2002 Chevrolet Silverado 1500 complaints

LIGHTING FOR GEAR AND MILEAGE INDICATOR HAS BEEN GOING OUT INTERMITTENTLY.

WE JUST PURCHASED A USED 2002 CHEVY SILVERADO ON 9/25, TOOK IT FOR A SAFETY INSPECTION AND WAS TOLD THAT THE BRAKE LINES HAD BURST AND BRAKE FLUID WAS LEAKING. THESE REPAIRS ARE GOING TO BE VERY EXPENSIVE AND I FEEL THAT GM SHOULD COVER THE COST OF THE REPAIRS, SINCE THERE ARE HUNDREDS OF PROBLEMS WITH THE BRAKE LINES ON VEHICLES OF THIS YEAR/MAKE/MODEL.

FRAME RUST ENTIRE FRAME IS RUSTED AWAY FROM THE CAN BACK INCLUDING CROSS MEMBERS HOLDING UP FUEL TANK.

TRAVELLING FROM PA TO CAPE HATTERAS, NC. TOTAL BRAKE FAILURE OF ALL 4 WHEELS IN BUMPER TO BUMPER TRAFFIC ON US 158 S BYPASS IN KILL DEVIL HILLS. MANAGED TO SWERVE ONTO RIGHT BERM GRASSY AREA AND SHIFT TO LOW AND USE HAND BRAKE TO STOP. HAD TWO CHILDREN IN THE BACK SEAT. ONE WAS A 2 YEAR OLD. HAD TO DRIVE 42 MILES WITH NO BRAKES TO REACH DESTINATION. MECHANIC IN RODANTHE HAD TO REPLACE ALL BRAKE LINES AND MASTER CYLINDER. BRAKE LINES WERE TOTALLY RUSTED OUT. IF THIS WOULD HAVE HAPPENED ON I-95 AT 70 MPH WE WOULD PROBABLY ALL HAVE BEEN KILLED.

FUEL AND BREAK LINES COMPLETELY RUSTED OUT. FUEL LINE BROKE WHILE REPLACING FUEL FILTER. NECESSITATED REPLACEMENT OF ENTIRE FUEL LINE SYSTEM. BREAK LINE BROKE WHILE DRIVING AROUND SAME TIME LOSING ALL BREAKING FUNCTIONS. NEEDED TO TURN OFF ROAD AND KILL MOTOR TO STOP. ALL BREAK LINES NEED REPLACEMENT. I SPENT $2500 FIXING.

I WAS PULLING MY 2000 LB BOAT TO THE LAKE SAT. WITH MY 2002 SILVERADO 1500 . I MADE IT TO THE LAUNCH RAMP OK BUT WHEN I WENT TO LAUNCH THE BOAT I COULDN'T STOP ROLLING DOWN THE RAMP [ NO BRAKES) I WAS ONLY ABLE TO SAVE THE TRUCK FROM BECOMING A SUBMARINE BY THROWING IT IN DRIVE AND HITTING THE GAS. I DROVE INTO THE PARKING LOT TO FIND THE BRAKE LINE RUSTED OUT . HAD THIS HAPPENED AT HIGHWAY SPEEDS IT WOULD HAVE BEEN CATASTROPHIC . I READ ONLINE ABOUT THE ISSUES WITH THE LINES AND THE FACT THERE WAS A BACKUP. TRUST ME WHEN I SAY WHILE PULLING A BOAT IT WOULD HAVE NEVER STOPPED ME. I'VE HAD CARS LONGER THIS IN MY 40+ YEARS OF DRIVING ANY NEVER HAD A BRAKE LINE FAIL FROM RUST. I WOULD HAVE LIKED A HEADS UP ON THIS ISSUE AS I'VE SEEN IT TO BE A PROBLEM IN MULTIPLE YEARS. NEEDLESS TO SAY I'M DISAPPOINTED AGAIN BY GM BY NOT AT LEAST GIVING THE OWNERS A HEADS UP. AND I'M THANKING GOD FOR MY WIFE AND I NOT BEING INJURED ON A SIMPLE FISHING TRIP. SHAME ON YOU GUYS. IF IT WASN'T AN ISSUE YOU WOULDN'T HAVE CHANGED THE LINES ON LATER MODEL CARS. JUST ONE MORE PUSH TO MAKE ME LOOK AT OTHER VEHICLE MANUFACTURERS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE ATTEMPTING TO ENGAGE THE BRAKES, THE BRAKE PEDAL SANK TO THE FLOORBOARD. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE BRAKE LINES FRACTURED DUE TO CORROSION AND CAUSED THE BRAKE FLUID TO LEAK. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 156,412. UPDATED 10/06/16*LJ *TR

BRAKE LINES AND FUEL LINES ARE VERY RUSTED ALSO THE DRIVE SHAFT AND ABS BRACKET 2 BRAKE LINES HAVE RUSTED THROUGH WHILE DRIVING THE TRUCK HAS ONLY ABOUT 100,000 MILES IT IS VERY DANGEROUS

I WAS DRIVING ON THE HIGHWAY AND HAD TO STOP, THE BRAKE PEDAL GOES TO THE FLOOR WITH HARDLY ANY BRAKES.I HAD TO GO ON THE RIGHT SIDE OF THE ROAD TO AVOID MAJOR CRASH . WAS VERY SHOCKED AND HEART WAS RACING . I NEVER HAD THAT HAPPEN BEFORE IN ALL THE YEARS I HAVE BEEN DRIVING. I MANAGED TO MAKE IT HOME BY USING LOWER GEARS AND EMERGENCY BRAKE TO STOP. WHEN I FINALLY GOT HOME I LOOKED TO SEE WHAT THE HECK WAS GOING ON AND SAW THAT MY BRAKE LINES HAD CORRODED THRU AND THE FLUID WAS COMING OUT. I WENT ON LINE TO SEE IF THERE WAS ANY OTHERS WITH THIS PROBLEM AND SAW THERE WERE MANY, MANY COMPLAINTS ABOUT THIS ISSUE. I CALLED SEVERAL PLACES AND THE COST TO REPLACE ALL MY BRAKE LINES WAS AROUND 1200 - 1700. I ENDED UP GETTING THEM REPLACED FOR $1600. THIS SHOULD NOT HAPPEN. I HAVE OWED MANY VEHICHLES OVER THE YEARS IN THIS SAME AREA AND HAVE NEVER EVER HAD TO REPLACE A BRAKE LINE. I THINK THIS SHOULD BE A MAJOR RECALL BEFORE ANYONE DIES. THERE MUST BE FAULTY METAL BEING USED IN THESE AND NEEDS TO BE STAINLESS STEEL. I WOULD LIKE TO BE REIMBURSED FOR THE $1600 I HAD TO SPEND ON THESE FAULTY BRAKE LINES. THEY NEED TO DO A RECALL OR LET PEOPLE KNOW ABOUT THIS PROBLEM AND REIMBURSE THEM FOR THE REPAIRS.

BRAKE LINE ARE RUSTING AND FAILING. I WAS DRIVING IN THE CITY AND THE PEDAL WENT TO THE FLOOR WHEN I APPLIED THE BRAKES. THIS IS THE SECOND LINE TO FAIL FROM RUST AND THE OTHER 3 LOOK VERY RUSTY.

THE FUEL LINES RUST AWAY AND START LEAKING FUEL BADLY. ALL LINES HAVE TO BE REPLACED. THE RUST ON THIS TRUCK IS UNBELIEVABLE. GM WILL NOT STAND BEHIND THE PRODUCT. THE ROCKER PANELS ALL RUSTED OUT AS WELL. THE FRAME IS RUSTING OUT. THESE TRUCK ARE JUST RUST BUCKETS

1ST INCIDENT - VEHICLE IN MOTION AT LOW SPEED, ANTI-LOCK BRAKES ACTIVATE AND PREVENT VEHICLE FROM STOPPING, RAN INTO GARAGE DOOR 2ND INCIDENT - AFTER 1ST INCIDENT, CAR SHOP REPLACED ABS MODULE. SAME SITUATION. VEHICLE IN MOTION AT LOW SPEED, ANTI-LOCK BRAKES ACTIVATE AND PREVENT VEHICLE FROM STOPPING, RAN INTO CAR IN PARKING LOT.

ONE OF THE REAR BRAKES STOPPED WORKING WHILE DRIVING.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT 2 MPH, THE LOW SPEED ABS ENGAGEMENT INCREASED THE STOPPING DISTANCE AND THE CONTACT COULD NOT STOP THE VEHICLE. THE CONTACT ALMOST CRASHED INTO THE GARAGE DOOR BUT WAS ABLE TO STOP THE VEHICLE BEFORE A CRASH OCCURRED. THE CONTACT RELEASED THE BRAKE PEDAL AND RE-APPLIED PRESSURE TO THE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,652. UPDATED 07/12/16*LJ

I PURCHASED THE TRUCK FROM THE DEALER, WITH 230,000 MILES ON SHORTLY AFTER PURCHASE AS I BRAKED TO STOP THE PEDDLE WOULD STIFFEN AND PURR... AND THE VEHICLE WOULD NOT STOP, RUNNING INTERSECTIONS AND PARKING SPOTS. CAUSING NEAR ACCIDENTS. II LEARNED THIS WAS RELATED TO BRAKE ANTILOCK SYSTEM. DEALER SAID THEY DONE THE RECALL PROCEDURE TO CLEAN SENSORS AND AVOIDED ANY FURTHER CONCERNE EXPRESSED. I CHECKED WITH OTHER DEALERS WHO HAD THE SAME DENIAL REACTION, THE INITIAL DEALER HAD DONE CHECKS TO ALL CHASIS AND COMPONANT CHECKS, I NOTICED A MILD GROWL WHEN IN FOUR WHEEL DRIVE BUT DROVE WELL OTHERWISE. I INSPECTED THE WHEEL SENSORS AND THEY WERE CLEAN I LEARNED THE RELUCTOR RING WHICH TRIGGERS THE SENSORS ARE WITHIN THE FRONT WHEEL BEARINGS I HAD ONE OIL SERVICE DONE BY ANOTHER GARAGE WHO DID A 21 POINT CHECK BUT NEGLECTED TO TELL ME OF THE APPARENT WEAR. AFTER ABOUT FIFTEEN MONTHS THE LEFT FRONT WHEEL BEARING BEGAN TO FAIL WHILE DRIVING CAUSING A EXTREME GROWL, I THEN HAD IT CHECKED BY A SERVICE GARAGE WHO CLEARLY IDENIFIED THE EVIDENT WEAR ON BOTH FRONT WHEEL BEARINGS, I HAD THE BEARINGS BOTH CHANGED ALONG WITH A LOWER BALL JOINT ALONG WITH BOTH FRONT AXLE SHAFTS, DUE TO MILD LEAKING BOOTS. THIS THEM STOPPED THE HARD PEDDLE AND BRAKE FAILURE WHEN STOPPING. THE DEALER KNEW OF THE WEAR AND IGNORED THE DANGER. THE DEALER SHOULD NOT BE ALLOWED TO SELL A VEHICLE IN THIS CONDITION . THE TRUCK DOES DRIVE WELL NOW. BUT I STILL HAVE A VERY MILD GROWL IN THE LEFT FRONT,BUT WITH THE AXLES N

EXCESSIVE CORROSION ON BRAKE AND FUEL LINES. HAD A METAL LINE BLOW OUT NEAR REAR DRIVER SIDE WHEEL CAUSING DRIVER TO HAVE TO USE TRANSMISSION AND HOLDING PARKING BRAKE RELEASE HANDLE WHILE USING E-BRAKE WHILE STEERING WITH ONE HAND. UPON SPLICING IN A SECTION OF REPLACEMENT TUBING, I NOTICED THE FUEL RETURN LINE FROM THE ENGINE TO THE TANK IS CORRODED SEVERELY TOO. I HAD A SECTION OF FUEL LINE FALL APART UPON REPLACING A FUEL FILTER AND SPLICED IN A RUBBER FUEL HOSE WITH CLAMPS TO GET A FUEL FILTER REPLACED. WHEN THE FUEL LINES RUPTURE, THERE IS A CHANCE OF FIRE FROM THE EXHAUST OR HOT BRAKE DRUMS. WAS ADVISED BY MECHANIC THAT I NEED TO SELL TRUCK AS IT HAS 18-24 MONTHS LEFT WITHOUT PROPER AND EXPENSIVE REPAIRS BEING MADE. RARELY GETS UNDERBODY WASH AS A QUALITY WASH IS FAR AWAY AND WAS ADVISED THAT THE RUST IS PROBABLY HOLDING IT TOGETHER AND ADVISED NOT TO KNOCK OFF ANY MORE RUST AS IT WOULD ACCELERATE FURTHER CORROSION. WAS ADVISED A WASTE OF TIME TO USE RUST REFORMER OR UNDERCOATING. I NOTICED THIS STATIONARY AS THE VEVICLE WAS MAKING SQUEAKING SOUNDS FROM THE REAR AXLE HUB ON DRIVER SIDE (SAME LINE THAT BLEW) AND FIGURED HANGING CALIPER SO I DID A FULL BRAKE PEDAL PRESS AND FELT THE PEDAL GET SPONGY AND DROP ANOTHER 1" TOWARD FLOOR. I OPENED DOOR, HUNG OUT LOOKING UNDER TRUCK AND PRESSED PEDAL AGAIN TO SEE FLUID POURING FROM REAR AXLE AREA. DROVE IT 30 MILES WITH NO SERVICE BRAKES TO GET TO THE GARAGE USING ONLY E-BRAKE AND 3,2,1 AND NEUTRAL RANGE OF TRANSMISSION TO BE A

CORROSION AND FAILURE OF METAL BRAKE LINE DIRECTLY BELOW LEFT FRONT DOOR. VERY POOR DESIGN AS TUBES ARE BEHIND A DOUBLE LOOP OF CHASSIS WIRING CAUSING BUILDUP OF DIRT AND MOISTURE RESULTING IN PREMATURE FAILURE. FAILED WHEN BACKING OUT OF THE DRIVEWAY AND THANK GOD I WAS NOT ON THE ROAD

4 BROKEN EXHAUST MANIFOLD BOLTS

WHILE APPROACHING A STOP SIGN I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. NO WARNING OF ANY KIND. LUCKY FOR ME NO TRAFFIC WAS COMING.

BRAKE LINES RUSTD OUT. MAKING MY TRUCK LOOSE BRAKE FLUID AND HAD TO BE REPLACE,. SERIOUS PROBLEM, LUCKY I DID NO HAVE AN ACCIDENT. RUST ETC, ALL OVER THE REST OF THE BRAKE SYSTEM, VERY COSTLY, $$$$$, I WAS DRIVING DOWN A STREET SLOWLY.

CHEVY RUST. BRAKE LINES RUSTED OUT COMPLETELY AND FAILED - HAPPEN AT SLOW SPEED NO ONE INJURED. SHACKLED BROKE OFF AND HIT BOTTOM OF BED WITHOUT TOWING. FRAME IS RUSTED OUT. NEIGHBOR HAS SIMILAR VEHICLE WITH SAME PROBLEMS (PUT JACK ON FRAME AND IT WENT THROUGH THE FRAME.) MANY COMPLAINTS ONLINE ABOUT THESE VERY ISSUES.

WHILE DRIVING ON TWO LANE COUNTRY HIGHWAY AT 55MPH LOW BEAM HEAD LIGHTS WENT OFF. AFTER A FEW SCARY SECONDS I WAS ABLE TO FIND A SAFE PLACE TO STOP. I TRIED SEVERAL THINGS AND DISCOVERED THAT THE HIGH BEAMS STILL WORKED. I PROCEEDED TO MY DESTINATION DEFECTIVE MULTI FUNCTION SWITCH. INTERNET TELLS ME I AM ONE OF MANY.

FRAME IS ROTTING OUT

BRAKES PULSATING AT LOW SPEED TRYING TO STOP ALMOST HIT ANOTHER CAR IN FRONT OF ME.

RECALL 05V379000 RELATED TO LOW SPEED ACTIVATION OF THE ABS BRAKING SYSTEM WHILE MY VEHICLE IS OPERATED WAS PERFORMED IN 2006 ON MY VEHICLE. THIS HAS NOT FIXED THE ISSUE AS LOW SPEED ACTIVATION OF THE ABS SYSTEM IS OCCURING NOW. I HAVE CONTACTED CHEVROLET CORPORATION (GMC) AND ASKED TO HAVE THE RECALL PROTOCOL PERFORMED AGAIN. THEY REFUSE. I SPOKE WITH KIMBERELY FROM NHTSA AND SHE ADVISED ME TO FILE A COMPLAINT IF GMC REFUSED TO TAKE RESPONSIBILITY FOR THIS DEFECT. PHONE CONFIRMATION # 868194

I PULLED INTO DRIVEWAY AND PUT CAR IN PARK, LEFT ENGINE RUNNING. WENT TO DOOR OF RESIDENCE TO GET MY KIDS. KIDS WENT OUT TO THE CAR AND WERE YELLING FIRE! I SEEN THE INSIDE UP IN SMOKE. I REACHED INSIDE TO TURN ENGINE OFF. WE THEN STARTED POURING BUCKETS OF WATER INTO SEAT AND ON FLOOR AROUND THE SEAT TO TRY TO PREVENT SPREAD OF THE FIRE. I LUCKILY PUT THE FIRE OUT. FIRE DEPT UNHOOKED BATTERY AND REMOVED MELTED PLASTIC AROUND SEAT. IT SEEMS A WIRE SOMEHOW SHORTED OUT BENEATH SEAT AND CAUGHT THE SEAT AND FLOOR ON FIRE.

2002 CHEV. 1500 SILV. PURCH. 2001 TX.ABS BRAKE SYSTEM FAILED ON ST UNDER 5MPH,BROUGHT TO MECHANIC.,BRAKE PADS, AND TIRES.SOUTHEAST TEXAS HOT AND VERY HUMID, LAWS OF NATURE, AIRBAGS ARE NO GOOD IN EITHER VEHICLE.(SHE HAS A SON AGE 14, AND 3YR OLD GRL).AXIL IS RUSTY WORRIED THAT IT MIGHT BREAK.GOD IS WITH ALL OF US ,HIS INTENTIONS ARE ALWAYS GOOD. GOD PROTECTED HER AND HER CHIILDREN IN THIS VEHICLE THUS SO FAR..\& WE DESIRE TO PROTECT THIER CHILDREN AND YOU KNOW THIS, BUT SOMETIMES PEOPLE GO THROUGH UNFORTUNATE TRAGEDYS SUCH AS DIVORCE, HEALTH, ETC.A SINGLE, NO MONEY THAT WANTS SAFETY FOR THER CHILDREN AND WORK .CHEVY SILVERADO BROUGHT NEW PAID OFF LESS THAN 3YR. HER 1994 FORD MUSTANG (WAS INSURED FARMERS)PURCHASED IN 1997.ABS BRAKES FAILED, TRANSMISION PROB.& ENGINE REPLACED. TRUCK( GEICO INS) UNDRIVABLE BECAUSE OFELECTRICAL SYSTEM AND ABS,RUSTY BRAKE LINES, RUSTY AXILS,LEAK IN THE LINE,NO HORN, DOORS DO NOT SEAL WATER LEAK, PAINT FADED,EVEN TOOLS CAN NOT FIX THESE PROBLEMS.SHE HAS A COLLEGE DEGREE AND LIVING IN A HOME SHE BOUGHT (BEFORE THE TRAGEDY )WHEN SHE WORKED.(HELPING OTHERS AT HERMAN MEMORIAL BAPTIST HOSPITAL BEAUMONT BEHAVIOR CENTER OF SOUTHEAST TEXAS, MEHAFFY WEBER LAW FIRM, CHRISTUS ST.MARYS HOSPITAL OUTPATIENT CENTER, PORT ARTHUR ANIMAL CLINIC,PORT ARTHUR NEWS PAPER, PNG ISD AS A SUB-TEACHER,SPINDLETOP MHMR AND FAMILY SERVICES WOMANS AND CHILDRENS SHELTER. SHE HAS VOLUNTEERED AT 3 RIVERS COUNCIL FOR BOYSCOUTS OF AMERICA AND EVEN GRADULATED WITH THE WO HE LO MEDALIO

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD WITHOUT WARNING. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 125,000. UPDATED 02/12/16*LJ INVALID VIN NUMBER 4/23/18*JB *CN

SEEMS THAT BELOW 10 MPH ANTI LOCK KICKS IN ON DRY PAVEMENT AND MAKES TRUCK HARD TO STOP IN MOTION ON ROAD

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING AT 10 MPH AND PROCEEDING TO STOP THE VEHICLE, THE BRAKE PEDAL FAILED WHEN DEPRESSED. THE VEHICLE WAS RESTARTED AND FUNCTIONED NORMALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 121,648.

WAS REPLACING BRAKE LINES AFTER A RUSTY LINE BROKE AND SEEN EXCESSIVE RUST ON THE PASSENGER SIDE FRAME IN THE FRONT 1/4 OF PICKUP. THE FRAME HAS A LONG HOLE ON BOTTOM OF FRAME SPANING ABOUT 10 INCHES AND ABOVE THE SAME SECTION OF FRAME HAS A LONG RUSTED CRACK RUNNING PARALLEL WITH THE FRAME SPANING ABOUT 8 INCHES. THE REST OF THE FRAME LOOKS IN GOOD CONDITION.

WHILE DRIVING THROUGH MY SUBDIVISION APPROXIMATELY 20 MPH AND PRESSING THE BRAKE, THE PEDAL WENT COMPLETELY TO THE FLOOR AND THE VEHICLE DID NOT SLOW DOWN. I PUMPED THE PEDAL REPEATEDLY AND ONLY SLIGHT BRAKING ACTION COULD BE ACHIEVED. I WENT THROUGH THE SUBDIVISION JUST NARROWLY MISSING TWO CROSSING CARS AND KIDS THEN TURNED ONTO A NEARBY SIDE STREET. AFTER FINALLY GETTING THE VEHICLE TO STOP, I GOT OUT AND SAW A PUDDLE OF BRAKE FLUID FORMING A FEW FEET BEHIND THE DRIVER SIDE FRONT WHEEL.

BRAKES FAILED COMPLETELY. AFTER I FELT THE BRAKE PEDEL WAS NOT RIGHT I BACKED THE TRUCK INTO THE FRONT YARD, AND WHEN I TRIED TO STOP THERE WAS NO PEDEL AND THE TRUCK KEPT GOING AND HIT A TREE, LAWN BENCH,MISC. OBJECTS, AND STOPPED AFTER HITTING S RETAINING WALL. I ESTIMATE SEVERAL THOUSAND DAMAGE DONE. I WAS TOLD THE BRAKE LINES WERE RUSTED.

I WAS DRIVING IN APPOMATTOX VA WHEN I STEP ON BREAK I HAD NO BREAKS. TWO OF LINES HAD BUST.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 60 MPH, THE TRANSMISSION FAILED TO RESPOND PROPERLY IN THE OVERDRIVE POSITION. IN ADDITION, THE TRANSMISSION TEMPERATURE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON THREE SEPARATE OCCASIONS WHERE A REPAIR WAS PERFORMED EACH TIME. THE CONTACT WAS UNCERTAIN OF THE SPECIFIC PARTS THAT WERE REPLACED. THE FAILURE RECURRED AND AN INDEPENDENT MECHANIC WAS DIAGNOSING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.

APPROACHED CORNER AND PRESSED BRAKES TO TURN. PEDDLE WENT TO THE FLOOR. ALMOST RAN INTO A CAR TURNING AND I HAD TO SWERVE TO MISS THEM.

MULTIPLE TIMES STOPPING ABOUT 4-5 MPH ON DRY PAVEMENT, MY VEHICLES ABS SYSTEM KICKS ON AND I LOOSE BREAKING POWER.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT FUEL WAS LEAKING UNDER THE VEHICLE. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AS SOON AS THE VEHICLE WAS OPERATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000. MA 10/19/2015

THE FIRST TIME I LOST ALL BRAKES WAS WHEN I WAS BACKING UP TO A TRALER ON 7/13/15. THE SECOND TIME I WAS HAULING A DUMP TRAILER WITH ROCK AND LOST ALL BRAKES AND WAS ABLE TO GET IT TO COAST TO A STOP. THE FIRST INCIDENT WAS TAKEN TO A CHEVY DEALERSHIP AND HAD THE REAR BRAKE LINE REPLACED, ONLY TO LOSE MY BRAKES AGAIN 40 DAYS LATER! THIS TIME IT WAS MY FRONT BRAKE LINE. WHY IS THERE NO RECALL ON THIS? I DON'T FEEL SAFE DRIVING THIS VEHICLE ANYMORE. I HAVE 3 YOUNG CHILDREN AND I CAN'T TRUST YOUR VEHICLE WITH THEIR LIVES OR MINE!

LUCKILY I WAS PULLING IN MY DRIVEWAY WHEN I FOUND OUT MY BRAKES HAD GONE BECAUSE THEY HAD RUSTED THROUGH NOT LONG AFTER MY GAS WAS POURING OUT CAUSE THE FUEL LINES RUSTED AND NOW CHANCES ARE I WONT GET AN INSPECTION STICKER THIS COMING YEAR BECAUSE MY FRAME IS RUSTED OUT

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR THE BRAKES ON THE VEHICLE. THE VEHICLE WAS REPAIRED. AFTER THE RECALL REPAIR WAS PERFORMED, THE BRAKES PULSATED WHEN APPLIED. THE DEALER STATED THAT THE FAILURE WAS DUE TO AN AFTERMARKET WHEEL BEARING. THE CONTACT STATED THAT THE BRAKES WORKED EXCEPTIONALLY WELL PRIOR TO THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER THE CONTACT WAS NOT OFFERED A REMEDY. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 130,000. UPDATED 09/10/15*LJ UPDATED 11/08/2017*CN

I LOST THE BRAKES. THE PEDDLE WENT TO THE FLOOR. IT TURNED OUT TO BE A RUSTED OUT BRAKE LINE. I WAS ABLE TO AVOID AN ACCIDENT BY PULLING OFF THE ROAD. AFTER RESEARCH, I FOUND THIS IS A RECURRING PROBLEM FOR CHEVY SUBURBANS.

MY BRAKE LINES FAILED, NEARLY RESULTING IN KILLING A CHILD THAT RODE HIS BIKE ONTO THE ROAD FROM A DRIVEWAY AND FORCING A VEHICLE HEADON INTO MY LANE OF TRAVEL. LUCKLY EVERYONE WAS ABLE TO SQUEEZE INTO APPROPRIATE PLACES AND WAS PAYING ATTENTION AS I WAS UNABLE TO SLOWDOWN. DUST COVERS ON THE REAR HAVE BEEN RUSTED AND GONE FOR THE LAST TWO YEARS, AND I HAVE REPLACED THE REGULATORS IN BOTH PASSENGER/DRIVERSIDE DOORS THREE TIME EACH DUE TO THE CABLES RUSTING AND SNAPPING. WHEN I TOOK MY VEHICLE INTO CHEVROLET DEALER SHIP FOR MAINTENANCE, IT HAD LESS THAN 36K AT THE TIME, THEY REMOVED ONE PLASTIC PANEL (FALLING DOWN FROM BEHIND THE DOOR INTERIOR TRIM PANELS) FROM EACH DOOR THAT WAS HANGING DOWN AND SCRATCHING MY ROCKER PANEL, AND SAID "WE DONT KNOW WHAT THESE ARE FOR, SO WE JUST REMOVED THEM", HMMM, MAYBE IT WAS TO HELP WITH MOITURE RELATED ISSUES WITHIN THE DOOR PANEL. NOT SURE JUST GUESSING, BUT CANT BELLIVE THAT THEY COULDN'T FIGURE IT OUT. OVER ALL NOT IMPRESSED WITH CHEVROLET EVEN THOUGH IT IS PRETTY MUCH ALL I HAVE OWNED, IF THEY KEEP PRODUCING THIS CRAP THEY SHOULD LOWER THE PRICE.

WHILE ATTEMPTING TO STOP THE 2002 CHEVROLET SILVERADO 1500, THE ANTI-LOCK BRAKES ACTIVATED AT ABOUT 5 MPH AND CAUSED TOTAL LOSS OF BRAKING CONTROL. UNABLE TO STOP, THE SILVERADO CRASHED DIRECTLY INTO AN ADVERTISING SIGN. THERE WAS MINIMAL DAMAGE TO THE SILVERADO, MODERATE DAMAGE TO THE ADVERTISING SIGN, AND NO INJURIES TO THE DRIVER OR TWO CHILDREN. FOLLOW-UP AFTER THE ACCIDENT REVEALED THAT ACTIVATION OF THE ANTI-LOCK BRAKING SYSTEM (ABS) IS A KNOWN ISSUE AND PART OF A GM RECALL (NHTSA CAMPAIGN NUMBER: 05V379000).

WENT TO START TRUCK. PRESSED BRAKE PEDAL. TRUCK STARTED, PEDAL WENT TO FLOOR. TOOK FOOT OFF PEDAL. LET TRUCK RUN FOR A FEW MINUTES TO SEE IF BRAKE LIGHT WOULD GO OFF. IT DID NOT. TURNED OFF TRUCK. CHECKED AROUND TRUCK. FOUND BRAKE FLUID UNDER TRUCK BY RIGHT REAR TIRE. CHECK BRAKE LINE NEAR LEFT REAR TIRE. IT IS IN BAD SHAPE AND WILL LIKELY FAIL SOON. TWO OR THREE YEARS AGO, HAD FRONT LINE FAIL BELOW DRIVER'S SEAT. REPLACED FRONT LINES. REAR LINES DID NOT LOOK TOO BAD AT THE TIME. WITH ALL NEW TECHNOLOGY ADVANCES, CHEVY IS NOW USING INFERIOR MATERIAL. DUST GUARDS AROUND REAR BRAKES OF THIS TRUCK ARE COMPLETELY GONE ON BOTH SIDES. EVERYTHING IS RUSTING. HAD 1975 BUICK ESTATE WAGON FOR 22 YRS. IT WAS IN BETTER SHAPE WHEN I SOLD IT THAN THIS TRUCK HAS BEEN FOR THE LAST SEVERAL YEARS. CHEVY COULD DO ALL THE CORPORATE DOUBLE SPEAK THEY WANT. FACT IS THIS RUST ISSUE IS A SAFETY ISSUE. I HAVE FRIENDS THAT HAVE A LITTLE OLDER AND NEWER 1500 AND ALL HAVE BRAKE LINE ISSUES AND VARYING DEGREES OF RUST UNDERNEATH THE VEHICLE. I SEE WHERE OTHERS HAVE REGISTERED SIMILAR COMPLAINTS. IT IS UNFORTUNATE THAT NOTHING WILL GET DONE UNTIL THERE ARE SERIOUS INJURIES. (I SEE WHERE YOU WANT A DAYTIME PHONE NUMBER. IF YOU CALL FROM A PHONE THAT DOES NOT HAVE A NHTSA ID, YOU WILL HAVE TO LEAVE A VOICEMAIL.) UPDATED 09/17/15*LJ UPDATED 10/27/2017*CN

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING AT 5 MPH, THE ANTILOCK BRAKE SYSTEM WOULD ACTIVATE INDEPENDENTLY. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL SPEED SENSOR MOUNTING SURFACE NEEDED TO BE CLEANED AND REINSTALLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,800.

I'VE HAD TO REPLACE CALIPERS, ROTORS, BRAKE LINES THE HAVE RUSTED, BRAKES HOSES THAT HAVE GONE BAD AND THIS VEHICLE IS WELL KEPT AND INSIDE. LOW MILES FOR A 2002 AND YET ALL AT ONCE EVERYTHING WENT BAD INCLUDING MY FUEL SENSOR FOR THE GAS GUAGE.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE BRAKES FAILED WHILE DRIVING 50 MPH. THE DEALER STATED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 153,000.

WITHOUT ANY WARNING AND FORTUNATELY AT LOW SPEED THE DRIVER'S SIDE REAR BRAKE LINE DEVELOPED A MAJOR LEAK. DESPITE GM'S CLAIM THAT AN INCIDENT SUCH AS THIS DOES NOT RESULT IN INADEQUATE BRAKING, IT WAS DIFFICULT TO STOP THE TRUCK. FURTHER INSPECTION OF THE BRAKE LINES YIELDED CONSIDERABLE CORROSION IN OTHER AREAS. CONTACTING THE DEALER WHERE I PURCHASED THE TRUCK REVEALED THE HIGH COST TO REPAIR THIS ISSUE, DESPITE THE FACT THAT IT IS A MAJOR SAFETY ISSUE WITH THE TRUCK. THE DEALER ALSO MADE NOTE THAT I SHOULD CONSIDER REPLACING THE FUEL LINES. CONTACTING GENERAL MOTORS YIELDED THE RESPONSE THAT THIS IS A MAINTENANCE ISSUE AND THAT THEY COULD DO NOTHING TO ASSIST ME. I DO CONSIDER OTHER COMPONENTS IN THE BRAKING SYSTEM TO BE MAINTENANCE ITEMS, NOT THE BRAKE LINES. BRAKE LINE FAILURE CAN RESULT IN IMMEDIATE CATASTROPHIC RESULTS WITH ABSOLUTELY NO WARNING. MY EXHAUST SYSTEM IS THE SAME AGE AS MY BRAKE LINES AND IS IN EXCELLENT CONDITION DESPITE THE SAME ENVIRONMENTAL EXPOSURE AS MY BRAKE LINES. GENERAL MOTORS NEEDS TO ADDRESS THIS SERIOUS SAFETY ISSUE. *TR

RUSTY BRAKE LINE BROKE. LOST BRAKE CONTROL FOR ENTIRE VEHICLE. *TR