Ford Motor Company: Suspension › Front › Control Arm › Lower Arm
Ford Motor Company reported this defect to federal regulators on May 9, 2025 and put the number of vehicles at risk at 3. The repair is free for as long as the recall stands.
Do not drive
NHTSA attached a do-not-drive advisory to this campaign. It applies to specific production runs, so check your own VIN with the manufacturer or at nhtsa.gov/recalls before driving the vehicle.
The defect
Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco vehicles. The front lower control arm fasteners may not have been tightened properly, allowing the control arm to detach from the frame.
The risk
A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
The remedy
Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the lower control arm fasteners are tightened properly. If a fastener is loose or missing, the dealer will replace the fastener. Repairs will be performed free of charge. Owner notification letters were mailed June 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S48.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2025 Ford Bronco | 56 | 19 | 2 | 5 |
| 2024 Ford Bronco | 82 | 16 | 4 | 4 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 25V308000.
Full record for the 2025 Ford Bronco → · Recalls carrying a do-not-drive advisory → · Where this data comes from →