1997 Ford Explorer complaints

MY 97 FORD EXPLORERS PAINT IS CHECKING VERY BAD ON ALL HORIZONTAL SURFACES AND REAR GATE, AND IS TRAVELING DOWN THE SIDES GETTING PROGRESSIVELY WORSE.

THE VEHICLE IN QUESTION IS A 1997 FORD EXPLORER WITH 38643KM. THE A/C HEATER UNIT WAS BLOWING OUT ONLY COOL AIR. DOES NOT HELP WHEN YOU GET -30C WEATHER AND YOU TRY TO DEFROST YOUR WINDSHIELD WITH COLD AIR. YES IT IS OUT OF THE 3 YEAR WARRANTY PERIOD BUT CERTAINLY NOT THE 60000KM. I DO NOT UNDERSTAND HOW A VEHICLE WITH LESS THAN 40000KM CAN HAVE SUCH A PROBLEM ? FORD'S ANSWER IS AS FOLLOWS: CAUSE: DIAGNOSED-TEMP BLEND DOOR IS BROKE. CORRECTION: REPLACED INTERIOR HEATER CASE. FORD REFUSES TO PAY ANY PORTION BECAUSE IT IS OUT OF WARRANTY. OTHER WEBSITES WITH SAME PROBLEM LISTED: HTTP://WWW.MIGHTYAUTOPARTS.COM/DATA/OTL1200.PDF HTTP://WWW.CARSURVEY.ORG/VIEWCOMMENTS_REVIEW_16717.HTML HTTP://WWW.EPINIONS.COM/CONTENT_66590314116

TRANSFER CASE FAILED WITH NO APPARENT PROBLEMS. WHEN TAKEN APART BY TECH. IT LOOKED PERFECTLY FINE. MUST HAVE COMPLETE REPLACE OF TRANSFER CASE, CAN'T JUST CHANGE PARTS. MSN AUTO-TECS BRINGS UP A NUMBER OF MECHANICS WHO FOUND SAME PROBLEMS. FORD HAS BUILT BETTER AFTER MARKET REPLACEMENT BUT NEVER NOTIFIED ANYONE OF THIS PROBLEM. SOME MECHANICS SAY THAT CUSTOMERS HAVE BROUGHT IN WITH THIS PROBLEM AND THEY HAVE NEVER ENGAGED THEIR 4X4.

HEATER/AC TEMPERATURE CONTROL. TEMPERATURE CONTROL DOOR IS STUCK IN THE POSITION FOR HEAT. HAVE TALKED TO DEALER THEY SAY INEXPENSIVE PART, LABOR FOR REPAIR IS ABOUT 7 HOURS TO BE CHARGED FOR. THIS DEALER HAS HAD OTHER COMPLAINTS AND FIXED SOME. CHECKED WITH OTHER DEALERS IN AREA, THEY GAVE SAME ANSWER AS TO COST AND COMPLAINTS. I AM TOLD THIS IS A PLASTIC BRACKET ON DOOR ASSEMBLY THAT BREAKS WHEN SERVO MOVES DOOR TO CONTROL HOT OR COOL AIR FLOW.*AK

REAR DOORS WON'T OPEN FROM INSIDE AND IT IS NOT THE CHILD DETERRENT LEVER ON DOOR, HEATING SYSTEM OVERRIDES A/C HEATER SOMETIMES DOSEN'T WORK. RECLINE LEVER BROKE OFF. *AK

WHILE DRIVING AT 35 MPH CONSUMER HEARD A NOISE, THEN VEHICLE STALLED. THE SPARK PLUGS BLEW OUT. AN INDEPENDENT TECHNICIAN INDICATED THAT ENGINE CYLINDER NEED TO BE REPLACED. *AK

TRANSMISSION OUT BEFORE I REACHED 87,000 MILES. WHEN MY HUSBAND CHANGED THE TRANSMISSION FLUID, LARGE CHUNKS OF METAL CAME OUT. THE PROBLEM OCCURED WHEN DRIVING HOME FROM KROGERS AND VEHICLE DID NOT SHIFT OUT OF 2ND GEAR, RMPS WENT UP PAST 4000, THEN VEHICLE WOULD LOSS POWER. WOULD TAKE MY FOOT OFF GAS TIL RMPS 0, THEN REPEAT THIS CYCLE FOR MY 5 MILES HOME. MY HUSBAND TOWED VEHICLE TO PEFFLEY FORD OF DAYTON, OHIO ON DEC 24, 2003. THEY SAID THIS IS NORMAL FOR THAT MANY MILES, BUT ACCORDING TO MY SEARCH, THIS IS NOT. FORD TRANSMISSIONS HAVE BEEN PROBLEMS FOR OTHER BUYERS. COULD HAVE BEEN FATAL IF I WAS ON INTERSTATE. WE ARE BEING CHARGE $2100 FOR A NEW TRANSMISSION, TODAY IS JAN 1, 2004 AND I DON'T EVEN HAVE IT BACK.*AK

THE DRIVER'S SHOULDER HARNESS WILL NOT UNBUCKLE. I WOULD LIKE TO KNOW IF THERE HAVE BEEN SIMILIAR PROBLEMS REPORTED TO NHTSA. THE LOCAL FORD DEALER HAS SPECIAL ORDERED THE PART (FMC F87Z 7861203 AAA).*AK

VEHICLE DEVELOPED UNDERCARRIAGE PROBLEMS AND CAUGHT ON FIRE. *MR *SC *JB

THE TRUCK'S OVERDRIVE LIGHT BLINKED AND THE ENGINE LIGHTS CAME ON. WHEN THIS OCCURRED THE TRUCK FAILED TO GO INTO OVERDRIVE AND THE # 3 CYLINDER MISFIRED. THE DEALERSHIP INDICATED THIS COULD BE CAUSED BY AUTOMATIC TRANSMISSION FAILURE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NLM

WHILE DRIVING SERPENTINE BELT CAME OFF, AND DRIVER LOST CONTROL OF THE VEHICLE. ALSO, WHEN BRAKING THERE WAS A GRINDING NOISE. *AK

THE CONSUMER NOTICED THE DRIVER SIDE SEAT BACK RECLINED BACKWARDS AFTER OPENING THE DRIVER'S SIDE DOOR. PRIOR TO THIS INCIDENT, THE CONSUMER HAD INFORMED THE DEALERSHIP THAT THE SEAT WAS LOOSE AND ROCKED. THE DEALER PROVIDED NO ASSISTANCE. RECALL 03V281000 WAS ISSUED FOR THE HIGH BACK SEAT, HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO THE VEHICLE IDENTIFICATION NUMBER. *AK *SCC *JB

CONSUMER RECEIVED RECALL 98060000 CONCERNING FUEL LINE RUPTURE; HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. WHILE ATTEMPTING TO CHARGE THE BATTERY, THE CONSUMER CONNECTED THE CABLE TO THE FUEL LINE BRACKET. THIS CAUSED THE FUEL BRAID TO OVERHEAT, CAUSING THE FUEL LINE TO RUPTURE. *AK

THE DIAL THAT CONTROLS THE HOT/COLD FEATURE OF THE HEATING/AIR-CONDITIONING UNIT IN MY 1997 EXPLORER MALFUNCTIONED. WHEN TAKEN IN TO DEALER THE SERVICE MANAGER TOLD ME THAT THEY HAVE BEEN SEEING ALOT OF THIS PROBLEM IN EXPLORERS AND THE SERVICE TECHNICIAN SAID HE WAS CONCERNED WITH IT HAPPENING IN HIS MOTHER'S CAR. *AK

LOSS OF REVERSE. FAILURE OF BEARING RACE ABOVE VALVE BODY CAUSED FLUID TO BE PORTED TO BOTH FORWARD AND REVERSE DRIVE AT SAME TIME. WHEN REVERSE WAS SELECTED, THE VEHICLE WOULD ONLY TRAVEL IN REARWARD DIRECTION TWO TO THREE FEET BEFORE BINDING AND ALL MOTION CEASED. DRIVE FORWARD WAS NOT ADVERSELY EFFECTED BEFORE THE REPAIRS WERE COMPLETED. FORD MOTOR COMPANY RECOMMENDED THE REPLACEMENT OF THE TRANSMISSION WITH A REBUILT UNIT AT THE COST OF $2800. WITH ONLY 61000 MILES ON THE VEHICLE, I OPTED FOR A SECOND OPINION. A RELIABLE TRANSMISSION SHOP DIAGNOSED THE PROBLEM WITH THE "EXPLODER" TRANSMISSION AND COMPLETELY REBUILT THE UNIT FOR HALF THE FORD REPLACEMENT COST. *LA

HEATER BLEND DOOR HAS BROKEN, SO DEFROSTER DOES NOT WORK. DIFFICULTY SEEING OUT FRONT WINDOW IN COLD WEATHER. THIS APPEARS TO BE A COMMON PROBLEM, FOR WHICH I WAS QUOTED A $900 REPAIR. *LA

TEMPERATURE CONTROL BLEND DOOR DOES NOT WORK PROPERLY. STUCK ON COLD. UNABLE TO DEFROST AND DEFOG WINDOWS. *LA

WHILE DRIVING DRIVER HEARD A LOUD NOISE COMING FROM THE FRONT OF THE VEHICLE. CONSUMER HAD THE VEHICLE TOWED TO A DEALERSHIP. MECHANIC INFORMED CONSUMER THAT WHEEL BEARINGS FAILED. *AK

CANNOT ADJUST THE TEMPERATURE OF THE HEATING AND COOLING SYSTEM - ALWAYS BLOWS COLD AIR. I HAVE BEEN TOLD THE MANUFACTURER INSTALLED THE WRONG PARTS AT TIME OF PRODUCTION. THE PART FAILS AND THEN YOU CANNOT ADJUST THE TEMPERATURE - IT ALWAYS BLOWS COLD AIR. THIS, IT SEEMS TO ME, IS A SERIOUS SAFETY ISSUE AS IT IS IMPOSSIBLE TO KEEP WINDOWS CLEAR IN COLD CLIMATES. *LA

CONSUMER TURNED ON THE IGNITION SWITCH AND THE ALARM CHIMED, INDICATING THAT A DOOR WAS AJAR. DRIVER GOT OUT TO CHECK THE DOORS. HEARD SOMETHING THAT SOUNDED LIKE THE GEAR WAS ENGAGING. THEN VEHICLE SUDDENLY BEGAN TO ROLL BACKWARDS. CONSUMER GRABBED THE STEERING WHEEL BUT WAS DRAGGED 300 FEET BEFORE THE VEHICLE CAME TO A STOP BY SLAMMING INTO A NEIGHBOR'S HOUSE.*AK

THE VEHICLE AUTOMATICALLY POPPED INTO 4X4 MODE WITHOUT WARNING. WHEN THAT HAPPENED THE VEHICLE MADE A LOUD GRINDING NOISE AND STOPPED IN THE MIDDLE OF TRAFFIC. *NLM THE VEHICLES WIPERS ALSO BECAME INOPERABLE. THE WINDOWS COULD NOT BE OPENED. THE INTERIOR LIGHTS FAILED. IT WAS LATER DETERMINED THAT ALL THESE FAILURES WERE AS A RESULT OF A FAULTY GEM MODULE. THE MODULE HAS BEEN RECALLED IN CANADA. *TS *NLM

IN A ROLL OVER CRASH CONSUMER'S DAUGHTER WAS KILLED DUE TO REAR SEAT BELT BUCKLE DISCONNECTING, AND SHE WAS EJECTED FROM FRONT WINDSHIELD.*AK

DEFROSTER DOES NOT DEFROST/DEFOG WINDSHIELD DUE TO THE HEAT/AC BLEND DOOR BEING BROKEN. COMMON PROBLEM FOR FORD EXPLORERS. FORD IS REMISS IN NOT RECALLING THE VEHICLE TO FIX THIS HAZARDOUS CONDITION. *JB

THE VEHICLE EXPERIENCED THE SAME PROBLEM WITH THE CRUISE CONTROL AS STATED IN RECALL 99 V 062 00, BUT THE VEHICLE WAS INCLUDED IN THE RECALL. THE CONSUMER STATED THE CRUISE CONTROL FAILED TO DISENGAGED, THE PROBLEM HAPPENED THREE TIMED. *AK *JB

WHILE DRIVING DRIVER'S SEAT BACK FELL, CAUSING THE VEHICLE TO VEER ACROSS THE ROAD. *AK

NHTSA# 03-V-281-000 ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. THE CONSUMER HAS THE SAME PROBLEM. *PH

CONSUMER STATES REAR DOORS WILL NOT LOCK OR UNLOCK DUE TO LATCHES BREAKING. DOOR LATCHES HAD BEEN REPAIRED FOUR TIMES.*AK

ENGINE SURGING WHEN COLD. I HAVE HAD THE CODES READ AND WILL NOT TELL WHAT THE PROBLEM IS. POOR GAS MILEAGE. VALVES RATTLING WHEN START UP OF ENGINE FOR SEVERAL SECOUNDS AND THEN STOPS RATTLING. BLACK SUTT IN EXHAUST PIPE.*AK

DURING A VEHICLE INSPECTION SEVERAL PROBLEMS WERE FOUND. THE CHILD SAFETY LOCK ON THE PASSENGER SIDE REAR DOOR WAS BROKEN AND THE DRIVER SIDE TAIL LIGHT DOESN'T WORK. PLEASE PROVIDE DETAILS.

WHILE DRIVING AT A LOW SPEED IN THE DRIVEWAY SPARE TIRE DETACHED FROM VEHICLE. DRIVER FOUND THE CABLE THAT WAS HOLDING THE TIRE, IT LOOKED SHREDDED. *AK

SEAT BELTS IN BACK SEAT AND SPEED CONTROL WILL NOT CANCEL AFTER BEING SET. A LADY HAD LATCH HER SEAT BELT IN THE RIGHT REAR SEAT,AND IT WOULD NOT RELEASE HAD TO CUT THE BELT TO GET HER OUT.*AK

ABOUT THREE MONTHS AGO AIR BAG LIGHT ILLUMINATED. CONSUMER TOOK VEHICLE TO AN INDEPENDENT MECHANIC LAST MONTH WHICH STATED CLOCKSPRING HAD TO BE REPLACED. *AK

CONSUMER STATES THAT AFTER DRIVING VEHICLE KEYS CAN BE REMOVED AND VEHICLE WILL STILL OPERATE AS THOUGH KEYS ARE STILL IN IT. ALSO, VEHICLE WILL START UP ON ITS OWN BEFORE THE KEY IS INSERTED.*AK

WHEN APPLYING BRAKES VEHICLE LURCHES FORWARD. DEALER NOTIFIED.*AK

CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING REAR WINDOW SHATTERED. DEALER NOTIFIED. *AK

CONSUMER TOOK VEHICLE INTO INSPECTION STATION AND DIDN'T PASS INSPECTION BECAUSE OF THE TIMING BELT WAS MAKING NOISE. DEALER STATED IT WOULD COST ABOUT $1500.*AK

DRIVER'S SEAT BELT BUCKLE FAILED TO UNLATCH. THE CONSUMER HAD TO USE A SCREW DRIVER TO PRY IT OPEN. *AK *SCC *JB

CONSUMER STATES VEHICLE WAS INVOLVED IN A COLLISION, DRIVER'S SIDE SEAT BELT DID NOT RESTRAIN OCCUPANT. AS A RESULT, DRIVER SUSTAINED MASSIVE HEAD INJURIES. DEALER NOTIFIED.*AK

WHILE DRIVING AT 65 MPH VEHICLE SUDDENLY STARTED TO DECREASE IN SPEED WITHOUT WARNING. ENGINE HAD BLOWN.*AK

I HAVE EXPERIENCED LOSS OF POWER IN THE ENGINE IN MY 1997, FORD\EXPLORER(PURCHASED USED, IN JUNE OF 1999) CAUSING ME TO LOSE MY BRAKES WHILE DRIVING, I HAVE TAKEN THIS VEHICLE TO SEVERAL MECHANICS (FOR DIAGNOSIS) AND HAVE BEEN TOLD THAT THIS IS A RECURRING PROBLEM, THAT FORD KNOWS ABOUT, AND THAT THERE IS SOMETHING DEFECTIVE IN THE TIMING SYSTEM, AND I SHOULD TAKE IT TO THE DEALER, FOR FURTHER DIAGNOSTICS, AFTER TAKING IT TO THE DEALER I WAS TOLD, THAT THE TIMING CHAIN AND TIMING CASETTE HAD WENT AND THAT THERE HAD BEEN A SERVICE BULLETIN OUT PERTAINING TO THIS PROBLEM AND THAT OWNERS HAD BEEN NOTIFIED, HOWEVER I WAS NEVER NOTIFIED THAT THERE WERE PROBLEMS WITH THE ENGINE IN THIS VEHICLE, THE DEALER ALSO TOLD ME THAT IT WOULD COST ME $4500.00 FOR A REMANUFACTURED ENGINE-REPLACEMENT BECAUSE THE CAR WAS BEYOND THE MILAGE OF THE SERVICE BULLETEN. AFTER PAYING $28,000.00 FOR A VEHICLE, AS A CONSUMER I WOULD NOT EXPECT TO BE SUBJECT TO REPETITIVE SAFETY CONCERNS FOR SELF, FAMILY AND THE PUBLIC AT LARGE, ESPECIALLY WHEN THE MANUFACTURER KNOWS OF THE DEFECTIVE PRODUCT (1997 EXPLORER), AND THEN TOLD THAT I MUST PAY THE AMOUNT IT WOULD COST FORA DOWN PAYMENT ($4500.00) ON A NEW VEHICLE, JUST TO KEEP MY INVESTMENT SAFELY ON THE ROAD. EVERYTIME I HAVE TAKEN THIS VEHICLE TO THE DEALER I HAVE BEEN ROBBED OF MY FINANCES AND DIGNITY. I SHOULD NOT HAVE TO KEEP PAYING FOR REPAIRS OF THIS CAR, WHEN FORD KNOWS THEY HAVE MANUFACTURED A DEFECTIVE PRODUCT. THIS IS NOT THE FIRST TIME I HAVE HAD TO

RIGHT REAR WHEEL DETACHED FROM 1997 EDDIE BAUER EXPLORER ON FREEWAY NEAR RAWLINS WYOMING ON 7-3-03 THE RATE OF SPEED WAS APPROX. 70 MPH THE REAR TIRES WERE REPLACED ABOUT 4000 MILES PRIOR TO THE INCIDENT. I WITNESSED THE INSTALLER TORQUE THE LUGNUTS TO SPECS.*AK

AIR CONDITIONER DOES NOT COOL AND DRIVER SIDE LOCK DOES NOT WORK. *AK

THE VEHICLE WAS INVOLVED IN A HEAD ON COLLISION BUT NONE OF THE AIRBAGS DEPLOYED UPON IMPACT. *NLM *TS *SCC *NLM

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITH NO WARNING STEERING BOLTS ARE LOSE AND IT IS CAUSING THE STEERING WHEEL TO JUMP AROUND, MAKING IT HARD FOR CONSUMER TO STEER THE VEHICLE. DEALER NOTIFIED.*AK

VEHICLE EXPERIENCED THE SAME DEFECT WITH ITS SPEED CONTROL AS STATED IN RECALL 99 V 062 001, BUT IT'S VIN NUMBER IS NOT INCLUDED.*AK

IN MANY OCCASIONS I HAD TURNED OFF THE CRUISE CONTROL AND THE CAR HAD CONTINUE TO ACCELERATE. MY GAS PEDAL HAS GOTTEN STUCK TOO MANY TIMES. WELL TODAY WAS THE BEST OF ALL. MY CAR FELT FOR A FEW DAYS THAT IT DID NOT ACCELERATE WHEN I PRESSED ON THE PEDAL. I TOOK IT IN YESTERDAY TO HAVE THE OIL CHANGED AND SEE WHAT THE MATTER WAS. NOTHING WAS FOUND WRONG WITH THE CAR BY THE MECHANIC. WELL, TODAY I FOUND OUT WHAT THE MATTER WAS. AS I WAS DRIVING ON MY WAY TO MY SON'S DAYCARE THE ACCELERATOR PEDAL CAME OFF THE FLOOR. I HAD NO PEDAL. I PULLED TO THE SIDE AND INDEED THE CABLE AND PEDAL WERE LAYING ON THE FLOOR. I MANAGED TO GET TO THE MECHANIC BY TRYING THE CAR TO MOVE. THE MECHANIC SAID THAT THE CABLE SNAPPED AND THAT IT HAD TO BE REPLACED. *NLM

I HAVE TO PUSH EXTRA HARD ON THE PEDAL TO ACCELERATE BECAUSE IT FEELS STUCK. WHEN AND WHEN THE PEDAL FINALLY GETS LOOSE, THE CAR ACCELERATES ABRUBTLY. *AK

VEHICLE ACCELERATED AT AN UNSAFE SPEED. *TT

THE VEHICLE STARTED TO MAKE LOUD NOISE, THE CONSUMER LEARNED THERE WAS A RECALL, BUT THE RECALL NOTICE WAS PROBABLY MAILED TO THE ORIGINAL OWNER. *JB

PREPARING TO BRAKE FOR A CORNER ON A RAINY NIGHT, THE ANTI-LOCK BRAKES LOCKED THE WHEELS AND SLID ME INTO AN ONCOMING TRAFFIC LANE AT ABOUT 35 MILES PER HOUR. THE ONCOMING VEHICLE SWERVED AND AVOIDED A HEAD ON COLLISION WITH ME. ABOUT 20 SECONDS LATER DOWN THE ROAD THE ANTI-LOCK BRAKES LOCKED AGAIN AS I TURNED INTO MY DEVELOPMENT AND AGAIN I SLID. VEHICLE HAS BEEN SERVICED THROUGH ITS LIFE AND HAS A LITTLE OVER 52,000 MILES ON IT. I COULD BE DEAD RIGHT NOW HAD I NOT BEEN A SLOWER HIGHWAY. IT APPEARS THIS PROBLEM HAS EXISTED SINCE THE VEHICLE WAS PRODUCED AFTER READING ALL OF THE COMPLAINTS ON THIS SITE. *JB