPLAINTS ABOUT THIS ISSUE HAVE BEEN MADE TO THE FORD CORPORATION REGARDING THIS PROBLEM BUT THEY CONTINUE NOT TO RECTIFY THE ISSUE AT HAND; WHILE LEAVING VEHICLE OWNERS HELPLESS WHEN THIS SITUATION OCCURS. I READ THAT THIS WAS A GOOD AVENUE TO REPORT THIS ISSUE SINCE FORD CONTINUES TO IGNORE THE PROBLEM AND WONDER IF MY HUSBAND WOULD NOT HAVE BEEN IN SHOUTING DISTANCE WHAT WOULD'VE HAPPEN TO MY SON, UNBORN CHILD AND MYSELF!!!!! *TR

REAR HATCH WINDOW HINGE (LEFT SIDE) BROKE AND RELEASED THE GLASS WHILE DRIVING. WINDOW FELL TO ONE SIDE. I HAD TO MAKE AN IMMEDIATE EMERGENCY STOP. IT WAS DIFFICULT TO PROP WINDOW TO A SAFE POSITION AND LOCK DOWN. IT MUST REMAIN LOCKED DOWN UNTIL I CAN FIX IT. *TR

THE REAR LIFTGATE WINDOW HINGE BROKE OFF AND THE ENTIRE REAR WINDOW FELL ON MY WIFE. THE HINGES ARE MADE OF A WHITE TYPE OF METAL THAT HAS CORRODED AND SHEARED OFF. THE PINS INSIDE APPARENTLY BROKE AND IT DIDN'T APPEAR TO BE FALLING OFF, IT JUST CAME OFF. THE WINDOW HIT MY WIFE IN THE ARM AND LEG. WE WERE LUCKY IT WASN'T ONE OF OUR KIDS CLOSING THE GATE AT THE TIME OR THAT THEY WEREN'T INSIDE WHEN IT HAPPENED OR THIS COULD HAVE BEEN A LOT WORSE. AFTER SEARCHING ONLINE FOR INFORMATION ABOUT THIS ISSUE I FOUND THOUSANDS OF COMPLAINTS ABOUT THIS EXACT ISSUE AND HUNDREDS OF POST OF INJURIES INCURRED FROM THIS. FORD RECALLED OTHER VEHICLES WITH THE SAME ISSUE WITH THE SAME PART AND YET THE 2004 WAS NEVER INCLUDED. SOMETHING NEEDS TO BE DONE. A PART OVER TIME SHOULDN'T BREAK OFF AND CAUSE A SAFETY HAZARD. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 55MPH THE TRANSMISSION DOWN SHIFTED TO FIRST GEAR CAUSING THE VEHICLE TO SLOW DOWN AND THE REAR TIRES TO DRAG. THE CONTACT WAS ABLE TO SHIFT GEARS WHICH BROUGHT THE VEHICLE BACK TO SPEED AS HE MERGED INTO A REST AREA. THE VEHICLE WAS TOWED TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 136,000.

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 25 MPH, THE OVERDRIVE WARNING LIGHT ILLUMINATED INTERMITTENTLY ON THE INSTRUMENT PANEL. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER AND SHUT THE VEHICLE OFF. AFTER RESTARTING THE VEHICLE, THE WARNING LIGHT CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

STARTED DRIVING AND WHEN I WENT TO MAKE A TURN I FELT A GRAB. THOUGHT I MIGHT BE IMAGING THINGS BUT HAPPENED AGAIN ON THE NEXT INTERSECTION TURN THIS TIME CAUSING ME TO HAVE TO MAKE A WHEEL CORRECTION. ON THE THIRD TURN IT WAS MARKEDLY WORSE AND A GRUNCH SOUND ACCOMPANIED IT AND IT WAS MORE DIFFICULT TO MAKE THE TURN. AND THEN NEXT FEW TURNS MARKEDLY WORSE AGAIN TO THE POINT I AM CONSIDERING PULLING OVER AND GETTING A TOW AS NOW IT IS DANGEROUS. I FIGURED OUT THAT IT WAS MOSTLY STRAIGHT DRIVING TO THE MECHANIC GARAGE AND THREE TURNS SO I DROVE CAUTIOUSLY. A VERY DIFFICULT DRIVE MAKING TURNS AND I COULD BARELY TURN INTO THE GARAGE DRIVE AS THE STEERING BARELY WORKED AND WAS ACCOMPANIED BY VERY LOUD GRUNCHING. IT WAS A QUICK FIX AS A BOLT IN THE STEERING COLUMN HAD COME OUT. HAD THIS HAPPENING ON A HIGHWAY THIS COULD HAVE BEEN A LIFE THREATENING SITUATION TO NAVIGATE OFF THE HIGHWAY. NO INJURIES. *TR

4 YEARS AGO THE PLASTIC NEXT TO THE FORD EMBLEM CRACKED RIGHT OF THE EMBLEM ON MY BACK HATCH. I LOOKED INTO IT AND THERE WAS 10'S OF THOUSANDS OF THE SAME COMPLAINT THAT I HAD AT AN AVERAGE COST OF ONLY $800. THEN TONIGHT MY WIFE GOT SOME CHAIRS OUT OF THE REAR HATCH THEN WHEN CLOSING IT THE REAR GLASS FALLS OUT OF THE EXPLORER BECAUSE " THE ALUMINUM REAR HATCH HINGE ON THE RIGHT SIDE BROKE" WHICH HAS AN AVERAGE COST OF $300. MIND YOU THE LITTLE PIECE THAT HOLDS THE WINDOW HINGE ON IS ONLY THE SIZE OF AN ERASER HEAD, BOTH OF THE REAR HATCH DEFECTS ARE NOT UNDER ANY RECALL YET MANY COMPLAINTS HAVE BEEN FILED AND OR POSTED VIA THE INTERNET. THIS IS A SAFETY CONCERN TO FAMILIES AS IT SHOULD BE TO THE FORD MOTOR COMPANY " WHICH SEEMS NOT TO CARE " AND ALSO TO THE NHTSA AS IT COULD BE A HUGE SAFETY ISSUE IF THIS WAS TO HAVE HAPPENED TRAVELING DOWN THE HIGH WAY AT 70 MPH. *TR

WHEN CLOSING THE REAR WINDOW HATCH, THE LEFT HINGE THAT HOLDS THE GLASS COMPLETELY LET GO OF THE GLASS. FORTUNATLEY MY HUSBAND WAS THE ONE CLOSING IT AND WAS ABLE TO CATCH THE GLASS BEFORE IT BROKE THE OTHER HINGE AND PULLED THE GLASS OFF COMPLETELY. THE RIGHT HINGE WAS ALSO BENT, AS THE WINDOW WILL NOW NOT SIT LEVEL TO BE PUT BACK INTO PLACE. THIS SHOULD BE RECALLED, AS THERE IS A LARGE HAZARD OF TH WINDOW FALLING. WHAT IF MY DAUGHTER HAD BEEN STANDING UNDERNEATH AS USUAL, OR HE HAD NOT BEEN ABLE TO CATCH THE WINDOW AND IT BROKE AND SEN "EXPLODING" GLASS PIECES EVERYWHERE. I SEE THAT THIS APPEARS TO BE A VERY WIDESPEAD ISSUE WHEN LOOKING THROUGH COMPLAINTS. ALSO, THE TAILGATE IN MY EXPLORER HAS ALSO EXPERIENCED THE SAME MYSTERIOUS CRACK THAT SO MANY OTHER VEHICLES HAVE HAD. ONE DAY IT WAS FINE, THEN IT WAS CRACKED. COULD THESE ISSUES BE SOMEHOW RELEATED? OR IS THE ENTIRE HATCH JUST FULL OF FLAWS. *TR

I PURCHASED A 2004 FORD EXPLORER IN JULY 0F 2011, AND TRADED IN MY 2001 OLDSMOBILE OF 5 YEARS. I ALSO PURCHASED THE 12 MONTH 12,000 MILE WARRANTY. BEFORE DRIVING IT OFF THE LOT I HAD THE DEALER FIX THE ABS SYSTEM BECAUSE THE LIGHT WAS ON. THERE IS A CRACK GOING DOWN THE BACK OF THE TRUNK BUT NOTHING ELSE WAS WRONG AT THE TIME SO I LEFT THE CRACK ALONE. IN APRIL OF 2012 I TOOK IT TO THE DEALERSHIP FOR A BELT, CHECK TRANS, SHOCKS, BALL JOINTS, AND A TICKING IN THE HEATER WHEN KNOB WAS TURNED TO HEAT (NOT COOL). I TOLD HIM TO JUST FIX WHAT WAS ON THE WARRANTY AND ALSO GIVE IT A OIL CHANGE. HE INFORMED ME THAT THE TRANS WAS FINE. AFTER GETTING THE CAR BACK MY HEAT WENT OUT AND I WAS TOLD BY A MECHANIC BUDDY THAT MY BRAKES, ROTTERS, EMERGENCY BRAKE PADS AND THE BACK TIRES WERE SHOT. SO I HAD HIM REPLACED THEM BECAUSE THIS WAS ALSO NOT COVERED ON WARRANTY. JUST LAST WEEK MY RPM STARTED JUMPING WITH MILES OVER 65.(NO LIGHTS WERE ON AT THE TIME)SO I TOOK IT TO 6 DIFFERENT PLACES GETTING ESTIMATES ON WHAT COULD BE WRONG. ALL SHOPS SAID THE SAME THING. "START WITH FUEL FILTER, OIL FILTERS AND OIL CHANGE". THE DAY AFTER I PAID FOR ALL THIS THE SERVICE ENGINE LIGHT CAME ON. (EGR VALVE CODE) THE MAN AT AUTO ZONE TOLD ME TO TAKE IT OFF AND CLEAN IT WITH SPRAY AND LET IT DRY BEFORE REPLACING. I TOOK IT TO A SHOP AND HAD THEM DO THIS. THE SAME DAY I PICKED UP THE CAR MY SERVICE ENGINE LIGHT CAME ON AGAIN, O/D LIGHT AND THE CAR WAS DRIVING LIKE I WAS HAULING A BUS AND JUMPING. I TOOK IT BACK

THIS ISSUE INVOLVES THE DRIVER SIDE SUN VISOR. THE PLASTIC PIECE ON THE LEFT SIDE OF THE VISOR THAT HOLDS IT IN PLACE ON THE CEILING HAS BROKEN OFF. WHEN YOU HIT A BUMP OR DIP IN THE ROAD THE VISOR FALLS DOWN AND BLOCKS YOUR VIEW TO SEE WHAT IS GOING ON IN FRONT OF YOU. THIS IS A REAL SAFETY CONCERN TO ME. I DON'T WANT TO HIT SOMEONE OR SOMETHING BECAUSE OF THIS. I AM ASKING FOR A RECALL TO BE ISSUED. THANKS *TR

I HAD TO HAVE THE HEATER BLEND DOOR REPLACED ON MY FORD EXPLORER. THE COST WAS OVER $1000.00. THE ENTIRE DASHBOARD HAD TO BE REMOVED. I KNOW THAT A TSB WAS ISSUED BY FORD ON THIS PROBLEM,MANY OWNERS HAVE HAD THE SAME PROBLEM AS I DID. THIS IS AN ENGINEERING/MANUFACTURING DEFECT THAT IS NOT ONLY COSTLY TO REPAIR,BUT IN MY OPINION CAN CAUSE THE WINDSHIELD TO FOG UP WHILE DRIVING BECAUSE YOU CAN NOT CONTROL THE HEATER FUNCTION. THIS CAN LEAD TO A POOR OR NON VISIBILITY SITUATION AND COULD CAUSE AN ACCIDENT. PLEASE LOOK INTO THIS PROBLEM TO AVOID ANY POSSIBLE ACCIDENTS. I HAVE READ NUMEROUS REPORTS FROM OTHER OWNERS ONLINE REGARDING THIS PROBLEM.PLEASE CONTACT FORD ABOUT THIS POTENTIALLY HAZARDOUS PROBLEM AND ISSUE A RECALL NOTICE. THE BLEND DOOR IS NOT STRONG ENOUGH TO WITHSTAND THE BLOWERS AIR PRESSURE. THANK YOU FOR YOUR HELP IN THIS MATTER. *TR

TRANSMISSION WENT AT 74,000 MILES. *TR

I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN MY TRANSMISSION STARTED SLIPPING AND THE CRUISE CONTROL KICKED IT BECAUSE THE VEHICLE STARTED TO SLOW DOWN SO IT WENT INTO HIGH RPMS THEN THE TRANSMISSION GRABBED AND SHOT THE VEHICLE FORWARD AND I LOST CONTROL AND WE SPUN IN CIRCLES OFF THE FREEWAY. HAD IT NOT OF RAINED ALL DAY THE SUV WOULD HAVE FLIPPED. NOW MY TRANSMISSION IS LEAKING FLUID AND IT MUST BE REPAIRED BY DEALERSHIP OR GARAGE ONLY AND I CANNOT AFFORD THIS REPAIR AND I SEE THAT THERE IS A MAJOR PROBLEM THESE TRANSMISSIONS IN THESE VEHICLES AND ME MY CHILD OR MY HUSBAND COULD HAVE BEEN BADLY HURT IF NOT KILLED HAD THIS BEEN ON DRY PAVEMENT!!! *TR

FILLED UP THE TANK AND IT REGISTERED NO FUEL, BAD FUEL SENSOR. *TR

I LEFT WORK ON FRIDAY WHEN SHIFTED FROM REVERSE TO DRIVE NOTICED I HAD A HESITATION/SLIPPAGE OF GEARS IN THE MIDDLE OF THE ROAD. I PICKED UP MY CHILDREN WENT TO THE STORE NOTICED A MILD BURNT SMELL WHICH I WAS TOLD WAS TRANSMISSION FLUID BURNING SO I WAS TOLD TO PARK THE CAR. I FINISHED MY SHOPPING CAME OUT GOT THE KIDS IN THEIR SEATS STARTED TO BACK UP AND HAD NO TRANSMISSION. MY KIDS AND I WERE STRANDED 8 MILES FROM HOME BECAUSE WE HAD NO FAIR WARNING THAT IT WAS GOING. I HAD NEVER HAD ANY ISSUES WITH IT BEFORE. THE GUY I BOUGHT IT FROM HAD REPLACED THE TRANSMISSION 2 YEARS BEFORE I BOUGHT IT. FORD NEEDS TO ISSUE A RECALL AND GET THINGS LIKE THIS FIXED. MY KIDS AND I COULD HAVE BEEN SERIOUSLY INJURED HAS THAT HAPPENED ON THE ROAD ON THE WAY HOME INSTEAD OF IN A PARKING LOT. *TR

TRANSMISSION SHIFTS VERY HARD SO BAD THAT IT JERKS ME AND MY CHILDREN'S HEADS FORWARD WHEN IT HAPPENS. THIS OCCURS THE WORST WHEN GOING INTO REVERSE AND INTO 2ND AND 3RD GEARS. BRAKES LOCK UP/STICK AFTER BEING PRESSED FOR 3 SECONDS. *TR

CANNOT ACCELERATE, FEELS LIKE TRANSMISSION IS SHIFTING HARD. SCARES ME TO BE IN TRAFFIC WITH TWO SMALL CHILDREN IN BACKSEAT. PUT INTO REVERSE IT JOLTS INTO GEAR AFTER A FEW SECONDS. MAKES A LOUD NOISE WHEN DRIVING DOWN THE ROAD. SOMETIMES THERE IS ALMOST NO ACCELERATION MAKING IT IMPOSSIBLE TO GET AROUND TOWN. *TR

OUR 2004 FORD EXPLORER - MY SON OPENED THE LIFTGATE AND THE RIGHT HINGE SNAPPED LEAVING THE WINDOW DANGLING IN MY 10 YR OLDS FACE. AFTER MUCH READING ONLINE, WE HAVE DISCOVERED THAT THE REAR WINDOW LIFT GATE GLASS HINGE HAS BEEN A PROBLEM FOR MANY FORD OWNERS. THE RUSTED OUT PLASTIC PIECES ARE SNAPPING OFF AND ALLOWING THE GLASS TO FALL FROM THE HINGE. I WAS ABLE TO RUSH TO THE BACK OF THE CAR TO GRAB THE GLASS BEFORE IT FELL. MY ENTIRE RIGHT SIDE IS SORE FROM TRYING TO HOLD THE GLASS AND TRYING TO SHUT THE WINDOW LIFT GATE SO I COULD GET THE CAR HOME. WITH ONE ADULT AND THREE KIDS, I WAS STUCK TRYING TO FIGURE OUT HOW & WHAT TO DO WITH THIS WINDOW DANGLING. WE ARE SHOCKED THAT FORD HAS YET TO RECALL THE 2004 MODELS BUT HAS RECALLED PREVIOUS YEARS. THIS IS OBVIOUSLY A HUGE PROBLEM & IT NEEDS TO BE ADDRESSED. SOMEONE IS GOING TO GET VERY HURT. THE HINGES & STRUTS NEED TO BE RECALLED ON THIS MODEL. *TR

THE PINS ON THE LIFTGATE WINDOW ARE BREAKING THROUGH THE HINGE. THE DRIVER SIDE HAS BROKEN CLEAN THROUGH AND THE PASSENGER SIDE IS BEGINNING TO BREAK THROUGH EVEN THOUGH I HAVEN'T USED IT SINCE THE OTHER ONE BROKE. THERE IS ALSO A CRACK UNDER THE WINDOW ON THE BACK LIFT DOOR. *TR

UPON OPENING THE REAR LIFT GATE, THE HINGES COMPLETELY GAVE OUT AND THE LIFT GATE FELL AWAY FROM THE TRUCK. I WAS FORTUNATE IN THAT I WAS ABLE TO CATCH AND HOLD IT, AS MY 5 YEAR OLD SON WAS STANDING BENEATH IN ORDER TO HAND ME HIS BEACH TOYS, AT THE TIME OF THE INCIDENT. I HAD TO HOLD THE (VERY HEAVY) LIFT GATE UNTIL A MECHANIC ARRIVED TO DETACH ELECTRICAL COMPONENTS AND PLACED THE LIFT GATE INSIDE THE 2004 FORD EXPLORER. I THEN HAD TO DRIVE HOME WITH NO LIFT GATE WHILE EXHAUST FUMES FILLED THE TRUCK. IT SHOULD BE NOTED THAT PRIOR TO THIS INCIDENT, THE TAILGATE CRACKED, WHICH I SEE IS A COMMON ISSUE WITH THIS PARTICULAR VEHICLE AND THE SUBJECT OF A CLASS ACTION LAWSUIT. *TR

TRAVELING WITH THE CRUISE CONTROL SET AT APPROXIMATELY 58 MPH, TRAFFIC 100 - 120 FEET IN FRONT OF THE VEHICLE CAME TO AN ABRUPT STOP. PRESSED THE BRAKE TO DISENGAGE THE CRUISE CONTROL AND STARTED APPLYING PRESSURE TO THE BRAKE PEDAL. THE VEHICLE SEEMED TO INITIALLY START TO SLOW, HOWEVER, AS WE APPROACHED THE STOPPED TRAFFIC, THE ENGINE CONTINUED TO REV AND WE COULD NOT STOP, CAUSING US TO HIT THE REAR-END OF THE VEHICLE IN FRONT OF US. THE VEHICLE WE HIT MOVED FORWARD A FEW FEET AND WE HIT THE REAR-END AGAIN AS THE EXPLORER'S ENGINE CONTINUED TO REV AND DRIVE US FORWARD EVEN WITH CONSTANT PRESSURE APPLIED TO THE BRAKE PEDAL. AFTER THE SECOND COLLISION, WE WERE ABLE TO PULL THE EXPLORER OFF TO THE SIDE OF A ROAD, NOTIFY THE POLICE, AND FILE A ACCIDENT REPORT. THE EXPLORER HAS NOT YET BEEN TAKEN TO THE DEALERSHIP TO EVALUATE WHAT HAD HAPPENED. *TR

I HAD JUST PURCHASED THIS VEHICLE TO TOW WITH. I WAS DRIVING IN THE COUNTRY WITH THE CRUISE CONTROL ON AND SET AT ABOUT 45MPH. ALL OF A SUDDEN I REALIZED I THE VEHICLE HAD TURNED ITSELF OFF. NO POWER STEERING, NO BRAKES NOTHING. IT DID START RIGHT BACK UP AFTER GETTING OFF THE ROAD. LATER IN THE DAY RETURNING HOME IT DID THE SAME EXACT THING AT 50MPH WITH CRUISE ENGAGED. I TALKED WITH FORD SHOP AND THEY SAY IT IS A KNOWN PROBLEM WITH NO KNOWN FIX. THIS IS VERY DANGEROUS. *TR

THE REAR HATCH JUST CAME OFF AS I WAS DRIVING OUT OUT OF A STORE, THE HINGE JUST BROKE OFF. *TR

DRIVING, AND AND LIGHT CAME ON, 4X4 LIGHT BLINKING 5TIMES EVERY 2/3 MILES. WENT TO REVERSE AND GOT A HARD JERK. CAR STARTED MAKING A RUBBING NOISE. TOOK ITHE SHOP WAS TOLD IT WAS EITHER THE TRANSMISSION OR THE TRANSFER CASE. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE HINGES ON THE REAR LIFTGATE BROKE AND THE WINDOW FELL DOWN ON THE CONTACT'S SHOULDER, RESULTING IN A SHOULDER INJURY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE HINGES ON THE REAR LIFTGATE NEEDED TO BE REPLACED. THE DEALER ALSO STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFGATE: HINGE AND ATTACHMENTS). THE FAILURE AND CURRENT MILEAGES WERE 160,000.

TRANSMISSION IS SLIPPING, NOT FULLY GONE YET, ONLY A MATTER OF TIME BEFORE IT COMPLETELY GOES. I DO NOT HAVE THE $2500.00 TO REPLACE THE TRANSMISSION. EVERY PERSON I HAVE TALKED TO SAY THIS IS A COMMON PROBLEM WITH THE FORD EXPLORERS. I HAVE TAKEN INTO THE GARAGE OVER 10 TIMES. FORD SHOULD BE FORCED TO RECALL THESE TRANSMISSIONS AND FORD SHOULD HAVE TO PAY FOR IT. *TR

THE LEFT (DRIVER SIDE) REAR LIFT GATE HINGE BROKE MAKING THE REAR LIFT GATE AND WINDOW UNUSABLE. THIS OCCURRED WHEN I WAS GOING TO CLOSE THE DOOR, THANKFULLY IT WAS ONLY THE WINDOW SECTION THAT WAS BEING CLOSED AS I'M SURE THE DOOR ITSELF IS PRETTY HEAVY. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE HESITATED TO ACCELERATE FROM STOPS. THE FAILURE OCCURRED WHILE IN DRIVE OR REVERSE. THE CONTACT ALSO STATED THAT THE VEHICLE JERKED VIOLENTLY WHILE SHIFTING GEARS. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000.

THE TRANSMISSIONS FOR FORD EXPLORERS HAVE ABOUT A 10% FAILURE RATE. THE SAFETY ISSUE IS THAT THE CAR MAY NOT ACCELERATE WHEN NEEDED. THE TRANSMISSION ACTS AS THOUGH IT IS IN NEUTRAL WHEN SHIFTING FROM SECOND TO THIRD GEARS. THE SYMPTOM ALSO APPEARS DURING NORMAL ACCELERATION (MERGING ONTO HIGHWAYS, TRYING TO PASS OTHER VEHICLES). THE DANGER IS THAT YOU MAY NOT BE ABLE MOVE OUT OF THE WAY OF OTHER VEHICLES. WE HAVE NOT BEEN HIT, BUT WE NO LONGER DRIVE THIS VEHICLE ON THE HIGHWAY. WE EXPECT A TOTAL FAILURE AT ANY MOMENT, AND DO NOT WANT TO BE IN A SITUATION WHERE THE VEHICLE WILL NEED TO BE TOWED FOR A LARGE NUMBER OF MILES. THIS VEHICLE IS UNSAFE, AND UNRELIABLE. FORD SHOULD FIX THIS PRODUCT, MUCH LIKE HONDA DID FOR THEIR 2003 ACURA TL. *TR

THE HINGES THAT HOLD ON THE REAR WINDOW ARE STARTING TO BREAK. THE 02 AND 03 MODEL EXPLORERS WERE RECALLED FOR THIS BUT FORD REFUSES TO ISSUE A RECALL FOR THE 2004 MODELS EVEN THOUGH THIS APPEARS TO BE A HUGE ISSUE AFFECTING A LARGE NUMBERS OF EXPLORERS. I HAVE CAUGHT IT BEFORE TOTAL FAILURE BUT MANY PEOPLE HAVE HAD THE GLASS COME LOOSE AND INJURE THEM. IT IS A HUGE SAFETY ISSUE. *TR

RIGHT REAR LIFTGATE WINDOW HINGE FAILED (CRACKED) CAUSING HEAVY (APPRX 40 LB) GLASS LIFTGATE GLASS PANEL TO FALL ON A PERSON CAUSING MINOR INJURY. APPEARS 02/03 MODELS RECALLED FOR SAME ISSUE (DESPITE FORD'S RESPONSE ON THE FIRST INVESTIGATION OF THIS IT IS THE SAME ISSUE AS 02/03). THE HINGE PART IS INADEQUATE TO HOLD THE HEAVY GLASS PANEL IN PLACE OVER TIME WITH USE. SINCE THE BACK GLASS IS A HEAVY SLAB OF UNFRAMED, TEMPERED GLASS IT COULD "EXPLODE" IF IT FALLS POTENTIALLY CAUSING SERIOUS INJURY OR TRAFFIC ACCIDENTS TO TRAILING VEHICLES. FORD APPARENTLY DOES A GOOD BUSINESS IN SELLING THESE REPLACEMENT HINGES AT A COST OF OVER $100 EACH FOR A SMALL PIECE OF WEAK CAST METAL. FORTY POUND SLABS OF GLASS FALLING OFF OF VEHICLES WITH NO PRIOR WARNING IS A SAFETY ISSUE! RESEARCH INDICATED MANY OTHER OWNERS WITH THE SAME COMPLAINT. *TR

THE HATCH BACK CRACKED DOWN THE MIDDLE. RIGHT BELOW THE WINDOWS. I JUST SHUT THE GLASS DOOR AND NOTICE A CRACK. *TR

O/D LIGHT CAME ON AND THE TRANSMISSION STARTED SLIPPING AND SLAMMING IN AND OUT OF GEARS AND THE ENGINE STARTED OVER REVVING. I HAVE TO PULL OFF THE ROAD AND TURN CAR OFF AND WAIT ABOUT 10 SECONDS TO START CAR AGAIN IN ORDER FOR PROBLEM TO CLEAR. THIS HAS HAPPENED MAY TIMES SINCE. I BOUGHT THE CAR NEW AND HAVE RETURNED IT TO THE FORD DEALER 3 TIMES WHILE UNDER WARRANTY AND THERE FIXES WOULD NOT LAST LONG. NOW THEY WANT $3,000 TO REPLACE THE TRANSMISSION WHICH I FEEL THEY SHOULD HAVE DONE IN THE FIRST PLACE. I CONTACTED FORD CUSTOMER SERVICE AND OF COURSE THEY SAID THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS OUT OF WARRANTY. I FEEL BECAUSE OF THE CARS HISTORY AND LOW MILES ON IT THEY SHOULD HAVE AT LEAST DONE SOMETHING. I FEEL IF THIS HAPPENS ON A MAJOR HIGHWAY IT COULD CAUSE A MAJOR ACCIDENT. *TR

2004 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO CRANKSHAFT PULLEY FAILURE *TGW THE CONSUMER STATED HE WAS UNABLE TO MOVE THE VEHICLE FROM THE ROAD AND HAD IT TOWED TO A REPAIR SHOP, BUT WAS UNABLE TO MAKE THE REPAIRS, DUE TO OTHER DAMAGE TO ONE OF THE COMPONENTS. THE VEHICLE WAS THEN TOWED TO THE DEALER, WHERE THEY INFORMED THE CONSUMER THE CRANKSHAFT PULLEY HAD FAILED, BROKE THE V-BELT, WHICH IN TURN HIT AND DAMAGED THE CRANKSHAFT POSITION SENSOR. *JB

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE HINGE OF REAR PASSENGER GLASS FRACTURED, CAUSING THE WINDOW GLASS TO SHATTER. THE CONTACT WAS ABLE TO NOTICE WEAR ON THE REAR DRIVER'S SIDE, BUT THE DRIVER SIDE HAD NOT BROKEN. THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION, BUT NO REPAIR WAS MADE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 97,102.

TL* THE CONTACT OWNS A FORD 2004 FORD EXPLORER. THE CONTACT STATED THAT THE LOWER PORTION OF THE LIFT GATE GLASS EXHIBITED A LONG STRESS CRACK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 69,000. THE VIN WAS UNAVAILABLE.

THE PLASTIC PIECE OF MOLDING UNDERNEATH THE REAR GLASS WINDOW CRACKED AND FELL OFF. NOTHING WAS DONE TO PROMPT THIS. I HAVE READ THAT THOUSANDS OF OTHER VEHICLES HAVE THIS SAME ISSUE. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT WHILE GOING 45 MPH, THE BRAKES WERE APPLIED BUT FAILED. THE CONTACT TRIED TO PUMP THE BRAKE PEDAL AND IT WOULD ONLY DEPRESS PARTIALLY. SHE TRIED AGAIN A FEW MOMENTS LATER AND THE BRAKE PEDAL WAS DEPRESSED COMPLETELY INTO THE FLOORBOARD. THE CONTACT HAD TO USE THE PARKING BRAKE IN ORDER TO SLOW DOWN. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY INFORMED THE CONTACT THAT THERE WAS A FAILURE IN THE BRAKE LINE, WHICH NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL TIMES LATER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 115000.

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT WAS DRIVING 2 MPH IN REVERSE WHEN THE BACK UP SENSOR FAILED AND THE CONTACT CRASHED INTO ANOTHER VEHICLE. THE CRASH CAUSED NO INJURIES AND THE POLICE WERE CONTACTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OF THE FAILURE OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 131,000.

THE LEFT REAR LIFT GATE WINDOW HINGE BROKE CAUSING THE WINDOW TO FALL AND BRUISE MY DAUGHTER'S ARM. TERRIBLE DESIGN AND FRAUGHT WITH PERIL. *TT

I WAS DRIVING DOWN THE STREET AND HEARD A NOISE. WE TURNED AROUND AND THE LIFTGATE HAD FALLEN OFF ITS ON HINGES AND WAS HANGING LOOSE ON BOTH SIDES. WE HAD TO HOLD IT ON AND DRIVE THE CAR BACK HOME. THE CAR HAS NOT BEEN DRIVEN SINCE THAT DATE IN 2010. FORD NEEDS TO BE RESPONSIBLE FOR THE 2004 MODEL AND ALL OF ITS DEFECTIVE PRODUCTS. THIS IS THE SECOND COMPLAINT THAT I HAVE FILED AGAINST FORD CONCERNING THIS CAR. THE FIRST WAS A #2 VALVE FALLING IN THE ENGINE AND CAUSING THE ENGINE TO BLOW UP. NHTSA PLEASE DO SOMETHING ABOUT FORD. SOMEONE HAS TO MAKE CAR MANUFACTURERS RESPONSIBLE TO THE CONSUMER. EVERY TIME THAT NHTSA IS CONTACTED NOTHING IS DONE UNTIL MILLIONS ARE NEGATIVELY AFFECTED. *TR

2004 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEM *TGW THE CONSUMER STATED THERE WAS A DELAY IN THE TRANSMISSION WHEN HE ATTEMPTED TO PUT THE GEAR IN REVERSE. THERE WAS ALSO A HARD SHIFT WHEN THE VEHICLE WAS WARM AND ON SEVERAL OCCASIONS, IT WOULD SLAM INTO GEAR. *JB

BOUGHT THE CAR USED WITH ABOUT 85,000 MILES ON IT. AFTER ONE YEAR OF AVERAGE USE (NO TOWING OR OFF-ROADING) THE TRANSMISSION FAILED (ABOUT 97,000 MILES). HAD IT REBUILT AND NOW 2 YEARS AND FOUR MONTHS LATER IT IS FAILING AGAIN (AT 122,000 MILES). *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE ENGINE TRANSITIONED INTO SAFE MODE AND STALLED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE PCM, THROTTLE, JACK SHAFT CHAIN, AND BEARINGS WERE REPLACED. THE FAILURE CONTINUED. BOTH THE DEALER AND MANUFACTURER STATED THAT THE FAILURE COULD NOT BE DIAGNOSED. THEY RECOMMENDED ATTEMPTING VARIOUS TRIAL AND ERROR REMEDIES. THE CONTACT STATED THAT THE PCM AND THROTTLE AGAIN NEEDED TO BE REPLACED. THE FAILURES CONTINUED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 118,861.

VEHICLE'S TRANSMISSION STARTED TO SLIP, AS WE WERE DRIVING WE WOULD HIT THE GAS HARDER TO COMPENSATE AND THEN THE TRANSMISSION WOULD CATCH CAUSING THE VEHICLE TO SURGE FORWARD UNEXPECTEDLY. *JS

ON 1/17/12 DRIVING ON HIGHWAY AND NOTICED A BURNING SMELL. IT WAS A STRONG SMELL. NOTICED A GLOW UNDER THE DASHBOARD AND PULLED INTO A EMPTY PARKING LOT. THE TRUCK WENT UP IN FLAMES. CALLED FORD AND THEY SAID PROVE WHAT HAPPENED. NOT SURE BUT THE VEHICLE WAS IN VERY GOOD CONDITION WITH NO PROBLEMS THAT I KNEW OF BEFORE THIS FIRE. NO ONE WAS HURT. *TR