2021 Tesla Model S complaints

The suspension is very stiff and to the point when the smallest of pot holes, road bumps, or going over the road divider marker sends the shock to the body of the passenger. My family complaints of neck pain after a short ride. I live in San Jose, CA. I drive with the comfort mode with the soft ride setting for the suspension. This deep discomfort, pronounced for rear passengers is also increasingly deteriorating. Tesla inspected my car on Sept 8, 2023 - partially fixed the suspension noise. No change to the ride stiffness causing deep discomfort to passengers. Tesla inspected my car on Nov 8, 2023 for the same issue. No resolution. Tesla inspected my car on Dec 17, 2023 for the same issue. No resultion. I was told by Tesla technician who drove with me, that the ride is stiff, however, there are no fixes currently. A change to the setting and / or suspension will happen if there is a volume of complaints. Initially, the suspension had sound issues and frequent cranking. Tesla fixed it partially. However, this did not resolve the stiff suspension. I went to the Tesla dealership three times, each of the times, Tesla toggled with the settings but not avail. Tesla now claims that the suspension is what it is, any relief has to come from NHTSA or I have to sell my car.

Dear Sir/Madam, I am highly concerned about the safety of the newest versions of Tesla Model S, Model X (without stalks), CyberTruck and Model 3 with the code name Highland. These models pose a significant danger when operated without intuitive direction signals, especially in the following situations: 1) Roundabouts: It is nearly impossible to correctly activate the signal lights. Please refer to the following example: [XXX] 2) Complete distraction of our focus from the road is required to operate signalling (eyes are EVERY TIME off a road), as shown in this example: [XXX] 3) In the event of a slightly dangerous occurrence, it is impossible to effectively and intuitively use the signals (or honk with the "Yoke" steering wheel). Please see: [XXX] Naturally, all of these points contribute to a significantly higher risk of accidents and undoubtedly impact the flow of traffic. Regards Alardo INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Have just learned (on routine check) that Front/Rear tire configuration has been backwards since delivery from the FACTORY; 24 mo, 24k miles. Factory specified FRONT REAR 255/45R19 285/40R19 NOTE REVERSAL Actual upon delivery FRONT REAR 285/40R19 255/45R19 ONLY service has been 1 left/right switch at 19k with NO front/back, per tire service recommendation; not detected then. And there’s NO chance it was reversed after delivery. I'm wondering effect on tread life, safety, drive-ability. Tech said this error would vastly affect performance, "Haven't you noticed car 'driving really funny'?" Notified Tesla; no response yet. In photos, Note door decal, fender placement will show front/rear.

The contact owns a 2021 Tesla Model S. The contact stated that while driving at an undisclosed speed, the driver’s side indicator was inoperable on the yoke steering wheel. The contact stated that the failure had occurred several times. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 24,500.

The 2021 and beyond Tesla Model S comes installed with camber arms that cause the wheel to be tilted in and thus wears the tire on the inside to the point of wearing out within 6 months. This is a flaw in the building and pertains to all the model S's 2021 and greater. This is a safety issue and is not addressed by Tesla. I think Tesla should be forced to provide a recall for this.

The OEM 21 inch wheel cracked which resulted in a flattening tire.

I have had my Tesla to their shop FOUR times to try to fix a safety airbag issue in the drivers side which they have had my car for weeks and weeks on end, only for me to get it back with the same issue after only a few days of repair! I asked them for a refund and other things and they have done nothing! They still make me pay full price for my lease even though they have had my car in their shop more than I have driving it.

Tire tread delaminated from the body of the tire, leading to loss of pressure and dangerous loss of vehicle control. Both rear tires had the same issue. 295 /30 R21

Rear passenger seat belt came unattached from receiver on braking. 7 year old in booster seat lunged forward

My rear driver side tire failed on the interstate and lost pressure so quickly I had to pull over immediately. Thankfully the tire remained intact enough for me to safely pull over and no one was injured. After realizing this wasn’t just a puncture, I was shocked. This is either a major defect with the tire or with Teslas installation of the tire. The inner part of the tire was shredded but the rest of the tire has significant tread left. These tires are less than 1 year old and less than 16500 miles of use. The tires offer a 30,000 mile warranty.

After backing out of a parking space and turning the steering wheel, the steering wheel locked up. I could still drive forward and reverse but had no ability to steer the car. I left the car in order to turn it off and when I returned and turned it back on, the steering unlocked. I had this happen two times today.

Vehicle braked without warning with cruise control engaged. Luckily there were no other vehicles near us when this phantom braking occurred.

The horn is a tiny button on the steering wheel. Several times when someone inadvertently started entering my lane I couldn't find the horn fast enough to warn them so had to veer away and brake suddenly to avoid them as I couldn't warn them.

The adaptive cruise control has had phantom braking issues from day 1 of ownership (and through every software release from Tesla as I always update when a new one is available). Most of the time it's not possible to identify exactly what triggers the event. However, on July 27th 2023 I drove from Phoenix to Sacramento via I10, I210, I5 and had 6 phantom braking events. 5 were directly correlated with passing a semi with me in the #1 lane and the semi in #2. I had the car in adaptive cruise control mode, but I maintained steering control. The car approached the semis normally, but as soon as the car was completely alongside the truck it began braking aggressively. More than just allowing regenerative braking to slow the car, the brakes were applied. This did not happen with every passed truck, maybe 1 in 10. One of the 6 phantom events could not be correlated with any clearly identifiable cause. There is no warning when the car begins decelerating so it is a surprise to the driver. Further it is an extreme hazard to following vehicles who WILL be forced to react. I have not directly reported my specific events to Tesla. For one thing they have no reasonable way to do this (online access, phone access. The number they give to report problems hits an automated phone tree where there is no option for reporting issues). Clearly Tesla is well aware of their phantom braking issues. I'm reporting this to you now in order to apply more pressure to Tesla to finally resolve this. In ge

The horn is a small button in a very small area of the steering wheel. The center of the steering wheel which acts as a horn on almost all other vehicles, does not work. In the event of an emergency, and the horn needs to be activated, it is difficult to find and press the small button, and the instinct would be to press the center of the steering wheel, which would not work and the horn would not activate.

Adaptive Cruise Control. The vehicle in this mode suddenly brakes for no apparent reason which under the right circumstances could cause a collision. Tesla Service Center looked at it but could not reproduce. This has happened many times on various dates not just once. Sometimes it happens more than once on a trip, sometimes it does not happen. This happens with no warning. Tesla knows about this problem for years but has failed to correct.

I was in the middle of a turn when someone veered into my lane. I tried to honk my horn to warn the other driver, but I couldn’t find it. The button was on the other side of the steering because the yoke was turned. I couldn’t find the horn button in time to avert a collision. Fortunately I was able to steer away in time.

Front axle half shafts have failed two times requiring replacement (on 3rd set now). During acceleration the steering wheel vibrates violently. Tesla service center diagnosed both times that front half shafts needed to be replaced. There seems to be some design or manufacturing problem - these items keep failing. The cost to fix is ~$1,650 so I delayed as long as possible until vibration became unbarable. First replacement was done under warranty, second replacement was required ~16,000 later and I was forced to pay for it. There is a Tesla service bulletin about this which I saw online.

There was a trash can on the edge of the road and my vehicle was in autopilot/FSD mode and for some reason it swerved over too close to the edge of the road. I intervened in time to avoid hitting the trash can head-on but it still struck the passenger side mirror and scraped across the passenger rear fender. The mirror got slammed into the passenger side door causing damage to the door and trim at the bottom of the passenger side window.

Going north on New York State highway I-87, there is a bridge which results in Tesla Autopilot erroring EVERY TIME AND EVERY DAY and results in a "Full Self Driving Error" which causes Telsa car to brake along with putting on hazard lights. Issue was reported to Tesla, but they responded that it happens to everyone under this bridge so there is nothing they can do right now. The fault occurs on a busy highway at 55mph zone, and happens 100% of time going under the bridge, every single day. The bridge is wide enough that shadow results in error and car loses all understanding of what lane it is in. Today at the Tesla service center, the employees all reported the same issue as well and that there is no idea if it will be fixed. Happens only when using FSD/AP driving support; manual driving is unaffected.

On 10Jul2023, approximately 1:00pm, while traveling southbound on Hwy 69, south of Toll Road 49 in Lindale, Texas, while driving in the right lane and speed set at 75mph, when all of a sudden the car activates the right blinker and - without slowing - pulls into a fairly short, dedicated right turn lane that turns into a business. At the end of the turn lane is a drainage culvert. The route of travel did NOT include a turn and the car should have been continuing straight down the highway. The car enters the turn lane and never slows from 75mph. I immediately hit the turn signal button to use the camera to get a look to my left to see if a car is there and also look over my left shoulder when there was no response (no camera) to activating the left turn signal. This all occurs as my hand is grabbing the yoke and my foot moving to the brake. I see the blue "path indicating line" wavering left and right and then lock into a right turn into the business parking lot at the end of this dedicated turn lane. Again, there is a culvert at the end of the turn lane also. As soon as I see over my shoulder that the lane to my left is clear the car attempts to make a 90 degree right turn at 75mph. At that exact moment I am able to yank the yoke left and tap the brake to disengage the Full Self Driving Beta as the car is starting the right hand turn. The rear end of the car breaks loose and slides as I get the yoke steered into the right hand lane of the highway. I allow the speed to bleed o

The control arm fore links of the car failed after 6000 miles

Third time this week I have been thrown forward into the steering wheel with no cars or objects surrounding me.

On both rear tires on the inner part of the tire the tread on Michelin 295 30zr21 is literally coming apart on both tires. Both at rear , no pot holes have been hit. rims are immaculate. Car was purchased brand new and only has 9800 miles. Almost like the tires are a used retreaded tires on a truck and the tread is literally detaching from the sidewalls. Luckily issue occurred while driving 25mph. Couldn’t imaging what would happen if driving fast. Tesla does not cover michelens issue but felt this needs to be reported. Someone will die if they blew out at higher speads. Will have bill from Tesla when tires are replaced.

Another automatic phantom braking throwing us toward in the car with no objects or other cars in proximity.

Oncoming vehicle suddenly turned in front of 2021 Tesla Model S resulting in collision at 34mph. Automatic braking did not engage, collision warning system failed to sound alert. Air bags deployed however seat belt completely spooled out causing the driver to strike the windshield and break the glass by contact with the top of the head. The vehicle was a total loss and the dealer never inspected the car.

Drivers door will not latch and car thinks the door is closed/latched. This allows the driver to drive away with the door unlatched. I've had to open and close the door while moving to get it to latch which is obviously unsafe. In attached picture you can see how open the door is but the car gives no indication this is the case. Tesla has confirm the issue and has tried twice to correct the issue but it has not been corrected yet. No warning lights or error messages even with the door obviously open.

When using adaptive cruise control vehicle randomly applies brakes while driving at highway speeds, for no reason. Sometimes braking is severe, sometimes moderate, sometimes light. In the instances of severe or moderate braking, a real danger exists that following vehicle will be unable to stop and will collide. This happens relatively frequently, particularly on some highways. Sometimes multiple incidents occur on one drive.

The tiny selection on the yoke to sound the cars horn requires me to take my eyes off the road to find it. This is unsafe. Several times I needed to sound the horn and was unable to in time. The worst instance was when I was making a U-turn in a 4-way intersection and needed to sound the horn to warn off a driver about to turn in front of me from the other direction. The yoke was inverted about 270 degrees and it was impossible to find the tiny horn symbol. There needs to be a conventional horn in the center of the yoke that can be pushed quickly without diverting eyes from the road. This has occured multiple dates that I do not specifically recall.

On March 19, 2023, I put my Tesla in drive and it went into reverse . When I tried to brake the speed accelerated. We were unable to stop the vehicle, while driving in reverse the car hit two mailboxes and two ceramic flower pots. It has been over 6 weeks and Tesla will not return my calls or messages. My insurance company looked at the body of the vehicle for a repair estimate. Nothing indicated that there was a problem prior to the incident.

To honk the horn, you have to find and push a very small button on the steering wheel. I have been in multiple situations where I have been unable to honk the horn in time to avert a potential accident because I could not find the horn button. Tesla appears to have recognized the problem and added a horn to the airbag on new vehicles, but they have refused to offer any retrofit.

The contact owns a 2021 Tesla Model S. The contact received notification of NHTSA Campaign Number: 22V702000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Vehicle is typically operated in FSD Beta mode. I have had approximately a thousand driver initiated disengagements due to unsafe or potentially unsafe operation in Beta mode. At times there have been indirect indications of unintended vehicle operation potentially due to anomalies with system hardware and communications between modules and control systems. The refreshed S and Y models feature a vehicle display behind the yoke steering wheel. When at stop signs, stop lights, or when turning, the yoke (in an upright or near upright position) blocks safety related displays indicating intended vehicle path, bollards and critical safety-related driver annotations. Visibility of these safety critical displays is further degraded when stopped making unprotected turns with the yoke erratically moving. The ability of the driver to safely takeover control of the vehicle is further degraded by the chaos associated with the yoke whipping back and forth on unprotected turns, and drivers and passengers being unable to see critical displays. When the vehicle, driver and passengers all have a reduced capability to ensure safe operation the chaos further degrades safe vehicle operation. At a minimum an over the air recall is required to add safety critical displays/annotations to the large rectangular display between the driver and front passenger similar to Y and 3 models. As noted above I also have hardware related concerns on my vehicle which at times appear to be masked/accommodated by t

All of a sudden my 2 driver side windows wouldn't fully close yesterday. I reported it to Tesla via the app and they thought it was their existing safety recall due to software issue, but service rep said it wasn't. Instead the window trim off the vehicle is very fragile and typically they noticed it needs to be fixed within 12 months of ownership. This is an obvious defect that can cause many issues with flooding, theft, and more if left as is. Getting a service appointment typically takes a week currently but I stressed the issue and that I don't have covered parking so they moved up my appointment. Regardless this needs to be addressed ASAP and customers shouldn't have to lose a work day or pay for resolving the defect... which I did reluctantly.

The steering wheel needs a center push horn. This is not available in 2021 model s. On occasions when someone seerved into my lane or to alert anyone on the road in an emergency, driver can’t be scrambling to find a touch sensitive button on the steering. When palm is placed on right side, it just triggers the wiper instead of horn sometimes adding to the chaos of the situation. This is a major issue. Please get it fixed. Don’t recall the exact date. So selecting random.

I had surgery on my right hand and had very limited use. I was completely unable to engage the horn as it is a very small button on the yoke rather than the standard pressing of the center. Allegedly this was supposed to be addressed with a software update last year and this has yet to happen

Im having total braking loss around freezing temps The issue occurs around freezing temps, after a car wash or if the roads are wet after driving on the highway for 20-30min without using the brakes. (Using one pedal driving) Last year I had the same issue and Tesla’s position was something to do with detergent in the car washes I use. Now they’re saying it’s because I put the “wrong” size rear tires on the car. They were sold to me and installed by Tesla as the factory recommended winter tires and rim package. They’re saying that the abs sensor is detecting the error and automatically applying ABS brakes because of the mismatch tire size. However, the issue is not an intermittent braking loss, it’s a complete braking loss. I’m also seeing abnormal front rotor wear. Tesla said this was an issue that was occurring on some other vehicles and they had a high level engineering team trying to figure it out. At the time mine was one of the first P2 refresh vehicles in Canada so I was guessing there weren’t that many being used in below freezing temps since they weren’t exporting to Europe at the time.

The Traffic-Aware Cruise Control has been braking unexpectedly and for no valid reason. The most recent example was when we were driving along US Hwy 24 between Wilkerson Pass and Fairplay, CO. The car suddenly braked even though there was no hazard. This has been happening regularly on this drive, in both directions, multiple times per drive. When this happens, the road is generally straight, with little, if any, elevation change. This is a safety issue because if this happens when a car is driving closely behind us, the unexpected braking could result in a rear-end collision. I have not reported this to Tesla because I understand this is a widespread issue that many people encounter, so I believe Tesla is fully aware of the issue. This problem seems to have gotten significantly worse after Tesla deactivated RADAR in the vehicle (without my consent). My understanding is that they are now using only cameras to manage Traffic Aware Cruise Control. Regardless of the reason, this issue has been happening with much greater frequency since around December, 2022 or January, 2023.

15,000 miles and 22/32 (70%) tire tread evenly worn available. The tire tread completely separated from the sidewall of the tire. This is a common and known problem with this tire. Many cases are presented on various online forums with photos and documentation.

Consistent with what is being reported on social media sites, my 2021 Tesla Model S Plaid is supposed to get 390 miles of range but in fact only gets approx 225-240 actual miles on a fully charged battery. This is wildly short of claimed mileage. Seems to be a common issue with Tesla Model S & Model X Plaid cars. Don't know if it's limited to the Plaid version of these cars or not

The horn placement on the yoke steering is dangerous and problematic. It is illogical and useless in the prevention of accident avoidance. I have had several scenarios where I have needed to use the horn and could not find it because I was in a turn, or I intuitively slammed the palm of my hand on the center of the yoke, where the horn should be located. Also, when holding the yoke in the proper position my thumb is not long enough to reach the horn button. Just by luck and quick action I was able to avoid being hit in multiple scenarios. It is DISTRESSING and UNNERVING to be driving a vehicle where you CANNOT find the horn when needed! I cannot stress enough how important it is to recall these vehicles and place the horn in the center of the yoke/steering. How this design ever passed safety regulations and put into production is mind boggling!

The instrument panel (screen) goes blank for approximately 5 seconds while driving. This issue happens at random. It has happened while on city streets, the highway, and in parking lots. Because of this issue, I cannot see my speed, the visualization of the car and surroundings (blind spot or pedestrians), any warnings that may pop up (such as an issue with the Autopilot or Full Self Driving Beta), nor any lighting or wiper information (for auto high beams and auto wipers). Tesla says it is a known issue, and it is software related, but there is no timetable for a fix. They do not believe a replacement screen/components will have any effect, so they are not offering any type of fix.

All 2021 Tesla Model S and/or X do not have horns in the center of the steering wheel. Instead, they have a button, which is impossible to find during an emergency situation, especially after many decades of muscle memory has been developed. Keep in mind that many, if not most, who can afford one of these cars do have decades of driving experience. I would really appreciate if these cars were recalled and Tesla were forced to replace the steering wheels with one that has a horn in the center of the wheel.

Our Tesla, in the "Full Self Drive" mode, has on more than one occasion applied the brakes suddenly without warning while traveling on the freeways. The date I indicate below was the last occurrence. I see that others have indicated this malady and I wanted to add our voice to this conversation. Thank you

The contact owned a 2021 Tesla Model S. The contact stated while driving approximately 100 MPH, as he took his foot off of the accelerator, with the vehicle brake control set to "aggressive slowdown," as the vehicle slowed the contact looked into the rearview mirror and observed white smoke issuing from the rear of the vehicle. The contact then depressed the brake pedal, and instead of slowing the vehicle accelerated at a dramatic rate and the contact lost control of the vehicle and left the roadway. The contact stated he was not aware of any warning lights being illuminated. The vehicle went into a ditch and continued straight following the ditch. The contact stated that the vehicle had not lost any speed, rather it seemed to be going faster. The vehicle crashed through a fence, drove up a slight berm, and went airborne. The contact's vehicle crashed into the ground, front end first, after flying 130 feet in the air, and began to roll end over end two to three times. The contact and his two passengers were unconscious after impact with the ground, the vehicle had come to a stop and caught on fire. The contact had attempted to exit the vehicle once he regained consciousness, however, he had difficulty since the driver's side door was jammed and his left ankle was dislocated and his right ankle was broken. The contact had managed to crawl out of the vehicle through the driver's side window which had completely shattered. The contact stated that the passenger in the front seat

I lost the use of my right hand and am unable to activate the horn as it is a tiny button on the right side of the yoke rather than simply pressing the center of the yoke.

When in autopilot, at highway speeds, the car suddenly will brake. There is nothing that instigates this and it seems to be a safety hazard.

I was unable to locate the horn capacitive button on my steering yoke to alert a biker who strayed into my lane. finding this small button has been a repeated problem when in dangerous situations

In August 2022 I was driving my Tesla S. I was traveling 25 miles an hour or less. I unfortunately lost consciousness for a very short time. My tesla then crashed into a parked car. There was snow emergency braking nor any emergency alarms. In theory describes shouldn’t of happened with an emergency braking system.

Today was at least the 3rd time "phantom braking" has occurred. While traveling on I-64 in Virginia, my speed was about 75mph with adaptive cruise control on. Suddenly, the car braked hard, slowing to about 40mph. I thought the car was going to stop. Fortunately, there were no vehicles behind me or there could have been a rear end collision. I did not use the automatic feature again for the rest of that drive.