2019 Toyota RAV4 complaints

Toyota RAV4 LE gas pump burst and caught fire leading to total fire damage along with major water damage from the firefighters putting out the fire. The vehicle was idle for hours at the time of explosion of the fuel pump. This was a major safety hazard/risk especially being that myself and two others were minutes away from going out to the vehicle before it all happened as I was getting ready to take a friend home for the night. A claim representative will look into this matter in coming days.

My 2019 Toyota 8 speed transmission jerking in stop and go traffic

The contact owns a 2019 Toyota Rav4. The contact stated while driving 70 MPH, the vehicle experienced a loss of motive power. No warning light was illuminated. The contact managed to push the vehicle over to the shoulder of the road, and the vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

Safety issue: The vehicle experiences intermittent loss of acceleration and transmission “slip/rev” events, especially when cold, from a stop, or at low speed. At times, the vehicle revs as if in neutral, then re-engages. The driver sometimes must press the accelerator fully to gain speed. In one instance, the vehicle was driven slowly for several miles, pulled over, shut off, restarted, and the function temporarily improved. When it started: Symptoms began immediately after a routine service visit at a Toyota dealership ([XXX]). First noted deceleration going uphill with recovery. Next day, multiple warning indicators/messages appeared and vehicle was towed to the same dealership. Dealer response: Dealership advised transmission replacement based on diagnostic codes and quoted approximately $10,000, stating fluid check was not necessary. Second opinion: Independent shop found transmission fluid level extremely low (reported approx. 1/4 full). They refilled fluid; initially vehicle drove normally, but intermittent slipping/revving continued after pickup (worse when cold/low speed). No external leaks observed by second shop at that time. Current status: Vehicle continues to show intermittent loss of acceleration/slipping behavior, creating a safety risk in traffic. No current check engine light, but symptoms persist. Codes/records available: Codes: P07457F, P28167F, P088A7F, P27137F, C137BA2, C1241, C1280, U1117, B2227. Location: New York. INFORMATION REDACTED PURSUANT TO THE

While traveling back from out of state, the fuel sensor and fuel gauge failed causing me to run out of gas when the fuel gauge stated I had just a tick under a 1/4 tank of gas left and the app read 35 miles left. While driving on freeway at freeway speed, the car sputtered, bogged down and then stalled, placing me in a very dangerous situation broken down on the shoulder of the freeway in the desolate country at night with semi trucks and cars flying by at estimated between 70-80 mph. While stalled and waiting for help, all the lights except the hazard flashers went out. The Sheriff assisted and added 2 gallons of gas that finally got the car restarted and I was able to get to the gas station which was 1 mile ahead of where I had been stranded. I kept filling the gas tank not allowing it to go under 1/2 tank on the fuel gauge the remainder of the trip home. I took the car to Tansky Sawmill Toyota for service, who thought it was a fuel sensor in fuel tank, which had to be dropped, resulting in a tube from the fuel sender being disconnected and not taking fuel from the other side of the tank and corrosion was cleaned out. They had to go through electrical system to check the fuel gauge which had corrosion on the electrical harnesses and sensors not caused by water or rodents - still unknown cause - resulting in $6500.00 to replace both electrical harnesses 82152-0R370 wire FR Door LH and 82141-oRB80 wire Instrument Panel! Known Toyota defect as the 2019 Rav4 Hybrids have alread

The contact owns a 2019 Toyota Rav4. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle stalled. The contact was unsure if the vehicle could be coasted to the side of the road. Several unknown warning lights were illuminated. The vehicle was towed to a collision center. The vehicle was then towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 116,248.

I am reporting a concern regarding the driver’s seat design in my Toyota RAV4. While driving this vehicle, I experience consistent back pain that can begin within approximately 15 minutes of driving and often persists for about two hours after driving has ended. The pain includes sharp discomfort in my mid-to-upper back and occurs despite adjusting the seat position and using aftermarket lumbar and seat supports. I do not experience similar pain when driving other vehicles for comparable durations, including a Toyota Highlander, Toyota Camry, Subaru Impreza, Ford Focus, Rivian truck, or a pickup truck. This strongly suggests the issue is related to the RAV4’s seat ergonomics rather than a preexisting condition. Because of this issue, I have begun avoiding driving my own vehicle when possible. I am submitting this report to document a potential seat design issue that may affect driver comfort and safety.

Steering wheel is making a buzzing noise when you turn the wheel towards the left or right while you’re driving. It will make the noise in park doing the same back and forth. I’m afraid that my power steering will go out while driving.

Jerks during acceleration. Lurching sensation when acceleration from a stop or after slowing down for a turn. The engine control module (ECM) not communicating effectively with the transmission, leading to searching for gears, rough shifting and low speed hesitation.

Strong gas smell when the engine is turned on. I started feel this issue about 2 year ago, now the gas smell is more stronger every time engine is turned on.

Complaint Summary: Seatbelt failure on 2019 Toyota RAV4. Complaint Description: I own a 2019 Toyota RAV4, and the driver-side seatbelt has begun failing. The retractor and locking mechanism are not working reliably. Sometimes the belt won’t retract, sometimes it locks up randomly, and other times it doesn’t lock at all. This is a major safety hazard. I’ve owned many vehicles over my lifetime—older cars, newer cars, even vehicles over 50 years old—and I’ve never had a seatbelt go bad. This is the first time I’ve experienced a critical safety component failing like this. Toyota has issued seatbelt-related recalls on other RAV4 model years, but not on the 2019, even though the symptoms match what others have reported. This failure puts me at risk in the event of a crash, and it needs to be investigated. I am reporting this because I believe this is a safety defect, not normal wear, and it may affect more 2019 RAV4s than just mine.

The contact owns a 2019 Toyota Rav4. The contact stated that the rear hatch door failed to remain securely closed. The contact stated that the failure intermittently occurred and became more frequent over time. Additionally, the front driver’s side seat belt buckle and rear passenger’s side seat belt buckle failed to buckle and lock securely. They also stated that the front driver's side electronic reclining seat made grinding sounds while operating. The contact also stated that water was leaking into the vehicle from the rear passenger’s side quarter panel. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was provided. The failure mileage was 32,000.

My 2019 Toyota RAV4 experienced a dangerous electrical and transmission failure that ultimately caused the vehicle to stall while driving and made me lose control. For several weeks before the incident, the vehicle showed subtle hesitation when accelerating but no warning lights. After the car stalled and spun out coming off the Ben Franklin Bridge onto I-76 near downtown Camden, police responded, confirmed the vehicle had unexpectedly shut off, and verified there was no crash damage. I later brought the car to the Toyota dealership, where they discovered corrosion on the battery cable, failed ABS sensors, and a weak battery. I paid $668 for a new battery, new cable, and ABS sensor repairs. At that time, the dealership did not inform me of any transmission issues and released the vehicle back to me. I made it only a short distance up the road before realizing the vehicle could not accelerate past 40 mph and was still malfunctioning, so I immediately returned it. The next day, the dealership initially claimed there was nothing wrong with the vehicle, but after I insisted they re-evaluate the car, they then informed me that the transmission was failing and needed replacement. This sequence of electrical instability, combined with the transmission malfunction, ultimately led to the earlier stall where I lost all power steering and braking assist and spun out into the median. The vehicle, diagnostic records, and replaced components are available for inspection. The sudden loss of

Rear door liftgate hinges defective. They are too week combined with electric power struts. They are being pulled away from body of vehicle and become misshapen (bent, deformed,etc) and causes door/liftgate to be unbalanced and and stick out too far away from body. Now the door/liftgate can not close and be secured

Was insinuating engine was over heating even in -4° weather has no hot air plenty of coolant. This is causing the vehicle to "buck" amd having to have to pull over and waiting several minutes to let the engine "cool off" I can make it about 3 miles in-between pull overs. After some research I feel like the issue falls under a current lawsuit against Toyota regarding the coolant valve based on reading other issues and what my rav is doing. It is a several thousand dollar fix through a dealership and one my family can not afford especially if it is a poorly manufactured part of the car. It is one of two vehicles we have and need to daily living especially having a child and no means yo offered another safe vehicle at this time. The coolant pump itself

The design of some Rav4 grilles (particularly 2019-2024 models) allows rocks and road debris to easily pass through and damage the vulnerable A/C condenser, or radiator behind it, which leads to very expensive repairs. This is what happened to my 2019 Toyota Rav 4. Now I have to pay 1300.00 to get it repaired.

Lift cylinders of power liftgate are operating at different times causing gate to twist. Liftgate fails to open and close automatically, causing prolonged beeping while liftgate is open. Hinges holding liftgate in place have started to bend and crack apart from the body of the car. An independent auto body shop inspected this issue and recreated the tailgate failure. Quote to repair included replacing hinges, lift cylinders and to recheck electronic connections.

My 2019 Toyota RAV4 Hybrid (VIN: [XXX] ) suffered sudden engine failure due to coolant intrusion. On Nov 20, 2025, Johnstons Toyota in Harriman, NY (RO#XXX) diagnosed the issue and recorded DTCs P26CA31 and P26CB, which indicate failure of the coolant flow control/bypass valve. The dealer confirmed heavy white smoke from the exhaust with a strong coolant smell and advised the engine had failed, recommending a replacement. This vehicle is part of the early 2019 Japan-built batch widely known for premature electric water pump and coolant-flow system failures. Internal impeller swelling, seal leakage, and bearing seizure can cause coolant pressure spikes and ultimately head-gasket failure with coolant entering the cylinders. This defect has been reported by thousands of RAV4 Hybrid owners (2019–2021). Toyota has addressed it quietly through internal TSBs such as XXX and XXX but no public recall has been issued. The safety risk is severe: the engine began emitting thick white smoke and ran roughly, risking sudden power loss, overheating, or engine seizure while driving. A stall at highway speed could easily cause a collision. Toyota USA opened Case #XXX but declined assistance despite the defect being well documented. This failure was sudden, with no warning lights prior to the incident. Given the widespread nature of this defect and its clear safety implications, I request that NHTSA open a formal investigation into the electric water pump/coolant system failures in 2019–2021 To

UNKNOWN

Stopped for gas on 11/6/2025 immediately after getting gas the truck shook twice, the power steering light and engine shut down light came on and the truck turned off. Waited for a few minutes to turn the engine again it wouldn’t start. Got it towed to my nearest dealership who kept it for a day. Said there was nothing wrong with the truck, there was no code showing and they couldn’t determine the cause of the problem.

One week ago one section of the heated steering wheel was very hot. So much so that I could not touch that area. I took it to the Anderson Toyota dealership in Rockford today. On the way there, I turned on the heated steering wheel, and it started smoking. They said they couldn’t find what was wrong with it, and to replace it would be $1800 because it isn’t in warranty. They suggested I not use it.

It happened yesterday , November 3rd at 8:45 am Approx. speed was 35mph to 40 •Location: 934 York Road, Towson, MD •Description: Front-right impact at 40 mph, no airbag deployment, two children in back seat, vehicle had recent 50K service and roof-rail repair, CSP 22TE05, at Sheehy Toyota Cockeysville. Vehicle now at Caliber Collision Cockeysville. Claim #060381946 I am experiencing neck, shoulder and rib pain right now, my 5 year old complain about right ankle pain and apparently hit his head on the right side.My 3 year old complain about neck pain yesterday. There was no sign showing any kind of failure on my dashboard. I asked my vehicle to be investigated formally by Toyota engineer asap or forensic expert. I asked my vehicle to be freeze right until proper airbag inspection have been conducted. I have picture of the car showing clearly that none of the airbags worked.

There is a known TSB out for 2019 toyota rav4 and some select other years. The issue is a slow speed transmission issue. It is due to a programming issue. At slow speeds, if you try to go from the brake pedal to the gas pedal too quickly, there is a serious lag before power is delivered to the wheels. Which is very dangerous when making specific turns. An example is what happened to my wife and myself the other day. We were in a median turning lane, cars were coming, as we were coming to almost a stop, my wife went to apply the gas. There was a serious lag before power was delivered and it almost resulted in a T bone collision. My wife went to apply gas, there was no power for several seconds, which caused her to panic and hit the brakes again. In that process, the power was finally delivered to the wheels and caused the car to pull about halfway into the oncoming traffic before it stopped from her applying the brakes. She then hard to quickly reverse to avoid the collision. The TSB calls for a flash of the TCM and a relearn procedure to be done. Which I am having done today due to the severity of the incident we had. This could have 100% caused a serious or fatal accident. The two dealerships I spoke with severely down played it as an issue. This deserves a investigation and a recall to be sent out. I was never advised of the TSB or anything.

I stopped for gas; my car would not start. The power steering fluid light came on. I went inside to purchase some but when I returned to the car, there was no place to pour it. After a few minutes the car started. About a month later, my husband stopped for gas and the car killed right after he left the gas station, about 10 minutes later, it started. Took it to a mechanic, they couldn't find anything wrong with it because the check engine light wasn't on and the car wasn't giving any problem codes. About two weeks ago, I stopped for gas, the car wouldn't start. Finally got it started, and the check engine light came on. However, it's still not reading any codes.

My check engine light is on due to O2 sensor being dirty. While this light is on some features in the car are disabled like cruise control. It might also be that the ABS braking system is turned off! I am not sure but once when the car in front of me abruptly stopped I was surprised my emergency braking did not kick in.

The car transmission hesitates to accelerate at slow speeds and jerks or lurches forwards in a uncontrollable way. Dangerous at stop signs or on slow or hilly roads. Dealership does not directly acknowledge this issue, despite mechanic mentioning very clearly it is related to T-SB-0107-19 which Toyota dealerships charge to repair. No warning messages. Issue has existed as long as I have owned the vehicle 1.5 years from 61,000 miles to 71,000 miles.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at 40 MPH, the steering wheel seized, and the contact had to use force to maneuver the steering wheel. A yellow light was illuminated, followed by a red light. The message "Power Steering Malfunction" was displayed. The vehicle was taken to the dealer, where it was diagnosed, and determined that the power steering unit sensor had failed. The vehicle was not repaired due to the cost. The contact retrieved DTCs: C05D604 (Electronic Power Steering (EPS) System Internal Failure); C151287 (Malfunction in the Electric Power Steering (EPS) System Torque Sensor); and C15D11C (Electric Parking Brake Failure). The vehicle was not repaired due to the cost. The contact stated that the failure persisted. The contact related the failure to NHTSA Campaign Number: 20V373000 (STEERING); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,500.

The contact owns a 2019 Toyota Rav4. The contact stated that while attempting to open the fuel door, the latch failed to unlock as needed. There was no warning light illuminated. The vehicle was taken to a local independent mechanic to be diagnosed, and the contact was informed that the spring in the latch was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 54,900.

I was driving to Kansas on a road trip and we stopped for gas when we noticed the rear drivers side tire tilting inwards (top of tire angled towards the car). We then drove it to a mechanic in Kansas to see if it is safe to drive further. She noticed the bolt for the rear suspension loose and almost out entirely. She then told us we could not drive the car any further because a few more bumps and the bolt would fall out and create major safely concerns. She also noted that she could see where the bolt was rubbing on the rear suspension sub-plate and could see the old rusted damage along with the new damage from recent driving. She also noted the uneven wear on the tire with the tread worn significantly more on the inner side of the tire. We towed it to Denver to have it looked at and the said the bolt and nut need to be replaced along with a tire alignment. There were no warning signs other than my car felt more bouncy than normal. The car bolt has been replaced but you can inspect the surrounding damage if needed. Both the safety of the people in my vehicle and those around me would have been at risk if we didn't notice the tilt and continued the road trip.

Vehicle states engine maintenance required. Is a consistent reoccurring problem according to dealer. System failure due to manufacturer always puts the user at risk.

Engine stopped power steering low, notification. When in Reverse. Car shuts off and I coast backwards. Have to put it in park and then restart the car.

Cooling System over Temperature. Message kept displaying and check engine lit up again since the first service was done by Tech at the dealership on July 15, 2025.

Got a "Hybrid System Malfunction" notification on my dash and took it to the dealer. I was notified that my high voltage hybrid cable is corroded, and that the vehicle is unsafe to drive. I understand that customer support program 22TE09 exists for this problem, but because my vehicle has over 100,000 miles, it is not covered. If this is a safety issue that Toyota has acknowledged and admitted is an issue, there should be a complete recall. I was FORCED to get the work done at a dealer because Toyota has a hold on the part. I attempted to get an independent garage to do the work, but they were not authorized to even purchase the parts necessary. Ultimately I had no choice but to spend almost $5000 for a safety repair on a 2019 vehicle that Toyota themselves have admitted to the engineering mistake, while also making it impossible to fix outside of a dealer. This is completely unacceptable. Thank you.

Got brand new transmission put in then right after the Coolant leak started into cylinder number 2

I’m reporting a safety issue with my 2019 Toyota RAV4 that has recently started and is getting worse. The problem seems related to the start-stop system or something in the powertrain. When I come to a stop—at a stop sign, red light, or roundabout—the car doesn’t always respond normally when I try to start moving again. Sometimes there’s a hesitation, and other times it lurches forward unexpectedly when I lightly press the gas pedal, like you normally would. It feels like a jolt, almost like whiplash. It’s especially dangerous in roundabouts or tight traffic situations because I can’t predict how the car will respond. I’m worried I could accidentally hit another car, or get rear-ended myself because the car doesn’t move smoothly or reliably when restarting from a stop. Even when I turn off the start-stop system, the issue still happens. It feels like a hesitation followed by a sudden surge. The RPMs don’t change, but the car still lurches. Yesterday, for the first time, I noticed the car slightly accelerated on its own after stopping, which was very concerning. I found out through Toyota’s official website that there is a technical service bulletin about this issue that came out before we owned the vehicle. But because it’s not a full recall, the dealership said they wouldn’t fix it unless we paid the $80 diagnostic fee. We’re now just out of warranty. We’re making $580 monthly payments on a car that I don’t currently feel is safe to drive. There are no warning lights or mess

26Aug2025 I notified Maplewood Toyota MN I had not been notified of safety recalls when nhtsa site confirmed 7 safety recalls. I had absolutly no response. Now nhtsa site says there are no unrepaired recalls when Toyota of Maplewood has done No repairs.

At times it is difficult to connect seat belt into the lock I have to press release multiple times and try to lock in and click seat belt several times. It sometimes connect on first try and has taken 20 minutes to connect seat belt. As of 8/12/25 in for repairs at a cost $430 Driver and left set set belt lock replaced

I am reaching out regarding a structural issue I’ve experienced with my 2019 Toyota RAV4, specifically with the rear power liftgate. Recently, I noticed that the liftgate hinges are beginning to crack and pull away from the body of the vehicle. The alignment of the trunk has shifted slightly, and there is visible damage around the hinge area. This appears to be worsening over time and is beginning to affect the liftgate’s ability to close properly and securely.

The DCM is nonfunctional, which renders the safety connect features of the car inoperable. Additionally, the Bluetooth microphone is powered by the DCM causing the driver to have to switch the call output on their phone manually taking their focus off the road. This seems to be a widespread issue with many reporting this on online threads and Toyota offering many internal service bulletins. To me this is a major safety concern that is extremely costly to repair.

The contact owns a 2019 Toyota Rav4. The contact stated that while the vehicle was parked, the contact noticed fluid leaking from the driver’s side rear door. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 40,000.

2019-2023 model year Toyota RAV4s and Toyota Corollas are equipped with defective coolant bypass valves prone to premature failure which can cause coolant to leak out of a vehicle’s closed-loop coolant system, harming its ability to properly regulate engine temperature. This can cause overheating, stalling, increased emissions, and total engine failure and also allows coolant to leak into and damage surrounding engine components, including a vehicle’s electrical system, the complaint relays. The warning message that common appears for this issue is "Engine maintenance required Visit your dealer "

The engine maintenance light came on and I took the car to my independent mechanic. The "soft code" indicates that the coolant system valve/hose (engine coolant bypass valve) is showing in the closed position when it should be open. My mechanic has tried to order a replacement part, but is having trouble finding one. After my personal research, I see that there is a Class Action Lawsuit regarding this part from 2024 indicating that it can cause the car to overheat, stall, and potentially severe engine damage. Toyota has no formal recalls on this, but it has been indicated that some owners have received support from Toyota on models built up to 2021.

The roof of my SUV is leaking and it’s leaking into my two airbags. There’s a sunroof and the roof rack

Was putting the cover back on after washing, putting the lower sitting piece on and the foam headrest just came right off

7/16/2025 Engine Maintenance Required Visit Dealer" message on a 2019 Toyota RAV4 LE came on and will not go off. Upon further research and inspection coolant bypass valve is faulty.

I am submitting this complaint regarding a recurring issue in the coolant bypass valve of my 2019 Toyota RAV4 XLE Premium. Although there was no check engine light, the vehicle displayed a persistent warning: “Engine Maintenance Required – Visit Dealership.” This message repeatedly appears on the instrument cluster and blocks critical driving information, including the speedometer, fuel economy, and other key displays. Even when the driver manually cancels the message, it returns within minutes. This creates a constant distraction and obstructs visibility, which poses a safety risk during driving. I took the vehicle to the dealership, where they diagnosed the issue as an internal short circuit in the coolant bypass valve and retrieved diagnostic trouble code P268115. This code relates to a malfunction in the valve’s electrical control system, which affects the engine’s ability to regulate temperature effectively. Toyota currently offers a Customer Support Program (CSP) for the coolant bypass valve, but only if the valve is leaking coolant. However, my vehicle's failure was due to an electrical defect, and Toyota does not cover this under the same program. This creates an unfair burden on owners and fails to address the full scope of the issue, even though the results—loss of proper cooling function—are the same. Many RAV4 owners have reported similar problems online, but no recall or technical service bulletin has been issued for this kind of failure. I believe this defect ra

The water pump failed at 49000 miles left me with a repair of $1500 at Kendall Toyota dealership

My car steering wheel is not responding correctly when I drive". Last week a warning light of faulty steering angle sensor keeps showing on and off. I am afraid that I may crash. I called Toyota to let them know and after verifying my VIN # they want to charge me $185.00 because according to them my car is not on their recall all the information can also be found on the website.

Scan Report done ! odometer 25266.Engine coolant bypass valve "A" control circuit failed test. Engine Control Module Code P2681-15. Message: factory service require !

The vehicle began displaying intermittent warning messages and slipping into "Mud & Sand" mode without cause. Later, multiple dash lights illuminated, including 4WD malfunction, check engine, and coolant system warnings. The vehicle became undrivable due to overheating. Dealership diagnostics indicated a failure in the coolant bypass valve actuator the electronic water pump was receiving a signal but not responding, resulting in loss of coolant circulation and overheating. There may also be a shorted control panel causing related system failures. This problem has been confirmed by a Toyota dealer, and the vehicle remains at the service center pending resolution. The issue appears related to a known Customer Support Program (CSP 24TE04), which covers the coolant bypass valve actuator. There was no prior accident or abuse of the vehicle, and the vehicle only has 52,000 miles. Safety was compromised due to unexpected power loss and overheating while in motion. The issue has not yet been resolved. The vehicle has also experienced prior water intrusion through the roof rails, which may have contributed to electrical damage.