1997 Ford Explorer complaints

PARKED ON A SLIGHT SLOPE WITH THE ENGINE OFF, MY 97 FORD EXPLORER ROLLED BACK 5 FEET BY ITSELF, COMING CLOSE WITH COMING TRAFFIC! *NM

I RETURNED FROM A TRIP TO NOTICE THAT THE SPARE ON MY 1997 FORD EXPLORER HAD "DISAPPEARED". SEEMS THAT THE CABLE THAT HOLDS IT HAD RUSTED OUT AND GIVEN WAY DROPPING THE SPARE WHO KNOWS WHERE. I HAD NEVER USED THE SPARE AND HAD ONLY NOTICED THINKING I HAD SEEN FLUID UNDER MY CAR. I HAVE THE CAR INSPECTED FOR STATE PURPOSES AND NOTHING WAS EVER SAID TO ME. I MENTIONED THE OCCURRENCE TO AN ONLINE BUDDY AND HE SAID THE SAME HAD HAPPENED TO HIM. ANOTHER ACQUAINTANCE SAID HE HAD IT HAPPEN WITH HIS PICK UP TRUCK. I CALLED MY FORD DEALER AND WAS TOLD THEY HAD A REPLACEMENT "WINCH & CABLE" IN STOCK SO I THOUGHT WHAT HAPPENED TO ME WAS NOT A RARE OCCURRENCE AND WAS RECALL WORTHY. IT CERTAINLY IS A SAFETY HAZARD AND I HAVE NO CLUE WHAT HAVOC MY SPARE MAY HAVE CREATED ON THE HIGHWAY OR WHEREVER IT DROPPED. *JB

THE BLEND DOOR ON MY 1997 FORD EXPLORER FAILED. THIS FAILURE DID NOT ALLOW PROPER DE-FOGGING OF THE WINDSHIELD. *NM

DT*: THE CONTACT STATED WHILE DRIVING 20MPH A VEHICLE COLLIDED WITH THE CONTACT'S VEHICLE. THIS WAS A SIDE AND FRONTAL IMPACT AND THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. THE SEAT BELTS WERE IN USE. NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP. UPON INSPECTION THE STEERING WHEEL WAS SEPARATED THREE MILLILITERS AS IF THE AIR BAG WAS GOING TO DEPLOY. THE AIRBAG WARNING AND CHECK ENGINE LIGHT WERE ILLUMINATED. THE MANUFACTURER HAS NOT BEEN ALERTED AND NO REPAIRS WERE MADE.

REGARDING RECALL 00V402000 ON SWAY BAR PROBLEMS I ALSO WAS TOLD MY VEHICLE WAS BEYOND THE RECALL DATE HOWEVER THE SAME PARTS HAVE BROKEN JUST AS THE RECALL STATES. *JB

THE HEATER BLEND DOOR FAILED ON MY 1997 FORD EXPLORER WHILE DRIVING IT IN SNOWY CONDITIONS. I ONLY HAD COLD AIR BLOWING ON MY WINDOWS. AFTER REVIEWING WEB SITES, I HAVE FOUND THAT THE TOP PIECE OF MY HEATERS HOT AND COLD BLEND DOOR IS BROKEN. THE COST OF REPLACING THIS ONE PIECE OF PLASTIC IS AROUND $1000. FORD HAS A REPLACEMENT PART THAT IS NOW STRONGER, BUT FAILS TO REALIZE THE DEFECT IN THE OLDER DOORS. *NM

1997 FORD EXPLORER REAR WHEEL BOUNCED AND TIRE TREAD CAME OFF. *TS *JB

DT: THE CONTACT STATED WHEN ATTEMPTING TO STOP AT A STOP SIGN THE VEHICLE SUDDENLY ACCELERATED AND IT WENT THROUGH THE STOP SIGN AND THEN CAME TO A STOP WHEN PLACED INTO NEUTRAL. THE VEHICLE ACCELERATED SUDDENLY TWO MORE TIMES BEFORE THE CONTACT WAS ABLE TO TAKE VEHICLE TO THE DEALERSHIP. IT OCCURRED WHILE AT A COMPLETE STOP. AGAIN THE BRAKES WOULD NOT HOLD AND THE VEHICLE WAS PLACED INTO NEUTRAL TO GET IT TO STOP. THE VEHICLE IS CURRENTLY AT THE DEALER FOR DIAGNOSTIC TESTING, WHICH HAS NOT BEEN COMPLETED AT THIS TIME. *AK UPDATED 12/27/2005 - WHEN THE VEHICLE WAS STARTED COLD IT WOULD NOT STAY ON AND IDLED ERRATICALLY. THE DEALER INFORMED THE CONSUMER THAT THE ACCELERATION PROBLEM AND IDLE PROBLEM WERE DUE TO A FAULTY THROTTLE SENSOR. THE DEALER REPLACED THE THROTTLE VALVE ASSEMBLY BUT THAT DID NOT CORRECT THE PROBLEM.*NM

DT: THE CONTACT STATE VEHICLE HAD BEEN REPAIR UNDER NHTSA RECALL 98V060000/ MANUFACTURER'S RECALL 98S09 BEFORE BY THE PREVIOUS OWNER. WHEN SHE CONTACTED THE DEALERSHIP THEY SAID THE RECALL REPAIRS WERE DONE ON JANUARY 9, 2001. SHE WAS HAVING THE SAME PROBLEM AS STATED IN THE RECALL. THE CONTACT'S HUSBAND HAD TO JUMP START THE VEHICLE ON JANUARY 24, 2005. IMMEDIATELY AFTER HE HAD DONE SO HE SMELLED FUEL INSIDE THE VEHICLE. WHEN HE TOOK VEHICLE TO A DEALERSHIP THEY FOUND TWO HOLES IN THE FUEL LINE. THEY HAD THE FUEL LINE REPLACED AT THEIR EXPENSE. THE PROBLEM HAPPENED AGAIN ON OCTOBER 15, 2005. THE CONTACT'S HUSBAND HAD TO JUMP START THE VEHICLE AGAIN. AFTER EXAMINING THE FUEL LINE HE FOUND THERE WERE TWO HOLES IN THE EXACT SAME SPOTS. SHE TOOK IT TO A FORD DEALER, AND THEY TOLD HER THAT THERE HAD BEEN A RECALL ON THE VEHICLE. *AK

CRUISE CONTROL UNDER THE HOOD CAUSED POWER OUTAGE TO OVERHEAD TEMPERATURE/DIRECTION DISPLAY. WHEN TAKEN TO DEALERSHIP FOR REPAIR THE TECH ALONG WITH THE SERVICE MANAGER,INDICATED THAT SPARKS AND SMOKE WAS COMING FROM THE CRUISE CONTROL LOCATED UNDER THE HOOD WHEN POWER WAS APPLIED. THIS IS THE SAME CRUISE CONTROL THAT HAS CAUSED ACCIDENTS AND DEATH. THIS CRUISE CONTROL IS THE SAME ONE THAT HAS SPARKED A LARGE RECALL FROM FORD BUT THE FORD MOTOR COMPANY ELECTED NOT TO INCLUDE THE EXPLORER. *NM

TEMPERATURE OUT OF CONTROL, DEFOGGING/DEFROSTING CHALLENGED ON A 1997 FORD EXPLORER. WAS TOLD IT WILL IT IS DUE TO DEFECT IN THE AIR BLEND DOOR. I CAN'T DEFROST THE WINDOWS WHICH COULD BE AN ACCIDENT WAITING TO HAPPEN. *NM

I HAVE A 1997 FORD EXPLORER THAT CAUGHT FIRE. THE FIRE ORIGINATED AROUND THE WIRING HARNESS IN AND AROUND THE MASTER CYLINDER. WHEN MY VEHICLE CAUGHT FIRE I LOST MY BRAKES INSTANTLY.*JB

1997 FORD EXPLORER DEVELOPED TWO FAILURES OF THE BRAKE LINE.***NO ANSWER REQUIRED***. *MR THE CONSUMERS WIFE EXPERIENCED A LOSS OF BRAKES DUE TO THE FAILURE OF THE BRAKE LINE ABOVE THE REAR AXLE. THE INCIDENT HAPPENED A SECOND TIME, BUT THERE WAS NO ACCIDENT, BOTH FAILURES WERE CAUSED BY CORROSION. *JB

DT: 1997 FORD EXPLORER. THE CONSUMER STATES THE FOUR WHEEL/ TWO WHEEL LIGHTS ARE FLASHING ON AND OFF. THIS WILL HAPPEN UNTIL THE VEHICLE IS TURNED OFF. THE VEHICLE AUTOMATICALLY ENGAGES INTO FOUR WHEEL DRIVE. THE ONLY WAY ONE CAN TELL THIS HAS HAPPENED IS FROM THE POPPING AND CRACKING NOISES COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO CUMBERLAND FALLS FORD TWICE. THEY HAVE NOT BEEN ABLE TO DIAGNOSE THE PROBLEM. THE VEHICLE WAS ALSO TAKEN TO A LOCAL MECHANIC, THEY THOUGHT IT WAS THE SWITCH. THE TRANSFER SWITCH WAS REPLACED, BUT THE PROBLEM RECURRED. THE VEHICLE AUTOMATICALLY SLOWS DOWN WHEN IT GOES INTO FOUR WHEEL DRIVE.*AK

THE CRUISE CONTROL ON OUR 1997 FORD EXPLORER STOPPED WORKING. I CALLED AND CHECK TO SEE IF THERE WERE ANY RECALLS ON THIS PROBLEM BECAUSE WE KNOW OF THE EXPEDITION HAVING PROBLEMS WHERE THIS WAS CAUSING FIRES TO START WITH THE VEHICLE. WE WERE TOLD THIS DID NOT INVOLVE THE EXPLORER. I WAS CONCERNED BECAUSE I FEEL THAT THERE COULD BE A CONNECTION. WE HAD THE REPAIRS DONE BUT I FELT THAT THIS NEEDED TO BE REPORTED. I ALSO FEEL THAT FORD SHOULD BE REQUIRED TO REPORT TO THE NHTSA EACH TIME THE FORD EXPLORER HAS TO REPAIR CRUISE CONTROL FAILURES TO HELP DETERMINE IF THERE IS A PROBLEM THAT IS WIDESPREAD. *JB

BRAKE FAILURE LEAVING PERSONNEL RESIDENCE (NOTED ABOVE). REAR STEAL BRAKE LINE BURST LEAKING BRAKE FLUID AND DE-MOBILIZING BRAKE SYSTEM (PEDAL WENT TO THE FLOOR, STOPPED THE VEHICLE WITH EMERGENCY BRAKE). LEAK WAS IN THE MIDDLE OF THE VEHICLE. BRAKE LINE BETWEEN THE REAR AXLE AND SPARE TIRE. BRAKE LINE WAS RUSTED AWAY. LOCAL REPAIR SHOP REPLACED THE LINE. *JB

1997 FORD EXPLORER DEVELOPED A DEFECT IN THE DEFROSTER AND DEFOGGER SYSTEM. *MR THE PROBLEM WAS DUE TO A BROKEN PLASTIC DOOR IN THE A/C/HEATER PLENUM. THIS CREATED A CONDITION OF FOGGING THE WINDSHIELD UNCONTROLLABLY AND IMPAIRING THE DRIVERS VISION. *SC

OVER ROUGH PAVEMENT OR ENTERING RAMPED DRIVEWAYS AT AN ANGLE, VEHICLE ROCKED SIDE-TO-SIDE MORE THAN NORMAL, WITH AN OCCASIONAL "CLUNK". INSPECTION REVEALED A BOLT HOLDING THE ANTI-ROLL BAR TO THE UPPER CONTROL ARM HAD RUSTED AND FAILED, RENDERING THE ANTI-ROLL BAR NON-FUNCTIONAL. GIVEN THE PROPENSITY OF THIS TYPE OF VEHICLE TO ROLL OVER IF DRIVEN IMPROPERLY, THIS FAILURE INCREASES THE RISK / DECREASES THE ROLLOVER THRESHOLD. *NM

ENGINE CRANK BROKE OFF AT PULLEY. NO PREVIOUS WARNING, IT HAPPENED WHILE DRIVING AT LOW SPEEDS. 110 MILES ON ENGINE AT TIME OF CATASTROPHIC FAILURE. DEALERSHIP LAUGHED AT REQUEST FOR REPAIRS, "WARRANTY EXPIRED". I PAID FOR NEW "REBUILT ENGINE" COST= $3000.00. *NM

WHILE DRIVING ON THE I15 INTERSTATE FREEWAY AND MAKING A MERGE ONTO CALIFORNIA STATE HIIGHWAY 78 IN HEAVY TRAFFIC THE ACCELERATOR PEDDLE BRACKET BROKE AWAY FROM THE ENGINE FIREWALL WHERE IT HAD BEEN SPOT WELDED. AFTER SEVERAL NEAR COLLISIONS, I MANAGED TO PULL OFF OF THE FREEWAY. UPON CLOSE INSPECTION I SAW THAT THE SPOT WELDS HOLDING THE BRACKET TO THE ENGINE FIREWALL HAD FAILED, ALLOWING THE BRACKET TO PULL AWAY FROM SUPPORT RENDERING THE ACCELERATOR PEDDLE USELESS. AS OF TODAY, 7/25/2005, I HAVE NOT YET REPORTED THE INCIDENT TO FORD MOTOR COMPANY AS I WANTED TO FIND OUT IF SIMILAR INCIDENTS ON THE 1997 FORD EXPLORER HAVE BEEN REPORTED.

SEVERAL PROBLEMS WITH THIS AUTO, IT SEEMS TO BE FALLING APART. THE DRIVER SIDE SEAT BELT NO LONGER LATCHES. WE HAVE TO LOOP THE DRIVER SIDE THROUGH THE PASSENGER SIDE. IT APPEARS THIS IS AN ISSUE WITH SEVERAL OF THESE MODELS. THIS IS A SERIOUS SAFETY HAZARD AND SEAT BELTS ARE MANDATORY BY LAW. IS THERE ANYTHING BEING DONE? THE LEFT TURN INDICATOR HAS HAD ELECTRICAL ISSUES FOR YEARS. IT MAKES A ZZZZ SOUND AND NO LONGER WORKS. I AM ALSO DOWN TO ONLY ONE DOOR THAT THE KEY WORKS ON. THAT IS THE BACK LIFT. THE DOOR KEY HAD NOT WORKED ON THE DRIVER SIDE FOR YEARS, THEN THE PASSENGER SIDE WENT. I HAVE THE SAME HEAT PROBLEM THE OTHERS ARE HAVING. YOU EITHER GET FULL ON HEAT AND HAVE TO TURN IT ON AND OFF WHEN IT GETS TOO HOT OR YOU GET PARTIAL AC, ALWAYS A LITTLE WARM. BOTH THE AC AND HEAT HAS BEEN SERVICED, THE PROBLEM IS IN THE SWITCH SOMEWHERE. AND NOW THE REASON I'M WRITING IS I HAVE MAJOR ELECTRICAL PROBLEMS. FUSES AND SOLINOIDS HAVE BEEN LOOKED AT, THERE ARE NO LONGER LIGHTS IN THE DASH AREA. THE LIGHTS ON ALARM (DING DING DING DING) REMAINS ON WHEN THE CAR IS OFF, THE KEYS OUT AND THE DOOR SHUT WHICH HAS DRAINED MY BATTERY COMPLETLY. I HAVE JUMPED STARTED IT TWICE AND NOW IT SITS IN MY DRIVEWAY BECAUSE IT WILL COST A FORTUNE TO HAVE THE ELECTRICAL LOOKED AT. IF THIS IS AN ISSUE WITH ANYONE ELSE IT SHOULD BE REPORTED TO FORD. NOT ONLY CAN I NO LONGER DRIVE THIS CAR, IT WOULD BE TOTALLY UNSAFE TO USE IT. I NEED 4WHEEL DRIVE JUST TO GET OUT OF MY DRIVEWAY IN WINTER AND HAVE NO ID

DT: THE ENGINE LIGHT CAME ON. CONSUMER TOOK VEHICLE TO DEALER ,WHO SAID THEY COULD NOT GET IT IN UNTIL SATURDAY FOR REPAIRS. TUESDAY THE VEHICLE CAUGHTON FIRE WITH THE ENGINE NOT RUNNING. THE VEHICLE HAD BEEN PARKED WITH ENGINE TURNED OFF FOR ABOUT 5 MINUTES , AND WHEN CONSUMER RETURNED THE VEHICLE WAS IN FLAMES. THE FIRE WAS MOST PROMINENT IN THE FRONT. THE FIRE DEPT CAME, AND THEY SAID THE VEHICLE CAUGHT FIRE FROM THE DASH AND HEAD AREA AND IT WAS ELECTRICAL IN NATURE. THE VEHICLE WAS TOTALED. THERE ARE POLICE AND FIRE DEPARTMENT REPORTS AS WELL AS PHOTOGRAPHS. NO OTHER INDICATION AS TO WHY THIS HAPPENED. *AK

SEAT BELT BUCKLE LATCH MECHANISM HAS FAILED FOR THE DRIVERS SEAT IN MY 1997 FORD 4 DOOR 4X4 EXPLORER

1997 FORD EXPLORER, 5.0 L ENGINE, AUTOMATIC TRANSMISSION. THE CAR'S ENGINE UNEXPECTEDLY RACES TO THE POINT THAT ITS BRAKES WILL NOT HOLD IT BACK. THIS SOMETIMES HAPPENS WHEN BACKING FROM A COLD START AND SOMETIMES WHEN BRAKING FOR A STOP AT AN INTERSECTION. THE ONLY WAY TO STOP THE VEHICLE IS TO SHIFT INTO PARK AND TURN OFF THE ENGINE. THE EFFECT IS LIKE BEING SLAMMED INTO BY A LARGE VEHICLE. IT ALMOST KILLED MY PREGNANT DAUGHTER AND ME EARLIER THIS MONTH WHEN IT HAPPENED AS I WAS BRAKING FOR A TRAFFIC LIGHT. IT FELT LIKE WE HAD BEEN HIT FROM THE REAR, BUT IT WAS THE ENGINE PULLING ITS OLD TRICK AGAIN. THE LOCAL FORD DEALER HAS BEEN UNABLE TO DIAGNOSE AND REPAIR THE PROBLEM. ONE YEAR AGO HE SAID THAT IT WAS THE PCV VALVE AND HE REPLACED THE VALVE. THE CAR THEN BEHAVED FOR ABOUT ONE YEAR. THEN, WITHOUT WARNING, WITH MY WIFE AT THE WHEEL, THE CAR, IN REVERSE, RACED OUT OF OUR GARAGE INTO THE STREET. IT WAS UNSTOPABLE. LATER IT DID THE SAME THING, WHILE IN DRIVE, AT INTERSECTIONS. I RETURNED IT TO THE DEALER WHO COULD FIND NOTHING WRONG. IT THEN HAPPENED TO ME AND MY DAUGHTER AND I RETURNED IT TO THE DEALER WHO TESTED IT FOR A WEEK WITHOUT RESULTS.

DRIVER SIDE SEAT BELT FAILS TO STAY LATCHED, OR SOMETIMES BECOMES UNLATCHED WITH DRIVERS FORWARD BODY MOTION (EXTEND LINE OF SIGHT, CHANGE RADIO/CLIMATE SETTINGS, TURN ON LIGHTS, ETC.). AS A RESULT, THE SEAT BELT IS NOT A RELIABLE SAFETY RESTRAINT. I AM HAVING PROBLEMS FIND A REPLACEMENT PART.

DT: THE CRUISE CONTROL SWITCH STOPPED WORKING, THE CONSUMER LIFTED UP THE HOOD AND NOTICED THAT FLUID WAS LEAKING AROUND THE MASTER BRAKE UNIT. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND THEY CONFIRMED THAT IT WAS A PROBLEM AND THEY REPLACED THE CRUISE CONTROL SWITCH ABOUT A WEEK AGO. *JB

DT: CONTACT STATED WHILE USING THE DEFROSTER SYSTEM THE WINDSHIELD CRACKED FROM THE OUTSIDE TO THE INSIDE. VEHICLE HAD NOT BEEN TO A SERVICE DEALER, BUT WAS SCHEDULED TO BE TAKEN IN THIS WEEK. *AK

CONSUMER HEARD NOISE ON DRIVER'S SIDE WHEEL AND FRONT STABILIZER BAR BROKE. CONSUMER CALLED THE DEALER, AND FORD WAS TOLD CONSUMER'S VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN NUMBER. OTHER VEHICLES OF SAME YEAR WERE RECALLED. CONTACT FELT THIS VEHICLE SHOULD HAVE BEEN RECALLED.*AK AT LOW SPEED VEHICLE WAS RESPONDING NORMALLY BUT AT INCREASED SPEED VEHICLE BECOMES UNSTABLE FOR A SHORT INSTANCE. CONSUMER COULD NOT CONTINUE TO DRIVE UNSAFELY, SO CONSUMER PURCHASED TWO NEW STABILIZER LINKS FROM FORD DEALERSHIP FOR $22. MECHANIC REPLACED BOTH OF THEM FOR AN ADDITIONAL $40. CONSUMER FEELS THAT THIS INCIDENT IS UNFORTUNATE FOR THE FORD COMPANY NOT TO STAND BEHIND THEIR VEHICLES BECAUSE THE LINKS ARE NOT MOVING PARTS OF THE VEHICLE AND SHOULD LAST A LIFETIME. *SB *NM

DT: THE OVERDRIVE LIGHT INTERMITTENTLY CAME ON. DEALER SAID IT COULD EITHER BE A LOOSE CONNECTION OR MOISTURE IN THE SYSTEM. AFTER ABOUT FIVE MILES ON THE ROAD, THE TRANSMISSION WAS SLIPPING. PULLS IN SECOND GEAR. TRANSMISSION FINALLY FAILED.*AK *SB

AIR BLEND DOOR FAILURE. I ONLY HAVE HOT AIR.

1997 FORD EXPLORER LOWER BALL JOINTS ON EXPLORER, BOTH SIDES, LEFT AND RIGHT, HAD A CLUNK WHEN GOING OVER DIPS IN ROAD. FORD DID NOT FIND THE PROBLEM. THE PROBLEM WAS THERE FROM NEW, I HAVE 57,000 MILES ON THE EXPLORER. THE PROBLEM WAS FOUND AT FIRESTONE WHEN ROTATING THE TIRES AND GETTING READY FOR A FRONT END ALINEMENT. I WAS TOLD THAT THE BALL JOINTS WERE BAD ON BOTH SIDES . NOTHING HAS BEEN DONE. I TALKED TO FORD, THEY SAY THE WARRANTY IS GONE AND WILL DO NOTHING, BUT WILL TURN IT OVER TO THE ENGINEERS

I OWN A 1997 FORD EXPLORER THAT SINCE ITS BEEN PURCHASED THE AIR CONDITIONING AND THE HEAT WERE ALWAYS GIVING ME PROBLEMS, I HAVE SINCE FOUND OUT THAT ITS A PROBLEM WITH ALMOST EVERY FORD EXPLORER OUT ON THE ROADS TODAY. THIS IS A MAJOR CONCERN TO ME DUE TO WINDOW DEFROSTING DURING THE WINTER MONTHS, THE BLEND DOOR HAS A MIND OF ITS OWN AND WILL OPEN AND CLOSE AT ANY TIME. PLEASE ADVISE ME ON HOW I CAN GET THIS LOOKED INTO. I BELIEVE THAT FORD SHOULD BE RESPONSIBLE FOR THIS AND THEY BELIEVE THAT THEY DONT. THANK YOU FOR YOUR TIME

DT: 1997 FORD EXPLORER THE DRIVER FRONT DOOR AND THE PASSENGER SIDE REAR DOOR WILL NOT OPEN. CONTACT STATES SHE CALLED THE SERVICE DEALER, BUT IT COSTS TOO MUCH TO HAVE IT LOOKED AT, PARTS AND LABOR WOULD BE MORE.*AK

WHILE DRIVING 55 MPH VEHICLE CAUGHT ON FIRE ON ITS OWN. PULLED OVER, AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. THE CAUSE HAD NOT BEEN DETERMINED AT THIS TIME. *AK

AFTER PULLING OFF THE INTERSTATE I NOTICED MY 1997 FORD EXPLORER WAS MAKING AWFUL NOISES AND DIDN'T HANDLE WELL. WHEN I GOT HOME I REALIZED THE SWAY BAR LINK HAD SNAPPED. AFTER LOOKING AT YOUR WEBSITE I SAW THAT THE 1997 FORD EXPLORER WAS RECALLED FOR SWAY BAR LINKS BREAKING. AFTER BRINGING MY EXPLORER TO THE DEALERSHIP TO GET THE ITEM FIXED I WAS TOLD MY VEHICLE WASN'T PART OF THE RECALL AND THAT THEY GO BY VIN #'S. SO MY QUESTION IS WHY ARE ONLY CERTAIN 1997 EXPLORERS RECALLED. JUST BECAUSE MY VEHICLE'S VIN # DOESN'T QUALIFY DOES THAT MEAN THAT I SHOULD LOOSE CONTROL ON THE INTERSTATE GOING 75 MPH. ONLY CERTAIN COLOR EXPLORERS GET RECALLED? MAYBE ONLY EXPLORERS BUILT ON WEDNESDAYS IN 1997 QUALIFY. DO I HAVE TO CRASH AND DIE UNTIL MY VIN # QUALIFIES? IT WILL BE TOO LATE THEN BUT MAYBE MY PARENTS CAN SUE FORD AND GET RICH. FORD ALREADY TRIED TO KILL ME WITH THEIR FIRESTONE TIRES AND NOW THIS. I'M GLAD THE NHTSA HAS THE KNOWLEDGE TO KNOW EXACTLY WHICH 1997 EXPLORERS HAD FAULTY PARTS, SEEMS LIKE A COINCIDENCE THAT I HAD THE SAME PROBLEM THAT RESULTED IN A RECALL FOR THE 1997 EXPLORER BUT YET I AM REFUSED SERVICE BY FORD. COULD YOU PLEASE TELL ME HOW THIS CAN HAPPEN. I AM FURIOUS WITH FORD BUT I GUESS I SHOULD BE MORE ANGRY WITH THE NHTSA SINCE THEY ISSUE THE RECALLS. PLEASE LET ME KNOW HOW YOU DETERMINE WHICH LIVES TO SAVE AND WHICH ONES AREN'T AS IMPORTANT. THANKS FOR YOUR TIME, JOE

I BOUGHT THE EXPLORER LAST APRIL AND THE A/C WORKED FINE, BUT WHEN WINTER GOT HERE THE HEATER WOULD NOT BLOW WARM AIR. I TOOK IT TO A MECHANIC WHO REPLACED THE THERMOSTATE AND LOOKED AT OTHER THINGS, BUT COULD NOT FIX IT. I THEN TOOK IT TO A SECOND MECHANIC WHO LOOKED AT IT AND TOLD ME THAT HE HAD JUST FIXED THE SAME PROBLEM ON ANOTHER 97 FORD EXPLORER--AND IT WAS THE BLEND DOOR. THAT THE DOOR WAS A FACTOR DEFECT AND WOULD COST ABOUT $650.00 TO REPLACE IT. I DID NOT HAVE THE MONEY TO HAVE IT REPLACED, AND IT IS A SAFETY HAZARD WHEN IT IS STUCK ON A/C AIR AND YOU CAN NOT DEFROST YOUR WINDSHILD WHILE YOU ARE DRIVING. IT HAS NOT BEEN FIXED AND RESTRICTS VISION OUT OF THE WINDSHIELD WHEN FOGGED OR ICED WHICH COULD CAUSE ME TO HAVE A BAD WRECK.

(1) CRUISE CONTROL, NORMAL USEAGE (2) WHEN THE CRUISE CONTROL IS ON FOR MORE THAN FIVE MINUTES, THE CRUISE CONTROL SWITCH CONTROLLING ACCEL, COAST, RESUME, ON THE STEERING WHEEL BECOMES HOT. FURTHERMORE, APPROXIMATELY 30% OF THE TIME, THE VEHICLE WILL SUDDENLY ACCELERATE WHEN THE COAST BUTTON IS DEPRESSED, RESULTING IN TWO NEAR MISSES, WITH TEMPORARY LOSS OF CONTROL OF THE VEHICLE. (3) THE FAILURE STILL EXISTS, HOWEVER I HAVE NOT USED THE CRUISE CONTROL FOR TWO MONTHS. I HAD CONTACTED A FORD DEALERSHIP FULLY EXPLAINING THE PROBLEM AND WAS TOLD THAT THERE WAS NO RECALL; I WOULD HAVE TO TAKE THE VEHICLE IN AND PAY FOR IT.

FEW MONTHS AGO I HAVE PURCHASED A SET OF BOSCH SPARK PLUGS (PLATINUM 2 PART # 4305). ABOUT 3 WEEKS AFTER I INSTALLED THEM WILE DRIVEN ON THE EXPRESSWAY ONE OF THEM EXPLODED RUINING THE WIRE AND CAUSING TO FLIP FLOP ALL OVER SPARKING LUCKY I STOP RIGHT AWAY. THE CERAMIC PORTION OF THE SPARK HAS COME OUT OF IT CLEAN CAN NOT EVEN FIND A TRACE OF CERAMIC ON THE PLUG BUT UNFORTUNATELY THE ELECTRODE OR PORTION OF IT FELL IN TO THE CYLINDER ,CAUSING AN IRREPARABLE DAMAGE TO THE ENGINE, I HAVE REPORTED THE DAMAGE AND DETAILS TO THE MANUFACTURER AND EVEN SEND THEM THE PLUG FOR INSPECTION AND EXPLAIN EVERY THING, BUT THEY HAVE RETURN THE PLUG AND A LETTER SATING THAT THE REASON THE PLUG EXPLODED WAS BECAUSE IMPROPER TORQUE. I HAVE BEEN INSTALLING THE PLUGS ON MY VEHICLES FOR THE LAST 20 YEARS AND I HAVE NEVER HAD A PROBLEM LIKE THIS AND PEOPLE I TALKED TO SAID THE PLUG SHOULD NOT EXPLODE FOR THAT REASON. I THAT IS THE CASE I FEEL THIS IS A SAFETY ISSUE ON THIS PARTICULAR PLUGS AND THERE IS NOTHING ON THE PACKAGE INDICATING TO THE CONSUMER OF THIS DANGER. *AK

WHILE DRIVING 35 MPH TRANSMISSION ENGAGED ITSELF INTO 4-WHEEL DRIVE. AS A RESULT, VEHICLE LOST POWER, AND WOULD NOT SHIFT GEARS. DEALER STATED TRANSMISSION BURNED ITSELF OUT, AND NEEDED TO BE REBUILT. *AK

FORD EXPLORER 1997, CONSUMER PAID FOR REPLACEMENT OF ENGINE PRIOR TO FORD RECALL. *BF THE CONSUMER WAS DENIED REIMBURSEMENT UNDER THE RECALL BECAUSE THE REPLACEMENT ENGINE WAS NOT PURCHASED FROM FORD. *NM

THE REAR LIFT GATE DOOR IS TEARING AWAY FROM THE WHERE IT ATTACHES TO THE LIFT GATE DOOR HINGE ON THE LEFT SIDE (DIRVERS SIDE). THE DOOR HAS ALWAYS BEEN A PROBLEM TO CLOSE AND WAS AJAR FROM WHEN I BOUGHT THE CAR NEW. THE DOOR AJAR LIGHT WOULD COME ON ALL THE TIME, AND OF COUSE THE NUMBEROUS TIME I TOOK IT TO THE DEALER THEY COULD NEVER "DUPLICATE THE PROBLEM". NOW IT IS BEYOND THE POINT OF AJUSTMENT. THE WHOLE LIFTGATE HAS TO BE REPLACED AT A COST OF APPROXIAMETLY $1,200. IT IS A SAFETY HAZZARD AS I HAVE TO PULL OUT THE FUSETO GET THE LIGHTS TO GO OUT, IN ORDER TO DRIVE IT AT NIGHT. THE LIGHTS WON'T GO OFF WHEN THE DOOR IS AJAR. WHEN IT RAINS I HAVE TO STOP TO PUT THE FUSE BACK IN AND DRIVE WITHT THE INTERIOR LIGHTS ON, WHICH IS VERY HARD TO SEE. ALSO FUMES COME IN FROM THE EXHAUST SO I CAN'T GO FOR LONG TRIPS N IT. IF I DIDN'T LIKE THE CAR SO MUCH I WOULD TRADE IT IN, BUT I REALLY LOVE MY EXPLORER EXCEPT FOR THIS DEFECT IN CONSTRUCTION. (IT HAS NEVER BEEN INVOLVED IN A ACCIDENT.) I AM TAKING IT IN TO BE FIXED NEXT WEEK.*AK

1997 FORD EXPLORER. WITH MALFUCTION CAR WOULD NOT STOP FAST IDELLIG AFTER AFER USING CRUISE CONTROL. COULD NOT GET IT TO STOP CAUSED THE BRAKES TO CATCH FIRE AD BURN. DUE TO TRYING TO KEEP THE CAR AT A SLOW SPEED. TILL I WAS AT ASAFE AREA WERE I COULD ABTAIN HELP.*AK

I WAS DRIVING THE TRUCK ON MY WAY HOME. I HAD DRIVEN 12 MILES WHEN I NOTICE SMOKE COMING OUT OF THE DASH BOARD BY THE STEERING COLUMN. I PULLED OVER AND BY THE TIME I GRABBED MY LAPTOP AND WALKED APPROXIMATELY 10 FEET FROM THE VEHICLE TO CALL FOR HELP THE TRUCK WAS FILLED WITH BLACK SMOKE AND WAS ON FIRE. I HAVE PICTURES OF THE BURNDT TRUCK, IF YOU WOULD LIKE TO SEE THEM. I ALSO STILL HAVE THE BURNDT TRUCK. I HAVE ALWAYS FELT THERE WAS A FAULT SOMEWHERE IN THE DASH ON THIS FIRE. IF YOU WOULD LIKE TO SEE THE PICTURES OR THE VEHICLE THAT CAN BE ARRANGED. *AK

HEATER IN VEHICLE BECAME INOPERATIVE DURING A SLEET AND ICE STORM. HEATER BLEND DOOR FAILED CAUSING ONLY COLD AIR TO BLOW OUT OF HEATER AND DEFROSTER, WINDSHIELD AND WINDOWS FOGGED UP AND I COULD NOT SEE THE ROAD. HEATER BOX AND BLEND DOOR REPLACED THAT COST ME $700.00. 8NM

THE HEADLIGHTS/TURN SIGNAL FAILSEDTO WORK INTERMITTENTLY. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

VEHICLE LOST STEERING CONTROL WHILE DRIVING 35-40 MPH. THIS ALMOST CAUSED VEHICLE TO RUN DOWN AN EMBANKMENT. VEHICLE TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE PROBLEM WAS CAUSED BY THE SWAY BAR LINKS WHICH NEEDED TO BE REPLACED.*AK

I HAVE TWO 1997 FORD EXPLORERS (AN XLT AND AN EDDIE BAUER) BOTH VEHICLES HAVE NUMEROUS PROBLEMS WITH DOOR LATCHES AND POWER LOCKS. OCCUPANTS HAVE BEEN UNABLE TO EXIT THE VEHICLES ON SEVERAL OCCASIONS DUE TO INOPERABLE HANDLES AND/OR LOCKS. I BELIEVE SOMEONE COULD BECOME TRAPPED IN ONE OF THESE VEHICLES IN THE EVENT OF AN ACCIDENT.*AK

THE FRONT PASSENGER SIDE SWAY BAR FRACTURED. RECALL 00V402000 WAS ISSUED, HOWEVER, THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK.....SWAY BAR BROKE IN JULY 2004. CAR FELT LIKE BOAT WHEN DRIVING. VEHICLE WAS REPAIRED IN JANUARY 2005. *AK

REPLACEMENT OF ENGINE DUE TO DEFECTIVE PARTS; THROTTLE BODY PLATE AND CAM CHAIN GUIDE ON MOTORS. *BF THE ENGINE THROTTLE PLATE STUCK WHILE THE CONSUMER WAS WARMING THE VEHICLE ON A COLD DAY. RECALL #00V422000. THE CONSUMER REQUESTED REIMBURSEMENT FOR THE DEFECTIVE ENGINE. THE STARTER DID NOT KICK IN PER INVOICE. *SC

DRIVER SIDE SEAT BELT BUCKLE FAILS TO LOCK WHEN CLIP IS INSERTED OR SOMETIMES APPEARS TO LOCK BUT COMES UNLOCK IF OCCUPANT TAKES A BREATH. *NM