2009 Dodge Grand Caravan complaints

VALVE SYSTEM FAILURE: WHILE TRAVELING 2000 MILES FROM HOME, THE LOW TIRE PRESSURE DASHBOARD WARNING LIGHT CAME ON. WE CHECKED ALL TIRE PRESSURE AND FILLED ONE LOW TIRE, BUT LIGHT CAME BACK ON. WE TOOK IT TO MECHANIC WHO NOTED THAT THE VALVE STEM WAS CORRODED AND CRACKED, AND COULD HAVE COME DISLODGED AT ANY MOMENT, CAUSING A BLOWOUT. REPLACED TPMS SENSOR AT A COST OF $153. *TT

WARPED FRONT BRAKE ROTORS: RECEIVED A NOTICE FROM CHRYSLER OF EXTENDED WARRANTY ON BRAKES BECAUSE PADS AND ROTORS MIGHT NEED REPLACEMENT "EARLIER THAN EXPECTED". TOOK IT TO THE DEALER 1/28/11 AT 35,300 MILES AND THEY SAID THERE WAS NO PROBLEM. AT 44,000 MILES NOTICED FAINT SQUEAL. TOOK IT TO INDEPENDENT MECHANIC WHO FOUND THAT FRONT BRAKE ROTORS WERE SEVERELY WARPED AND NEEDED TO BE REPLACED. MECHANIC SAID THERE WAS WAS NO NEED TO REPLACE PADS, WHICH WERE FINE, AND THAT THIS WAS UNUSUAL BECAUSE THEY USUALLY WEAR AT THE SAME TIME. (NOTE THAT HIGH MILEAGE COMES FROM CROSS-COUNTRY TRIPS IN THE INTERSTATE, WITHOUT HEAVEY USE OF BRAKES). *TT

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH HE APPLIED THE BRAKES AND THE BRAKE PEDAL BEGAN TO PULSATE. THE STEERING WHEEL ALSO BEGAN TO SHAKE DURING THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT BOTH FRONT ROTORS WERE WARPED. THE ROTORS WERE REPLACED. APPROXIMATELY EIGHT MONTHS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ANOTHER AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE BRAKES EXHIBITED AN ACCEPTABLE AMOUNT OF RUST BUT DID NOT NEED TO BE REPAIRED. APPROXIMATELY FOUR MONTHS LATER THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE CONTACT WAS ADVISED TO REPLACE THE REAR ROTORS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 9,800 AND THE CURRENT MILEAGE WAS 23,000.

2009 DODGE GRAND CARAVAN VALVE STEM FAILURE. IN NOV WE WENT OUT FOR THANKSGIVING SUPPER COME OUT AND FOUND FRONT LEFT TIRE FLAT, VALVE STEM WAS BROKEN OFF AND COULD NOT FIND CAP OR VALVE. VAN HAD ABOUT 38,000 ON IT. THIS SUNDAY PULLED BACK INTO DRIVE AND IN MATTER OF SECONDS REAR RIGHT WENT FLAT. FOUND SAME PROBLEM. WENT OVER TO CHECK LEFT REAR AND FOUND CRACK IN STEM WITHIN 1/32" BELOW CAP, I CALLED FOR NEW STEMS DEALER IS OUT OF STOCK SO THE VAN MUST SIT. I WILL HAVE TO PUT RUBBER STEMS IN AND DEAL WITH THE LIGHT SO I CAN USE THE VAN. NOW WHAT WOULD HAPPEN IF MY WIFE OR MYSELF WITH KIDS AND GRANDKIDS ARE ON A TRIP BUSY ROADS,LOTS OF TRAFFIC AND THIS WOULD HAPPEN. WHEN THESE BLOW TIRES ARE FLAT IN SECONDS. ITS MAKES ME AFRAID TO DRIVE NOING THIS COULD HAPPEN. $74.25 EACH PER STEM NOT INCLUDING LABOR. THIS IS NOT FAIR OR SHOULD NOT BE ALOAD ON VEHICLES. THANKS FOR YOUR TIME. THE VAN NOW HAS 40,449. *TT

VERY NOTICEABLE BRAKE PULSATION,ALL FOUR BRAKE ROTORS AND PADS REPLACED DUE TO THEIR BEING PITTED,RUSTED AND DOWN TO METAL ON METAL. SINCE OFF WARRANTY ASKED FOR GOODWILL FROM DODGE DEALER AND REPAIR DONE FOR $100. ONCE AGAIN ON 08/02/2010 THE FRONT ROTORS WERE FOUND TO BE BAD BY DEALER AND REPLACED BY DEALER UNDER WARRANTY. NOW, AS OF 07/07/2011 LEFT REAR BRAKE APPEARS TO BE STUCK IN A LOCKED ON POSITION, BRAKE IS OVERHEATING,SQUEALING AND POOR GAS MILEAGE AND CAUSING DAMAGE TO ROTOR, PAD AND CALIPER PER LOCAL MECHANIC. THIS FAILURE IS A REAL DANGER TO SOMEONE WHO DOESN'T NOTICE THE CONDITION AS IT MAY CAUSE A FIRE DUE TO EXCESSIVE HEAT, PREMATURE TIRE WEAR, LOSS OF BRAKING DUE TO FADE AND BOILING OF BRAKE FLUID. THIS CONDITION ALSO CAUSES OTHER BRAKES TO WORK HARDER CAUSING THEIR PREMATURE WEAR.

2009 DODGE GRAND CARAVAN 70,000 MILES HAVING PROBLEMS WITH DRAGGING REAR BRAKES AND SHORT (UNDER 20,000) MILES FOR TOP OF LINE BRAKE PADS STILL HAVEN'T FOUND A FIX FOR THIS. *TR

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED HE HEARD A WHINING NOISE COMING FROM THE FRONT WHEELS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FRONT WHEEL BEARINGS WERE REPLACED. THE FAILURE MILEAGE WAS 42,400. . UPDATED 10/14/11 *BF. THE CONSUMER STATED HE BELIEVED THE BEARING FAILURE WAS DUE TO EXCESSIVE HEAT BUILD-UP FROM THE FRONT DISC BRAKES. UPDATED 11/07/11

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO HAVE THE BRAKES REPAIRED UNDER WARRANTY. WHILE HAVING THE VEHICLE REPAIRED, THE CONTACT WAS INFORMED THAT THE REAR ROTORS WERE WARPED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED CONCERN OVER THE ROTORS WARPING ON A LOW MILEAGE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 23,673. UPDATED 09/09/11*LJ THE REAR ROTORS WERE TURNED, BUT NOT REPLACED. UPDATED 10/31/11

2009 CARAVAN REAR CALIPER GRINDING AND RIM SO HOT YOU CAN'T TOUCH IT . SECOND TIME IN 5 MONTHS THIS HAS HAPPENED . CANT DRIVE THE VEHICLE WHEEL DOESN'T WANT TO ROTATE BECAUSE CALIPER IS LOCKED UNDER PRESSURE. *TR

TL*THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE CONTACT STATED THAT SHE HAD TO REPLACE THREE VALVE STEMS WITHIN THE LAST YEAR. THE DEALER REPLACED THE SENSOR, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 91,000.

TL*THE CONTACT OWNS 2009 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE ATTEMPTING TO APPLY THE BRAKES THEY PULSATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST THAT DETERMINED THE FAILURE WAS LOCATED IN THE REAR AND FRONT BRAKE ROTORS AND PADS. THE DEALER REPLACED THE REAR AND FRONT BRAKE PADS AND ROTORS. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE IS 27,000. UPDATED 07/28/11*LJ UPDATED 08/01/11

2009 DODGE CARAVAN MODIFIED BY THE BRAUN CORPORATION TO INCLUDE A MANUAL RAMP FOR WHEELCHAIR PASSENGERS WAS TRAVELING ON A 2 LANE ICY BRIDGE AND WAS UNABLE TO STOP FOR A 1997 CHEVY TRUCK THAT HAD ALREADY SLID OUT ON THE BRIDGE AND WAS LEFT SITTING ACROSS BOTH LANES. THE DODGE CARAVAN HIT THE VEHICLE HEAD ON WITH SUCH FORCE THAT THE DRIVER HAD THE PARTS FROM AN ARTIFICIAL HIP COME OUT. WHEN LOOKING AT THE VEHICLE THE AIRBAGS DIDN'T DEPLOY BUT THE FRONT END IS SERIOUSLY DAMAGED AND THE VEHICLE IS A TOTAL LOSS. *TR ..UPDATED 04/26/12 *BF. UPDATED 06/27/12 *BF CAR FAX REPORT RECEIVED. UPDATED 06/27/12

2009 DODGE GRAND CARAVAN. ALL 4 TIRE VALVES ARE CORRODING. ONE BROKE OFF AND FELL INSIDE TIRE. OTHER BROKE OFF WHEN TRYING TO UNSCREW OF CAP. BOTH PASSENGER TIRES WENT FLAT. *TR

DRIVER'S FRONT TIRE PRESSURE SENSOR NUT CORRODED AND BROKE OFF CAUSING AN IMMEDIATE FLAT TIRE. THE ALMOST NEW TIRE (LESS THAN 25,000KM) WAS ALSO DESTROYED IN THE PROCESS OF BRING THE VEHICLE TO A SAFE STOP. HAD TO PURCHASE A NEW SENSOR AS WELL AS A NEW TIRE. $361.35 LATER OUT OF MY POCKET FOR A DEFECT THAT I AM TOLD IS NOT RESTRICTED TO DODGE VEHICLES BUT WITH ALL TIRE PRESSURE SENSORS IN GENERAL. THE DEFECT HAVING TO DO WITH THE METAL COMPONENTS BEING USED. IF THE COMPONENTS WERE RUBBER AS REGULAR VALVE STEMS ARE OR EVEN RUBBER COATED SUCH FAILURES WOULD BE GREATLY REDUCED. WOULD LIKE FOR DODGE TO PAY MY BILL BUT UNLIKELY..... MILEAGE AND SPEED ARE CANADIAN AND IN KM AND KM/H. *TR

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE CONTACT STATED THAT TWO OF THE VALVE STEMS DETERIORATED AND CAUSED THE CAP TO FRACTURE FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR STATION WHERE THE FIRST VALVE STEM WAS REPLACED FEBRUARY 2011. THE SECOND FAILURE OCCURRED ON APRIL 2011 AND THE SECOND VALVE STEM WAS REPAIRED AT THE SAME REPAIR STATION. THE CONTACT CALLED AN AUTHORIZED DEALER WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 49,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 47,000. UPDATED 06/17/11 *BF THE CONSUMER STATED THE VALVE STEMS WERE CORRODED. UPDATED 08/04/11

2009 GRAND CARAVAN. WAS WASHING THE WHEELS, AROUND THE VALVE STEM AREA, WHEN THE VALVE SNAPPED OFF AT THE BASE OF THE VALVE CAP, RELEASING ALL THE AIR IN THE TIRE WITHIN 10 SECONDS. HAD THIS BEEN A PART FAILURE DURING A HIGH SPEED DRIVE IN HEAVY TRAFFIC, IT WOULD HAVE BEEN CATASTROPHIC. THERE SHOULD BE A SAFETY ALERT REGARDING THIS DEFECT AND AN IMMEDIATE RECALL. I REFUSED TO PAY A $150.00 TIRE REPAIR , SO I OPTED OUT WITH REMOVING THE EXISTING PRESSURE MONITORING SYSTEM, AND HAD A GOOD OLD RUBBER VALVE STEM PUT IN, AND THE TIRE REBALANCED. IF A RECALL IS NOT IMPLEMENTED SOON, I PLAN ON HAVING ALL THE VALVE STEMS REPLACED, AND WITH ALL THE OTHER PROBLEMS I'VE HAD WITH THIS VEHICLE, I WOULD NEVER AGAIN BY A DODGE. *TR

2 TPMS VALVE STEMS ON MY 2009 DODGE CARAVAN BROKE OFF IN THE MECHANICS HAND WHILE UNSCREWING THE VALVE STEM CAP AS HE WAS CHECKING TIRE PRESSURE. THIS OCCURRED AT THE DODGE DEALER WHERE I PURCHASED THE VEHICLE. THIS IS 3 OUT OF 4 VALVE STEMS ON THIS VAN THAT HAVE BROKEN. FIRST WAS ON 10/20/10, OTHER TWO TODAY (3/8/11). METALIC STEMS NOT MADE TO STAND UP TO NORMAL ROAD CONDITIONS. PARTS AND LABOR IS $152 EACH TIRE, JUST FOR THE VALVE STEMS! *TR

2009 DODGE GRAND CARAVAN REAR BRAKES FAILURE AT 30,937 MILES.. AN EXTENDED WARRANTY WAS ISSUED FOR FRONT BRAKES, BUT PROBLEM WITH REAR BRAKES HAVE BEEN IGNORED. MY REAR BRAKES REQUIRED REPLACEMENT AT 30, 700 MILES THE FRONT BRAKES STILL HAVE OVER HALF THE LIFE REMAINING.. CHRYSLER SHOULD BE FORCED TO ISSUE A RECALL. *TR

BOUGHT VEHICLE ON 12-14-2010(USED FROM A CAR DEALER) VEHICLE WAS SUPPOSE TO HAVE BEEN INSPECTED(72 POINT CHECK) THIS VAN HAD 34,916 MILES ON IT. DEALER DID RECALLS AND WARRANTY WORK. WE COMPLAINED ABOUT THE TIRE "LIGHT" GOING ON & OFF. WAS ADVISED THAT NOTHING WAS WRONG WITH THE MONITOR, THAT THE TIRES JUST NEEDED A LITTLE AIR FOR THE HIGHER ALTITUDE. THEY OVER FILLED TIRES. TIRE LIGHT CAME ON AGAIN. THIS TIME WE WERE ADVISE, BY A TIRE DEALER, THAT THE VALVES(MONITORS) WERE CRACKED & LEAKING AIR. ALSO THE ENGINE LIGHT CAME ON AND STAYED ON UNTIL WE GOT TO THE DEALER, HE SAID TO TURN OFF THE MOTOR AND RESTART THE ENGINE. THIS TIME IT WENT OFF. AFTER READING THE COMPLAINTS ABOUT ENGINE LIGHTS, WE ARE SCARED THAT THE DEALERS ARE AGAIN LYING TO US. WE DO NOT WANT TO END UP WITH THE VEHICLE JUST STOPPING ON US ON THE HIGHWAY, INFRONT OF AN 18 WHEELER! THIS ENGINE LIGHT PROBLEM HAS OCCURRED TO OTHERS AND THEIR TRANSMISSION JUST QUIT. WE BELIEVE THAT THESE DEALERS, ARE IN DENIAL. WHY DID THE DEALER TELL MY HUSBAND JUST TO TURN OFF THE VEHICLE WITHOUT USING A CODE TO FIND OUT WHAT THE PROBLEM IS? WE HAVE HAD THE VEHICLE IN 2 TIMES ABOUT THE 'LOW TIRE" LIGHT & EACH TIME THEY JUST BLEW IT OFF AS NEEDING AIR! IT WAS AN INDEPENDENT TIRE PERSON WHO ACTUALLY EXAMINED THE TIRE TO FIND THE CRACKED VALVE-HE DID NOT HAVE ANY THING TO GAIN, AS THE VALVE STEM WAS RETURNED AGAIN TO THE DEALER. WHEN WE LOOKED BACK AT THE REPAIR TICKETS (2) WE NOTICED THAT OUR REPORTING OF THE TIRE LIGHT BEING ON W

I BOUGHT MY 2009 VAN IN OCT. IN DEC. I HAD TO HAVE BOTH VALVE STEMS REPLACED BECAUSE THEY WERE LEAKING AIR, I HAVE SINCE THEN READ ONLINE ABOUT OTHERS HAVING PROBLEMS WITH THIS ISSUE WITH THE TIRE SENSORS. YESTERDAY I WENT TO TAKE THE CAP OFF MY FRONT TIRE WHICH HAD NOT BEEN CHANGED TO REGULAR VALVE STEMS AND THE WHOLE STEM CAME OFF IN MY HAND AND BOOM FLAT TIRE. THANK GOD I WAS NOT DRIVING WHEN IT WENT AND HAD MY CHILDREN OR SOMEONE ELSE'S CHILD WITH ME. I CANNOT BELIEVE THAT A DESIGN FLAW LIKE THAT WOULD BE NOT BE RECALLED BY NOW. JUST TRYING TO TAKE THE CAP OFF AND BOOM IT'S IN MY HAND. STILL CANNOT BELIEVE IT. *TR

ON 1/18/20010 I EXPERIENCED UNCONTROLLED ACCELERATION OF MY 2009 DODGE GRAND CARAVAN. THE VEHICLE WAS SERVICED AT GALEANA DODGET, FT. MYERS FL ON 1/24. I WAS TOLD THAT FUEL INDUCTION PARTS NEEDED CLEANING AND THAT WOULD RESOLVE THE PROBLEM. ON 1/24 AFTER ONLY 377 MILES SINCE SERVICE I EXPERIENCED THE PROBLEM AGAIN. I WAS IN THE MIDDLE LANE OF A 3 LANE HIGHWAY DRIVING ABOUT 45 MPH. WHEN I BEGAN MOVING TO THE FAR LEFT LANE AND BRING THE VEHICLE UP TO THE POSTED SPEED OF 50 MPH I NOTICED THE GAS PEDAL DEPRESS BEYOND MY INTENTION. I ATTEMPTED TO STOP ACCELERATION BY APPLYING THE BRAKES TO NO EFFECT. IT SLOWED THE RATE OF ACCELERATION WHICH RESUMED AS SOON AS I RELEASED THE BRAKE. AS THE HIGHWAY BUSY I HAD A HARD TIME CONTROLLING THE CAR AND PULLING BACK TO THE RIGHT LANE SO I COULD SAFELY STOP THE CAR ON THE SHOULDER WHEN I TURNED THE IGNITION OFF. WHEN I RESTARTED THE CAR THE ENGINE CONTINUED TO RACE AT OVER 4,000 RPMS. EVENTUALLY AFTER SEVERAL TIMES STARTING AND STOPPING THE IGNITION THE ENGINE RETURNED TO APPROPRIATE IDLE SPEED. AS WE WERE IN A DANGEROUS PLACE AND CLOSE TO THE PLACE WE WERE STAYING (ON VACATION) AND DID NOT KNOW WHO TO CALL I DROVE THE CAR PACK AND PARKED IT WAITING INSTRUCTIONS FROM DODGE ON HOW TO PROCEED. AT THIS TIME I AM AFRAID TO DRIVE THE CAR AS WE HAD A VERY HARROWING EXPERIENCE. PROBLEM PREVIOUSLY REPORTED AT A GASOLINE FUEL SYSTEM PROBLEM AS THAT IS THE WAY THE REPAIR SHOP DESCRIBED IT. *TR

BRAKES WOULD SQUEAL AND SCREECH WHILE DRIVING AND WOULD STOP WHEN THE BRAKES WERE APPLIED. THE FRONT ROTOR WAS RED HOT AND SMOKING. I LATER HAD THE SAME PROBLEM WITH THE REAR BRAKES AND THEY HAD TO REPLACE THE ROTORS PADS AND CALIPERS. THIS APPEARED AGAIN AFTER 15,000 MILES AND THEY SAID IT WAS NORMAL AND WANTED TO CHARGE ME FOR REPAIR.

I RECENTLY EXPERIENCED AN UNCONTROLLED ACCELERATION OF MY 2009 DODGE GRAND CARAVAN. I PASSED A TRUCK THAT WAS TRAVELING AT ABOUT 35 MPH. WHEN I ATTEMPTED TO RESUME AN APPROPRIATE SPEED BY RELEASING THE ACCELERATOR I REALIZED THAT THE VEHICLE WAS CONTINUING TO ACCELERATE. I APPLIED THE BRAKE TO LITTLE EFFECT AND EVENTUALLY REGAINED CONTROL OF THE VEHICLE BY SHUTTING THE IGNITION OFF. WHEN I BROUGHT THE VEHICLE TO A DODGE DEALER I WAS TOLD THAT THIS WAS COMMON AND ALL IT REQUIRED WAS ROUTINE MAINTANCE. DODGE DID NOT SEE THIS AS A SAFETY ISSUE AND CHARGED ME FOR THE SERVICE DESPITE THE FACT THAT THE VEHICLE WAS STILL UNDER WARRANTY. *LN

WHEN MOVING THE CVT TRANSMISSION, DASH MOUNTED GEAR SHIFT LEVER FROM REVERSE TO DRIVE THE GEAR SHIFT LEVER ASSEMBLY FELL APART. THE HANDLE FELL TO THE FLOOR, AS DID THE BUTTON AND THE INTERNAL SPRING. THIS OCCURRED TODAY 8/12/2010 FOR THE FIRST AND ONLY TIME (SO FAR). I MANAGED TO RE-ASSEMBLE THE SPRING, BUTTON AND LEVER UPHOLSTERED GRIP ONTO THE LEVER ITSELF BUT I HAVE NO IDEA WHAT IS SUPPOSED TO KEEP IT IN PLACE. I FOUND NO SCREW ON THE FLOOR OF THE VEHICLE. IT WILL REQUIRE SERVICING TO REPAIR AT A DEALERSHIP. IN THE MEANWHILE I GUESS I WILL HAVE TO JUST USE THE LEVER ITSELF BUT I HAVE CONCERNS ABOUT THAT BECAUSE I NOW HAVE A POINTED PIECE OF METAL STICKING OUT OF MY DASH. I HAVE NOT DRIVEN THE VEHICLE SINCE THE INCIDENT. *TR

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE CONTACT OBSERVED THAT THE FRONT DRIVER SIDE TIRE PRESSURE SENSOR GAUGE WAS DEFECTIVE CAUSING AN EXCESSIVE AMOUNT OF AIR PRESSURE LOSS IN THE TIRE. THE DEALER WAS NOTIFIED OF THE FAILURE AND THEY INFORMED THE CONTACT THAT THE PART NEEDED FOR REPAIRS WAS ON BACKORDER FOR A PERIOD OF TWO TO THREE MONTHS. THE CONTACT HAD EXPRESSED CONCERN OF THE SAFETY RISK INVOLVED IN THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 14,800.

TIRE VALVE STEM BROKE WHEN PUTTING AIR IN THE TIRE CAUSING IMMEDIATE DEFLATION OF TIRE. *TR

2009 DODGE GRAND CARAVAN - TPMS- TIRE PRESURE MONITORING SENSOR - VALVE STEM. *TR

THE EVENTS LEADING UP TO THE FAILURE = WHILE VEHICLE IN MOTION ENGINE LOST COMPLETE POWER AND DIED ON STREET---THE FAILURE HOW OFTEN IT OCCURS = ONE TIME--- ITS CONSEQUENCES = TOWED TO DEALER FOR REPAIRS---ADDITIONAL PROBLEMS WITH THE VEHICLE = 1-WHILE DODGE CARAVAN WAS IN MOTION'ON THE STREET'DODGE CARAVAN ENGINE POWER WAS TOTALLY LOST'DODGE CARAVAN CAME TO A STOP WHILE HOLDING THE BRAKE PEDAL DOWN VERY HARD! 2-TRANSMISSION SHIFT LEVER STUCK IN PARK WITH ENGINE RUNNING - I COULD NOT MOVE GEARSHIFT LEVER TO DRIVE- I HAD TO TURN OFF IGNITION AND START ENGINE AGAIN. 3-INTERMITTENT ELECTRICAL OPERATION OF LEFT AND RIGHT SLIDING DOORS TO OPEN OR CLOSE. 4-INTERMITTENT TRANSMISSION JUMPS AND A CLUNK NOISE AT APPROXIMATELY 21 MILES PER HOUR SPEED. *(ON 04-06-2010 VEHICLE BOUGHT IN FOR SAME PROBLEM). 5-SECURITY SYSTEM HEAD AND TAILLIGHTS DO-NOT FLASH WHEN CAR IS ARMED OR UNARMED. 6-INTERMITTENT LOW TIRE PRESSURE LIGHT SYMBOL INTERMITTENTLY GOES ON/OFF OR STAYS ON . 7-ENGINE IDLES HIGH. 8-VERY LOW GAS MILEAGE. APPROXIMATELY 12 MILES CITY AND 14 MILES HIGHWAY PER 18 GALLON TANK = APPROXIMATELY 240 MILES PER TANK-----VEHICLE ID [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2009 DODGE GRAND CARAVAN FRONT WHEEL BEARING FAILURE. DEALER TOLD ME THEY WOULD NOTIFY ME WHEN THE NEW BEARINGS ARRIVE. THEY ARE ON A NATIONAL BACK ORDER BECAUSE OF ALL THE REPORTED FAILURES. *TR

2009 DODGE GRAND CARAVAN BEGAN SHAKING AS I WOULD BRAKE FROM SPEEDS ANYWHERE FROM 40-100 MILES PER HOUR (I LIVE IN GERMANY). AT 15,000 MILES WE TOOK THE CAR TO THE DEALERSHIP AND THEY DETERMINED THAT THE FRONT ROTORS ARE WARPED. THE ODD THING IS THAT THE ROTORS WENT OUT BEFORE THE BRAKES DID. THE DEALER SAID DUE TO A DESIGN FLAW IN THE GRAND CARAVAN, THE FRONT RETAINS A LOT OF HEAT AND WILL WARP THE ROTORS ON A REGULAR BASIS. WE WERE TOLD TO EXPECT THIS REPAIR EVERY 15,000 MILES OR SO. *TR

ON 6/27/2010 MY FAMILY AND MYSELF WERE TRAVELING TO HACKENSACK MN ON HWY 371 AND WHEN I ATTEMPTED TO PASS A SLOW MOVING VEHICLE MY MINI VAN KEPT INCREASING IN SPEED. NO INJURIES HAPPENED I CALMLY GOT IT TO STOP BUT I HAD TO PULL OFF TO THE SIDE OF THE ROAD AND SHUT OFF THE ENGINE. THE CRUISE WAS ON BUT NOT ACTIVATED. I TRIED TO HIT THE CANCEL SWITCH HIT THE ON OFF SWITCH ALL THE TIME PUSHING THE BRAKE PEDAL. THE SKID PROTECTION LIGHT AND BRAKE LIGHT CAME ON AND THE BRAKES HEATED UP REALLY BAD BUT I WAS ABLE TO STOP. THE ENGINE WOULD NOT STOP RACING AND THE LIGHTS WOULD NOT GO OUT UNTIL I SHUT DOWN THE ENGINE ON THE SIDE OF THE ROAD. WE THEN CONTINUED OUR TRIP WITH NO MORE INCIDENTS AND I DID TRY TO GET IT TO HAPPEN AGAIN WITH NO LUCK. *TR

SHAKING IN STEERING WHEEL WHEN BRAKES APPLIED AT HIGHER SPEEDS. STARTED INTERMITTENTLY AT ABOUT 12,000-13,000 MILES, PROCEEDED TO GET WORSE. HUSBAND AT FIRST COULDN'T FEEL IT SO I DID NOT TAKE IT IN. WHEN IT GOT REALLY BAD I TOLD MY HUSBAND TO TAKE IT FOR A DRIVE AGAIN, HE SAID HE THOUGHT IT WAS THE ROTORS TO TAKE IT IN TO THE DEALER. SURE ENOUGH I HAD WARPED ROTORS WHICH WERE CHANGED ON JUNE 4, 2010. I AM NOT THE ONLY PERSON I KNOW TO HAVE THIS PROBLEM AT SUCH LOW MILES ON A DODGE VEHICLE. I HAVE INFORMED THEM TO NOTIFY YOU. *TR

TL*-THE CONTACT OWNS A 2009 DODGE CARAVAN. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE STARTED TO VIBRATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN REPLACED THE FRONT ROTORS. THE SECOND FAILURE OCCURRENCE WAS APPROXIMATELY SIX MONTHS AFTER THE SERVICE REPAIR WAS PERFORMED ON THE VEHICLE. THE DEALER REPLACED THE ROTORS AND CALIPERS. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE IDENTICAL FAILURE FOR THE THIRD TIME, AND HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE MANUFACTURER WAS NOTIFIED WHICH INFORMED THE FAILURE WOULD BE UNDER AN INVESTIGATION. THE CONTACT WAS WAITING ON A RESPONSE FROM THE MANUFACTURER REGARDING THE FAILURE. THE FAILURE MILEAGE WAS 3,095. THE CURRENT MILEAGE WAS 9,100.

APRIL 12TH I HAD THE OIL CHANGE IN MY 2009 DODGE CARAVAN AT VALVOLINE. AS I WAS DRIVING HOME MY LOW LIGHT INDICATOR CAME ON. I CHECKED THE AIR PRESSURE AND THEY WERE ALL FINE. I AM IN SALES AND DO A GREAT DEAL OF TRAVEL IN THIS CARAVAN IN THE MINNEAPOLIS AREA. I COULD FEEL THE VAN PULLING HARDER AND HARDER TO THE RIGHT. WHEN I PULL IN TO THE PARKING LOT, THE RIGHT FRONT TIRE WAS LOW. THE AIR VALVE BLOW OUT AND COMPLETE DEFLATED THE TIRE. IF I WOULD HAVE BEEN DRIVING, WHO KNOWS WHAT COULD HAVE HAPPENED. I GOT THE TIRE CHANGED AND BROUGHT THE CAR TO GOODYEAR. I WAS TELLING ME CO WORKER ABOUT THIS AND SHE HAS HAD THE SAME THING HAPPEN TO HER 2009. *TR

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN SXT. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED BUT HE WAS ABLE TO KEEP IT UNDER CONTROL BY DEPRESSING THE BRAKE PEDAL. THE NEXT DAY, ANOTHER DRIVER OF THE VEHICLE NOTICED THE VEHICLE SUDDENLY ACCELERATED SO SHE SHIFTED OUT OF GEAR AND TURNED THE VEHICLE OFF. THE NEXT TIME THE VEHICLE WAS RESTARTED, THE RPMS SHOT UP TO 3000. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND A DIAGNOSTICS TEST WAS PERFORMED. THE DEALER PERFORMED SOFTWARE UPGRADES AND RETURNED THE VEHICLE TO THE CONTACT. IN FEBRUARY 2010, THE CONTACT NOTICED THE ACCELERATION PROBLEM AGAIN SO SHE WENT INTO AN EMERGENCY LANE. THE VEHICLE WAS RETURNED TO THE DEALERSHIP AND THE DEALER TOLD THEM THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE CONTACT CALLED THE MANUFACTURER AND WAS AWAITING RESPONSE FROM A CASE MANAGER. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 5,400. THE FAILURE MILEAGE WAS 3,202-BK

ON ONE OCCASION, MY VEHICLE SWERVED WITHOUT WARNING INTO THE ONCOMING TRAFFIC LANE, LIKE BEING BLOWN BY A STRONG GUST OF WIND. ON ANOTHER OCCASION, THE VEHICLE SPONTANEOUSLY STARTED PULLING AND MY WIFE HAD TO FIGHT IT TO GET IT TO PULL SAFELY TO THE SHOULDER. WHEN I ARRIVED I TRIED IT AND EXPERIENCED THE SAME PROBLEM. THE DEALER DIAGNOSED IT AS A FAULTY CLOCKSPRING & STEERING WHEEL POSITION SENSOR. THE ELECTRONIC STABILITY PROGRAM HAD IMPROPERLY SENSED THE STEERING WHEEL POSITION AND HAD BEEN TRYING TO COMPENSATE. WHILE REPLACEMENT OF THE SAID PARTS RESOLVED THE PROBLEM, MY FAMILY WAS LUCKY TO HAVE AVOIDED A SERIOUS ACCIDENT WHEN THE VEHICLE SWERVED INTO THE ONCOMING TRAFFIC LANE. *TR

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. WHILE DRIVING 65 MPH HE NOTICED THAT THE PASSENGER SIDE 3RD ROW WINDOW/HINGES HAD SUDDENLY FRACTURED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE WINDOW WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 14293. UPDATED 01/12/10. *LJ THE CONSUMER STATED THE WINDOW SEPARATED AND FLEW INTO TRAFFIC. UPDATED 01/13/10.*JB

BRAND NEW 2009 DODGE GRAND CARAVAN. ALL FOUR ROTORS ON THIS VAN HAD TO BE REPLACED. THE BRAKES WERE LIKE NEW. MILEAGE 14,338. *TR

WHILE I WAS GETTING ON THE HIGHWAY GAS PEDAL GOT STUCK AND ACCELERATED. IT WOULD NOT DES ENGAGE EVEN WHILE APPLYING THE BRAKE. *TR

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. THE THIRD ROW SEAT HAD BUTTONS TO FOLD IT DOWN. THE BUTTONS WERE VERY EASY TO TOUCH , SO THE CHILDREN CAN EASILY FOLD DOWN THE SEATS. THERE WAS NO STOP BUTTON, SO THE SEATS WOULD KEEP FOLDING. THE SEAT ALMOST "CRUSHED" HER CHILD SEAT. SHE HAD NOT CONTACTED THE DEALER OR THE MANUFACTURER . THE CURRENT MILEAGE WAS 12,899. THE FAILURE MILEAGE WAS APPROXIMATELY 4,000.

HAD TO REPLACE PADS AND ROTORS ON 2009 DODGE GRAND CARAVAN. TOTAL MILEAGE ON VEHICLE WAS 23,500 MILES. FIRESTONE, WHERE WORK WAS DONE, TOLD ME THAT THEY HAD USED CHEAP PARTS DURING MANUFACTURE. SPOKE TO AN ACQUAINTANCE WHO ALSO HAS THE SAME TYPE OF VEHICLE AND HE HAD TO REPLACE HIS PADS AND ROTORS ALSO AT ABOUT THE SAME MILEAGE. THINK THIS IS A SAFETY ISSUE BECAUSE OF PEOPLE CONTINUING TO DRIVE BECAUSE THEY EXPECT 30K OR MORE JUST OUT OF THE PADS AND THE FACT THAT THIS HAS HAPPENED TO 2 OUT 2 OWNERS OF DODGE CARAVANS. *TR

2008 DODGE CARAVAN. MY WIFE COMPLAINED ABOUT NOISE FROM BRAKES. BROUGHT IN FOR A DIAGNOSIS AND IT NEEDS BOTH FRONT AND REAR BRAKE PADS AND ROTORS. THE CAR HAS 21,000 MILES, 90 PERCENT ON THE HIGHWAY. AFTER RESEARCH ON THE INTERNET, THIS IS A COMMON COMPLAINT AND CHRYSLER IS REFUSING TO DO ANYTHING ABOUT THE ACCELERATED WEAR ON THE PADS AND ROTORS. APPARENTLY THE SUBPAR MATERIALS THAT ARE USED ARE OVER HEATING CAUSING THIS WEAR. THIS IS TOTALLY UNACCEPTABLE. CHRYSLER NEEDS TO ADDRESS THIS AND ISSUE A RECALL. WE WERE LUCKY TO GET 21,000 MI. FROM READING MANY OTHER COMPLAINTS, MOST NEED REPLACING AROUND THE 12,000 MILE MARK. *TR

SEATBELT LOCKED UP. *TR

WE PURCHASED THIS VEHICLE IN EARLY FEBRUARY 2009. TWO WEEKS LATER, THE "CHECK ENGINE" LIGHT CAME ON. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THEY COULD NOT FIND THE PROBLEM. IT HAS BEEN BACK TOT HE DEALERSHIP 2 MORE TIMES FOR THE EXACT SAME PROBLEM AND THEY HAVE NOT BEEN ABLE TO FIND THE SOURCE OF THE PROBLEM AND THE VEHICLE WAS RETURNED TO US. THE EVENING OF APRIL 3RD, WE WERE RETURNING HOME ON THE FREEWAY AND THE TRANSMISSION COMPLETELY FAILED AND ALMOST CAUSED US TO BE INVOLVED IN AN ACCIDENT ON THE FREEWAY. *TR