2018 Tesla Model 3 complaints

Vehicle will randomly lock various doors and not allow them to be opened from the outside unless they are first opened from the inside and then the car will allow the extrnal handle to be used to open the door. This has happened on the passenger side front and rear and on the driver side rear door.

Hit a rock and the wheel cracked open circumferentially between the rims. The tire did not pop nor did the edge of the wheel rim get damaged. The rock did not damage the front valance so the rock was less than 6”.

The rear seatbelt mechanism needed to be replaced due to a computer seatbelt restraint error.

The car started producing a warning that there was an issue with the driver’s side safety harness. Tesla has a warranty described as “Supplemental Restraint System Limited Warranty” which should cover this repair. The Tesla service center would not cover the cost of the repair under the terms of the warranty. I asked for a list of which specific equipment was covered under the terms of this warranty and they would not provide any details.

The contact owns a 2018 Tesla Model 3. The contact stated that upon reversing out of a parking lot, an abnormal clunking sound was coming from the vehicle while turning to the right. There was no warning light illuminated. The contact continued driving and the steering wheel became loose, and an unknown object detached from the vehicle upon entering her driveway. Due to the failure, the contact decided to have the vehicle towed; upon arrival, the tow truck driver discovered that a bolt had fallen out of the vehicle. Once the vehicle arrived at the service center, the mechanic replaced a lower front lateral link and half shaft assembly. Upon investigation, the contact discovered NHTSA Campaign Number: 23V235000 (Suspension); which she linked to the failure. The manufacturer was not notified of the failure. The vehicle was repaired. The failure mileage was 70,950.

Seat moves back and forth during acceleration and deceleration. Previous owner said he was told by Tesla that it is within “spec”

Tesla Vehicle safety concern. Safety May 1, 2023 on Rt 95 south from Washington DC to Richmond VA (near Richmond VA) at about 10:45 pm. (Please note the clock time on the vehicle is incorrect—it is about 5 minutes slower and sets to a time I hr. earlier than the current eastern time). Vehicle: 2018 Model 3 VIN [XXX] The computer system failed in the middle of highway. The computer screen where all system functionality is monitored went bank except for a Tesla icon. Losing control of vehicle including turn signals in the middle of the highway was dangerous and a safety concern. For fear of being stranded on the road I carefully drove the vehicle to home in Yorktown Va. It was scary! Much of the settings on computer and navigation info was lost. This is a vehicle defect I need to report. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I received a message on the cars screen Steering alignment service recommended On the drivers side 2 bolts fell out at low speed which we picked up behind the vehicle. Using a jack one of the bolts was reinstalled to allow it to be driven onto a tow truck. I researched and found you had a recall on 2018 model 3 for bolts coming loose. It appears my vin was not part of this recall . I feel it should have been obviously as they must have worked themselves loose to fall out. I discussed this with Tesla service and they are quoting me $2500 for repairs because my vin was not included in the recall.

This is an issue regarding the full self driving software. My car continues to run red lights at which it is already stopped. The light is solid red to the naked eye, and the camera definitely does not show the normal steady blink of a malfunctioning signal. The pitch forward in the video is me slamming on the brakes as the car tries to run the light (about 28 seconds in). I have previously reported this to Tesla on 12/28/21, 8/25/22, 9/21/22, 11/21/22, and 4/24/23. It has happened many more times than that, as I usually don't see a point in reporting the same bug multiple times on the same software version. As far as I know, nothing is being done about this and I have received no acknowledgement of the problem. The [email protected] autoreply states that they forward this information to the correct department. This is, in my opinion, many orders of magnitude more serious than the previous Tesla recall regarding waiting too long at stop signs as this will cause a crash for an inattentive driver. https://youtu.be/ZvJASdlEEPU

My wife was driving and the left front suspension became disconnected. It appears some type of connection bolt came loose. The car became undriveable and unable to steal properly.

Multiple "phantom braking" events in which the car, on a clear day & no cars around, would suddenly slam on the brakes and try to stop. No messages were displayed on the screen. Tesla Service seems uninterested as it is a "software" issue. I tried a full reset of the car with no improvement.

Side airbags did not deploy in a major side impact.

I purchased this car used 12/05/2022. The seatbelt /driverside, doesn't catch on sudden stops, lurching me forward. I've almost hit the steering wheel with my face and head. Tesla says they are not responsible for replacing seatbelt. I have to pay for it. I don't know previous owners knew about this issue prior to selling it , but according to tesla, this issue doesn't fall with in their purview. Also the sealed control arm bushings on steering are squealing & after squeaking 10,000 miles of my driving this car and purchase. That too isn't covered.

Car speed control malfunctioned. There was a sudden acceleration when car was below 10 miles in the parking lot. The driver lost control on braking and car keep accelerating even no force was applied to pedal. Dribe had to steer out of parking lot and crash through a wood en fence on next door neighbor. Car still keep going thru front yard of two houses cross the street and eventually hit a concrete barrier on front porch of the house. Several parts breakoff underneath the car , fluid leaked and all wheels are severely damage. Severy damage to front body side of the of the car and battery system , has occurred . There was near miss body injury to pedestrians in the area and neighbor hood. No physical injury was reported at the time of accident. but driver reported psychologycal distress. Currently CAR is towed away per Instruction from Insurance company for evaluation. Police report CASE# 23021162 NORTH bRUNSWICK pd 710 hermann road North Brunswick, NJ 08902

I was experiencing intermittent Bluetooth connection issues along with vehicle not powering off and the gear shifting to park when moving the vehicle at (very) low speed without the seatbelt buckled. I noticed the Bluetooth connection problem after a bad software installation in Jan 2023, however the other two issues have been noticed since at least 2020. When I took the car for a second time, Tesla diagnosed the problem as a faulty seat occupancy sensor (SOS). Tesla told me that the driver side seat SOS is “sticky” that the car didn’t consistently know there was a driver in the car when I sit on the seats (which explained why the car would put itself in park when driven at low speed (<3mph) without seatbelt on, and why the engine kept running even after I stepped out of the car when the car wasn’t locked ( like, when the car is parked in the house’s garage). Further research on the web (https://www.carproblemzoo.com/tesla/model3/2018/seats-problems.php ) shows that other teslas had faulty seat occupancy sensors at both driver side and passenger side. Faulty sensors may lead to improper, or failed, airbag deployment. This is a safety issue that Tesla had known and should have performed a recall and fixed, or the very least sent a billeting to its service centers so that they would check the seat sensor when someone’s complaining about any of the three symptoms I had. When I took the car to Tesla in Feb 2023 their (mis)diagnosis was that I had too many wires plugged into USB p

On April 21st 2023, by pure chance I happened to notice that, after plugging in my Model 3 to recharge at a local charger, the charging rate was lower than normal: instead of its full 32A charge, the rate was only 16A. I kept getting a notification of an issue with charging, Error: PCS_a019 "Charging slowed - Poor Grid power quality possible, unplug and retry / try different charging location" I've attempted several charging stations and all the same outcome. I've done research on this issue online and others are having the same issue. Tesla did cover a few from what I read as "battery warranty" that I've reach but most are denied as it wouldn't be part of the "battery warranty". I've reached out to Tesla and was informed my warranty was expired almost 28 days on March 23rd 2023 as it was April 21st when I made the service appointment. The cost to repair was $1,987.58 and NOT covered by the battery warranty. I've asked if Tesla would waive the fee as my car was just out of warranty and has a mileage of 30,193. It was declined as she "informed" management at the Burbank, CA repair location. I'm very sadden by this issue as Tesla advertises the electric car is "low maintenance" compared to the average gas vehicle, this is false advertisement. Other manufacture do cover this part under their battery warranty. The vehicle isn't operable if not repair to charge at a normal faster speed. I'm now considering to sell my vehicle once repaired and give people my honest opinion about my

I drive a 2018 Tesla, Model 3 mid range rear wheel drive vehicle. On Saturday, April 22, at approximately 5:10 pm, while driving on east bound on interstate 264 in Norfolk, Virginia, my car suddendly began swerving wildly from left to right. It nearly missed the median on the left and then swerved into the lane next to me on the right. It repeated this about 6 times before it allowed me to regain control of my car. I attempted with my best efforts to counter turn the steering wheel to no avail. During this time, I tried to control the vehicle, although the car's software was in control. It was frightening. If I had been on a two lane road, this could have resulted in a fatal head on collision. If there had been a pedestrian / bicyclist on the road the car that decided to drive itself could have struck a vulnerable person fatally. When I called Tesla service to report the incident, they did a quick review of the cars data and said there was some issues reported from the cars cameras. I asked for the root cause and for some reassurance that this would not happen again. I was told that sometimes the auto pilot cameras have issues and I may need to reboot the system to correct it. I was told that I should restart the software periodically as a preventive measure. I checked the owners manual, and found no mention of restarting the software regularly as preventive maintenance. Regardless of a reboot issue, a fatality could have occurred in a split moment, this dangerous event shoul

On a trip today from Pasco wa to Spokane WA (us395) there autopilot and full self driving would randomly phantom brake for no obvious reason. It happened every 5 minutes or so in both directions. Scary and dangerous.

The Power Conversion System (PCS), 1 of the 3 module fails, therefore, it limits the AC charge current to 32A out of the max of 48A the car was never pullged into a 48A AC charging connector, therefore, the PCS module likely to be defective

Computer failure. The car became unsafe to drive because the screen went completely black and could not be reset. The rear view mirrors would not unfold, the car’s cooling system wouldn’t work, there was no way to see the speedometer or the amount of charge the vehicle had and the vehicle would not charge.

Recommended Software update is not available. Tesla App has stopped working for the past 2 months.

My 2018 Tesla Model 3 Long Range abruptly parks itself when a seatbelt is not used. The car does not wake up when sitting into the driver seat and the likely culprit is the driver side occupant sensor. To wake up the car one must press the brake or tap on the screen multiple times. If the sensor is faulty this means the airbags on the driver side will not deploy due to the car thinking there is no occupant. Tesla wants to charge customers $1300 for a replacement seat, which is unfair as it compromises the cars air bags and safety system. The car is drive able even when the sensor is not working. I am scared that if an accident were to occur the airbags will not deploy.

Power conversion system failure. Only charges 32/48 amps at destination chargers. Unsure how long this has been a problem because I just upgraded my power panel to be able to charge at 48 amps. Being told $1800 to get car to charge at expected amp limit. 90k miles on car.

The Tesla was parked and locked unoccupied with all security features enabled. When I returned to the car the front driver's side was completely crumpled with the bodywork torn , like it was reveresed in to. I was gone about 30 minutes. The car gave no notification on the app, the car alarm didn't activate and the sentry mode did not record the incident. All the things they say the car will do. I called Tesla and was told it works 99% of the time ,(but clearly when you need safety and security it doesn't) they stated that if the car gets hit a certain way it can cause the system to shut down /reboot ,so that none of these systems work... Seems wrong that this can be allowed to be the case that not only all the systems fail, that when they do fail there's no backup or way for the car to know something is wrong. That if there is a unexpected forced reboot it doesn't tell you or acknowledge something is wrong in any way . They seem to think that this is ok . I have reported to them and they really didn't seem to care , just said the statement above about it working 99% of the time..However all the things they say the car can do ,and several reasons you think you are buying the car for with it's increased safety and security, apparently don't work at all. Now I have a 4 figure out of pocket to get the car repaired because I have no way to find the person who hit my car because the none of the cars security or safety warnings worked.

The front left control arm (lateral link) of my Model 3's front wheel just came completely off (bolts unscrewed) without any incident. It fell to the ground and preventing my car from steering properly and was dragging on the ground. The car couldn't drive properly and needed to be towed to the Tesla service center. This could have easily caused a fatal accident by causing the car to suddenly not be able to steer and drive properly. I had the vehicle towed to the Tesla service center and the engineers did not know how or why the bolts were unscrewed and came out. The Tesla service center forced me to pay out of pocket since my vehicle had 70K miles and was out of warranty. They refused to accept it as a manufacturing safety defect.

The main bolt that holds together the wheel and body on the driver side fell off while driving, resulting in wheel falling off and car not able to operate safety. The bolt is marked with kxv109. This caused damage to the entire subframe assembly. This could have been a very terrible accident if I was driving at a higher speed. On October 27, 2022 I noticed an odd sound from my steering wheel which I reported to Tesla and had my car in for service and was told that nothing was wrong and everything worked as expected, so I continued to drive my car. My car’s wheel fell off on January 20, 2023, the bolt that held the wheel to the body completely broke off and fell on the ground.

My Tesla Model 3 without any warning stopped working suddenly. I could not put the car in drive and there were error messages about climate control and electrical system. I had to get the car towed to the service center as it was blocking my other car in the driveway. The service center in Sunnyvale, CA diagnosed the problem to be a faulty PTC heater and has charged me over $1100 to replace it. I beileve it is quite absurd to have a fault in the HVAC system render the whole vehicle completely immobile and useless. This seems like a serious design flaw and it could lead to serious health or safety concerns.

The side blind spot cameras are blinded at night by the turn signal lights when flashing, making them very unsafe. Difficult to view due to the orange light flashing, blinding both left and right cameras.

I am driving on the new FSD beta that Tesla just released to comply with NHTSA's previous recall, version 2022.45.13. Despite the claim that this release has addressed these issues, I experienced these today while driving around my town on city streets and on the open highway: As I approached the stop sign at the end of the exit ramp off the highway to my neighborhood street, the car blew right past the stop sign just like it wasn't there. It did this before the current update as well. While this is improved over previous versions, it still doesn't slow down in advance of a new lower speed limit sign to ensure it's moving at that posted new slower speed by the time it reaches that sign, as it should. As you know, it's illegal, e.g., to continue driving at 45 mph after you've passed a 35 mph sign. But with this latest update, even though the car can "see" the new lower speed limit sign ahead, the car only begins to slow down once you've passed this new lower speed limit sign and then goes about 200 ft before it actually reaches the lower speed. This is still illegal in every state and is a danger to drivers and others. Please make Tesla fix both of these problems fully.

Rear passenger side seat belt, when used for the first time since new car purchase in 2019, had an issue where it kept getting stuck and the retractor made a clicking noise majority of the time. This seatbelt is unable to be used as expected due to it getting stuck and not retracting fully and making noise. Reported this issue to Tesla Santa Monica Service center in October 2022, where the service advisor simply showed me how to use seat belt properly and come back later if issue kept happening and "resolved" the issue via "remote education," thus not offering a proper fix.. Issue has persisted, and I have reported it once again to Tesla Santa Monica Service center who tells me they're under new management and will decide whether I will be required to pay out of pocket after a test drive but are otherwise quoting me a diagnostic fee now. A test drive is not needed for this though since it's a seat belt malfunction issue. Reporting this to NHTSA because other Teslas have faced seatbelt recalls too.

Heater suddenly stopped working. Will not produce any heat or defrost windshield. Passenger/Driver safety affected by lack of warmth in extreme cold and visibility while driving with iced windshield. 35,000 miles on well maintained vehicle w no damage or accidents. Dealer states that resistance heater and wire harness will need replaced. No cause identified.

The power conversion system is failing on my vehicle. It is causing faults that trip the breakers at my charger and could potentially cause a major problem at my charging station. It could also cause my vehicle to be stranded or possibly lose power while driving.

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the display screen intermittently went blank and failed to display the speedometer. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 37,740.

I experienced premature failure of all 3 modules is the vehicles PCS (Power Conversion System) part of the HV Battery System. Although a TSB was issued to replace the same part in other cars with "affected" VINs Tesla has ignored this faulty part and has declined to replace it under the vehicles HV Battery warranty even though the unit is replaced as a single unit when the HV Battery requires replacement. This is a well known issue that is being intentionally ignored by Tesla. It could leave a driver stranded in an unsafe condition or situation. I would like to see the part recalled. https://static.nhtsa.gov/odi/tsbs/2018/MC-10148850-9999.pdf

The window switches on the driver window panel have deteriorated and broken not allowing the driver to pull up the windows. For a car that’s only 3 years old this should not happen and is a major safety issue as the driver has no way of controlling the windows. I have searched online regarding this issue and have found that many other owners have experienced the same exact defect that I have, most a VIN number around 30000

Auto was in reverse and moved backwards while rear rt side door was open causing damage to another auto parked alongside. Shouldn't the auto not move in gear when a door is open and unlatched ? The auto can move forward or back with any door that remains open. I thought this would be a safety issue

When I turn on the turn signal, Tesla displays the side repeater camera on the screen, which allows me to see if there is a car in the blind spot. In addition to the video on the screen, I believe the side repeater cameras are used by the onboard computer to determine whether there is a car in the blind spot (in which case it would display the lane in red and shows a car drawing on the screen). As you can see on the attached photo, when the turn signal is on at night, there is a massive light bleed from the turn signal to the camera, which makes it impossible to see whether there is a car in my blind spot. Presumably, this also hinders the car’s ability to detect whether there’s a car in the blind spot as well. This issue has been widely discussed online, and there are even YouTube videos teaching you how to fix it DIY. For example, here’s a YouTube video: https://youtu.be/_BUPsjguqdY Here is an example of a discussion thread: https://teslamotorsclub.com/tmc/threads/my-experience-diying-a-fix-for-the-blind-spot-camera-light-leak.261481/ It appears to be a hardware design flaw, which has been fixed in recent Tesla models. But the problem still exists on my 2018 Tesla Model 3, and I believe not being able to see the blind spot on the screen at night is a safety hazard that needs to be addressed.

The issue is with autostart, enhanced auto pilot and lane departure warning. I paid for Enhanced auto pilot. This car totally relies on cameras. 1. In the slightest occurrence of rain, it complains about one or more cameras malfunctioning or out of vision. This doesn't happen often in Full Self Driving version. For early adopters of Model3 FSD, manufacturer updated the cameras. However they did not do that for early Enhanced Autopilot customers. 2. For the same reason, on a 3 lane or more highway, on autopilot when one moves from speed most lane and if there is a truck on the slowest lane, the camera shows somehow that the truck is on the middle lane when it is not, and hence the software assumes an impending crash and pulls you back to the speed most lane, giving no time for anyone behind you to think anyone, and leaves yourself in a dumbfounded state. 3. Without the upgraded cameras, Autopilot is prone to accidents. 4. Car tent to automatically brake when sun directly shines on the driver or there is a bridge in front of you while on autopilot. I believe this has something to do with the older version of cameras.

The contact owns a 2018 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 22V702000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front driver's and passenger's side door panels made clicking sounds while the windows were rolling up and down. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000. Parts distribution disconnect.

Our Tesla Model 3 had a failure of LV contactor which engages the HV circuit while driving the car in a 45MPH side road. The car had a sudden shutdown with emergency brakes engaged and the car came to a stop violently. It was providence that there were no vehicles following or car was not being operated in a 75MPH freeway and hence did not end up in a rear collision accident or worse involving an 18 wheeler. We talked to Tesla service and they indicated that such contactor failures occur and the car would typically behave like it did with stopping immediately as per design. I was telling Tesla service that the car should probably move into Neutral mode rather than stopping immediately. I also heard other instances where Tesla has stopped suddenly in the media. I would like Tesla to review their current logic with handling contactor failure and prevent violent and sudden stops of the vehicle to prevent accidents.

The rear view camera in our Model 3 stopped working in April 2022. This is a known problem related to NHTSA Recall Number 21V-00D, which was issued in December 2021. It has been over a year & Tesla is still waiting for parts to become available to perform the repairs for this recall. Although our car is still drivable, it is very difficult to use Tesla’s Superchargers since they require the car to be backed into the parking space.

In the Tesla, when using your blinkers, the side cameras display on the main center display screen. In this version of the cameras, the blinker light can actually be seen on the display because light leaks in behind the camera sensor. At night, this results in a bright flashing image on the screen, is completely distracting, and partially blinds the visibility of the "blind spot monitor". It is impossible to configure the car to turn off the camera display. Each time it turns on, you need to swipe the screen to remove the camera image, taking you eyes off the road to manipulate the screen while performing a lane change or turning maneuver. Newer versions of the car/cameras do not have this issue. While I do not have any saved video of this occurring, I can obtain it easily. However, here is an article about the problem and how one user decided to repair it themselves. https://driveteslacanada.ca/model-3/diy-fix-for-side-repeater-camera-glare-in-tesla-model-3-and-model-y-but-it-is-not-for-the-faint-of-heart/?fbclid=IwAR21UEPjKyvKPBYt_iTY4obGNIoHDjFK8gEci4dPNxIEmzlsVlPTv6uzt54 I selected yesterday as the date of incident, but this has been occurring for a while - ever since Tesla added the this camera to the screen when turning in version 2022.24 of their software. I believe I received this in early 2022. However, with the pandemic, I did not drive much and did not see this issue in action often. I was hopeful for a software update to correct this or minimize the impact, but th

Tesla recently pushed out a significant software update version 2023.2.12. Like a similar software upgrade last year, the upgrade wipes out all user profiles and rearranges control settings. The sudden change makes it hard to find simple and necessary control features of the car. The driver is significantly distracted trying to find where the new controls are. Some are hidden. Some are no longer visible. Software update is inherently unsafe especially for older drivers. In addition, the controls panel font is so small that many of the controls cannot be seen by older drivers. We have complained to Tesla that this is inherently unsafe and poses a risk to motor vehicle safety. No response.

Automatic Headlights fail to illuminate when wipers are active. This has been reported to Tesla in 3/2022.

OEM Chrome on door handles is a thick metallic wrap over plastic. Over time the chrome wrap delaminated on 3 out 4 handles. This results in very sharp metal edge that presents a laceration hazard. Just wanted to share this in case others have this issue. It's not a serious issue but it definitely is unsafe and it might be good to warn others.

Looks like "upper control arms Parts" are poorly constructed and Tesla is not able to fix . I've had my 2018 model 3 for a 4.5 years now I notice a squeaking noise coming from the steering wheel and its constantly whenever I turn the wheel. Tesla said to replace upper control arms Parts by owner , even though it was poorly designed .costing about $2800.00.. which is not acceptable . Would you mind take a look at this issue

Hi, I did order Tesla in 2016 and delivered car in June 2018. Beased on the software updates, and recalls , Tesla was not about to full fill any of the recalls. Apart from existing recalls , I did notice couple of other issues with this my car . one of them is unable to configure /activate Cabin camera , even though Camera with pre installed Hardware. I did try to contact Tesla , as per their episode, 2018 Tesla models come with older computer/processor, and it not support Cabin Camera.& I have to pay $1000 +tax in order to make it active. They also said , I did not purchased 'auto pilot feature '. that way camera is not active. but newer models of does work without ' auto pilot feature'. That means older Tesla model3 computers of Tesla' must be recalled, because of poor computer design. Is there anything I could expect help from NHTSA? thanks [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Heating has malfunctioned and car will not warm up defrost windows in snow storm. This happened shortly after charging the tesla at a supercharger and the car also seemed to suddenly require a software update. Having performed the update and reboot, the heat has not fixed. The weather is currently 14f and the car is essentially undrivable in the recent snow storms due to no heat. The system will blow air but this will not melt accumulating ice. Unsafe and random.

Power Conversion System (PCS) failure. This happened without warning over 60 miles from home and service center on x-range Model 3, less than 50,000 miles. Tesla did the repair, and took no responsibility for its premature failure, nor did they provide any explanation for why the failure occurred, leaving me (the owner) with a very expensive repair bill.

I was turning left into our garage at low speed, and a bolt fell out of the front right suspension (bolt came out of lower control arm) and the wheel practically fell off the car. A whole mess of damage happened, and it came out to an over $5,000 repair, and we're still getting it repaired. We recently had the tires aligned at Tesla in October 2022, roughly 3 months before the bolt fell out. Bolts like this shouldn't be falling out of the car, and at the very least Tesla should be checking the torque on all these things on any major service.