2007 Toyota FJ Cruiser complaints

SEVERE SUSPENSION BRACKET RUST ON MULTIPLE REAR AND FRONT COMPONENTS. I LUCKILY WAS ABLE TO AVOID AN ACCIDENT WHEN BRAKING BUT MY ENTIRE CAR SWAYED WHEN THE REAR LATERAL SUPPORT BAR BRACKET BROKE RIGHT OFF THE MOUNT THAT IS WELDED TO THE REAR DUE TO RUST. I THEN INSPECTED AND FOUND MULTIPLE RUST AREAS ON FRAME AND OTHER SUSPENSION BRACKETS. MAKING THIS VEHICLE UNSAFE TO DRIVE. I AM AWARE OF TOYOTA'S ONGOING DILEMMA WITH USING THIS HORRIBLE UNTREATED STEEL AND HOPE THE NHTSA ADDRESSES THIS ISSUE. THIS IS NOT NORMAL CORROSION THIS IS AN ABSOLUTE NEGLECT IN SAFETY BY NOT HAVING THIS STEEL TREATED ON SUCH CRITICAL COMPONENTS OF A VEHICLES FRAME. HAD THIS INCIDENT HAPPEN ON THE HIGHWAY AT SPEEDS OF 55 MPH OR GREATER. SERIOUS INJURY AND/OR DEATH CAN OCCUR. IF I AM NOT THE ONLY CONSUMER HAVING THIS ISSUE ON TOYOTA FJ CRUSIER VEHICLES. I HOPE THE NHTSA ENFORCES A RECAL ON THESE FRAMES AND/OR CRITICAL SUSPENSION COMPONENTS. MY VEHICLE IS 16 YEARS OLD, I PURCHASED IT FROM A DEALER WHOM RECIEVED IT FROM THE ORIGINAL OWNER WITH 57,000 MILES ON IT. NOW CURRENTLY AFTER 4 YEARS OF OWNING THIS FJ CRUISER I ONLY HAVE 71,000 MILES ON IT. HAD THIS BRACKET CAUGHT ONTO MY BRAKE LINES WHICH IS LOCATED DIRECTLY BELOW THIS REAR BRACKET I WOULD HAVE LOST ALL ABILITY TO STOP MY VEHICLE.

UNDER CARRIAGE, IS RUSTING AWAY ! VEHICLE, ONLY HAS 97,000 MILES ON IT. MECHANIC, SAID THE VEHICLE IS FALLING APART, WITH RUST...

MY SON WAS DRIVING HOME FROM SCHOOL WHEN HE HEARD A RATTLE/BANG WHEN HE TOOK A CORNER OR WENT OVER A BUMP. HE TOLD ME ABOUT THE NOISE AS SOON AS HE GOT HOME. WE TOOK THE FJ OUT FOR A DRIVE AND I HEARD THE NOISE COMING FROM THE DRIVER'S SIDE. UPON INSPECTING THE EXTERIOR DRIVERS SIDE I FOUND THAT THE LEFT SIDE, REAR TRAILING ARM MOUNTING POINT AND A SECTION OF THE FJ'S FRAME, HAD TORN AWAY FROM THE FRAME. THE TRAILING ARMS WAS NOT FLOATING, UNATTACHED. WE ARE VERY LUCK THAT THE TRAILING DID NOT DROP WHILE MY SON WAS DRIVING HOME, AS IT WOULD HAVE BEEN DRIVEN INTO THE PAVEMENT, POSSIBLY CAUSING A CATASTROPHIC ACCIDENT. I HAVE CALLED TOYOTA CORPORATE, WHO CAN PROVIDE NOT SOLUTION ON HOW TO REPAIR THIS ISSUE. AGAIN, I AM LUCKY MY SON WAS ON SECONDARY ROADS AND NOT THE HIGHWAY AND THE TRAILING ARM FELL TO THE PAVEMENT.

DRIVER SEAT AND PASSENGER SEAT HEATING UNIT IS COMING ON WITHOUT THE SWITCH TURNED ON.

UPON STATE INSPECTION, SEVERE RUST AND CORROSION WAS DISCOVERED ON THE FRAME. NOT ONLY DID IT FAIL INSPECTION, MY MECHANIC STRONGLY URGED ME NOT TO DRIVE IT, AS THE REAR AXLE HAS A POSSIBILITY OF FALLING OUT.

TOYOTA'S HAVE BEEN HAVING RUST ISSUES WITH FRAMES. A GOVERNMENT MANDATED FIX FOR TUNDRAS AND TACOMAS HAVE BEEN APPROVED, BUT NOT FOR FJ CRUISERS, EVEN THOUGH IT'S A SIMILAR MODEL. I NEED TO HAVE MY FRAME RUST ISSUES FIXED IN ORDER TO PASS INSPECTION.

GAS TANK STRAPS BROKE FRAME DETERIATED ON FJ CRUSIER WITH ONLY 72000 MILES ON IT WOULD HAVE NEVER KNOWN HOW UNSAFE FRAME IS IF STRAPS GAS TANK HANGING

SEVERE RUST ISSUES. ENTIRE REAR DIFFERENTIAL REQUIRED REPLACEMENT. ALL POWER STEERING AND AUTOMATIC TRANSMISSION LINES NEEDED REPLACEMENT, FUEL LINES ARE NEXT FUEL TANK STRAPS RUSTED AND BROKE OFF, TANK FELL DOWN. BRAKE PAD PINS REQUIRED CUTTING OFF. PROTECTION PLATES RUSTED OFF. EXHAUST SYSTEM COMPONENTS REQUIRED REPLACEMENT DUE TO RUST. ENTIRE FRAME AND ENGINE COMPARTMENT COVERED IN RUST. ALL THESE ITEMS HAVE CAUSED MULTIPLE SAFETY ISSUES. MULTIPLE STRAPS AND CONNECTIONS FOR VARIOUS COMPONENTS ARE NO LONGER USABLE DUE TO RUST.

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR TIRE REPAIRS AND THE MECHANIC FOUND THAT THE FUEL TANK STRAPS WERE SEVERELY CORRODED AND THE SUBFRAME WAS ALSO SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 71,000.*DT THE CONSUMER PROVIDED PHOTOS. *TR

FRAME RUSTING OUT, SUSPENSION ATTACHMENT PARTS RUSTING, BODY MOUNTS RUSTING AND BROKEN

FUEL TANK STRAP RUST

MY 2007 FJ CRUISER HAS MAJOR PROBLEMS WITH RUST. THIS INCLUDES BEING INFORMED TODAY THAT THE FRAME HAS HOLES THAT HAVE RUSTED THROUGH AND THE VEHICLE WOULD NOT PASS INSPECTION. I HAVE ALREADY PUT A LOT OF MONEY INTO THE VEHICLE REPLACING RUSTED PARTS INCLUDING REPLACING THE FUEL TANK STRAPS LAST YEAR, PARTS OF THE SUSPENSION AND RADIATOR. THIS SEEMS EXCESSIVE DAMAGE DUE TO RUST AND CREATES AN UNSAFE TOYOTA PRODUCT.

I HAVE BEEN HAVING NOTHING, BUT PROBLEMS WITH KEEPING MY FJ ALIVE. IT WON'T EVEN KEEP A HOLD LONGER THAN A FEW HOURS. I HAVE ALSO HAD PROBLEMS WITH THE FUEL TANK AS I CAN NEVER GO LOWER THAN 1/4 OF A TANK BECAUSE IT WILL DIE. I HAVE READ THAT OTHER FJS HAVE HAD THEIR FUEL PUMPS REPLACED UNDER RECALL AND I WOULD LIKE MINE DONE AS WELL.

IT HAS TAKEN A FEW YEARS SINCE I KEEP MY FJ CRUISER GARAGED, BUT I FOUND A SOUND MAT ON THE INSIDE OF THE DOORS THAT RETAIN WATER AND CAUSE RUST. MY PROBLEM RIGHT NOW IS IN THE LEFT DOOR (DRIVER'S SIDE) AND THE RUST FROM INSIDE THE DOOR HAS FINALLY MADE IT'S WAY COMPLETELY THROUGH THE DOOR. I AM ATTACHING PHOTOS SHOWING THE PERFORATION WHICH IS WELL OVER 1/8 OF AN INCH DEEP. I ONLY HAVE 57450 MILES ON MY VEHICLE DUE TO BEING OVERSEAS IN SYRIA, IRAQ, AND AFGHANISTAN AS A CIVILIAN DOD WAR ZONE PILOT SO WEATHER AND RAIN HAVE NOT BEEN AN ISSUE WHILE IT WAS GARAGED. VEHICLES ARE DESIGNED TO LET WATER IN THE DOOR THEN DRAIN THROUGH THE DRAIN HOLES AT THE BOTTOM OF THE DOOR BUT TOYOTA BUT THIS SOUND MAT ON THE INSIDE OF THE DOOR WHICH CAUSING PROBLEMS FOR MYSELF AND A FEW OTHER UNFORTUNATE FJ CRUISER OWNERS. KNOWING THIS IS A DESIGN PROBLEM / DEFECT FROM TOYOTA, I FEEL THEY SHOULD COVER THE REPAIR BECAUSE THIS ISSUE IT OUTSIDE OF NORMAL USE DUE TO IT'S DESIGN. I LIVE INLAND AND SALT FREE DOWN HERE IS FLORIDA SO ROAD SALT OR ROAD CHEMICALS CANNOT BE BLAMED. ALL I CAN DO FOR NOW IS FILL IN THE HOLES AND USE TOUCH UP PAINT WHICH RUINS THE APPEARANCE OVERALL OF MY VEHICLE BECAUSE IT IS KEPT IN TOP NOTCH SHAPE INSIDE AND OUT AND THIS DOOR NOT ONLY LOOKS BAD, BUT OVER TIME WILL COMPLETELY RUST THROUGH COSTING MY HUNDREDS OF DOLLARS.

PREMATURE FRAME AND SUSPENSION RUST. I WORRY ABOUT THE SAFETY OF THE VEHICLE WITH HIDDEN RUST POSSIBLY CAUSING A CATASTROPHIC FAILURE.

FACTORY RECEIVER ON FRAME DROPPED COMING TO A STOP WHILE TOWING A TRAILER DUE TO FRAME RUST/CORROSION.

FRAME SEEMS TO BE RUSTING QUICK. AIR CONDITIONING WATER DRAIN AND RUN OFF HITS FRAME AND RUSTS IN THAT SPOT

REPEATED BEADING ISSUES. FORCED TO REPLACE RIMS.BEADING ISSUES HAVE OCCURRED OVER MULTIPLE YEARS...SINCE PURCHASING THE CAR NEW.

FRAME OF THE VEHICLE IS HAVING WHOLE SPOTS AND UNSAFE THE DRIVE THE VEHICLE. I DON'T KNOW WHY THERE IS NO RECALL IN THIS VEHICLE. EVEN THERE IS FRAME RECALLS FOR THE SAME YEAR AND MODEL CARS. WHY NOT MY CAR DOESN'T HAVE RECALLS. I WANT TO GET INTO BOTTOM OF THIS.

MY FJ HAS 63K MILES ON IT AND HAS RUST ALL OVER THE UNDERCARRIAGE INCLUDING THE SPRINGS, CONTOL ARMS, CALIPERS, FRAME, SWAY BAR, ETC...

I AM THE THIRD OWNER OF A 2007 TOYOTA FJ CRUISER, THIS VEHICLE HAS MAJOR RUST OVERTAKING THE FRAME AND ALL SUSPENSION PARTS AND MOUNTS, EVEN THE INSIDE OF THE FRAME IS RUSTING OUT. THIS SEEMS TO BE A REGULAR ISSUE. I AM VERY CONCERNED I AM GOING TO HAVE SUSPENSION PARTS BREAK OFF WHILE I'M DRIVING, I HAVE ALREADY HAD TO REPLACE THE FUEL TANK STRAPS THAT RUSTED IN HALF WHILE DRIVING DOEN THE HIGHWAY.

SEVERE RUST ON THE FRAME AND UNDERCARRIAGE HAS RENDERED THE VEHICLE COMPLETELY UNDRIVEABLE

THE ENTIRE FRAME IS BADLY RUSTED TO THE POINT OF BEING UNSAFE. THE CAR HAS BEEN REGULARLY WASHED AND WELL MAINTAINED. ALL OTHER COMPONENTS ARE IN GREAT WORKING ORDER, BUT THE CAR NOW NEED EXTENSIVE FRAME REPAIRS TO REMAIN ROAD WORTHY. IN ADDITION, THE STRAPS HOLDING THE FUEL TANK IN PLACE RUSTED THROUGH AND NEARLY CAUSED THE TANK TO FALL OUT OF THE CAR.

THE STRAPS THAT HOLD THE GAS TANK UP UNDER THE VEHICLE HAVE RUSTED AWAY AND THE GAS TANK HAS FALLEN OUT OF THE BOTTOM OF THE VEHICLE. THIS INCIDENT OCCURRED WHILE DRIVING ON CITY STREETS NEAR MY HOME.

HAVE OWNED THE VEHICLE FOR OVER 4 YEARS AND RUST ON FRAME HAS GOTTEN PROGRESSIVELY WORST. VEHICLE HAS BECOME UNSAFE TO DRIVE DUE TO REAR SUSPENSION LIKELY TO COLLAPSE DUE TO HOLES IN FRAME. DANGEROUS TO DRIVE AND IF VEHICLE WHERE TO BE IN AN ACCIDENT THE WHOLE STRUCTURE COULD COLLAPSE. VERY UNHAPPY WITH TOYOTA EXPERIENCE.

SEVERE RUST ON CRITICAL SUSPENSION COMPONENTS DESPITE FREQUEN UNDERCARRIAGE WASHING AND CARE. CONTROL ARMS AND TANK STRAPS WILL NEED TO BE REPLACED AND MOUNTS WELDED

I AM ONE OF THE ORIGINAL PURCHASERS OF A 2007 FJ CRUISER IN AUGUST OF 2006. I ORDERED MY VEHICLE IN JULY 2006. I RECEIVED A SCALE MODEL OF MY FJ WITH SERIEL NUMBER BELOW 500, WHICH I WAS TOLD INDICATED THAT I WAS ONE OF THE FIRST 500 PURCHASERS OF THE NEW MODEL I HAD READ ON THE NEWLY ESTABLISHED FJCRUISERFORUMS.COM THAT THE NEW FRAMES WHERE ARRIVING WITH RUST ON THE WELDS. WHEN MY VEHICLE ARRIVED I POINTED OUT RUST ON THE FRAME JUST FROM SHIPPING AND TOLD THE DEALER THAT I NEEDED THE FRAME UNDERCOATED. I ALSO SHOWED THE DEALER THE FJ CRUISER FORUM POSTS THEY COMPLIED. I HAVE USED THIS VEHICLE FOR WORK FOR MANY YEARS. I HAVE TAKEN IT IN ALMOST WEEKLY FOR AN UNDERCARRIAGE WASH IF I WAS USING IT WEEKLY. MOST ALL OF MY MILES ARE HIGHWAY. THE RUST HAS NOT ABATED. I HAVE WIRE BRUSHED THE FRAME MULTIPLE TIMES, SPRAYED IT WITH RUST PREVENTIVE PAINT, SQUIRTED OIL INSIDE THE FRAME. IT STILL HAS NOT STOPPED THE RUST. NOW I FINALLY HAVE A HOLE IN THE FRAME. IT IS NOT IN A CRITICAL AREA BUT I CANNOT TELL IF THERE ARE AREAS THAT IT MAY ALSO BE WEAK. TOYOTA HAS ADMITTED TO FRAME ISSUE ON THE TACOMA AND TOYOTA SEQUOIA. ARE THEY NOT ADDRESSING THIS BECAUSE THERE ARE FEWER OF THE FJ'S ON THE ROAD? THIS FRAME SHOULD BE REPLACED. IT WAS DEFECTIVE WHEN IT WAS SOLD.

WHILE DRIVING AROUND 45 MPH THE FJ BECAME LOOSE AND LOW IN THE REAR. AT THE SAME TIME ALL THE ABS AND TRACTION CONTROL LIGHT CAME ON. WHILE LOOKING FOR THE PROBLEM WE FOUND THAT THE LATERAL TRACTION BAR MOUNTS WELDED TO THE AXLE HAD ROTTED AND COLLAPSED SEVERING THE ABS WIRE. THE UPPER PART OF THE AXLE WAS NO LONGER CONNECTED TO THE VEHICLE. TOYOTA DOES NOT OFFER A REPLACEMENT PART OTHER THAN A COMPLETE AXLE.

2007 TOYOTA FJ CRUISER FRAME ROTTING FROM INSIDE AND OUT. REAR UPPER CONTROL ARM MOUNTS RUSTING LOOKING LIKE ITS ABOUT TO BREAK OFF. UNSAFE TO DRIVE. 13 YEAR OLD FRAME SHOULD NOT BE ANYWHERE NEAR THIS CONDITION.

VEHICLE WAS DRIVING IN TRAFFIC AND MULTIPLE HAZARD LIGHTS CAME ON, ALARM CAME ON, AND AS DRIVER ATTEMPTED TO SLOW DOWN BRAKE PEDAL WENT TO THE FLOOR AND DOWNSHIFTING WITH EMERGENCY BRAKE USED TO STOP IN MIDDLE OF INTERSECTION.VISUAL INSPECTION REVEALED NO BRAKE FLUID IN MASTER CYLINDER RESERVOIR AND LEAKING BRAKE FLUID ON DRIVERS REAR BRAKE CYLINDER.PICS ATTACHED.PRIOR REPORTS APPEAR OF THIS FJCRUISER ISSUE BUT ONLY TACOMA VEHICLES RECALLED.I AM CONTACTING MY LEWISVILLE TOYOTA WHERE I PURCHASED VEHICLE.

THE FRAME IS EXTREMELY RUSTY ON ALL OF THE FJ CRUISERS, JUST LIKE THE TACOMA AND SEQUOIA. THERE IS NO PAINT OR UNDERCOATING APPLIED ON THE INSIDE OF THESE FRAMES SO THEY RUST FROM THE INSIDE OUT.

MY VEHICLE IS GETTING PRETTY RUSTY, EVEN WITH PROPER MAINTENANCE AND CLEANING. THE FRAME AND SUSPENSION COMPONENTS PRETTY SOON ARE GOING TO BECOME UNSAFE. I'M NOT GOING TO BE ABLE TO DRIVE THE TRUCK ANYMORE, THE VALUE IS STILL PRETTY HIGH, IT JUST HAVE 118.000 MILES.

FRAME AND SUSPENSION COMPONENTS ARE VERY RUSTY TO THE POINT OF A SAFETY CONCERN. I REPLACED THE REAR BUMPER WITH AN AFTERMARKET ONE TO DISCOVER THE REAR BUMPER SUPPORT WAS SO RUSTED IT WOULDN'T BE OF ANY HELP IN THE EVENT OF BEING REAR ENDED BY ANOTHER CAR. ALSO, THE REAR BUMPER COMES STOCK WITH 2 SENSORS SO WHEN BACKING UP WILL LET YOU KNOW WHEN YOU GET CLOSE TO SOMETHING. BOTH SENSORS WERE NON-TRANSFERABLE TO THE NEW BUMPER BECAUSE THEY WERE SO RUSTED ON THE INSIDE WHEN YOU TRIED TO REMOVE THEM THEY CRUMBLED INTO BITS, A COMBINATION OF METAL AND PLASTIC. THE RUST WORKED ITS WAY UP THE WIRES AS WELL. NUMEROUS BRACKETS UNDERNEATH THE TRUCK WHICH HOLD WHAT APPEARS TO BE ELECTRICAL COMPONENTS THE VEHICLE WOULD NEED TO OPERATE. IF ONE OF THESE COMPONENTS BROKE AND NEEDED TO BE REPLACED I WOULD NEED TO BUY NEW BRACKETS ALONG WITH THE NEW COMPONENT - NEW SCREWS WOULD ALSO BE REQUIRED ALONG SIDE A HOLY PRAYER THAT THE OLD SCREWS DON'T SNAP OFF WHILE ATTEMPTING TO REMOVE THEM. BY THE TIME I WAS DONE PAYING OFF MY VEHICLE AND HAVING MORE FREE INCOME TO PUT TOWARDS OTHER PRIORITIES I WAS CONSISTENTLY DELAYED WITH REPAIRES THE VEHICLE NEEDED TO KEEP FUNCTIONING. I HAD TO PAY FOR NEW TRANSMISSION LINES BECAUSE THE ONES ON THERE WERE SO RUSTED, IN A LUMP SUM I WAS NOT PREPARED FOR. POWER STEERING LINES WERE REPLACED ONCE AND THE POWER STEERING STILL HAS AN ISSUE HOLDING FLUID. I AM GOING TO CHOSE TODAY'S DATE AS THE DATE THIS OCCURRED BECAUSE NOW I AM AT MY WIT'S END WITH THE RUST. I TOO

PURCHASED A 2007 FJ CRUISER USED AND DISCOVERED THE FRAME IS RUSTING AND DETERIORATING AT AN ALARMING PACE. THE DAMAGE IS EXTENSIVE AND HAS OBVIOUSLY BEEN ONGOING FOR QUITE SOMETIME.

FRAME IS RUSTED UNDERNEATH. CAR LOOKS AND DRIVES PERFECTLY. I CRAWLED UNDER AND THE ENTIRE FRAME IS RUSTED. I PURCHASED FROM A DEALER TWO WEEKS AGO. IT HAD 2 OWNERS AND LESS THAN 100000 MILES.

HAD A VIRINA SAFETY INSPECTION PERFORMED ON 6-25-2020 AND IT WAS FOUND THE FRAME IS COMPLETELY RUSTED OUT. THE VEHICLE CANNOT BE DRIVEN DUE TO SAFETY REASONS. 2007 TOYOTA FJ CRUISER WITH 101000 MILES. NO ACCIDENT OR INJURY BUT VEHICLE IS NOT OPERABLE DUE TO STRUCTURAL FAILURE COULD HAPPEN AT ANY TIME. *TR

I BOUGHT MY 2007 TOYOTA FJ BRAND NEW FROM THE DEALER, A YEAR LATER I BROUGHT TO THE ATTENTION OF MY DEALERSHIP THAT THE UNDERSIDE OF MY VEHICLE WAS SHOWING SIGNS OF RUST. I WAS TOLD THAT IT WAS JUST SURFACE RUST NOTHING TO WORRY ABOUT. MY VEHICLE WAS KEPT IN THE GARAGE AND DRIVEN VERY LITTLE ON A YEARLY BASIS DUE TO THE FACT THAT I HAVE OTHER VEHICLES TO DRIVE. I DIDN'T PAY MUCH ATTENTION THROUGHOUT THE YEARS UNTIL I HAD TO GO UNDERNEATH THE VEHICLE TO INVESTIGATING RATTLING NOISES, WHEN I WENT UNDERNEATH THE SITE WAS DISGUSTING RUST WAS EVERYWHERE SERIOUS RUST. I WENT TO TOYOTA THIS WINTER THEY PUT IT ON A LIFT AND TOOK PHOTOGRAPHS THAT WERE TO BE SENT IN TO TOYOTA HEADQUARTERS FOR ANALYSIS THEY PRETTY MUCH TOLD ME AT THE DEALERSHIP THAT I WAS ON MY OWN. ALTHOUGH THERE HAVE BEEN RECALLS ON OTHER TOYOTA VEHICLES BECAUSE OF CHASSIS OR BODY RUST ISSUES NOTHING ON MY FJ CRUISER, I HAVE SPOKEN TO OTHER FJ CRUISER OWNERS IN SOME BUT NOT ALL ARE AFRAID TO DRIVE THEIR VEHICLES DUE TO SAFETY CONCERNS WOULD YOU PLEASE LOOK INTO THIS SEVERE NEGLIGENCE ON THE PART OF TOYOTA THANK YOU. *TR

QUOTING TOYOTA EXACTLY, ' TECH INSPECTED FOUND FRAME ROTTING AWAY WERE LEFT REAR BODY MOUNT MEETS FRAME, CUSTOMER WAS ADVISED TO SPEAK TO TOYOTA NORTH AMERICA CUSTOMER SERVICE.' *TR

TL* THE CONTACT OWNED A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH WITH A TRAILER ATTACHED TO HIS VEHICLE, THE VEHICLE BEGAN VEERING TO THE RIGHT DUE TO HIGH WINDS. AS THE CONTACT ATTEMPTED TO REGAIN CONTROL OF THE VEHICLE, THE VEHICLE FLIPPED AND ROLLED OVER MULTIPLE TIMES. THE AIR BAGS DID NOT DEPLOY AS A RESULT OF THE ACCIDENT. BOTH THE CONTACT AND HIS PASSENGER WERE INJURED AT THE SCENE AND WERE TRANSPORTED TO A LOCAL HOSPITAL. BOTH PARTIES WERE TREATED FOR A CONCUSSION AS WELL AS SEVERAL CUTS AND BRUISES ON VARIOUS PARTS OF THEIR BODIES. A POLICE REPORT WAS FILED. NO DAMAGES TO THE TRAILER WERE REPORTED. THE VEHICLE WAS DESTROYED AT THE SCENE AND WAS TOWED TO AN INDEPENDENT TOW YARD. THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.

AIR BAG LIGHT HAS BEEN ON 3 TIMES ALREADY NEVER BEEN IN ACCIDENT AIR BAGS HAVE NEVER DEPLOYED SO WHY ARE ALL THE MODULES BAD AND THE ENTIRE AIR BAG SYSTEM I HEAR ALOT WITH THIS YEAR MAKE AND MODEL AND THE AIRBAGS STOP WORKING THIS IS VERY DANGEROUS. *TR

I PURCHASED THIS VEHICLE USED AND AFTER FURTHER INSPECTION BEYOND REMOVING THE LAYER OF UNDERCOATING THAT THE PREVIOUS OWNER HAD APPLIED I NOTICED THAT THE REAR MOUNTS TO THE BODY OF THE VEHICLE HAVE RUSTED AND BROKEN COMPLETELY OFF. FRONT AND REAR BODY MOUNTS ARE RUSTED WITH HOLES THROUGH MOST OF THE BRACKETS. NUMEROUS SPOTS IN THE FRAME ITSELF HAVE RUSTED THROUGH AND SOME SPOTS HAVE REQUIRED PATCHING ALREADY. THE TRAILING ARMS ARE ALSO RUSTED THROUGH AS WELL AS THE SKID PLATE AND WHERE IT CONNECTS TO THE FRAME AND THE RADIATOR SUPPORT IS RUSTED AS WELL. THE VEHICLE IS NOT CURRENTLY INSPECTABLE DUE TO THE FRAME BEING IN THE CONDITION THAT IT IS IN.

THE RUST ON THE FRAME IS MIND BLOWING. RUST HOLES IN FRAME AND GAS TANK STRAPS, AND SUSPENSION PARTS. THIS IS DANGERS AND SOMEONE CAN BE INJURED OR DEAD. *TR

I REAR ENDED SOMEONE AND I WAS GOING 30MPH APPROX AND MY AIRBAGS DID NOT DEPLOY AND THE CAR ENGINE AREA AND BATTERY CAUGHT ON FIRE

FRAME RUST ON THIS VEHICLE IS OVERWHELMING. IT IS CORRODING EXTENSIVELY, EVEN HAVING TAKEN STEPS TO TREAT IT AND PREVENT FURTHER DISINTEGRATION. HAVING DESCALED THE FRAME AND MANY COMPONENTS AND TREATING EVERYTHING WITH A RUST CONVERSION PRODUCT AND SEALER, MUCH OF IT IS STILL COMING BACK THROUGH. THIS IS EVEN AFTER AVOIDING DRIVING UNDER ANY NEGATIVE WEATHER CONDITIONS. THERE ARE MANY PLACES THAT THE RUST IS JUST EATING ITS WAY BACK THROUGH AGAIN. THERE ARE INDIVIDUAL PARTS THAT COULD BE BROKEN OFF BY HAND DUE TO THE RUST. ALTHOUGH IT SEEMS TO BE FAIRLY STABLE AT THE MOMENT, I AM UNSURE HOW LONG THE FRAME AND STRUCTURE MAY STAY INTACT BEFORE THERE IS A MAJOR MALFUNCTION. THIS INCLUDES THE GAS TANK STRAP THAT IS RUSTING THROUGH AS WELL. *TR

I AM EXPERIENCING SEVER RUST, ESPECIALLY ON THE UNDERSIDE OF MY 2007 TOYOTA FJ CRUISER. THIS HAS CAUSED THE EXHAUST MOUNTS TO BREAK, THE LOSS OF THE SKID PLATE WHICH DETERIORATED AS PARTS OF IT WERE TRYING TO HANG ON AND EVEN MY GAS TANK STRAPS BROKE! THE EXHAUST BROKE WHILE I WAS DRIVING AROUND TOWN FOR WORK BUT I WAS ABLE TO SAFELY PULL OVER AND HAVE A COLLEAGUE TEMPORARILY REATTACH IT. THE SKID PLATE HAPPENED OVER TIME UNTIL IT WAS IN PIECES AND HAD TO BE REMOVED THE REST OF THE WAY AND THE GAS TANK STRAP HAPPENED ON A ROAD TRIP IN NORTHERN MICHIGAN AND WE WERE ABLE TO RATCHET STRAP IT BACK IN PLACE FOR THE REST OF THE TIME. *TR

REAR DIFFERENTIAL CARRIER IS BAD. THIS IS A KNOWN PROBLEM TO TOYOTA; BAD GEARS IN 2007 MODELS. THEY CORRECTED IT IN 2010 WITH UPGRADED GEARS. THIS SHOULD HAVE BEEN RECALLED BY TOYOTA SINCE THEY WERE AWARE OF THE PROBLEM.MY FJ HAS ONLY 80,000 MILES AND NO REAR END SHOULD GO OUT AT THIS LOW MILEAGE.THE REPAIRS FOR THIS AT TOYOTA SERVICE CENTER IS $4,000.00. *TR

THE FRAME HAS MAJOR RUST , SCALING, HOLES AND FALLING APART MAKING THE VEHICLE UNSAFE, I BOUGHT THE CAR IN TO BE REPAIRED AND WAS TOLD THE FRAME IS ROTTING FROM THE INSIDE OUT , THAT IT SHOULD NOT BE DRIVEN TILL FRAME IS REPLACED OR REPAIRED

RUST HAS DECIMATED THE FRAME OF THIS VEHICLE RESULTING IN THE CONTROL ARM MOUNT TO BREAK AWAY FROM THE FRAME OF THE VEHICLE. THE CONTROL ARM IS COMPLETELY IN TACT. THE PART THAT BROKE IS IRREPARABLE BECAUSE IT IS THE FRAME ITSELF. NO WELDING/BODY SHOP WILL TOUCH IT BECAUSE THEY DEEM IT UNSAFE EVEN IF WELDED BACK TO REST OF FRAME. IT IS BEING RECOMMENDED NOT TO ATTEMPT A REPAIR AND TO INSTALL A NEW FRAME. FORTUNATELY, THIS BROKE IN A PARKING LOT INSTEAD OF ON THE HIGHWAY WHERE AN ACCIDENT WOULD HAVE HAPPENED OR WORSE. FRAME RUST HAS BEEN A PROBLEM WITH TOYOTA TRUCKS AS I UNDERSTAND BUT TO HAVE A FRAME ACTUALLY BREAK IS ABSURD.

THE FRAME ON MY 2007 FJ CRUISER IS IN BAD SHAPE. MULTIPLE AREAS OF BAD EXFOLIATION CORROSION, FLAKING OFF IN LARGE CHUNKS NEARLY EVERY PART OF THE FRAME. BODY IS IN PERFECT CONDITION BUT THE FRAME IS TERRIBLE.

WHEN I CRUISE ON A HIGHWAY AROUND 70MPH, MY CAR SUDDENLY LOST POWER. I WAS VERY SCARED BUT TRIED TO MOVE THE CAR TO CURB, THEN THE CAR DIED. ONE MINUTE LATER I TRIED TO RESTART THE CAR BUT FAILED. I CALLED THE ROAD ASSISTANCE SERVICE. WHEN THEY CAME AND POURED IN ONE GALLON GAS IN THE CAR, THEN THE CAR WAS STARTED. THE PROBLEM IS THAT BEFORE THE CAR DIED, THE FUEL INDICATOR POINTER POINTED AT THE A QUARTER POSITION. THE FUEL EMPTY WARNING LIGHT WAS NOT ON.