Volkswagen Group of America, Inc.: Electrical System › Ignition › Switch
Volkswagen Group of America, Inc. reported this defect to federal regulators on Apr 1, 2015 and put the number of vehicles at risk at 20,676. The repair is free for as long as the recall stands.
The defect
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
The risk
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
The remedy
Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2010 Volkswagen Routan | 240 | 2 | 3 | 5 |
| 2009 Volkswagen Routan | 294 | 6 | 3 | 6 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 15V194000.
Full record for the 2010 Volkswagen Routan → · Recalls carrying a do-not-drive advisory → · Where this data comes from →