2020 Ford Escape complaints

My left side door. The door is making a popping/cracking noise the window won’t go down because the welding broke off

ON [XXX] I NOTICED MY WIFES FRONT DRIVER DOOR HINGE WAS MAKING NOISE. AT THAT TIME I LUBED THE DOOR HINGES. NOISE STILL PRESENT DOOR HARD TO CLOSE. OPENED AND CLOSED DOOR MULTIPLE TIMES TO MAKE SURE DOOR WOULD CLOSE AND LATCH. ON [XXX] MY WIFE DROVE THE VEHICLE IN THE AM. UPON ARRIVING HOME SHE INFORMED ME THAT THE WINDOW ON THE DRIVER DOOR WOULD NOT OPEN. I OPENED THE DOOR AND PUT THE WINDOW DOWN .AND IT WOULDN'T GO BACK UP AND THE DOOR WOULD NOT CLOSE.AT THAT POINT I CONTACTED A FRIEND WHO OWNS A BODY SHOP AND HE TOLD ME TO BRING THE VEHICLE TO THE SHOP. WITH THE DOOR NOT CLOSING I TOOK THE SEAT BELT AND PUT IT AROUND THE DOOR FRAME AND THROUGH THE WINDOW OPENING AND DROVE THE VEHICLE 2 MILES TO HIS SHOP WITH THE DOOR OPEN ABOUT 8 INCHES FROM THE LATCH WHILE HOLDING ONTO THE SEAT BELT. AT HIS SHOP WE WERE ABLE TO GET THE WINDOW UP AND THE DOOR CLOSED.THE DOOR OPENS AND CLOSES NOW BUT WE WONT PUT THE WINDOW DOWN.HE NOTICED THAT THE DOOR HINGE CHECK REINFORCEMENT HAD BROKEN OFF OF THE INSIDE OF THE DOOR. ON 12/27/2023 @907AM I NOTIFIED FORD MOTOR CO OF THE PROBLEM. THE GAVE ME A CASE #([XXX]) AND TOLD ME TO TAKE VEHICLE TO A DEALER TO VERIFY PROBLEM. ITOOK THE VEHICLE TO TUNKHANNOCK FORD AND PROBLEM WAS VERIFIED. DEALER TRIED TO VERIFY CASE # BUT WAS UNABLE TO VERIFY. AGAIN ON 01/04/2024 8PM. ICALLED FORD AGAIN GIVE ANOTHERCASE #([XXX]).DEALER AGAIN TRIED WITH NO LUCK CALLED FORD AGAIN ON 01/16/24 @6.40PM AND TOLD THE 1ST CASE # WAS THE CORRECT #. NO LUCK AGAIN FINALLY ON 01/

Problem with 2020 Ford escape door hinge. It happened about 1,000 miles after warranty ended. Repair shop took pictures and sent to Ford. Ford said it was out of warranty. Since then window will not go down and door is harder and harder to close and lock. 10/9/23 took to be serviced because check engine light would come on and off intermittently along with other messages. They found multiple codes for lost communication. They reprogrammed them. Ford also recommended to reprogram instrument panel. They told me because of door I may still get messages. I still get message about low windshield washer fluid. This is intermittently too. 1/22/24 took car to be inspected. They are concerned about the door. Got call they are trying to replace a part in door but having problems. Car is still at garage.

AWD Module failed, deactivated all traction control, all wheel drive, pre-collision alert, emergency breaking. Module failure is known issue to Ford

Drivers side inside door welds have broken loose at catch arm attachment. Related to Ford TSB SSM 50150. Car bought used 1/6/2024 but previously used as a rental in another state. Car has approximately 64,500 miles. Door failure occurred 1/19/2024. Bought from out of town dealer and inspected by local Ford dealer who verified issue. No prior signs leading up to the failure. Neither dealer agrees to repair without charge.

The contact owns a 2020 Ford Escape. The contact stated that while the vehicle was parked, the contact started the vehicle, and the power train malfunction indicator lamp warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed gear shifter module. The contact was informed that the gear shifter module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 19,000.

Had Driver Front door welds broke on the inside of the door about one year ago and now the passenger front door has the same issue

The welding on the driver side door broke for no reason. Since that time it has sprung open for no reason and almost hit another vehicle. It has also slammed shut several times and hit my leg as I have attempted to exit the car.

Left front door hinge arm broke because of a failed weld. Dealer says it’s not covered and I have to pay for full door replacment.

The driver's side door hinge/arm is broken. Sometimes the door cannot shut, sometimes it is very difficult to open. If this is the same issue as that reported by car and driver [XXX], then whoever drives the car could be at risk of the door coming open while the car is in motion. I took the car to my local Ford Dealer/Repair shop today. They said it isn't an issue they can handle: I have to take it to a body shop. I've taken it to 2 body shops. One believes the door must be replaced (for $3,900) and the other thinks he can fix it without replacing the door. The problem first started as a sound like plastic getting caught. Then it worsened (the weather here got worse as well-- down to -25). When the door was hard to open, I pushed it harder and then I started getting metal against metal noises. There were no warning lights on the dashboard at all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am experiencing the piping sound on the drivers door arm as mention in the active investigation. I called the dealer and they want $4000 to put a whole new door on. The arm Barack also bust my window clips and now my drivers window will not go down as a result.

Driver door popping and won’t shut. Welds broke off the hinge

The contact owns a 2020 Ford Escape. The contact stated that the front driver’s side door failed to open and close as needed. The vehicle was taken to a dealer and the contact was informed to take the vehicle to a body shop to have the door serviced. The vehicle was taken to an independent mechanic where they discovered that the spot weld inside the door was defective, and the door needed to be replaced. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 28,400.

The contact owns a 2020 Ford Escape. The contact stated that while opening the driver's front door, the contact heard a popping sound. In addition, the contact stated that when the door was closed, she heard the popping sound. The contact stated that several days later, while opening the door the popping sound was extremely loud and the door was difficult to close. The contact also stated that the driver's side front door was inoperable, and the window would not go up or down. The vehicle was taken to the dealer where it was diagnosed with failed check arm welding and that the driver's side front door needed to be replaced. The vehicle was not repaired. The contact was informed that the repair would not be covered under warranty. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

Driver's side door hinge is loose, making cracking sounds and hard to close. Also affecting the window operation - doesn't allow window to be rolled up.

Door Hinge spot welds broken on the check arm moving freely causing loud noise in the driver door making it hard to operate and won't allow the window to roll down.

The contact owns a 2020 Ford Escape. The contact stated that when pressing the brake pedal while in reverse the vehicle would emit a loud howling noise. There were no warning lights. The vehicle was taken to the dealer where it was diagnosed that the bolt kit and spring kit for the brakes failed and needed to be replaced. The vehicle had not been repaired due to the parts being on backorder. The manufacturer had been made aware of the failure. The contact was referred to NHTSA to file a complaint. The failure mileage was 32,000.

The driver side door of my 2020 Ford Escape is making a popping noise as the door opens and closes. I have researched that this may be caused by cracks or broken spot welds in the left front door at the check arm attachment point in the door assembly.

My vehicle is one of the 2020 Ford Escapes with the broken spot welds on the door control arm. I can no longer operate the driver-side window and Ford wants $2500 to replace the door.

Approximately 1/4/2024 The front drivers side door is broken. The bolts broke off on the inside.I had no prior warning, I went to open my door and a huge clunk sound happened and it was difficult to open , there was friction ,opening it all the way is causing friction and I don’t want the door to fall off. Also it’s causing the automatic window not to work now , that only is opening half way . I took it to the dealer to assess the problem and it’s the left door asy , I looked this up online and it’s stating Ford is aware of this problem but still hasn’t issued a recall. I do not want my door to fall off , especially if I’m driving and this happened . This is also a huge financial burden on anyone , please can you help with this situation . Thank you

The door hinge on the driver side of my 2020 Ford escape snapped causing damage to my window. The spot welds broke. Even though Ford is aware that this is an ongoing problem with this make and model and I pay for an extended warranty. They refused to cover this and are telling me I have to pay for it out of pocket. This door hinge broke about a month ago and I called Ford and they told me that they would not cover it at all. I even called corporate office for Ford and they told me they would not cover it upon bringing my vehicle to formula Ford in Rutland Vermont to have inspected. They refuse to inspect my car, took it to a body shop to have an estimate provided to me and said that they might be able to have Ford cover it upon getting the estimate and contacting ford They refused to pay for it repair and will not inspect my car . I feel that this is unfair since it’s nothing I did to break this door. It’s just really crappy craftsmanship.

2020 Ford Escape has a broken spot weld in the drivers door. First the door would stick when opening and closing then it would not close. This cost us a tow to the dealership and from there to a collision shop. My warranty ran out on Feb. 27 this occurred in April on Easter Sunday. I contacted Ford support about the matter, several times, and wrote letters to the Ford Corporation because the cost of this repair should not fall on me this is a known problem to Ford. I have a copy of the paper work that Ford sent out to repair shops detailing the problem. This defect happened in the factory it was not caused by me. In order to close the driver's door I could only roll my window down a few inches. Every time I went to a drive through I had to open my door to do business, rain or shin and embarrassing. I asked the repair shop to help me with the window issue so they removed a part in the door. Now I have to hang on to the door when opening because it will fly open. This defect is a Ford defect and the consumer should not be held responsible. Since my car went to the shop they have had many others come in with same problem, if they are still under warranty door is paid for. But not mine! We even bought the EasyCare to cover future car trouble and guess what the inside of door not covered. I have notes and letters to show my attempt to get Ford to own up to their mistake They can afford it more than me.

Drivers side Front door pops when you open or close it drivers side window won’t let down all the way lift gate doesn’t work most of the time but the most scary issue is riding down the road radio screen will read turn engine on or shut off to save battery this car is only 3 years old I shouldn’t have these kind of issues

I own a 2020 Ford Escape. While entering the vehicle through the driver's side door, the door made an abnormal popping sound while being opened. The passenger’s side front door also made the abnormal popping sound while being opened. I have been informed by my repair shop that the doors will need to be replaced. I took to my local dealership, Kindle Ford and they informed me that the vehicle is out of warranty as the mileage is at 40,000 miles.

Opened the driver's door and heard a crunching sound and the door could not be opened all the way. Along with that the rear back window would not close and the driver's window went up slowly. Went to the dealership and they say it is a known problem, but they don't have any recalls about them so out of pocket it would cost me upwards of 2000 for the window regulators and 5,000 to replace the door which is a known problem.

My car is what is being investigated under PE23013. The welds on my driver door have come undone.

Heard a cracking or popping when opening or closing front driver side door. Took our 2020 Ford Escape to Authorized Ford Dealership for routine service. While the vehicle was at the dealership we were told that the front drivers door would not close shut. The technician managed to "jimmy rig" the door to get it to close. The door temporary closes but now the drivers window will not operate. Was instructed to take the vehicle to the dealership owner's body shop but due to the mileage on the vehicle it was not recovered under warranty. At the body shop we were asked if the car had been in an accident or if a strong wind had blown on the door. Neither applied. The car has not been in a single accident nor a strong wind pulled or pushed on the door. Was told that we would incur a cost of nearly $3,000, because the whole door would need to be replaced. Was told again that this was not covered by factory warranty. On the estimate from the body shop they listed "t-boned" as reason for damage. We reached out to our extended warranty and they wanted to talk to the body shop but the body shop refuses to work with the warranty company and only speak with our auto insurance. We are in the process of looking for another body shop that might reach out to the warranty company to see if there is any chance this is covered. We contacted Ford Motor Company Customer Service and was told that there is not a recall on the defect and there was nothing they could do. Research on the internet shows

Door check bracket is popping/clicking as I close & open my drivers side door. Also the window can only roll down 25% of the way now because of the bracket failure

Bought new, June 2021, both rear shocks leaking. Replaced with same type. Now 12/28/23 63,800 miles, both rear shocks leaking again. Can only replace with same part.

This is 1 of 3 2020 - 2021 Ford Escapes that my company owns and is affected by this known issue with NHTSA and Ford Motor Company as it relates to Ford Technical Service Bulletin (TSB) SSM 50150. The spot welds at the check arm attachment points on the driver door have failed. This has lead to a horrible noise and feeling when opening and closing our door. Sometimes the door does not shut all the way making this a safety issue. The door is now hard to open and close. The window is also inoperable as it either won't roll down at all or, if it does roll down, it will now roll back up. This issue has been inspected by 2 dealerships and they are not allowing our PremiumCARE extended Warranty to cover this. We have had 10's of Escapes with 100,000+ miles and this has never been an issue. This has occurred in this 2021 Escape and 2 of our other 2020 Ford Escapes (I will file complaints separately for them so NHTSA understands this is a massive issue Ford needs to fix ASAP and reimburse any customers who have paid out of pocket to get this fixed). NHTSA needs to issue a recall immediately.

This is 1 of 3 2020 - 2021 Ford Escapes that my company owns and is affected by this known issue with NHTSA and Ford Motor Company as it relates to Ford Technical Service Bulletin (TSB) SSM 50150. The spot welds at the check arm attachment points on the driver door have failed. This has lead to a horrible noise and feeling when opening and closing our door. Sometimes the door does not shut all the way making this a safety issue. The door is now hard to open and close. The window is also inoperable as it either won't roll down at all or, if it does roll down, it will now roll back up. This issue has been inspected by 2 dealerships and they are not allowing our PremiumCARE extended Warranty to cover this. We have had 10's of Escapes with 100,000+ miles and this has never been an issue. This has occurred in this 2020 Escape and 1 other 2020 Ford Escape and 1 other 2021 Ford Escape (I will file complaints separately for them so NHTSA understands this is a massive issue Ford needs to fix ASAP and reimburse any customers who have paid out of pocket to get this fixed). NHTSA needs to issue a recall immediately.

Door hinge broke and caused window motor to fail

The weld on my driver door has completely come loose. The only repair is to replace the whole door.

Door hinge stop welds broken inside door.

My driver's side door suddenly made a loud cracking/popping noise when I opened it and then was a little difficult to close. Later when I opened my driver's side window it got stuck and wouldn't go up or down. I took it to my mechanic who said the door hinge had broken free from the body of the car. I then took it to the local Ford dealership who confirmed this is the case and also mentioned this was the second 2020 Ford Escape to be brought in that day for the exact same problem. They were unable to fix it at the dealership and said I need to go to an auto body repair shop to have a new hinge welded back on. Upon doing a little research I discovered that this is a very common problem with this year/make of vehicle.

7/31/23 Used 2020 Ford Escape was bought at Cecil Atkission Motors, it was deemed "fully functional, no present issues." 08/02/23 Tire issues, dealership inspected and found 2 screws in driver tire/failed alignment test. Also suddenly found oil pan and left axle seal leaking. Seal leaking and replaced. Front axle leaking. 12/08/23 Took Ford Escape to Ford Dealership due to broken popping driver door. Vibration while driving 70mph, inspected and the cause of it is front suspension and uneven tires given by Cecil Atkission Motors. Found oil leak again front cover and oil pan, leak on crank shaft rear main seal. Trans and engine dye found between. Rear seal leaking. Rattle noise at cold start, coming from turbo. Misfire at 2 and 3 cylinders. Blindside spot doesn't detect cars next to car. Due to the driver door being broken and unable to open it poses a safety hazard if car caught on fire or if an accident, unable to escape. Being a 2020-year vehicle, this should not be happening early on. All issues mentioned above are hazardous to my safety and others, including children.

When opening and closing the driver's door, it makes a creaking sound. It will not open completely and will not stay open. In addition, the power windows seem to be affected. I have taken it to a dealership and they report that the door hinges welding has failed.

Spot welds on the driver's side (left) door have failed, teh welds hold the door limiting arm attachment . Documented in NHTSA ID Number: 10201603 Manufacturer Communication Number: SSM 50150 Car has <30,000 miles and is a family vehicle, not high use nor commercial. Failure was recent <2 weeks after noises first appeared. All welds are noticeably failed from the outside of the door.

The AWD module (LX6Z 7P238 AANP MODULE) went out on my 2020 Ford Escape. One day when starting my car several warnings popped up on the screen. The warnings were “AWD off”, “Pre-collision assist not available”, “Service Advanced Trac”, “AWD fault service required”, “Up hill assist not available” “Traction control system fault or not available?” and the wrench on the dashboard lit up. After googling the issue I found other 2020 Escape owners with the same problem. They all had to have the AWD MODULE replaced. Ford even recalled a select few 2020 Escapes for this issue, even though many more are having the same issue with not many miles on them. Called Ford to get in for a diagnostic and informed them what warnings were flashing. They confirmed it was the AWD MODULE causing the issue and replaced it. The cost was $835.14. Since AWD and traction control were disabled it made the vehicle dangerous to drive in slippery conditions. With the uphill assist disabled, that also made it more dangerous. The safety feature, Pre-collision assist, being disabled put my family and others in danger. Since replacing the Module all the warnings have stopped and everything seems to be back to normal. Ford is aware of this issue and is not taking responsibility for installing faulty AWD modules.

The driver's side door started making a strange squeaking noise a few months after I bought the vehicle. After about 3 months the door made a serious creaking noise and started to have issues closing. I inspected the door and found a hole in the metal where the weld spot is.

The contact owns a 2020 Ford Escape. The contact stated while reversing and depressing the brake pedal, there was a very loud screeching sound coming from the rear wheels. The vehicle was taken to the local dealer who replaced the brake pads and rotors, but the failure continued to occur. The vehicle was recently taken back to the dealer for the failure and the contact was informed that the rear brake pins needed to be replaced; however, the brake pins were on backorder. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 5.

The contact owns a 2020 Ford Escape. The contact stated while opening and closing the front driver's side door, there was an abnormal popping sound coming from the door as if the door hinge was fracturing. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the driver's side door needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The contact had researched online and related the failure to NHTSA Action Number: PE23013 (Structure). The failure mileage was approximately 26,000.

Door hinge on drivers side makes a popping sound and is hard to close Also drivers side window won’t roll down Took the car to dealership and they are checking with Ford to see if the car is covered under the warranty

Driver side door randomly started popping, hard to close completely, and driver side window struggling to roll up and down

Drivers front door started making popping noises. Called Ford dealer where car purchased and they said it just need hinges sprayed with WD40. I did and no change. Went to local mechanic and when I opened the door to show him it popped but then wouldn’t close. He said the welded holder for metal rod broke. Took off door panel to get it to close and now I have car with no door function, door opener, window opener, and door interior panel now in my back seat. Dealer won’t look at for 3 weeks.

The Spot Weld on the Driver side door is broke. based on information read this is an issue on this vehicle where the hinge breaks where the spot weld is suppose to hold. Has to be replaced and cost is $2400. Dealership said they have repaired a lot of these doors/Hinges. Asking to pay $2400 on an issue that Ford knows. They have a notice 50150 fro NHTSA that it is a known issue . Looking to help in reimbursing . per the site--- the spot welds' failure in the door's arm. In interviews with owners, NHTSA learned of 25 "minor injuries" and 1 report of "minor property damage." Some people have reported a popping noise when the door comes open and say that the door can be unable to latch when closed or can suddenly come open when it had been closed. According to the safety agency's investigation document, the problem is believed to be faulty spot welds in the check arm attachment points on the doors.As one example, an owner reported to NHTSA that "The driver side front door made a creaking sound, could not be opened, and the window would not go down. The internal weld to the door failed."

My driver side door starting making cracking sounds when opening and closing then would not close. Got the door to close finally and took to Ford. They said it was something to do with the welds on the door. They originally told me that I would have to pay to have it fixed. Because I purchased the extended warranty I was told it would be covered under that. They told me I would need a new door and that they were on backorder. 9 months later and multiple unreturned calls and I find out they never ordered my door. My door swings open as soon as it unlatches and window doesn't go down.

A few weeks ago, the drivers side front door of our 2020 Ford Escape began to make a popping sound upon opening and closing. The issue has now progressed to the door being nearly impossible to open, and the window will not go up and down. The issue seems to be related to what is described in the NTHSA bulletin SSM 50150.

The driver's side door makes a popping sound when you open and close the door. The car was not involved in any accident and the mechanic stated it was a door hinge weld issue

Drivers side drivers door popping when opened and closed, will not latch