2007 Chevrolet Aveo

Defect. General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

Risk. If the DRL module melts due to the heat generation, it could cause a vehicle fire.

Remedy. GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

Defect. ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.

Risk. IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.

Remedy. DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.

The airbag warning light has remained illuminated since I acquired the vehicle in January 2025. The warning light stays on continuously and does not reset. This indicates a fault in the airbag system, and I have been advised that when this light is on, the airbags may be disabled and may not deploy in a crash. The vehicle has also experienced ongoing electrical problems, including lighting failures, blown fuses, and shift-interlock malfunctions, which suggests an electrical system fault affecting multiple safety-related systems. These issues create concern that the airbag control system may be impacted by the same electrical malfunction. The vehicle has not been repaired or diagnosed by a dealer for the airbag issue. The condition is still present and the warning light remains illuminated. This failure creates a serious safety risk because the airbags may not function in the event of a collision.

The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warning lights were illuminated, and the vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the contact stated that the failure had reoccurred, and the vehicle failed to restart. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver’s side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with the front driver’s side air bag. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately of 52,000.

Out of no where it cought on fire

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE SHUDDERED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO AN UNKNOWN ENGINE CYLINDER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

I HAVE PROBLEMS WITH WHENEVER I GO TO PUT GAS IN MY CAR, SOME OF IT GOES ON THE GROUND. NOT ALL OF THE GAS GOES ON THE GROUND, BUT A LITTLE LESS THAN HALF OF WHAT I PURCHASED. MY HEADLIGHTS ARE SO DIM THAT I CAN'T HARDLY SEE WHEN I'M DRIVING AT NIGHT. ALSO, MY PASSENGER SIDE AIR BAG LIGHT IS CONSTANTLY ON? THERE'S ONE THERE AND NOTHING BIGAMY WRONG WITH IT THAT I CAN SEE. THE STEREO.....ONLY THE DRIVER SIDE FRONT SPEAKER WORKS, THE OTHER THREE DOESN'T WORK AT ALL....PLEASE LOOK INTO THESE FEW THINGS OR GIVE ME SOME SORT OF IDEA OF WHAT I CAN DO

VEHICLE HEADLIGHTS FAILED. CAR WAS PARKED IN THE DRIVEWAY. AN HOUR LATER WHEN IT WAS STARTED AGAIN, THE HEADLIGHTS FAILED TO COME ON AND REMAIN INOPERABLE. BULBS, SWITCH, AND RELAY HAVE ALL BEEN CHECKED AND VERIFIED TO BE OPERABLE.

"TAKATA RECALL" I BOUGHT MY CAR IN 2009. ABOUT 6 MONTHS LATER THE AIRBAG LIGHT CAME ON AND THE DEALER WENT OUT OF BUSINESS. WHEN I CHECKED THE VIN NUMBER IT WAS NOT AMONG THE MANY, MANY AVEOS TAGGED FOR RECALL TO REPLACE FAULTY AIRBAG SYSTEMS. AND I'M NOT ALONE. COMPLAINTS KEEP PILING IN FROM AVEO OWNERS ABOUT THE AIRBAG SAFETY LIGHTS THAT NEVER TURN OFF, NEARLY CATCHING UP WITH 20 YEARS OF "COMPLAINTS INVOLVING TAKATA INFLATORS..." MY CAR WAS PARKED WHEN AN INDIVIDUAL BACKED INTO MY PASSENGER DOOR. THE COLLISION WAS SO SEVERE THE DOOR HAD TO BE REPLACED. YET IT TRIGGERED NO AIRBAGS. DID YOU KNOW WHILE THE AIRBAG LIGHT IS ENGAGED, THE CAR CANNOT BE SOLD? YOU THINK THIS MIGHT BE DUE TO THE FACT THAT IT INDICATES A SERIOUS PROBLEM WITH THE AIRBAG SYSTEM - THAT MOST PROMINENT FEATURE IN AVEO'S HIGHLY TOUTED "5-POINT" SAFETY RATING? SO WHAT'S ITS RATING WITHOUT AIRBAGS? OR DO WE NEED A HIGHER BODY COUNT BEFORE THE MAKERS AND SAFETY REGULATORS ARE WILLING TO TALK ABOUT THAT? NEED WE REALLY TOIL WITH THE QUESTION ABOUT WHY AMERICA LOST ITS PLACE IN THE AUTO INDUSTRY? WE NEED GO NO FURTHER THAN RIGHT HERE.

TAMARA RECALL MY CAR COMBUSTED INTO FRAMES AFTER BEING WRECKED INTO A CURVE OF LAST YEAR OF JUNE.

RECALL FOR DAYLIGHT RUNNING LIGHTS OVER HEATING DIDN'T APPLY TO MY PARTICULAR CAR, BUT SEEMS TO BE A PROBLEM IN MY CAR REGARDLESS. GROUND WIRES IN MY HEADLIGHT ASSEMBLY HAVE FRIED AND LEFT SCORCH MARKS ON HEADLIGHT CONNECTION. NO ACTUAL FIRE YET JUST A MELTED PLASTIC UNDER THE HOOD. NOT SURE IF MY CAR IS INVALID AS HAVE BEEN FIXED OR JUST NOT COVERED BUT IN EITHER CASE PART IS FAILING.

BLOWS A FUSE AND WILL NOT COME OUT OF PARK

1. AIRBAG READINESS LIGHT REMAINS ON FOR DURATION OF VEHICLE'S OPERATION. 2. DRIVER SIDE INSIDE DOOR LATCH IS CRACKED AND WILL NOT OPEN DOOR.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHEN THE CONTACT PULLED IN THE DRIVEWAY AND ATTEMPTED TO TURN OFF THE VEHICLE, THE ELECTRICAL POWER SHUT OFF. AS A RESULT, THE CONTACT WAS UNABLE TO ROLL THE WINDOWS UP OR DOWN, UNLOCK THE DOOR WITH THE SWITCH, AND THE KEY WOULD NOT TURN TO THE OFF POSITION IN THE IGNITION. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE ATTEMPTING TO PARK THE VEHICLE, IT INDEPENDENTLY ACCELERATED UPHILL. THE CONTACT STATED THAT THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 8-3467846222. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THE SEAT BELT WARNING LIGHT ILLUMINATED AND THE WIRES FOR THE PARKING LIGHTS WERE BURNT. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO REPLACED THE VEHICLE'S FRONT LIGHT ASSEMBLY. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE THE VEHICLE WAS PARKED OR WHILE DRIVING, A BURNING ELECTRICAL ODOR WAS DETECTED IN THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE ODOR COULD NOT BE DETERMINED. THE CONTACT WAS REFERRED TO AN ELECTRICAL SPECIALIST BY THE INDEPENDENT MECHANIC, BUT THE VEHICLE WAS NOT DIAGNOSED DUE TO THE DIAGNOSTIC FEES. THE CONTACT STATED THAT THE INDEPENDENT MECHANIC ADVISED HER TO DISCONNECT THE VEHICLE'S BATTERY. THE CONTACT RESEARCHED THE ISSUES ONLINE AND FOUND NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE, CONFIRMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL, AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 10/25/17*LJ THE CONSUMER STATED THE VEHICLE WAS TRADED IN. *JS

AIRBAG LIGHT CAME ON AND HAS STAYED ON FOR 2 MONTHS. UNABLE TO DETECT WHAT IS WRONG WITH ELECTRONIC READER. AIRBAGS ARE DISENGAGED, AND I CAN'T FIND OUT WHY WITHOUT PAYING MORE MONEY THAN I HAVE TO SPEND BECAUSE EACH COMPONENT HAS TO BE CHECKED, AND THAT DOESN'T INCLUDE ACTUALLY FIXING THE PROBLEM, JUST FIGURING OUT WHAT THE PROBLEM IS. I'VE SEEN THAT MANY PEOPLE HAVE COMPLAINED ABOUT THIS. PASSENGER AIRBAG SENSOR STARTED ACTING WEIRD/ NOT WORKING FIRST. OCCURRED AROUND 100 K MILES. WHEN WILL A RECALL HAPPEN? THIS IS APPARENTLY A COMMON SAFETY ISSUE.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 55 MPH, THE ACCELERATOR PEDAL FAILED TO OPERATE AND THE GEAR FAILED TO SHIFT AND WENT STRAIGHT INTO NEUTRAL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COOLANT LEVEL SENSOR MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING COLUMN SEIZED WITHOUT WARNING. THE VEHICLE WAS MANUALLY RESTARTED AND THE STEERING OPERATED NORMALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 127,429.

THE AIR BAG WARNING LIGHT CAME ON WHILE DRIVING 20MPH WHILE TURNING AND HAS NEVER WENT OFF (STARTED AROUND 125,000MILES). I TOOK IT TO THE LOCAL MECHANIC, HE CHECKED WIRES AND HOOKED IT UP TO A DIAGNOSTIC MACHINE AND BELIEVES IT IS EITHER THE MODULE OR THE SENSOR IN THE SEAT, BUT CAN'T/WON'T GIVE AN EXACT CAUSE. WHEN I TRIED TO CONTACT GM THEY KEPT SAYING I WAS JUST GOING OFF WHAT THE INTERNET SAID AND NEEDED TO SEE A DEALER. JUST MADE IT FEEL LIKE THAT DIDN'T CARE ABOUT MY SAFETY OR THE SAFETY OF ANY ONE IN ONE OF THESE VEHICLES. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 05/04/17*LJ *TR

TAKATA RECALL MY 2007 CHEVY AVEO ON 9/ 10 2016 WEN I STARTED IT UP THE PASSENGER SIDE AIR BAG LIGHT SAYING THAT THE AIRBAG IS OFF! HAS JUST COME ON AND WILL NOT GO OFF! IT IS ON EVERY TIME I START THE CAR AND WILE DRIVING IT WITH OR WITH OUT A PASSENGER IN IT. THIS FROM WHAT I HAVE READ ON LINE MEANS THE AIR BAG IS BAD AND WILL NOT DEPLOY OR WILL DEPLOY FOR NO REASON THERE NEEDS TO BE A RECALL I HAVE READ MANY POST FROM OTHERS WITH THIS SAME PROBLEM IN THE 2007 CHEVY AVEO PLEASE RECALL THIS CAR BEFORE SOMEONE IS KILLED!!!

DASHBOARD CAUGHT FIRE WHILST CAR WAS PARKED FOR HOURS IN SECURE PARKING LOT. CAR FIRE WAS PUT OFF BY FIREFIGHTERS WHO CUT BATTERY AND CABLES BROKE WINDOWS IN ORDER TO STOP FIRE. NOW CAR DOES NOT TURN ON AT ALL AND DASHBOARD CENTER IS COMPLETELY MELTED.

LIGHT STAY ON ALWAYS.

FOR THE LAST WEEK, MY AIRBAG LIGHT HAS BEEN STAYING ON.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STARTED THE VEHICLE AND THE FRONT DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 5 MPH, THE VEHICLE STALLED AND THE STEERING WHEEL SEIZED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

I WAS INVOLVED IN AN ACCIDENT IN WHICH MY AIRBAG DIDN'T DEPLOY. I SUFFERED FROM A CONCUSSION, A HAIRLINE NASAL FRACTURE, AND I STILL HAVE ISSUES WITH MY NECK AND BACK TO THIS DAY. AS I HAVE NOTICED IT SEEMS TO BE A COMMON PROBLEM NOT ONLY WITH GM VEHICLES BUT AVEO'S AS WELL. WHEN IS A RECALL GOING TO BE ISSUED?

THE "PASSENGER AIR BAG" LIGHT ON THE DASH STAYS ON AND WON'T GO OFF.ALSO THE CHECK ENGINE LIGHT GOES ON AND OFF AND I HAD THE CODE CHECKED AND THEY SAID IS IS SOMETHING WITH THE FUEL.I HAVE HEARD OTHER COMPLAINTS ABOUT THE AIR BAG LIGHT AND IT MIGHT NOT BE DEPLOYED IN AN ACCIDENT.WHY DOES GENERAL MOTOR HAVE TO WAIT UNTIL PEOPLE GET KILLED IN THEIR CARS AND HAVE A CLASS ACTION LAWSUIT FILED BEFORE THEY DO THE RIGHT THING?WHY DON'T THEY RECALL THESE CARS AND FIX THE PROBLEMS WITH ELECTRICAL, AIR BAGS AND OTHER MANUFACTURING DEFECTS? MY CAR ONLY HAS ABOUT 21,000 MILES ON IT.CHEVROLET SHOULD BE ASHAMED TO SELL LEMONS AND SHOW TOTAL DISREGARD FOR THEIR CUSTOMERS LIVES.

MY CHEVY AVEO HAS HAD EL CERVICAL ISSUES FOR THE LAST 3 YEARS. I HAVE NOTICED THAT THERE IS A RECALL FOR THIS YEAR ON LIGHTING BUT MY VIN IS NOT ASSOCIATED WITH THIS RECALL AND I AM HAVING THE SAM ISSUES. AND NOW NOTHING ON THE DRIVERS SIDE OF MY CAR IS WORKING. BLINKERS, BRAKE LIGHT AND MORE. MY LIGHT FOR MY RADIO DO NOT WORK AS WELL. I HAVE 2 KIDS AND MY CAR IS NOT SAFE WITH THE ELECTRICAL ISSUES GOING ON WITH IT. I HAVE CALLED THE CHEVROLET GARAGE WHERE IT WAS PURCHASED AND ALL I AM BEING TOLD IS THERE ANYTHING S NOTHING THEY CAN DO CAUSE MY VIN IS NOT LISTED WITH THE RECALLS. I NEED MY CAR FIXED ESPECIALLY WITH IT HAVING THE SAME ISSUES AS THE RECALLED 2007 AVEOS.

SINCE THE DRL MODULE WAS REPLACED AS A RECALL ITEM, I HAVE HAD TO REPLACE EACH HEADLIGHT EVERY 2-8 WEEKS DUE TO BURNING OUT. THERE IS OBVIOUSLY A PROBLEM WITH THE SO-CALLED "REPAIR."

AIR BAG LIGHT STAYS ON DURATION WHEN I'M DRIVING. I TOOK IT TO THE DEALER AND THEY LOOKED AT IT AND THE LIGHT WAS OFF, BUT IT CAME BACK ON AGAIN AFTER 3 MONTHS.

I HAVE A 2007 CHEVY AVEO THAT I'VE HAD TO REPLACE THE DRIVERS SIDE > HEADLIGHT ON 5 TIMES IN THE 4 YRS I'VE HAD IT. ALSO, FOR THE PAST 2 YRS I > HAVEN'T HAD ANY RADIO LIGHTS. THERE'S A RECALL ON THE RUNNING LIGHT > MODULES FOR THIS YEAR, THE CARS CAN CATCH FIRE. RECALL NUMBER: 14V261000. THE MODULE ON MY CAR IS MELTED AND BLACK. I HAVE PICTURES OF THIS. I'VE CALLED CHEVY SEVERAL TIMES > BUT GET TOLD THERE'S NO RECALL ON MY CAR. DO I HAVE TO WAIT UNTIL THE CAR CATCHES FIRE TO DO BE ABLE TO DO SOMETHING ABOUT THIS?

MY AIRBAG LIGHT HAS BEEN ON FOR 3 MONTHS AND KNOW ONCE IT'S ON WON'T WORK IF AND WHEN I NEED IT. THIS A MAJOR SAFETY CONCERN AND SOMETHING THAT GM SHOULD BE ADDRESSING AS IT SEEMS TO BE A MANUFACTURER RELATED ISSUE. I TOOK MY VEHICLE DOWN TO MY LOCAL AUBURN CHEVEROLET AND THEY TOLD ME THEY WOULD HAVE TO REPLACE THE CLOCK ON MY DASHBOARD WHICH WORKS PERFECTLY FINE IN ORDER TO FIX THE AIRBAG PROBLEM. THIS DOESN'T SEEM RIGHT AND SHOULD BE A BIG RED FLAG. I WOULD LIKE TO SEE GM ADDRESS THESE ISSUES INSTEAD OF SWEEPING IT UNDER THEIR PROVERBIAL RUG. THEY ARE PUTTING CUSTOMERS AT GREAT RISK.

TL* THE CONTACT OWNED A 2007 CHEVROLET AVEO. WHILE MAKING A TURN AT 20 MPH, THE STEERING WHEEL LOCKED UP AND CAUSED THE VEHICLE TO SPIN OUT OF CONTROL. THE CONTACT CRASHED INTO AN ONCOMING VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE POLICE WAS CALLED TO THE SCENE AND A POLICE REPORT WAS FILED. THE CONTACT WAS UNINJURED; HOWEVER, THE PREGNANT DRIVER OF THE OTHER VEHICLE SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE CONTACT'S VEHICLE WAS DESTROYED AND TOWED TO A TOW YARD. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 126,859.

MY HEADLIGHTS ARE COMPLETELY BURNING OUT. I'VE CHANGED THEM A COUPLE TIMES AND MY FATHER TOLD ME MY WIRES KEEP BURNING OUT. ALSO MY FUEL SYSTEM KEEPS NOT GIVING ENOUGH FUEL. I KEEP GETTING A GAS LINE EMISSIONS WHEN I GET A CHECK ON MY CAR. CHECK ENGINE LIGHT ON THEN OFF A FEW DAYS LATER. ALSO MY SEATBELT IN THE BACK KEEP COMING OUT.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, ANOTHER VEHICLE CRASHED INTO THE SIDE OF HER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MULTIPLE BRUISES, CUTS ON AN UNKNOWN ARM AND LEG, ONE PASSENGER SUSTAINED A BROKEN NOSE, AND THE OTHER PASSENGER SUSTAINED A CUT BELOW THE EYE THAT ALL REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A IMPOUND LOT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE. ...UPDATED 01/25/16 *BF

BEEN SMELLING SOMETHING THAT SIMILAR TO PLASTIC BUT COULD NOT LOCATE ANYTHING BUT NOW I HAVE HAD MULTIPLE FUSES BLOWN FOR LOW BEAMS AND DRL. ULTIMATELY ALL DASHBOARD LIGHTS HAVE NOW GONE OUT ALONG WITH NO TAIL LIGHTS OR LOW BEAMS OR DRLS AT ALL AND NO HORN. DEALER IS SAYING THAT THE FUSE BLOCK IS GOING TO HAVE TO BE REPLACED BUT THE CAR ONLY HAS 83,000 AND NOTICED THAT THERE WAS A RECALL OUT THERE FOR THE DRL MODULE MELTING OR CATCHING ON FIRE BUT LOW AND BEHOLD MY CAR IS NOT ON THAT RECALL BUT LOOKS TO ME THAT IT SHOULD BE. IN ADDITION TO THE LIGHTS NOT WORKING CORRECTLY, THE GEAR SHIFTER WILL NOT COME OUT OF PARK AND THE KEY WILL NOT RELEASE FROM THE IGNITION SWITCH. I DID ALSO THINK IT ODD THAT MY KEY WOULD BE HOT TO TOUCH WHEN IT WOULD RELEASE ON PREVIOUS OCCASIONS LEADING UP TO THIS FAILURE. THE FIRST INSTANCE WHEN THE FAILURE INITIALLY STARTED WITH THE LIGHTS AND ALL THAT I COULD NOTICE WAS WHILE I WAS IN A PARKING LOT CRANKING THE CAR, BUT THE SECOND TIME AFTER CHANGING OUT THE FUSE, THE FUSE BLEW AGAIN AFTER I WAS DRIVING ON THE ROAD IN 5 O'CLOCK TRAFFIC.

I WOULD LIKE TO SUGGEST THE CHEVROLET AVEO ONLY HAS FRONTAL AIR BAGS AND SHOULD HAVE MORE AIR BAGS ESPECIALLY FOR SIDE COLLISIONS.

MY AIR BAG LIGHT KEEPS COMING ON. I TOOK IT TO A CHEVY DEALER (HUBER AUTOMOTIVE) NUMEROUS TIMES AND THEY CLAIMED TO FIX IT BUT IT KEEPS RETURNING ON

HAVE TO CHANGE HEADLIGHTS EVERY OTHER MONTH. WHEN I CHANGE ONE THE OTHER WENT OUT IMMEDIATELLY. SHOULD NOT HAVE TO CHANGE HEADLIGHT BULBS. TOLD DEALER HE SAID BY BULB FROM THEM?? I BOUGHT CORRECT BULB???? THIS HAS BEEN ONGOING SINCE I BOUGHT CAR IN 2010..IVE REPLACED OVER 7/8 TIMES.

WHILE DRIVING ON I95 MY RPMS DROPPED TO ZERO WITHOUT WARNING AND I WAS ABLE TO GET IT OFF THE ROAD. THE TOW TRUCK DRIVER SAID THE ENGINE WAS BLOWN. IT HAD 63,504 MILES ON IT AND THE REQUIRED MAINTENANCE HAD BEEN DONE LESS THAN 1600 MILES EARLIER. NO LIGHTS OR WARNING. LUCKILY I WAS ABLE TO GET IT OFF THE ROAD SAFELY.

THE DAYTIME RUNNING LIGHTS MODULE HAD A RECALL ON IT. I MADE AN APT AT THE LOCAL DEALER LAST WEEK AND MADE AN APPOINTMENT TODAY TO GET THE RECALL DONE. RECALL NUMBER IS 14236. THEY DID NOT FIX IT, SAID THEY DIDN'T HAVE THE PART EVEN THOUGH I CONTACTED THEM LAST WEEK AND GAVE THEM THE VIN AND THE RECALL NUMBER. I PICKED UP THE CAR WITH THE INTENT OF TAKING IT TO ANOTHER DEALER AND IT CAUGHT FIRE ON THE WAY HOME AND DESTROYED THE CAR.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING THE VEHICLE, THE IGNITION KEY BECAME EXTREMELY HOT. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE IGNITION SWITCH MODULE, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,000. UPDATED 09/18/15*LJ *CN

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT NOTICED AN ABNORMAL NOISE AND THE BRAKES FAILED. THE CONTACT BEGAN PUMPING THE BRAKE PEDAL AND THE VEHICLE WAS ABLE TO STOP. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED AN ABS SPEED SENSOR FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,800. MA 10/1

IN JUNE, 2011 MY SISTER WAS DRIVING A AVEO AND CLIPPED A ROAD SIGN ON THE RIGHT FRONT BUMPER, CONTINUED TO GO STRAIGHT OVER TO LEFT DOWN AN EMBANKMENT OF APPROX. 6 FT AND 40-45 MPH AND HIT STEERING WHEEL SO HARD THAT IT BROKE STEERING WHEEL AND BUSTED HER HEART KILLING HER INSTANTLY. I WENT TO SCHOOL FOR AUTOMOTIVE AND KNOW A LOT ABOUT CARS AND THIS ACCIDENT MAKES NO SENSE. I TOOK PICS OF EVERYTHING. EVEN THOUGH THE AIRBAG WAS OUT IT DIDN'T APPEAR TO HAVE INFLATED COMPLETELY AND THE CLOTHING MY SISTER HAD ON SHE SHOULD'VE HAD SOME SORT OF CUTS, BURNS,ABBRASIONS,BUT INSTEAD NOTHING BUT A BUSTED HEART. SHE ALSO HIT THE WINDSHIELD WITH HER FOREHEAD. I SAW NO SORT OF RESIDUE ON OR IN THE CAR AS EVIDENCE THAT THE AIRBAG DID WHAT IT WAS SUPPOSED TO. SHE SUSTAINED INJURIES COMMON TO THOSE INJURIES SUSTAINED FROM A CAR NOT EQUIPPED WITH AN AIRBAG. I WAS EVEN GOING TO SEE IF AVEO CAME WITH A BLACK BOX AND TO PULL IT OFF AND HAVE IT ANALYZED, BUT THE CAR GOT SENT TO JUNK YARD BEFORE I COULD DO THAT. NO CONCLUSION TO THIS WHOLE ORDEAL AND THIS GREAT LOSS WE'VE SUFFERED WILL EVER BRING HER BACK, BUT KNOWING WHAT I DO ABOUT CARS, I HAVE SO MANY QUESTIONS AND REALLY WANT THIS LOOKED INTO. I HAVE INC REPORTS PICS OF THE SCENE WITH AND WITHOUT THE CAR , AS WELL AS THE CAR BY ITSELF PANEL FOR PANEL PICS OF THE CAR. I KNOW THE AVEO IS NOT ONE OF THE VEHICLES NAMED ON THE NEWS, BUT THERE ARE OTHER SIMILAR CARS WITH THE SAME ISSUES.

I WAS DRIVING TO MY MOTHER'S HOUSE, THE CAR WAS NOT SHIFTING RIGHT AND THE ENGINE WAS WHINING, ALL OF A SUDDEN I SMELLED SMOKE AND SEEN FIRE UNDER THE HOOD. GM WOULD ONLY FIX THE HARNESS , THE VEHICLE WOULD START AGAIN BUT YOU COULD NOT DRIVE IT. NO POWER IN THE ENGINE. SO I HAD TO EAT $6400.00 DOLLARS I OWED AND TRADED IT WITH CARBONE AUTO IN YORKVILLE NEW YORK. THEY SOLD ME A CAR WITH THE ABS LIGHTS ON THE TRACTION LIGHTS ON, THE TIRE PRESSURE LIGHTS COME ON AND MY DOORS LOCK AND I HAVE TO CLIMB OVER TO THE OTHER SEAT TO GET OUT. THE SALESMAN KNEW THESE LIGHTS WERE ON BEFORE I SIGNED THE PAPERS AND MY CAR IS STILL NOT FIXED. THIS PAST WINTER I HAD NO HEAT AND GOT CAUGHT IN AN ICE STORM AND MY WINDOWS ICED RIGHT OVER I COULD NOT SEE AND HIT A POLE BY MY DRIVEWAY AND DENTED AND SCRATCH THE WHOLE RIGHT SIDE OF MY CAR. IT IS CARBONE AUTO THAT MADE IT SO MY AVEO CAUGHT FIRE. THEY WOULD NOT FIX IT, THE CAR WOULD NEVER SHIFT RIGHT THE MOTOR WOULD WHINE OUT AND THEY SAID OH THAT IS THE WAY A 1.6 LITER CAR RUNS. I HAD THE FIDELITY EXTRACT WARRANTY AND THEY WOULD NOT FIX THE AVEO I HAVE LOST 6400 DOLLARS ON THESE CARS AND IT IS THE DEALERS FAULT, WHAT DO I DO NOW MY 2008 IMPALA VIN IS [XXX] THE SALESMAN NAME IS [XXX] HE KNEW THESE LIGHTS WERE ON BEFORE I SIGNED THE PAPERS HE SAID IT WOULD BE FIXED. 8 MONTHS LATER STILL NOT FIXED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ON 7/6/2015 MY AIRBAG LIGHT CAME ON. WHEN I TOOK IT TO THE DEALER TO HAVE IT DIAGNOSED, THEY SAID IT WAS DUE TO A FAULTY OCCUPANT RESTRAINT CONTROL MODULE WHICH WOULD COST ALMOST $900 TO GET FIXED. I WAS TOLD BY THE DEALERSHIP IF I GOT INTO AN ACCIDENT, MY AIRBAGS WILL NOT DEPLOY DUE TO THIS FAILURE. I AM SHOCKED THIS MAJOR SAFETY ISSUE IS NOT COVERED BY GM AND HAS NOT BEEN RECALLED. MY VEHICLE WILL NOT PASS INSPECTION WITHOUT THIS PART.

1. ON JUNE 14, 2015, THE RED PASSENGER AIRBAG WARNING LIGHT CAME ON AND WILL NOT GO OFF. I CHECKED THE OWNERS MANUAL AND ALL IT SAID WAS THAT THERE MAY BE A PROBLEM WITH THE AIRBAG MODULE. NHTSA'S DATABASE STATES IN SERVICE BULLETIN #SB-12-09-41-001, ID #10047441 THAT BUICK/CHEVROLET IS PROVIDING INFORMATION REGARDING COUNTERFEIT VEHICLE AIRBAG MODULE FOR 2006-2010 AVEO (AND OTHER MODELS). ANY VEHICLE AIRBAG DEFECT OR COUNTERFEIT PART IS A MAJOR SAFETY PROBLEM! WHAT "INFORMATION" HAVE CHEVROLET/BUICK PROVIDED??? I AM EXTREMELY UPSET THAT ANY PASSENGER IN OUR 2007 CHEVROLET AVEO IS AT GREAT RISK! 2. IN NHTSA'S #14V2161000 RECALL SUBJECT: DAYTIME RUNNING LIGHT MODULE OVERHEATING INVOLVES 2007 CHEVROLET AVEO VEHICLES (& OTHER GM VEHICLES). THIS IS OF REAL CONCERN TO US BECAUSE WE HAVE NEVER BEEN CONTACTED BY CHEVROLET ABOUT THIS DEFECTIVE RUNNING LIGHT MODULE OVERHEATING AND POSSIBLY CAUSING A VEHICLE FIRE. WE PURCHASED OUR 2007 CHEVROLET AVEO IN 2009! PLEASE HELP. THE CONSUMER STATED THAT GM WILL NOT REPLACE THE DEFECTIVE AIR BAG SENSOR AND MODULE AS THERE WAS NO RECALL ISSUED FOR THIS DEFECT, AND THEY CAN NOT AFFORD TO FIX THE REPAIRS AT THE COST OF $1,697.48. *TR