2019 Toyota RAV4 complaints

Started normally, but had a message on the screen saying “Check Fuel Cap.” I needed gas anyways, drove about 3 minutes to the gas station, turned engine off, put gas. Turned engine back on and within 3 seconds it shut off. The screen displayed “engine stopped- Power steering low.” I tried a handful of times to start, it did not. After 20 minutes and some rest, it started. With no more messages. Battery and alternator were tested, both were good.

The contact owns a 2019 Toyota Rav4. The contact stated that while stopping the vehicle, the contact heard an abnormal slushing sound coming from the front passenger's side door. The vehicle was taken to the dealer, and it was determined that the door seals had failed and needed to be replaced. The vehicle was not yet repaired and remained with the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000. The VIN was unavailable.

Sudden, unexpected, surprise Surging Idle upon placing the vehicle in Park after driving a 15 minute distance at a top speed of 35mph. Loud Surge up to 2.5 (x1000RPM) Sounds like the Engine Shifted Idle Drops down and immediately begins Surging up again. Idle is high while driving. Some chugging upon acceleration. Immediately drove to Auto Parts store for Diagnostic Test. Started vehicle and showed Technicians what was happening. Diagnostic Test provided: Code P0171 Stored and Permanent System is Too Lean Bank 1 Code P0505 Stored and Pending Idle Control System P117B Stored Fuel Performance/Direct Injector Most Likely Solution: Replace Fuel Pump Primary DTC: System Too Lean Bank 1 Suggested Part: Fuel Pump Operating The Vehicle Could Result in Sudden Shut Down, causing a Collision. Could also Cause Compromised Gas Mileage and Engine Damage. Check Engine Light is On Additional Message states that All Wheel Drive Mode has been disengaged and 2 Wheel Drive Mode is active. No Warning or Any indication that there was any issues prior to the Sudden Idle Surging upon placing the vehicle in Park. I have searched existing recalls for 2019 Toyota Rav-4 and found a Fuel Pump listed. I checked my license plate and VIN only to see the result that there are Zero Unrepaired recalls for both searches. This vehicle is clearly having an internal battle between air and fuel. I find it concerning that 2019-2020 Toyota Rav-4 vehicles had a Fuel Pump recall and yet my search has Provided these res

You get a message that said engine maintenance required contact the dealer, when you do the scan it's shows that there is a problem with engine coolant bypass valve. After checking online it was multiple people with the same problem.

Back doors are completely water logged (full of water) and won't drain .

1st: veh purchased Jan 2023 with new set of tires. Within 11k miles, about 9months: Rear tires unable to be aligned properly due to no camber adjustment. Rear tires have excessive inner rear (belts showing) with 11k miles on tires. Took veh to dealership and was told I just need a set of tires and an alignment. When the tech was questioned if it was an accurate alignment, we were told it would be off a couple degrees because the OE rear control arms did not have any adjustment. This was repaired by an independent shop using aftermarket set of rear control arms, a proper alignment and 2 new rear tires ($1200)--because Toyota dealer would not own any accountability of an error nor do the PROPER requested repair since proper repair did not involve OE Toyota parts. This was repaired, case closed and tires have 20k miles on them with beautiful, even wear. 2nd: Rear door hatch will not close electronically. 2 incidences of bent (left) hinge from forcing the tailgate closed and damaged rear taillamp from mis-alignment. Post hinges replaced: re-sets have been done, disabling door and re-enabling, and disconnected battery. Still will not close electronically. This had been occurring over a year and no one knows the fix. I will not be going back to my local stealership and the next one is 30 miles away.

While driving at interstate speed and cruise control set, the cruise control stopped working and Cruise Control Malfunction errors, as well as Hybrid System Malfunction errors appeared. With other cars driving so closely behind me, the quick deceleration caught me off-guard and could have easily been hit from behind. I took the car to Toyota Dealership and appears there's already a known issue for a corroded traction cable and since not under warranty (due to mileage >120,000 miles) will cost $4668 to fix. Why is this not a recall if the problem is known?

Faulty coolant bypass valve at 115,000 miles. Seems to be a repeat issue for many Toyota owners. Not covered by the powertrain warranty, but a known issue by the manufacturer.

The contact owns a 2019 Toyota Rav4. The contact stated while driving 60 MPH, the vehicle started swaying in and out the lane. There was no warning light illuminated. The contact linked the failure to the lane keep assist feature. The contact stated that the failure persisted. The contact continued to drive the vehicle and the vehicle violently jerked, forcing the contact to pull over. In addition, the contact stated that the vehicle was accelerating unintendedly upon releasing the accelerator pedal. The contact immediately pulled over and turned off the vehicle. The contact turned off the lane assist feature and proceeded to drive the vehicle at a slow speed. The contact stated that while accelerating above 35 MPH, the abnormal jerking returned. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 62,000.

The Engine Maintenance required light comes on when I use the air conditioner. I suspect the coolant bypass hose is not working properly.

I bought my Rav4 in 2019 brand new. For years, anytime there is a hard rain, the doors fill up with water. Water does not drain properly. I brought my car into Toyota a couple of years back. They told me that there was no fix and that when that happens, just to lift up the weather stripping on all four doors, to let the water drain. They acted like this is completely normal. Just last week, I brought my car in again to Toyota to see if they had a fix for it. They ended up charging me about $700 to replace all of the weather stripping on the doors. This is very clearly a manufacturing default and the customer should not be charged for what is a common issue with this car! If this is a well known issue at this point, why has this not been recalled? Again, the doors have had issue draining the water properly since day one and the car was brand new! Anytime the doors fill with water, you can literally hear the water splashing around in the doors while driving! I am not a happy customer. Toyota never takes responsibility!

There is a water accumulation problem in the doors. This could potentially cause some rot from the inside out causing electrical to fail or metal to rust and cause the affected door(s) to not open correctly. No warning lights came on or anything on the dashboard.

Check engine light came on and code P268115 was shown for coolant bypass valve internal failure. Valve was replaced by dealership and I was told it would not be covered under the Toyota Customer Support Program because that only covers valves that leak externally, not internal failures.

Rear passenger door keeps flooding after rain. Bottom door seal needs to be physically lifted to the side for water to drain out of the door.

While driving or stopped at a light, car will switch drivings modes to “mud and sand” turning off the vehicle stability control and pre-collision system warning light will illuminate. After pressing desired mode, car will switch back to “mud and sand” at varying intervals resulting in me pressing the desired mode constantly while driving.

Faulty coolant valve and Toyota says that it is not covered/part of a recall. However, many vehicles are experiencing this issue so this seems like a widespread problem that Toyota is not taking responsibility for.

The contact owns a 2019 Toyota Rav4. The contact stated that upon starting the vehicle, several unknown warning lights illuminated, and several unknown messages were displayed. The contact stated that the transmission and steering wheel seized during the failure. The vehicle was towed to the dealer; however, no cause for the failure was found. The contact stated that unknown parts were replaced. The contact stated that the failure persisted and worsened during the cold months. The manufacturer was not notified of the failure. The failure mileage was approximately 55,000.

Coolant bypass failure

A Hybrid System Malfunction warning appeared about 1 week ago. The car was taken to the Toyota dealer who said that the car was safe to drive and that they would need to order a part and it will probably be weeks before they get it because so many other cars have the same problem. Three days later the car will not start with several errors including Brake Power low, PKSB Malfunction, and Precolllision System Malfunction. Toyota is not providing any coverage for any of our repair, car rental or now the need to tow the car.

Well, making my research it shows that the RAV4 2020 will have a recall with the brake booster that my car the 2019 is having the same issues and it’s a very expensive fix. My car only has 40,000 miles is still brand new and I don’t understand why am I having this issues with the brake booster RAV4 2020 has a recall for that same part so I would like them to honor the 2019 brake booster and fix it as well

An error code titled “Engine Maintenance Required. Visited your dealer” appeared on my dash screen. The error code was unable to be removed. I attempted have the car diagnosed by a private auto shop, however no faulty codes pop up. After research online, the problem was determined to be the engine coolant valve, which are faulty on many Rav4s. I eventually get a letter from Toyota for a Customer Support Program regarding the Engine Coolant Valve. When brought in for maintenance, Toyota pulled the error code “P268115” which is for an internal failure of the engine coolant valve. However, Toyota will not replace the part due to their Customer Support Program (24TE04) only covering the part for “small engine coolant leak[s]”. Essentially, Toyota will replace the part for being faulty if it had small leaks, but not if the part itself is faulty. When I asked the service member I was working with stated that this is a known problem and “[Toyota] should have just replaced the whole part, but they only do it for small leaks.” Currently, litigation is proceeding regarding the engine coolant valve, alleging Toyota knowingly put faulty parts in their Rav4s. I urge you to investigate this claim.

The contact owns a 2019 Toyota Rav4. The contact stated that when the vehicle was started, the vehicle was shaking abnormally. The contact stated that the overheating, parking brake, cruise control, maintenance required, and check engine warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed that there was a misfire in cylinder #2, and that coolant was leaking into the engine. The contact related the failure to NHTSA Campaign Number: 20V064000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was unknown.

Door lock actuator has failed prematurely on all four doors, this prevents me from entering my vehicle in a quick and timely manner if there were to be an emergency

Engine Maintenance Required warning came on. Took car to dealership, diagnostic informed the issue was the coolant bypass valve. Repair cost is $781.28 + diagnostic $160.

The contact owns a 2019 Toyota Rav4. The contact stated that the liftgate hinge had fractured into two pieces, causing the liftgate to fail to operate as designed. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the repair was not covered under recall or warranty. The failure mileage was approximately 60,000.

The trunk door has been having major issues, where the hatch hinges and power liftgate strut are not operating correctly. The door is unable to close without manual assistance. Ghettel Toyota of Bradenton's service center has inspected and confirmed the malfunction. There were no warning messages or other symptoms of the problem prior to the failure; it first appeared in December 2024, and this car is a 2019 model with 37,000 miles on it. A second opinion was provided by a local body shop, prompting me to report this issue, as they informed me that this has been happening to multiple RAV4 vehicles.

The engine coolant bypass valve has malfunctioned. this is caused a faulty part that toyota knows malfunctions often in their toyota rav4 for multiple years including the 2019. It can cause problems for the engine cooling component, meaning the vehicle overheats, as well as affects the cars internal A/C. It can only be diagnosed at the dealership, not through a normal diagnostic. There is currently a class action lawsuit, and many others owners of multiple years of the toyota rav4 have the same issue.

Engine coolant bypass valve not working vehicle has 53000 miles was charged 783.00 dollars to replace at the dealership I understand there is pending lawsuit against toyota for not doing a recall in regards to this problem with all 2019 to 2023 rav4

The rear hatch hinges cracked almost all the way through and had to be replaced. We were afraid to drive the vehicle because we didn’t want the hatch back to fall off while driving and create an accident.

The Engine Maintenance Required message is constantly on. The Engine Coolant Bypass Valve needs to be replaced.

The contact owns a 2019 Toyota Rav4. The contact stated while driving at approximately 35 MPH, the vehicle stalled. The contact pulled over and was able to restart the vehicle. The contact stated that the failure was a recurring failure. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer. The vehicle was not yet diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 118,000.

After driving for 5-10 minutes, the center console screen stated: “A malfunction in the SRS Airbag System has been detected. Contact your dealer in order to have your vehicle inspected immediately” This continues to happen on subsequent trips. It only happens when somebody is actually sitting in the front passenger seat. There were no warning signs or symptoms prior to this message appearing. It makes me very concerned about passenger and driver safety and that the airbags may not deploy when needed.

Vehicle is displaying Engine Maintenance Required. Dealership stated that it’s a Coolant Bypass Malfunction.

My 2019 TOYOTA RAV4 ADVENTURE is groaning, especially when accelerating or decelerating, particularly with the AWD system engaged. Plus, there no or slow forward collision warning. Toyota seems to ignore these issues related to the Adventure RAv4 of 2019 and 2020. Thanks

The rear differential stopped working in January, 2025 and went into two wheel drive only. The message lit up on the dash board saying the vehicle was driving in two wheel drive only. We were driving home and the roads were slippery. We brought it to Mountain States Toyota and they confirmed there was a technical service bulletin (0086-19) issued in 2019, due to a Toyota manufacturing problem. It was issued three months after we bought the new vehicle. We were never notified and a recall was never issued in 2019 when Toyota knew about it. I contacted Toyota Brand Engagement and they agreed to pay for half of the $4,800 cost to replace the entire rear differential even though they acknowledged it was a Toyota manufacturing problem and possible safety issue. We don't understand why we were not notified about the known manufacturing problem that affected the drive train of an all wheel drive vehicle. We also don't understand why they won't cover the entire cost of the required repair to make the all wheel drive operational when they acknowledge it is a known Toyota manufacturing problem. We believe it is also a safety issue. Thank you! Toyota repair Invoices #1178424, #1169684

The seat warmer/heater burned a hole through my driver's side seat and my coat. Luckily, I was not injured but I have severe concerns about this problem also occurring in the passenger seat where my children sit. This problem causes me worry about my own safety and that of my children. I am disappointed to be unable to use a feature that I specifically purchased this vehicle to use and enjoy. I currently have my vehicle at a Toyota dealership for diagnosis and evaluation.

I have been experiencing water intrusion with my vehicle, I first noticed it by a mildew smell. Acknowledged under Toyota’s Customer Support Program 22TE05. This water leak has led to multiple secondary issues, including: Interior water damage Clogged A/C drainage system Sunroof drainage issues I reported this issue to a Toyota, but they denied repairs under 22TE05, claiming the issue was only due to a sunroof leak and clogged drains. [2/14] – Took my car to AutoNation Toyota due to a persistent water leak. The dealership diagnosed the issue as a clogged sunroof leak and clogged drains but did not provide clear documentation that they properly inspected the roof rail gasket. [2/18] – Dealership denied repair under 22TE05 but then stated they could replace the roof rail gaskets if my insurance paid for it—which contradicts their claim. [2/18] – I escalated my case to Toyota Corporate for review, but I am still waiting for a response. My car was left outside in the rain, potentially worsening the water damage. The dealership never provided me with a written repair estimate. Safety Concerns & Impact on Vehicle Use: I am worried about driving my car due to potential electrical system failure and airbag malfunctions caused by water damage. According to industry knowledge and Toyota customer experiences, a roof rail leak can directly contribute to all of the issues the dealership claims my car has: Clogged A/C Drainage System – Water leaking from the roof rails can enter the A/C sy

The contact owns a 2019 Toyota Rav4. The contact stated that upon starting the vehicle, the messages "Parking Brake Malfunction", "Secondary Brake system Malfunction”, “4WD Malfunction", "Lane Assist Malfunction", "Pre-collision Malfunction" and messages indicating malfunctions of the electrical system, the engine throttle, and the transmission were displayed. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where a spark plug and ignition coil were replaced; however, the failure recurred. The vehicle was taken to the dealer, where the contact was informed that all the spark plugs and ignition coils needed to be replaced prior to the final diagnostic test. The vehicle was not completely diagnosed and was taken back to the mechanic, where a specialist used a camera to diagnose that there was coolant intrusion in cylinder #4, due to a fractured cylinder head. The mechanic related to the failure of NHTSA Campaign Number: 20V064000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided because the vehicle was not covered under warranty and the VIN was not included in the recall. The failure mileage was approximately 87,230.

UNKNOWN

The electronic power steering light intermittently illuminates, particularly when the start-stop system is engaged. I recently brought my vehicle to the Toyota dealership where a diagnostic test was performed. However, no fault codes or issues were identified at that time. Despite this, the warning light continues to appear.

On 01/29/2025 at around 5:30pm I was driving home from work when suddenly the car stalled. I was going about 45 mph on a secondary to Lane Highway that was completely black because there are no street lights in that area. There were all kinds of warning lights flashing on the dash. I let my car drift to the shoulder was able to break and put it in park. I tried turning the vehicle back on but it would not start. My cell phone showed no Wi-Fi connection but I know the area very well and I knew I could walk several feet to a connection. Therefore spite concerns for my safety I had to leave my vehicle in order to call for help. I walked about 30 ft in the pitch black on this highway dressed in dark clothing on a shoulder that was very narrow. There was a pickup truck coming my way who flashed his high beams in my face but did not stop to see if he could help. Actually I was grateful for this because it's a pretty secluded area and I was very frightened for my safety. I was able to get a connection about 30 ft away from the vehicle and called my husband who said he would be on his way. I walked back to the vehicle got in and tried to start it. It would not start but all the warning lights were flashing on the dash. I decided I should take pictures of the warning lights in case we needed that for the dealer. After a couple of minutes I decided to try to start the car again and it did start. I was able to drive down the road to a Wi-Fi connection called my husband to let him know I

A warning message "Engine Maintenance Require Visit Your Dealer" appeared on my vehicle dashboard screen on approximately May 22, 2024. I googled and looked up on Facebook group and many other owners shared their experiences who encountered the exact issue with the Engine coolant bypass valve, and it requires a replacement, or else it could overheat and cause damages to the engine. Those owners who got it replaced and shared it costs about $1,000 or more at the dealership. I went to a local mechanic shop, and they diagnosed the exact issue as expected, and they were able to replace the part at a much lower cost than the dealership.

Toyota RAV4 5th Gen Power Lift Gate Hinge Issues Unpredictable Failure: If the lift gate or its components fail unexpectedly, it could cause injury to someone loading or unloading items, especially if they are unable to react in time. Obstructed Visibility: If the lift gate detaches while in motion, it could obstruct the driver’s rear visibility, increasing the risk of an accident. Risk to Other Road Users: A detached lift gate or related debris could pose significant danger to pedestrians, cyclists, or other vehicles on the road. Vehicle Stability and Control: A sudden failure or detachment of the lift gate components could destabilize the vehicle, especially at high speeds. Damage to Emergency Equipment: If the lift gate collapses or detaches, it could damage essential safety or emergency equipment stored in the trunk, leaving occupants unprepared in an actual emergency. Child and Pet Safety Concerns: Families frequently use RAV4s as family vehicles. A collapsing or failing lift gate could pose a serious risk to children or pets while loading or unloading. Potential for Escalating Damage: The failure of hinges or struts could result in cascading damage to other parts of the vehicle, such as electrical systems or the rear windshield, creating additional safety hazards. Delayed Emergency Response: If the lift gate malfunctions or becomes stuck in a partially open or closed position, it could impede access to the cargo area in emergencies, such as retrieving a first aid kit.

The vehicle suddenly started to smoke and burn by itself when driving on the super crowded highway. I immediately stopped the vehicle and found that the burning site was the bottom of the front-left head of the vehicle (please see the images attached). The mechanician I visited after judged that the fire may due to failed electrical parts or system. He suggested to visit a Toyota dealer for recall. However, the Toyota dealer (Crown Toyota, 1201 Kettering Dr, Ontario, CA91761) declined my request with the reason that my vehicle has passed warranty time. The vehicle was just inspected in the Toyota dealer a few days ago. The dealer's inspection report shows that the vehicle does not have any problems besides suggesting to replace tires and front brakes.

The contact owns a 2019 Toyota Rav4 Hybrid. The contact stated while driving 35 MPH and making a left turn, the vehicle suddenly accelerated to approximately 45 MPH unintendedly. The contact stated that the vehicle failed to respond upon depressing the brake pedal, and the accelerator pedal felt stuck, causing the front of the vehicle to crash into a building. There was no property damage. There was no warning light illuminated. The air bags deployed. The contact was able to exit the vehicle. The contact sustained bruising and a fractured rim on the right hand. The emergency units transported the contact to the hospital, where the contact underwent surgery. A police report was filed but the contact did not have the police report information available. The vehicle was towed to a tow lot, where it was totaled by the insurance company. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that they would have the vehicle inspected. The failure mileage was approximately 70,000.

The Data Communication Module has failed in my vehicle. This causes several major distractions and increases the risk of an accident. The media screen in the center of the dashboard will send an alert message every 15 seconds saying that ‘the connected device is not compatible’. At night, this alert message is especially bright and distracting. The lights on the SOS button are constantly blinking. More significantly, the SOS button does not work anymore. The only known solution to this problem is either to disconnect the DCM, or to pay more than $1300 to replace it.

First the problem was the seat belt malfunction and I check it everything was ok do accident or damage and two week later passager side air bag malfunction I took it to toyota the see the problem they said there are no recall and i have pay out of my pocket to fix manufacture malfunction problem.. after there months later my suv would not drive faster is move very slow and now it not even 5 years now and my transmission went out I have replace it

The following information refers to recall notice 19V544000 "SERVICE BRAKES" and "ELECTRONIC STABILITY CONTROL" (recall number same for both notices) by Toyota for the 2019 Rav 4 Hybrid: "In 2019, Toyota issued a recall for certain 2019 Toyota RAV4 Hybrid vehicles due to a faulty brake assist system, specifically related to a potential issue with the brake booster pump which could lead to brake failure; the 2019 Toyota Prius was also included in this recall." The recall covered the manufacturing period 4/26/2019 - 6/3/2019 and a recall notice was issued on 7/24/2019 for the affected vehicles and owners were notified on 9/20/2019. We purchased our vehicle on 9/21/2019 with manufacture date August 2019 and on 12/19/2024 we suffered a brake failure causing damage to the vehicle and our garage. The Rav Hybrid Limited comes with sensors that will auto brake if it believes the speed/distance is insufficient and the brakes have not been applied. The brakes were self-applied at the time and no sensor action occurred. I believe the above recall should be extended to include August 2019 manufacture and should also include any sensors that involve the braking system and/or stability control system. Currently we are dealing with insurance and Toyota, no appraisal costs as yet

Dear NHTSA, I am writing to formally lodge a complaint regarding a recurring issue with my 2019 Toyota RAV4, which I believe poses a significant safety concern. The check engine light on my vehicle frequently illuminates, resulting in the disablement of the all-wheel drive (AWD) system. I initially brought my vehicle to a Toyota dealership, where they replaced the charcoal canister (EVAP) three times based on the diagnostic code. Despite these repeated repairs, the problem persists. Suspecting that the issue might be related to the dealership's service, I sought a second opinion from another Toyota dealership. Unfortunately, they provided the same diagnosis and solution, which again failed to resolve the issue. Given that the AWD system is a critical safety feature, especially in adverse driving conditions, I believe this issue should be considered a safety concern and potentially covered by a recall. Further given that the EVAP system is directly tied to the fuel it also should be considered a safety concerns. The repeated failure to address the root cause of the problem not only undermines the reliability of the vehicle but also compromises the safety of its occupants. I kindly request that the NHTSA investigate this matter and consider issuing a recall to address this widespread issue. Your attention to this matter would be greatly appreciated, as it would ensure the safety and satisfaction of Toyota RAV4 owners. Thank you for your time and consideration. [XXX] INFORMATION

The contact owned a 2019 Toyota Rav4 XLE. The contact stated that the vehicle was experiencing excessive lane assist efforts. The contact stated while driving at various speeds near a right turning lane, the lane assist engaged erroneously, causing the vehicle to jolt and pull towards the right turning lane. The vehicle was taken to the dealer several times; however, the contact was informed that the lane assist was operating as designed. The contact stated while driving 75 MPH with cruise control mode a rainstorm suddenly started. The contact stated he disengaged the adaptive cruise control mode and allowed the vehicle to decelerate. The contact stated that the vehicle jolted to the right. The contact stated while attempting to correct the steering wheel, the vehicle hydroplaned. The vehicle veered off the road at 50-60 MPH and hit several trees, was stuck in the trees, and became crushed. The air bags deployed. The driver's side windshield was shattered. The contact was able to push the door open and to climb out of the vehicle. The contact also received assistance from bystanders. The ambulance examined the contact but was not immediately transported to the hospital due to cost. The contact later went to the hospital where he underwent a brain scan, but no brain damage was found. The contact sustained nerve damage in left arm, injured leg, left arm twitching, head trauma, back, neck, and heart injury. The contact also sustained significant PSTD. The contact stated that a b