2002 Toyota Highlander complaints

2002 TOYOTA HIGHLANDER SUN VISOR KEEPS FALLING DOWN ON ITS OWN. NOTICED THAT THIS IS A COMMON COMPLAINT ON THE INTERNET. THIS IS A SAFETY HAZARD AND THE VISOR SHOULD BE RECALLED. *TR

I NOTICED COOLANT LEAKING FROM UNDERNEATH THE PLASTIC INTO INTAKE MANIFOLD IN THE REAR OF THE ENGINE. I BROUGHT IT IN FOR REPAIR AND THE MECHANIC SAID HE NOTICED A LARGE PIECE OF FOAM RUBBER BETWEEN THE INTAKE MANIFOLD AND THE ENGINE BLOCK AND HEAD.THE LEAK WAS BEHIND THE FOAM PIECE. THE ONLY OPTION TO DISCOVER THE SOURCE OF THIS LEAK WAS TO REMOVE THE PLASTIC INTAKE MANIFOLD, WHICH THE MECHANIC DID. AFTER THIS WAS REMOVED, IT BECAME OBVIOUS THAT COOLANT HAD BEEN LEAKING A MINOR AMOUNT FOR QUITE SOME TIME DUE TO BUILD UP BETWEEN THE CYLINDER HEAD AND BLOCK. THE ONLY OPTION LEFT IS TO REMOVE THE HEAD, WHICH REQUIRES AN EXTENSIVE DISASSEMBLY (R AND R CYLINDER HEAD). AFTER LOOSENING THE BOLTS IN SEQUENCE, HE NOTICED THREE OF THE HEAD BOLTS IN THE BACK OF THE ENGINE WERE LOOSE. AFTER HE REMOVED THE HEAD SURE ENOUGH, ONE BOLT CAME OUT WITH ALUMINUM IN THE THREAD THUS INDICATING A STRIPPED BOLT. AND THE OTHER THREE WERE LOOSE. HE SAID THE ONLY OPTION WAS TO REPLACE THE ENGINE BLOCK, WHICH WILL COST ABOUT $6000 INCLUDING SHIPPING/LABOR. I CAN NOT AFFORD THIS AND SO HAD THE HIGHLANDER TOWED BACK TO MY HOME. *TR

FALLING VISOR ON TOYOTA HIGHLANDERS ARE CREATING DRIVER VISIBILITY ISSUES. A MAJOR CONCERN FOR SAFETY. SENT IN ATTACHMENT THAT LISTED OTHER DRIVER COMPLAINT ON THE SAME ISSUE TO DOT QUESTION 090817-000072. *TR

DRIVE SHAFT GOING BAD ON TOYOTA HIGHLANDER 2002. MAJOR PART LIKE THIS ALMOST NEVER FAILS. VERY EXPENSIVE TO FIX. *TR

1. REGULAR DRIVING CAUSES THE ISSUE WHICH SEEMS TO BE DUE TO POOR PRODUCT DESIGN. 2. THE DRIVER SIDE SUN VISOR DOES NOT STAY IN THE UPRIGHT POSITION EVER, AND CONTINUOUSLY BLOCKS MY CLEAR VIEW OF THE ROAD. 3. THE TOYOTA DEALER WAS INFORMED AND THEY DID NOTHING TO FIX THEIR INFERIOR PRODUCT. I HAVE TO PURCHASE A REPLACEMENT SUN VISOR. *TR

2002 TOYOTA HIGHLANDER HAS ISSUE WITH DRIVER'S SIDE SUNVISOR THAT CONSTANTLY FALLS OBSTRUCTING VISION. *TR

I AM FINANCING A 2002 TOYOTA HIGHLANDER. ON 6/25/09 WHILE DRIVING ON A MAJOR SERVICE ROAD, I HEARD A LARGE THUMP SOUND. I TRIED TO PULL OVER TO MAKE SURE THAT I DID NOT HIT ANYTHING OR BLOW A TIRE. ONCE THAT I SAW THAT EVERYTHING SEEMED OKAY, I PROCEEDED INTO MY VEHICLE AND PUT THE CAR INTO DRIVE WHEN I STEPPED ON THE GAS THE CAR JUST REVVED AND IT STAYED INTO POSITION, I KEPT CHANGING GEARS NOT KNOWING WHAT WAS WRONG AND AS I CHANGED INTO DRIVE AND STEPPED ON THE GAS, MY CAR QUICKLY SHIFTED AND ALMOST HIT THE CAR IN FRONT OF ME THEN IT STOPPED AGAIN. FORTUNATELY THERE WAS A AUTOMECHANIC SHOP ON THE CORNER, SOMEONE FROM THE SHOP CAME TO WHERE I WAS TO LOOK AT MY CAR. THE MECHANIC DID THE SAME AS I DID, SHIFT GEARS AND THE CAR WOULD JERK SPONTANEOUSLY BACK THEN FORTH BUT WOULD NOT DRIVE. THE MECHANICS PUSHED IT INTO THE GARAGE AND INSPECTED TO FIND THAT MY TRANSMISSION WA GONE AT 68,000 MILES. I HAVE MY CAR CHECKED OFTEN, FLUIDS REPLACED WHEN NEED BE. I DO NOT UNDERSTAND HOW A TRANSMISSION CAN JUST DIE AT 68,000 MILES. I CALLED TOYOTA BECAUSE I HAVE MY CAR SERVICED AT TOYOTA. AND BECAUSE MY EXTENDED WARRANTY WAS EXPIRED IN 2008 , THEY SAID THERE WAS NOTHING THEY CAN DO BUT PUT IN A NEW TRANSMISSION. I HAVE HAD THE CAR TOWED TO 3 LOCATIONS TO MAKE SURE I HAD SEVERAL OPINIONS AND THEY ALL SAID THE SAME THING THAT MY TRANSMISSION WAS BAD. MY CAR HAS BEEN AT RELIABLE TRANSMISSION FOR 2 WEEKS NOW, THEY ARE CURRENTLY REPLACING THE TRANSMISSION FOR 4,000.00. THE CAR WILL NOT BE PAID

1. PLASTIC TENSION COIL HOLDING UP VISOR FAILED ALL OF THE SUDDEN. 2. PLASTIC TENSION COIL HOLDING UP VISOR FAILED CAUSING THE VISOR TO FALL DOWN OBSTRUCTING MY VISION WHILE DRIVING. THIS OCCURS ANYTIME I HIT A BUMP IN THE ROAD WHILE DRIVING. 3. I WENT TO TOYOTA TO HAVE IT FIXED AND THEY TOLD ME IT WOULD COST A SIGNIFICANT AMOUNT OF MONEY SINCE THERE HADN'T BEEN ANY RECALL NOTICES INVOLVING THE DESCRIBED FAILURE. *TR

I HAVE A 2002 TOYOTA HIGHLANDER AND THE DRIVER'S SIDE VISOR WILL NOT STAY UP. THE VISOR CONSTANTLY FALLS IN MY LINE OF VISION. I'VE HAD THE PROBLEM OVER TWO YEARS. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. SINCE FEBRUARY OF 2007, THE SUN VISOR IN THE VEHICLE DOES NOT ATTACH TIGHTLY AND COMES DOWN WHILE DRIVING 35 MPH AND ABOVE. THE VEHICLE HAS NOT BEEN INSPECTED, BUT THE REPAIR WOULD COST OVER $300. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE AND THE DEFECT SHOULD BE REPAIRED BY THE MANUFACTURER. THE FAILURE MILEAGE WAS 95,000. UPDATED 07/01/09 *BF UPDATED 07/06/09. *JB

2002 TOYOTA HIGHLANDER DRIVERS SIDE VISOR WILL NOT STAY UP. MANY COMPLAINTS ABOUT THIS ISSUE. IF YOU HIT THE EVEN A SMALL BUMP THE VISOR FALLS DOWN WHICH IN TURN CREATES A VIEWING PROBLEM. ONE DAY THERE WILL BE AN ACCIDENT CAUSED BY THIS PROBLEM. *TR

2002 TOYOTA HIGHLANDER DRIVERS SIDE VISOR. WILL NOT STAY IN PLACE, NEVER REPORTED UNTIL I SAW HOW MANY PEOPLE HAVE SO HERE I GO. *TR

SUN VISOR PROBLEM ... MY DRIVER SIDE SUN VISOR WILL NOT STAY UP AND HAS BECOME AN HAZARD. I'VE ALSO NOTICE THE SAME THING STARTING TO HAPPEN TO MY PASSENGER SUN VISOR, A SEAT IN WHICH IS ALL MOST NEVER OCCUPIED! *TR

SUN VISOR ON DRIVER'S SIDE OF 2002 TOYOTA HIGHLANDER CAN'T BE USED TO PROTECT DRIVER FROM THE BRIGHT SUNLIGHT AS IT CANNOT BE RATCHETED UP OR ADJUSTED AND JUST HANGS LOOSELY BLOCKING DRIVER'S VIEW OF WINDOW AND REQUIRING DRIVER TO HOLD IT IN PLACE WITH ONE HAND. PROBLEM HAS EXISTED ALMOST FROM BEGINNING. OTHERS HAVE REPORTED SIMILAR PROBLEMS ESPECIALLY WITH THAT MODEL YEAR. *TR

MY 2002 TOYOTA HIGHLANDER'S CHECK ENGINE LIGHT SEEMS TO COME ON EVERY 10,000 MILES. THIS HAS BEEN HAPPENING SINCE 2004, AT ABOUT 43000 MILES, WHEN I FIRST TOOK IT TO A LOCAL DEALER MECHANIC. IT IS NOW 2009, 111000 MILES LATER, AND AGAIN THE CHECK ENGINE LIGHT COMES ON QUEUE. ORIGINALLY, THE DEALER MECHANICS TOLD ME THEY HAD CORRECTED IT PRIOR TO MY WARRANTY EXPIRING. WHEN MY WARRANTY EXPIRED, THEY TOLD ME THAT I NEEDED TO GET AN OVERHAUL ON MY CATALYTIC/EXHAUST SYSTEM, WHICH WAS QUOTED TO COST ABOUT $5000 TO FIX! I BELIEVE MY CAR WAS WORTH NO MORE THAN $7000 AT THE TIME. AN INDEPENDENT MECHANIC TOLD ME THAT THERE WAS NOTHING WRONG WITH MY CATALYTIC SYSTEM AND THAT THERE MAY BE A PROBLEM WITH THE DETECTION SYSTEM. I'VE BEEN SHOWN HOW TO RESET THE CHECK ENGINE LIGHT BY THE TOYOTA DEALER PERSONNEL, I SUSPECT, BECAUSE IT IS HAPPENING TO OTHER HIGHLANDER OWNERS. I AM BRINGING THIS ISSUE UP NOW BECAUSE IT SEEMS LIKE A RECALL SHOULD HAVE BEEN ISSUED YEARS AGO. I HOPE SOMEONE FROM TOYOTA WILL RECOGNIZE AND FIX THIS ISSUE. *TR

2002 TOYOTA HIGHLANDER LIMITED - THE DRIVER AND PASSENGER SIDE SUN VISORS WILL NOT STAY IN UPRIGHT POSITION. VERY DANGEROUS WHEN DRIVING. TOYOTA OFFERS NO SOLUTIONS BUT PURCHASING ANOTHER $600 VISOR. LOOKING ONLINE, I AM NOT THE ONLY ONE HAVING THIS PROBLEM. AT WHAT POINT DOES A MANUFACTURE BECOME RESPONSIBLE FOR WHAT IS OBVIOUSLY A DESIGN DEFECT AND SAFETY ISSUE. *TR

2002 HIGHLANDER LTD, 48K MILES, WELL MAINTAINED. ABS SYSTEM AWRY, ACTIVATING LEFT FRONT BRAKES AS BRAKES APPLIED, MOST SEVERE AS COMING TO STOP. NO CODE, NO REMEDY WITH REPLACEMENT OF REAR SENSOR. PRESENTLY DRIVING WITH ABS DISABLED, SERVICE PROVIDER SEEKING SOLUTION. *TR

2002 TOYOTA HIGHLAND FLIP VISOR KEEPS ON FALLING DOWN. AFTER RESEARCH FROM THE NET, APPARENTLY, THERE ARE MANY OTHERS THAT EXPERIENCE THIS ISSUES. THIS IS VERY DANGEROUS. IT WILL COSTS $700.00 TO REPLACE IT. I REALLY THINK THIS IS A DEFECT. *TR

FAILURE OF 55904-48210 HVAC CONTROLLER ON A 2002 TOYOTA HIGHLANDER. THE FAILURE OF THIS PART CAUSE THE HEATING AND COOLING CONTROL DIAL TO BECOME INOPERATIVE. THE VEHICLE COULD ONLY BLOW COLD AIR CAUSING MY WINDSHIELD TO FOG OVER. THIS RESULTED IN MY BEING UNABLE SAFELY OPERATE THE VEHICLE. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. WHEN THE CONTACT OPENED THE DOOR TO HER VEHICLE, SHE DISCOVERED THE PASSENGER COMPARTMENT FILLED WITH SMOKE. THE PASSENGER SEAT WAS BURNED. THERE WERE NO OCCUPANTS IN THE VEHICLE AT THE TIME OF THE FAILURE. THE POLICE AND FIRE DEPARTMENTS ARRIVED AT THE SCENE AND EXTINGUISHED THE FIRE. THE INVESTIGATOR INFORMED HER THAT THERE WAS AN ELECTRICAL FIRE UNDERNEATH THE PASSENGER SEAT. THE CONTACT STATED THAT THE SEAT WAS A MANUAL SEAT, NOT ELECTRIC. THE VEHICLE WAS DESTROYED. A POLICE AND FIRE REPORT WAS FILED. THE FAILURE MILEAGE WAS 97,000. UPDATED 1/6/09 *CN UPDATED 01/14/09. *JB

THE INTERIOR HEATING/AC SYSTEM AND FAN REPEATEDLY FAILS TO OPERATE PROPERLY. IN THE SPRING SUMMER WHEN THE AC WOULD FAIL TO BLOW COLD AND BLOW HEAT THAT WASN'T SO BAD. I GOT THE CONTROL KNOB FIXED AND ALL SEEMED TO WORK FINE. HOWEVER THE KNOB HAS FAILED AGAIN AND WHEN I NEEDED THE HEAT/DEFROST FAN TO WORK AT NIGHT THE FROST GOT WORSE BECAUSE THE KNOB FAILED AND THE HEATER/FAN WOULD ONLY BLOW COLD AIR. DEPENDING ON THE SEASON AND THE POSITION OF THE KNOB WHEN IT FAILS THIS SHOULD BE CONSTRUED AS A SAFETY ISSUE WHEN IT AFFECTS THE VISUAL CLARITY OF THE WINDSHIELD . *TR

2002 TOYOTA HIGHLANDER DRIVER SIDE SUN VISOR FALLS DOWN WHILE DRIVING CAUSING A POSSIBLE HAZARD. *TR

ACCELERATOR DOES NOT RESPOND WHEN PUSHED,THE FAILURE OCCURS REGULARLY WHEN PASSING VEHICLE WONT ACCELERATE,THE DEALER ACKNOWLEDGE THIS IS A PROBLEM WITH THESE VEHICLES THAN CAN BE REPAIRED FOR $1200. *TR

2002 TOYOTA HIGHLANDER - BOTH DRIVER AND PASSENGER SUNVISORS DO NOT STAY UP. WHEN PLACED IN THE UPRIGHT POSITION, THE SUNVISORS RELEASE OVER ANY SMALL BUMP IN THE ROAD. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH OR LESS, THE SUN VISOR WOULD AUTOMATICALLY RELEASE AT ANY GIVEN TIME. THE FAILURE MADE VISIBILITY DIFFICULT AND OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE SUN VISOR NEEDED TO BE REPLACED AT THE COST OF $700. THE CONTACT DETACHED THE SUN VISOR FROM THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 42,000. UPDATED 09/10/08 *BF UPDATED 09/11/08.*JB

SAFETY ISSUE WITH TOYOTA HIGHLANDER (02 MODEL)...SUN VISOR ON DRIVERS SIDE KEEPS FALLING DOWN AND OBSTRUCTING VIEW. *TR

I PURCHASED A USED 2002 TOYOTA HIGHLANDER 3 YEARS AGO, LAST YEAR, THE VISOR ON THE DRIVERS SIDE STARTED FLIPPING DOWN (WILL NOT STAY UP). I HAVE BEEN QUOTED APPROX $700 TO REPLACE THE VISOR WHICH SEEMS EXCESSIVE ESPECIALLY SINCE IT IS NOT EVEN LIGHTED. *TR

2002 TOYOTA HIGHLANDER. SUN VISOR WITH HOMELINK KEEPS FALLING DOWN WITH HITTING MINOR BUMPS. SAFETY HAZARD, AS VISION IS BLOCKED AND CAN LEAD TO ACCIDENTS. *TR

2002 TOYOTA HIGHLANDER. BOTH SUNVISORS FAULTY. HIT A BUMP AND THEY WILL FALL DOWN IN FRONT OF VISION. CRASH HAZARD IN CERTAIN DRIVING SITUATIONS, ESPECIALLY DRIVING UPHILL OR TRYING TO LOOK AT A TRAFFIC LIGHT. THEY SUDDENLY FALL AND OBSCURE UPWARD VISION. *TR

2002 TOYOTA HIGHLANDER DRIVER SIDE SUN VISOR WILL RANDOMLY FALL DOWN, COMPLETELY BLOCKING THE VIEW OF THE ROAD AHEAD. ON A BUSY HIGHWAY, IF THIS FALLS AT THE WRONG MOMENT, IT CAN RESULT IN A SEVERE MULTI-CAR ACCIDENT. *TR

A/C BLOWS HOT AIR ON DRIVER SIDE WHEN IT SHOULD BLOW COLD AIR AS IT DOES WITH PASSENGER SIDE. *TR

THE DRIVER SIDE SUN VISOR (W/ LIGHTED MIRROR AND HOMELINK) ON MY 2002 TOYOTA HIGHLANDER WILL NOT STAY UP AND DROPS DOWN WHEN DRIVING WHICH IS A SERIOUS HAZARD. I UNDERSTAND THAT THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE AND THE COST FOR ONLY THE REPLACEMENT PART IS OVER $700.00. IT IS OBVIOUSLY A DESIGN ISSUE AND SERIOUS HAZARD THAT TOYOTA WILL NOT ADDRESS. *TR

2004, MY HIGHLANDER WAS SERVICED FOR GEL IN THE VALVE SEALS. ON APRIL 2, MY CAR WAS BROUGHT TO LEITH TOYOTA BECAUSE THE CAR MADE A LOUD NOISE AFTER BEING CRANKED AND THE OIL LIGHT WAS ON. AS I DROVE A COUPLE OF MILES, ALL COMPUTER LIGHTS CAME ON AND THE CAR CUT OFF. I WAS TOLD TESTING WAS DONE AND I HAD OIL ALTHOUGH IT WAS NOT BEING PUMPED TO THE ENGINE FOR SOME REASON. (I HAVE OIL CHANGED EVERY 3,000 MILES). THE NEXT DAY, I WENT TO CHECK ON THE PROGRESS AND THE SERVICE MANAGER TOLD ME THEY DROVE THE CAR AROUND AND IT NEVER CUT OFF AND HE REALLY DID NOT KNOW WHAT WAS WRONG WITH IT. I DECIDED TO TAKE IT TO ANOTHER MECHANIC TO FIND OUT AND 10 MILES AWAY, THE ENGINE BLEW UP. NOW, I HAVE NO CAR TO DRIVE AND I AM A SINGLE MOM THAT HAS TO WORK. I FEEL THAT THE SERVICE MANAGER SHOULD HAVE BEEN HONEST WITH ME REGARDING TOYOTA'S PAST ENGINE DEFECTS AND TO DRIVE MY CAR WOULD BE FATAL. AFTER HAVING IT TOWED TO ANOTHER TOYOTA DEALERSHIP TO CHECK FOR OIL SLUDGE AND REQUESTING THAT MY MECHANIC BE PRESENT WHEN DROPPING THE OIL PAN, THEY TOLD ME THAT WAS NOT NECESSARY AND DID IT WITHOUT CALLING ME FIRST. I HAVE LOST ALL FUTURE TRUST WITH THIS COMPANY AND FELL THAT THEIR"HUSH HUSH RECALL" SHOULD HAVE BEEN MADE PUBLIC. *TR

I HAVE A 2002 TOYOTA HIGHLANDER. THE SUN VISORS ON THE DRIVER AND PASSENGER SIDES NO LONGER STAY UP. THIS STARTED NINE MONTHS AGO. IF THE SUN VISOR DOES STAY UP, IT DROPS DOWN WHEN THE VEHICLE HITS A MILD BUMP. *TR

2002 TOYOTA HIGHLANDER DRIVERS SIDE SUN VISOR FELL DOWN WHEN HITTING A SMALL POTHOLE, OBSCURING DRIVER VISION...NARROWLY AVERTING A COLLISION WITH ONCOMING VEHICLE BEFORE I COULD GET IT PUSHED BACK UP INTO PLACE, WHEREUPON IT FELL AGAIN AND I HAD TO SWING IT OUT OF THE WAY TO DRIVE HOME...NO FRICTION TO HOLD IT UP OUT OF THE WAY....CALLED DEALERSHIP...SORRY...600 DOLLAR REPLACEMENT W/ HOMELINK..NO OTHER FIX AVAILABLE...DEFINITE DESIGN, ABSOLUTE SAFETY FLAW...WENT ONLINE TO RESEARCH AND NOTED THOUSANDS OF RESPONSES TO THIS EXACT PROBLEM FOR 2002 VEHICLE. I TRULY BELIEVE A RECALL IS WARRANTED. *TR

AC/HEAT TEMPERATURE CONTROL SWITCH MALFUNCTION. THIS IS A PROBLEM THAT TOYOTA IS AWARE OF AND CHOOSES TO DISREGARD, SINCE IT TENDS TO FAIL AFTER THE WARRANTY ON THE NEW PART AND REPLACEMENT PARTS EXPIRES BEFORE THE PROBLEM. A SMALL, SOLDERED WIRE WHICH CONNECTS THE SWITCH TO A CIRCUIT BOARD IN THE DASH FAILS. SHOULD BE AN EASY FIX, BUT TOYOTA DEALERS WILL ONLY REPLACE THE ENTIRE PANEL FOR $800 - 1200. THIS HAS HAPPENED TWICE TO ME ON THIS SAME VEHICLE. FIRST TIME I PAID $800, THE SECOND TIME I GOT A LOCAL GUY TO SOLDER THE WIRE ON THE OLD PART AND REPLACED MYSELF. TOTAL COST ABOUT $10. SHAME ON TOYOTA. *TR

2002 TOYOTA HIGHLANDER DRIVER'S SIDE VISOR FALLS DOWN AND BLOCKS THE VISION OF THE DRIVER. TOYOTA'S SOLUTION TO THIS PROBLEM IS TO REPLACE THE VISOR AT A COST OF $600 PLUS LABOR. THERE HAVE BEEN MANY REPORTS OF THIS PROBLEM ACCORDING TO THE TOYOTA DEALER, YET TOYOTA HAS NOT ISSUED A RECALL. *TR

COMPONENT: EQUIPMENT:ELECTRICAL:AIR CONDITIONER SUMMARY: THE PROBLEM IS WITH THE AIR CONDITIONING A/C CONTROL UNIT. I'D TALKED TO SEVERAL TOYOTA OWNERS ABOUT THIS, AND THEY SAID THAT THEY HAVE HAD THIS PROBLEM , AND EACH HAS TAKEN IT TO A DEALERSHIP NEAR THEM AND GOT THE SAME REPLY. THIS WAS A VERY EXPENSIVE REPLACEMENT PART. THE DEALERSHIP THAT I WENT TO SAID THEY HAVE SEEN A FEW VEHICLES. THE OWNERS I TALKED TO OWNED HIGHLANDERS,4 RUNNERS, AND MINIVANS. MY WIFE'S HIGHLANDER IS A 200, 2 THE OTHER VEHICLES RANGE FROM 2002 TO 2004, FOR AS I KNOW THERE HASN'T BEEN ANYTHING REPORTED ABOUT THIS. I SENT AN EMAIL TO TOYOTA AND ALL I GOT BACK WAS THEY HAVEN'T HAD ANY RECALLS FOR THAT. THE PROBLEM WITH MY WIFE'S HIGHLANDER WAS THAT THE HEAT STOPPED WORKING DURING THE WINTER. THE ONLY WAY TO GET IT TO WORK WAS TO KEEP TURNING THE KNOB UNTIL IT WOULD START BLOWING WARM AIR, BUT IT WOULD NOT DO IT FOR LONG. THE A/C WORKED FINE ,BUT WHEN WINTER RETURNED, THERE WAS NO HEAT. IF THE WAS A CONTINUING PROBLEM, AND MORE DEALERS FOUND OUT ABOUT, WHY WEREN'T THEY DOING SOMETHING ABOUT IT. IF ONE COULD RESEARCH THIS I WOULD APPRECIATE IT. IF ANY BODY HAS ANY INFORMATION ON HOW TO SOLVE THIS PROBLEM THANK YOU *TR

THE SUN VISORS ON MY 2002 TOYOTA HIGHLANDER ARE BOTH FAILING. THE DRIVER SIDE VISOR FAILED AFTER ABOUT 2 YEARS. I TOOK IT TO THE DEALERSHIP AND THEY REPLACED IT UNDER WARRANTY. NOW IT IS FAILING AGAIN. THE PASSENGER SIDE VISOR IS NOW FAILING AS WELL. ACCORDING TO MY MECHANIC, THE COST TO REPLACE THEM WOULD BE ABOUT $1,000 - PARTS ONLY. *TR

2002 TOYOTA HIGHLANDER. DRIVER SIDE SUN VISOR DOES NOT STAY UP, DROPS DOWN WHILE DRIVING DUE TO ANY SMALL BUMPS. OFTEN DROPS AND TEMPORARILY BLOCKS VIEW WHILE DRIVING. FROM WEB SEARCHES SOUNDS LIKE A COMMON ISSUE WITH THE 02 HIGHLANDERS. *TR

I HAVE A COMPLAINT ABOUT MY 2002 TOYOTA HIGHLANDER. THE DRIVER SIDE SUN VISOR HAS A PROBLEM STAYING UP AND MY LOCAL TOYOTA DEALERSHIP HAS QUOTED ME A PRICE TO REPLACE THE PART THAT SEEMS EXTREMELY HIGH. THIS VISOR IS THE HOMELINK VISOR. *TR

THE TEMPERATURE CONTROL KNOW IN OUR 2002 TOYOTA HIGHLANDER IS NOT WORKING CORRECTLY. THE VENTS BLOW COLD AIR WHEN THE DIAL IS SET TO THE HOTTEST SETTING. IT IS VERY HARD TO KEEP THE ICE FROM FORMING ON OUR WINDOWS WHEN WE DON'T HAVE HOT AIR BLOWING. THE ICE STORMS IN MISSOURI OCCUR FAIRLY FREQUENTLY AND HOT AIR BLOWING IN THE DEFROST POSITION USUALLY KEEPS THE WINDSHIELD WARM ENOUGH TO KEEP IT CLEAR. HOWEVER, WITHOUT THE HOT AIR, THE WINDSHIELD ICES UP IMMEDIATELY AND MAKES DRIVING VERY DANGEROUS. THERE ARE MANY PEOPLE HAVING THIS PROBLEM. THIS IS ONE OF THE SITES THAT DESCRIBES THE ISSUE AND ALL THE PEOPLE WITH THE SAME PROBLEM HTTP://WWW.TUNDRASOLUTIONS.COM/FORUMS/HIGHLANDER/32217-HEATER-QUIT-SORT-OF/ *TR

WHILE DRIVING THE DRIVER SIDE SUN VISOR FALLS DOWN AFTER HITTING MILD BUMP IN ROAD. *TR

I HAVE READ OF NUMEROUS COMPLAINTS FROM CONSUMERS CONCERNING THE A/C SYSTEM ON 2002 TOYOTA HIGHLANDERS. THE COMPLAINTS ARE SIMILAR TO MY OWN IN THAT THE A/C JUST STOPS WORKING ONE DAY. IF I TURN THE HOT/COLD SWITCH KNOB TO THE COLD SECTION WHEN JUST THE VENT IS ON, IT BLOWS HOT AIR. IF I TURN IT TO THE RIGHT FOR HOT AIR- IT GETS EXTREMELY HOT. EVEN IF I TURN THE A/C BUTTON ON, COLD AIR DOES NOT COME OUT. THIS SEEMS TO BE A DEFECT IN A SWITCH. I'VE HAD THE PRESSURE TO THE A/C CHECKED AND IT WAS NORMAL AND CHARGED. I AM FEARFUL THERE IS A SHORT IN A SWITCH SOMEWHERE THAT MAY CAUSE MY VEHICLE TO CATCH FIRE. IT SEEMS TO BE A MAJOR COMPLAINT WITH A LOT OF HIGHLANDER OWNERS. *TR

DRIVER'S SIDE SUN VISOR WILL NOT STAY UP. I HAD TO TIE THE THING INTO PLACE IN ORDER TO SEE OUT THE WINDSHIELD AND NOW CANNOT USE IT WHEN THE SUN IS AT A BOTHERSOME ANGLE. VERY ANNOYING THAT A PART LIKE THIS SHOULD FAIL. *TR

THE SUN VISOR ON THE DRIVER SIDE OF OUR 2002 TOYOTA HIGHLANDER FALLS DOWN WHEN YOU ARE DRIVING ALONG. IT IS EXTREMELY DANGEROUS SINCE YOU NEVER KNOW WHEN THE VISOR WILL DROP DOWN AND OBSTRUCT YOUR VIEW. THERE HAVE BEEN A FEW OCCASIONS WHEN I HAVE BEEN DRIVING ALONG AND REACH TO PUT THE TURN SIGNAL ON. AT THAT MOMENT THE VISOR DROPS DOWN AND BEFORE I CAN RECOVER I AM CLOSE TO HITTING A CAR FROM THE REAR. I HAVE TRIED SIMPLE SOLUTIONS BUT THE DEALER INDICATES THAT NOTHING IS WRONG AND IT WILL COST OVER $700 TO FIX. *TR

THE HOT/COLD KNOB IN MY 2002 TOYOTA HIGHLANDER IS NOT WORKING PROPERLY. I RESEARCHED AND CALLED TOYOTA THEY SAID THERE ARE NO RECALLS ON IT AND THEY ONLY ISSUE THEM ACCORDING TO HOW MANY PARTS ARE SOLD TO REPAIR THAT VEHICLE. I LOOKED ONLINE AND ALOT OF PEOPLE THAT OWN THE SAME YEAR AND MODEL OF MY SUV ARE COMPLAINING ABOUT THE SAME ISSUE. TOYOTA QUOTED ME $805 TO REPAIR IT WHEN I WENT IN TO THE SERVICE DEPARTMENT. HE SAID THEY HAVE HAD ALOT OF COMPLAINTS ABOUT THE SAME ISSUE AND HAD ALREADY REPAIRED A COUPLE. WHEN I WENT IN TO HAVE IT LOOKED AT I HAD HEAT, WHEN I CAME OUT I DIDN'T. THEY TOLD ME I HAD TO FIX IT AND THERE WAS NOTHING ELSE I COULD DO. I CALLED THE MANAGER OF THIS PARTICULAR DEALERSHIP AND HE TOLD ME TO BRING MY CAR BACK IN AND THEY COULD SET IT TO HEAT. WHY DIDN'T THEY RETURN MY CAR IN THE SAME ORDER IT WAS IN WHEN I BROUGHT IT TO THEM IN THE FIRST PLACE. *TR

I SEEM TO BE ONE OF MANY THAT IS HAVING AN ISSUE WITH THE SUN VISOR ON A 2002 TOYOTA HIGHLANDER. THE DRIVER SIDE SUN VISOR WILL NO LONGER STAY IN PLACE PROPERLY. THIS RESULTS IN IT FALLING DOWN AND BLOCKING THE VISION OF THE DRIVER. SO FAR THIS HAS NOT CAUSED A SAFETY ISSUE BUT THE POTENTIAL IS DEFINITELY THERE. *TR

THE SUN VISOR ON THE DRIVER SIDE WILL NOT STAY IN PLACE. THIS IS A MAJOR SAFETY HAZARD AS IT FALLS INTO THE DRIVER'S LINE OF SITE WHILE THE VEHICLE IS IN MOTION. *TR

DRIVERS SIDE SUN VISOR IN '02 TOYOTA HIGHLANDER WILL NOT STAY UP. THE PASSENGER SIDE IS STARTING TO FAIL AS WELL. THIS IS A CONSISTENT PROBLEM. *TR