2021 Toyota Highlander complaints

Whine noise when vehicle is in motion and accelerating. Took it to the dealer for inspection, and advise to replace the transmission

Transmission makes whine noise upon accelerating. Cannot be fixed except with new transmission. The longer you drive, the longer it affects and damages other parts. Mechanic was amazed that my relatively new Toyota needed over $10k in repairs. Toyota denying there’s a problem.

Yesterday, as I do a couple times a month, I went to switch parking places, putting my 2021 Toyota Highlander where my 2007 Mazda was parked, in order to drive it and keep the battery from dying. After starting both cars I first moved the Mazda to make room for the Toyota. As I was slowly steering the Toyota at (idle speed) into the now vacant parking spot, the car accelerated on it's own, prompting me to hit the brakes, but to no avail. The car jumped the curb hitting, knocking over and and damaging a large ceramic planter and small tree in my neighbor's yard. My split second reaction upon having no brakes and a run away car was to push it out of drive, which ended up putting the car into reverse, causing a harsh jolt, followed by the car accelerating again on it's own, in reverse towards another neighbor's garage. I live in a condo complex, so all of this took place within about 30 feet of forward/backward/forward motion. My second split second decision (with no brakes) to avoid smashing into the garage was throwing it back into drive, which sent it accelerating back towards the parking place again. This time I had the presence of mind to push the power button on the dash, allowing me to barely come to stop before jumping the curb again. Whole thing lasted about 15 seconds. I had an appointment to attend, so after a brief conversation explaining to my (now outside) neighbor what happened, I left in the older car. Returning later in the day I found damage to the front of my

My 2021 Toyota Highlander Hybrid has a braking issue identified in Toyota Service Bulletin T-SB-0059-23, Hybrid Regenerative Brake Transition Feeling Improvement. When going downhill and applying the brake, the vehicle lurches forward temporarily as the braking system transitions from regenerative to hydraulic braking. The first time my vehicle did this, it was very alarming and I had to take additional measures to slow my vehicle as I was driving downhill. My vehicle frequently demonstrates this problem, however, I did not report it to my local Toyota dealer because I read in an online chat group that it was a characteristic of this vehicle. Although the TSB recommends a Reprogram of the Brake Actuator Assembly Control Module, the repair is only covered under the Toyota Basic Warranty which is in effect for 36 months or 36k miles, whichever occurs first. My vehicle is past the warranty limit, and because I did not report it to my dealer previously, this repair is not covered under the TSB or the Toyota Basic Warranty. Toyota Highlander Hybrid model years 2020-2022 are affected. The Technical Service Bulletin was issued August 29, 2023, so if a 2020 model Highlander Hybrid has this problem, 2020 models would have already passed the warranty limit by the time the TSB was issued and thus would not be covered. This is a safety risk as drivers can lose control of the vehicle when braking, particularly when going downhill. The Warranty should be extended, or this problem should be

The transmission is making a whining noise when accelerating. I took the vehicle to a Toyota dealership and they said the transmission needs to be replaced. And I asked why the Highlander only has 58 thousand miles on it. How is it already going out. And they couldn’t give me an answer

The transmission has a whining, grinding noise and occasional jerks vehicle. I had dealership look at the vehicle and they said it's a problem with this model but Toyota has not done a recall they issued a service bulletin. I was told it needs replacement but Toyota has been reluctant to work with owners outside of the service manufacturers warranty. This proved true, I was denied any goodwill assistance, and after several days of requesting why they denied any assistance, I'm not able to get an answer. This is a safety issue that they are aware of and not taking proper acceptance and assistance in rectifying. We carry our new born and toddler grandchildren in this vehicle as well as elderly parents. The thought of a total transmission failure on a busy highway or street is terrifying, I asked the dealership service manager about the safety of driving the vehicle and he recommended not operating it until it's replaced. In my[XXX] I haven't asked the government for anything, but I am asking you to look into this matter and if called for mandate a recall.. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My transmission started whining at 63,000 miles and my mechanic said it needs to be replaced. However, there is a nationwide backorder on Toyota transmissions. That should be a sign to NHTSA that this is a widespread issue and needs a recall! Of course this was right after the 60,000 mile Toyota warranty. I have extended warranty but it doesn't cover consultations or taxes.

I have a 2021 Toyota highlander platinum. The car makes whining noise when accelerating my car has 70k miles and according to Toyota my warranty expired at 60k miles it’s a common issue with these cars and Toyota knows that but they won’t help with the fix. This affected a lot of people and they want almost 11k for a trans replacement. If it’s a common issue with all their cars then they should take full responsibility and fix the cars. I hope you guys could be of help and hold they accountable.

Transmission failure

My 2021 Toyota Highlander, purchased with 16k miles, has a leak in the AC system in the rear of the vehicle (as of May 2025, at 3 years 10 months into the vehicle's service, with 28k miles). This pipe runs the length of the car and costs $2000-$3000 to repair. This was confirmed at an independent service center that used leak detection dye to identify the problem. I am finding multiple reports of people having this problem in young Toyota vehicles (<4 years old) and with low miles. I believe this is a design flaw and not indicative of normal corrosion, as the vehicle does not exhibit corrosion elsewhere in the under carriage.

Premature AC refrigerant leak and failure in system in the 2021 Toyota Highlander due to corroded/defective rear AC lines located near the exhaust/spare tire, observed at very low mileage and upon official inspection at the nearest Toyota dealership. Noticed early in ownership and decided to have the vehicle scanned when air being released only continued to grow warmer in the sweltering summer months. Reporting due to advice from friends and owners in my exact situation with the very same issue as well as the pricey three-thousand dollars and upwards quote to have this work done from Curry Toyota, 3026 E Main St, Cortlandt, NY 10567. Vehicle purchased new to avoid these very issues.

This is a supplemental complaint to add more detail to a prior submission. I am the original owner of a 2021 Toyota Highlander with 10,000 miles at the time of the issue worsening to the point that I finally broke down and was forced to pay the Toyota dealership's hefty diagnostic fee. The air conditioning system has failed due to a refrigerant leak in the rear A/C lines, specifically near the exhaust area under the vehicle. The dealership diagnosed the issue and quoted me over $3,000 to replace “all necessary components in the rear.” They offered no coverage or goodwill repair despite the vehicle’s age and mileage. Upon researching the issue for longer than a year at this point, I discovered far too many similar complaints from other Highlander owners (years 2019–2021) describing identical failures — typically rear A/C lines corroding, cracking, or leaking prematurely. In some cases, customers were told Toyota is aware of the issue but not issuing a TSB or recall. In other cases, dealers said no permanent fix exists. These repairs are prohibitively expensive and, in some reports, recurring due to poor line placement or dissimilar metal corrosion near heat sources. This significantly impacts safety in several ways: Impaired Visibility: The AC system is integral to effective defogging and defrosting of the windshield, especially in humid or cold conditions. Without it, visibility is severely compromised, increasing the risk of an accident. Driver Impairment: In extreme tempera

I am seeing a transmission slip and also engine whining noise. There is a widely known issue with this transmission failing. My serial number A3A20M01780 falls right outside the scope of the TSB issued by Toyota for these transmissions.

My transmission is failing in my 2021 Toyota Highlander. Has started making the high pitched whining noise. Fix is to replace the whole transmission. Dealer has confirmed and does have the transmission on order.

Transmission failure at 62000 miles. Toyota issued a service bulletin in Feb 2021. I bought the vehicle new in August 2021 and was not told of service issue. Also, I took vehicle to Toyota dealership for service every 5000 miles up to 55000. I was never told about service bulletin nor advised there could be a full imminent failure of the transmission.

My 2021 with 73000 miles is now at a dealershop 700 miles away from home. I didn't drive far while away but a week into my vacation, i started hearing a whining sound upon accelerating. Sound seemed to get louder on second day of hearing the sound. Took it to a dealership in the Leesburg Virginia area....they charged me 203.00 for diagnostics and indicated need new transmission for near $11,000. Each time I went to my dealership in my area for an oil change, they indicated that I needed a transmission fluid change. I read that when Toyota installed a "Sealed Transmission System" these changes would not be needed or at least limited.... Because the so call system is sealed, only dealership techs can check your fluid levels. How do you know if, when they check it, do they replace what they took out and if they do this regularly and don't refill what they took out, your fluid would eventually be pretty low...there is no way to check because "Sealed Transmission System" is only check by the dealerships (no transmission fluid dip stick on 2021 highlanders (and 2022, 2024, 2025). So you can't check it like an oil dip stick. We're [XXX].....INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Routine maintenance was done 5000 miles ago. Routine maintenance. At 50,151 miles and routine 50,000 mile maintenance a whistling/whining sound was noted. I was told a new transmission is needed. PLEASE MAKE THIS A RECALL. PLEASE MAKE TOYOTA STOP CHANGING OUT TRANSMISSIONS AT 50,000 miles on the regular. There is a known TSB, but so many VIN's are outside of this range experiencing the exact same issue that it is inconceivable that Toyota doesn't know they have a problem. Having a warranty that covers it is a band-aid. The wear and tear on the overall engine and parts due to transmission failure means they are knowingly selling cars that will fail. Why isn't it told to every buyer to expect transmission failure at 30-50,000 miles at the time of purchase? TELL US AND THEN LET US DECIDE IF THAT IS HOW WE WANT TO INVEST OUR MONEY IN OUR CARS. My first Toyota and my last. AND what is worse, the NHTSA KNOWS about all these incidents and just lets it ride. We have lost the consumer in the values we hold as a country. Insurance doesn't mean insurance. Transmissions are only worth 30-50,000 miles when it should be 200,000+ by now. Quality standards are there for a reason. Having a powertrain warranty that protects the manufacturing IS NOT how it was intended. FORCE TOYOTA TO FIX THIS ISSUE. STOP SELLING CARS WITH FLAWED TRANSMISSIONS. I feel taken advantage of and am stuck with a car I no longer want, (because as the service advisor said, "if it happens again, you will still be cover

A whirring and grinding sound from transmission when put into gear. Intermittent sluggish when accelerating.

Transmission whine

When accelerating there is a whining noise coming from the front of the vehicle. There was no warning lamp that came on just the noise is what prompted me to take it to Toyota of Hattiesburg to be diagnosed. The transmission is what malfunctioned. Yes Toyota confirmed the problem and said my transmission needs to be replaced. I am very disappointed because Toyota’s has the reputation to last forever. As this is my 3rd Toyota and I have been very happy until now because Toyota is not taken responsibility for this problem that is continuing to arise in the transmissions. I have attached the paperwork showing what Toyota said.

My 21 Highlander has a wine noise coming from the transmission. There is currently a bulletin out by Toyota T-SB-000821 confirming that the transmission in this model needs to be replaced. I took my car to two separate mechanics who confirmed the noise is coming from transmission. I called Toyota this morning. Spoke with a lady and she told me she cannot locate the bulletin on my VIN number so pretty much there’s nothing they can do to help. I’m having the issue with my car that Toyota is aware about and has put out a bulletin regarding the issue. I think Toyota needs to take care of this. This is not something that should be VIN specific if I’m having the issue then fix it! At least send me to a Toyota dealership for you guys to confirm the issue and fix it!

2021 Highlander has 103000 miles. Transmission started a whine that only presents under acceleration. It follows the speed of the car, not the engine speed and is getting louder. My [XXX] granddaughter asked today what is that loud whining noise. It was diagnosed by my mechanic as another bad Toyota transmission. They stated it could stop working at the most inoperative time. Could cause death. I have to wait for more than 2 months to hopefully get a new transmission. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am filing this complaint due to a severe transmission failure in my 2021 Toyota Highlander XSE, which I believe poses a significant safety hazard. At approximately 70,000 miles, the vehicle’s 8-speed automatic transmission failed. Prior to this failure, I reported a persistent gear noise (described as a whining or grinding sound during acceleration and gear shifts) to my Toyota dealership [Shore Toyota] when the car had less than 60,000 while the vehicle was under the 5-year/60,000-mile powertrain warranty. The dealership dismissed the noise as “normal” and did not perform diagnostics or repairs, despite my concerns. The gear noise worsened over time, leading to more frequent noise and shifting, jerking, issue failure in May 2025. The noise occurres while driving from 0 to at 35mph. I later learned that the 2021 Toyota Highlander’s 8-speed transmission (UA80E/UA80F) has known issues, as documented in Toyota Technical Service Bulletin (TSB) T-SB-0008-21 (issued February 2021). The TSB describes a whining noise identical to what I reported, requiring a full transmission replacement for affected vehicles. Numerous other owners have reported similar failures, with some experiencing delays of 3–6 months for replacement parts due to backorders. My vehicle’s symptoms match the TSB, and the dealership’s failure to address the noise during the warranty period likely allowed the defect to progress to catastrophic failure.

The transmission started making a whirring and grinding noise so I took it into the mechanic who notified me that Toyota put out a TSB on this issue in February 2021. I leased this vehicle in April 2021 and it was never disclosed to me that I would experience a transmission issue down the line. At the end of my lease, I purchased the vehicle and again it was never disclosed to me of this issue. I immediately took the car into the Toyota dealership where they heard the noise and confirmed it is the transmission defect that Toyota previously identified. I am ordered to bring my four minor children from Las Vegas to Los Angeles minimum once a month and my fear is getting stuck on the 15 freeway at 75 miles an hour in the heat of summer. This is a huge safety issue and this matter should have been a recall. I understand from the Toyota service manager that Toyota did not redesign the transmission so even if I get a new transmission it will experience this issue again. At $11,000 for a new transmission or $4500 for the extended warranty, it isn't right that the consumer is on the hook for a defect Toyota knew about and didn't disclose. This is auto fraud and negligent. A car is a hefty investment and Toyota took advantage of the public. They should be held accountable.

Transmission failure at approximately 80,000 miles dealer has confirmed diagnosis and recommended replacement on-line forums indicate this is a recurring problem with this model engine noises began at approximately 78,000 miles

There is a known flaw with this car that the transmissions fail prematurely. There is a technical service bulletin (TSB0008-21) released 2 months before purchasing the car on this exact issue and we were not made aware before purchase. Toyota has not recalled these vehicles and this applies to a very select serial number range of transmissions implying a manufacturer defect even further. Now my car, with 68k miles, is expected to have a transmission replaced at full cost. There are many forums discussing this issue and I hope that more people come forward because this is clearly a defect in the design that Toyota should be responsible in fixing.

Roof rails leak and allow water to enter the head liner and the air bags in the support arms of the cabin. Toyota has a Toyota Service Bulletin related to this but they and their dealers will not fix this. It would seem to be an issue if the air bags do not function as intended due to Toyota ignoring a manufacturing defect on their vehicles.

Transmission was making a wine noise. Little grind but winey noise. Went away. Came back few min later at shifting and went away thank went home

Around 76k miles, a whining occurs upon accelerating. Hear ever so slightly in 1st gear. Gradually is more evident as the speed increases. At 78k I decided it was definitely getting louder and was concerned after researching and learning that MULTIPLE 2021 Highlanders have needed transmissions replaced. I brought it in to a mechanic who searched for every possible problem, but ultimately came back to tell me it is my transmission failing.

Engine/Transmission 'whining' noise upon acceleration. We cannot drive it, three places said we shouldn't - it will only get worse, and eventually fail. No one knows when. My wife was driving on interstate when it firsts occurred, she couldn't get to the side fast enough. My wife feels unsafe driving it alone and with our young son. We are receiving very high quotes - despite the fact that they don't seem to be doing any real diagnostics. It seems to be a well known problem that only Toyota can address, as their design seems to have caused this dangerous problem and their supply chain issues seem to be common knowledge to many in the industry. Toyota service tells us at least a two month wait for a new transmission to arrive. Then three of four days to install. My wife feels very unsafe driving this vehicle knowing it could just stop operation at any time.

While driving the vehicle will wobble, shake and make grinding noises at lower speeds and at higher speeds.

The transmission has a whining noise caused by the front carrier pinion shafts. There is a TSB out for the transmission issue. Transmission has been inspected by a technician. No warnings - the noise was a warning I suppose. It first appeared in March 2025.

The transmission started to make a higher pitch sound when accelerating. We brought the vehicle in for evaluation @ 70,500 miles. We were advised the vehicle needed a new transmission for $ 9,900.00 Not even 4 years old, and Toyota Warrantee department said past the 60K drive train warranty so no support from them.

P 235 / 55 R 20 The sidewall blew out on the highway. I did not hit any road hazards and the tires were properly inflated. I have the tire now but Continental has requested I ship it to them.

P 235 / 55 R 20 This tire has developed a sidewall bulge. It has always been properly inflated. I currently have the tire but the manufacturer has requested that I send it to them.

MY TRUNK WILL NOT OPEN OR CLOSE PROPERLY FAULTY SENSORS

My SUV is having issues with the tires air and also the sensors are not working properly

Was driving and all of a sudden ‘steering power low’ came on and engine died, got stuck in a busy intersection and needed assistance from police officer until I could be towed. Steering did not work to push car to side of the road so I was stuck in the center of the traffic. There was absolutely no lights or warnings before the steering power low and it died. Could have been very dangerous, I am supposed to drive north through the mountains to go camping in 2 days, lucky it didn’t happen then. At the mechanic now and they jumped the battery and say it’s working fine and they can’t find the problem.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and a case was filed. The contact had not experienced a failure. VIN tool confirms parts not available.

There is a TSB about the transmission whine between certain serial numbers. My transmission was outside of the range but started whining. I took it to the Toyota dealership and they advised me that the transmission needs to be replaced.

There is a whining noise that occurs when the car is accelerating. At times, there car will skip when accelerating. There is also a vibration. I was informed the issue is with the transmission. A bad transmission can make driving very difficult, potentially causing the vehicle to stall or become unresponsive, and can be a safety concern. I drive my child to school daily, over an hour from our home, and drive to homes to provide hospice care to terminally ill patients. This issue causes great concern, both financially and for safety.

Windshield side beveled trim driver’s side snapped and flew off on the highway into oncoming traffic and the passenger side is also loss and almost coming off.

The transmission is whining at medium speeds of 30-35 mph. The transmission started making the noise about 3 weeks ago. It appears that Toyota was aware of the potential defect in the transmission as Toyota issued a technical service bulletin (T-SB-008-21 and NHTSA # 10188917) on February 9, 2021. The TSB was sent to dealerships 17 days before we purchased the vehicle. Toyota took no steps to notify the owners or to prevent the sale of the vehicle with a know defective transmission. The TSB said the only cure to the defect was a transmission replacement. Toyota offered no extension for this drivetrain defect beyond the standard 60 month/60,000 mile warranty. Our vehicle is just outside of these parameters at 70k miles. The vehicle should not have been sold with know defects in the transmission and Toyota at the very least should offer to extend the standard warranty.

Transmission is producing a whining noise during acceleration. Very common with this model transmission.

I am reporting that the fix for NHTSA recall #23V-865, Toyota recall #23TA15 has not been done in a timely manner & I am concerned for the safety of my passengers. The recall info came out December 2023 & Toyota was supposed to have a fix 3rd quarter 2024. We are now in 2nd quarter 2025 & there is still no fix. This is unacceptable. Again, I am concerned for the safety of my passengers, one of which is my elderly mother-in-law who has difficulty getting in & out of the back seat.

TRANSMISSION, Jolts when backing up, and hesitates in traffic. The dealership confirmed it's the transmission. No warning lights, just running poorly with hesitation, afraid of breakdown. First appear a month ago after my warranty expired. I have a 2021 Highlander with 80,000 miles and still owe $22,992.84 on the vehicle. My warranty 60/60,000 is of is not any good. The issues is the transmission. The dealership is telling me it's not covered even though this is an issue with this model. For a another $11,000 they can install a new transmission. Toyota you are better then this, my Camry I had almost 300,000 on it. I had another highlander before this one. Very disappointed.

I purchased a new 2021 Toyota Highlander and began to experience a clicking noise coming from under the vehicle which grew in intensity. The vehicle has 76,000 miles. I regularly took the vehicle to a Toyota dealership for service where they never mentioned any needed service for the transmission. I informed the dealership of the clicking noise where I was told by a Service Technician that they have seen a large number of newer Toyota Highlanders experience transmission failures. I asked the Technician if a recall was issued and he simply shrugged his shoulders and walked away. This is a serious issue affecting a major component of a vehicle and safety, it is unconscionable that a major reputable manufacturer such as Toyota would be aware of a major defect and refuse to address the issue.

- transmission has a whine sound. - steering while start in to peel off after 25k miles driving

The transmission began to do a whining noise at 70K which is a signal of soon deterioration and failure. Toyota acknowledged the widespread issue but for only a very small portion in the T-SB-0008-21, though covered only under the standard 60K warranty. My car doesn't fall in the range of transmission mentioned in the TSB, though it is the same UA80 transmission model, and the symptoms and the problem is exactly the same as verified by the dealer. I have learned that many Highlander owners with UA80 transmissions are having the exact same issue around or right after the 60K miles.

The contact owns a 2021 Toyota Highlander. The contact stated that while operating the vehicle, the display screen malfunctioned and displayed a solid black screen. During the failure, several functions and features could not be accessed or activated, including the front and rear defrosters. The contact was unable to clear the front and rear windshields, which created a visibility hazard for the driver. The vehicle was taken to the local dealer, who diagnosed that the display screen unit needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 45,000.