2009 Volkswagen Jetta complaints

2009 VOLKSWAGEN JETTA TDI. VEHICLE RAN OUT OF DIESEL FUEL, UPON FILLING WITH NEW FUEL VEHICLE FAILED TO START. VEHICLE WAS TOWED TO VOLKSWAGEN DEALER TO PERFORM REPAIRS. DEALERSHIP INFORMED ME THE FUEL INJECTION PUMP WENT OUT AND THE ENTIRE FUEL SYSTEM NEEDED REPLACEMENT AT A TOTAL COST OF $8600.00. DUE TO THE FUEL INJECTOR PUMP GOING OUT CAUSED METAL SHAVINGS TO ENTER THE ENTIRE FUEL SYSTEM AND ALLEGEDLY REQUIRING A COMPLETE SYSTEM REPLACEMENT. SIMPLY BECAUSE THE VEHICLE RAN OUT OF FUEL. PEOPLE RUN OUT OF FUEL EVERY DAY AND ARE NOT PUT IN MY CURRENT SITUATION WITH MY VOLKSWAGEN. THIS MUST BE FAULTY ENGINEERING TO RESULT IN A COMPLETE FUEL SYSTEM REPLACEMENT FOR THE SOLE REASON OF RUNNING OUT OF DIESEL FUEL. WHAT I WAS TOLD BY THE DEALERSHIP O THE NECESSARY REPAIRS AND COSTS ARE ABSURD. ANY HELP IS APPRECIATED. THANK YOU. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE MADE A LOUD BUZZING NOISE WITH THE ILLUMINATION OF THE INSTRUMENT PANEL WARNING LIGHTS. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL PUMP FAILED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

WHILE LEAVING A CONCERT, THE VEHICLE WAS FINE LEAVING THE PARKING LOT. ONCE WE INCREASED SPEEDS TO 45 MPH, THE ENGINE COMPLETELY SHUT DOWN. THE DIALS ON THE DASHBOARD ALL FELL TO ZERO AND THE GAS PEDEL NO LONGER WORKED. WE COASTED INTO A SMALL CAMPGROUND AREA OFF TO THE SIDE OF THE ROAD. AFTER TRYING TO RESTART THE CAR THREE TIMES, IT FINALLY STARTED AND WE PROCEEDED TO GO DOWN THE ROAD, ONLY TO MAKE IT 500 MORE YARDS AND PULLED IN TO A HAY STACK PAD. AFTER NUMEROUS ATTEMPTS TO START WHILE SITTING ON THE PHONE WIHT OUR INSURANCE COMPANY, THE CAR STARTED ONCE AND DIED AFTER SITTING IDLE FOR THREE MINUTES. WE THEN ATTEMPTED TO START IT ONE LAST TIME AND DROVE 25 MPH TO THE NEAREST GAS STATION. WE ALL GOT OUT OF THE CAR, LOCKED IT UP THINKING IT MAY HAVE SOMETHING TO DO WITH AN ANTITHEFT FEATURE. WE GOT BACK IN THE CAR AND WERE ABLE TO DRIVE 41 MILES HOME AT HIWAY SPEEDS. THE FOLLOWING DAY WE DROVE 5 MILES INTO TOWN AND IT DIED AGAIN GOING 25 MPH. THE CLOSEST VOLKSWAGON IS ANOTHER 25 MILES AWAY. *TR

ABRUPT DECELERATION TO 30MPH FROM 50MPH D/T VEHICLE IN FRONT OF ME HITTING THEIR BRAKE AND TURNING. THEN I ACCELERATED TO GET BACK TO THE POSTED SPEED OF 50MPH. WHEN DEPRESSING ACCELERATOR AT APPROX 40MPH HEARD A LOUD "POP", LOSS OF POWER, GLOW LIGHT ON DASH CAME ON AND WARNING. LOSS OF POWER WITH 3 CARS COMING BEHIND ME SO I QUICKLY MOVED TO THE SHOULDER AND RESTARTED THE CAR. CAR TURNED OVER BUT WAS IN "LIMP" MODE - I WAS LESS THAN 1 MILE FROM MY HOUSE, SO I PULLED OUT AND "LIMPED" HOME. CONTACTED VW ON MONDAY 11/14/11 AND MY DEALERSHIP. THE CAR WAS FLAT BEDDED TO THE DEALERSHIP AND HPFP FAILURE WAS DIAGNOSED, VW PAID IN FULL FOR COMPLETE REPLACEMENT OF ENTIRE FUEL SYSTEM. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE HIGH PRESSURE DIESEL FUEL PUMP FAILED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS TRADED DUE TO THE DEFECT. THE FAILURE AND CURRENT MILEAGES WERE 111,000.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD. AS THE CONTACT MERGED THE VEHICLE TO THE SHOULDER, IT RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INSPECTED THE VEHICLE AND STATED THAT THE FAILURE WAS DUE TO A BLOWN TURBO. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE REPAIR WAS COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 73,800.

I WAS DRIVING MY 2009 VOLKSWAGEN VW JETTA TDI DIESEL AND IT STALLED WHILE DRIVING. THANK GOD IT DIDN'T STALL WHILE DRIVING AT A HIGHER SPEED AROUND A CORNER WITH ONCOMING TRAFFIC !!! I HAD IT TOWED TO MY PLACE AND PLUGGED IN MY OBD READER AND GOT 2 CODES, PO47A (UNDEFINED CODE) AND PO191 (FUEL RAIL PRESSURE SENSOR CIRCUIT RANGE/PERFORMANCE). I DID SOME RESEARCH ONLINE AND DECIDED TO TRY AND REPLACE MYSELF, THE EXHAUST PRESSURE SENSOR #2 AND THEN LATER THE FUEL RAIL PRESSURE SENSOR WITH NO LUCK EITHER WAY. SO I DECIDED TO TOW IT THE MY LOCAL VW DEALER AND THE WORST POSSIBLE CASE SCENARIO WAS THE OUTCOME. THE DEALER SAID IT WOULD COST $ 6,500.00 TO REPAIR AND THAT THE ENTIRE FUEL SYSTEM WOULD HAVE TO BE REPLACED DUE TO FUEL (METAL) CONTAMINATION AND A BAD HIGH PRESSURE FUEL PUMP. UNDER MY RESEARCH ONLINE I'VE FOUND THAT MANY CUSTOMER'S OF 2009-2012 HAVE HAD THE SAME PROBLEM'S THAT VW WILL NOT RECALL. I'M WRITING THIS IN HOPE THAT SOMEONE MAY THESE MANY COMPLAINTS AND FORCE THE GREAT VW EMPIRE TO RECALL THESE PROBLEMS BEFORE PEOPLE, FAMILIES , AND CHILDREN ARE SEVERELY HURT, HANDICAPPED, AND/OR KILLED. I INVITE ANYONE WHO READS THIS AND ALL THE OTHER SIMILAR COMPLAINTS OF THESE VEHICLES TO TAKE THIS VERY SERIOUSLY AND THINK ABOUT IF SOMEONE YOU LOVE OR CARE ABOUT WAS OR CAN BE HURT, INJURED, HANDICAPPED, OR KILLED BECAUSE VW WANTS TO MAXIMIZE THEIR PROFITS !!!!! SHAME ON VW AND SHAME ON ANYONE WHO HAS THE POWER OR AUTHORITY TO POSSIBLY DO SOMETHING ABOUT THIS AND DOESN'T DO ANYT

DRIVING AT LOW SPEED IN THE CITY, WHEN A ENGINE FAILURE WARNING DISPLAYED AND THE VEHICLE STARTED RUNNING ROUGH. TOOK IT TO THE DEALERSHIP AND WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP FAILED SENDING METAL SHARDS THROUGHOUT THE FUEL SYSTEM. THIS HAS APPARENTLY TRIGGERED REPLACEMENT OF THE ENTIRE FUEL SYSTEM FROM THE PUMP TO THE ENGINE. AFTER RESEARCHING THIS ONLINE, I HAVE FOUND THAT THIS IS A KNOWN ISSUE. TO MY KNOWLEDGE THE HPFP'S HAVE NOT BEEN RECALLED. VW AND YOUR WEBSITE SO FAR STATES THAT THE PROBLEM IS A FUEL CONTAMINATION ISSUE, BUT I HAVE ONLY BOUGHT DIESEL FROM MURPHY USA I CONFIRMED THIS WITH RECEIPTS. ( A HIGH VOLUME DEALER IN MY AREA). THE DEALERSHIP STATES THAT THE REPAIR SHOULD BE COVERED EVEN THOUGH THE WARRANTY HAS EXPIRED. THIS IS SUSPECT TO ME. EITHER OUR FUEL STANDARDS ARE NOT PAR WITH THE REST OF THE WORLD AND NEED FURTHER REGULATION OR THE PUMPS NEED TO BE RECALLED. BUT A CAR DESIGNED TO SAVE MONEY BY CONSERVING FUEL IS NOT DOING THAT IF THE 27000 DOLLAR CAR NEEDS 10000 DOLLARS OF WORK. *TR

A CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP LEFT MY WIFE WITHOUT POWER AS SHE WAS DRIVING IN TRAFFIC. THERE WAS NO PRECEDING INDICATION AND IN OTHER CIRCUMSTANCES COULD HAVE CAUSED A TRAFFIC ACCIDENT. WHEN THE HPFP FAILED, ALL NON-ELECTRICAL POWER FAILED WITH A POTENTIAL FOR SIGNIFICANT CONTROL AND BRAKING PROBLEMS. *TR

2009 TDI JETTA HIGH PRESSURE FUEL PUMP. THREE PUMPS HAVE BEEN PUT IN AND IT KEEPS FAILING ON THE HIGHWAY TWICE AND WAS EXTREMELY DANGEROUS AND I AM OVER WARRANTY AND IT SEEMS TO BE A FAULTY DESIGN. DON'T KNOW WHAT STEPS TO TAKE HERE THEY HAVE HAD MY CAR FOR ALMOST 90 DAYS. *TR THE CONSUMER ALSO STATED TWO TRANSMISSION FANS HAVE BEEN INSTALLED IN THE VEHICLE. HE WAS THEN TOLD A NEW TURBO WAS NEEDED AT A COST OF $3000. UPDATED IVOQ 12/10/12

DRIVING VEHICLE THEN LOSS OF ALL POWER. HIGH PRESSURE FUEL PUMP FAILURE. *TR

JETTA IS A TDI, DIESEL. GLO PLUG ENGINE LIGHT BEGAN FLASHING AND EXPERIENCED DECREASED (BUT NOT COMPLETE) LOSS OF POWER. PULLED OVER. EXAMINED ENGINE, WHICH WAS SHAKING. TURNED CAR OFF AND GLO PLUG WARNING LIGHT WENT OFF, SO ATTEMPTED TO DRIVE, BUT GOT LESS THAN A MILE DOWN THE ROAD BEFORE GLO LIGHT BEGAN FLASHING AGAIN AND ENGINE LIGHT CAME ON. AT THIS TIME, I PULLED OVER, TURNED OFF THE CAR, AND HAD IT TOWED TO OCALA VOLKSWAGEN (FLORIDA). AT THE TIME OF THE INCIDENT, I HAD BEEN DRIVING ON THAT TANK OF GAS FOR APPROXIMATELY 100 MILES OR SO (IE, WAS NOT THE RESULT OF PUTTING GAS IN A DIESEL TANK -- DEALER PERFORMING REPAIRS WILL CONFIRM). DIAGNOSIS IS EX/IMPLODED HIGH PRESSURE FUEL PUMP (HPFP) RESULTING, LIKELY, FROM CONTAMINATED FUEL -- NOT THE WRONG FUEL (I AM CAREFUL TO ONLY PUT ULTRA LOW SULFUR HIGHWAY DIESEL IN). VW PAYING FOR ALL COSTS TO REPLACE FUEL SYSTEM (PUMPS, INJECTORS, RAILS) BUT NOT FUEL TANK. DANNY AT VW OCALA HAS BEEN VERY GOOD TO DEAL WITH, BUT I'M CONCERNED THIS WILL HAPPEN AGAIN AND VW MAY NOT BE SO KIND/RESPONSIBLE TO COVER COSTS. NOT SURE WHETHER NEW HPFP SYSTEM WILL BE INSTALLED, OR THE SAME ONE AS BEFORE (THUS LEAVING ME AT THE MERCY OF HAVING TO "CHOOSE" THE RIGHT GAS STATIONS). CAR IS IN FOR REPAIRS AT THIS TIME. *TR

VEHICLE IS A 2009 JETTA SEDAN - TDI (DIESEL) VEHICLE SHUT DOWN WHILE DRIVING. FLOW PLUG LIGHT FLASHED ON DASH ALONG WITH DISPLAY OF "ENGINE FAULT WORKSHOP" VEHICLE WOULD NOT RESTART. PULLED CODE OF P0087 FUEL RAIL/SYSTEM PRESSURE LOW. TOWED TO DEALER, BOUCHER VW IN FRANKLIN, WI. DEALER CONFIRMED FAULT WAS A HIGH-PRESSURE FUEL PUMP FAILURE. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE ATTEMPTED TO ROLL THE WINDOWS DOWN, BUT THEY WOULD NOT ROLL DOWN. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE ELECTRICAL INSTRUMENT PANEL FOR THE WINDOWS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 56,000.

MY JETTA SPORTWAGEN TDI WITH DSG TRANSMISSION WAS PURCHASED NEW IN MAY 2009. WITHIN 3 MONTHS OF PURCHASE, WE NOTICED THE CAR WOULD JERK AND SLAM INTO GEAR. EVERY TIME WE HAD THE CAR IN FOR SERVICE WE COMPLAINED OF THE "JERK" OR "SLAM". THEN, IN DEC 2009 WE RECEIVED A WARRANTY EXTENSION FOR THE DSG TRANNY FROM 60,000 MILES TO 100,000. THIS OBVIOUSLY SHOWED THERE WERE KNOWN PROBLEMS. AT ALL OF IT'S SCHEDULED MAINTENANCE APPOINTMENTS, I WOULD MENTION THE JERKINESS. THE DEALERSHIP SAID THERE WAS NO PROBLEMS SINCE THEY NEVER FELT IT SHIFT FUNNY WHEN THEY DROVE IT. IT WASN'T EVEN UNTIL 43,000 DID ANYONE RIDE IN THE CAR WITH ME TO SEE! NOT ONCE DID THEY HOOK THE CAR TO A COMPUTER TO RUN FOR CODES OR FAULTS. I DID NOT HAVE A CHECK ENGINE FAULT CODE EITHER. WE HAD THE TRANNY SERVICED PER THE VW MANUAL AT A LITTLE OVER 40,000 MILES AND THAT DID NOT HELP THE CAR. NOW, THE CAR TENDS TO DOWNSHIFT WHILE COMPLETELY STOPPED, STILL SLAMS/JERKS INTO GEAR, ROCKS BACK AND FORTH WHEN YOU PUT IT IN PARK AND ROLLS BACKWARDS SEVERAL FEET WHEN YOU PUT THE CAR IN DRIVE FROM REVERSE (IN OUR SLOPED DRIVEWAY.) THIS NEVER HAPPENED IN THE PAST, BUT NOW YOU HAVE TO "POWER" BRAKE THE CAR TO ENSURE YOU DON'T ROLL BACK AND HIT THE OTHERS IN OUR DRIVEWAY. SINCE I WAS GETTING NO WHERE, I FINALLY CALLED AN OPENED A CASE WITH VW CUSTOMER CARE. THIS TIME WHEN I TOOK THE CAR IN FOR SERVICE I MENTIONED THE PROBLEM AGAIN AND REFERENCED MY CASE NUMBER. THEY CHECKED MY CAR OUT TODAY AND SAID THEY ORDERED A NEW MECHATRON

FIRST INCIDENT IN JULY 2011 BUT SAME ONGOING ISSUE AND AT THE DEALERSHIP AT LEAST 8 TIMES IN 11 MONTHS. CURRENTLY AT THE DEALERSHIP AGAIN FOR ALMOST 3 WEEKS NOW. ITS ALWAYS THE SAME "SYMPTOMS" BUT ALWAYS TOLD ITS ANOTHER PROBLEM..... AS FOLLOWS: -SPUTTERS AND JERKS -EXHAUST OR GAS FUMES OVERCOME THE CAR -ENGINE REVS BUT THE CAR WONT MOVE, THEN JOLTS FORWARD. -STALLS WHEN TRYING TO START, IT JERKS VIOLENTLY MAKING A PUTTING NOISE AS IF IT CAN'T GET FUEL THEN DIES. -THERE'S A BEEPING NOISE COMING FROM SOMETHING IN THE ENGINE WHEN IT STALLS THAT NO ONE SEEMS TO KNOW WHAT IT IS. I HAVE REPLACED: -INTAKE MANIFOLD -ALL FUEL SENSORS -LOW PRESSURE FUEL PUMP -HIGH PRESSURE FUEL PUMP -MELTED FUSES WITH UNKNOWN CAUSE -TWO BATTERIES -OTHER SMALLER ITEMS RELATED TO FUEL SYSTEM. *JB

I WAS GOING DOWN THE ROAD AT APPROXIMATELY 45 MPH, THE ENGINE LOST POWER AND STALLED. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD, THEN HAVE IT TOWED. MY SPOUSE IS AN ENGINE MACHINIST, AND AFTER TALKING TO A VOLKSWAGEN DEALERSHIP, AND TAKING THE CAR APART, FOUND METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM. SO FAR, HE HAS SPENT $3200 FOR PARTS WHICH HAS DEPLETED OUR SAVING ACCOUNT. HE IS SELF EMPLOYED AND I WORK PART TIME AND PART TIME STUDENT, PAYING $400 A MONTH FOR A CAR WE THOUGHT WOULD BE SAFE, DEPENDABLE AND ECONOMICAL! THIS IS CLEARLY A SAFETY ISSUE, DOCUMENTED FOR OVER 2 YEARS WITH NO RESPONSIBILITY TAKEN BY VW, WHO HAS FALSELY DENIED ANY ONGOING ISSUE OF THIS SORT. FORTUNATELY, MY HUSBAND CAN DO THE LABOR, BUT PEOPLE ARE SPENDING $8,000 TO $10,000 TO GET THIS VW PROBLEM FIXED, AND IN SOME CASES HAS HAPPENED AGAIN. THIS HIGH PRESSURE FUEL SYSTEM IS FAULTY AND UNSAFE. VW NEEDS TO TAKE RESPONSIBILITY FOR THEIR PRODUCT TO ENSURE CUSTOMER SAFETY ON THE ROADWAYS. *TR

MY ABS LIGHT CAME ON WHEN I WAS IN CRUISE CONTROL AT 60 MPH AND KNOCKED ME OUT OF CRUISE CONTROL. ANOTHER TIME I WAS GETTING READY TO STOP FOR A STOP SIGN AND THE BRAKE PEDAL STARTED TO VIBRATE AND I ALMOST COULDN'T STOP AND THE ABS LIGHT WENT ON. *TR

THIS IS A VW JETTA 2009 TDI WITH 74,200 MILES. I HAVE BEEN THE ONLY OWNER. VEHICLE SUDDENLY LOST POWER AND BLACK SMOKE CAME FROM EXHAUST, RED LIGHTS ON DASHBOARD CAME ON WITH ERROR MESSAGE "ENGINE FAILURE". TECHNICIAN AT VW DEALER FOUND THE TURBO CHARGER HAD AN INTERNAL FAILURE. THE FAULTY TURBO PUMPED OIL THROUGHOUT THE EXHAUST SYSTEM INTO THE CAT CONVERTERS, AND HOSES. ALL WOULD NEED TO BE REPLACED AND COSTS $7,200. *TR

FOR THE SECOND TIME MY FUEL PUMP WENT OUT. ALSO FOR THE SECOND TIME I WAS ACCUSED OF USING BIO DIESEL OR REGULAR FUEL BY THE DEALER. I WAS DRIVING A LONG IT SOUNDED LIKE A GEAR WAS TUMBLING AROUND THEN A GRINDING NOISE FOLLOWED. LUCKILY I WAS A LOW RATE OF SPEED AND WAS ABLE TO PULL OFF TO A SIDE STREET WITH OUT PROBLEM. LAST WEEK THE GEAR BOX WENT OUT AS WELL. IT HAD ISSUES ON GOING IN TO REVERSE FROM DRIVE. OFTEN I WOULD HAVE TO PUT THE CAR IN TO PARK TURN IT OFF THEN RESTART TO GET IT TO GO IN TO REVERSE. *TR

VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF AN INTERSECTION DURING FRIDAY AFTERNOON RUSH HOUR TRAFFIC AND WOULD NOT RESTART, NEARLY CAUSING MULTIPLE ACCIDENTS. DASHBOARD BRIEFLY FLASHED "ENGINE MALFUNCTION WORKSHOP" AND THE GLOW PLUG LIGHT ILLUMINATED PRIOR TO FAILURE. HAD VEHICLE TOWED TO JIM ELLIS VW IN CHAMBLEE, GA FOR DIAGNOSIS. DEALERSHIP CALLED WITH A DIAGNOSIS OF A FAILED HIGH PRESSURE FUEL PUMP AND STATED THAT THE ENTIRE FUEL SYSTEM WOULD NEED TO BE REPLACED DUE TO METAL SHAVINGS FOUND THROUGHOUT THE SYSTEM. ADVISED THAT REPAIRS WOULD NOT BE COVERED UNDER EXISTING 5-YEAR/60,000 MILE POWERTRAIN WARRANTY, CLAIMING THAT THE FUEL SYSTEM WAS SOMEHOW EXEMPT FROM WARRANTY COVERAGE, AND ESTIMATED $8700 TO FIX THE CAR. I CALLED VOLKSWAGEN OF AMERICA TO REPORT THE INCIDENT AND QUESTION WHY THE MANUFACTURER'S WARRANTY WOULD NOT COVER AN OBVIOUS DEFECT IN THE CAR; THEY EVENTUALLY AGREED TO COVER THE FULL COST OF REPAIRS UNDER WARRANTY. VEHICLE WAS REPAIRED WITHIN A WEEK, BUT IS NOW BACK AT JIM ELLIS VW FOR FURTHER EVALUATION AFTER THE SAME "ENGINE MALFUNCTION WORKSHOP" AND GLOW PLUG LIGHT ILLUMINATED AGAIN ONLY 30 MILES AFTER THE REPAIRS. PLEASE COMPEL VOLKSWAGEN TO RECALL THIS CLEARLY UNSAFE VEHICLE AND FIGURE OUT WHY THEIR HIGH PRESSURE FUEL PUMPS ARE FAILING CATASTROPHICALLY AT SUCH HIGH RATES AROUND THE COUNTRY. *JS

BRAKES SQUEALED FROM THE DATE OF DELIVERY IN MARCH 2009. VEHICLE WAS TAKEN TO VW SERVICE DEPARTMENT ON SEVERAL OCCASIONS TO INSPECT BRAKES. I WAS TOLD EACH TIME THAT THAT'S COMMON IN THE VW JETTA AND I HAD TO GET USED TO IT. BRAKES SEEMED TO FAIL ON SEVERAL OCCASIONS AND CAUSED AN ACCIDENT. VEHICLE WAS TAKEN TO VW SERVICE AFTER ACCIDENT SEVERAL TIMES TO INSPECT BRAKES AND EACH TIME I WAS TOLD NOTHING IS WRONG UNTIL THEY FINALLY REPLACED THE BOOSTER AND THE SWAY BAR LINKS. AFTER VEHICLE WAS DELIVERED BACK TO ME, THE BRAKE FLUID STARTED TO LEAK AND THE BRAKE WARNING LIGHT KEEPS ILLUMINATING. VW SAID THAT NOTHING IS WRONG WITH THE CAR. THE CAR HAS DELAYED BRAKING AND SOMETIMES NO BRAKES AND IS DANGEROUS ON THE ROADS, ESPECIALLY THE HIGHWAY. *TR

I WAS DRIVING OUR 2009 VW JETTA TDI AT APPROXIMATELY 60MPH AND THE DISPLAY FLASHED ENGINE MALFUNCTION AND DISPLAYED A SYMBOL INDICATING GLOW PLUG PROBLEM. THE ENGINE FELT SLUGGISH SO I PULLED OVER TO THE SIDE OF THE ROAD. I CONTACTED THE LOCAL VW DEALER AND ASKED IF I COULD STILL DRIVE IT AND HE TOLD ME YES AND TO BRING THE CAR TO THE DEALER THE FOLLOWING MORNING. I PULLED BACK ONTO THE HIGHWAY, GOT UP TO 50MPH. THEN THE VEHICLE STALLED, THEN DIED COMPLETELY. I WAS BARELY ABLE TO PULL OFF SIDE OF HIGHWAY. WE HAD THE CAR TOWED TO DEALER. THE DEALER INSPECTED THE CAR AND EXPLAINED THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED AND METAL SHAVING AND CONTAMINANTS WERE THROUGHOUT THE FUEL SYSTEM AND THAT THE ENTIRE FUEL SYSTEM WILL NEED TO BE REPLACED. THE CAR IS CURRENTLY AT THE DEALER AWAITING A THIRD PARTY INSPECTION FROM THE WARRANTY COMPANY. ALL REQUIRED VEHICLE SERVICES HAVE BEEN PERFORMED AT THE REQUIRED INTERVALS. THE DIESEL FUEL INJECTION LINES HAD RECENTLY BEEN REPLACED IN MARCH 2012 BY THE DEALER SECONDARY TO A RECALL BY VW (V5 23J9). *TR

THE INCIDENT HAPPENED ON THE HIGHWAY MINUTES AFTER I LEFT WORK. SOME OF THE LIGHTS CAME UP ON THE DASHBOARD THAT MADE ME PULL OVER AND STOP TO CHECK WHAT THEY MEAN. I TURNED THE CAR OFF AND CHECKED THE MEANING OF THE ICONS IN THE AUTO MANUAL. PER ADVISE IN THE MANUAL, I CONTACTED VW DEALERSHIP WHERE I WAS TOLD TO BRING THE CAR IMMEDIATELY IN. UNFORTUNATELY, THE CAR DID NOT START ANYMORE AND I WAS TOWED TO THE DEALERSHIP WHERE THE VEHICLE WAS PURCHASED. THE CAUSE FOR THIS WAS INTERNAL PUMP FAILURE WHICH MEAN REPLACING HIGH PRESSURE PUMP, FUEL TANK ETC. I POSSES ALL THE NECESSARY DOCUMENTS WITH THE DETAIL INFORMATION AND CORRECT DEFINITIONS OF EXACT FAILURE. IT HAS CAUSED GREAT INCONVENIENCE SINCE THIS IS THE ONLY CAR IN OUR FAMILY. IT ALSO COST US $219.92 OUT OF POCKET TO COVER THIS INCIDENT SINCE EXTENDED WARRANTY OF VW DID NOT PICK UP THE TAB IN FULL. AGAIN, ALL DOCUMENTS ARE IN MY POSSESSION TO PROVE IT. IT TOOK 7 DAYS TO RECEIVE THE CAR BACK. *TR

VEHICLES CHECK ENGINE LIGHT CAME ON AND LOSS OF POWER DIED IN MIDDLE OF ROAD TOWED TO DEALERSHIP AND IT WAS COVERED FOR WARRANTY THEY REPLACED THE WHOLE FUEL SYSTEM DUE TO CONTAMINATION, NOW NOT EVEN A YEAR LATER LESS 15,000 MILES THEY LOSS OF POWER AGAIN, DEALERSHIP HAS HAD MY CAR FOR 2 WEEKS THEY DIDN'T KNOW WHETHER OR NOT THEY WERE GOING TO WARRANTY IT THEY SAID IT HAD A FAILED FUEL INJECTOR. STILL DO NOT HAVE CAR BACK.IM BEGINNING TO WONDER IF THERE WASN'T MORE WRONG THAN JUST A FUEL INJECTOR, MAYBE THE HIGH PRESSURE FUEL PUMP WAS AT FAULT A SECOND TIME, AND THEY JUST DIDN'T WANT TO TELL ME. *JS

I WAS DRIVING UP A HILL IN A NEIGHBORING TOWN AND MY CAR LOST ALL POWER ALMOST INSTANTLY. MY ""MDF" READ "ENGINE FAULT WORKSHOP" AND MY GLOW PLUG LIGHT (SINCE THIS IS A DIESEL POWERED VEHICLE) STARTED RAPIDLY FLASHING. I WAS ABLE TO SHIFT THE CAR TO NEUTRAL AND COAST TO THE TOP OF THE HILL, THEN ONCE REACHING THE APEX OF THE HILL, COAST INTO A GROCERY STORE PARKING LOT. MY CAR WAS COMPLETELY DEAD, AND I HAD TO TOW IT TO THE DEALER. *JS

SUNROOF DRAINAGE TUBES BECAME UNGLUED FROM THE DRAINING NIPPLES THAT ATTACH TO THE PANORAMIC SUNROOF ASSEMBLY CAUSING A LARGE WATER LEAKS EVERY TIME IT RAINED. THE A, B, C, AND D INTERIOR PILLARS AND HEADLINER BECAME SOAKED AS DID THE INTERIOR CARPETS AND OTHER COMPONENTS INCLUDING THE FUSE PANEL BOX AND CENTRAL ELECTRONICS CONTROL MODULE (CECM) BEHIND THE DRIVER'S SIDE DASH CAUSING INTERMITTENT ELECTRICAL SHORTS AND DRIVABILITY ISSUES. THIS IS A REAL SAFETY HAZARD THAT HAS AFFLICTED MANY VW SEDANS WITH THE STANDARD GLASS SUNROOF AND WAGONS EQUIPPED WITH THE OPTIONAL PANORAMIC GLASS SUNROOF. EVIDENCE OF OTHER FAILURES OF THESE COMPONENTS HAS BEEN DOCUMENTED ON MANY VW ADVOCATE FORUMS BUT NO VW TSB OR RECALL CAMPAIGNS HAVE BEEN ISSUED TO DATE TO ADDRESS THIS DEFECT. THE REPAIR IS VERY COSTLY (4-5 HOURS OF LABOR PLUS PARTS). A CLASS-ACTION LAWSUIT IS CURRENTLY UNDERWAY FOR THIS SAME DEFECT FOR MANY VOLKSWAGEN CARS UP TO 2009 BUT THE SAME DEFECT PERSIST IN 2009 AND NEWER JETTA SEDANS AND SPORTWAGENS WITH SUNROOFS. I URGE THE NTSA TO INVESTIGATE THIS SAFETY HAZARD ON AFFECTED VW VEHICLES FROM 2009-2012. *TR

WHILE REPLACING FUEL FILTER CARTRIDGE I FOUND METAL SHAVINGS IN THE FILTER HOUSING. THE NEXT WILL BE HIGH PRESSURE FUEL PUMP FAILURE WITH THE HEAVY FUEL SYSTEM CONTAMINATION BY METAL SHAVINGS AS PER COMMON SCENARIO. SHOULD BE NOT PLEASANT EXPERIENCE. VW SHOULD CONCENTRATE ON FUEL FILTER/SYSTEM ROUTINE CHECK UP AND OFFER PREVENTIVE MAINTENANCE. *JS

2009 VOLKSWAGEN JETTA TDI 2.0L. CONSUMER WRITES IN REGARDS TO A FAULTY FUEL PUMP SYSTEM *TGW THE CONSUMER STATED WHEN SHE CAME UPON A STOP LIGHT, THE VEHICLE STALLED. THE GLOW PLUG LIGHT, ENGINE LIGHT AND A MESSAGE INDICATING ENGINE FAULT WORKSHOP ALL FLASHED. THE CONSUMER MANAGED TO RE-START THE VEHICLE. AS SHE CONTINUED TO DRIVE, SHE NOTICED THE VEHICLE WAS BECOMING LESS RESPONSIVE. SHE APPLIED PRESSURE TO THE ACCELERATOR, ONLY TO SEE THE RPM'S RAISE VERY HIGH AND THEN DROP TO ZERO WITH NO FLUCTUATION IN SPEED. THE CONSUMER STATED THE VEHICLE STALLED AGAIN. AFTER SEVERAL ATTEMPTS, THE VEHICLE STARTED, BUT WAS BARELY RUNNING. THE VEHICLE HAD COMPLETELY LOST IT'S ABILITY TO ACCELERATE. SHE SHIFTED THE GEAR INTO DRIVE AND MANAGED TO GET TO A LOCAL AUTO PARTS STORE. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THEY INFORMED THE CONSUMER THE FUEL SYSTEM WOULD NEED TO BE REPLACED. THE DEALER INFORMED THE CONSUMER VW WAS COVERING THE COST OF THE REPAIRS. *JB

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HEADLIGHT WAS DEFECTIVE. THE DEALER DIAGNOSED THAT THE MAIN FUSE BOX MELTED, CAUSING FIVE EXTERIOR LIGHTS TO BECOME DEFECTIVE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 79,000.

ON FOUR SEPARATE OCCASIONS, THE REAR SEATBELTS HAVE LOCKED IN THE FULLY WITHDRAWN POSITION AND WILL NOT RETRACT, REQUIRING COMPLETE MECHANISM REPLACEMENT. THIS OCCURRED INITIALLY AFTER PURCHASE ON A ROAD TRIP WITH OUR KIDS, THEN RECENTLY AGAIN ON BOTH SIDES, AND AGAIN JUST A WEEK AGO. ON ALL BUT THE MOST RECENT OCCURRENCE WERE REPLACED AT NO CHARGE BY VW. THE MOST RECENT OCCURRENCE MAKES US BELIEVE THIS IS A TRUE DEFECT IN THE MECHANISM. VW HAS NOT, TO MY KNOWLEDGE, ACKNOWLEDGED ANY DEFECT OR MADE A REVISION TO THE PART. THE SAFETY CONCERN IS THAT THE BELT WILL LOCK AND NOT RETRACT DURING TRANSIT, ENDANGERING MY PASSENGERS IN THE EVENT OF AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE SPOKES ON THE LEFT FRONT WHEEL BROKE. THE CONTACT WAS TRAVELING 55 MPH AT THE TIME OF THE FAILURE. THE CONTACT DID NOT THINK THE VEHICLE HIT A POT HOLE. THE CONTACT STATED THE TIRE WAS STILL INFLATED, BUT THE WHEEL HAD FAILED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 45,000.

2009 VOLKSWAGEN JETTA TDI WHILE TRAVELING INTERSTATE 81 IN NY VEHICLE JUST STALLED, GLOW PLUG AND "ENGINE FAIL WORKSHOP" MESSAGE APPEARED. COASTED TO SIDE OF ROAD CYCLE KEY OFF AND ON, BACK TO NORMAL. BACK TO 65 MPH, SAME THING. HEADED HOME AT 50 MPH FOR APPROX 50 MILES AND THEN OCCURRED AGAIN ON A HILL. WOULD NOT RESTART, COASTED BACK INTO A DRIVEWAY, RESTARTED DROVE AT 20 MPH COASTED INTO A LOCAL RESTAURANT AFTER ANOTHER STALL. AAA TOWED TO THE DEALERSHIP. AFTER THREE DAYS THEY HAVE " NO IDEA" WHAT THE PROB. WAS AND RETURNED MY CAR TO ME. THEY COULD NOT GET IT TO DO IT AGAIN. SO I AM WAITING TO BE STRANDED AGAIN....... *TR

HIGH PRESSURE FUEL PUMP FAILED AT 52000 MILES. THE ENTIRE FUEL SYSTEM WAS REPLACED WITH A WARRANTY ON PARTS OF 12000 MILES. AFTER 15000 MILES I EXPERIENCED ISSUE WITH HIGH PRESSURE FUEL PUMP AGAIN. THE FUEL LINE FROM HIGH PRESSURE PUMP TO FUEL RAIL WAS REPLACED. *TR

THE DIESEL HPFP FAILED WHILE DRIVING. CAR LOST POWER AND HAD TO BE TOWED TO DEALER FOR REPAIR. ENTIRE FUEL SYSTEM WAS REPLACED UNDER WARRANTY. *TR

I TURNED MY CAR ON, AND THE AIRBAG WARNING LIGHT CAME ON. THE OWNER'S MANUAL STATES TO TAKE IT IMMEDIATELY TO A DEALER. I DID SO, AS QUICKLY AS POSSIBLE, FOR COMPUTER DIAGNOSTICS. I WAS TOLD THE PODS SYSTEM HAD FAILED ON MY PASSENGER SIDE. MY PASSENGER AIRBAG DOES NOT TURN ON WHEN I HAVE A PASSENGER IN THE CAR. VW TOLD ME THEY WOULD NOT PAY FOR THE PART BECAUSE I WAS OUT OF WARRANTY, DUE TO MILEAGE. HOWEVER, I WAS ALSO TOLD THAT WEAR AND TEAR ON A VEHICLE DOES NOT IMPACT THE FUNCTIONING OF THE AIRBAGS. NOW, VW HAS A NATIONWIDE BACKORDER OF THE PART TO REPAIR MY VEHICLE, WITH NO INDICATION OF WHEN I WILL BE ABLE TO REPAIR MY VEHICLE. AS OF NOW, MY VEHICLE IS UNSAFE FOR PASSENGERS. ACCORDING TO THE DRIVER'S MANUAL, AIRBAG FAILURES MAY ALSO REDUCE THE EFFECTIVENESS OF THE RESTRAINT SYSTEM IN THE EVENT OF A CRASH. FOR THE PRICE OF THIS VEHICLE, I WOULD NOT EXPECT THE AIRBAGS TO FAIL, EVER, LET ALONE IN BARELY THREE YEARS. *TR

REAR PASSENGER SIDE BRAKE PAD WORN DOWN TO METAL WHILE REAR DRIVER SIDE HAS 5 MM LEFT ON IT. DEALER INDICATES A FAULTY CALIPER. WOULD NOT EVEN ENTERTAIN THE POSSIBILITY OF A STICKING LEFT PARKING-BRAKE CABLE OR NOT PROPERLY ADJUSTED PARKING CABLE THAT MIGHT NOT BE LETTING THE LEFT REAR CALIPER RELEASE COMPLETELY (CABLE READJUSTMENT IT'S A PAIN SINCE THE REAR HALF OF THE CENTER CONSOLE HAS TO BE DISASSEMBLED TO GET ACCESS TO THE PRIMARY ADJUSTER NUT AND MECHANICS DO NOT LIKE TO MESS WITH IT). DEALER WOULD NOT REPLACE REAR PADS AND ROTORS IF I DID NOT ALSO REPLACE THE CALIPER, EVEN THOUGH SERVICE MANAGER ACKNOWLEDGED THAT DIAGNOSTIC WAS ONLY BASED ON VISUAL INSPECTION AND NOT ON TAKING APART THE REAR BRAKE ASSEMBLY TO PROPERLY INSPECT THE CALIPER. FOR THE AUTO TECHNICIAN TO KNOW IT IS A FAULTY CALIPER (INSTEAD OF STICKING CABLE OR OTHER ISSUE) WITHOUT REMOVING IT FROM THE VEHICLE AND ONLY UPON VISUAL INSPECTION MUST MEAN THAT VW IS AWARE OF THE FAULTY CALIPERS AND KEEPING QUIET ABOUT IT UNTIL THE CUSTOMER WALKS INTO THE DEALERSHIP WITH THE PROBLEM. PREMATURE AND/OR UNEVEN REAR BRAKE PAD WEAR APPEARS TO BE A COMMON ISSUE ON JETTAS, AS HAS BEEN EXTENSIVELY DOCUMENTED ON JETTA OWNERS FORUMS AND WEBSITES. AS INDICATED BY A VW MECHANIC ON AN INTERNET FORUM "VW NEEDS TO DESIGN INTO THE PARKING BRAKE ADJUSTING SCREW INSIDE THE REAR CALIPER PISTON A MORE ROBUST SYSTEM TO SPRING THE REAR CALIPERS PISTON BACK AWAY FROM THE PADS AFTER BRAKE APPLICATION. INTERNAL BRAKE ADJUSTER SCREW SPINS

CAR STALLED WHILE ACCELERATOR WAS PRESSED. STALL LASTED ABOUT 3 SECONDS. STALLING OCCURS ABOUT ONCE A MONTH. *TR

WHEN STARTING TO MOVE THE CAR SUCH AS AT A STOP SIGN OR AT AN INTERSECTION, WHEN PUTTING THE ACCELERATOR PEDAL DOWN TO START THE VEHICLE MOVING, THE WHOLE CAR ALMOST STALLS AS ENGINE POWER DISAPPEARS FOR A TERRIFYING FEW SECONDS. *TR THIS IS VERY DANGEROUS BECAUSE YOU PULL OUT INTO TRAFFIC AND EXPECT THE CAR WILL MOVE FORWARD AND NOT STALL. I WENT ONTO A VW FORUM AND LEARNED THAT THIS IS A COMMON PROBLEM FOR VW. *TR

MY 2009 VW JETTA TDI HAD THE ENGINE LIGHT COME ON. THE DEALER SAID IT WAS AN 048 CODE FOR EXHAUST FLAP FAILURE. THIS IS A KEY PART OF THE EMISSION CONTROL. THEY TOLD ME IT WOULD COST $655 TO REPLACE. RESEARCHING THE INTERNET, THIS IS A GROWING PROBLEM WITH THE JETTA. PAGES AND PAGES ON THE INTERNET COMPLAINED ABOUT THE PROBLEM.SOME DEALERS ARE REPLACING IT UNDER THE FEDERALLY MANDATED 80,000 EMISSIONS WARRANTY. OTHERS ARE NOT. IT EXPLICITLY IS COVERED IN CALIFORNIA AND NEW YORK, WHERE I PURCHASED MY CAR. I ALSO DISCOVERED ON THE INTERNET THAT THIS PART IS CLEANABLE, WHICH IS MUCH LESS COST THAN REPLACING. I UNDERSTAND THIS IS UNDER INVESTIGATION BY YOUR ORGANIZATION. THIS EARLY FAILURE SHOULD BE COVERED BY THE WARRANTY BUT IS NOT BEING IMPLEMENTED. *TR

2009 VOLKSWAGEN JETTA TDI AT 53,000 MILES MY RADIATOR WENT OUT DUE TO A DESIGN FLAW WERE A CLAMP RUBBED A HOLE IN THE RADIATOR. VW WOULD NOT COVER UNDER FACTORY WARRANTY, AT 68,000 MILES THE ALIGNMENT WENT OUT IN THE AUTOMOBILE, AND FINNALLY AT 72,000 MILES I NOTICED MY TRANSMISSION MAKING A HARD SHIFT AND A DELAY SHIFT WHEN TAKING OFF, I INQUIRED ABOUT IT TWICE AT THE DEALER SHIP AND WAS ADVISE NOTHING WAS WRONG. THEN AT 94,000 MILES I STARTED HEARING A LOUD NOISE FROM MY MOTOR IT IS THE DUAL MASS CLUCH FLYWHEEL HAS GONE OUT. THE DEALERSHIP WANTS $3000.00 TO FIX. I CALLED VW OF AMERICA, THE VP I TALKED TO, SAID JUST BECAUSE THE PART WAS RECALLED IN AUSTRALIA AND CANADA IT DOESN'T MEAN ANYTHING TO THEM. *TT

TL * THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA SPORTWAGEN TDI. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL PUMP WAS UNABLE TO PUMP FUEL INTO THE SYSTEM AND AS A RESULT, THE FUEL PUMP WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 45,000.

VEHICLE WILL NOT START ON FIRST 4-6 ATTEMPTS AFTER A COLD SNAP AND SUBSEQUENT WARM WEATHER. ISSUE POINTS TO WATER BUILDING UP IN INTERCOOLER HOSES. VW HAS TSB POSTED BUT MAY NOT FULLY RESOLVE ISSUE. 21 11 01 / 2025464 DATED MAY 24, 2011, TITLED "FROZEN CHARGE AIR COOLER ? ENGINE WILL NOT START". IT CALLS FOR INSTALLING A 1K0-198-803-B COLD WEATHER INTERCOOLER KIT. A LOT OF INTERNET DISCUSSION ON THIS: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=266863. DATE OF NO START: 25 DEC 2011 (WONDERFUL CHRISTMAS GIFT!) LOCATION: CENTRAL NEW YORK (UTICA AREA) MILEAGE: ~42000 SIGNIFICANT WEATHER BEFORE NO START: SOME VERY LIGHT SNOW... LOW OF 19F, HIGH OF 39F... SEE HTTP://WWW.WUNDERGROUND.COM/HISTORY/...Q_STATENAME=NA TOOK TO DEALER: NOT THAT DAY... HAD A STATE INSPECTION IN CHARLOTTE, NC SCHEDULED FOR LATER THAT WEEK AT VW OF SOUTH CHARLOTTE: THEY FOUND ZERO ISSUES WHEN I MENTIONED THE PROBLEM (NO CODES, ETC.) AND DIDN'T CHARGE ME ANYTHING FOR "CHECKING IT OUT". COMMENTS: THIS WAS THE FIRST NO-START SINCE BUYING THE JETTA IN 12/2008. CAR DID HAVE WEIRD "PHANTOM FUEL LOSS" ISSUE SINCE INITIAL IN-SERVICE DATE... AFTER 6 VISITS TO 2 DIFFERENT DEALERS COMPLAINING OF ISSUE IT WAS FINALLY ADDRESSED IN AN ECU UPDATE IN LATE WINTER/EARLY SPRING OF 2011. DATE OF NO START: 5 JAN 2012 LOCATION: PHILADELPHIA, PA MILEAGE: 44250 SIGNIFICANT WEATHER BEFORE NO START: COLD SNAP THE NIGHT BEFORE (MID TEENS F) THEN MEAN OF MID 30'S THIS DAY... HAPPENED IN MORNING OF 5TH WHEN IT WAS STILL COLD FROM NIGHT B

2ND TIRE OF THIS TYPE ON THIS VEHICLE THAT HAS DEVELOPED A SIDEWALL BUBBLE RENDING THE TIRE UNSAFE TO DRIVE ON. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE VEHICLE WOULD JERK STALL AND NO WARNING LIGHTS WOULD ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION, BUT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 14,000 AND THE CURRENT MILEAGE WAS 15,000. UPDATED 02/15/12*LJ THE DEALER STATED THE STALLING PROBLEM WAS DUE TO NOT LETTING THE GLOW PLUG WARM-UP. UPDATED 02/22/12 UPDATED EVOQ 06/26/12

VEHICLE STOPPED RUNNING AT HIGHWAY SPEED. AFTER TOW AND REFUELING CAR FAILED TO START AND RUN. TAKEN TO DEALER FOR SERVICE AND INFORMED THAT HIGH PRESSURE FUEL PUMP WAS DEFECTIVE/HAD FAILED. THIS PROBLEM SEEMS TO BE MORE THAN COMMON FOR THESE TDI VEHICLES. VOLKSWAGEN OF AMERICA REFUSES TO OFFER ASSISTANCE WITH THE MATTER AND WILL NOT ACKNOWLEDGE THAT THESE PUMPS ARE AN ISSUE. *TR

GLOW PLUG LIGHT AND ENGINE FAULT WORKSHOP LIGHT CAME ON AS I WAS PULLING INTO WORK IN A.M. PARKED AND RESTARTED VEHICLE, WITH NO FURTHER WARNING LIGHTS. I MADE APPOINTMENT FOR SCHEDULED MAINTENANCE WITH DEALER. WHEN I LEFT FOR HOME THAT EVENING THE VEHICLE STARTED OK WITH NO WARNING LIGHTS. WHILE DRIVING DOWN THE INTERSTATE FREEWAY AT 70 MPH THE SAME WARNINGS SUDDENLY CAME BACK ON AND VEHICLE SUFFERED IMMEDIATE DECREASE IN POWER WITH SPEED DOWN TO ABOUT 50 MPH. I EXITED THE INTERSTATE AND TRIED TO MAKE IT TO THE VW DEALERSHIP, BUT ENGINE SHUT DOWN WHEN I STOPPED AT STOP SIGN AND WOULD NOT RESTART. VEHICLE WAS PUSHED TO THE ROADSIDE BY STATE POLICE AND HAD TO BE TOWED. VW MECHANIC FOUND THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED WITH EXCESSIVE METAL SHAVINGS FOUND THROUGHOUT THE FUEL SYSTEM. A DIESEL FUEL SAMPLE WAS SENT FOR TESTING AND WAS OKAY. DEALER HAD TO REPLACE THE ENTIRE FUEL SYSTEM. *TR

CAR WOULD NOT START. LUCKILY PARKED IN GARAGE. TOWED TO DEALER. DETERMINED TO BE HPFP FAILURE AND DPF FAILURE. HPFP AND DPF REPLACED ALONG WITH ASSOCIATED SMALL PARTS. BUT DID NOT REPLACE ENTIRE FUEL SYSTEM. A FUEL SAMPLE TAKEN FROM THE FUEL RETURN HOSE WHEN THE CAR DIED LOOKS LIKE FINE METALLIC PARTICLES. SETTLED TO THE BOTTOM OF THE JAR AFTER SEVERAL DAYS. A MAGNET DID NOT ATTRACT THE PARTICLES SO MUST HAVE BEEN ALUMINUM - MOST LIKELY FROM THE PISTON BORE OF THE HPFP. VW PAID FOR THE REPAIR. THE DAY I GOT THE CAR BACK I TOOK A FUEL SAMPLE FROM THE FUEL TANK. ONCE AGAIN METAL PARTICLES (ALONG WITH OTHER DEBRIS NORMALLY FOUND IN A FUEL TANK) WERE FOUND. NOW WE ARE FEARFUL OF DRIVING THE CAR DUE TO METAL PARTICLES IN THE FUEL SYSTEM WILL DESTROY THE NEW HPFP. PLEASE MAKE VW DO A RECALL AND REPLACE THE PUMP WITH A NEW DESIGN THAT WILL NOT SELF DESTRUCT! A CAR THAT SHOULD GO 200K MILES OR MORE HAS FAILED AT 67K MILES. AND IS GUARANTEED TO FAIL AGAIN DUE TO THE POOR DESIGN OF THE HPFP. THIS IS A HUGE FINANCIAL HIT FOR OUR FAMILY AS NOW WE ARE FEARFUL OF DRIVING THE CAR AND MAY HAVE TO SELL IT TO GET A MORE RELIABLE CAR. VW IS BLAMING THE PROBLEMS ON FUEL CONTAMINATION AND THAT MAY BE TRUE BUT THERE IS NO EXCUSE FOR A HUGE REPAIR BILL FROM ONE TANK OF FUEL THAT IS NOT UP TO SPECS. *TR

CAR IS 2009 VOLKSWAGEN JETTA TDI 2.0L COMMON RAIL INTER COOLED TURBO DIESEL.L ISSUE OCCURS AFTER DRIVING IN BELOW FREEZING WEATHER, AND ATTEMPTING TO RESTART AFTER WEATHER HAS GONE ABOVE FREEZING (SUCH AS DRIVING TO WORK IN FREEZING WEATHER, TEMPS WARM UP DURING THE DAY, OCCURS ON ATTEMPT TO DRIVE HOME). VEHICLE WILL START, THEN DIE AFTER A VERY BRIEF RUN OF 5 SECONDS OR LESS. RESTARTS WILL RANGE TO VERY LONG CRANKING BEFORE A VERY ROUGH RUN, OR NO CRANKING WITH ALL LIGHTS AN EQUIPMENT GOING OUT DUE TO VERY HIGH AMP DRAW ON STARTER MOTOR. WATER AND OIL IS NOTED DRIPPING FROM THE INTER COOLER PIPING AS IT LEADS TO THE ENGINES INTAKE. PIPING REMOVED TO ALLOW SOME WATER TO DRAIN OUT. AFTER SEVERAL ATTEMPTS OF 1 REVOLUTION AT A TIME, CAR WILL START TO TURN MORE AND MORE IF A PAUSE OF 30 SECONDS BETWEEN ATTEMPTS IS ALLOWED. SUSPECTED WATER SUCKED INTO COMBUSTION CHAMBER AND HYDRO-LOCKING ENGINE. WATER IS SUSPECTED TO SEEP PAST THE PISTON RINGS INTO THE CRANKCASE WHILE PAUSING BETWEEN START ATTEMPTS. THIS IS PROVEN WITH FROTHY MOISTURE ON THE OIL FILL CAP AFTER EACH INCIDENT. SUSPECTED ISSUE IS MOISTURE FROM EGR SYSTEM GOES INTO INTAKE AIR, AND IS FREEZING IN THE INTER COOLER IN FREEZING WEATHER. WHEN WEATHER WARMS UP WHILE THE CAR IS OFF, THE WATER WILL POOL IN THE INTER COOLER PIPING. UPON ATTEMPTED RESTART, WATER IS SUCKED INTO THE ENGINE CAUSING ANYWHERE FROM SOME ROUGH STUMBLING TO FULL HYDRO-LOCK. INCIDENT HAS HAPPENED 6+ TIMES IN VARYING SEVERITY. ISSUE IS KNOWN TO HAPPEN TO

THE CAR IS A 2009 VW JETTA TDI CLEAN DIESEL. WHILE ON THE NEW YORK STATE THRUWAY AT 55 MPH, SUDDENLY THE CAR'S WARNING CHIME SOUNDED, THE CHECK ENGINE LIGHT CAME ON, THE GLOW PLUG WARNING LIGHT FLASHED AND THE CAR IMMEDIATELY LOST POWER, AND I COASTED TO A STOP ON THE SHOULDER. IT WAS TOWED TO THE NEAREST DEALER, WHO REPLACED THE ENTIRE FUEL SYSTEM AT VW'S COST. THEY SAID IT WAS THE HPFP (HIGH PRESSURE FUEL PUMP) THAT DISINTEGRATED AND DESTROYED THE FUEL SYSTEM, FROM THE FUEL TANK FORWARD. *TR