2000 Toyota Tundra complaints

2000 TOYOTA TUNDRA 2WD 4.7L V8 AUTOMATIC SR5 EXTENDED CAB 1. TRANSMISSION NOISE AND TRANSMISSION "BUMP" WHEN STARTING OUT FROM STOP. IT OCCURRED FROM APPROX 10,000MI (CURRENTLY 93,000 MI) 2. EVENTUAL COMPLETE FAILURE OF THE DEFECTIVE TRANSMISSION OVERDRIVE GEAR AND TRANSMISSION LOCKUP, LEADING TO SKID AND NEAR CRASH. 3. TOYOTA SERVICE PACKED GREASE IN U JOINT. ONLY SOFTENS BUMP AND NOISE FOR 100MI THEN BACK TO SAME PROBLEMS. REPAIR ESTIMATED AT $5000.00+. *TR

THE FRAME ON MY 2000 TOYOTA TUNDRA IS RUSTING THROUGH AND BECOMING UNSAFE. TOYOTA INDICATES THERE IS NO REPAIR AVAILABLE AND NOTHING THEY CAN DO NOW AS THERE IS NO "RECALL" IN EFFECT. THE TRUCK IS 8 YEARS OLD WITH 94K AND WORTHLESS AND UNSAFE. *TR

PREMATURE FRONT ROTOR AND BRAKE SYSTEM FAILURE. FRONT ROTORS ARE ENGINEERED TO THIN CAUSING SEVERE WARPING WITH STRONG POSSIBILITY FOR COMPLETE FAILURE. STANDARD MANUFACTURER PARS LAST 2,000 TO 6,000 MILES BEFORE FAILURE. *TR

WE OWN 2000 TOYOTA TUNDRA W/55,000 MILES. PURCHASED & SERVICED BY SAME TOYOTA DEALER. TOOK FOR ROUTINE SERVICE 6/9/08 & CONCERN GAS TANK LEAKING. TOLD US "NOT WORTH FIXING" TOYOTA REP CAME & TOOK PICTURES. THE DEALER SAID PER THE REP TOYOTA IS GOING TO BUY IT BACK. IF WE NEED A RENTAL TOYOTA WOULD PAY SINCE IT'S UNSAFE TO DRIVE. FRAME IS BADLY RUSTED THROUGH & PITTED. WE INSPECTED & FOUND WHERE THE FRAME MEASURED ONLY 65/1000' THICK. IT'S THE SAME SAFETY ISSUE AS THE 95-00 TACOMAS. AFTER 7 WEEKS WAITING & CHECKING, PER TOYOTA THE TUNDRA ISN'T PART OF TACOMA BUYBACK. THEY OFFERED $2,000 TOWARD NEW OR CERTIFIED TOYOTA. WE'RE NOT AN ISOLATED CASE OF UNSAFE RUSTING ON THIS TUNDRA. HERE'S JUST SOME COMMENTS FOUND IN BLOGS & RESPONSE TO QUESTIONS & CONCERNS ABOUT THE 2000 TUNDRA: -MY FATHER WAS DRIVING HIS 2000 TUNDRA WHEN THE BACK END JUMPED OFF THE ROAD & ALMOST CRASHED THE TRUCK. COME TO FIND OUT, THE SPARE TIRE FELL OFF & HIT THE TRUCK. THE TIRE ROLLED DOWN THE ROAD & ALMOST TOOK OUT A BUNCH OF CARS. WE LOOKED UNDER THE TRUCK & THE WHOLE FRAME LOOKS LIKE IT'S ABOUT TO CRUMBLE AWAY' -MY TUNDRA ALSO A 2000 RUSTED OUT PRETTY GOOD AROUND THE FRAME & IN BETWEEN THE BED & FRAME.., HAD TO REPLACE BOTH FRONT & REAR BUMPERS & HAVE THE ROCKER PANELS SPRAYED WITH TOUGH STUFF -MY FATHER IN LAW HAS A 2000 TUNDRA THAT THE FRAME IS RUSTED OUT VERY BAD. HIS TRUCK HAS LESS THAN 60,000 MILES... WHEN I LOOKED UNDERNEATH I COULDN'T BELIEVE HOW MUCH RUST IT HAD ON THE FRAME.. - I HAVE ABOUT 93K MIL

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE VEHICLE HAS COOPER DISCOVERER RADIAL LT TIRES. WHILE DRIVING 70 MPH, THE CONTACT HEARD A THUMPING SOUND FROM THE REAR DRIVER'S SIDE TIRE. THE VEHICLE FISHTAILED, SPUN AROUND TOWARDS THE RIGHT SIDE OF THE ROAD, AND ROLLED OVER. THE DRIVER SUSTAINED FACIAL FRACTURES AS WELL AS NECK AND BACK INJURIES. A POLICE REPORT WAS FILED. THE INVESTIGATING OFFICER STATED THAT THE TIRE STILL HAD 30 LBS. OF PRESSURE REMAINING; HOWEVER, THE TREAD WAS WRAPPED AROUND THE HUB AND CAUSED THE VEHICLE TO FISHTAIL. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE TIRE SIZE AND DOT NUMBER WERE UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 180,000.

I WAS DRIVING MY 2000 TOYOTA TUNDRA, LUCKILY AT ABOUT 35 MPH ON A TWO LANE COUNTRY ROAD, WHEN I HEARD A LOUD NOISE AND FELT AS THOUGH I RAN OVER SOMETHING ALMOST LOSING CONTROL OF MY VEHICLE. THE SPARE TIME AND SUB FRAME FELL RIGHT OFF THE FRAME OF THE TRUCK! MY TOYOTA DEALERSHIP CONFIRMED THAT THE SUB FRAME DID INDEED RUST OUT BUT THERE WAS NOTHING THEY COULD DO BECAUSE THE WARRANTY HAD EXPIRED AND RECOMMENDED I TAKE TO A BODY SHOP. I DID AND LEARNED THE REAR FRAME IS ALSO 60% RUSTED. I BOUGHT MY TRUCK IN 2001 AS A NEW TRUCK AND SERVICE IT AT THE DEALERSHIP (I JUST GOT NEW TIRES) THIS HAPPENED AT 124,000 MILES, JULY 2008. *TR

2000 TOYOTA TUNDRA - THE FRAME/UNDERCARRIAGE HAS MAJOR RUST PROBLEMS. MY MECHANIC SAID IT WILL NOT PASS THE NEXT INSPECTION AND I SHOULD CONTACT A TOYOTA DEALER ABOUT THE PROBLEM. I FEEL TUNDRAS SHOULD BE INCLUDED IN THE BUY-BACK THAT TOYOTA IS DOING FOR THE TACOMA OWNERS, SINCE IT HAS THE SAME PROBLEM. IF TOYOTA WANTS TO UPHOLD ITS REPUTATION, IT NEEDS TO STAND BY ITS VEHICLES AND THEIR OWNERS. *TR

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT HEARD A NOISE IN THE REAR OF THE VEHICLE AND THOUGHT IT WAS A BACK SHOCK. WHEN HE TOOK THE VEHICLE TO THE DEALER, HE WAS INFORMED THAT THE REAR DRIVER'S SIDE FRAME WAS ROTTED. THE DEALER STATED THAT NOTHING COULD BE DONE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. HE HAS BEEN UNABLE TO DRIVE THE VEHICLE BECAUSE HE BELIEVES THE REAR END IS GOING TO FALL OFF. THE CURRENT AND FAILURE MILEAGES WERE 160,000.

EXCESSIVE FRAME RUSTING ON A 2000 TOYOTA TUNDRA, IT IS THE MATERIAL USED FOR THE FRAME. THE RUST COMES OFF IN LARGE WAFERS. I AM A MECHANICAL ENGINEER AND I AM VERY CONCERNED ABOUT THE INTEGRITY OF THE FRAME. *TR

MY 2000 TOYOTA TUNDRA WITH 108,499 MILES ON IT. I HAD IT IN FOR SERVICED WHEN IT WAS LIFTED UP I WAS TOLD THAT A BIG PIECE OF MY FRAME FELL OFF AND THAT THE FRAME WAS BUCKLED AND IT LOOKED VERY POOR. AT THIS TIME I DIDN'T SEE ANY HOLES IN IT. I CALLED TOYOTA CUSTOMER SERVICE AND THEY SAID THAT THERE ARE NO PROBLEMS WITH THE FRAMES ON THE TOYOTA TUNDRA. JUST THE TACOMA'S. THE LADY STATED THAT I COULD TAKE IT TO TOYOTA AND HAVE IN INSPECTED SO I DID. UPON HAVING IT INSPECTED THE TOYOTA TECHNICIAN FOUND THAT THE FRAME HAS HOLES IN IT. AFTER SPEAKING TO THE SERVICE MANAGER HE ADVISED ME NOT TO DRIVE THE VEHICLE AND THAT IT WAS UNSAFE TO DRIVE. I CALLED TOYOTA CUSTOMER SERVICE AND THEY SAID THAT THEY WERE SORRY BUT THERE IS NOTHING THAT TOYOTA COULD DO FOR ME. *TR

3 PAIRS OF CRACKED EXHAUST MANIFOLDS IN LESS THAN 100K MILES. HAD I BEEN MORE VIGILANT ABOUT REPAIRING THEM AS SOON AS THEY OCCURRED, IT LIKELY WOULD HAVE BEEN ANOTHER COUPLE OF PAIRS. DEALER REPLACED THEM UP TO 100K, AND ALTHOUGH I PRESSED THEM FOR A SOLUTION, THEY WOULD NOT HONOR PROBLEM AFTER 100K MILES. *TR

MY 2000 TOYOTA TUNDRA LIMITED V8...O2 SENSORS NEED REPLACED (ALL 4 OF THEM)...THIS IS AN APPARENT PROBLEM AND SHOULD BE A FACTORY RECALL ITEM. THIS IS A $850 DOLLAR JOB...RIDICULOUS! CHECK ENGINE LIGHT COMES ON AND CODES OUT AS OXYGEN SENSORS. *TR

CRACKED EXHAUST MANIFOLDS, HAVE HEARD THE NOISE FOR QUITE SOME TIME. IT HAS GOTTEN WORSE BUT GOES AWAY WHEN THE TRUCK WARMS UP. *TR

I HAVE AN OXYGEN SENSOR FAILURE. DON'T KNOW IF IT'S ONE OR BOTH ON THE RIGHT SIDE. WILL COST WELL OVER $400 TO FIX. HAVE HEARD OF SEVERAL OTHER HAVING THE SAME ISSUE. *TR

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 55 MPH THE PASSENGER SIDE SEAT BELT DISENGAGED WITHOUT WARNING. AS OF MAY 27, 2008, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 104,000. UPDATED 07/29/08 *BF THE SEAT BELT MOUNTING BOLT DISENGAGED FROM THE ROOF POST MOUNTING BRACKET. THE CONSUMER STATED AT LOOKED AS THOUGH IT WAS INSTALLED INPROPERLY. UPDATED 08/01/08

I DRIVE A 2000 TOYOTA TUNDRA AND HAVE BEEN RECENTLY APPALLED AT NON ONLY MY VEHICLE'S BRAKE PERFORMANCE BUT THE AMOUNT OF LISTINGS WITH THE SAME COMPLAINT! AND YET, NO RECALL HAS BEEN MADE. MY BRAKE ROTORS NEED REPAIR, BY ABS KICKS IN EVEN ON DRY SURFACES AT LOW SPEEDS. THIS HAPPENS REGULARLY AND HAS CAUSED NUMEROUS CLOSE-CALLS. THE FACT THAT A RECALL HAS NOT BEEN MANDATED IS INEXCUSABLE. *TR

MY 2000 TUNDRA HAS EXCESSIVE RUST ON THE FRAME AND ENTIRE UNDERCARRIAGE. THE TRUCK IS ONLY 8 YEARS OLD AND SHOULD NOT BE DOING THIS. THE SAME PROBLEM HAS OCCURRED WITH TACOMAS OF THE SAME MODEL YEAR. *TR

MY 2000 TOYOTA TUNDRA HAS A INTENSE SHAKE AROUND 40-80MPH. THIS IS DUE TO THE DEFECTIVE BRAKING SYSTEM, SINCE MY TRUCK HAS OVER 80K MILES THERE IS NO WARRANTY, THIS MAKES ME FEARFUL TO DRIVE WITH MY WIFE AND FOUR YEAR OLD SON. *TR

THE FRAME ON MY 2000 TOYOTA TUNDRA IS JUST AS RUSTY AS ALOT OF THE TACOMAS BEING BOUGHT BACK BY TOYOTA. I FEEL TOYOTA SHOULD ADD THE TUNDRAS TO THEIR INSPECTION LIST. *TR

EXCESSIVE RUST ON FRAME. *TR

I RECENTLY PURCHASED A 2000 TOYOTA TUNDRA AND HAD NO IDEA OF THE PROBLEMS TO COME. I HAD AN ACCIDENT WITH THE TUNDRA, WHO'S BRAKES FAILED TO STOP THE TRUCK. I WAS ABLE TO QUICKLY USE THE EMERGENCY BRAKES, BUT MADE NO DIFFERENCE. I HIT AND DAMAGED MY GARAGE DOOR. I DID SOME RESEARCH AND FOUND OUT THAT MANY COMPLAINTS HAVE BEEN FILED BECAUSE OF BRAKE PROBLEMS ON THE TUNDRA. I ALSO FOUND OUT THAT I HAVE TO SPENT A LOT OF MONEY TO REPAIR OR REPLACE THE BRAKE SYSTEM. I AM VERY DISAPPOINTED WITH TOYOTA NOT BEING ABLE TO HELP RESOLVE THIS IMPORTANT PROBLEM. I HAVE TWO CHILDREN AND MY WIFE WHO'S LIFE IS AT STAKE NOW. WE HAVE BEEN USING THE TRUCK QUITE EXTENSIVELY, BUT FOR NOW, THE TRUCK IS IN PARK UNTIL WE DECIDE WHAT TO DO WITH IT. I BELIEVED IN TOYOTA LIVING UP TO THEIR NAME, BUT NOW. I LOST CONFIDENCE IN THEIR PRODUCT. TOYOTA HAS FAILED TO TAKE INTO SERIOUS CONSIDERATION THE SAFETY OF MY FAMILY. *TR

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE APPROACHING A STOP AT LESS THAN 5 MPH, THE CONTACT LOST CONTROL OF THE STEERING. HE MANAGED TO PULL THE VEHICLE OVER AND HAD IT TOWED TO THE DEALER. THE DEALER STATED THAT THE RACK AND PINION SEPARATED FROM THE FRAME AND WAS UNABLE TO BE REPAIRED BECAUSE THE FRAME WAS RUSTED. THE CONTACT BELIEVES THAT THE FRAME SHOULD NOT BE RUSTED OUT BECAUSE THE VEHICLE IS ONLY EIGHT YEARS OLD. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 135,000.

WHEN I APPLY THE BRAKES ON MY TUNDRA, THE ENTIRE TRUCK SHAKES VIOLENTLY. I HAVE HAD THE BRAKES REPLACED AND THE SHAKING CONTINUES. I WAS TOLD BY MY REPAIRMAN THAT TOYOTA KNOWS OF THE PROBLEM WITH THIS YEAR AND MODEL HOWEVER, WILL NOT COVER THE REPLACEMENT TO CORRECT THE PROBLEM. MY TRUCK HAS 82,000 MILES NOW AND FAR OUT OF WARRANTY. I BELIEVE THAT TOYOTA SHOULD PAY TO CORRECT THE PROBLEM SINCE THEY ARE AWARE OF IT. *TR

2000 TOYOTA TUNDRA LIMITED: I PURCHASED MY VEHICLE WHEN IT ONLY HAD 34,000 MILES ON IT. I NOW HAVE 98,000 MILES ON MY TRUCK AND I HAVE ALWAYS HAD BRAKE PROBLEMS, SHAKING, PULSATING. I HAVE REPLACED MY ROTORS BEFORE AND SHORTLY AFTER THE SAME PROBLEM WAS BACK IN NO TIME. I AM WONDERING IF THERE IS A RECALL ON THE BRAKES FOR THIS PARTICULAR MODEL. IF NOT THERE SHOULD BE. I HAVE BEEN ON NUMEROUS DISCUSSION BOARDS AND PEOPLE STILL WITH FACTORY WARRANTIES AND ALL OR BARELY OVER HAVE HAD THERE BRAKES OVERHAULED AT NO CHARGE. *TR

MY TOYOTA TUNDRA'S PLANETARY GEAR EXPLODED WITHIN THE TRANSMISSION AND DISABLE THE VEHICLE COMPLETELY. THE TRANSMISSION WAS IN OTHERWISE PERFECT CONDITION. IT LEFT ME STRAND ON 2 SEPARATE OCCASIONS WITHOUT ANY PRE-NOTICE THAT THE TRANSMISSION WAS HAVING ANY ISSUES. *TR

2000 TOYTA TUNDRA AUTOMTIC TRANSMISSION FAILURE. *TR

I HAVE HAD ONE OXYGEN SENSOR REPLACED WITHIN THE PAST YEAR AT AN EXPENSE OF OVER $400. I NOW HAVE ANOTHER OXYGEN SENSOR FAILURE AND NOTE THAT MANY OTHERS ARE EXPERIENCING THE SAME MANUFACTURER DEFECT. MY TRUCK HAS ONLY 52,000 MILES BUT IT IS BEYOND THE EXTENDED WARRANTY PERIOD GRANTED BY TOYOTA. IT IS OBVIOUS THAT TOYOTA SHOULD RECALL ALL 2000 TUNDRAS AND FIX THEM RATHER THAN EXTEND A WARRANTY. *TR

CHRONIC REAR AXLE SEAL LEAKAGE (LEAKS GEAR LUBE). DEALER HAS ATTEMPTED TO REPAIR MY PROBLEM 3 TIMES SINCE 2005. DEALER CANNOT REPAIR PROBLEM. THIS IS A KNOWN ISSUE WITH TOYOTA TRUCKS AND SUVS USING A SIMILAR REAR AXLE DESIGN. IT IS A FIRE HAZARD SINCE GEAR LUBE LEAKS ONTO HOT EXHAUST PIPING. IT IS A BRAKING HAZARD SINCE GEAR LUBE CONTAMINATES REAR BRAKES AND REDUCES BRAKING POWER. SEALS BEGIN TO LEAK EARLY IN LIFE OF VEHICLE BUT ARE NOT DEALT WITH UNTIL LEAK IS NOTED (AFTER SEALS HAVE BEEN LEAKING FOR SOME TIME) AND PROBLEM IS SEVERE. *TR

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 55 MPH, THE GEAR SHIFT INDICATOR SLIPPED OUT OF GEAR AND INTO NEUTRAL. THE MECHANIC STATED THAT THE TRANSMISSION FAILED. AS OF OCTOBER 9, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CONTACT FELT THAT THE TRANSMISSION FAILED PREMATURELY. THE CURRENT AND FAILURE MILEAGES WERE 108,000. UPDATED 10/24/07.*JB

EXHAUST MANIFOLD FAILURE; CRACKS IN THE EXHAUST MANIFOLD CAUSING FORCED EXHAUST EMISSIONS INTO THE ENGINE COMPARTMENT WHICH WILL EVENTUALLY CAUSE CARBON EMISSIONS COATING THE INTERIOR OF THE ENGINE COMPARTMENT AND THUS CAN POTENTIALLY CAUSE FIRE IN THE ENGINE COMPARTMENT WHICH CAN RESULT IN DEATH; ALSO EXHAUST FUMES CAN MAKE THEIR WAY INTO THE CABIN OF THE VEHICLE AND THUS CAUSE THE DRIVER TO LOSE CONSCIOUSNESS AND RESULT IN ACCIDENTS AND POTENTIAL DEATH. THIS IS THE 3RD FAILURE SO FAR. *JB

I BROUGHT MY TUNDRA IN FOR AN OIL CHANGE ONLY TO DISCOVER ALL THE GREASE FROM THE INSIDE OF THE RUBBER BOOTS COVERING THE AXLES ENDS HAS COMES OUT. THE RUBBER BOOTS HAD NOT FAILED AND THE CLAMPS WERE STILL INTACT. THE GREASE HAD MADE IT WAY PAST THE CLAMP. I HAD TO HAVE BOTH FRONT AXLES REPLACED AT 73,000 MILES. *TR

2000 TOYOTA TUNDRA HAS POOR BODY PAINT. THE PAINT ON THE HOOD AND ON THE SIDE OF TRUCK IS LOSING COLOR AND PAINT IS CHIPPING OFF. *JB

WHILE DRIVING AT APPROX. 50 MPH, WITH NO WARNING THE RIGHT FRONT SUSPENSION CAME APART. THE TIRE FOLDED UNDERNEATH AND THE TRUCK SKIDDED TO A STOP. FORTUNATELY WE WERE ON A 2 LANE MACADAM ROAD. THERE WERE NO INJURIES. THE TRUCK WAS TOWED TO A GARAGE WHERE THE MECHANIC REPLACED THE UPPER AND LOWER BALL JOINTS RIGHT HAND SIDE, RIGHT HAND DRIVE SHAFT, AND INNER AND OUT TIE-ROD ENDS AND A NEW TIRE. *JB

I BOUGHT MY TRUCK AND ABOUT THREE WEEKS AGO I WAS DRIVING ALONG WHEN IT DIED. ANYTIME I CAME TO A FULL STOP IT DIED. TURNS OUT IT'S THE TRANSMISSION AND A LOT OF OTHER PEOPLE HAVE HAD THE SAME PROBLEM. TOYOTA REFUSES TO ISSUE A RECALL ON THEIR PLANETARY GEAR EVEN THOUGH IT MALFUNCTIONS. THIS FAILURE CAUSED MY TRUCK TO STOP IN A BUSY INTERSECTION AND ALMOST KILLED ME. *TR

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 45 MPH, THE VEHICLE SHAKES AND WOBBLES WHEN THE BRAKES ARE APPLIED. THE CONTACT STATED THAT IT FEELS AS IF THE WHEELS ARE COMING OFF OF THE VEHICLE. THE CAUSE OF FAILURE IS THE WARPING OF THE ROTORS WHEN THEY BECOME OVERHEATED. THE CONTACT SPOKE TO THE MANUFACTURER AND THEY OFFERED HIM $200 TOWARD THE BRAKE REPAIR. THE COST TO REPLACE THE ROTORS, BRAKE LINES, AND CALIBERS IS $2,000. THE FAILURE HAS BEEN ONGOING FOR A MONTH. AT 60,000 MILES, THE MECHANIC TURNED THE ROTORS AND STATED THAT THE BRAKE PADS DID NOT NEED TO BE REPLACED. TOYOTA HAS THE KIT TO REPAIR THE VEHICLE. THE CURRENT MILEAGE IS 77,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 09/05/07

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 5 MPH, THE VEHICLE STOPPED ACCELERATING. THE DEALER STATED THAT THE SHIFT SOLENOID COULD BE THE CAUSE OF FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE OVERDRIVE GEAR CLUSTER WAS NOT WORKING PROPERLY. AS OF JUNE 27, 2007, THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE IS 145,000 AND FAILURE MILEAGE WAS 144,000.

2000 TUNDRA BRAKE VIBRATION ISSUE; PURCHASED AS COMPANY TRUCK OCT 1999, TOOK TO DEALER AT 15K FOR BRAKE VIBRATION; STATES ROTORS AND PADS REPLACED BUT IT NEVER REALLY GOT BETTER, I JUST GOT USED TO IT. COULD NOT CONSTANTLY TAKE TRUCK IN TO LOOSE FOR 2-3 DAYS THE DEALER REQUIRED SO I BEGAN USING MY PERSONAL MECHANIC OF YEARS. PERSONAL MECHANIC REPLACED PADS AND TURNED ROTORS AT 59K, PERSONAL MECHANIC CHANGED 2 OXYGEN SENSORS AT 67K (I HEARD THOSE WERE RECALLED PRIOR TO 80K), PERSONAL MECHANIC BECAME A NUT CASE OVER THESE BRAKES AT 88K, HE REPLACED ROTORS, DRUMS, PADS AND I STILL BEGAN TO EXPERIENCE PROBLEMS.... I KNEW MY MECHANIC WAS SINCERE. I HAVE JUST LIVED WITH IT; I AM NOW AT 140K MILES AND A BIT SICK IN STOMACH FROM THE BRAKING ISSUES. I DECIDED TO HAVE ANOTHER AREA MECHANIC GIVE IT A GO; WHILE MY TRUCK IS IN SHOP I SURF WEB AND DISCOVER THIS HAS BEEN A SERIOUS ISSUE SINCE I DROVE OFF THE FREAKING LOT WITH THAT TRUCK. I'VE GOT RECEIPTS, NOT NECESSARILY IN ORDER BUT I HAVE THEM. THANKS, CARLA. *TR

SERIOUS VIBRATION, SOFT BRAKE PEDAL AND LIMITED TRAVEL. THIS VEHICLE HAS EXHIBITED BRAKE PROBLEMS SINCE NEW. IT WAS RETURNED TO THE DEALER WHICH REPLACED THE MASTER CYLINDER UNDER WARRANTY. THE PROBLEMS CONTINUED TO WHICH THE DEALER INSISTED THE SYMPTOMS WERE NORMAL. LATER, THEY SAID IT NEEDED ANOTHER MASTER CYLINDER BUT I DECLINED BASED ON PREVIOUS EXPERIENCE. VIBRATION WAS ATTRIBUTED TO TIRES. I HAVE BEEN CHASING VIBRATION AND SOFT BRAKES FOR THE LIFE OF THE VEHICLE. *TR

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE'S REAR TAIL LIGHT BULB IS FAILING BECAUSE THE BULB IS LOOSE IN THE SOCKET. THE CONTACT HAS REPLACED THE BULB FOUR TIMES IN THE PAST FOUR MONTHS, THE LAST TIME BEING MAY 16, 2007. THE CONTACT STATED THAT THERE IS SAFETY RECALL # 99V347003 (EXTERIOR LIGHTING:TAIL LIGHTS), BUT HIS VIN IS EXCLUDED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 95,675 AND FAILURE MILEAGE WAS 91,000. UPDATED 06/08/07 *TR

2000 TUNDRA PICKUP TRUCK LOWER BALL JOINT FAILURE. *AK

ON AN EXTREMELY COLD MORNING (-22DEG F) I STARTED MY 2000 TOYOTA TUNDRA ACCESS CAB V8 AND WENT TO TURN ON HEAT. THE TEMPERATURE NOB WOULD NOT TURN EASILY, BUT DID TURN, AND MADE A SNAPPING SOUND. THE HEAT NEVER CAME, THOUGH THE FAN DID WORK AND BLEW COLD AIR. I HAVE BEEN WORKING OVERSEAS AND NOT REQUIRING THE USE OF THE VEHICLE SINCE THIS INCIDENT, AND JUST FOUND THE CAUSE OF THE ERROR. THE CABLES FOR THE HEAT SELECTOR SEIZED AND THE DASH MECHANISM BROKE. AFTER READING MANY OTHER POSTS ON THIS MODEL, AND OTHER TOYOTA MODELS, THEY NEED TO REDESIGN THE CABLE, THE HEAT VALVE, THE METHOD THE CABLE IS SECURED AND ENSURE THAT WATER IS NOT PENETRATING THE CABLE. THE RESULTING PROBLEM IS OFTEN NOT CORRECTED PROPERLY BY THE DEALERS. I EXPECT THAT THIS PROBLEM WILL COST AT A MINIMUM OF $300 FOR THE DASH MECHANISM, $20 FOR EACH CABLE THAT MAY NEED TO BE REPLACED PLUS LABOR COSTS, MORE IF IT IS NOT CORRECTED PROPERLY THE FIRST TIME.

2000 TOYOTA TUNDRA SHIFT ASSEMBLY FAILURE**CC THE CONSUMER STATED THE SHIFT LEVER BROKE. *JB

MY 2000 TUNDRA TRD 4X4 V-8, AUTO TRANS DEVELOPED AN ENGINE NOISE WITHIN THE FIRST 10,000 MILES AND FIRST YEAR OF OWNERSHIP. I TOOK IT TO THE DEALERSHIP, GODFREY TOYOTA OF CADILLAC, MI AND THEY WERE UNABLE TO IDENTIFY THE PROBLEM. AT APPROXIMATELY 78,000 MILES, THE O2 SENSOR FAILED, AS IDENTIFIED TO ME BY THE CHECK ENGINE LIGHT. THE DEALERSHIP SERVICE DEPARTMENT REPLACED MY SENSOR, AND INITIALLY BILLED ME FOR THE WORK. WHEN I ASKED THE MECHANIC, HE IDENTIFIED THE OCCURRENCE OF AN EXTENDED SERVICE BULLETIN ON THE O2 SENSOR. HE FURTHER IDENTIFIED THE REASON FOR THE NOISE WAS THE CRACKED MANIFOLD, THAT HAD APPARENTLY OCCURRED WITHIN THE FIRST 10,000 MILES OF DRIVING. HE INDICATED THE NOISE WAS WORSE WHEN THE ENGINE WAS COLD AND THAT AFTER DRIVING AWHILE, THE CRACKED TENDED TO CLOSE UP AND REDUCE THE NOISE. HE FURTHER INDICATED THAT IF THE O2 SENSOR HAD NOT COME OUT, THAT TOYOTA WOULD HAVE REPLACED THE MANIFOLD AND SENSOR AT THE SAME TIME, AT NO CHARGE. MY CHIEF CONCERN WITH THE CRACKED MANIFOLD IS THE POSSIBLE REDUCTION IN LIFE OF THE ENGINE DUE TO EXHAUST LEAKAGE, SECONDARILY TO VEHICLE OCCUPANTS DURING ANY EXTENDED IDLING, SOMETHING I PERSONALLY DO NOT OFTEN DO. *NM

DRIVING 2000 TOYOTA TUNDRA IN NORTHERN WYOMING 1 WEEK AGO DURING FREEZING TEMPS. ENGINE SHUT DOWN SHORTLY AFTER STARTING IN THE MORNING LEAVING DRIVER WITH NO POWER TO MANEUVER IN TRAFFIC. VEHICLE SITS IN TRAFFIC UNTIL IDLE SPEED WILL MOVE VEHICLE OUT OF WAY OF OTHER CARS. THIS HAS HAPPENED BEFORE WHEN VEHICLE SITS OUT ALL NIGHT IN FREEZING COLD WEATHER. CAR TAKEN TO DEALER EACH TIME AND WE ARE TOLD THIS HAPPENS ON THIS V-8 ENGINE FOR TUNDRA AND LAND CRUISER MFG 1999. DEALER HAS OTHER VEHICLES IN FOR REPAIR AT THIS TIME AND SAYS HE REPLACES SEVERAL EACH YEAR. DEALER SAYS INTAKE MANIFOLD MUST BE REPLACED WITH CORRECTED MANIFOLD. DEALER BELIEVES THE PROBLEM IS IN THE ELECTRICAL CIRCUIT ATTACHED TO THE MANIFOLD. COST IS TO BE APPROX $1400. DEALER SAYS TO TAKE UP PROBLEM WITH TOYOTA CORP. *NM

FRONT BRAKES SHAKE VEHICLE VIOLENTLY WHEN APPLIED BETWEEN 50 TO 40 MPH. A TOYOTA SERVICE BULLETIN WAS PUBLISHED FOR THIS PROBLEM INVOLVING REPLACING UPGRADED MAJOR BRAKE COMPONENTS, BUT WILL NOT PAY TO FIX UNDER ENGINEERED ORIGINAL PARTS. THIS NEEDS A RECALL. *JB

DT*: THE CONTACT STATED THE SHIFT LEVER DISINTEGRATED OFF THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THEY WOULD NEED TO REPLACE A BRACKET TO FIX THE SHIFT LEVER. THE VEHICLE WAS STILL AT THE DEALER AWAITING THE REPAIR WORK. THE CONSUMER STATED THE SHIFTER SHATTERED WITHOUT WARNING AND WAS UNABLE TO PLACE THE VEHICLE IN GEAR. UPDATED 12/18/06. *JB THE CONSUMER STATED THE PROBLEM WITH THE ACCELERATOR BEGAN IN SUMMER OF 2005. HE STARTED THE VEHICLE STEPPED ON THE ACCELERATOR AND NOTHING HAPPENED. HE THEN DEPRESSED THE ACCELERATOR PEDAL TO THE FLOOR AND THE TRUCK LUNGED FORWARD. ONLY BY CAREFULLY PUMPING THE GAS PEDAL UP AND DOWN WAS HE ABLE TO ATTAIN APPROXIMATELY 40 MPH. THE SEARCHED THE INTERNET TO SEE IF OTHERS HAD EXPERIENCED THE PROBLEM. WITHIN IN A SHORT PERIOD OF TIME, HE FOUND SOMEONE ELSE WHO EXPERIENCED THE SAME PROBLEM. IT WAS CAUSED BY A LOOSE CONNECTION WHERE THE ACCELERATOR PEDAL POSITION SENSOR WIRE CONNECTS TO ITS FEMALE CONNECTOR. WHICH WAS LOCATED ON TOP OF THE ENGINE. THE CONSUMER LOOKED AT THE CONNECTOR AND IT SEEMED CONNECTED. HE PUSHED THE CONNECTOR DOWN HARD AND TO HIS ASTONISHMENT IT CLICKED INTO PLACE. WHICH SOLVED THE PROBLEM. THE CONSUMER STATED TWO YEARS LATER, THE SAME PROBLEM PRESENTED ITSELF AGAIN. ONCE HE ARRIVED HOME, HE CLICKED THE ELECTRICAL CONNECTOR SECURELY IN PLACE. HE USED SOME COPPER ELECTRICAL WIRE AND WIRED THE CONNECTOR FIRMLY IN PLACE. THE CONSUMER STATED HIS BEST GUESS TO THE PROBLEM WITH THE CONNE

CARRYING A HEAVY LOAD IN MOUNTAIN TERRAIN. THE FRONT BRAKE ROTORS RAPIDLY WARPED, LEADING TO VIOLENT SHAKING, INABILITY TO STOP AND NEAR-LOSS OF CONTROL. BRAKE ROTORS WERE TURNED AND PADS UPGRADED TO CERAMIC. GOING THROUGH THE MOUNTAINS WITHOUT A LOAD CAUSED THE ROTORS TO WARP AGAIN, ONCE MORE LEADING TO INABILITY TO STOP AND NEAR-LOSS OF CONTROL. THE FRONT BRAKE ASSEMBLIES WERE COMPLETELY REPLACED BY PELLMAN'S AUTOMOTIVE IN BOULDER, CO, WITH THE MECHANIC STATING THAT THE ORIGINAL TUNDRA BRAKES WERE INADEQUATE. PARTS UNAVAILABLE. *JB

ROTORS WARP AFTER ONLY A FEW WEEKS. HAVE REPLACED A NUMBER OF TIMES WITH "IMPROVED" ROTORS WITHOUT ANY HELP. TOYOTA KNEW OF THIS PROBLEM AND FIXED MANY BUT WILL NOT FIX MY 2000 TUNDRA. JB

FRONT BRAKE DISC (OR ALSO CALLED ROTORS) WARP APPARENTLY DUE TO EXCESSIVE HEAT. DEALER SAYS NO RECALL BUT THERE IS A TSB RECOGNIZING PROBLEM. OWNER REPLACED ROTORS AND PROBLEM RECURRED WITHIN 10,000 MILES. DEALER NOW RECOMMENDS USING WARRANTY ON ROTORS FROM PARTS HOUSE. THE WIDESPREAD OCCURRENCE OF THIS PROBLEM ON TOYOTA TUNDRA INDICATES THAT THERE IS A DESIGN FLAW THAT SHOULD BE CORRECTED AT MANUFACTURER EXPENSE EVEN WHEN THE VEHICLE IS OUT OF WARRANTY. *NM

AUTOMATIC TRANSMISSION TRANSMISSION ON THE TUNDRA TRUCK IS A KNOWN PROBLEM, EXPERIENCED BY THOUSANDS OF TUNDRA OWNERS ACROSS THE COUNTRY, AND YET TOYOTA FAILS TO ADMIT THE PROBLEM AND HELP OWNERS WITH THE COST OF REPAIR. THE TRANSMISSION ON MY 2000 TUNDRA NEEDS TO BE REPLACED DUE TO ABRUPT GEAR SHIFTING WHICH CAUSE THE TRUCK TO LUNGE FORWARD. I'VE COMPLAINED TO TOYOTA AND THEIR ANSWER WAS " YOUR TRUCK IS OUT OF WARRANTY". I'VE BEEN A TOYOTA OWNER FOR 15 YEARS, BUT AFTER THIS EXPERIENCE I WILL NOT BUY ANOTHER TOYOTA. *NM