2004 Toyota Tundra complaints

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA EQUIPPED WITH A WEBASTO HOLLANDIA 600 SUN ROOF ASSEMBLY. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10E038000 (VISIBILITY:SUN ROOF ASSEMBLY). THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REMEDY THE FAILURE WOULD BECOME AVAILABLE WITHIN A TWO WEEK TIME PERIOD. THE PARTS HAD NOT BECOME AVAILABLE FOR APPROXIMATELY SEVEN MONTHS. THE VEHICLE WAS NEVER REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE DRIVING, THE CONTACT STATED THAT THE LOWER FRONT CONTROL ARM BROKE ON BOTH THE PASSENGER AND DRIVERS SIDE OF THE VEHICLE. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DID NOT ASSIST THE CONTACT WITH THE FAILURE. THE FAILURE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 65,000.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT HEARD A CRACKING SOUND COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE SUDDENLY DROPPED TO THE GROUND AND THE CONTACT WAS UNABLE TO CONTROL THE VEHICLE. THE VEHICLE CAME TO A STOP INDEPENDENTLY AND WAS TOWED TO THE CONTACTS HOME. A MECHANIC INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE FRONT, DRIVER SIDE UPPER AND LOWER BALL JOINTS WERE BROKEN AND CAUSED THE WHEEL TO DETACH FROM THE VEHICLE. THE FAILURE CAUSED DAMAGE TO THE BRAKE LINES, ABS LINES, LOWER CONTROL ARMS, DRIVE SHAFT AND CONTROL ARM SHAFT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

[XXX], THE OWNER OF TOYOTA 2004 TUNDRA VEHICLE ID [XXX] FOR TOYOTA CASE #[XXX]. AS REPORTED TO THE TOYOTA CUSTOMER EXPERIENCE CENTER (CENTER) ON MARCH 7, 2011, [XXX] AND HIS VEHICLE WERE INVOLVED IN A VERY FRIGHTENING AND TRAUMATIC INCIDENT ON MARCH 3RD. THE FRONT ARM, JOINT, AND WHEEL OF THE VEHICLE SUDDENLY BROKE APART AND FELL OFF THE VEHICLE WHILE DRIVING 65 MPH ON THE HIGHWAY. WITH OTHER DRIVERS WATCHING, [XXX]WAS ABLE TO CONTROL AND MANEUVER THIS CRIPPLED VEHICLE 2,000 FEET - FROM THE INNER MOST LANE TO THE SHOULDER OF THE ROAD WITHOUT CAUSING INJURY TO HIM AND OTHERS, DRIVERS/VEHICLES. AS STATED BY THE POLICE AT THE SCENE AND OTHERS WITNESSED THE INCIDENT, IT WAS SIMPLY A MIRACLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY 2004 TOYOTA TUNDRA MUST BE MANUALLY ATTENDED WHEN PUMPING FUEL. IF THE PUMP IS SET TO AUTOMATICALLY PUMP UNTIL THE TANK IS FULL, THE PUMP WILL STOP FUELING BEFORE THE TANK IS FULL AND OCCASIONALLY STOPS WITH SUCH FORCE THAT THE PUMP JUMPS OUT OF IT'S POSITION IN THE VEHICLE AND ONTO THE GROUND SPILLING GAS. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE AT A TRAFFIC LIGHT THE VEHICLE SUDDENLY CAUGHT FIRE NEAR THE FUEL PUMP. THE CONTACT WAS ABLE TO SAFELY GET OUT OF THE VEHICLE IMMEDIATELY AND CALL THE FIRE DEPARTMENT WHO EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE CONTACT NOTIFIED THE MANUFACTURER REGARDING THE FIRE AND FILED A CLAIM. THE MANUFACTURER ALSO HAD THE VEHICLE INSPECTED BY AN INVESTIGATOR WHICH CONFIRMED THAT THE FIRE STARTED WITHIN THE FUEL PUMP. THE CONTACT RECEIVED A LETTER AFTER THE INVESTIGATION FROM THE MANUFACTURER STATING THAT THEY WERE NOT RESPONSIBLE. THE CONTACT STATED THAT SINCE THE FAILURE WAS A SAFETY ISSUE, THE MANUFACTURER SHOULD BE RESPONSIBLE. THE FAILURE MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT WHEN DRIVING AT HIGHWAY SPEEDS, THE CHECK ENGINE WARNING LIGHT WOULD INTERMITTENTLY ILLUMINATE. SHE WOULD ATTEMPT TO ACCELERATE YET THE VEHICLE WOULD NOT RESPOND BEFORE STALLING. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE THROTTLE WOULD NEED TO BE REPLACED. THE THROTTLE WAS REPLACED. THE FAILURE RECURRED AND THE THROTTLE WAS REPLACED A SECOND TIME AT A LOCAL REPAIR FACILITY BY A CERTIFIED MECHANIC BUT TO NO AVAIL. THE THROTTLE WAS REPLACED A THIRD TIME YET IT DID NOT CORRECT THE FAILURE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHO ADVISED THAT THE THROTTLE WAS DEFECTIVE. THE CONTACT ADVISED THAT THE THROTTLE WAS REPLACED THREE TIMES TO NO AVAIL. THE DEALER THEN ADVISED THAT THERE WAS WATER LEAKING INTO THE CONNECTOR THROUGH THE WINDSHIELD GLASS. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE SAFETY OF THE VEHICLE STALLING AND THE POSSIBILITY OF A CRASH. THE FAILURE MILEAGE WAS 27,484 AND THE CURRENT MILEAGE WAS 42,556.

COLUMN SHIFTER OVERDRIVE ON/OFF SWITCH WIRE LEADS IN 2004 TOYOTA TUNDRA FAILS OR SHORTS OUT CAUSING LOSS OF CONTROL OF OVERDRIVE SETTING ON AUTOMATIC TRANSMISSION. THIS CAN CAUSE DOWNSHIFTING AT HIGHWAY SPEED OR YOUR VEHICLE TO NOT SHIFT INTO OVERDRIVE CAUSING POOR FUEL ECONOMY PROBLEM OCCURS AFTER SO MANY SHIFT CYCLES OF THE COLUMN SHIFTER FROM PARK TO DRIVE CAUSE THE WIRE LEADS TO BREAK FROM METAL FATIGUE CAUSING THE FAILURE OR SHORT IN THE SWITCH MY TRUCK STARTED THIS WITH ABOUT 123,000 MILES ON IT. I FOUND NUMEROUS POSTS ON THE WEB DETAILING THE FIX ON THIS PROBLEM. UPON INVESTIGATION I FOUND THE ROUTING OF THE WIRES IS CAUSING THE ISSUE AND YOU CAN SEE WHERE TOYOTA HAS TRIED TO TAPE THE WIRES TO GIVE EXTRA PROTECTION IN A POOR ROUTING OF THE SWITCH WIRES. *TR

2004 TOYOTA TUNDRA. CONSUMER STATES ELECTRONICS MALFUNCTION. TAPE ENCLOSED. *TGW THE CONSUMER STATED WHEN THE VEHICLE WAS IN OVERDRIVE, THE RPM'S WERE 2,000 AND WHEN THE OVERDRIVE WAS TURNED OFF, THE RPM'S READ 3,000 WHICH WAS OPPOSITE OF THE NORMAL FUNCTION. *JB UPDATED 09/24/10

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHEN THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, THE FRONT DRIVER SIDE TIRE DISENGAGED FROM THE VEHICLE WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE POLICE ARRIVED AT THE SCENE. THERE WERE NO INJURIES OR DAMAGES. THE CONTACT EXPERIENCED THE IDENTICAL FAILURE WITH NHTSA CAMPAIGN ID NUMBER 05V225000 (SUSPENSION: FRONT: CONTROL ARM: LOWER BALL JOINT). THE FAILURE AND CURRENT MILEAGES WERE 103,000.

I OWN A 2004 TOYOTA TUNDRA PICKUP TRUCK. THE BOTTOM OF THE TRUCK IN THE REAR HAS RUSTED AND THE SHOCK MOUNT BROKE OFF. THE PIECE THAT BROKE OFF ALSO HAS THE BRAKE LINES ATTACHED. THIS CAN POTENTIALLY LEAD TO THE LINES SNAPPING AND FAILING. I SAW A RECALL ON THIS FOR 2000 TO 2003 YEARS BUT NOT FOR 2004. THE PROBLEM IDENTIFIED IN THE RECALL IS THE EXACT PROBLEM I AM HAVING. I AM ALSO CONCERNED THAT THE MOUNT FOR THE SPARE TIRE WILL CONTINUE TO RUST AND FALL OFF. *TR

THE 2004 TOYOTA TUNDRA THAT I HAVE HAD TO HAVE THE BOTH FRONT ROTORS REPLACED DUE TO WARPING AND SERIOUS VIBRATIONS DURING BRAKING. I RESEARCHED THIS ON THE TOYOTA FORUMS AND ALL OVER THE INTERNET. THIS IS A WELL DOCUMENTED ISSUE THAT MANY OF US OWNERS HAVE COMPLAINED ABOUT TO TOYOTA. TOYOTA HAS NOT ADDRESSED THIS ISSUE AS THE ROTORS WERE MADE TO SMALL FOR THE SIZE AND WEIGHT OF THE VEHICLE. THIS IS CLEARLY A DESIGN FLAW THAT HAS BEEN OVERLOOKED. VIBRATIONS. SEE ARTICLE HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/TOYOTA_TUNDRA_BRAKES.HTML I HAD TO FIX THESE BRAKES OUT OF MY OWN POCKET LIKE THE REST OF TOYOTA TUNDRA OWNERS. THIS SHOULD HAVE BEEN RECALLED. THANKS. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH BEFORE APPROACHING A STOP SIGN. THERE WAS AN UNINTENDED ACCELERATION. THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE CONTINUED WITHOUT SLOWING DOWN. THE IGNITION KEY WAS REMOVED FROM THE IGNITION AND THE VEHICLE CRASHED INTO A WALL. THERE WERE TWO PASSENGERS IN THE VEHICLE THAT SUSTAINED INJURIES. THE AIR BAGS FAILED TO DEPLOY WITH THE IMPACT INVOLVED. A POLICE REPORT WAS TAKEN. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 34,000.

THE BRAKES FAILED TO DISENGAGE THE CRUISE CONTROL AND THE VEHICLE CONTINUED TO GAIN IN SPEED AS I WAS EXITING THE FREEWAY. I TURNED THE IGNITION OFF AND TRIED TO NAVIGATE A LEFT TURN AT 70+ MPH. WITH THE REAR END HOPPING SOMEHOW I NEGOTIATED THE TURN BUT COULD NOT TURN AGAIN. I CROSSED THE NEXT STREET AND ENDED UP GOING THRU THE WALL OF AN APARTMENT BUILDING AND STOPPED IN THE MIDDLE OF THE LIVING ROOM. IT WAS ONLY GOD'S DESIGN FOR ME NOT TO DIE THIS DAY. HAD I NOT MADE THE FIRST TURN I WAS GOING TO RUN INTO A SMALL GROVE OF MATURE TREES. ALSO, IF ANY OTHER CARS HAD BEEN ON THE STREET I COULD NOT HAVE AVOIDED THEM. LUCKILY THE SINGLE MOTHER OF 3 SMALL CHILDREN WERE NOT IN THE LIVING ROOM. *TR

STARTED TRUCK, CONNECTED SMALL TRAILER TO HITCH. I NOTICED LIGHTS ON TRAILER NOT ON GOT OUT OF TRUCK TO PLUG AND UNPLUG CONNECTOR. LIGHTS CAME ON. ENTERED TRUCK , PUT FOOT ON BRAKE TO PUT IN GEAR. THE ENGINE REVVED UP AND THE TACH. WAS FLUCTUATING BETWEEN 1000 AND 6500 RPM WITHOUT EVER TOUCHING THE ACCELERATOR. I TURNED THE IGNITION TO THE OFF POSITION. SCARED TO RESTART, I LET IT SIT FOR FIVE MINUTES THEN STARTED ENGINE. EVERYTHING RAN NORMAL AND I PROCEEDED TO DRIVE HOME. THIS HAD NEVER OCCURRED BEFORE OR SINCE THIS INCIDENT. I DID NOT REPORT THIS TO TOYOTA SINCE THE RECALL MODELS WERE OTHER THAN MY 2004 TOYOTA TUNDRA . *TR

MY 2004 TOYOTA TUNDRA DOUBLE CAB HAS AN EXCESSIVE AMOUNT OF RUST ON THE UNDERCARRIAGE. BECAUSE OF THIS RUST, THE CAMBER BOLTS CANNOT BE REMOVED TO PROPERLY ALIGN THE VEHICLE. I HAVE BEEN TOLD THAT THEY WILL HAVE TO USE HEAT TO REMOVE THEM, ALONG WITH A LOT OF FORCE, AND IN TURN MAY DO FRAME DAMAGE IN THE PROCESS. I HAVE BEEN QUOTED BY MY DEALER $5,200 TO FIX THE PROBLEM WHICH INITIALLY STARTED WITH A SMALL SHIMMY IN THE STEERING WHEEL WHICH GREW INTO A BIG SHIMMY ESPECIALLY WHILE TOWING. THAT QUOTE DOES NOT INCLUDE ANY POSSIBLE CHARGED FROM THE BODY SHOP IF DAMAGE TO THE FRAME SHOULD OCCUR. I DO NOT HAVE $5,200 SO I ENDED UP WITH A NEW SET OF TIRES AND HALF OF AN ALIGNMENT BECAUSE THE CAMBER BOLTS WERE NOT ABLE TO BE REMOVED. HERE I AM MONTHS LATER AND MY NEW TIRES ARE SO BALD ON THE FRONT THAT I AM ACTUALLY SEEING THE TREAD SHOWING THROUGH. I HAVE ALWAYS LOVED MY TUNDRA, BUT ALL OF THIS RUST ON THE FRAME AND UNDERCARRIAGE IS VERY CONCERNING REGARDING THE LONGEVITY OF MY VEHICLE. I WAS TOLD THAT TOYOTAS LAST FOREVER. AT THIS POINT I FEEL THAT MY TRUCK IS DANGEROUS TO EVEN DRIVE BUT IT IS MY ONLY VEHICLE. I HAVE OWNED AND MAINTAINED MANY VEHICLES AND NEVER HAD RUST ISSUES LIKE THIS, NOR HAVE I EVER BEEN FACED WITH SUCH A COSTLY REPAIR ON A NOT SO OLD VEHICLE. I AM STUCK IN A BAD PLACE AND JUST DON'T KNOW WHERE TO GO OR WHAT TO DO. I DESPERATELY NEED MY TRUCK. WITHOUT IT I LOSE MY SOURCE OF TRANSPORTATION AS WELL AS MY ABILITY TO EARN A LIVING. I JUST SIMPLY CANNOT AFFORD... ME

I WAS IN LINE TO GO THROUGH THE GATE AT THE LAKE. I HAD 6 CARS IN FRONT OF ME AND I HAD MY FOOT ON THE BRAKE WAITING FOR THE CARS TO MOVE. THE RPM WENT UP IN MY 2004 TUNDRA AND THE TRUCK STARTED TO MOVE FORWARD. I PUSHED HARDER ON THE BRAKE BUT IT DID NOT STOP. IT CONNECTED WITH THE BUMPER OF THE CAR IN FRONT AND STARTED TO PUSH IT. I PUT THE TRUCK IN NEUTRAL AND TURNED THE IGNITION OFF. THE TRUCK STOPPED THEN. THE DAMAGE WAS ONLY A SCRATCHED BUMPER. *TR

2004 TOYOTA TUNDRA DOUBLE CAB HAD SEVERE RUSTING WHICH CAUSED THE EMERGENCY BRAKE CABLE AND PIN ATTACHMENTS TO BREAK. WHEN THE DEALER FIXED THE BRAKE, I WAS TOLD THAT THE PROBLEM WAS CAUSED BY VERY RUSTED PARTS WHICH THEN LED ME TO DISCOVER THAT THE ENTIRE FRAME OF THE TRUCK IS HEAVILY RUSTED. DEALER CALLED IT FLAKING. I CONTACTED TOYOTA AND THE DEALER WAS INSTRUCTED TO INSPECT THE TRUCK AND SEND RESULTS TO TOYOTA. THEY NOW CALL IT SURFACE RUST. I ASKED THE DEALER TO PUT IN WRITING THAT THE TRUCK WAS SAFE BUT THEY DID NOT. I AM NOW CONCERNED THAT WITH THE FRAME, BOLTS, NUTS AND JOINTS SO RUSTY IT WILL SOON BECOME A SAFETY ISSUE. I HAVE LOOKED AT OTHER TUNDRA'S THE SAME AGE AND THE UNDERCARRIAGE APPEARS TO HAVE AN UNDERCOATING THAT I DO NOT. I AM NOT SATISFIED WITH THE ANSWER THAT TOYOTA HAS GIVEN ME WHICH STATES THAT IT IS ONLY SURFACE RUST. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE DRIVING 52 MPH THE FRONT PASSENGER WHEEL DETACHED FROM THE VEHICLE. HE WAS ABLE TO SAFELY STOP THE VEHICLE. THE ENTIRE WHEEL ASSEMBLY AND DRIVE TRAIN WERE ON THE GROUND. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY. HE WAS ADVISED BY THE MANUFACTURER THAT HIS VEHICLE IDENTIFICATION NUMBER WAS INCLUDED IN RECALL #07V013000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). HE FILED A COMPLAINT, AND THE CASE# IS 0910124225. HE WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS 75,000.

FRAME RUST. *TR

2004 TOYOTA TUNDRA LEAKS GEAR OIL FROM REAR DIFFERENTIAL COVER PLATE. COVER PLATE IS SO THIN A PIN HOLE DEVELOPED. COVER PLATE IS PRESSED ON SO IN ORDER TO CORRECT PROBLEM, A WHOLE NEW REAR AXLE IS NEEDED ACCORDING TO DEALER. WHEN I BROUGHT TRUCK INTO DEALER, DEALER TOLD ME HE SEEN 6 OF THESE LIKE THIS ALREADY. METAL PLATE IS TOO THIN AND DOESN'T HOLD UP TO WINTERS IN NEW YORK AND IS RUSTING OUT DUE TO METAL BEING TOO THIN. COST FOR REPAIR IS $3500 . WHEN I CONTACTED TOYOTA, THEY JUST SAID THERE ISN'T ANY RECALLS ON THIS SUBJECT YET. THEY DID RECALL TOYOTA TACOMAS DUE TO RUST EATING OUT THE FRAMES BUT NO RECALLS ON REAR DIFFERENTIAL COVER PLATE. IF GEAR OIL FOR REAR DIFFERENTIAL LEAKS OUT, DUE TO METAL FATIGUE, TRUCK IS NOT DRIVABLE AND HEAT CAUSED BY FRICTION OF GEARS COULD CAUSE A FIRE. *TR

2004 TOYOTA TUNDRA DOUBLE CAB SR5 WITH 54000 MILES- FRONT SWAYBAR LINKS BREAKING. I JUST BROUGHT MY TRUCK INTO THE DEALERSHIP FOR AN OIL CHANGE AND BOTH FRONT SWAY BAR LINKS ARE BROKEN. LOOKING ON A COUPLE OF SITES, THIS APPEARS TO BE A COMMON PROBLEM. THE TRUCK IS FACTORY ORIGINAL AND IS A PERSONAL VEHICLE, NOT USED FOR OFF ROAD TRAVEL. *TR

THE GLASS ON THE SUNROOF OF MY 2004 TOYOTA TUNDRA CAME LOOSE. *TR

VEHICLE FRAME AND UNDERCARRIAGE SEEMS TO HAVE AN EXCESSIVE AMOUNT OF RUST AND DETERIORATION. AS I PERFORM MAINTENANCE ON THE VEHICLE, I AM REPLACING RUSTED PARTS INCLUDING BOLTS, DRAIN PLUGS AS WELL AS SPRAYING THE UNDERCARRIAGE WITH WD-40, 3M UNDERCOATING SPRAY AND CORROSION STOP. THIS ISSUE IS AN ON-GOING FIGHT TO KEEP THE RUST AT BAY. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT THERE WAS A SHORTAGE IN THE ELECTRICAL SYSTEM IN HIS VEHICLE. THE FAILURE AFFECTED THE CRUISE CONTROL, DOOR LOCKS, POWER WINDOWS, AND ALL OTHER ELECTRICAL COMPONENTS. HE CALLED THE DEALER AND MANUFACTURER AND WAS INFORMED THAT THE FAILURE WAS NOT UNDER WARRANTY; THEREFORE, HE WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THERE WERE NO RECALLS AVAILABLE. THE FAILURE MILEAGE WAS 61,000.

UNKNOWN WHAT HAS CAUSED THIS, IT SEEMS AS IF THE WINDOWS ON MY 2004 TOYOTA TUNDRA DOUBLE CAB WILL FALL OUT OR JUST BREAK IF A DOOR IS CLOSED AND THE RESPECTIVE WINDOW IS NOT ALL THE WAY UP. SHOULD YOU FORGET YOU WILL BE REMINDED BY THE HORRIBLE SOUND AND THE EXCESSIVE MOVEMENT THE WINDOW MAKES WHEN YOU CLOSE THE DOOR OR FORGET TO ROLL UP THE WINDOW WHEN YOU DRIVE THIS VEHICLE. THE ONLY FIX I HAVE FOUND IS TO NOT LEAVE YOUR WINDOWS DOWN AND TO ALWAYS HAVE THEM ALL THE WAY UP. THIS PROBLEM IS NOT ONLY ANNOYING BUT IS CLEARLY A DISTRACTION WHILE OPERATING TRUCK. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT SWERVED TO AVOID AN ANIMAL IN THE ROAD. AS A RESULT, THE VEHICLE CRASHED INTO A DITCH AND TURNED OVER. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED AN INJURY TO HIS BACK. THE POLICE DEPARTMENT WAS CALLED TO THE SCENE AND THEY FILED A REPORT. THE VEHICLE WAS COMPLETELY DESTROYED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 92,00 UPDATED 09/15/08 *BF. UPDATED 09/18/08. *JB

I HAD TWO AUTO REPAIR SHOPS TELL ME THAT MY BALL JOINTS WERE BAD I WENT TO HADDAD TOYOTA TO HAVE THEM CHECKED HADDAD TOYOTA TOLD ME THERE WAS NOTHING WRONG WITH THE BALL JOINTS. I THEN PROCEEDED TO HAVE NEW TIRES PUT ON BECAUSE OF EXCESSIVE WEAR AT THE TIME THE TIRE STORE SAID YOU HAVE TO REPLACE YOUR VBALL JOINTS SO AT A COST OF 500 DOLLARS I HAD THEM REPLACED WHEN THE FIRST RECALL CAME OUT AFTER I HAD THE JOINTS REPLACE I SENT AL,L THE INFORMATION TO TOYOTA FOR REFUND OF MY MONEY. THEY SAID BECAUSE I HAD THE REPLACEMENT DONE BY SOMEONE OTHER THAN TOYOTA I COULD NOT GET MY MONEY . IS THERE ANY WAY I CAN RECOVER THE MONEY I SPENT AFTER TOYOTA DENIED THERE WAS ANYTHING WRONG WITH THE BALL JOINTS? *TR

THERE ARE TWO CABLES THAT HOLD THE TAILGATE IN PLACE WHEN FULLY OPENED(EXTENDED). YESTERDAY(7/17/08) WHILE UNLOADING MY MOTORCYCLE, BOTH CABLES BROKE SIMULTANEOUSLY MID WAY THROUGH THE UNLOADING PROCESS. THE CABLES BROKE AT THE EXACT SAME PLACE WHICH WAS EXACTLY HALF WAY FROM ONE END TO THE OTHER. THE CABLE IS ENCLOSED IN A PLASTIC SLEEVE. THAT SLEEVE IS NOT SEALED AT EACH END. WHEN THE TAILGATE IS IN THE CLOSED POSITION, WHICH IS MOST OF THE TIME, RAIN OR OTHER MOISTURE COLLECTS IN THE PLASTIC ENCLOSURE AND SETTLES AT THE BOTTOM OF THE "U" SHAPED TUBE. OVER TIME THAT MOISTURE HAS CAUSED THE CABLES TO RUST AND WEAKEN THUS THE BREAK IN MY OPINION. THE RESULT OF THE BRAKE WAS THAT THE TAILGATE FEEL UNANNOUNCED TO THE TOP OF THE BUMPER THUS DENTING THE BUMPER AND POTENTIALLY CAUSING HARM TO THE INDIVIDUAL WHO WAS DOING THE UNLOADING. IN MY OPINION THIS IS A FLAWED PRODUCT. *TR

FRONT DISC BRAKE ROTORS SUBJECT TO REPEATED WARPING CAUSING FRONT WHEEL TO VIBRATE WHEN BRAKING AND MAKING THE VEHICLE HARD TO CONTROL. *TR

EVENT WAS THE GEAR LEVER BECAME LOOSER AND LOOSER. IT RESULTED IN THE GEAR NOT BEING ABLE TO GO INTO PARK. TRUCK WOULD NOT START. IT APPEARED TO BE IN PARK AND I THOUGHT IT WAS A DEAD BATTERY. AAA REPLACED BATTERY. IT WAS NOT THE PROBLEM. CREATIVE GEAR MANIPULATION ALLOWED TRUCK TO START. REPAIR DISCOVERED A CRACKED STEERING COLUMN! *TR

2004 TOYOTA TUNDRA WITH 44000 MILES HAS DEVELOPED A BRAKE PROBLEM. AIR REPEATEDLY GETS INTO THE BRAKE LINES WITH NO LOSS OF FLUID CAUSING THE BRAKE PEDAL TO GO TO THE FLOOR WHEN BRAKING. THE TUNDRA HAS BEEN AT THE DEALER FOR FOUR MONTHS TRYING TO BE REPAIRED, THE TOYOTA REP HAS VISITED ON FIVE SEPARATE OCCASIONS, CALLED THE FACTORY ENGINEERS AND IT IS STILL NOT FIXED! REPAIRS COST TO DATE ARE OVER $3500, TOYOTA PICKED UP $2,000 LEAVING ME OUT OF POCKET $1500+ AND A TRUCK THAT HAS A DEFECTIVE BRAKING SYSTEM THAT MUST BE BLED EVERY 75 MILES TO REMAIN DRIVABLE. THIS PROBLEM STARTED IN MID JANUARY 2008. *TR

FAULTY WINDOW REGULATOR DESIGN CAUSES WINDOWS TO RATTLE VIOLENTLY POTENTIALLY LEADING TO SHATTERING. *TR

2004 TOYOTA TUNDRA RECALL FOR FRONT BALL JOINTS--2006 RECEIVED NOTICE AND TOOK TO DEALER IN BOZEMAN, MT TO CHECK...WE WERE TOLD OUR TRUCK WASN'T PART OF RECALL....MONTHS LATER, RECEIVED ANOTHER NOTICE...CALLED AND EMAILED DEALER, BUT THEY DID NOT RETURN CALLS OR EMAILS. OCTOBER 2007 FRONT PASSENGER WHEEL "BROKE" WHILE DRIVING AND WE WRECKED. DEALER IN LARAMIE, WY STATED THAT "YES, YOUR TRUCK WAS PART OF THE RECALL AND THIS WAS DUE TO FRONT BALL JOINT FAILURE." LUCKILY WE WERE ONLY DRIVING 10MPH, BUT IF WE HAD BEEN DRIVING ON INTERSTATE, WE WOULD HAVE ROLLED. *TR

LOWER BALL JOINT RECALL DANGER. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHEN THE REAR WINDOWS ARE ROLLED DOWN, THE CONTACT HEARS A DEAFENING NOISE. THE VEHICLE HAS BEEN TAKEN TO THE DEALER SIX TIMES, BUT THE NOISE CONTINUES. THE CURRENT MILEAGE WAS 105,000 AND FAILURE MILEAGE WAS 38,000. UPDATED 02-14-08 *BF UPDATED 02/14/08 *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT THE STOPPING DISTANCE EXTENDED WHEN HE DEPRESSED THE BRAKE PEDAL. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE; HOWEVER, THEY ADJUSTED THE BRAKES. APPROXIMATELY SIX MONTHS LATER, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO A DIFFERENT DEALER AND THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE; HOWEVER, THEY ADJUSTED THE BRAKES AGAIN. AS OF DECEMBER 26, 2007, THE FAILURE HAD NOT RECURRED. THE CONTACT FELT THAT THE SLACK ADJUSTER CAUSED THE FAILURE, BUT THE DEALER STATED THAT THE SLACK ADJUSTER WAS FINE. THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 21,000. UPDATED 01/17/08. *LJ

THE BRAKES ON MY 2004 TOYOTA TUNDRA DOUBLE-CAB DO NOT WORK PROPERLY (AND NEVER HAVE). WHEN YOU PRESS ON THE BRAKE PEDAL, THE BRAKES MAKE A LOUD NOISE (NOT THE TYPICAL ANTI-LOCK BRAKE NOISE) AND DO NOT STOP EFFECTIVELY. I'VE ALMOST RAN INTO CARS IN FRONT OF ME. I TOOK IT TO STEVINSON TOYOTA, BUT THEY SAID THE BRAKES WERE FINE. THEY WEREN'T. I TOOK IT PEP BOYS AND THEY REPLACED THE PADS & TURNED THE ROTORS. IT IS BETTER, BUT STILL BAD. I THINK I'LL GET RID OF THE TRUCK. SOMEONE IS GOING TO GET HURT WITH THIS BRAKE SITUATION ON THE TRUCK MODEL. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V013000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). HE IMMEDIATELY SCHEDULED AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED. THE DEALER STATED THAT IT WOULD TAKE THREE MONTHS TO GET REPAIRED BECAUSE THE PARTS WERE ON BACK ORDER. IT HAS NOW BEEN NINE MONTHS AND THE DEALER WILL NOT RETURN HIS PHONE CALLS. HE ATTEMPTED TO FILE A COMPLAINT WITH THE MANUFACTURER, BUT THEY GAVE HIM AN INCORRECT TELEPHONE NUMBER. HE STATED THAT THE VEHICLE VIBRATES TERRIBLY WHEN THE BRAKES ARE APPLIED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 34,600.

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A FRONT SUSPENSION LOWER BALL JOINT RECALL NOTICE IN JUNE OF 2007. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THEY DID NOT HAVE THE PARTS FOR THE RECALL REPAIR AND WOULD HAVE TO WAIT A MONTH FOR THEM TO ARRIVE. A MONTH LATER HE CALLED THE DEALER AND WAS INFORMED THAT THE PARTS WERE STILL UNAVAILABLE AND THEY WOULD CALL HIM WHEN THE PARTS ARRIVED. MONTHS PASSED AND THE CONTACT NEVER RECEIVED A PHONE CALL. WHILE DRIVING APPROXIMATELY 45 MPH, THE BALL JOINTS BECAME LOOSE AND HE LOST CONTROL OF THE VEHICLE. WHEN THE VEHICLE FINALLY CAME TO A STOP, IT WAS TOWED TO THE SHOP. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 87,000. UPDATED 12-12-07. *KB UPDATED.

OVER THREE MONTHS AGO, I CALLED DAVID MAUS TOYOTA IN SANFORD TO GET THE LOWER BALL JOINTS ON MY 2004 TOYOTA TUNDRA PER RECALL SSC 70B. I WAS TOLD IT WOULD TAKE SIX TO EIGHT WEEKS FOR THE PARTS TO COME IN AND THEY WOULD CALL ME WHEN IT DID. I HAVE NOT HEARD FROM THEM YET AND THEY HAVE NOT RETURNED MY PHONE CALLS. THE FRONT END OF MY TRUCK IS ACTING UN-STABLE AT THIS TIME AND I FEAR THAT I MIGHT GET INTO AN ACCIDENT IF I CONTINUE TO DRIVE IT IN THIS CONDITION. *TR

GAS TANK DEFECT, SOMETIMES IT INDICATES EMPTY TANK BUT IT IS NOT EMPTY, SOMETIMES IT INDICATE FULL TANK BUT IT IS NOT FULL. THIS TANK IS UNPREDICTABLE POSSIBLY A MANUFACTURING DEFECT. ALSO THE TIRES WEARS FASTER ON THE OUTER SURFACE UNEVEN. SOMETIMES THE VEHICLE VEERS OFF TO LEFT AND SOMETIMES TO THE RIGHT MAY BE RELATED TO BALL JOINTS DEFECT OR SLOPPY TOYOTA TECHNICIAN WORK OR BOTH. *TR UPDATED 02/01/08 *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED RECALL NOTICE NUMBER 05V225000 (SUSPENSION FRONT:LOWER BALL JOINTS). WHILE DRIVING, THE VEHICLE SHAKES SEVERELY. THE CONTACT HAS CALLED THE DEALER TO HAVE THE RECALL REPAIRED, HOWEVER, THEY CONTINUE TO INFORM HIM THAT THE PARTS ARE UNAVAILABLE AND THAT HE WOULD HAVE TO PAY FOR THE REPAIR. THE CONTACT STATED THAT THE RECALL NOTICE INDICATED THAT THE REPAIR WOULD BE PERFORMED FOR FREE. THE DEALER STATED THAT THEY WOULD CALL HIM WHEN THEY HAD AN AVAILABLE APPOINTMENT TIME, BUT THEY HAVE NOT CALLED OR PROVIDED A LOANER OR RENTAL VEHICLE. THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 41,000 AND CURRENT MILEAGE WAS 42,000.

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. HE STATED THE HE HEARD A NOISE COMING FROM THE FRONT END OF HIS VEHICLE. THERE IS A RECALL FOR THE FRONT LOWER BALL JOINTS (NHTSA CAMPAIGN # 07V013000). THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 43,000.

I WAS DRIVING TO MY LOCAL MCDONALD'S DRIVE THROUGH AND I FELT SOMETHING UNUSUAL ON MY STEERING WHEEL. I GOT OUT AND CHECKED NEAR FRONT SUSPENSION AND I FOUND OUT THAT THE TIE ROD ON THE RIGHT SIDE IS BROKEN/DISCONNECTED. I WAS FORTUNATE ENOUGH NOT TO EXPERIENCE THIS BROKEN TIE ROD ON HIGHWAY. *TR

I RECEIVED A RECALL NOTICE FOR MY 2004 TOYOTA TUNDRA FOR THE FRONT BALL JOINTS. I HAVE CALLED 3 TIMES AND EACH TIME MY NAME IS SUPPOSEDLY PLACED ON A LIST TO CALL AS SOON AS THE PART ARRIVES. WELL, 90 DAYS LATER I HAVEN'T HEARD FROM ANYONE. I CALLED MY LOCAL DEALER TODAY AND WAS TOLD MY INFORMATION WOULD HAVE TO BE TAKEN DOWN AND THEY WOULD CALL WHEN THE PART ARRIVED, I ESCALATED AND SPOKE TO THE MANAGER TO SAID THE PART WAS IN BUT IT COULD ONLY BE INSTALLED ON 7/25/07, NO OTHER DAY OF THE WEEK WOULD WORK SINCE HIS STAFF IS GOING BACK TO SCHOOL? I GUESS THEY JUST EXPECT ME TO QUIT MY JOB IN AN EFFORT TO HAVE THIS PROBLEM FIXED. I ALSO ESCALATED THIS ISSUE TO THE MANAGER OF SERVICE DEPARTMENT AT LAKE NORMAN DEALERSHIP WHERE TRUCK WAS PURCHASED. THEY KEPT TRANSFERRING ME TO SERVICE DEPT THEN TO PARTS, AFTER ABOUT 30 MINUTES, I ASKED IF THEY WOULD EVEN HONOR THE RECALL NOTICE AND THEY SAID YES, BUT I HAVE TO BE TRANSFERRED AGAIN, NO ONE EVER ANSWERED. I HAVE BEEN DEALING WITH THIS WAY TO LONG AND DO NOT UNDERSTAND WHY TOYOTA WILL NOT STAND BEHIND THEIR PRODUCTS, I DIDN'T DO ANYTHING TO THE VEHICLE AND THIS WASN'T MY FAULT, I WISH SOMEONE COULD HELP! I DO NOT TRUST ANY OF THE DEALERS I HAVE SPOKE TO AT THIS POINT BECAUSE I FEEL LIKE THEY ARE ALL LYING TO ME AND TRYING TO GET OUT OF REPAIRING MY TRUCK. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE DRIVING 65 MPH, THE FRONT SUSPENSION FAILED AND THE PASSENGER SIDE FRONT TIRE AND RIM DETACHED FROM THE VEHICLE. THE VEHICLE IS CURRENTLY AT THE DEALER. THE CAUSE OF THE SUSPENSION FAILURE HAS NOT YET BEEN DIAGNOSED. THE CURRENT AND FAILURE MILEAGES WERE 69,000.

I RECEIVED A SAFETY RECALL NOTICE ON MY 2004 TOYOTA NOTICE #SSC 70B FRONT BALL JOINTS, I CONTACTED THE LOCAL TOYOTA DEALERSHIP WHERE I PURCHASED THE VEHICLE, THEY HAVE STATED I MUST GO ON A WAITING LIST AS THERE ARE LIMITED SUPPLIES OF THE REPLACMENT PARTS FROM TOYOTA, 2-WEEKS LATER THEY ARE NOW TELLING ME IT MAY BE "WEEKS AND WEEKS" BEFORE PARTS ARE AVAILIBLE. MY COMPLAINT IS WITH TOYOTA FOR NOT FOLLOW THROUGH ON PROVIDING THIER DEALERSHIPS WITH THESE PARTS IN A TIMELY FASHION, ESPECIALLY IN THIS CASE WHERE THIS IS A CRITICAL REPAIR. PLEASE FEEL FREE TO CONTACT ME IF FURTHER INFO IS NEEDED, AND FEEL FREE TO PRESSURE-CHEW OUT TOYOTA. THANKS FOR YOUR HELP.

WHILE DRINVING AT SPEED OF 55 MPH ON AVENUE THE WHOLE TIRE FELL OFF , CUTIIN BRAKE HOSE AND TIRE GOT TRAP UNDER NEATH . *AK

FRONT BALL JOINT ON DRIVER'S SIDE JUST COLLAPSED AND THE AXLE CAME OUT AND THE WHEEL TURNED SIDEWAYS AT 45 MPH, CAUSING A 300' SKID.*AK