2018 Ford Edge complaints

The contact owns a 2018 Ford Edge. The contact stated while driving on several occasions at speeds over 30 MPH, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the pressure sensor on one of the cylinders needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately 8 months later. The vehicle was taken to the same dealer where it was diagnosed that there was coolant leaking into the cylinders, and the engine needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 68,000.

In June of 2024 we had coolant getting into cylinder head. A new head gasket was installed and the car was ok until May of 2025 when we are faced with the same problem again. We have a 3rd party warranty program that made the repair last year but are refusing to this time. So we now a vehicle that is not drivable, is a safety risk if it is driven. Ford motor company has no assistance to offer at this time unless a recall is issued! The warranty company said since TSB’s are out that they will not cover this! If this is a Ford defect then it should be covered and repaired by them. There have been many recalls on this issue. Why not mine?

Coolant intrusion into the engine (eco boost) slow leak but failing emissions testing. engine misfires and runs hard. Only 80,000 miles on the car. Can be inspected, had it inspected by a local mechanic who confirmed the issue. No warning signs, never had a check engine light on prior to the issue. Mechanic says I need an entire long block replace. Now that I know of the warning signs, they have been ongoing for about 20,000 miles, but the only gone light just came on in April. Safety issues for this is that this can cause engine fires.

The contact called on behalf of her son, who owns a 2018 Ford Edge. The contact stated that while her son was driving on the highway at 60 MPH, there was white smoke coming from the rear end of the vehicle. The contact stated that the vehicle lost automotive power; however, there were no warning lights illuminated. The contact pulled over and had the vehicle towed to a local dealer, where the vehicle was diagnosed. The contact was informed that there was a coolant intrusion into the engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,234.

The contact owns a 2018 Ford Edge. The contact stated while driving at various speeds, the vehicle was driving rough, with the check engine warning light illuminated. The contact stated that the vehicle failed to properly accelerate. The vehicle was taken to the local mechanic who diagnosed that there was coolant inside the engine and informed the contact that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The local dealer was not contacted. The failure mileage was 100,000.

Engine long block needed replacing at 55,625 miles. Verified by Al Packer WPB , Fl., and engineer replaced. Ford paid $3300 for block while I was charged almost $3300 for labor (after discounting over $1000 from sales/service) Block design fault per Ford on TSB 22-2229. (All 2013-2015 Edge model with 2.0 Ecoboost engines need replacing.) The danger is overheating and engine seizing … could happen while driving and cause an accident. Check engine light was on. After learning about this, I checked for missing coolant, needed to top it off as it was almost empty. Then on a restart the smoke coming from tailpipe was quite obvious. (I have that on video). FORD should pay for 100% of this repair. I have had this vehicle 8years, and have 55,625 miles on 5year/60,000 warranty.

2nd time this has happened, coolant leaking into cylinder head. June of 2024 and now May2025. If this is a design flaw by Ford why hasn’t this been addressed? Vehicle has little over 90,000 miles.

The contact's son owns a 2018 Ford Edge. The contact stated that the check engine warning light was displayed on the instrument panel. Upon investigation, the contact's son discovered that the coolant level was extremely low. The vehicle was taken to an independent mechanic where mechanic discovered coolant intrusion into several engine cylinders. The contact's son was then informed that the engine needed to be replaced. The vehicle had also been taken to a dealer where a diagnostic test was performed; however, the contact was provided the same information as the independent mechanic. The manufacturer was also notified of the failure and the contact was referred to the dealer. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 68,000.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle was erratically shaking, and the check engine warning light was illuminated. The vehicle was driven to the shoulder of the roadway. The contact checked the coolant level, and the coolant lever was low. The coolant reservoir was refilled. The vehicle was driven to the dealer where it was diagnosed with a coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under warranty. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 59,000.

2018 Ford Edge 2.0 Ecoboost engine misfire in cylinder 2 (code P-0302 and Smoke from tailpipe. After replacing coil assembly and then spark plugs engine still runs rough. Looking in internet I discovered a Ford TSB 22-2229. Which clearly admits Ford knowledge of said “design flaw” which can cease the engine. Ford should be held liable and fix ALL vehicles effected. My car has 55,700 miles on it. Ford is covering engine block cost and charging me the labor costs in excess of $4,200..

The check engine light came on. Took the car for service. The mechanic did many diagnostic tests and discovered coolant leaking into the cylinder. Advised this caused engine failure and is unsafe. The engine must be replaced. The manufacturer is aware of this problem and the unsafe driving conditions it causes. They have issued a technical service bulletin but not a recall.

Check engine light displayed despite the fact that the car seemed to be running fine. I took the car to a repair shop and then to Ford Service who documented the diagnostic code P0302 Misfire4 on Cylinder #2. They did a pressure test. and found coolantintrusion on cylinder #2. The recommended repair was to replace the engine at a cost of $8700. My Ford EDGE has only 61,000 miles on it. I have found the following information on this car's engine indicating this was a known problem. I purchased this car < 2 yrs ago. Prior owner was not aware of any notification from Ford. The 2018 Ford Edge, particularly those with the 2.0 EcoBoost engine, are known for a design flaw that can cause coolant intrusion into the engine cylinders. This issue can lead to significant engine damage and potentially require a full engine replacement. Ford has addressed this with a recall and customer satisfaction program. Here's a more detailed explanation: Design Flaw: A design flaw in the 2.0 EcoBoost engine can cause coolant to leak into the engine's cylinders. Consequences: This coolant intrusion can lead to overheating, engine damage, and potentially requires a full engine replacement. Ford's Response: Ford has issued a recall (21N12 customer satisfaction program) and a TSB (Technical Service Bulletin) to address this issue, offering a one-time free fix. Symptoms: Signs of coolant intrusion can include low coolant levels, overheating, rough idle, white exhaust, and possibly a "milkshake" appearance

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle unexpectedly jerked with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that there were metal shavings inside the torque converter, which caused the transmission to fail. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 79,000.

My vehicle has 47K miles on it as the vehicle sat in the garage for 2 years ( 2019/2020) during COVID, it was never used. Recently as of Jan, Feb 2025, Slowly the car started to vibrate when starting the engine and the check engine came on. Every start in the morning or between trips, the engine would vibrate significantly , having the passengers inside (including kids) get worried about what is going on!. Also, an odd smell of burning in the exhaust , as though something other than fuel was being burnt. Took it to the dealership and they confirmed, an coolant intrusion. I checked online , to my surprise, I found everywhere that a lot of customers are having this coolant intrusion into the engine on the Ecoboost Engine and there has also been several class action lawsuit against this coolant intrusion into the engine. The Ford dealership mentioned , it would cost 10K to replace an engine and that is the only solution. With the powertrain warranty being within 60K miles, I am not qualified for the warranty as it is more than 5 years old as per Ford dealership. I am worried, that it could be very dangerous, as the engine could catch fire, if left untreated and I hope Ford acknowledge this known issue and not have their customers drive this faulty engine to end up into any disastrous issue with engine fires!!.

The contact owns a 2018 Ford Edge. The contact stated while driving 5 MPH in a parking lot, the check engine warning light illuminated. The contact stated that the engine went into LIMP Mode. The contact pulled over and turned off the vehicle. The contact restarted the vehicle after several minutes. The vehicle was taken to Pep Boys, where it was diagnosed that the spark plugs, and ignition coils had failed and needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken back to Pep Boys and was diagnosed with coolant intrusion into the cylinder, causing a misfire in cylinder #3 and engine failure. The vehicle was not repaired. Upon further investigation, the contact related the failure to Ford Campaign Number: 22-229. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 96,000.

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the vehicle was idling roughly. The contact stated that once the engine had warmed up, the vehicle ran smoothly; however, while the accelerator pedal was depressed, the vehicle hesitated. The contact stated that the vehicle was lunging forward while the accelerator pedal was depressed. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that there was coolant intrusion into the engine block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was approximately 72,000.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the heater was activated but failed to operate as needed. The message "Engine Coolant Overtemperature" was displayed. The contact added coolant to the coolant reservoir, but the failure persisted. The vehicle was taken to the dealer, who diagnosed that there was coolant intrusion in cylinder #3 and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 73,000.

The contact owns a 2018 Ford Edge. The contact stated while driving 55 MPH, the vehicle failed to respond as needed. The check engine warning light was illuminated. The contact stated that coolant was leaking into the cylinder and head gasket. The contact was informed that the engine needed to be replaced. The vehicle was then taken to a dealer and was diagnosed with engine failure. The vehicle was then taken to an independent mechanic to be diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was only able to be driven for short distances. The vehicle was driven to the dealer and the independent mechanic who were nearby. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 70,000.

The car felt hard idling after putting gas in it or it hesitates to start. The engine light came on after.

There is a coolant intrusion in cylinders 1 and 2.

The contact owns a 2018 Ford Edge. The contact stated while attempting to start the vehicle, the contact heard an abnormal sound coming from the engine. The contact smelled a sweet smell and became aware of white smoke coming from the exhaust. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and several codes were displayed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related to the failure of Technical Service Bulletin: 19-2172 (Coolant in Cylinders, White Exhaust Smoke). The manufacturer was notified of the failure but offered no assistance. The manufacturer transferred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 109,000.

The contact owns a 2018 Ford Edge. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. Additionally, a slushing noise was present coming from inside the driver’s side dashboard location. The vehicle was taken to the local dealer, who diagnosed that coolant was present inside the engine cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 90,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving approximately 65 MPH, the blinking check engine warning light activated along with the message "Engine Coolant Temperature High". The contact stated that after parking the vehicle, the vehicle was towed to the local mechanic and was later towed to the local dealer, who diagnosed the vehicle and determined that the coolant had mixed with the engine oil, causing severe damages to the engine. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed that the vehicle was not covered under the Extended Warranty coverage for the failure. The failure mileage was 81,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at approximately 35 MPH, the check engine warning light illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The contact contacted an independent mechanic and was informed that, based on the symptoms, the vehicle might have a blown head gasket. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 87,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving on several occasions at various speeds, the check engine warning light intermittently illuminated. The contact stated that on one occasion the warning light illuminated and remained illuminated. Additionally, the contact stated that on several occasions, the temperature gauge warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that there was a crack in the engine block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 125,000.

Check engine light came on. Took to the Ford dealer workshop, they checked and found nothing wrong with the engine. Check engine light came on again and this time the car jerks when it tries to accelerate. Could not go more 40mh due to the jerky motion. Took it back to the shop, they said coolant intrusion. They said it is going to need new engine because there is water/coolant intrusion. New engine estimate approximately $9000. Same dealership that we have been going to for maintenance, not sure why they did not see this from previous visits. I have seen complaints for same issue on this 2018 Edge, Ford needs to acknowledge that this is an issue.

The contact owns a 2018 Ford Edge. The contact stated while driving at 20 MPH, the service engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed with a flaw in the engine design. The contact stated that coolant was leaking into the engine, causing engine failure. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall. The vehicle was taken to an independent mechanic who provided the same diagnosis. The manufacturer was not made aware of the failure. The failure mileage was approximately 98,500.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the spark plugs had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into cylinder #4, causing the engine to fail. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The contact was referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 146,000.

At approximately 80K miles started to smell the odor of burning antifreeze. Was told new engine was needed due to water intrusion into engine. $5,000 later and a new engine, Ford would not acknowledge that this is a known ongoing problem with the Ecoboost engine.

Warning lamp went on. Took immediately to Ford, with only 28K miles on my 6-year-old vehicle. They diagnosed a coolant intrusion. Was told this is a "known problem" with the Ford Edge 2.0L Ecoboost engine, due to a "manufacturing defect". Had to do a "Long Block" replacement, costing me thousands of dollars.

The contact owns a 2018 Ford Edge. The contact stated that after refueling the vehicle, while attempting to start the vehicle, the vehicle stalled three times after starting. The contact stated that the failure occurred daily. The contact stated that the battery charging warning light was illuminated. The dealer was contacted. The vehicle was taken to Auto Zone to be diagnosed. The contact was informed that the canister purge valve needed to be replaced. The vehicle was then taken to the dealer and the contact was informed that the part to repair the vehicle was unavailable. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V735000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 31,200.

The contact owns a 2018 Ford Edge. The contact stated while driving at approximately 50 MPH, the check engine warning light illuminated. The contact attempted to activate the heater however, only cold air was blowing out of the vents. The vehicle was taken to a local dealer who diagnosed that there was coolant intrusion into the engine block. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 98,000.

Driving to work & the vehicle started to behave like it was running out of gas, kind of a jerky motion. I was able to get an appointment @ the local dealership, they diagnosed it as having a cracked block by cylinder #3 causing coolant to enter the cylinder. This vehicle just turned 80k miles and was service for the same thing 6 months prior, same cylinder. There was no mention of a common problem with Ecoboost design flaws until the Service Advisor shared the info with me. A new engine had to be replaced @ a cost of almost $8000. A 2018 vehicle with a perfect maintenance record and only 80k miles should be needing a total engine replacement. Ford should back their products. I essentially bought a used Edge according to Blue Book and in reality bought my car twice.

The contact owns a 2018 Ford Edge. The contact stated that while the vehicle was parked, the vehicle was started, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 105,000.

The contact owns a 2018 Ford Edge. The contact stated that while having a routine inspection at the local dealer, the vehicle was diagnosed, and it was determined that there was an oil leak to the oil pan gasket that needed to be replaced. There were no warning lights illuminated. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 48,000.

Coolant intrusion into cylinder 1 due to failure noted in TSB 19-2346

Coolant entering the cylinder Wouldn't allow us to drive car home Convinced us to purchase a new vehicle.

The issue is Coolant intrusion in the #2 cylinder. Rough idle when starting and white smoke. Ford bulletin 22-2229 The issue was confirmed by the dealer Capital Ford of Wilmington Dec of 2024. Yes, the problem stated prior to engine light coming on. It starting getting worse.

Car went into limp mode and over temp light came on. Coolant reservoir empty. Research led to TSB 19-2346. Prior to this CEL was coming on and off and throwing code P0301 errors. Replaced plugs and coil packs at the suggestion of the dealer but made no difference. Started out with rough idle but smoothed out after about 30 seconds. Dealer diagnosed issue and quoted $6,900.00 plus tax to install new long block. Ford finally agreed to cover part of the repair costs but still left me with a $3,000 bill. Car is now repaired but I'm hoping to recoup some of my expenses now.

Fly wheel and flex plate broke causing the car to lose power. The car then stopped having use of the transmission so was unable to move the car.

See attached document for complaint.

A manufacturing defect has caused coolant to leak into the engine which can lead to an engine fire. Many other people with he same engine have reported the same issue.

Vehicle began to rough idle, and then while driving the vehicle MIL came on, as well as a "Engine overheat throttle limited" error. Pulled over and vehicle would not move. Tried to power cycle the vehicle and would not start back up. Had it towed to dealer and was told this was the long block coolant intrusion problem that leader to my engine completely failing. I was made aware of Ford TSB 19-2346, and told the repairs would be $9200. After googling around, this is a common problem on these 2018 ford ecoboost engines and Ford obviously knows there is a problem that could cause accidents or engine fires. Luckily my kids were not in the car, otherwise this could have been catastrophic due to the loss of power while driving. I called Ford support and they told me that Ford has no programs to help affected customers. There should be a Recall and Ford should be forced to replace or repair affected engines as this will get someone killed if they lose power or have an engine fire while driving.

Coolant leaking into engine cylinders. Had an independent service center state we need a new engine. The labor cost to replace the gasket would add up to the cost of a new engine. Told us Ford had corrected the engineering problem that caused the leak. Said it was common problem with the Ford Edge vehicle.

The contact owns a 2018 Ford Edge. The contact stated that while driving on the highway at 50 MPH, the vehicle lost automotive power, and decelerated to 30 MPH. The contact stated that the check engine warning light illuminated, with the “Low Coolant” message displayed. The contact restarted the vehicle and continued driving. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that coolant intrusion into the engine had caused engine damages and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 95,000.

We have had 2 seatbelts in this vehicle fail. The drivers seat belt would not pull out all of the way and was replaced under warranty. The rear left (drivers side) seatbelt has now failed in a similar way. The belt is stuck retracted and will not pull out. The part is back ordered with no estimate of availability. I have never had a seatbelt fail and to have 2 fail on the same vehicle raises concerns.

I bought the car and 2 days later the check engine light came on so I took it to Wendle Ford Town in Spokane Washington and I was told that the Engine was leaking antifreeze into the cylinders so I became concerned that if it was doing that then it could cause the Engine to overheat or stop unexpectedly because of overheating and cause an accident

The contact owns a 2018 Ford Edge. The contact stated that the check engine light had illuminated upon starting the vehicle. The vehicle was taken to a local dealer where the vehicle was diagnosed. The contact was advised that the coolant intrusion was responsible for the failure and that the engine would need to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 102,000.

Car has a defect that causes coolant to leak into the engine’s cylinders, which can caused corrosion, oil dilution and contamination, and engine failure. Ford failed to disclose these defects and created a safety risk, because the lack of coolant created by the leaks caused overheating and resulted in total engine failure. Car is available for inspection. Mechanic has confirmed car needs a new engine. See attached. Car has not been inspected by any others. ' The car has multiple error codes indicating failure.

The contact owns a 2018 Ford Edge. The contact stated that while his wife was driving approximately 40 MPH, the check engine warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that there was coolant leaking into the engine and the cylinder was cracked. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was contacted and confirmed there was no recall on the VIN for the failure. The manufacturer offered to assist with the cost of the repair. The failure mileage was approximately 33,000.