1998 Audi A4

Defect. Volkswagen Group of America, Inc. (Audi) is recalling certain 1998 Audi A8 and 1997-1998 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflator may absorb moisture, causing the inflator to explode or the air bag cushion to underinflate.

Risk. The inflator could explode during air bag deployment, resulting in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.

Remedy. Dealers will replace the driver's air bag inflator with an alternative inflator of a different design, free of charge. Owner notification letters were sent September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BT. The vehicles in this recall were mistakenly omitted from recall 20V-056. All vehicle owners have already been notified by mail and informed that the remedy is available.

Defect. CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Remedy. AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Defect. CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.

Risk. IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.

Remedy. DEALERS WILL REPLACE THE TIE RODS.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A CONTROL VALVE IN THE VACUUM HOSE CONNECTING THE BRAKE BOOSTER TO THE INTAKE MANIFOLD MAY NOT OPEN OR CLOSE FULLY AT TEMPERATURES BELOW -4 F UNDER CERTAIN DRIVING CONDITIONS.

Risk. THIS CONDITION COULD CAUSE INSUFFICIENT VACUUM TO BE PROVIDED TO THE BRAKE BOOSTER.

Remedy. DEALERS WILL INSTALL A VACUUM BY-PASS SYSTEM INTO VEHICLES OPERATED IN THESE STATES WHICH IS DESIGNED TO PROVIDE SUFFICIENT VACUUM FOR FULL BRAKE ASSIST UNDER ALL WEATHER CONDITIONS.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE ENGINE BACKFIRES DURING A COLD-START, AN AIR SCREEN WHICH IS LOOSELY SEATED IN THE AIR FLOW METER CAN BECOME DAMAGED.

Risk. SCREEN PIECES COULD ENTER THE INTAKE AIR FLOW SYSTEM AND PREVENT THE THROTTLE PLATE FROM RETURNING TO ITS FULL IDLE POSITION.

Remedy. DEALERS WILL INSTALL A RETAINING RING TO HOLD THE AIR SCREEN IN PLACE.

Recall 69bt was not accomplished at McDaniels Audi of Charleston dealer. They indicated they had replaced airbag with 8D0898201A kit.

The contact owned a 1998 Audi A4. The contact stated that while driving at 35-40 MPH with his 12-year-old son sitting in the passenger seat, he crashed into another vehicle. The air bags failed to deploy. There were no warning lights illuminated. The contact did not sustain any injuries, however, his son sustained a broken rib and was transported to the hospital. A police report was filed. The vehicle was towed to a tow lot, where it was totaled. The contact recently received a recall notice for NHTSA Campaign Number: 20V056000 (AIR BAGS). The dealer and the manufacturer were not made aware of the failure. The approximate failure mileage was 80,000.

Takata recall. The contact owns a 1998 Audi A4. The contact received notification of NHTSA Campaign Number: 20V056000 (Air Bags) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.

TL* THE CONTACT OWNS A 1998 AUDI A4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V056000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. A DEALER WAS NOT CONTACTED. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

THE AIRBAG FAULT LIGHT AND ABS LIGHT HAVE BEEN ON EVER SINCE I HAD THE VEHICLE, THINKING THAT IT MAY BE A FAULT BY THE MANUFACTURER AS SEEING VERY COMMON PROBLEMS IN MANY WEBSITES. ANOTHER MAIN CONCERNED IS THE FAULT OF THE MANUFACTURER'S ENGINE DESIGN CAUSING ENGINE DAMAGE FROM OIL SLUDGE. MY CONCERN IS FOR FUTURE PREVENTION MEASURES.

THE AMBER ABS WARNING LIGHT GLOWS WHILE THE RED BRAKE LIGHT BLINKS. I UNDERSTAND NEWER AUDI MODELS HAVE JUST BEEN RECALLED FOR ABS ISSUES, BUT MY 1998 A4 WAS NOT INCLUDED IN THE RECALL. BRAKING APPEARS NORMAL, AND WARNING LIGHT ILLUMINATION IS SPORADIC.

TL* THE CONTACT OWNS A 1998 AUDI A4. THE CONTACT HAD THE TURBO REPLACED IN THE VEHICLE; HOWEVER, MONTHS LATER, THE VEHICLE STALLED. THE CONTACT FELT UNSAFE IN THE VEHICLE BECAUSE SHE BELIEVED THAT A CRASH COULD OCCUR DUE TO THE STALLING. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.

TL* THE CONTACT OWNS A 1998 AUDI A4. THE CONTACT STATED THAT HE SMELLED A BURNING WIRE ODOR UPON STARTING THE VEHICLE. THE CONTACT ALSO STATED THAT THE WINDSHIELD WIPERS AND VARIOUS OTHER ELECTRICAL COMPONENTS WERE NOT FUNCTIONING. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 00V317000 (ELECTRICAL SYSTEM:IGNITION:SWITCH). THE FAILURE MILEAGE WAS 201,000.

TL* THE CONTACT OWNS A 1998 AUDI A4. THE CONTACT STATED THAT THE AMBER REFLECTOR HEADLIGHTS ILLUMINATED POORLY AND DECREASED VISION. THE DEALER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE TO REPAIR THE VEHICLE BECAUSE THE VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 06E049000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 190,000.

I HAVE HAD A RECENT DISCUSSION WITH AUDI CUSTOMER SERVICE MANAGER IN WAYZATA, MN AT 11:55AM. THIS IS REGARDING A DEFECT IN MY MODEL YEAR 1998 AUDI A4 2.8., OR AUDI A4 2.8 MANUFACTURED JUNE OF 1997. I RESEARCHED THE WEB AND SAW HUNDREDS OF SIMILAR COMPLAINTS REGARDING THE LIGHT SWITCH. I TURNED MY LIGHT SWITCH ON AND THE LOW BEAM AND HIGH BEAM DO NOT WORK. THE TEMPORARY HIGH BEAM WORKS. I SAW MANY OTHER 1998 AUDI OWNERS WITH THE SAME PROBLEM; EVEN MORE SIMILAR WITH THE FACT THAT WE HAD A 1998 MODEL YEAR CAR THAT WAS MANUFACTURED IN 1997. THE RECALL CAMPAIGN IS A LITTLE AMBIGUOUS STATING MODEL YEARS AND MANUFACTURE DATES. MY CAR FALLS WITHIN THE MANUFACTURE DATE BUT NOT THE RECALL DATE. THE RECALL IS OPEN HOWEVER 1998 MODELS, WHICH ARE BEING AFFECTED BY THIS ISSUE, ARE NOT INCLUDED. IT IS OBVIOUS THAT CARS MANUFACTURED PRIOR TO AUGUST OF 1997 EVEN THOUGH THEY ARE MODEL YEAR 1998 HAVE THE SAME PROBLEM. *TR

ON A 1998 A4 QUATTRO AUDI, IT IS THE 2ND TIME THAT THE HEADLIGHTS SWITCH FAILS, THE FIRST TIME WAS 6 MONTHS AGO AND HAVE TO REPLACE THE ENTIRE STEERING WHEEL COLUMN SWITCH PACKAGE. THIS IS THE SECOND TIME, AND THIS TIME I WAS ON A HIGHWAY AROUND 11:00 PM WITH NO HEADLIGHTS AT ALL, IN THIS CAR IF THE HEADLIGHTS DON'T WORK, ALSO THE FOG LIGHTS DON'T WORK TOO, SO SUDDENLY YOU END AT THE MIDDLE OF THE NIGHT ON A HIGHWAY WITH NO LIGHTS AT ALL. THIS DEFINITELY IS A HIGH RISK SITUATION BECAUSE YOU CAN NOT DRIVE WITH OUT HEADLIGHTS IT IS LIKE BLIND DRIVING. I BEEN SEARCHING ON THE WEB AND IT LOOKS LIKE A VERY COMMON FAILURE ON THIS CAR BUT THERE IS NO RECALL AT ALL FOR THIS YET. *KB

THE ANTI LOCK BRAKE CONTROL MODULATOR UNIT FAILED, AND NOW I HAVE BRAKES THAT DO NOT WORK. AT THE SLIGHTEST PEDAL PRESSURE, ALL 4 WHEELS WILL HAVE A STRONG PULSATING, GIVING YOU ABOUT 1/3 OF THE BRAKING PRESSURE THAT IS NEEDED. VOLKSWAGENS USED A NEARLY IDENTICAL PART, AND THEIR ABS CONTROLLER IS UNDER RECALL, I DO NOT UNDERSTAND WHY NHTSA, CANNOT FORCE AUDI OF AMERICA TO DO THE SAME. THANK YOU *TR

FAULTY ABS MODULE IN MY 1998 AUDI A4 1.8T. THE ELECTRICAL COMPONENT TO THE ABS SYSTEM FAILS IN MANY OF THESE SIMILAR YEAR AUDIS AND VWS, AND IT APPEARS TO BE A BIG PROBLEM. THE FAILURE OF THIS COMPONENT CAN CAUSE DEADLY ACCIDENTS, AND SHOULD BE ADDRESSED BY AUDI. *TR

TL* THE CONTACT OWNS A 1998 AUDI A4. WHILE THE VEHICLE WAS PARKED, HE NOTICE THE ABS LIGHT WAS ON AND THE BRAKE LIGHT WAS FLASHING ON THE DASHBOARD. THE CONTACT STATED THAT HE WAS A MECHANIC AND TRIED TO SCAN INFORMATION FROM THE ABS MODULAR AND WAS UNABLE TOO. HE STATED HE WAS UNABLE TO REPAIR THE FAILURE. THE VEHICLE WAS PURCHASED USED SEPTEMBER 28, 2005. THE CONTACT PURCHASED THE VEHICLE USED WITH THE FAILURE. THE FAILURE MILEAGE WAS 133,500 AND THE CURRENT MILEAGE WAS 270,000.

THE ABS CONTROL UNIT ON MY AUDI A4 FAILED AFTER 95,000 MILES. I HAVE NO ANTI-LOCK BRAKING AND AUDI HAS DENIED ANY RESPONSIBILITY FOR THE PART SINCE IT IS OUT OF WARRANTY. SEARCHING THROUGH AUDI FORUMS I FOUND THIS FAILURE TO BE VERY COMMON AND EVERYONE HAD NO ABS UNTIL THE CONTROL UNIT WAS REPLACED WHICH COST AN AVERAGE OF $1500+. THERE WERE NO EVENTS THAT LEAD UP TO THE FAILURE, I STARTED THE CAR ONE DAY AND THE ABS AND BRAKE LIGHT STARTED FLASHING ON MY DASH. I TESTED THE ABS AND FOUND THAT IT INDEED DOES NOT PREVENT MY BRAKES FROM LOCKING UP. NEARLY THREE YEARS LATER, THE PART HAS NOT BEEN FIXED DUE TO THE HIGH COST TO REPAIR IT.

1998 AUDI A4 2.8 - DRIVING ALONG HIGHWAY, IN 7 DEGREE TEMP, CAR STARTED ACCELERATING ( FEELS LIKE IT IS DRIVING ITSELF) EVEN AFTER FOOT WAS REMOVED FROM PEDAL AND FULL FORCE HAD TO BE APPLIED TO BRAKE TO STOP THE CAR AT WHICH POINT IT WENT INTO HIGH REV AND ENGINE WAS IMMEDIATELY TURNED OFF. MECHANIC COULD FIND NOTHING WRONG. THIS CAR ALSO HAD 2 SIMILAR INCIDENT (ONCE WHEN NEW) AND ONCE A NUMBER OF YEARS AGO. AFTER MUCH BACK AND FORTH WITH AUDI, THEY TOOK THE CAR IN, AND SAID THEY COULD FIND NOTHING WRONG. AS A PRECAUTION I HAD THE CRUISE CONTROL DISCONNECTED AND THE THROTTLE BODY CABLE REPLACED SO FELT THE CAR WAS SAFE. (ALL AT MY EXPENSE) *TR

CONTROL ARM ON MY 1998 AUDI A4 FRACTURED WHEN PULLING OUT OF A PARKING LOT, CAUSING COMPLETE LOSS OF STEERING CONTROL. AUDI TECHNICAL SERVICE BULLETIN NHTSA # 10016418, #11242004 COMPONENT DESCRIPTION: 22. SUSPENSION:FRONT:CONTROL ARM:LOWER ARM BULLETIN NUMBER: 11242004 BULLETIN DATE: NOV 2004 VEHICLE: 1,998 AUDI A4 SUMMARY: SERVICE ACTION JE CAMPAIGN-CHECK/REPLACE FRONT SUSPENSION LOWER CONTROL ARMS. AUDI HAS FOUND THAT IN RARE CASES, ONE OR BOTH FRONT SUSPENSION LOWER CONTROL ARMS ON AFFECTED VEHICLES CAN EXHIBIT WEAR, EVEN THOUGH THE DAMAGE TO THE RUBBER BO ( NHTSA ITEM NUMBER - 10016418 ). *TR

TL* THE CONTACT OWNS A 1998 AUDI A4. WHILE DRIVING 45 MPH THE ENGINE STALLED WITHOUT ANY PRIOR WARNINGS. THE VEHICLE WAS TOWED TO HER PLACE OF RESIDENCE. A MECHANIC STATED THAT THE TIMING CHAIN HAD FRACTURED WHICH CAUSED THE ENGINE TO STALL. SHE CONTACTED THE MANUFACTURER IN REFERENCE TO A CLASS ACTION LAWSUIT REGARDING TIMING CHAIN FAILURE. A REPRESENTATIVE STATED THAT BECAUSE THE VEHICLE EXCEEDED 70,000 MILES SHE WAS INELIGIBLE FOR A FREE REMEDY. HOWEVER SHE NOTED THAT THE OWNERS MANUAL STATED THAT THE TIMING CHAIN SHOULD BE REPLACED AT 90,000. SHE WAS IN THE PROCESS OF HAVING THE ENGINE REBUILT BY A INDEPENDENT TECHNICIAN. THE FAILURE AND CURRENT MILEAGES WERE 74,000.

TIE ROD FAILURE RESULTING IS A COMPROMISE OF STEERING CONTROL AS DESCRIBED IN NHTSA 99V248000. *TR

HI. I HAVE A 1998 AUDI A4 6 CYLINDER QUATRO5 SPEED. IT HAS 97K MILES. THE ABS LIGHT HAS COME ON AND I UNDERSTAND THAT IT IS A COMMON FAILURE. APPROX. $1700 REPAIR AT THE DEALER. I UNDERSTAND THAT VW HAS HAD A RECALL FOR EXACTLY THE SAME ISSUE WITH EXACTLY THE SAME PART. IT SEEMS LIKE SUCH A RECALL SHOULD EXTEND THE AUDI USING THE SAME PART, WHICH HAS A HIGH FAILURE RATE. IT SEEMS TO BE A VERY SERIOUS SAFETY ISSUE AND SHOULD BE RECALLED AND REPAIRED BY AUDI. CAN YOU HELP ME UNDERSTAND WHY A PART AND SAFETY ISSUE WOULD BE RECALLED FOR VW BUT NOT FOR AUDI? HERE IS A LINK TO FURTHER INFORMATION: THANKS! HTTP://AUDI-VW-ABS-RECALL.BLOGSPOT.COM/2005/07/AUDI-AND-VW-PLEASE-RECALL-CARS-BETWEEN.HTML. *TR