2020 Volvo V60cc

Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.

Risk. A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.

Remedy. Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.

Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

Risk. Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.

Remedy. Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.

Defect. Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.

Risk. If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.

Remedy. Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.

Occurring 7/10/2025 WATER LEAK CONCERN:: mildew smell coming from the vehicle, trunk is wet and smelling mildew. have gaps on the rear sunroof glass seal. recommend replacing rear sunroof glass seal, replaced all the drain hoses, remove all the carpets and dry them—water incursion may have affected electrical systems responsible for safety and driving. In Volvo's Service and Parts Business Technical Journal Title: Panoramic sunroof, sealing strip has a gap Ref No: TJ 35503.3.0 the description states: "If the customer complain about that the sealing strip in rear end of panoramic sunroof is too short, or if the short sealing strips cause water leaks into the care, please follow advice under Service. Replace the sealing strips and glue it in each end in according to the method in VIDA." Volvo has been aware of the poor panoramic sunroof design which can result in water incursion into the cabin of the vehicle. At no point has Volvo informed the customer or direct service departments to be proactive in addressing the sealing gaps. There is no mention of any maintenance or concerns in the car manual.

Front left axle shaft failed at 18,000 miles, producing noticeable noise and vibration when accelerating and turning to the right. The car has never been in an accident, nor has there ever been an incident (e.g., striking a curb) or other abuse that could have caused this failure. Fortunately I brought it into my local Volvo repair shop before further damage to the transmission and other connected parts. Test drive by the repair shop confirmed the vibration at various speeds and maneuvers. Cost to replace the axle was $1,056.75. I contacted the nearby dealer after diagnosis and before the repair. They said there was nothing they could do as the vehicle is out of warranty. I am in contact with Volvo corporate headquarters, who is saying the same thing. This is a defective product, not warranty, claim. It seems likely that this defect is not isolated to my vehicle.

Driver’s side side view mirror moves to a different location each time car is entered/started. Saving pre-set location of mirror does not hold. Even after a repositioning and saving, or repositioning without saving, the mirror on left side is horizontally in a different spot. This is a safety issue as one usually expects mirrors to be where they were left previously using the mirror controls. Car has been into dealer multiple times for a fix which included both software and hardware attempts. Appears to be known problem based on on-line review. Mirror should stay in a fixed position unless driver wants to relocate. If not risk of visibility issue is large.

Case Number in Volvo System 210611-000605 For malfunctioning of mirror and obstruction of vision of oncoming vehicles on the driver side of the vehicle. Mirror reset itself in a different position randomly and unaware that this has happened the driver is not prepared to react to the no vision to the side of the vehicle that may be occur when merging or turn in the direction of on highway ramp or merging at a yield sign or village roundabout. The vehicle has been return for resolution four times without a proper fix or countermeasure to the issue.