2000 Ford Expedition complaints

FORD EXPEDITION SPARK PLUG EJECTION. THIS IS THE SECOND TIME THIS HAS HAPPENED ON THIS 2000 XLT. VERY DANGEROUS, ON HIGHWAY AT 65 MPH, SOUND OF CATASTROPHIC FAILURE THEN OPEN CYLINDER NOISE, SMELL OF RAW GAS. *TR

2000 FORD EXP WENT UP IN FLAMES AFTER RETURNING FROM A TRIP TO THE GROCERY STORE ON 8/16. WAS JUST AT REPAIR SHOP FOR CRUISE CONTROL NOT WORKING ON 8/14. TOLD THAT FORD HAD A RECALL AND THAT I NEEDED TO TAKE IT TO A DEALERSHIP TO BE REPAIRED. EVERYTHING INSIDE THE VEHICLE WAS DESTROYED AS WELL AS THE CONCRETE SIDEWALK IT WAS PARKED ON. *TR

I OWN A 2000 FOR EXPEDITION AND HAVE HAD NOTHING BUT EXPENSIVE PROBLEMS. FIRST THE CAPS ON THE SPARK PLUGS GO BAD EVERYTIME IT GETS WASHED OR GOES THROUGH PUDDLES ON THE ROAD. THEN WHEN IT RAINS WATER SEEPS INTO SOME CONTROL BOX AND CAUSES THE RADIO AND AIR TO RUN WHEN THE VEHICLE IS TURNED OFF AND THE KEY REMOVED, IT WILL EVEN GO AS FAR AS ENGAGING THE ANTI THEFT SO IT WON'T START. I HAVE EVEN LOST CONTROL OF THE WINDSHIELD WIPERS WHILE DRIVING, THE RAIN DRIPS ON MY FEET AND SOAKS THE FLOOR MAT EVEN IF IT JUST SITTING. THE LATEST ISSUE IS WITH AN EJECTED SPARK PLUG WHICH FORTUNATELY DID NOT START A FIRE JUST LEAVING ME STRANDED TWICE IN ONE WEEK. I AM TOLD THERE IS NO GOOD FIX FOR THIS PROBLEM AND I AM GETTING ESTIMATES AS HIGH AS $3500. MOST SAY THAT THIS VEHICLE HAS ONE DESIGN FLAW AFTER ANOTHER AND THAT FORD ONLY GIVES ONE EXCUSE AFTER ANOTHER. SO MANY PEOPLE SEEM TO HAVE THE SAME EXACT PROBLEMS I CAN'T HELP BUT TO THINK THE FAULT LIES WITH FORD. SO MANY OTHER THINGS HAVE GONE WRONG WITH IT TO FIX THEM ALL WOULD BE REPLACING EVERY PART, WIRE, AND DEVICE ON IT. I THINK IT'S JUST A LEMON DESIGNED TO CREATE REVENUE. SURELY SOME MUST HAVE THE POWER TO INVESTIGATE ON BEHALF OF THE CONSUMER. *TR

I HAVE A 2000 FORD EXPEDITION. AFTER A REALLY BAD RAINSTORM TODAY MY SUV STARTED ACTING POSSESSED. IT HAS BEEN WORKING FINE AND NOW ALL OF THE SUDDEN THE HEADLIGHTS TURN THEMSELVES OFF AND ON, WHEN THEY CAR IS OFF THE KEY IS NOT IN THE IGNITION. THE FAN/AC IN THE SUV RUNS WHILE THE VEHICLE IS OFF AND THE KEY IS NOT IN THE EXPEDITION. THE WHOLE ELECTRICAL SYSTEM IS ACTING CRAZY, THE SUV DOES THINGS ON ITS ON EVEN WHEN THE VEHICLE IS OFF AND THE KEY IS NOT IN THE IGNITION.I HAD BEEN LEFT STRANDED WITH MY VEHICLE IN THE WALMART PARKING LOT WITH THE LIGHT, GAUGES, AND AIR TURNING ITSELF ON AND OFF. I AM A SINGLE MOTHER AND I AM SO SCARED TO DRIVE IT WHEN IT DRIVES BECAUSE I AM WORRIED THE ELECTRICAL SYSTEM COULD CATCH FIRE OR I COULD GET INTO AN ACCIDENT WITH MY DAUGHTER IN THE VEHICLE. *TR

ALL FOUR WINDOWS WOULD NOT GO DOWN ON VEHICLE. WENT TO CAR LOT TO HAVE IT CHECKED OUT. MECHANIC FIXED THE PROBLEM. WENT BACK TO WORK. I GOT OFF AT 5:00PM. WENT HOME AND PARKED THE VEHICLE. 2 HOURS LATER A NEIGHBOR TOLD ME THAT THE VEHICLE WAS ON FIRE AFTER BEING PARKED FOR HOURS. *TR

I HAVE A 2000 FORD EXPEDITION WITH THE TRITON V-8, 5.4 LITER ENGINE THAT HAD A SPARK PLUG POP OUT OF THE HEAD WHILE I WAS DRIVING, DESTROYING THE FUEL INJECTOR. ACCORDING TO MY FORD DEALER, THIS IS A COMMON ISSUE. I HAVE NEVER HEARD OF THIS BEFORE AND CAN'T REALLY SEE HOW YOU CAN USE THE WORD COMMON WITH A SPARK PLUG EJECTING ITSELF, BUT OH WELL. ANYWAY, FORD DOES NOT HAVE ANY KIND OF WARRANTY ON THIS. HOW CAN THIS BE?? A SPARK PLUG EJECTING CAN LEAD TO THE VERY REAL POSSIBILITY OF FUEL COMING OUT OF THE CYLINDER AND IGNITING. THIS SEEMS PRETTY DANGEROUS TO ME. THE DEALER WILL HAVE TO HAVE THE SPARK PLUG PORT RE-THREADED AND A NEW INJECTOR PUT IN PLACE FOR A TOTAL OF 590 DOLLARS. UPON DOING SOME RESEARCH, THIS IS A VERY COMMON PROBLEM WITH FORD. *TR

2000 EXPEDITION WINDSHIELD WAS REPLACED IN NOVEMBER LEAK CAUSED VEHICLE TO DO CRAZY THINGS LIKE TRY TO START WHEN I TURNED THE HEADLIGHTS ON WITH KEY OUT OF IGNITION AND HAD A BURNING SMELL. THIS MORNING VEHICLE WOULDN'T START AFTER RAIN. AFTER JUMP STARTING VEHICLE OVERDRIVE LIGHT ON GEARSHIFTER HANDLE WAS BLINKING AND VEHICLE WOULDN'T GO INTO GEAR FEELS LIKE YOU'RE DRIVING WITH BRAKES ON. NO PROBLEMS MOVING IN REVERSE. PROBLEM STARTED OUT OF NOWHERE, ALSO LIGHTS FLICKER WHEN TRIED TO JUMPSTART. CONNECTED CABLES WOULDN'T START LIGHTS WENT DEAD REPOSITIONED CABLES LIGHTS CAME ON AFTER DOING THIS FOR OVER AN HOUR CAR FINALLY STARTED WITH THE ABOVE NOTED PROBLEMS. *TR

MY 2000 FORD EXPEDITION CAUGHT ON FIRE WHILE PARKED IN MY DRIVE WAY (WHICH IS A TOTAL LOSS). THE VEHICLE HAD NOT BEEN IN USE FOR ABOUT A DAY BEFORE IT CAUGHT ON FIRE. THE VEHICLE WAS PARKED SO CLOSE TO THE GARAGE DOOR THAT IF I WERE NOT OUT SIDE AT THE TIME OF THE FIRE I WOULD OF PROBABLY SEEN MY HOUSE BURN DOWN AS WELL. THE GARAGE DOOR ALTHOUGH SUSTAINED SOME DAMAGE. AFTER THE FIRE WAS PUT OUT BY THE FIRE DEPT. I WAS ASKED IF THERE WERE ANY RECALLS ON THE VEHICLE. WHEN THE VIN WAS CHECKED ON FORD WEBSITE IT TURNED OUT THAT THE VEHICLE HAD A RECALL ON THE CRUISE CONTROL SWITCH WHICH WE WERE NEVER NOTIFIED OF. NOT ONLY WERE WE NOT NOTIFIED BUT NO WERE ON THEIR RECALL DID IT SAY OF THE DAMAGE IT COULD CAUSE. I FOUND OUT BY INTERNET RESEARCH THAT IF IT IS NOT REPLACED IT COULD CAUSE UNDER THE HOOD FIRE. *TR

MY FAMILY AND I WERE AWAKEN IN THE MIDDLE OF THE NIGHT WITH OUR HOME FULLY ENGULFED IN FLAMES. IT WAS DETERMINED BY FORD INVESTIGATORS AND OUR LOCAL FIRE DEPARTMENT THAT THE FIRE ORIGINATED FROM MY FORD EXPEDITION THAT WAS PARKED IN THE GARAGE ALONG WITH MY WIFE'S VEHICLE. IT TURNED OUT THERE WAS A RECALL ON A CRUISE SWITCH ON MY VEHICLE. MY WIFE OR I NEVER RECEIVED ANY LETTER OR PHONE CALL FROM FORD NOTIFYING US OF THIS DANGEROUS CONDITION. WE WERE BLESSED TO ESCAPE WITH OUR LIVES. *TR

VEHICLE CAUGHT ON FIRE WHILE IT WAS PARKED AND TURNED OFF AND THE ASHES FROM THIS VEHICLE BURNED THE VEHICLE NEXT TO IT. *TR

VEHICLE WAS PARKED NEXT TO A FORD EXPEDITION THAT CAUGHT ON FIRE AND BURN MY VEHICLE TOO. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. IN 2007, THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE CRUISE CONTROL. THE VEHICLE WAS REPAIRED AT THAT TIME. TWO YEARS LATER, THE VEHICLE BURST INTO FLAMES WHILE PARKED IN THE DRIVEWAY. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND STATED THAT IT WAS CAUSED BY AN ELECTRICAL MALFUNCTION WITH THE CRUISE CONTROL. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 134,000.

OUR 2000 FORD EXPEDITION WAS PARKED FOR 12 HOURS AND THEN A FIRE STARTED IN THE ENGINE COMPARTMENT ON THE DRIVER'S SIDE NEAR THE BRAKE MASTER CYLINDER. IN 2007, WE HAD THE CRUISE CONTROL REPLACED BY A FORD DEALER DUE TO THE RECALL. THE FIRE WAS QUICKLY EXTINGUISHED, HOWEVER, THE VEHICLE IS TOTALED. APPARENTLY THE RECALL DID NOT CORRECT THE FIRES. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT NOTICED THAT BOTH OF THE REAR CHILD SAFETY LOCKS WERE INOPERATIVE IN HER VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 200,000 AND CURRENT MILEAGE WAS 334,000.

I WENT OUT TO MY TRUCK TO START IT AND THE RADIO WAS ON. NO KEYS IN IGNITION. STARTER ENGAGES WHILE RUNNING IN PARK AND NEUTRAL. WIPERS COME ON AND OFF NO KEYS IN IGNITION. LOCKS AND UNLOCKS BY ITSELF NO KEYS IN IGNITION. WHILE DRIVING HAVE TO PUT IN NEUTRAL TO ROLL WINDOW DOWN AND UP. ALL THIS HAPPENS WHEN IT RAINS OR SNOWS. *TR

I WAS DRIVING ON THE PENNSYLVANIA TURNPIKE IN A HARD RAIN AND THE WINDSHIELD WIPERS STOPPED WORKING. I COULD NOT SEE AND WAS FORCED TO QUICKLY BRAKE AND PULL OFF OF THE ROAD. THIS CAUSED A CAR BEHIND ME TO SWERVE OUT OF CONTROL. FORTUNATELY, THERE WAS NOT ANY PHYSICAL ACCIDENT. I AM VERY CONCERNED ABOUT THE SAFETY OF THIS VEHICLE AND FEEL LIKE I CAN'T DRIVE THE VEHICLE SAFELY IN THE RAIN. SYMPTOMS IN THE RAIN ONLY: WINDSHIELD WIPERS STOP WORKING. RADIO, FAN LIGHTS WORK INTERMITTENTLY. CLICKING NOISES AND FAN RUNNING WHEN VEHICLE IS OFF AND KEY IS NOT IN IGNITION. VERY WELL DOCUMENTED ISSUE ON THE INTERNET. DUE TO LEAKY WINDSHIELD WHICH DAMAGES ELECTRICAL SYSTEM BUT FORD HAS NO RECALL SINCE IT IS "NOT A SAFETY ISSUE". CASE NUMBER FROM FORD CUSTOMER SERVICE - 0382221079. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE WINDSHIELD WIPERS, RADIO, REAR WINDSHIELD WIPER, AND INTERIOR LIGHTING IN THE VEHICLE HAVE ALL STOPPED WORKING. THE FAILURES WOULD OCCUR ON RAINY DAYS. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE FAILURES WERE CAUSED BY THE GENERIC ELECTRONIC MODULE AND THE FUSE BOX. BOTH OF THESE COMPONENTS NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED, BUT THE CONTACT BELIEVES THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIRS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 125,000 AND CURRENT MILEAGE WAS 135,000.

2000 FORD EXPEDITIOPN SPARK PLUG BLEW OUT OF CYLINDER HEAD. *TR

RECURRENT ISSUE WITH MY 2000 FORD EXPEDITION. WHEN IT RAINS, THE ELECTRICAL SYSTEM SHORTS OUT, CAUSING THE BATTERY TO DRAIN, MAKING IT UNDRIVEABLE. VARIOUS ELECTRICAL COMPONENTS GO ON AND OFF WITHOUT THE KEY IN THE IGNITION, AND SOME GO OUT WHILE DRIVING. EXTREMELY DANGEROUS FOR WINDSHIELD WIPERS TO FAIL DURING A RAINSTORM!!! SOMETIMES, THERE IS A BURNING SMELL COMING FROM BELOW THE STEERING WHEEL. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE VEHICLE CAUGHT FIRE WHILE PARKED IN THE GARAGE AT THE CONTACT'S RESIDENCE. THE HOUSE AND THE OTHER VEHICLE PARKED IN THE GARAGE WERE BURNED. THE SHERIFF AND FIRE DEPARTMENT ISSUED CASE NUMBER 09021176 AND CONCLUDED THAT THE FIRE ORIGINATED UNDER THE HOOD OF THE VEHICLE. THERE WERE NO INJURIES. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 89,000.

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE VEHICLE CAUGHT FIRE WHILE IT WAS PARKED IN FRONT OF THE CONTACT'S HOME. THE FIRE ORIGINATED UNDER THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN IMPOUND LOT FOR INVESTIGATION BY THE CITY. THE CONTACT WAS INFORMED THAT THE VEHICLE SPEED CONTROL COULD HAVE CAUSED THE FAILURE. THE MANUFACTURER WAS CALLED, BUT THEY DID NOT CALL THE CONTACT BACK. THE FAILURE MILEAGE WAS 128,000.

I WENT TO WORK ON SUNDAY MORNING,AT 4:30 AM I GOT OFF WORK AND WENT BY THE WAL MART TO PICK UP A FEW THINGS AND WENT HOME FROM THERE, MY HUSBAND WAS BARBECUING SO I LEFT THE GARAGE UP. IT WAS SUPER BOWL SUNDAY. WELL WE WENT IN TO CATCH SOME OF THE GAME, OUR NEIGHBOR CAME TO THE BACK DOOR AND SAID THE TRUCK IN THE GARAGE IS ON FIRE,MY SAID WHAT AND THIS WAS ABOUT A HOUR AND A HALF AFTER I GOTTEN HOME. SO MY HUSBAND GRABBED SOME SHOP TOWELS AND PUT OUT THE FIRE AND HE GOT BURNED ON HIS HAND IN THE PROCESS OF PUTTING OUT THE FIRE. FORD WILL NOT TALK TO US ARE RETURN ANY CALLS. IM CALLING MY LAWYER...

2000 FORD EXPEDITION EJECTED SPARK PLUG LEADING TO FAILURE OF VEHICLE TO PROVIDE RELIABLE SAFE TRANSPORTATION IN WINTER DRIVING CONDITIONS, OUT OF CELL PHONE RANGE IN RURAL CENTRAL MOUNTAINS OF COLORADO. SPECIFIC SAFETY FACTOR OF 4WD SUV HAS BEEN REDUCED TO ZERO AND PLACES FAMILY AT ADDITIONAL RISK OF AN ENGINE FIRE. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN TO VIBRATE AND THE ABS INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY FOLLOWING, THE ODOMETER, HEAT, AND RADIO BECAME INOPERABLE AND THE VEHICLE BEGAN IDLING LOUDLY. UPON ENTERING HER DRIVEWAY, THE VEHICLE STALLED. THE BRAKE PEDAL WAS DEPRESSED, BUT THERE WAS NO REACTION. THE CONTACT REAR ENDED ANOTHER VEHICLE IN THE DRIVEWAY. THE VEHICLE DID NOT SUSTAIN ANY DAMAGES; HOWEVER, THE VEHICLE THAT WAS REAR ENDED SUSTAINED DAMAGE TO THE REAR BUMPER. THERE WERE NO INJURIES OR A POLICE REPORT. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT WATER ENTERED THROUGH THE WINDSHIELD AND DRAINED INTO THE FUSE BOX, WHICH DAMAGED THE G.E.M MODULE. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER STATED THAT THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE 120,000.

I HAVE A 2000 FORD EXPEDITION WITH THE TRITON 5.4 LITRE V8 ENGINE. THIS VEHICLE HAS A LITTLE OVER 100,000 MILES AND IS USED FOR PERSONAL TRANSPORTATION ONLY. TODAY WE HAD A SPARK PLUG BLOW OUT ON THE VEHICLE AND HAD TO HAVE IT TOWED TO THE LOCAL FORD DEALERSHIP. THE MECHANIC AT THE DEALERSHIP QUOTED ME A PRICE OF OVER $700 TO HAVE A TEMPORARY FIX OF A HELI COIL PLACED INTO THE SPARK PLUG HOLE TO REPLACE THE STRIPPED THREADS CAUSED BY THE BLOWOUT AND TO HAVE THE COIL REPLACED. HE MENTIONED THAT THIS TEMPORARY FIX IS NOT SOMETHING THAT HE CAN GUARANTEE WILL WORK SO HE ALSO OFFERED ME A $5000 "PERMANENT FIX" OF HAVING THE ENTIRE ENGINE BLOCK REPLACED. UNFORTUNATELY, DUE TO MY FINANCIAL SITUATION, I CANNOT AFFORD THE PERMANENT FIX AND AM HAVING TO OPT FOR/GAMBLE WITH THE TEMPORARY FIX ATTEMPT. ACCORDING TO THE MECHANIC AND RESEARCH INFORMATION I FOUND ON THE INTERNET, THIS IS A COMMON OCCURRENCE PROBLEM. WE ARE IN THE PROCESS OF HAVING THE MECHANIC AT THE FORD DEALERSHIP ATTEMPT THE $700 TEMPORARY REPAIR. WITH THE FACT THAT THIS IS A KNOWN ISSUE TO FORD AND CONSUMER AFFAIRS, THIS ISSUE SHOULD BE PART OF A RECALL FROM FORD MOTOR COMPANY. *TR

MY 2000 FORD EXPEDITION XLT OUT OF THE BLUE STARTED ACTING BIZARRE. COME TO FIND OUT THE WINDSHIELD SEAL HAD A LEAK WHICH IN TURN DESTROYED MY GEM MODULE AND FUSE BOX. ACCORDING TO OTHERS THIS IS A PROBLEM THAT IS OUT OF HAND. FORD NEEDS TO FIX THIS AND RESEAL ALL WINDSHIELDS, I DON'T HAVE $1000+ TO REPAIR AND HAVE A VEHICLE I PAID TOO MUCH MONEY FOR THAT IS NOW SITTING IN MY GARAGE. *TR

WE RECENTLY HAD A SNOW STORM IN OUR AREA. AFTER THE STORM OUR EXPEDITION STARTED HAVING PROBLEMS. THE FIRST PROBLEM TO OCCUR WAS THE FRONT BLOWER MOTOR FOR THE CLIMATE CONTROL WOULD TURN ON HIGH WHEN THE IGNITION WAS TURNED TO THE OFF POSITION. I STARTED RESEARCHING THIS PROBLEM AND STARTED FINDING MANY SIMILAR STORIES ON THE INTERNET. THE NEXT DAY MANY OTHER PROBLEMS POPPED UP SEVERAL DASH LIGHT WERE FLASHING ON AND OFF, WHEN THIS WAS HAPPENING YOU COULD HERE RELAYS UNDER THE DASH CLICKING ON AND OFF. WHEN THE TRUCK WAS HAVING ITS EPISODE OF FLASHING LIGHTS I FOUND THAT MY WINDOW CONTROLS AND WINDSHIELD WIPERS ALSO DID NOT WORK. I PARKED THE CAR AND TURNED IT OFF THAT DAY AND IT HAD ONE MORE SURPRISE FOR ME. WHEN THE LIGHT SWITCH WAS TURNED TO THE AUTOMATIC DAY TIME RUNNING LIGHTS AND THE KEY WAS OFF YOU COULD HERE RELAYS UNDER THE DASH OPENING AND CLOSING AT A FAST RATE. I TURNED THE SWITCH TO OFF AND IT STOPPED. I TALKED TO MY STEPFATHER WHO IS A MECHANIC. HE TOLD ME THAT HE HAS SEEN THIS BEFORE HE SAID IT PROBABLY WAS MY GEM MODULE, HE SAID THAT THIS TYPE OF VEHICLE IS PRONE TO THESE MODULES MALFUNCTIONING. I DID MORE RESEARCH ON LINE AND FOUND THAT A INVESTIGATION WAS DONE ON THIS ISSUE BY NHTSA THE ACTION NUMBER WAS EA05015 IT WAS CONDUCTED IN 2005. FROM THE LOOKS OF IT THIS HAS BEEN A PROBLEM FOR A LONG TIME THAT HAS AFFECTED MANY PEOPLE BUT STILL NO ACTION HAS BEEN TAKEN. THIS IS ONE OF TWO PROBLEMS I HAVE HAD WITH THIS OTHERWISE GOOD VEHICLE WHICH IS MAKING IT AN UNR

LEAK IN WINDSHIELD AREA. SHORTS OUT HE FUSE BOX AND GEM. ONCE THIS HAPPENS THERE ARE MULTIPLE ELECTRICAL PROBLEMS. FORD DOES NOT COVER THE COST FOR THIS OBVIOUS DEFECT. HAVE HEARD AND READ OF MANY OTHER PEOPLE WITH SAME ISSUE. THIS CAN MAKE THE VEHICLE SHUT OFF WHILE DRIVING, WINDSHIELD WIPERS TO STOP FUNCTIONING, VEHICLE TRYING TO START WITH KNOW KEYS IN IT. IT CAN EFFECT ALL FACETS OF THE ELECTRICAL SYSTEM. *TR

FIRST THE BLOWER WOULD TURN ON HIGH AFTER THE KEY WAS TURNED OFF. THEN THE DASH WARNING LIGHT WOULD FLASH ON AND OFF ALONG WITH RELAYS. THE THE ABS RELAYS WOULD CLICK ON AND OFF AFTER KEY HAS BEEN TURNED OFF. THE WIPERS WOULD STOP WILL THE VEHICLE WAS RUNNING. NOW WHEN THE KEY IS TURNED OFF AND REMOVED THE CAR IS STILL IN THE START POSITION,RADIO,FUEL INJ.,HEATER,WIPERS. ALL STAY ON. THE ONLY WAY TO KEEP BATTERY FROM DYING IS TO DISCONNECT THE NEGV. POST. THEN THE THEFT LIGHT FLASHES SOMETIMES WHEN BATTERY IS RE-CONNECTED CAUSING THE CAR NOT TO START. I HAVE CHECKED AND REPLACED MANY RELAYS. I AM AT A LOSS,WHAT CAN I DO? *TR

PLEASE REOPEN 1000'S OF EMAILS TO FORD. DOORS LOCKING AND UNLOCK WITH CHILDREN IN BACK SET. GAUGE AND LIGHTS NOT WORKING CORRECTLY, WINDSHIELD WIPERS NOT WORKING CORRECTLY WHILE IT RAINING PLEASE DON'T MAKE ME HAVE TO DIE IN AN ACCIDENT BEFORE YOU DO SOMETHING WE BOUGHT THIS VEHICLE FOR SAFETY. AND NO ONE WILL ACCEPT PROBLEM AND WE DON'T HAVE MONEY TO FIX FORD SCREW UP PLEASE READ EMAILS ON THIS ISSUE IF YOU SAY THERE AREN'T ANY YOU LYING TO YOURSELVES NHTSA ACTION NUMBER : EA05015 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE / MODELS : MODEL/BUILD YEARS: FORD / EXPEDITION 1999-2001 MANUFACTURER : FORD MOTOR COMPANY COMPONENT : ELECTRICAL SYSTEM EXTERIOR LIGHTING VISIBILITY:WINDSHIELD WIPER/WASHER DATE INVESTIGATION OPENED : OCTOBER 13, 2005 DATE INVESTIGATION CLOSED : DECEMBER 6, 2006. *TR

ALARM WENT OFF AND TRUCK CAUGHT A FIRE; LOCAL FIRE DEPARTMENT PUT FIRE OUT. *TR

I WAS JUST DRIVING ALONG GOING 15MPH WHEN MY SPARK PLUG BLEW-OUT OF THE CYLINDER HEAD IN MY 2000 FORD EXPEDITION. I HAVE 91,000 MILES ON IT. NOW IT IS COSTING ME $1100.00 TO FIX. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT HIS FUEL TANK WAS LEAKING AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE DEALER STATED THAT THE FUEL VAPOR RECOVERY SYSTEM WAS NOT OPERATING PROPERLY. AFTER TESTING THE VEHICLE, THE DEALER DISCOVERED THAT THE FUEL TANK WAS WARPED AND FUEL WAS LEAKING FROM THE TOP. THERE IS NO RECALL ON THE FUEL TANK AND THE REPAIR WOULD COST $2,000. THE CONTACT WAS UNSURE WHETHER OR NOT HE COULD REPAIR THE FAILURE. THE FAILURE MILEAGE WAS 78,253. UPDATED 12/02/08. *LJ UPDATED 12/03/08. *JB

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT WAS AWAKENED BY HIS VEHICLE CATCHING FIRE. HIS VEHICLE AND HOUSE WERE COMPLETELY DESTROYED. HE HAS PICTURES OF THE FAILED INCIDENT AND A POLICE REPORT WAS FILED. THE INSURANCE COMPANY IS IN THE PROCESS OF INSPECTING THE VEHICLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 175,000.

I HAD A SPARK PLUG BLOW OUT FROM THE ENGINE COMPARTMENT. AFTER SEARCHING THE INTERNET, I FOUND THIS IS A VERY COMMON PROBLEM WITH FORD TRITON ENGINES. *TR

I HAVE A 2000 FORD EXPEDITION AND I HAVE PROBLEMS WHEN IT RAINS OR SNOWS WITH THE WINDSHIELD LEAKING AND THEN THE CAR STARTS DOING THINGS LIKE WINDOWS GOING UP AND DOWN WIPERS NOT WORKING OR THE CAR WILL JUST STOP WORKING THIS HAS HAPPENED TWICE THE FIRST TIME I WASN'T DRIVING WHEN IT HAPPENED I WAS IN MY DRIVEWAY. THEN TODAY I STARTED MY CAR UP AND IT HAD BEEN RAINING BUT EVERYTHING SEEMED FINE THEN THE WINDOWS WENT DOWN AND THE CARE SHUT DOWN I COULD NOT STEER AND I HIT A PARKING SIGN I TRIED TO FIND OUT IF THE WINDSHIELD WAS RECALLED I NO A FEW PEOPLE THAT HAVE HAD THE SAME PROBLEM WITH LEAKING WIND SHIELD AND THE ELECTRICAL WIRES GETTING WET THANK YOU FOR YOUR TIME. *TR

GEM MODULE FAILURE CAUSING REAR WINDSHIELD WIPER AND RADIO DISPLAY NOT TO WORK AND HEAT/AC ONLY TO WORK IN DEFROST MODE. *TR

AS I WAS DRIVING MY 2000 FORD EXPEDITION DOWN MY STEEP DRIVEWAY, I FELT A HARD BUMP AND FELT LIKE I HIT SOMETHING. I LOOKED OUT MY REARVIEW MIRROR AND SAW MY TIRE ROLLING DOWN THE STREET! THE TIRE WAS OUR FULL-SIZE SPARE THAT HAD BEEN SECURED UNDER THE TRUCK. THE HAPPENED LAST YEAR, 2007 AROUND SPRING TIME. LUCKILY, I WAS JUST COMING OUT MY OWN DRIVEWAY AND NOT DRIVING DOWN THE FREEWAY WITH MY CHILDREN. I WOULD HAVE FILED THIS SOONER BUT JUST FOUND THIS WEBSITE TODAY. WE HAVE NOT TAKEN THE TRUCK TO THE DEALER TO SEE WHAT BROKE OFF BUT NOW THAT I SEE WE MAY NEED TO FOR THE CRUISE CONTROL RECALL FROM 2005..WE WERE IN SOUTH KOREA AND NEVER RECEIVED ANY RECALL NOTIFICATIONS OVER THERE. ANYWAY, IF YOU'VE HAD NUMEROUS COMPLAINTS SIMILAR TO MINE, IT MAY BE WORTH CHECKING INTO BEFORE SOMEONE ELSE LOSES A SPARE IN THE MIDDLE OF A CROWDED FREEWAY. THANK YOU, CHRISTINE HOLLOWAY *TR

MY 2000 FORD EXPEDITION CAUGHT ON FIRE IN THE PARKING GARAGE AT MY JOB AND DAMAGED 6 OTHER CARS WITH NO SIGNS OF ANY WARNINGS. *TR

SPARK PLUG BLOWN OUT ON MY 2000 EXPEDITION. *TR

A 2000 FORD EXPEDITION PARKED IN THE YARD FOR 3 HOURS AND SUDDENLY STARTED BURNING UNDER THE HOOD. WE DIDN'T SMELL ANYTHING BURNING .IT JUST STARTED TO BURN AFTER 3 HOURS. IS THERE A RECALL ON THIS TRUCK? IT HAS CRUISE CONTROL. THANK YOU. *TR

WITH NO WARNING SPARE TIRE CABLE SNAPPED WHILE DRIVING DOWN ROAD CAUSING SPARE TIRE TO FALL OUT AND STRIKE REAR WHEEL OF VEHICLE, THEN FLEW OFF SIDE OF ROAD. DISCUSSION WITH FORD INDICATED THIS IS UNHEARD OF AND THEY WANTED $300+ TO REPAIR. DISCUSSIONS WITH MULTIPLE OTHER SHOPS (NOT FORD) INDICATE THIS DOES HAPPEN WITH THIS TYPE OF SPARE MOUNT. REPAIRS COMPLETED FOR UNDER $150. I AM CONCERNED THAT SPARE CAN COME OUT AND ONCE LOOSE HIT OTHER VEHICLES OR PROPERTY/PERSONS. *TR

2000 FORD EXPEDITION CAUGHT ON FIRE AND BURNED. *TR

SPARK PLUG BLEW OUT, CAUSING LOUD, POP-LIKE NOISE, AND PUFF OF WHITE SMOKE. PLUG BLEW A HOLE IN THE ENGINE BLOCK. ENGINE WAS A 2000 FORD EXPEDITION EDDIE BAUER 5.4 TRITON V8. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WOULD SPORADICALLY STALL. THE DEALER STATED THAT THE COIL PACK LOCATED NEAR THE AIR COMPRESSOR, COULD DEVELOP MOISTURE, WHICH WOULD CAUSE THE COIL SPRINGS TO FAIL AND THE VEHICLE TO STALL. SECONDLY, THE TECHNICIAN STATED THAT IN RAINY CONDITIONS, CONDENSATION UNDER THE HOOD COULD CAUSE THE COIL SPRINGS TO FAIL SPONTANEOUSLY. AS A RESULT, THE RISK OF A CRASH IS INCREASED. THREE COIL SPRINGS NEED TO BE REPLACED AT THE COST OF $500. THE MANUFACTURER DID NOT ASSIST. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. A WEEK AFTER THE VEHICLE WAS TUNED UP, THE CONTACT HEARD A LOUD POP WHILE DRIVING 20 MPH. SHE DROVE HOME AND HAD THE VEHICLE TOWED TO A DEALER. THE DEALER STATED THAT THE SPARK PLUG BURST OUT OF THE SECOND CYLINDER IN THE ENGINE. APPROXIMATELY ONE YEAR LATER, IN JUNE OF 2008, THE CONTACT'S HUSBAND HEARD A LOUD POP AGAIN WHILE DRIVING. HE PULLED OVER AND NOTICED THAT THE SPARK PLUG WAS LOOSE AND DETACHED FROM THE FIFTH CYLINDER. THE DEALER STATED THAT IT WAS A MANUFACTURER DEFECT AND DUE TO THE FAILURE, THE ENTIRE ENGINE HEAD WOULD HAVE TO BE REPLACED TO DECREASE THE LIKELIHOOD OF THE ISSUE RECURRING. THE CURRENT MILEAGE WAS APPROXIMATELY 114,000 AND FAILURE MILEAGE WAS APPROXIMATELY 100,000.

WHEN I TURNED MY TRUCKS ENGINE OFF LAST NIGHT AND REMOVED THE KEY, THE AC BLOWER CONTINUED RUNNING. OF COURSE IT DRAINED MY BATTERY. I REPLACED THE BATTERY. I RESEARCHED THE SITUATION ON THE INTERNET AND FOUND THAT HUNDREDS OF OTHER FORD EXPEDITION OWNERS HAVE THE SAME PROBLEM. DUE TO A MAL-FITTING WINDSHIELD, WATER DRAINS INTO THE FUSE BOX. IT SHORTS OUT THE FUSE BOX AND GEM MODULE. MY TRUCK IS NOW NOT WORKING AND ESTIMATES RANGE ABOUT $1000 TO FIX. CLEARLY THIS SHOULD HAVE BEEN A RECALL ISSUE, SINCE FORD ADMITS THAT THE WINDSHIELD IS THE CAUSE OF THE PROBLEM. *TR

I HAVE A 2000 4.6 FORD EXPEDITION WITH APPROX 150,000 MILES ON IT. I DROVE IT FROM LOS ANGELES TO SAN FRANCISCO. WHEN I ARRIVED IN SAN FRANCISCO I WAS GREETED BY A LOUD POP AND AN ACCOMPANYING RATTLE AND SPUTTER. THE FRONT DRIVER SIDE SPARK PLUG HAD BLOWN OUT AND BROKE OFF THE IGNITION COIL. THE SPARK PLUG STRIPPED THE THREADING OF THE ALUMINUM HEADS. I TOOK IT TO A FORD DEALERSHIP IN SAN FRANCISCO AND THEY BLAMED FAULTY INSTALLATION OF THE SPARK PLUG. IN RESEARCHING THE PROBLEM I HAVE FOUND THAT MANY OTHERS HAVE HAD THIS SIMILAR PROBLEM NOT SPECIFIC TO CHANGED SPARK PLUGS. I HAVE ALSO LEARNED THAT SOME CLASS ACTIONS SUITS HAVE BEEN FILED AGAINST FORD IN REGARDS TO THIS PROBLEM BUT HAVE NOT BEEN SUCCESSFUL. I AM OUT A COUPLE OF THOUSAND DOLLARS AND AN EXTENDED STAY IN SAN FRANCISCO DUE TO THIS PROBLEM THAT I AM LEARNING WHAT IS HAPPENING FAR TO COMMON REGARDLESS OF THE AGE OR THE MAKE OF A FORD PRODUCT. I AM THANKFUL THIS DID NOT OCCUR IN A DESOLATE OR DANGEROUS AREA BUT I AM EXTREMELY UPSET IN WHAT SEEM APPARENT TO ME AND MANY OTHERS AS A FACTORY DEFAULT. *TR

2000 FORD EXPEDITION XLT WITH 5.4 TRITON ENGINE. I'VE HAD 2 SPARKPLUGS POP OUT OF THE ENGINE ON TWO SEPARATE DAYS. ONE IN DEC. 07 AND THE OTHER IN AUG. 08. SINCE IT IS INEVITABLE THAT THE HEADS BE REPAIRED I USED JB WELD TO EPOXY THE SPARKPLUGS IN WITH SUCCESS. IN 100,000 MILES I'LL HAVE TO PAY TO HAVE THE HEADS REPAIRED, BUT I MAY NOT HAVE THE CAR AT THAT TIME. *TR

I OWN A FORD EXPEDITION 2000. THE PAINT OF THE CAR IS LETTING GO FORM THE PRIMER THIS VEHICLE HAS BEEN TAKEN CARE OF. I CHECKED ON LINE AND FOUND SEVERAL OTHER PEOPLE COMPLAINING ABOUT THE SAME PROBLEM. THE VEHICLE WAS INSPECTED BY A BODY SHOP AND THE STATED THAT FORD SHOULD BE RESPONSIBLE SINCE IT IS THE PRIMER THAT IS LETTING GO OF THE METAL AND BUBBLING THE PAINT RIGHT IF THE CAR. WHEN THE PAINT FLAKES OFF IT IS JUST THE METAL AND NO RUST AT THAT POINT THEN WITH IN DAYS IT IS RUST PLEASE HELP. *TR