2003 Ford Explorer complaints

WHILE DRIVING HOME FROM WORK THIS EVENING THE O/D OFF LIGHT BEGAN STEADILY BLINKING AND THE TRANSMISSION TOOK WAY TOO LONG TO SHIFT (RPM ALMOST RED LINE) AND WOULDN'T SHIFT INTO 5TH GEAR. I WAS DRIVING ON A CITY STREET AND FIRST NOTICED THE TRUCK NOT SHIFTING AND WITHIN 3 MINUTES OF DRIVING THE O/D OFF LIGHT BEGAN FLASHING. IF YOU TURN THE TRUCK OFF THEN BACK ON THE O/D OFF LIGHT TURNS OFF BUT THE TRUCK STILL WON'T SHIFT CORRECTLY AND THE LIGHT STARTS TO BLINK AGAIN. MY TRUCK ONLY HAS 133,000 MILES. I GOOGLED THIS PROBLEM AND DISCOVERED THAT THE VAST MAJORITY OF 2003 FORD EXPLORER OWNERS HAVE THIS SAME PROBLEM.

I WAS DRIVING IN MINUS 20 DEGREE CELSIUS TO TAKE HIGHWAY 15 NORTH FROM JUST AFTER PANAMA BUS STATION. IN THE ENTRANCE, MY CAR START TO SLOW DOWN TO THE 5 KMPH. IN THE BACK OF MY CARS WERE ALL ON THEIR HAZARD LIGHT AND BEING MAD AT ME. SO I DRIVE BACK TO MY HOME TAKING THE NEXT EXIT. I WISH SOMEBODY COULD TAKE THE VIDEOS AND SENT TO THE FORD COMPANY TO LET THEM KNOW MY SITUATION.

2003 FORD EXPLORER SHUTS DOWN WHILE DRIVING. I LOSE BRAKING AND STEERING ABILITY. IT CAN HAPPEN AT ANY TIME. IT HAS HAPPENED SEVERAL TIMES . TODAY 12 FEB. 2016 IS THE LATEST DATE.

CRACKED PANEL BELOW THE REAR WINDOW

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING ON AN INCLINE AT AN UNKNOWN SPEED, THE VEHICLE FAILED TO ACCELERATE AND THE OVERDRIVE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SOLENOID PACK AND THE OXYGEN SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT ALSO MENTIONED THAT THE CHECK TRANSMISSION AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

I BOUGHT MY FORD EXPLORER XLT BACK IN JUNE OF 2015. SINCE THEN I REPLACED MY OXYGEN SENSOR DO TO A FAULT IN THE SYSTEM AND MELTING BACK IN AUG. 20015. THE SUV WOULDN'T START BECAUSE OF IT AND HAD TO BE TOWED. SINCE I PURCHASED AND HAD REPLACED THE OXYGEN SENSOR BY A FORD DEALER, I NOTICED THE SUV HAVING POWER FAILURE EVEN FROM A COMPLETE STOP AND NOW THE OVER DRIVE OFF LIGHT FLASHES; THIS STARTED IN THE BEGINNING OF NOV. 2015 I NOTICED THAT THERE IS OVER 2755 COMPLAINTS OF TRANSMISSION PROBLEMS AND FAILURES EXACTLY THE SAME AS MINE, BUT NOT ONE RECALL. THIS IS A ISSUE WITH THE SUV THEMSELVES AND NOT OWNER ERROR. I HAVE CHILDREN AND DON'T WANT TO END UP STRANDED IN THE STREET OR SIDE OF THE HIGHWAY DUE TO TRANSMISSION FAILURE. THERE HAS TO BE SOMETHING CAUSING THE TRANSMISSION TO BREAK DOWN OR FAIL AND I REFUSE TO BE THE THE BLAME NOR PAY THOUSANDS TO FORD DEALERSHIP TO FIX A FLAW IN THERE OWN SUV. A RECALL NEEDS TO BE MADE FOR THIS PROBLEM AND IT IS CLEARLY A MANUFACTURE FLAW.

VEHICLE WAS PARKED(ENGINE COLD) ON RESIDENTIAL STREET,ALARM SOUNDED,UPON OPENING HOOD DISCOVERED FLAMES, PUT OUT IMMEDIATELY WITH EXTINGUISHER, CAR WILL NOT RUN AND THERE APPEARS TO BE EXTENSIVE DAMAGE ESPECIALLY ON RIGHT SIDE.

1. TRANSMISSION DOES NOT LET YOU ACCELARATE. PRESSURE BUILDS UP WHILE YOU ARE PRESSING ON THE GAS PEDAL AND IT DOESN'T INCREASE YOUR SPEED UNTIL 10 SECONDS OR SO OF PRESSING THE GAS PEDAL, AND THAN IT EXPLODES AND YOU ARE THRUST BACK WITH THE ACCELERATION. VERY DANGEROUS WHEN YOU ARE TRYING TO CHANGE LANES OR ARE ENTERING THE HIGHWAY. LACK OF ACCELERATION HAS ALMOST GOT US INTO A FEW ACCIDENTS. 2. SENSORS ARE NOT FUNCTIONING, CONSTANTLY TELLING ME THAT THE DOORS ARE OPEN. I DON'T KNOW WHEN A DOOR IS ACTUALLY OPEN OR NOT. 3. THE REAR HATCH IS CRACKED AND I'M AFRAID IT DOESN'T PROVIDE ENOUGH STABLE PRORECTECTION FOR THE REAR GLASS TO BE HELD IN PLACE PROPERPLY.

TL* THE CONTACT OWNED A 2003 FORD EXPLORER. WHILE DRIVING AT 50 MPH, THE FRONT AND REAR DRIVER SIDE TIRES BLEW OUT, WHICH CAUSED THE VEHICLE TO FLIP OVER SEVERAL TIMES. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUFFERED INJURIES TO THE LOWER BACK, ARM, AND KNEES. THE PASSENGER SUFFERED AN INFLAMMATION OF THE LOWER BACK. THE DRIVER AND PASSENGER BOTH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

THE REAR AIR CONDITIONER LINE RUBBED AGAINST THE BRAKE LINE CAUSING BRAKE LINE FAILURE. THE RUPTURE OCCURRED DURING AN ATTEMPT TO SUDDENLY STOP. THERE WERE NO SIGNS OF RUST EITHER INSIDE OR OUTSIDE THE BRAKE LINE. THE FAILURE OCCURRED AT ABOUT 156,000 MILES ON THE VEHICLE. ODDLY ENOUGH, THE MECHANIC SPECIFICALLY NOTED THAT RUST WAS NOT A FACTOR IN THIS CASE AS IS COMMON ON MANY NEWER VEHICLES. I HAVE OWNED THE VEHICLE SINCE 3/7/2006. NO COLLISION WORK HAS BEEN PERFORMED ON THE VEHICLE SINCE TAKING OWNERSHIP.

THE PROBLEM WITH SEAT BELTS DOES NOT HAVE ENOUGH TENSION TO RETRACT THE HARNESS CAUSING TO STAY BY THE DOOR AND NOT CLOSING GOOD, IT MEANS THE BELTS IT IS BY THE DOOR MECHANISM JAMMING THE LOCK AND NOT LOCKING PROPERLY ON DRIVER OR PASSENGER SIDE, I HAD THE DOOR OPEN WHILE I WAS DRIVING, ALSO DESTROYED MY DOOR SEAL TEARING UP, THE MANUFACTURE FORD DOES NOT WANT TO REPLACE IT FOR FREE SINCE IT IS A MANUFACTURE DEFECT, THEY WANT TO CHARGE FOR THE REPLACEMENT AND EVEN THE NEW ONES ARE NOT WORKING PROPERLY. I CHECK ALL THIS STUFF SINCE I WAS A FLEET MAINTENANCE MECHANIC, CAR INSPECTOR. GOVERNMENT NEEDS TO STEP IN AND FIX THE SAFETY HARNESS FOR GOOD TENSION. THIS HAPPENED WHEN I WAS DRIVING, ALSO PARKED THE DOOR DID NOT CLOSE PROPERLY DUE THE HARNESS DID NOT RETRACTED.

MY 2003 FORD EXPLORER XLS IS HAVING ISSUES WITH THE AUTOMATIC TRANSMISSION. WHEN I ACCELERATE FROM A STOPPED POSITION, THE TRANSMISSION STALLS, SLIPS AND DELAYS WHEN IT SHIFTS INTO THE NEXT GEAR. AS I SEARCHED FOR ISSUES WITH THE TRANSMISSION I FOUND 100'S OF COMPLAINTS REGARDING THIS MATTER. FROM WHAT I HAVE FOUND, THE TRANSMISSION IS A DESIGN FLAW

WE HAVE RECURRING WHEEL BEARING AND HUB ASSEMBLY ISSUE. THE TIMING I PUT ON THE FORM MAY BE OFF A BIT BUT NOT MUCH. ITS ALL LIKE A RECURRING FORD EXPLORER NIGHTMARE AT THIS POINT! WE HAVE REPLACED BEARINGS, HIB ASSEMBLY, TIE ROD, THEN REAR END WENT UP ( AND SHOULDN'T HAVE)/NOW AGAIN, ANOTHER BEARING AND WHEEL SENSOR. THE TRUCK CUTS OUT WHEN AT A SLOWER SPEED. I LOST STEERING A FEW MONTHS AGO WHILE DRIVING AND WHEN I TRY TO PUT IT IN GEAR, SOMETIMES IT WON'T MOVE.I HAVE CALLED FORD, NHTSB AND NO ONE IS WILLING TO MAKE FORD RECALL THESE ISSUES AND FORD WON'T DO THE RIGHT THING KNOWING IT'S AN ONGOING PROBLEM WITH A LOT OF FORDS! PLEASE SOMEONE HELP! I HAVE MULTIPLE SCLEROSIS AND A HEART ISSUE. I NEED A SAFE RELIABLE CAR AND CAN'T AFFORD TO GET ANOTHER ONE. SOMEONE, PLEASE DO THE RIGHT THING HERE! I KNOW ITS AN OLDER MODEL AND I QUESTION IF THIS IS WHY THE RECALL ISN'T HAPPENING.IDK BUT THIS ISN'T RIGHT. THE TRUCK IS SITTING OUT FRONT NEEDING AN ADDITIONAL $700 OF WORK . AFTER REAR END, TIE ROD, BEARINGS, BRAKES IN THE PAST SEVERAL MONTHS, WE HAVE NO WAY TO FIX THIS LEMON. ALWAYS BEEN FORD BUT IF THEY OR A GOVERNING AGENCY DOESN'T HELP.. NEVER A FORD AGAIN. LOOK AT ALL THE COMPLAINTS FOR THE SAME THING!!!! SHAMEFUL.

MY FIANC AND I PUT OUR 10 MONTH OLD AND OUR 8 YEAR OLD IN THE SEATBELTS AND I GOT IN THE CAR (I AM PREGNANT) AND SHUT MY DOOR AND MY FIANC GOT IN AND SHUT HIS DOOR AND THE CURTAIN AIRBAGS WENT OFF AND THE BACK AIRBAGS. WE WERE IN PARK AT THE TIME. THERE WAS NOT REASON FOR THE AIRBAGS TO DEPLOY. I ONLY HAD LIABILITY INSURANCE SO THEY WON'T PAY ANYTHING. I CALLED THE FORD DEALER (WHO I JUST BOUGHT A $50,000 2015 FORD EXPLORER FROM HIM JANUARY 2015) AND HE SAID I COULD CALL THE SERVICE DESK WHO WAS NO HELP. STATED THERE IS NO RECALL. ANYONE I CAN CALL? THIS IS CRAZY AND DANGEROUS!!!!

MY DAUGHTER AND HER FIANC AND PUT THEIR 10 MONTH OLD AND THEIR 8 YEAR OLD IN THE SEATBELTS AND MY DAUGHTER GOT IN THE CAR (SHE IS PREGNANT) AND SHUT HER DOOR AND HER FIANC GOT IN AND SHUT HIS DOOR AND THE CURTAIN AIRBAGS WENT OFF AND THE BACK AIRBAGS. THEY WERE IN PARK AT THE TIME. THERE WAS NOT REASON FOR THE AIRBAGS TO DEPLOY. THEY ONLY HAD LIABILITY INSURANCE SO THEY WON'T PAY ANYTHING. I CALLED THE FORD DEALER (WHO I JUST BOUGHT A $50,000 2015 FORD EXPLORER FROM HIM JANUARY 2015) AND HE SAID I COULD CALL THE SERVICE DESK WHO WAS NO HELP. STATED THERE IS NO RECALL. ANYONE I CAN CALL? THIS IS CRAZY AND DANGEROUS!!!!

MY 2003 FORD EXPLORER REAR PASSENGER, AND REAR LIFT GATE AND WINDOW EXPLODED. IT WAS PARKED IN FRONT OF MY HOME.

TRANSMISSION FAILURE, A COMMON OCCURRENCE IN THESE VEHICLES

MY HINGES TO MY BACK GLASS HATCH KEEP BREAKING AND GLASS KEEPS ALMOST FALLING OFF. I'M AFRAID THAT KIDS MIGHT HIT BUTTON UNDER THE HANDLE THAT POPS IT OPEN AND IT COMES DOWN ON THEM AND HURT THE BADLY!! THIS IS THE 5TH TIME SINCE 2011 THAT THIS HAS HAPPENED AND I CALLED BEFORE TO MAKE SURE WAS NO RECALL AND WASN'T AND STILL ISN'T FOR MY YEARAKE AND MODEL. I HAVE BEEN ABLE TO FIX IT UP MYSELF UNTIL THIS LAST TIME. SO I AM UNABLE TO FIX IT NOW. I FILED A COMPLAINT WITH FORD AND THE GAVE ME THIS SITE AND MY REPORT # FOR THAT CLAIM IS CAS7942030. EACH TIME ITS BEEN PARKED.

THE BRACKETS CONNECTED TO THE LIFTGATE RELEASED WHILE THE CAR WAS PARKED AND LOCKED AND BLEW THE BACK LIFTGATE PANEL OUT ALONG WITH SHATTERING THE GLASS.

I PURCHASED MY 03 FORD EXPLORER BACK IN 2/15. IT LOOKED LIKE I PURCHASED A VERY VERY GOOD USED VEHICLE. EVERYTHING HAS BEEN FINE WITH IT UP UNTIL 2 WEEKS AGO. MY DOOR AJAR LIGHT KEEPS COMING ON WHEN EVERYTHING IS CLOSED, THE OD LIGHT IS BLINKING NON STOP AND THE TRUNK WINDOW OPENS BY ITSELF WHEN I AM DRIVING. WHEN IM DRIVING IT FEELS LIKE THE CAR IS TRYING TO "CATCH UP". LIKE IT KNOWS I'M TRYING TO DO A CERTAIN SPEED BUT ITS WAY BELOW AND AFTER A MIN. OR SO, THEN IT WILL GO THE CORRECT SPEED. I HAD IT HOOKED UP TO A DIAGNOSTIC TOOL AND ITS GIVING ME THE CODE OF P7032 (SOMETHING LIKE THAT). SOMETHING ABOUT 2ND GEAR OF TRANS? IVE BEEN TOLD THAT THIS IS A KNOWN ISSUE WITH THIS MAKE, MODEL AND YEAR.. IVE ALSO READY 100S OF REVIEWS AND COMPLAINTS ON THESE ISSUES. WHAT I DON'T SEEM TO UNDERSTAND IS WHY ISN'T FORD DOING ANYTHING ABOUT THIS???? IF YOU ARE A MANUFACTURER AND SEE ALL THESE COMPLAINTS AND REVIEWS (WHICH I'M SURE THEY DO) THEN WHY AREN'T THESE VEHICLES GETTING RECALLED? I'M NOT RICH IN ANY WAY FASHION OR FORM. I'M A SINGLE MOTHER OF 4 WHO WORKS FULL TIME AND RECEIVES NO GOV'T ASSISTANCE. IF I WOULD HAVE KNOWN THAT THIS IS A "KNOWN" ISSUE I WOULD NEVER HAVE SPENT MY HARD EARNED MONEY.... DOES ANYONE KNOW IF ANYTHING IS BEING DONE ABOUT THIS??

ADJUSTED HVAC TEMPERATURE FROM COLD TO HOT. APPROXIMATELY 5 SECONDS LATER, A LOUD AND REPETITIVE POPPING SOUND CAME FROM THE DEFROSTER VENTS. I WAS STARTLED AND IMMEDIATELY STOPPED THE CAR (ON A 2 LANE HIGHWAY) TO INVESTIGATE. THE BLEND DOOR ACTUATOR IS FAILING. THIS CONDITION WILL CAUSE A LOSS OF CLIMATE CONTROL IN THE CABIN. IT CAN GET STUCK ON HOT OR COLD OR ANYWHERE IN BETWEEN. IF IT GETS STUCK IN THE COLD SETTING, THE WINDSHIELD DEFROSTER WILL NOT WORK WHICH COULD CAUSE AN ACCIDENT DUE TO LOSS OF VISIBILITY. IF IT GETS STUCK ON THE HOT SETTING, HEAT-SENSITIVE PASSENGERS MAY BE INJURED BY HEATSTROKE IN THE SUMMER MONTHS SINCE AIR WILL ALWAYS FLOW THROUGH THE VENTS WHEN THE VEHICLE IS MOVING.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE ACCESSING THE POWER LIFTGATE, THE HINGES FRACTURED AND CAUSED THE DOOR TO ABRUPTLY CLOSE. THERE WERE NO INJURIES. THE LIFTGATE WAS COMPLETELY REMOVED AND PLACED IN THE VEHICLE TEMPORARILY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, THE CHECK ENGINE AND ABS INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE BRAKES FAILED AND THE STEERING WHEEL SEIZED. THE EMERGENCY BRAKE WAS ENGAGED IN ORDER TO COME TO A COMPLETE STOP. THE CONTACT RESTARTED THE VEHICLE AFTER FEW MINUTES AND IT FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.

BEING THAT I AM DISABLED, I'M AFFRAID THAT WHEN THE TRANSMISSION FINALLY GOES COMPLETELY OUT, I'LL BE STRANED SOMEWHERE OR THE SUV WILL CAUSE A WRECK AND HURT/KILL ME OR SOMEONE ELSE. THERE HAVE BEEN THOUSANDS OF COMPLAINTS ABOUT THE TRANSMISSION ON THIS EXPLORER THAT A RECALL SHOULD HAVE BEEN SENT OUT. I CAN NOT AFFORED THE REPAIR COST OR THE COST OF ANOTHER SUV/CAR, PLEASE HELP!

THE O/D OFF LIGHT & CHECK TRANSMISSION LIGHTS WENT ON, THEN VEHICLE WOULDN'T SHIFT PROPERLY AND BECAME INOPERABLE.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 45 MPH, THE TRANSMISSION EXPERIENCED DIFFICULTY SHIFTING FROM FIRST INTO SECOND GEAR. WHEN IT SHIFTED, AN ABNORMAL SOUND WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REBUILT OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 152,000.

I USED MY KEY REMOTE AND POPPED OPEN THE BACK HATCH AND WHILE THE HATCH WAS UP THE HINGE SNAPPED DROPPING THE HATCH ON MY HEAD NEARLY KNOCKING ME OUT COLD.

THERE IS A CRACK IN THE REAR LIFT GATE DOOR. HAVE SEEN THIS ON MANY OTHER FORD, MERCURY, ETC. ALSO THE DOOR AJAR INDICATOR STAYS ON.

TL-THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE CLOSING THAT THE LIFTGATE BOTH HINGES FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE BOTH HINGES AND STRUTS WERE REPLACED. IN 2005, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE) HOWEVER,THE REMEDY WAS INSUFFICIENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,000. JS

OPENED BACK HATCH TO PLACE HELIUM BALLOONS IN; UPON CLOSING THE REAR GLASS EXPLODED. WE HAD THE FULL HATCH OPEN, NOT JUST THE GLASS PART & CLOSED IT AS YOU WOULD NORMALLY.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE GLASS AND THE WINDOW ON THE REAR LIFTGATE PANEL CRACKED. THE CONTACT STATED THAT THE DEALER REPLACED IT THREE TIMES, BUT THE FAILURE OCCURRED BECAUSE THE MATERIAL WAS NOT MADE TO EXPAND OR CONTRACT BASED ON THE WEATHER. THE FAILURE MILEAGE WAS UNAVAILABLE.

WAS LEAVING GAS STATION, SHIFTED FROM PARK TO DRIVE, SHIFT LEVER BROKE OFF INTO MY HAND. OBVIOUSLY A DEFECT, AS I HAVE OVER 2 MILLION MILES UNDER MY BELT, DRIVEN NUMEROUS CARS & TRUCKS, AND HAVE NEVER HAD THIS HAPPEN BEFORE IN OVER 40 YEARS OF DRIVING, BOTH PERSONALLY AND PROFESSIONALLY. I SEE THERE ARE HUNDREDS OF SIMILAR COMPLAINTS FOR THIS, WHY IS THERE NO RECALL?? *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR PASSENGER SIDE LUG NUTS SHEARED OFF THE WHEEL. THE CONTACT STATED THAT THE SAME FAILURE PREVIOUSLY OCCURRED TO THE FRONT DRIVER SIDE WHEEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LUG NUT WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 159,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR WHEELS SHOOK AND DETACHED FROM THE VEHICLE. THE CONTACT REPLACED THE WHEEL BEARINGS, BUT THE FAILURE STILL OCCURRED. THE LUG NUTS WERE TIGHTENED TWICE BY THE DEALER, BUT THE LUG NUTS ON THE REAR WHEELS WERE STILL LOOSE. THE DEALER STATED THAT THEY DID NOT HAVE A REPAIR FOR THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 129,000.

I NOTICED THAT THE PAINT WAS PEELING OFF IN SEVERAL PLACES ON THE VEHICLE. SIX MONTHS LATER MORE PAINT HAS DISAPPEARED. *TR

TL* THE CONTACT OWNED A 2003 FORD EXPLORER. WHILE DRIVING 45 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUFFERED LACERATIONS TO THE LEFT ARM AND REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 260,000. THE VIN WAS UNAVAILABLE.

AS I HAVE BEEN DRIVING LIKE I NORMALLY DO THE O/D LIGHT CAME ON BLINKING. THEN I PRESSED THE BUTTON FOR IT NOTHING HAPPENED. I CONTINUED WITH MY DAILY ROUTINE AND THE LIGHT CAME ON AND OFF. AND CONTINUED TO BLINK. THEN ALL OF THE SUDDEN I WOULD STEP ON THE GAS BUT IT WOULD NOT GIVE ME ANYMORE THAN 15MPH. WHEN I CAME TO A TRAFFIC LIGHT MY CAR DID NOT WANT TO GO ANYMORE SO I HAD TO PULL OVER ON THE SIDE OF THE ROAD. IT DIDN'T WANT TO CONTINUE GOING. THEN AFTER THE THIRD TRY IT GAVE ME MORE GAS TO DRIVE NORMAL NOT EVEN A MINUTE AFTER IT DID IT AGAIN. I WAS AFRAID YO GET HIT BY TRAFFIC AND SINCE I HAD MY THREE TODDLERS I WAS SCARED. I PULLED INTO A SHOPPING CENTER AND CALLED MY DAD. AND ALSO A MECHANIC. IT NEEDS A NEW TRANSMISSION WHEN THAT VEHICLE HAS HAD ALL ITS NEEDS. I CANNOT AFFORD IT AND ITS UPSETTING SEEING ALL THE COMPLAINTS ON CARCOMPLAINTS.COM ABOUT IT KNOWING I AM NOT THE ONLY ONE WITH THIS PROBLEM. THIS IS A DEFECT AND IT SHOULD BE RECALLED. *TR

THE PROBLEM THE SEAT BELTS DOES NOT HAVE ENOUGH SPRING ACTION TO RETRACT CAUSING TO BE LAYING DOWN AND IT IS GETTING CAUGHT BY THE DOOR LOCK MECHANISM MESSING THE BELT PLUS CAUSING THE DOOR NOT TO LOCK PROPERLY, EITHER THE DRIVER OR THE PASSENGER SIDE. THE DOOR CAME UNLOCK SINCE THE HARNESS DID NOT RETRACT. IT NEEDS ATTENTION AND BEING REPLACE BY THE DEALER OR BEING RECALL TO MAKE SURE IT IS REPLACE. THE BELT IS GETTING DAMAGE.

SECOND OWNER OF THIS VEHICLE AND HAD FOR ALMOST A YEAR. DRIVING SON TO SCHOOL AND SUDDENLY HEARD A LOUD RATTLING NOISE UNDER HOOD. TOOK DIRECTLY TO MECHANIC AND FOUND OUT TIMING CHAIN WAS GOING. MECHANIC SAID HE HAD SEEN THIS PROBLEM A LOT IN THIS MODEL AND AROUND THE SAME MILEAGE. *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR HATCH WAS OPEN AND THE HINGES THAT OPENED THE GLASS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,500.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES WERE FRACTURED AND TILTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS ALSO TAKEN TO THE DEALER WHO STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE FAILURE MILEAGE WAS 100,000.

FOR YEARS FORD HAS HAD A POORLY DESIGNED HYDRAULIC MANUAL CLUTCH SYSTEM . OFTEN IMPOSSIBLE TO SHIFT AT RED LIGHT OR WHILE DRIVING AND HAD MANY NEAR REAR END COLLISIONS DUE TO NOT BEING ABLE TO CONTINUE SHIFTING AND MAINTAINING SPEED. FOR OVER A DECADE THE POORLY DESIGNED SYSTEM GETS AIR BOUND RENDERING THE CLUTCH USELESS . THIS IS CAUSED BECAUSE THE HYDRAULIC LINE HAS LOW AND HIGH SPOTS AND AIR BECOMES TRAPPED IN THE HIGH SPOTS AND RESULTS IN LOSS OF CLUTCH OPERATION . THE ENTIRE SYSTEM MUST BE REMOVED AND ELONGATED TO ALLOW AIR TO BE RELEASED FROM SYSTEM . NO BLEEDER VALVE AT MASTER CYLINDER FOR ONE THING . THERE IS A BLEEDER VALVE AT THE SLAVE CYLINDER BUT BECAUSE THE LINE HAS MANY TWIST AND TURNS WITH HIGH SPOTS BLEEDING DOES NOT ELIMINATE AIR TRAPPED IN HIGH SPOTS . THIS IS A WELL KNOW PROBLEM AND A DANGEROUS ONE . FORD COULD CARE LESS . ITS ABOUT TIME FORD ANSWERS AND MODIFIES THIS FAULT . YOU NEED ONLY GO ONLINE AND ENTER FORD RANGER HARD SHIFTING PROBLEMS AND YOU WILL SEE IT IS COMMON PLACE PROBLEM . OF COURSE AFTER THE 36 K WARRANTY THIS BECOMES A COMMON PROBLEM AND FORD TURNS THERE CHEEK . I CANT TELL YOU HOW FRUSTRATING TO BE AT A RED LIGHT AND UNABLE TO SHIFT ALONG WITH NOT BEING ABLE TO SHIFT AT HIGH SPEEDS WITH CARS RUNNING UP YOUR REAR . PLEASE ADDRESS THIS BEFORE LIFE IS LOST . THANK YOU . I URGE ALL RANGER OWNERS TO GET ON BOARD. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE REAR LIFTGATE FIBERGLASS WAS CRACKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

THE MECHANIC CALLED IT A REAR COMPLETE STRUT ASSEMBLY PART OF THE SPRING BACK BY THE BACK WHEEL ON THE DRIVER SIDE IS BROKEN OFF *TR

WHILE THE VEHICLE WAS PARKED IN FRONT OF MY HOUSE, THE REAR WINDOW EXPLODED AND I HAVE A CCTV VIDEO SHOWING IT WAS NOT SMASHED OUT. AFTER READING THAT THERE HAD BEEN A PREVIOUS RECALL ISSUED IN 2004, I CONTACTED FORD TO INQUIRE ABOUT THE RECALL STATUS. THEY INFORMED ME THAT THE PREVIOUS OWNER OF THE VEHICLE HAD ALREADY BROUGHT IT IN FOR THIS RECALL. AFTER THE RECALL REPAIRS TO PREVENT THE REAR WINDOW EXPLOSION, IT STILL EXPLODED LATER ON. *TR

VEHICLE DIED UPON TURNING ONCE AGAIN. THIS IS BECOMING MORE FREQUENT, AS IT HAS HAPPENED TWICE NOW IN THE LAST WEEK. SEEMS TO OCCUR AFTER HIGHWAY SPEED, THEN SLOWING FOR A TURN (TIPICALLY A RIGHT HAND TURN). I CONSIDER MYSELF QUITE MECHANICALLY INCLINED AND I AM BAFFLED. I ALSO OWN AN OBDII SCANNER AND NO CODES COME UP!! THIS IS THE SECOND TIME I HAVE FILED A COMPLAINT, AND WOULD LIKE SOME ANSWERS. VERY DANGEROUS ISSUE IN MY OPINION!! I WILL ALSO BE POSTING THIS ON OTHER WEBSITES TO RAISE AWARENESS, AND HOPEFULLY GET SOME RESULTS!! THIS IS UNACCEPTABLE. *TR

AIR BAG LIGHT BLINKS WHEN STARTED AND THEN REMAINS ON. I HAVEN'T HAD IT CHECKED OUT YET BUT I WAS SEEING IF THERE WAS A RECALL ON THIS TO SEE IF IT WOULD COVER THE COST TO FIX. *TR

IN THE EARLY MORNING HOURS OF DECEMBER 11, I WAS DRIVING TO WORK WHEN WITHOUT WARNING BOTH SIDE CURTAIN AIR BAGS DEPLOYED. THERE WERE NO CARS BEHIND ME AND THERE WERE NO ONCOMING TRAFFIC SO I WAS ABLE TO PULL OFF THE ROAD WITHOUT INCIDENT. UPON INSPECTION THERE WAS NO DAMAGE ANYWHERE TO THE VEHICLE. AS OF NOW THERE IS NO REASON WHY THEY DEPLOYED. *TR

FRONT END ACCIDENT DID NOT DEPLOY DRIVER AIRBAG,HOWEVER PASSENGER AIRBAG DEPLOYED WITH NO OCCUPANT IN SEAT. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE LUG NUTS SHEARED OFF THE WHEELS CAUSING THE REAR PASSENGER TIRE TO BECOME DETACHED FROM THE VEHICLE. THE TIRE CAUSED DAMAGE TO THE VEHICLE AS A RESULT OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.