2021 Toyota Highlander complaints

My vehicle was rear-ended while stopped by a 2014 Toyota Corolla that was estimated to be traveling between 60-70 miles per hour. During the crash, the driver seat failed, resulting in the partially reclining into the second row passenger. The failure mechanism appears to be internal to the seatback, as the seat twisted during the failure, causing me to lean more towards the passenger side of the vehicle.

The car started making a whining.humming sound only while pressing the gas. Took to mechanic and they advised it was TSB 0008-21. I need a new transmission. I drive this daily with my own kids, and several that aren't mine. If the transmission were to go out, I would not be able to accelerate and the care would stop moving. I can't even imagine this happening on a high with hundreds of cars speeding or a busy road. This could cause a bad accident, injury or death. No warnings etc. The noise just started and took right to mechanic. I gave the mechanic a copt of power train warrant and hoping it gets covered and fixed.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Regarding Toyota TSB T-SB-0008-21, ‘Whine or Grind Noise From the Transmission’, issued February 2021: Some 2021 model year Avalon, Highlander, and Camry vehicles equipped with UA80E or UA80F transmissions may exhibit a whine or grind noise from the transmission. This condition may be caused by an issue with the front carrier assembly pinion shafts. This is a widespread problem with these specified transmissions. The noise generally starts around 60-70k miles, just outside the warranty period. Toyota knowingly continued to sell vehicles with these defective transmissions. Repair estimates range from $8.5k-$13k.

SAFETY RECALL 23TA15 (Interim Notice 23TB15) was issued December 20, 2023 - almost one year ago. Toyota does not yet have a remedy for this potentially serious safety issue. For several months, Toyota's website has had the following verbiage regarding this "Toyota estimates the remedy can be available in Quarter 3, 2024, but this is subject to change based on parts availability." I cannot continue to drive people with this potentially serious safety issue. When will a remedy be available?

Transmission failure at 70,000 miles waited 3 months for replacement transmission.

Water leaking into the A pillar where airbags are located due to faulty seals in roof rails.

My wife’s Highlander started whining under acceleration. I am not a trained mechanic but know enough about vehicles that I k ew it was the transmission. I checked Google for 2021 Highlander complaints and found hundreds of them. The vehicle has 90k on it but luckily we bought the extended warranty through Toyota. I took the vehicle in for service and told them the transmission was whining and needed replaced and would be covered under my warranty. They looked at me strange and said ok sure, we’ll check it out. 4 hours later they called to confirm I needed a new transmission. They estimate it to take be 4 weeks before they receive the transmission. Apparently so many being replaced they are on back order. Luckily we bought our vehicle as a “Certified Pre-Owned” so we get a loaner the entire time. Just sad to see Toyota quality going down hill like it has.

See attached document for complaint.

Chest clip is magnetic and can be opened by child without using the buttons to open. No longer staying closed.

I WAS COMING HOME FROM WORK AND THE BREAK SYSTEM FAIL AND THEN I WAS COMING TO SA STOP LIGHT I WAS ABLE TO BREAK SLOWLY AND I WAS ABLE TO GO INTO SHELL GAS STATION GOT OFF TO PUT GAS AND THE STARTED TALKING TO TAKE IT TO THE NEAR DEALER TOYOTA .I GOT OFF THE VECHICLE PUT GAS AND WHEN I STARTED TO TURN ON I WOULD TURN ON AT ALL I DO T KNOW I GAVE IT SOME GAS AND I WAS ABLE TO TURN IT ON BUT THE MOTER WAS SHAKING AND IT WAS STALING ON ME. THE H AND COLD GAUGE WAS STUCK NOT MOVING ETHIER. THAT FAN FROM THE MOTER STOP WORKING AS WELL I WAS ABLE TO TURN IT ON AND I DRO E IT TO MY MOTHERS HOUSE AND LEFT IT THEIR GOT A TOWTRUCK ON THE JULY 28 2024 TO TAKE IT TO THE DEALERSHIP I HAD TO PAY THE TOW TRUCK AND UNTILL KNOW I HAVENT GOT MY REFUND BACK BECAUSE I HAD TOWNIG WITH THE VECHICLE WHEN I PURCHASED IT. ITS 2 MONTHS OUT I STILL HAVENT GOTTEN MY TRANSMISSION OR GOTTEN FIX AND THE VECHICLE HAD THE EXTENDED WARRANTY AS WELL IT HAS 71,700 ML ON IT AND I ALSO HAVE TO PAY THE RENTAL VECHICLE AS WELL. TOYOTA DOENT WAST TO PAY AT ALL FOR THE RENTAL VECHICLE.

Sunroof shattered while vehicle was parked. Nothing touched the vehicle. We were just sitting in the car when it happened.

[XXX], while driving on a [XXX], my 2021 Highlander Platinum unexpectedly shut down without ANY prior warning or indication of a malfunction. This abrupt failure put my safety, as well as that of my passengers and other motorists, at considerable risk. As a longtime Toyota customer, I have always valued the reputation of Toyota vehicles for their reliability and safety. However, this incident has significantly shaken my confidence in that reputation. I trusted that my vehicle, particularly one as recent as the 2021 Highlander, would perform safely and effectively in all driving conditions. The complete and sudden failure of the vehicle on a busy highway is not only unacceptable, but also alarming. I now find myself questioning whether I can continue to rely on this vehicle or the brand itself. After having the vehicle towed from obstructing a busy lane of traffic, the battery was jump started to get the car running again. I had NEVER had ANY issues with battery and all regular services had been completed at a Toyota Service Center, but several codes appeared on the dashboard after this incident advising the vehicle be taken to a dealer. Vehicle was taken to Toyota Service Center [XXX] for a diagnostic check, but they couldn’t find any error codes or issues with the vehicle. I contacted Toyota to thoroughly investigate this matter and address the underlying issue that caused the shutdown, so that I can regain confidence in its safety and dependability. INFORMATION REDACTED PUR

I just bought this 2021 Highlander XSE & the drivers side mirror vibrates above 30mph. I feel this makes it very hard to see properly especially on the interstate traveling 70mph & trying to get a clear view of the roadway & cars around me. I took the car to my local Toyota dealer & was told this is a common problem among the new design with the Highlander’s. I do not feel safe not being able to see properly.

A whine developed while accelerating on the highway. The whine continued any time I accelerated higher than about 35 mph. I suspected it was the transmission and Toyota confirmed I was right. I need a whole new transmission. At 59,000 miles, my Highlander is still under power train warranty. However, my car was diagnosed July 9 and I am still waiting for the part to come in at the dealership more than 2 months later. I was told verbally that I would be able to still drive the car while waiting, but I don't feel safe doing so.

Transmission/differential - Took my car in around 80k miles for a routine transmission service. I got my car back and it started making a whining noise when you accelerate. Never did I get a code, check engine light nothing. Took it back to get looked it since the sound never went away. I am being told it needs a new transmission. I was told my car transmission was too hot for them to even look at after sitting for 24hr parked! I have read and done a lot of research that this is a common issue and never has been recalled. Even a shortage now on transmissions with so many needing them now! My car is only 3 years old and won’t be covered.. this should have been recalled and or known to buyers before purchasing if it was known to have issues early 2021…

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The vehicle is a hybrid. While traveling downhill at a speed around 35 mph with light brake pressure, the vehicle feels like it lurches forward a second or so before returning to braking. It has occurred since we purchased the vehicle new in 2021. It has happened multiple times in a variety of scenarios but it occurs most consistently in the downhill scenario described above.

The contact owns a 2021 Toyota Highlander. The contact received notifications of NHTSA Campaign Numbers: 23V720000 (Structure) and 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving 65 MPH, there was an abnormal sound coming from the front end of the vehicle and it felt like the front tires had struck an object on the highway. The contact stopped the vehicle and observed that the lower half of the front bumper had detached and was on the road surface. The contact called a local dealer and was informed that the parts were not yet available. The vehicle was not repaired. The failure mileage was approximately 31,000. VIN tool confirms parts not available.

Transaxle Repair/Replacement: recommend transmission replacement due to whining noise coming from transmission due to internal failure. The transaxle is the transmission for front wheel drive vehicles. The transaxle transfers power from the engine to the wheels. Unsafe driving conditions issue is stemming from faulty transmission, not only on this particular vehicle but many 2021 Toyota Highlander vehicles for the same transaxle repair/replacement issue. I have gone to Toyota multiple times before and even with a Technical Service Bulletin in place for this transmission issue, they did not correct the problem, nor fix it while it was under warranty. Toyota has been aware of this Technical Service Bulletin since Feb 9 2021. T-SB-0008-21 [XXX] Owners of the 2021 Toyota Highlander have reported various transmission problems, including: Whine or Grind Noise: Some vehicles exhibit a whine or grind noise from the transmission, which may be caused by an issue with the front carrier assembly pinion shafts1. Jerky Gear Shifts: Drivers have experienced jerky gear shifts, especially when accelerating from a stop or slowing down to very low speeds2. Delayed Shifts and Hard Shifts: There have been complaints about delayed shifts, hard shifts, and lurching when shifting gears3. Transmission Slipping: Instances of the transmission slipping between gears and jerking when accelerating have also been reported4. Safety Concerns These transmission issues pose several safety risks: Loss of Contro

Our Highlander has a recall for the clips on the front bumper. A few weeks ago, my wife was driving behind a truck pulling a trailer. My wife that it was a set of caster wheels that flew out from the trailer and made contact with her front bumper. Upon inspection the impact from that debris put a crack in the upper front bumper. No other visible damage was present. Later that day while my wife was driving 75 on the interstate, the defective clips from the recall gave way and the lower front bumper gave way and started to drag on the ground. Luckily it stayed in tack enough that the vehicle did not run it over causing my wife to wreck or even worse having other vehicles needing to avoid it on the interstate. We paid for a tow truck to safely take it off the interstate so we could tie wrap the lower bumper up and take it to the dealer. Toyota recall does warn that light impact to the bumper could result in the bumper falling. It also goes on to say that if the clips cannot be changed out, they will replace both the lower and upper bumpers. I took the car to the local dealer, and they confirmed that the clips could not be replaced due to the damage that had been done. I showed the dealer the recall notification on the internet, and they stated they could not do anything as they were not a body shop. So, I opened a complaint with Toyota Customer Care [XXX] ) and stated my case. They in turn notified a local dealer to address the issue. I have called customer care twice not withou

Unknown

The sunroof exploded in 75 degree weather. My safety was put at risk by the sunroof exploding and others were put at risk that were following on highway from flying glass. The problem was confirmed by safelite. Toyota refuses to take any responsibility. The sunroof was inspected and repaired by safelite. There was no warning that the sunroof was going to explode. The vehicle maintenance is at the highest level.

Excessive whining noise, shift flare. The vehicle is only a couple of years old. I was told by the dealer that the transmission will likely need to be replaced. There are numerous complaints within the Toyota Nation forums. It was recommended that we report the incidents here, as having a large number of cars on the road with failing transmissions can certainly be considered a road hazard/safety issue.

The start/stop operating system failed. When the engine cut off while waiting for train to pass, the engine went to turn over and completely stopped the vehile. Although the car would not start, I was unable to cut the car off completely. It would say ignition on. The lights in vehicle were on. Running the ac caused the car to say high power consumption but there was no way to cut vehicle off without removing the battery to reset the vehicle. Caused the car to malfunction while sitting at a complete stop. Also cause the parking break to engage and I was unable to disengage parking break. A message came across saying parking break unavailable. My safety and others were put at risk because had it happened at any other time a crash would have been caused. It caused a roadway to be blocked off which caused confusion and near accidents.

I noticed in March of 2024 that the lower part of my bumper was starting to detach. So I brought my car in to get inspected while I was getting my car serviced. Their was a recall issues in 2023. When the dealership looked at my car they said their was no remedy for the recall that I would have to wait until their is one. They said they can not fix the car even though the lower bumper was already starting to detached. Now July 27, 2024. While driving the bumper fully detached and now I’m dragging the bumper underneath my car. Had to take it to a mechanic to get it removed and then saw my dealership to get it fixed because of the recall. Now My bumper got fully detached and I suffered because of this Recall problem. Dealership said they can’t fix the problem that it was because of a collision that happened from a previous owner of the car that got into a collision in 2021. Where I bought the car in 2023 where the bumper was not detached and now I’m suffering because the dealership said Toyota corporate won’t fix the car under the recall. Now I’m stuck with fixing a bumper where I never got into an accident and could of been injured because of this bumper falling while drive and I have to pay out of pocket to fix it.

Transmission is failing. Making whiny noise on acceleration.

The electric park brake makes a loud screaming sound during engaging cycle as I put the gear in park. The sound gets worse during warmer weather. I visited the dealer twice for the same problem and reported it to Toyota. During my visit another highlander came into dealership. It made the same sound when the driver placed it in Park. According to the dealer, this sound is normal. I say it’s not. I have way cheaper cars with Electric park and they don’t make this sound. If the park brake unit fails it’s going to be real costly to repair and may fail while driving and gets engaged.

Vista Toyota in Casper WY refused to preform the repair for recall 23V720 due to a scratch on the bumper. I contacted Toyota corporate they did not respond.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Toyota Highlander. The contact stated that while driving at various speeds, there was a whining sound coming from the transmission while accelerating. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 54,000.

This is my new car certified

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

THE ENGINE COVER ASSEMBLY DETACHED FROM THE BOTTOM OF MY CAR WHILE DRIVING. SIMILAR TO THE EXISTING RECALL FOR THE FRONT LOWER BUMPER COVER ASSEMBLY. While pulling out of a parking lot, I noticed that there was a scraping noise under my car. Prior to parking at Jones Beach State Park, I was traveling on Ocean Parkway at a high rate of speed (50-60MPH) and it was a very windy day. I did not hit any obstructions or scrape the bottom of my car on anything. There was nowhere for me to pull over and as I sped up, the noise went away. When I got off the highway, the noise returned. When I got home, I looked under my car and there was a plastic piece dragging just in front of my front tires. I remembered I had received a notice about a Toyota recall related to the lower front bumper cover assembly and looked that up - it felt very similar to what I had experienced. When I got to the dealer, they told me it was not subject to the recall and the repairs on this would be $200 diagnostic plus $529.88 parts and labor. I was told I must have hit something to make it detach. I did not hit or scrape anything. My car has pretty good clearance, it would have had to be HUGE for me to hit or scrape it. I would have known.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Undershield came loose and was dragging on the ground

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available. I am VERY concerned that Toyota hasn’t taken this more seriously. I notice in the NTSB website it has injuries and fatalities listed to the left of the complains. Does someone have to be injured or killed before Toyota gets their act together??? Thinking we may need to trade this for another SAFER, RELIABLE vehicle. I have also had many people flash me due to the headlights being too high and in their face-another SAFETY concern.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

When decelerating from a speed of approximately 25 mph on a downward slope of about 5 degrees, and applying the brakes, a number of things occur: 1) There is a 1-2 second delay in the braking action. 2) When applied the braking action is less than expected for certain brake pedal pressure, which causes the driver to increase the brake pedal pressure 3) When the brake pedal is initially depressed, the speed of the vehicle experiences a slight upward speed bump before the braking action is applied, which is 'light' as described in 2). This behavior is transient. Most of the time, it does not happen. It happens often enough to be of concern.

When braking, there is a momentary period where it feels like the brakes fail, then function again. When approaching stopped traffic, this could put those vehicle occupants, and our vehicle occupants at risk of an accident. Toyota maintains this is normal for a hybrid, however our 2013 Camry Hybrid has no such momentary brake failure. Our independent repair shop has been unable to replicate this condition , but they have found no obvious problems with the braking system - they believe it is something computer caused, likely when the hybrid generation brake switches to the hydraulic brake. There are no warning lights displayed. This has been a long standing issue.

The vehicle hesitates during right turns, creating a hazardous, potentially dangerous, situation. From research I understand this is a known issue when transitioning between battery and gasoline propulsion. Research indicates this is a known situation, Toyota T-SB-0059-23. However, the TSB expires at the termination of the vehicle 3 years/36 months warranty. As a safety issue, in my opinion this problem should be addressed, regardless of vehicle age or mileage.

The sun roof on this car spontaneously combusted. I was able to pull up many other complaints regarding the same issue on this car. This needs to be recalled. My [XXX] baby could have had shattered glass had we not had it closed. These sun roofs need to be recalled and inspected! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While accelerating onto the freeway the vehicle suddenly loses power creating a serious safety issue. A check-engine light comes on but the safefy issue is that the vehicle goes into a power loss mode ON THE FREEWAY. A truck nearly rear-ended me the first time it happened. Toyota Service was unable to duplicate and so said National Toyota advised them to release the vehicle back to me. The same issue happened to my boyfriend and his son - total loss of power while accelerating onto the freeway. Then a mechanic recreated the issue 5 additional times (usually in the dawn hours when traffic was light due to safety concerns). Was unable to find the cause of the issue but a loss of power in a vehicle is as serious a concern as an unwanted acceleration. I am frustrated that Toyota is not taking this seriously.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

I had been driving for about 20 minutes at approximately 50-55 MPH when the check engine light came on. Seconds later, the red hybrid malfunction message displayed and I lost the ability to accelerate. I was able to pull over and I saw grayish smoke and flames coming from under the hood on the right side. I exited the vehicle and called 911. It took moments from the start to being completely engulfed in flames. Several loud pops or explosions happened during this period. The police and fire department arrived and extinguished it.

We were driving across the Texas panhandle at the posted speed limit of 75 mph. It was about noon, the outside temperature was about 60 fahrenheit & there was a cross wind of about 30 mph. There were no vehicles in front of me & the closest approaching vehicle was a good half mile away. No vehicles had recently driven past us from the approaching lane. There was a sudden explosion above us & through the 1-2" gap in the motorized retractable sunshade of our moonroof, I could see broken glass. Through that gap, some glass fragments fell in on us. I pulled over to stop, got out & inspected the roof, & the front glass panel was completely shattered & 75% gone. Many of the fragments were on the sunshade & I removed those. Going at about 40 mph we went to the closest small town where a mechanic removed some residual loose glass, vacuumed as much off the shade as he could, & patched the hole with cardboard held in place by duct tape so we could get home for a repair. If the shade had not been almost closed, we would have been showered with glass with risk of bodily & eye injury.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure) and 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

I have noticed that my vehicle tends to jolt forward as I’m applying the brakes to come to a complete stop.

Light impact caused bumper to disconnect from my 2021 highlander. The bumper retainer clips came off. The lower valence clips are stuck and cannot be detached without damaging the lower valence.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Numbers: 23V720000 (Structure) and 23V865000 (Air Bags) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the lower end of the front bumper had become loosened, and the contact was concerned that the lower part of the bumper might detach. The failure mileage was approximately 55,000. VIN tool confirms parts not available.