2019 Chevrolet 6500

Routine

Owners filed 1 complaints about this vehicle with federal regulators, most often about the service brakes. It has been recalled 2 times.

Park away from buildings

NHTSA attached an advisory to a recall on this vehicle. Advisories apply to specific production runs — check your VIN with the manufacturer or at nhtsa.gov/recalls before driving it.

What fails

Component	Reports		Crashes	Fires	Injuries
Service Brakes	1		0	1	0

2 safety recalls

Part 573 reports

Service Brakes, Hydraulic › Brake Fluid Low Warning › Switch/Sensor/Float25V390000Park outside

Filed Jun 12, 202562,468 vehiclesGeneral Motors, Llc

Defect. General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.

Risk. An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N242482680. Vehicles in this recall that were previously repaired under 23V266 will need to have the new remedy completed.

Engine and Engine Cooling › Engine › Engine Control Module (ecu/Ecm) › Software21V346000

Filed May 13, 2021196 vehiclesGeneral Motors, Llc

Defect. General Motors, LLC (GM) is recalling certain 2019-2020 Chevrolet 6500HD vehicles. The engine control module (ECM) was calibrated incorrectly, allowing the vehicle to exceed the tires' maximum speed rating of 75 mph.

Risk. Tire failure can occur if the vehicle speed exceeds the maximum tire speed rating, increasing the risk of a crash.

Remedy. Dealers will update the ECM software, free of charge. Owner notification letters were mailed June 7, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202325530.

What owners reported

Newest filings

Service BrakesFire

Filed Oct 2, 2024AR

The brake switch nearly burned the truck to the ground could smell the electrical burning, and the brake pressure failed due to a brake line failure Chevrolet says, the switch was covered in recall. But the say the brake lines arent covered. These same brake lines were recalled on Chevrolet commercial van chassis. This could have resulted in serious injury or death if it hadn't have failed at very low speeds. This is urgent an needs to be addressed. This vehicle has been in arkansas, not up north with salt on the roads. The brake lines shouldn't fail on a truck that's less than 4 years old.

1 of 1 complaints, reproduced as filed.

Other Chevrolet models

All Chevrolet models →

Malibu 19,321 Silverado 1500 17,919 Impala 10,410 Tahoe 10,004 Equinox 9,119 Silverado 8,748 Suburban 8,007 Blazer 8,000 Cobalt 7,681 Trailblazer 7,137

Reading this record

No unusual pattern of severe incidents in the complaint record.

Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.

Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.

Most recent recall on file: Jun 12, 2025. Source: NHTSA Office of Defects Investigation.