2001 Workhorse P320032

Defect. VEHICLE DESCRIPTION: MOTOR HOME AND COMMERCIAL CHASSIS. THE REAR AXLE U-BOLTS MAY NOT BE TIGHTENED CORRECTLY DUE TO RANDOM FAILURE OF PRODUCTION TOOLING IN THE SPECIFIED TIME SPAN.

Risk. LOW U-BOLT TORQUE CAN RESULT IN U-BOLTS COMING LOOSE AND NOT PROPERLY RETAINING THE REAR AXLE TO THE VEHICLE, RESULTING IN A LOSS OF VEHICLE CONTROL.

Remedy. DEALERS WILL TIGHTEN THE REAR AXLE U-BOLTS. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WORKHORSE AT 1-877-946-7731.

VEHICLE STOPPED DEAD NO ELECTRICAL SMOKE CAME FROM UNDER DASH. WOULD NO START AFTER THAT. *TR

TL* THE CONTACT OWNS A 2001 WORKHORSE ALLEGRA RV WITH A P32 MODEL CHASSIS. THE CONTACT STATED WHILE ATTEMPTING TO BRAKE FROM 35 MPH, THE BRAKES WOULD NOT ENGAGE. THE VEHICLE WAS MOVED OFF THE ROADWAY WHERE THE CONTACT FOUND THAT THE REAR CALIPERS AND ROTORS HAD OVERHEATED. THE FAILURE CAUSED THE BRAKE HOSES TO COLLAPSE AND LEAK EXCESSIVE AMOUNTS OF BRAKE FLUID FROM THE RESERVOIR. THE VEHICLE WAS TAKEN TO A REPAIR FACILITY WHERE THE BRAKE LINE HOSES, CALIPERS, ROTORS, BRAKE PADS AND WHEEL SEALER WAS REPLACED. THE MANUFACTURER STATED THERE WAS NO RECALL FOR THE VEHICLE AND WOULD NOT PROVIDE ANY ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 27,000.

I HAVE A 2001 MOTOR HOME ON A WORKHORSE CHASSIS AND HAVE A SEVER BRAKE PROBLEM. WHEN YOU APPLY THE BRAKES, ONLY THE FRONT BRAKES TRIES TO STOP THE COACH, THEN YOU SMELL THE PADS GETTING HOT AND THE PEDDLE GOES TO THE FLOOR AND YOU HAVE TO PUMP THEM TO STOP. I HAVE PUT BRAND NEW SHOES , CALIPERS, AND MASTER CYLINDER WITH NO HELP. IT HAS BEEN AT A WORKHORSE DEALERSHIP FOR ONE MONTH NOW AND THEY CAN'T FIND THE PROBLEM. AFTER READING RV.NET, PLENTY OF PEOPLE OWNING WORKHORSE CHASSIS HAS THE SAME PROBLEMS. *TR

MY ONE-MONTH-OLD 2001 WORKHORSE/CHEVROLET 18,000 GVW CHASSIS MOTORHOME HAD PARTIAL FAILURE OF ITS AUTOPARK BRAKING SYSTEM. THERE WERE VERY UNSETTLING NOISES WHILE DRIVING. MY INSPECTION REVEALED LEAKING BRAKE/TRANS FLUID. PERSONALLY PERFORMED A TEMPORARY FIX BY ATTEMPTING TO TIGHTEN FITTINGS AND CONTINUALLY TOPPING OFF QUARTS OF ATF FLUID IN BRAKING SYSTEM UNTIL ABLE TO GET TO A REPAIR AGENCY IN ANCHORAGE, AK. NOW I HAVE COME TO REALIZE HOW LUCKY WE WERE THAT THE SYSTEM DID NOT LOCK UP AND CAUSE AN UNEXPECTED AND DANGEROUS STOP ON THE HIGHWAY. A SEAL WAS REPLACED AND THE SYSTEM HAS WORKED OK SINCE,BUT I WISH TO EXPRESS SERIOUS CONCERN OVER THE DESIGN AND DURABILITY OF THIS (MOST UNUSUAL AND UNNECESSARILY COMPLEX) "SYSTEM"! I NO LONGER DRIVE WITH THE SAME LEVEL OF CONFIDENCE IN THIS SYSTEM'S DURABILITY.

PARKING BRAKE SYSTEM ON WORKHORSE P32 CHASSIS LOCKS UP AND CANNOT BE RELEASED. THIS IS AN ELECTRONIC TRANSMISSION BRAKING SYSTEM.*AK