2012 Toyota Prius complaints

The contact owns a 2012 Toyota Prius. The contact stated while driving 60 MPH, there was an abnormal grinding sound coming from the brakes while the brake pedal was depressed. The brakes, the traction control, and the ABS warning lights were illuminated. The vehicle was then taken to an independent mechanic where it was diagnosed with brake booster and master cylinder assembly failure. The vehicle was not repaired for the most recent failure. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 106,019.

I accidentally slid out into traffic as my brakes failed as I pulled up to stop at the edge of the parking lot. I was nearly hit driver's side on a pickup. Fortunately, it was able to swerve around me and there was no immediate following vehicle. I was able to pull out and back into a nearby parking lot to address the problem with my brakes. Upon speaking to my mechanic and local Toyota Dealership I was informed that the brake booster/accumulator had failed and that this was a known issue on my vehicle. Toyota extended a special warranty on these parts several times but did not notify owners of the safety risk. That warranty coverage has expired for my vehicle. I believe it is an inherent safety risk and they obscured it by covering the parts under this extended warranty. I believe they should be recalled and at the least owners should be warned of the risks. All communications were done over the phone or in person, I have no electronic records. I submitted an identical request on my 2011 Prius by accident, as I used it's VIN when I meant to use the VIN on my 2012 Prius. Regardless, I am now concerned for my safety in both vehicles.

Failure in ABS system

Vehicle has good break pads and rotors. Also the vehicle turn on the ABS the Break and the slippery lights on. When the car was scanned is show code C1391" which indicates a problem with the brake accumulator within the system, often requiring replacement of the brake booster and accumulator assembly. I can't drive the car and other people with same car on 2011 year has the same issue

As i was driving, my breaks suddenly became spongey and unresponsive. I could hear a "hiss" sound come from below me. ABS and other warning lights came on on my dash. As i was near my auto mechanic i tried to make it there safely, and as i drove the brakes seemed to become softer and softer. By the time i had reached my mechanic i was so uncomfortable with its ineffectivness i felt it necessary to use the emergency brake to come to a complete stop. My mechanic confirmed that the issues included the failing of the Brake Booster, Brake Master Cylinder, Accumulator Pump, ABS, ABS Computer. According to him this was caused by a set of issues involving internal leaks in the brake booster assembly. These issues were replicatable, and my mechanic says they pose a saftey risk. Even after he gave it a "temporary patch job." Due to this the only times it has been driven were to get it home, to move it along our street so as to not get ticketed for having a stationary vehicle too many days in a row, and one time it was taken up the nearest rise in preparation for a Tsunami warning. When looking for replacment parts, my mechanic allerted me to a Technical Service Bulletin that should have been sent out to owners warning them of this issue and offering replacment parts. I never received this notice as I am the second owner of this vehicle, the notices were sent before i owned it, the previous owner claims not to have been aware of this issue herself, and because it was a voluntary service

My Brakes almost caused me to crash on Jan 18th. I'm driving down the highway and traffic comes to a complete stop. I started braking but my abs, stability control and brake light come on. When this occurred I had to push the brakes to the floor just to stop. My brakes were very unsafe and unpredictable. I had to drive way below the speed limit to make it home, keeping at least 8 car lengths between me. I inspected the vehicle when I made it home. Their is noise coming from the driver side firewall. Something is consistently turning on and off and a slight click after each cycle, every 5 seconds approximately. I was told that it was my abs pump or brake actuator. This is unacceptable and dangerous to all consumers. The fact there was no warning that occurred in a safer environment. I'm so thankful my kid wasn't driving it. Why isn't this a recall? I don't understand how something this dangerous is not a factor to the consumers. I have researched and found many cases that consumers have had a similar issue. This issue is not like brake pads. Their is a clear warning when its time to change brake pads. I honestly would like to see toyota to fix this issue.

I am writing to bring attention to a critical safety issue affecting the 2012 Toyota Prius and other Toyota models equipped with the brake booster and actuator system. These components are failing at alarming rates, leaving vehicles with no functional brakes, ABS, or traction control. Additionally, this failure compromises the hybrid system due to the regenerative braking no longer working, potentially causing further damage to hybrid components and resulting in repairs costing several thousand dollars. Toyota issued Customer Support Program ZJB, which covered these issues for a limited period. This program was in effect from August 31, 2021, with no mileage or year restrictions, but offered secondary coverage for up to 10 years or 150,000 miles from the vehicle’s first use. Unfortunately, my vehicle, with approximately 130,000 miles and 12 years of age, was denied coverage when brought to a dealer after the program had ended. Despite the brake booster and actuator failing, the dealership did not advise me not to drive the vehicle, further emphasizing the gravity of this oversight. This is a significant safety hazard, as vehicles with these failures lack the ability to stop effectively, risking lives on the road. Furthermore, this problem is not isolated to my Prius; it affects thousands of Toyota vehicles equipped with these components. The estimated repair cost exceeds $3,000, an undue burden on owners for an issue that stems from defective manufacturing. I firmly believe T

The brake actuator has failed in this 2012 Prius with 135,000 miles. No issues were noticed while braking, however, when starting the car, the ABS, Brake and Traction Control warning lights lit up. The Toyota Dealership said this is a failed Brake Actuator and quoted $3,800. We have learned there is a secondary warranty on this part due to constant failures that Toyota issued, however, this warranty only applies to Prius up to 150,000 miles or 10 years from initial use, whichever comes first. This is unfair to most Prius users as this is a common problem happening, but typically happening after the 10 year mark.

The ABS, Brake, and Traction Control lights all illuminated while driving. I took it into a local shop, the computer scanned "brake accumulator leak". The accumulator is buzzing every 10 seconds and the brake fluid needs topping up. Now there is a brake fluid puddle under the car. The fix is to repair the brake master cylinder and replace the brake booster pump. The car is a 2012 with 110,000 miles. This is a known Toyota Prius vehicle issue but they decline to service it and can the brakes can fail.

Without warning, the ABS, Traction Stability, Brake and other lights lit up and I lost braking on the highway. Luckily, I was in very light and narrowly avoided a crash. I was able to get home with far less braking power and no regenerative braking. Since then, I have researched the problem and found that this is an extremely common issue. I can remedy it for ten or twenty minutes by putting the car in DIAG mode and pumping the brakes, but it will do it again, and again. I need a new accumulator and ABS module, and the dealer wants thousands for it. I cannot afford it and it is a known flaw and a safety issue. I take my daughter to school in this car, thankfully it's nearby, but it's terrifying. Our other Prius has no issues, and I understand that Toyota has repaired other cars under a warranty program of which I was never notified.

2012 Prius in very good condition with 180k miles- only 12 years old. Driving on back roads (thankfully) and the drivers side rear wheel compelely fell off while driving. I was doing about 30 MPH and felt like there was a flat tire so I was in the process of pulling over when the whole rear assembly snapped. The wheel hit the rear quarter of the car and bounced about 100 feet down the road. I could have been on the highway and this could have been fatal I believe. Very, Very scary. As can be seen in attached photos the issue was rust from the inside. This is very concerning since there was no way for me to know this was an issue. I could have been killed or killed someone else. I believe Toyota needs to look into this since there are other Prius' out there the same thing happened to on this very thread. Although this is a Massachusetts car I have owed it since 25k miles and have maintained it impeccably. I always have the undercarriage cleaned after driving on salty roads. Safety inspection was current- only done the month before. Had that wheel bearing replaced about 2 weeks before the incident and the reputable mechanic reported no issues. There was no warning except for maybe a minute before it happened- the car was vibrating like I had a flat tire. The damage repair estimate on this was $8500. Catastrophic fail Toyota. Is this a rust issue like the Tacoma, Tundra, and Sequoia?????

2012 Toyota Prius 5 with 105k miles. ABS, Brake, and Traction Control lights all illuminated while driving to work. Drove to the dealership and had their service department run a diagnosis for 200$. Their scanner reported CODE C1391, and that a new BRAKE PUMP and MASTER CYLINDER ASSEMBLY would need to be replaced for a total cost of $4,000. Toyota has a Customer Support Program Bulletin indicating that certain 2010-2015 Toyota Prius will experience internal malfunctions and require repair for BRAKE BOOSTER AND BRAKE BOOSTER PUMP ASSEMBLIES. Since this is a safety issue, Toyota should extend the program indefinite and repair their faulty systems.

Wednesday morning I went to start my car to go to work. I noticed the brake would not go down. It was difficult to press. I was unable to go to work safely. I brought my car to a mechanic where I was informed it was a faulty brake booster. When I researched online, I saw many many other Toyota owners went through the exact same issue. There is no recall but it’s a huge issue and a a safety problem.

ABS Pump and Actuator failed at 100,000 miles. Traction control, ebrake, ABS light came on while driving. Many other stories of Toyota vehicles with the same failure.

My actuator is failing. This is a known issue for Priuses and a danger to those on the road. Toyota issued a voluntary service program on these parts to avoid a recall and now many are on the road with actautors that should have been replaced.

ABS brake system doesn't work with three warning lights on and warning beeping sound. I'v learned that Brake actuator failed. Current mileage is only 67300.

ABS Break Lights turned ON and it need replacement. Toyota have faulty ABS this is my 3rd Prius that have the same Issue.

I started noticing a strange noise when I applied the brakes. It was an electronic type of almost grinding sound. When I looked into it, it was determined that the brake actuator was failing despite no warning lights coming on. This started around the beginning of March. Finally in the beginning of July the noise stopped and a lot of dashboard lights came on including ABS, BRAKE, and others. This is when the brake actuator actually failed, and the battery no longer was charged when the brakes were applied. This is extremely concerning that a major brake component can fail like this and affect the safety of the vehicle. I am attaching a photo of the dash that shows the lights that came on when this failure occurred.

I contacted Toyota about the peeling paint on my car. The Toyota representative told me to file a complaint with your agency. The paint is peeling on the roof of my car. There are many similar cars with the same problem. Toyota is unresponsive.

On 07-June-2024 @14:47 my 2012 Toyota Prius suffered a catastrophic failure. I was attempting to back my 2012 Toyota Prius vehicle a few meters back into my driveway while turning slightly. This was a very slow speed backup. Suddenly, the rear passenger side wheel collapsed inward, and rendered the vehicle unmovable. A video of the incident is attached for viewing The vehicle has low mileage approximately 58,000 miles. The vehicle is in excellent condition and the service records provide evidence of proper maintenance, often at Toyota dealership. This vehicle was originally from Cape Cod Massachusetts and perhaps suffered adverse effects from ocean salt air? Although the rest of the vehicle does not show any significant rusting. . I am impressed by the engineering of the Prius hybrid technology, but this point of failure seems to be an engineering weakness.

In 2019, I took my Prius in for service. I reported that when I suddenly brake, the pedal feels spongy as if the brakes will not stop vehicle and lights on dash lit up. Toyota did diagnostic, no action taken by service department at Toyota dealership. I have service history documentation. On June 29, 2024 we had routine maintenance and the service department of the Toyota dealership recommended brake fluid serviced. On July 1, 2024, I was driving my child home from his summer camp and when I tried to stop the brake did not work. I started pumping the brakes several times until the car slowed and came to a stop. The lights on the dash lit up again. The brake failure put my son and I in danger. We had the car towed to the service department of the Toyota dealership. The service department sent the following information after their diagnostic. "The warning lights re-appeared after we drove it a few times. Now regarding the brake fluid service we performed, it is not related to those warning lights. Your accumulator is internally failing. The accumulator is a computer that distributes and controls the amount of pressure going into the brake system, and the computer was not untouched. Unfortunately it was bad timing and the computer started to internally fail. These vehicle's are known to have bad brake actuators, and Toyota created a type of recall for it to get replaced under no charge. Unfortunately they only cover up to 10 years and your warranty expired last year." My husband

Completely lost vacuum brake assist without any prior warning, while driving on the interstate. Got warning lights on the dash for brake and ABS, when it happened. Fortunately there was little traffic, but if there had been even moderate traffic, it could have caused a crash. Checked the codes and found a C1391 leak in the accumulator. Dealer has quoted me $3200 to repair.

Hi NHTSA, I have a 2012 Toyota Prius and all the Brake-related lights came on the dash. ABS and TC stopped working and the Brake Pedal lost sensitivity. I was about to crash the car and immediately took my car to the Toyota Dealership. They said that there was a Recall unfortunately the program has expired on my vehicle. I asked a couple of Toyota Prius owner friends and half of them had the same issue and they have been fixed under a program. But they said my 95k miles Prius is barely out of the program. My concern is that they charged the diagnosis cost released my vehicle and said that it was not safe to drive! I don't have the budget to cover the Manufacturer's low-quality BRAKE Booster production and I have to drive my car every day! I don't want to risk anyone but I have no choice. I hope you can help!

The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle did not stop as intended. In addition, several unknown warning lights were illuminated. The contact used the parking brake to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with a failed brake master cylinder, accumulator, and brake booster. The contact was informed that the brake master cylinder, accumulator, and brake booster needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed of an unknown recall for the failure; however, the contact was informed that the recall had expired. The failure mileage was approximately 136,000.

Traction control, brake, and abs warning lights all came on at once while driving on freeway. Braking became harder. Car has fewer than 60,000 miles. I took it to the mechanic. He says I need a new booster pump.

Decreased braking performance. Sudden loss of ABS and Traction Control capabilities. (ABS light and Traction Control lights are now permanently illuminated on the dash). During the drive home, the brake response changed dramatically. More force is now required to operate the brakes. This failure occurred during a merge into traffic while on a merge ramp, going about 35 mph. It took what felt like a few seconds for both the vehicle and myself to adjust to the new braking requirements. During this time, it felt like a brief loss of braking ability. I continued to depress the brake pedal, and finally noticed a slowing of the vehicle. The pedal clearly requires much more effort and depress distance to begin slowing down the car. This decreased braking performance appears to be sustained until repairs are made to the vehicle.

ABS, Stability Control and Brake warning lamps on dashboard. Faulty Brake Booster/Pump/Accumulator doesn't allow for safe stopping. Looking on the world wide web, it appears to be a common issue with this generation Prius (and it is COSTLY to repair).

Was 8 days out of warranty so Toyota would not honor offer to replace the brake booster/actuator. Paid personally to have it done with genuine Toyota parts. 16 months later same parts need replacing. Toyota refuses to help.

Brake system warning lights illuminated. The brake pedal pressure required to stop the vehicle has increased. In effect: no power brakes, no traction control, and no antilock available. Intermittent engagement of an electric motor can be heard about every 8 seconds for a period of about 3 seconds during operation of the vehicle at all times.

Sudden lights appear on dashboard. Brake system sudden fail becomes very hard to press the pedal or apply brakes My car has 136000 miles only Asked mechanic and mentioned the brake booster pump.

Brake pressure actuator defect leading to major brake failure. No warning until it's too late.

Warning lights, and while driving the ABS, brake, and traction control lights came on, and I NOTICED a strange sound when applying the brakes. The brakes seem somewhat soft when applied. This is a 2012 Prius with 123,000 miles.

2012 Prius has a fault from the the manufactor where the electronic brake abs actuator and pump, which are two seperate parts working together, are faulty. Various lights on dashboard illuminate brake, tire pressure, abs, and traction control. When this occurs the car becomes very unsafe to drive as the brakes become almost non existant because the braking system on the car is electronic and controlled by both the pump and actuator. This makes the car dangerous to drive, even in short trip conditions as the brakes could fail to engage at any time. The dealer confirmed that it is a known issue on this model Prius and did not cover the cost to fix it even though the car is not safe to drive. This is dangerous and should have a recall so the car can be safe to drive on roads and potenially save lives if the brake system fails to engage,

The contact owns a 2012 Toyota Prius. The contact stated that when the vehicle was started, there was a rattling sound coming from the vehicle. The contact stated that while depressing the accelerator pedal, the vehicle started shaking abnormally with a rattling sound. The vehicle was taken to the dealer where it was diagnosed with a blown head gasket and that the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 106,000.

I bought my first used car, 2012 Toyota Prius, from Fowler Toyota back at the end of October 2023, but I was not able to pick it up until September 21, 2023 due to extra time for re-conditioning. I did not haggle about the price nor complained about the 3 week delay. In the last 3 weeks of owning my car, the TPMS sensor light and check engine light infrequently turned on. February 28, 2024 all the fault sensor lights on my instrument panel are on, along with the loss of proper braking function. I was not worried about the other sensor faults, but brake malfunction is a matter of life and death to myself and others on the road. I have had the car for a little over 4 months and less than 10k miles. I brought the car in to diagnose all the error codes. The dealer said it will cost over $2600 to fix the brake malfunction. I chose this particular car because carfax had well documented service records and Fowler Toyota advertised that every used vehicle for sale has surpassed rigorous inspection. I voiced my complaint to the used car director and he offered numerous default excuses for unforeseen problems inherent in buying a used car. I said I did my due diligence by selectively purchasing a used Toyota Prius, from a reputable Toyota dealership that uses a Toyota certified service center to inspect and recondition vehicles for sale. All the cliche nightmare stories of buying a used car from the side of the road car lots came true in my experience at Fowler Toyota. The worst used c

Brake master control system failure with constant issues over 80k miles. Forward running lights control housing has not held a light fixture since day one and dealership wants to charge for light replacement. It’s a faulty part and burnt through the housing. Olathe Toyota refused to repair under warranty saying it was a customer issue but is clearly a safety problem. Irresponsible dealer management.

I was driving on the internet doing 60mph and there was a very loud bang and then a shaking of the parts under the hood. I was right next to an exit and coasted off the exit to a hotel parking lot. I had car towed to my mechanic. He said that the piston went thru the engine and the engine is done and needs replaced. I am having a hard time trusting Toyota again to purchase another Prius. I have had Prius for over 10 years and never had anything like this occur. I had no warning signs and no dashboard lights lit up until after all of this occurred and scared the life out of me then the engine light came on.

The contact owns a 2012 Toyota Prius. The contact stated that while driving at various speeds, the ABS warning light illuminated and the vehicle skidded while depressing the brake pedal. The contact stated that the hazard lights independently activated and caused the battery to drain, and the vehicle would stall. The vehicle was taken to a dealer where the contact was informed that there was a Customer Satisfaction Program for the failure, but the Customer Satisfaction Program had expired. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 120,000.

The contact owns a 2012 Toyota Prius. The contact stated that on several occasions while driving at various speeds, the brake pedal was depressed, and the vehicle started shaking and failed to slow down as intended. The brake, ABS, and traction control warning lights were illuminated. On another occasion, while driving 70 MPH, the brake pedal was depressed, and the vehicle began shaking and failed to slow down as intended. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 88,000.

Brake failure

Hard to stop, ABS AND BRAKE AND TRACTION CONTROLL RELATED WARNING LIGHTS ON. ERROR CODE C1391

Weather stripping around the solar sunroof cracked and has come off in sections. This is a very common problem with this specific model, but remains low due to the low numbers the solar sunroof packages was produced. Afraid the sunroof will leak if used, so it stays inoperable in order to not damage broken seals.

On October 24, 2023, while driving my car, several lights went on all at once, including the ABS, and brake lights. I immediately drove it to the Toyota Dealership on 2213 Old Jacksboro Hwy, WF TX 76301. The car was also making a noise constantly, that I had taken into Toyota service center previously which was also causing an issue with my battery dying. (It went through 4 batteries in the last 2 years). Toyota diagnosed it as a problem with brake booster and assembly and brake booster pump. calling for both of them to be replaced at a cost of $3,888. Toyota did not inform us of any recall regarding brakes, I did email Toyota directly, called and tried to work with the dealership, all to no avail. They are being sued due to numerous complaints and refused to assist me.

I have had a 2012 Prius since 2016. The entire time I've had it, it occasionally "hydroplanes" but without any water. It happens in wet or dry (but mostly dry) conditions. Usually at slower speeds so, though it makes me very uncomfortable, it doesn't happen with any regularity. I've taken it multiple times to my mechanic who always says "Prius' just do that", which is not reassuring. I know there was a recall and I was told my car did not fall under that umbrella. On Wednesday of this week, 10/25/23, I finally had an accident because of this. The brake lockup had been happening more frequently in the past week and in this instance I saw the car in front of me suddenly slow down - I had about 2/3 of a cars distance between me and the car ahead. I hit the brakes and nothing happened. I was pushing down on them long enough to think, "Ok, this is it. They aren't responding at all and I'm going to hit this car in front of me." I did and it crushed the passenger side of the car. Luckily I wasn't hurt. There were no warnings from the car at all that this was going to happen, as there never are. I took it in for possible repair today (the mechanic is not sure but thinks it may be a total loss). This car did everything they describe in the recall cases and I want to know if there's anyway to be repaid from the company for this as there was nothing I could do to stop this accident? Why wasn't my car included in the recall?

Error code C1391 confirmed by two separate facilities, described as "abnormal leak in accumulator" and "accumulator pressure." Took to an independent shop first, then to Haley Certified Toyota Dealership. At dealership, parts needed were quoted to include tsb-0024-19. Three lights went on simultaneously (ABS, Traction, Brake).

The abs pump kept running after the car stopped running... Malfunction and had to be replaced!

My car breaks with out i almost hit the car in front of me, i could killed someone . This is very dangerous i took my car to a Toyota dealership they said the Extended warranty expired. They said upon inspection found code C1252,C1253,C1256 brake pump and actuator fault. Upon inspection found abs actuator accumualtor leak. Causing brake pedal to be hard and brake system malfunction. Toyota should had made a recall of this and not just a extended warranty that expires. I have 206,000 miles original owner they should me a lawsuit for this its very dangerous. I end paying $3000 of my own money to fix it, i should get reimburse for my money.

ABS, Break and traction control lights from dashboard lit on and breaks were difficult to operate during driving, able to drive back home safely. Find out that ABS (brake booster and brake booster pump assemblies which are consider safety items), are defective and can cause accidents. When calling Toyota Customer Experience Center, they decline to honor customer support program ZJB due to my car is exceeding by 5k miles the additional limited warranty. Now I will have to pay out of pocket on known safety defective part, this should be a recall and not wait to an accident to happen.

There is no incident occurring to me .but I change some parts like head light.& whisper .engine .

******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT IS REQUESTED BY THE CONSUMER THAT THEY WISH TO HAVE IT REMOVED. DJR ******* DELETE VOQ *******