Owners filed 2 complaints about this vehicle with federal regulators, most often about the unknown or other. It has been recalled 3 times.
What fails
Component
Reports
Crashes
Fires
Injuries
Unknown or Other
1
0
0
0
Air Bags
1
0
0
0
3 safety recalls
Part 573 reports
Steering23V001000
Filed Jan 5, 202374 vehiclesVolvo Car Usa, Llc
Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Risk. A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy. Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Seat Belts › Rear/Other › Retractor21V682000
Filed Sep 1, 202119,149 vehiclesVolvo Car Usa, Llc
Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk. An unsecured child restraint system can increase the risk of injury during a crash.
Remedy. Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
Air Bags › Air Bag/Restraint Control Module21V001000
Filed Jan 7, 20212,883 vehiclesVolvo Car Usa, Llc
Defect. Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Risk. A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Remedy. Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.
What owners reported
Newest filings
Air Bags
Filed Feb 23, 2025CA
CONCERN: Volvo cars’ sunroofs are negligently designed, allowing sunroof drain obstructions to flood the vehicle’s internal electronics. This results in catastrophic and simultaneous system failures, including brake loss, airbag failure, and disabled traction control—posing an extreme and imminent safety risk. SUMMARY OF EVENTS: While driving at speed, I received a “BRAKE FAILURE / PLEASE STOP SAFELY” warning, followed by “ABS / ESC” and “SRS Airbag” failure messages. This led to a sudden and dangerous loss of braking power and airbag system failure, forcing me to pull over in an emergency maneuver. Diagnostics confirmed that water leaked into the car’s critical electronic systems via the sunroof. Like other manufacturers, Volvo sunroofs degrade over time and require drainage. However, Volvo’s design is fatally flawed—clogged drains lead to direct water ingress into the electronics, causing total vehicle system failure while in motion. No warning is provided before catastrophic failure occurs. This is not an isolated case. An identical failure occurred in our second Volvo (2020 V90 Cross Country), owned and operated in California. This proves a systematic design defect—the same critical safety failure occurred in two separate vehicles, in different environments, under identical circumstances. I am deeply alarmed by Volvo’s negligent sunroof drainage design, which puts drivers and the public at severe risk of fatal system failures. I am reporting this to NHTSA because I believ
Unknown or Other
Filed Jun 19, 2022MD
Rear tires tread started shredding off particularly on the outside edge. The passenger rear tire is bald on outside edge the driver side is bad but not as extreme.This only took 1,500 miles I don’t know the cause but with 150 miles to get home I switched the drive mode from comfort to eco and that might have slowed or stopped the issue.Pic1passenger rear pic2 drivers rear pic3 drivers front pic4 passenger front The first appointment I can get at the dealership is June 28,2022 but I plan on stopping by 6/19/22 to show him the issues and order new tires.
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.
Most recent recall on file: Jan 5, 2023. Source: NHTSA Office of Defects Investigation.