BMW of North America, LLC: Electrical System › Starter Assembly › Relay
BMW of North America, LLC reported this defect to federal regulators on Jul 8, 2026 and put the number of vehicles at risk at 29,119. The repair is free for as long as the recall stands.
Park away from buildings
NHTSA attached a park-outside advisory to this campaign. It applies to specific production runs, so check your own VIN with the manufacturer or at nhtsa.gov/recalls before driving the vehicle.
The defect
BMW of North America, LLC (BMW) is recalling certain 2018-2020 530e xDrive, 2017-2019 740Le xDrive, 2018-2020 530e iPerformance, 2016-2018 330e iPerformance vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
The risk
A short circuit in the starter relay may increase the risk of a fire.
The remedy
Owners are advised to park outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed September 30, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning August 28, 2026.
12 model years covered
Newest firstWhat this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 26V441000.
Full record for the 2020 BMW 530e Iperformance → · Recalls carrying a do-not-drive advisory → · Where this data comes from →