Terex South Dakota, Inc.: Suspension › Front › Springs › Air Suspension › Springs/Bags
Terex South Dakota, Inc. reported this defect to federal regulators on Mar 16, 2016 and put the number of vehicles at risk at 131. The repair is free for as long as the recall stands.
The defect
Terex South Dakota, Inc. (Terex) is recalling certain model year 2015-2016 C5000, C6000, General 80, RMX, TM100, and TM125 aerial devices, and digger derrick lifts installed on trucks manufactured August 4, 2015, to February 16, 2016. The suspension circuit can inflate the suspension air bags on the affected vehicles if the Master/PTO switch or ignition is turned off in the cab while the boom is in the raised position. This can cause the frame to rise, lifting the outriggers from the ground.
The risk
If the outrigger lifts off the ground, causing instability of the truck, it can increase the risk of injury to the operator.
The remedy
Terex will notify owners, and dealers will install a second outrigger enable relay, free of charge. The recall began on April 29, 2016. Owners may contact Terex customer service at 1-800-982-8975. Terex's number for this recall is SN636.
63 model years covered
Newest firstWhat this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 16V154000.
Full record for the 2016 Terex C5000 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →