2022 Ford Expedition complaints

The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V314000(Service Brakes, Hydraulic) and a mobile mechanic from an unknown dealer had inspected the vehicle at the residence. Additionally, the contact stated that a week later, the contact noticed a puddle of oil on the ground. Upon inspecting the vehicle, the contact noticed that the oil was leaking from the left rear wheel. The vehicle was diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 36,000.

I have a 2022 Ford expedition Platinum that has a window washer hose that has a split causing a water leak on the right-side panel of the vehicle. The labor repair cost is significant, and a mechanic feels it is a defective manufacturing issue. The labor cost to repair by the Ford Dealership is $1,250

Bought [XXX] at Corwin Ford Reno Nevada. April 2023 vehicle had sporadic transmission issues - slipping randomly. Took it in and explained the issue. Told there’s no transmission person. Nothing was done and told to continue to drive it. [XXX] Vehicle ended up going into reverse on its own at a stop light. Took the car in and given the same story, were completely back logged and could not get the car in. Car also had an active recall on it, never was looked at because they stated back logged until mid 2024 and couldn’t schedule an appointment. Asked for a loaner vehicle, told that’s not available anymore. May 2024 went into reverse again on its own. Called to get it in, stated they could not make any appointments at that time. October 2024 engine intermittently began revving on its own up to 4000RPM. Told no transmission mechanic was available. We were told there’s no more loaner program, transmission mechanic is 3 months out and there’s nothing that can be done at this time. Asked us if we wanted to pay $2500 for preventative maintenance and fluid top off on the vehicle though. [XXX] the rear AC went out on the vehicle also. There is also a new recall on the vehicle for the fuel pump and a loss of fuel pressure. These are all a massive safety concern for our entire family (4 kids + 2 adults) and for the general public. Ford is refusing to take responsibility for these issues and are making it very difficult for us to work with. We have a [XXX] who has [XXX] and we need a rel

The contact owns a 2022 Ford Expedition. The contact stated that while driving at various speeds, the vehicle was sputtering and making a grinding sound while shifting gear. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed and determined that the transmission had failed, and the front differential needed to be replaced. The contact stated that the front deferential was rebuilt; however, the sputtering failure persisted. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 123,000.

On Nov 22 I pulled over to the shoulder of a highway in the midst of a snowstorm to make a phone call. When I went to get back onto the highway, my vehicle lost all brakes...the brake pedal hit the floor...and I had a low-speed impact with a berm rising up to a driveway that intersected the shoulder. The vehicle had to be towed to a nearby dealer. The only mechanism to stop it on/off the tow truck was slamming transmission into park. Due to the storm, I had to spend the night in the vehicle in the freezing cold at the tow destination. The cause of the brake failure was determined to be a material defect of a rubber section of brake line deep in the engine compartment that burst, causing a loss of all brake fluid. It was repaired under warranty. I had just received the vehicle back from repairing the body damage to the bumper when the Ford brake line recall was issued. I believed that my incident in Nov was the result of the issue that resulted in the recall, and that surely the warranty repair would have thus resolved all related issues. That was not the case. When I brought the vehicle to Koons Ford Woodbridge four routine service, they found that it failed the brake line recall test and that the vehicle was unsafe to drive. However, they are not actively repairing it. In fact, the parts needed to repair don't exist. I'm told it will be 2-3 months before a part is even available. And they have failed to provide an any vehicle that can safely transport my family of 7. I there

The coating and plastic is failing in the headlights, this can reduce visibility and by extension safety.

The contact owns a 2022 Ford Expedition. The contact stated that while opening the hatch by engaging the automatic release switch, a hole formed in the sheet material, and the spoiler was fractured. The contact stated that there was an abnormal loud clicking sound prior to the failure. There was no warning light illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

A-pillar/hinge integrity engineering concern. While opening my door in a parking lot, the wind caught the door before I could catch the door. The door met the hinge stop and flexed enough for the edge of the door panel to contact a bolt on the A-pillar door hinge assembly, causing a small crease in the aluminum door panel. My concern is that in 30 years of driving, I have had a door caught be wind before but never had damage to the vehicle. This was not a strong wind, just enough to catch the door. The A-pillar is now flexed slightly such that the door panel gap is larger and seems related to the actual A-pillar flex, not a hinge failure. Vehicle testing of the 22 Ford Expedition has show some poor performance in the A-pillar area and I am concerned that this door issue is due to poor engineering and strength of the A-pillar. I have had the vehicle inspected at the Ford dealership and a customer service complain with Ford is in process. I do not feel this issue can be attributed to user error or considered "accidental" but is due to structural/safety deficiency of the A-pillar structure. [XXX] [XXX] Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

Rear defrost coils have continually fallen off. Dealer fixed one in February of 2024. It fell off March 2024. They are both hanging there. Dealer won’t touch it - says rear window needs replacement. I’ve researched on ford expedition forum and many expeditions have a similar issue. Especially with dealer not covering it.

The contact owns a 2022 Ford Expedition. The contact stated while the vehicle was parked, the contact opened the liftgate, and the liftgate failed to operate as intended. The contact stated that the liftgate struck the roof and caused the liftgate to be damaged. The contact stated that when it was cold, the liftgate failed to operate as intended. The vehicle was taken to a dealer and diagnosed that there was insufficient margin between the liftgate and roof spoiler. The contact was provided with Manufacturer's Recall Number: SSM 53469. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 37,000.

According to Special Service Message (SSM) 51346, Ford has acknowledged that certain 2022-2023 Expedition models may exhibit this issue due to the roof and spoiler components contacting each other. You can find more details on this concern on Ford's official website and in the SSM documentation. My vehicle has experienced this issue

Sunroof explosion with zero impact

The contact owns a 2022 Ford Expedition. The contact stated that while driving in the rain at 60 MPH with the windshield wipers at max speed, the driver’s side windshield wiper started hanging off the side of the windshield and failed to operate as needed. The contact pulled into the nearest gas station and attempted to move the wiper back to the original position; however, the driver’s side windshield wiper failed to move. Despite the failure, the contact continued to drive the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 22V250000 (Visibility), which was linked to the failure. Two dealers were notified about the failure, and both informed the contact that there were no recalls on the VIN. The dealers provided estimates for the repair. The manufacturer was also notified of the failure and referred the contact to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 49,000.

When I am completely stop, If I press the cruise control button, it will set the speed at 15 Mph. and will start moving till reaches that speed. I can reproduce that at will, you can see a video here [XXX] After googling this issue, found that I am not the first customer that happens to have that issue. Seee the following thread where a similar issue is described: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The audio system has become inoperable and instead the speakers are blasting static noise with crackling and popping sounds at high volume. Cannot stop it or use any other audio. Very unsafe to drive due to extreme noise level and lack of controls. Appears many people have this issue and there needs to be a recall to fix.

Wipers are the recalled version missing the little block. HOWEVER, the recall is not for my VIN. Coolant keeps disappearing. Hard shifting and or no movement at all while transmission is cold.

Several incidents in which adaptive cruise control resets itself to 90mph when moving into a higher speed limit area- for example, cruising along at 70mph, pass a speed limit sign allowing 75mph, and suddenly the cruise control resets at 90mph. If you are not very consciously thinking about this you quickly find yourself going 90mph. It never resets at 80 or 85- always 90mph. Going 15 or 20 mph faster than thought or planned certainly grabs your attention and is a safety risk.

I am writing to formally report a significant issue with my vehicle that has resulted in damage to the roof and potential long-term integrity concerns. The liftgate spoiler is contacting the roof in freezing temperatures, which creates a hole in the roof when opening the liftgate. Upon inspection, it appears there is an insufficient margin between the liftgate spoiler and the roof area centerline. This problem is particularly concerning because a hole in the roof allows moisture to penetrate, jeopardizing the structural integrity of the roof and potentially leading to further damage, such as rust or water intrusion into the vehicle. I believe this issue may be the result of a design flaw and would like to request an immediate inspection and resolution. As this defect directly impacts the durability and safety of the vehicle, I urge you to treat this matter as a priority. Please let me know how this issue can be resolved, including any repairs, adjustments, or recalls that may apply. I am happy to provide photographs or additional documentation if needed.

The contact owns a 2022 Ford Expedition equipped with Hankook, Tire Line: Dynapro, Tire Size: 275/55/R20, DOT Number: (N/A). The contact stated that while the vehicle was parked, the contact became aware that the tire pressure was low. Additionally, the check engine warning light was illuminated. The contact drove to Discount Tire to inflate the tire. The contact stated that there was an abnormal sound coming from the brake pedal. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced, and the brake pedal needed to be cleaned. The battery was replaced, and the brake pedal was cleaned. The vehicle was driven back to the dealer where it was diagnosed, and the failure was linked to the brake pads and rotors. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 8,065.

My vehicle doesn’t alert me of incoming vehicles and the reverse camera stays on. When I turn on my vehicle the dash stays on with ford sign so when I put on reverse my back up camera doesn’t turn on at all. I have to use all my mirrors to back out of parking. This feature hasn’t been working properly for a year. They keep telling me ford is working to fix this issue.

The contact owns a 2022 Ford Expedition. The contact stated while driving 40-80 MPH, there was an abnormal vibration in the vehicle. There was an abnormal humming sound coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed and determined that the wheels, drive shaft, and u-joint needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken to another local dealer, Bob Moore Ford (8948 S I-35 Service Rd., Oklahoma City, OK 73149); where it was diagnosed and determined that the tires and the rims needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 400.

See attached document for complaint.

The contact owns a 2022 Ford Expedition Max. The contact stated that while stopped with the brake pedal depressed in a parking lot, the vehicle accelerated inadvertently without warning. The vehicle crashed into the driver's side center of another vehicle totaling it. The approximate four occupants of the vehicle crashed into sustained unknown injuries and were transported to the hospital. A police report was filed. The contact did not sustain any injuries. The vehicle was towed to a collision center where it was repaired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 41,000.

3rd row seat has metal frame coming through cushion. Had seat cushion replaced once. Ford technician said was design flaw in vehicle and issue will continue to happen. Just had vehicle in again for same issue but Ford will not replace cushion this time because they confirmed other like vehicles are having same issue and deeming is a normal condition. This is a huge safety issue for my children. This is not a normal condition to have a cushion fall through and the metal seat frame is exposed.

While driving the vehicle, the stereo system suddenly without warning started an unbearable loud and deafening noise. I was driving on a busy highway and was able to the the next exit. I had 2 other occupants in the vehicle. We had to exit the vehicle because the noise level from the speaker was painful and caused disorientation. I turned the vehicle off but the noise continued for at least 10 minutes then stopped. Myself and the 2 other occupants still have ear pain 24 hours later.

The contact owns a 2022 Ford Expedition. The contact stated that while starting the vehicle, there was a moldy odor coming from the vents. The vehicle was not diagnosed or repaired by an independent mechanic or local dealer. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 30,000. The VIN was not available.

The contact owns a 2022 Ford Expedition. The contact stated that on several occasions after his wife had reversed and then shifted to drive, the vehicle made a clunking sound and failed to accelerate as intended for several seconds. On another occasion, while stopped at a stop sign, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended for several seconds. The vehicle was taken to a dealer where it was diagnosed that the transmission software needed to be updated. The vehicle was repaired; however, on several occasions, while driving at undisclosed speeds, the contact experienced a failure with an abnormal clunking sound coming from the front of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.

The contact owns a 2022 Ford Expedition. The contact stated while driving approximately 40 MPH, the instrument panel went black. The horn failed to be as loud as designed. The contact also stated that while driving approximately 45 MPH and making a left turn, the turn signal failed to activate. The contact stated that the instrument panel was black during the failure. The contact stated that before the failure, the Bluetooth Sync system had failed, and the contact believed that was when the failures started. The vehicle was taken to the dealer who was unable to determine the cause of the failure. The instrument panel and the touch control panel screen were replaced. The contact stated that after the repairs were completed, the back over prevention alarm was not as loud as before. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 25,000.

We started to notice some body issues -rear side fenders popping out, the front grill popping out,, the inside screen would go blank, fuel tank lid pops open. As if this was not enough - we then encountered more issues - sunroof was falling on our heads, the step up railing is falling apart....WAIT- there's more - paint coming off the hood...And to top it all off - there is a cracking noise thru the inside. We cannot control the noise. We lose all function and use of controls (radio, climate, etc.).

Upon starting vehicle, loud pop sound and then excruciatingly painful white noise throughout the sound system. No controls will work to turn audio down. Upon shutting vehicle off, painful white noise continued for another 10sec or more. Waited a few minutes tried again, same thing happened with sound. Unable to drive vehicle with sound this loud. Tried 5x to shut off vehicle and restart, white noise continued. Hours later, ears are still ringing the noise was so loud. No controls on the touch screen would work and even shutting off car, disconnecting all phones excruciating white noise continues.

In December of 2023 (not even one full year after purchasing my brand new Ford Expedition) I used the FOB to remotely open the trunk on my 2022 Ford Expedition. Upon doing so, I heard popping and cracking sounds. I didn't see any damage, so I didn't think anything of it until I drove on the interstate and immediately heard a violent slapping noise coming from the back of my vehicle. I took the truck to the dealership (where I purchased my vehicle). They inspected the vehicle and said that the spoiler is misaligned and loose - causing the sound and also resulting in a dent on the roof of the vehicle. The dealership said that Ford would not cover the repair under their FULL BUMPER TO BUMPER WARRANTY. Three other people with new Ford Expeditions at my dealership have experienced this exact issue. (Also a simple Google search of "Ford spoiler issue" will demonstrate that many others have experienced this issue.) I am extremely nervous to drive my vehicle anywhere as it sounds and feels like the spoiler is going to fly off of the vehicle especially when I drive on the interstate. This is a HUGE safety issue. The spoiler is loose and could fly off on the highway and cause an accident or hit another vehicle. NHTSA is aware of this issue and submitted an SSM to Ford [XXX] ), but Ford will not recall or cover repairs to their vehicles that have a defect and pose a safety risk. This needs to be immediately rectified before someone is seriously hurt. INFORMATION REDACTED PURSUANT TO THE

On [XXX] the front section of the panoramic moonroof shattered after opening the drivers side passenger door and drivers door, the children were climbing into the backseat and I proceeded to open the drivers door after opening their door and the glass shattered. Thankfully nobody was injured. The car was towed to the Ford dealership and they after inspection found no reason for the malfunction. I have asked them today to reach out to Ford Customer Assistance as the estimated repair is $4,000. It was not reported to police or insurance at this time. There were no warning signs, nothing has fallen on the roof to my knowledge and the vehicle has 19,600 miles. The car is stored in a driveway safe of any falling debris or ice and we live in Michigan. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

The contact owns a 2022 Ford Expedition. The contact stated that the vehicle had collected snow and while opening the trunk, the spoiler fractured. The vehicle was taken to an Auto Body shop, where it was determined that the spoiler needed to be replaced. The vehicle was not repaired. An unknown dealer was contacted, and a voicemail message was left. The manufacturer was not notified of the failure. The failure mileage was approximately 19,000.

Since purchasing this vehicle in January of 2023, it has been to the dealer three times to repair a failed blind spot monitoring system and rear cross traffic alert system due to corroded pins in the connectors of the sensors. According to the dealer, this is due to the connector utilizing only four of eight pins which leaves four pins unused and open to corrosion. On the third trip in, the dealer applied, "super glue" to try and prevent any future corrosion. While there was not a specific accident related to this, I do believe this has the potential to cause issues in the future if not properly addressed by Ford. See attached pdf from dealer for additional supporting information.

DOCUMENTATION OF UNWARRANTED / UNCONTROLLED VEHICLE ACCELERATION: DRIVER STATED THAT WHILE VEHICLE WAS STOPPED IN TRAFFIC, VEHICLE ACCELERATED WITHOUT USE OF ACCELERATOR PEDAL. VEHICLE LURCHED FORWARD INTO VEHICLE AHEAD, AND INTO 2ND VEHICLE AHEAD IN TRAFFIC. ENGINE CONTINUED TO RACE AT HIGH SPEED WITH TRANSMISSION IN DRIVE, SPINNING REAR TIRES UNCONTROLLED WITH BOTH FEET DEPRESSING BRAKE PEDAL. VEHICLE HAD TO BE PUT IN NEUTRAL TO SHUT OFF ENGINE. APPROXIMATELY 15 - 20 MINUTES PRIOR TO INCIDENT, VEHICLES CRUISE CONTROL DISENGAGED WITHOUT REASON WHILE DRIVING @ 60 MPH ON PARKWAY. SYSTEM RE ENGAGED WITHOUT FURTHER ISSUE ON PARKWAY. THERE WAS NO DISPLAYED WARNING LIGHTS OR MESSAGES PRIOR TO INCIDENT INCIDENT REPORT FILED WITH FORD CORPORATE MOTOR CO. CASE # .

The contact owns a 2022 Ford Expedition. The contact stated that while her husband was having a light bulb replaced, the dealer became aware that the electrical wiring was damaged due to rodents chewing on the wiring insulation. The vehicle was repaired but the failure persisted. There was no warning light illuminated. The manufacturer was notified of the failure. The failure mileage was 22,489.

The contact owns a 2022 Ford Expedition. The contact stated while driving at various speeds, the infotainment screen went blank without warning. Occasionally the vehicle would inadvertently shut off once the screen went blank. The contact stated that the adaptive driving system feature would independently active, causing the vehicle to jerk out of the driving lane, and the contact would temporarily lose control of the vehicle. In addition, the contact stated that the vehicle would independently surge forward upon depression of the brake pedal without warning; while in reverse(R) or drive(D). The vehicle was taken to the dealer on multiple occasions however, the parts to repair the vehicle were on backorder. The contact filed a complaint with the manufacturer. The vehicle was not repaired. The failure mileage was unknown.

My speakers / sound system made a loud sound and minutes later my speakers were explosively loud. I couldn’t get the noise to stop. It was a static / gunfire at the highest volume. I turned my car in and off and couldn’t get it to turn off. It blew my ear drums out. Ultimately had to pull the amplifier fuse to get it to turn off. We have not had it inspected yet. We are taking it to the dealership tomorrow although I have heard of many issues of other owners having the same speaker problem. The only thing that happened before this incident. I thought it sounded like something fell inside my door or dash. I was in park when that happened and had just gotten into my car. Not five minutes later, the speakers blared. Thank god my kids were not in the car this time but I have an infant and he is in my car daily. I couldn’t focus on driving. I almost crashed my car. I had to pull over on a dangerous road just to get away from the sound

The audio system of my Expedition has twice made max volume level popping sounds in the dash. It sounded as if fireworks were going off in my car. I turned my car off both times. One time it stopped when turning the car off, the other time I turned the car off and opened and closed the doors multiple times as that usually kills the power to the vehicle bit it continued loudly popping. The popping could be heard from outside of the vehicle it was so loud. It did this for about 15 minutes before we finally got it to stop. I have this on video amd would be happy to send it but it will not let me download it.

While the vehicle is in 2 wheel high, it operates as all the hubs are locked or there is a severe transmission issue. On turns which causes safety issues when trying to navigate corners. My wife hit a curb because of the issue. It causes a severe drag and terrible sound. It also has extremely rough shifting. We had a 2019 Navigator with the same drivetrain that had issues that eventually had to have the motor replaced with less than 10,000 miles.

Vehicle has been shifting into neutral at speeds for 65 mph or more , it is constantly locking and unlocking itself when turned off. It malfuctiins during auto pilot asst( doesnt read the hands even though they are on the wheel) Today it wouldn't turned on. when I pressed the brake to turn it on, it said that the steering system fails and that the braking system failed and the screen powered down to save battery. when pressed the brake shook and then locked down. even if left on this vehicle turns off after idling for more than 10 minutes. so that makes no sense. It wouldn't even attempt to turn over.

Bought car new last year. Current 15,000 miles. On Saturday, September 2, I turned the ignition off and then opened the drivers door. Suddenly there was a horrendous loud static noise coming from I assume the radio speakers. It was deafening, and lasted about 3 seconds. I have read about other Ford trucks having this problem, but it is the first time for me. I will take it to my Ford dealer tomorrow morning. Apparently there is a quick program update to correct the issue. If this happened while I was driving, it may have caused an accident.

Unintended acceleration just after engaging the transmission in forward motion. This has happened four (4) times since new.

On start-up, vehicle had an ear-piercing noise coming through all speakers. All of the dashboard screens were black, buttons were not responsive, but the vehicle would still move. Even after getting the vehicle to turn off, the sound persisted. I had to manually disconnect the battery to get it to stop. I have video of the incident if helpful. Ford service had no idea how to handle.

Transmission shifted into neutral while driving at highway speed

Alternator failed suddenly. Caused loss of power to all components while driving.

The contact owns a 2022 Ford Expedition. The contact stated that when the vehicle was started in the morning and the air conditioning system was activated, there was a mildew odor inside the vehicle. The contact stated that while driving the odor dissipated. The contact stated that water was accumulating in the passenger’s side wheel well and could cause a short circuit due to the electrical wires and connectors underneath the carpet. The vehicle was taken to a local dealer however, the failure could not be duplicated. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure TSB Number: 20-2170 Water Leaking on Right Front Floor During Or After A/C Use (Visibility). The failure mileage was approximately 14,000.

While driving with cruise control set at 65mph the vehicle will maintain set speed for a undetermined amount of time at which point the vehicle cruise will jump to a very high setting of 88mph....forcing me to shut the system down...this happens frequently and I can't determine what sets it off. Ford Dealer can't find anything wrong . Also the lane assist will constantly warn of not holding the wheel or lane in fractions forcing me to shake the steering wheel to let the system know I'm holding the wheel.

The contact owns a 2022 Ford Expedition. The contact stated that while her husband was driving at an undisclosed speed and trying to activate the cruise control, the vehicle inadvertently lost motive power. The driver was able to pull over the side of the road, but the vehicle failed to restart. There was no warning light illuminated. The contact stated that roadside assistance arrived, and it was difficult getting the vehicle onto the tow truck. The vehicle was towed to the dealer, who diagnosed a failure with the fuel pump module and determined that the battery needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 7,250.

I had my three young children in the car and was driving a brand new 2022 Ford Expedition when I heard a loud sound and my sunroof completely shattered, causing shards of glass to fall on me and my 3 children, as well as almost causing me to get into an accident due to the shock of the incident.