2006 Yamaha XV19

Defect. ON CERTAIN MOTORCYCLES, WHEN EQUIPPED WITH A WINDSHIELD, THE THROTTLE CABLES CAN KINK AT THE GUIDE BRACKET LOCATED AT THE STEERING HEAD WHEN THE HANDLEBAR IS TURNED ALL THE WAY TO THE LEFT. IN THIS POSITION, A KINKED CABLE CAN CAUSE EITHER A STICKLY THROTTLE FEELING OR PREVENT THE THROTTLE FROM RETURNING TO THE CLOSED POSITION.

Risk. IF THE RIDER TURNS THE HANDLEBAR TO THE FULL LEFT LOCK DURING A SLOW-SPEED MANEUVER, THIS STICKY/BINDING THROTTLE FEELING COULD RESULT IN REDUCED VEHICLE CONTROL, WHICH COULD CAUSE A CRASH RESULTING IN INJURY OR DEATH.

Remedy. DEALERS WILL REPLACE THE GUIDE BRACKET WITH A NEW ONE THAT HAS AN ADDITIONAL GUIDE TO PREVENT THE THROTTLE CABLES FROM KINKING. THE RECALL BEGAN ON APRIL 19, 2007. OWNERS MAY CONTACT YAMAHA AT 1-800-962-7926.

I AM GETTING A LOUD CLACKING AND WHINE FROM THE TRANSMISSION IN 3RD GEAR. THIS IS THE ONLY GEAR THAT IS DOING IT AND IT SOUNDS LIKE IT IS COMING APART! I AM AFRAID TO RIDE IT VERY FAR BECAUSE IT MIGHT BRAKE AND LOCK UP MY DRIVE TRAIN WHEN I AM AT SPEED ON THE INTERSTATE AND IT CAUSE ME TO CRASH! THIS HAPPENS WHEN I AM GOING THROUGH THE GEARS, 1ST TO 2ND THEN TO 3RD AND ALL HELL BREAKS LOOSE. IF I GO ON TO 4TH GEAR IT STOPS AND THE SAME WITH 5TH GEAR. I HAVE BEEN TOLD THAT IF THIS GEAR BREAKS WHILE I AM RIDING, TO BE PREPARED FOR THE TRANSMISSION TO COMPLETELY LOCK UP AND IT MOST LIKELY WILL PUT ME DOWN AND MAKE ME CRASH. THIS HAS BEEN GOING ON NOW FOR ABOUT A MONTH AND THERE IS ONLY 40K ON THIS BIKE AND NO REASON THE TRANSMISSION SHOULD BE GOING OUT. I HAVE BEEN RIDING MOTORCYCLES FOR 50YRS AND HAVE NEVER HAD A TRANSMISSION PROBLEM!

WHILE RIDING AT LOW RPM'S IN 3RD GEAR A LOUD "CLACKING" IS PRESENT. I CONTACTED MY YAMAHA DEALER AND WAS ADVISED THAT THERE IS A "REPLACEMENT" 3RD GEAR LISTED FOR THAT MODEL AND YEAR, HOWEVER, YAMAHA IS NOT ACKNOWLEDGING THE KNOWN DEFECT WHICH COULD RESULT IN CATASTROPHIC LOSS OF POWER. *TR

I BEGAN TO NOTICE A WHINING FROM THE TRANSMISSION IN THIRD GEAR. MINOR AT FIRST BUT HAS GOTTEN PROGRESSIVELY LOUDER OVER THE LAST MONTH. LOOKED THE PROBLEM UP ON SEVERAL YAMAHA ROADLINER / STRATOLINER FORUMS AND FOUND OUT THAT MANY OTHERS ARE HAVING THE SAME AND WORSE PROBLEMS INCLUDING LOOSING THIRD GEAR. I HAVE READ THAT SOME HAVE TRIED TO GET YAMAHA TO RECALL THESE BUT NO RECALL TO DATE AS OF YET. I WILL HAVE TO STOP RIDING MY BIKE AS I DON'T WANT TO LOOSE THIRD OUT ON A TRIP. I HAVE ALSO RED THAT YAMAHA HAS COME UP WITH A REPLACEMENT GEAR THAT SOLVES THE PROBLEM BUT AS OF NOW BIG MONEY IS REQUIRED TO REPAIR THIS DESIGN FLAW. *TR

WHILE RIDING MY 2006 YAMAHA ROADLINER 1900,I NOTICED A KNOCK IN THIRD GEAR AS I WAS GOING SLOW. NEXT RIDE IT GOT LOUDER,AND A WHINING STARTED COMING FROM THE TRANSMISSION MAINTENANCE WAS PERFORMED CORRECTLY SINCE I BOUGHT IT BRAND NEW. THE KNOCK IS SO BAD I CAN'T RIDE IT, I HAVE HEARD OF MANY OTHERS WITH THIS PROBLEM, AT OR AROUND 20,000 MILES, MINE HAS 21,256.I HAVE CONTACTED YAMAHA FOR HELP, AND THEY SAID THERE'S NOTHING THEY CAN DO ABOUT IT SINCE ITS OUT OF WARRANTY . CAN YOU HELP ? I HEAR ITS A VERY EXPENSIVE FIX, AND YAMAHA HAS ALREADY CHANGED THE GEAR ON THE NEWER BIKES BECAUSE OF THIS PROBLEM, SHOULDN'T THERE BE A RECALL ? THANK YOU . *TR

I WAS DOWNSHIFTING AND HEARD A REALLY LOAD NOISE FROM THE TRANSMISSION. THE NOISE IS PREVALENT IN 3 RD GEAR ONLY WHEN DOWNSHIFTING. IT IS WORSE AS IT CAN BE HEARD WHEN ACCELERATING NOW. ONLY 3RD GEAR IS EFFECTED. I CANNOT USE 3RD GEAR AT ALL AT THIS TIME. THE NOISE CAN BE HEARD WHEN RIDING THE BIKE OR STANDING NEAR WHEN DRIVING BY. *TR

TL* THE CONTACT OWNS A 2006 YAMAHA XV19 MOTORCYCLE. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE EXHIBITED A LOAD NOISE WHILE IN THIRD GEAR. THE CONTACT STATED THE VEHICLE DID NOT STALL OR HAVE A DEFECT BUT HE WAS CONCERNED THAT THERE COULD HAVE BEEN AN ISSUE WITH THE TRANSMISSION. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR A LOCAL MECHANIC FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 28,000.

LOUD GROWLING SOUND WHEN RUNNING THROUGH TOWN IN THIRD GEAR.

THIRD GEAR IS HOWLING CAUSED BY DEFECTIVE PINION PARTS WITHIN THE TRANSMISSION. COMMON PROBLEM ON YAMAHA ROADLINERS/STRATOLINERS XV1900'S AS MULTIPLE PEOPLE HAVE REPORTED THE SAME ISSUE. YAMAHA SHOULD BE FORCED TO RECALL TO CORRECT MANUFACTURING ISSUES. I'M WORRIED THAT THE TRANSMISSION WILL LOCK UP AT SPEED CAUSING A CATASTROPHIC CRASH. GEAR, 3RD PINION, P/N 99999-03864-00 (REPLACES 1D7-17131-01-00) . *TR

THIS IS A FOLLOW UP COMPLAINT FOR THE SAME ISSUE. SEE COMPLAINTS #10396064 FILED 15 APRIL 2011 AND #10410158 FILED 30 JUNE 2011. SINCE THESE TWO COMPLAINTS I HAVE HAD THE BIKE BACK TO THE DEALER TWICE AND HAD MORE THINGS CHECKED.AND STILL THE MOTORCYCLE CONTINUES TO DIE RANDOMLY. TODAY, AUGUST 15 2011 I TOOK MY GRANDDAUGHTER FOR A RIDE TO BREAKFAST AND A LITTLE SIGHTSEEING LOCALLY AND 3 TIMES IT DIED ON US WHEN COMING TO STOPS AT TRAFFIC LIGHTS OR STOP SIGNS. NOW WHEN I'M BY MYSELF I CAN DEAL WITH THE PROBLEM BUT WHEN I'VE GOT MY GRANDDAUGHTER WITH ME WERE TALKING A WHOLE NEW SAFETY CONCERN WHICH IS TOTALLY UNACCEPTABLE. SINCE AUGUST 2 2011 MY BIKE HAS DIED 12 TIMES IN FIVE DAYS OF RIDING. I DON'T KNOW HOW MUCH MORE DETAIL I CAN GIVE THAN WHAT I'VE DETAILED IN THE PREVIOUS TWO COMPLAINTS. AS I'VE ALSO STATED IN MY PREVIOUS COMPLAINTS, I'VE BEEN TRACKING FELLOW RIDERS WITH TH THIS SAME PROBLEM AND AM NOW UP TO 59 RIDERS OF THE SAME MOTORCYCLE THAT ARE HAVING THIS SAME PROBLEM. INITIALLY THE PROBLEM SEEMED TO BE CONFINED TO THE 2006 MODEL YEARS BUT I'VE GOT MODELS THROUGH 2009 WITH THE 2007 MODELS INCREASING IN NUMBERS REPORTED TO ME. I HOPE SOMEONE DOESN'T HAVE TO GET REAR ENDED AND DIE BEFORE THIS GETS RECTIFIED. *TR

MY MOTORCYCLE (2006 YAMAHA XV19 STRATOLINER) IS HAVING A PROBLEM WITH 3RD GEAR MAKING A LOUD NOISE. THE YAMAHA DEALERSHIP I TOOK IT TO BE REPAIRED SAID THAT IT IS A KNOWN PROBLEM WITH MY MODEL AND YEAR BIKE. THE PARTS THAT I KNOW THAT WERE REPLACED WERE THE MIDDLE SHAFT PINION GEAR AND 3RD GEAR AND SEALS. *TR

MY 2006 YAMAHA ROADLINER STALLS ALMOST EVERY TIME I STOP AT A RED LIGHT. IT HAPPENS WHEN I LET UP ON THE THROTTLE AND PUSH IN THE CLUTCH. MY WIFE AND I HAVE ALMOST BEEN RUN OVER 20 OR 30 TIMES AND ALMOST TURNED THE BIKE OVER MANY TIMES BECAUSE OF THIS. I ASKED MY YAMAHA DEALER TO HELP ME BUT THEY SAY THERE IS NO PROBLEM ON THE BIKE. IT LOOKS TO ME LIKE THE ONLY WAY TO FIX THIS PROBLEM IS TO GET RID OF THE BIKE AND NEVER BUY ANOTHER YAMAHA. *TR

MOTORCYCLE INTERMITTENTLY STALLS OR WILL NOT START. *TT

THIS IS A FOLLOW UP COMPLAINT WITH NHTSA. TO REITERATE THAT COMPLAINT SEE COMPLAINT ID: 10396064 SINCE FILING THAT COMPLAINT I HAVE HAD THE BIKE BACK TO THE DEALER FOR MORE ADJUSTMENTS AND CHECKING WHICH AT FIRST SEEM TO WORK BUT WITHIN A FEW DAYS THE PROBLEM RETURNS. I JUST RETURNED FROM A 6700 MILE TRIP ACROSS THE COUNTRY AND MY BIKE HAD BEEN RUNNING WELL WITH NO STALLING SINCE THE LAST ADJUSTMENT A COUPLE WEEKS EARLIER. FOUR DAYS INTO THE TRIP I WAS DOWN IN LOUISIANA WHEN IT DIED SEVERAL TIMES OVER A FEW HOURS TIME. ONE OF THE WAYS TO SEEMINGLY STOP THE BIKE FROM QUITTING LIKE IT DOES IS TO DISCONNECT THE CLUTCH LEVER SAFETY INTERLOCK SWITCH. THIS SWITCH KEEPS THE BIKE FROM BEING STARTED WHEN THE BIKE IS IN GEAR BUT WILL ALLOW IT TO START IF THE CLUTCH LEVER IS PULLED IN. WHEN THE SWITCH IS DISCONNECTED YOU MUST MAKE SURE THE BIKE IS IN NEUTRAL TO START IT BUT IT HAS KEPT THE BIKE FROM DYING WHEN COMING TO A STOP....UNTIL I WAS ON MY TRIP. AFTER DISCONNECTING THE SWITCH AS I AND OTHERS HAVE BEEN DOING FOR THE LAST COUPLE YEARS THE BIKE DIED FOR THE FIRST TIME JUST AS IF IT WAS STILL CONNECTED. WHEN YOUR SITTING AT AN INTERSECTION OR AT A FREEWAY OFF RAMP WAITING FOR A LIGHT TO CHANGE AND THE BIKE DIES LIKE IT DOES YOU MUST SHUT THE BIKE OFF COMPLETELY AND THEN TURN THE KEY BACK ON AND LET THE BIKE GO THROUGH IT'S STARTUP DIAGNOSTICS WHICH TAKE ABOUT A MINUTE OR LONGER. OTHER CARS COMING OFF FREEWAYS DON'T KNOW YOUR DEAD ON THE ROAD AND A FEW OF US HAVE COME CLOSE TO BEING

MY MOTORCYCLE ENGINE STOPS RUNNING UNEXPECTEDLY AND WITHOUT WARNING. IT HAPPENS APPROXIMATELY EVERY 50 MILES OR SO. THE WORST CONSEQUENCE SO FAR IS THAT IT MADE ME FALL TO THE PAVEMENT RESULTING IN INJURIES TO MY KNEES, ELBOW AND BACK. MY BIKE CONTINUES TO STALL WITHOUT WARNING AND I HAVE NOT BEEN ABLE TO RECTIFY THIS SITUATION. *TR

I HAVE A 2006 YAMAHA STAR STRATOLINER THAT STALLS WHENEVER I ENGAGE THE CLUTCH AND DOWNSHIFT WHEN APPROACHING A STOP CREATING A HAZARD AT A BUSY INTERSECTION. INCIDENT AS BEEN 2007 TO PRESENT. *TR

MY 2006 YAMAHA STRATOLINER XV1900 STALLS WHEN I PULL THE CLUTCH COMING TO A STOP. THIS HAS BEEN HAPPENING SINCE I FIRST GOT MY BIKE. IT HAPPENS REGARDLESS OF WHETHER OR NOT THE BIKE IS HOT OR COLD. I CALLED YAMAHA TO COMPLAIN AS IT STALLED WHILE COMING TO A STOP AND CAUSING AN EXTREMELY UNSAFE SITUATION FOR ME AND MY PASSENGER. I WAS TOLD THAT THEY WERE NOT AWARE OF A PROBLEM, YET WHEN I TOOK THE BIKE TO THE DEALER, THERE WAS A TECH BULLETIN DESCRIBING THE PROBLEM AND SPECULATING ON POSSIBLE RESOLUTIONS. MANY OTHER OWNERS HAVE COMPLAINED OF THIS ISSUE. MANY SPECULATE THAT IT IS A DEFECTIVE CLUTCH SWITCH AND THE METHOD BY WHICH THE CLUTCH SWITCH INTERACTS WITH THE ECU. *TR

YAMAHA ROADLINER XV 1900 I HAVE A 2006 YAMAHA ROADLINER XV1900 ON WHICH THE ENGINE WILL DIE COMPLETELY WHEN COMING TO A STOP FREQUENTLY AFTER PULLING IN THE CLUTCH. THIS HAS BEEN HAPPENING SINCE I FIRST BOUGHT THE BIKE BACK IN NOVEMBER OF 2006. IN FACT IT HAPPENED THE FIRST DAY I DROVE IT HOME BUT I THOUGHT I WAS OUT OF GAS AND AFTER FILLING UP IT DID NOT OCCUR FOR SOME TIME AFTER. AS THE MILES ROLLED UP THIS PROBLEM WOULD OCCUR RANDOMLY WHEN COMING TO A STOP SUCH AS EXITING A FREEWAY OR PULLING UP TO A STOPLIGHT. ONE DAY I WAS ACTUALLY ABLE TO REPLICATE THE ACTION OVER AND OVER AGAIN OVER THE COURSE OF MY DAYS RIDE. I BELONG TO AN ONLINE COMMUNITY OF FELLOW STAR MOTORCYCLE OWNERS OF SPECIFICALLY THE YAMAHA STRATOLINER, ROADLINER AND RAIDER MODELS. THE BIKES USE IDENTICAL COMPONENTS AND WE HAVE NOTED THAT THERE ARE A SIGNIFICANT NUMBER OF US WHO HAVE EXPERIENCED THIS EXACT SAME PROBLEM. IN THE COURSE OF OUR DISCUSSIONS ABOUT IT WE HAVE NOTED THE FOLLOWING: #1 - IT ALWAYS HAPPENS WHEN COMING TO A STOP WHETHER DOWN SHIFTING OR NOT. #2 - IF THE CLUTCH SAFETY INTERLOCK SWITCH IS REMOVED FROM THE SYSTEM THE PROBLEM NO LONGER OCCURS. THIS WAS DISCOVERED BY MYSELF AND A COUPLE OTHER FELLOWS WHOSE SWITCHES HAD FAILED AND WERE NO LONGER FUNCTIONING PROPERLY. WITH A FAILED SWITCH THE BIKE WILL NO LONGER START UNLESS IT IS NEUTRAL AND THE KICKSTAND IS RAISED. SINCE THE SWITCH CONTROLS THE ELECTRONIC CONTROL MODULE THIS MEANS THAT THERE IS SOME KIND OF ISSUE WITH THE MAPPING THAT YAMAHA

ENGINE STALLED AND CUT OFF AT ~25 MPH THREE TIMES WHEN DECELERATING IN MAR 2008 (~5,500 MILES), OCT 2009 (~11,500 MILES), AND APR 2011(~15,200 MILES), JEOPARDIZING THE OPERATOR'S SAFETY. PER YAMAHA/STAR ROADLINER OWNERS BLOG THIS IS A COMMON PROBLEM WITH THIS MODEL AND REQUIRES MANUAL UPWARD ADJUSTMENT OF ENGINE IDLE RPM.

I HAVE A 2006 YAMAHA ROADLINER XV1900 ON WHICH THE ENGINE WILL DIE COMPLETELY WHEN COMING TO A STOP FREQUENTLY AFTER PULLING IN THE CLUTCH. THIS HAS BEEN HAPPENING SINCE I FIRST BOUGHT THE BIKE BACK IN NOVEMBER OF 2006. IN FACT IT HAPPENED THE FIRST DAY I DROVE IT HOME BUT I THOUGHT I WAS OUT OF GAS AND AFTER FILLING UP IT DID NOT OCCUR FOR SOME TIME AFTER. AS THE MILES ROLLED UP THIS PROBLEM WOULD OCCUR RANDOMLY WHEN COMING TO A STOP SUCH AS EXITING A FREEWAY OR PULLING UP TO A STOPLIGHT. ONE DAY I WAS ACTUALLY ABLE TO REPLICATE THE ACTION OVER AND OVER AGAIN OVER THE COURSE OF MY DAYS RIDE. I BELONG TO AN ONLINE COMMUNITY OF FELLOW STAR MOTORCYCLE OWNERS OF SPECIFICALLY THE YAMAHA STRATOLINER, ROADLINER AND RAIDER MODELS. THE BIKES USE IDENTICAL COMPONENTS AND WE HAVE NOTED THAT THERE ARE A SIGNIFICANT NUMBER OF US WHO HAVE EXPERIENCED THIS EXACT SAME PROBLEM. IN THE COURSE OF OUR DISCUSSIONS ABOUT IT WE HAVE NOTED THE FOLLOWING: #1 - IT ALWAYS HAPPENS WHEN COMING TO A STOP WHETHER DOWN SHIFTING OR NOT. #2 - IF THE CLUTCH SAFETY INTERLOCK SWITCH IS REMOVED FROM THE SYSTEM THE PROBLEM NO LONGER OCCURS. THIS WAS DISCOVERED BY MYSELF AND A COUPLE OTHER FELLOWS WHOSE SWITCHES HAD FAILED AND WERE NO LONGER FUNCTIONING PROPERLY. WITH A FAILED SWITCH THE BIKE WILL NO LONGER START UNLESS IT IS NEUTRAL AND THE KICKSTAND IS RAISED. SINCE THE SWITCH CONTROLS THE ELECTRONIC CONTROL MODULE THIS MEANS THAT THERE IS SOME KIND OF ISSUE WITH THE MAPPING THAT YAMAHA USES TO CONTROL THEIR ENG

THIRD GEAR IN MY 2006 STRATOLINER "S" IS COMPLETELY USELESS. THE GEAR HAS EITHER SEVERELY WORN ITSELF OR IS CHIPPED. WHEN IN GEAR (FROM 25-35MPH) THE TRANSMISSION PRODUCES A SEVERE WHINE AND GRINDING SOUND. YAMAHA AND THE DEALERSHIP CLAIM THERE IS NO "WIDESPREAD" ISSUE HOWEVER I AM IN CONTACT WITH FIVE OTHER 2006 STRATOLINER OWNERS WHO HAVE THE EXACT SAME PROBLEM! *TR